Waste Anaerobic Digestion Research Articles

EXPLORING THE POTENTIALS OF CEREAL FOOD WASTE IN ANAEROBIC DIGESTION

Cereal food waste makes up a significant part of municipal solid waste, and its proper treatment has become an urgent issue due to its increasing generation. In Nigeria, where around 50% of municipal waste is organic, this study focuses on the need for effective waste management. It highlights the negative environmental and economic impacts of improper disposal methods. The study examines the potential of using cereal food waste in anaerobic digestion for biogas production. Cereal food waste was collected from student hostels at the College of Nursing and Midwifery Malumfashi, sorted, and converted into a composite for anaerobic digestion. An anaerobic digester was constructed using a 25-litre plastic container designed for batch loading. The anaerobic digestion process was carried out for 30 days. The results show that a total biogas volume of 14,634 mL was produced during this time. The daily biogas yields varied, reaching its highest point on the 5th day. This finding underscores the importance of addressing food waste in the cereal supply chain to ensure sustainable food production and consumption. The results demonstrate that cereal food waste has significant potential for biogas production, which can contribute to sustainable waste management and help address environmental challenges linked to food waste. Based on these findings, the study recommends promoting the use of biogas technology to improve food waste management, thus enhancing environmental sustainability and supporting economic development.

Insight into using hydrochar to alleviate ammonia nitrogen inhibition during anaerobic digestion of waste activated sludge: Performance, metagenomic and metabolomic signatures

In this study, hydrochar (HCR) was used to alleviate high ammonia inhibition to the anaerobic digestion (AD) of waste activated sludge (WAS) and to elucidate the inner microorganism mechanism. After HCR addition, the cumulative methane yield increased by 73.6 % and 35.6 % under ammonia inhibition levels of 3000 and 6000 mg/L, respectively. Metagenomic analysis showed that HCR enriched the diversity of hydrogenotrophic methanotrophs, and the relative abundances of functional microorganisms with electron transfer capabilities (Geobacteraceae bacterium etc.) were 1.5–7.8 times higher than those without HCR addition. Metabolomics analysis implied that metabolites related to fatty acid degradation, such as glutaric acid and hexadecanal, were downregulated (2.9–15.7 %) under ammonia inhibition conditions and that HCR regulates metabolites in the methane metabolic pathway. Moreover, HCR changed the methanogenic pathway from hydrogenotrophic methanogenesis to multiple pathways under ammonia inhibition conditions, especially methanolic and methylotrophic methanogenesis, which facilitated the methane yield. This study provides valuable information for understanding the inner microbial mechanism of HCR addition on alleviating high ammonia inhibition to AD of WAS, and gives basic knowledge for the application of AD of WAS under ammonia inhibition conditions.

Carbon reduction trade-off between pretreatment and anaerobic digestion: A field study of an industrial-scale biogas plant

With the implementation of municipal solid waste source segregation, the enormous sorted biogenic waste has become an issue that needs to be seriously considered. Anaerobic digestion, which can produce biogas and extract floating oil for biodiesel production, is the most prevalent treatment in China for waste management and greenhouse gas (GHG) emissions reduction, in accordance with Sustainable Development Goal 13 of the United Nations. Herein, a large-scale biogas plant with a capacity of 1000 tonnes of biogenic waste (400 tonnes of restaurant biogenic waste and 600 tonnes of kitchen biogenic waste) per day was investigated onsite using material flow analysis, and the parts of the biogas plant were thoroughly analyzed, especially the pretreatment system for biogenic waste impurity removal and homogenization. The results indicated that the loss of the total biodegradable organic matter was 41.8% (w/w) of daily feedstock and the loss of biogas potential was 18.8% (v/v) of daily feedstock. Life cycle assessment revealed that the 100-year GHG emissions were −61.2 kgCO2-eq per tonne biogenic waste. According to the sensitivity analysis, pretreatment efficiency, including biodegradable organic matter recovery and floating oil extraction, considerably affected carbon reduction potential. However, when the pretreatment efficiency deteriorated, GHG benefits of waste source segregation and the subsequent biogenic waste anaerobic digestion would be reduced.

Biogas production prediction model of food waste anaerobic digestion for energy optimization using mixup data augmentation-based global attention mechanism.

Achieving rapid, efficient, and cost-effective anaerobic digestion (AD) of food waste is a key means to improve the efficiency of food waste treatment. However, in view of the shortage of historical anaerobic digestion data, the limitation of general neural networks in predicting biogas production, and its sensitivity to abnormal variation points, achieving accurate prediction of biogas production is not easy. This paper proposes a novel biogas production prediction model of food waste AD for energy optimization based on the mixup data augmentation integrating an improved global attention mechanism long short-term memory (LSTM). Taking the AD data of the actual factory as samples, the mixup data augmentation is introduced to generate virtual samples with the similar distribution as original samples. Then original samples and generated virtual samples are used as the input of the global attention mechanism LSTM to establish the food waste AD biogas production prediction model. Finally, the proposed method is applied in the biogas production prediction of actual food waste treatment plants. Compared with other industrial modeling models, the experimental results show that the proposed method has the highest prediction accuracy of 0.988, which performs well in predicting biogas production and can effectively guide and timely adjust feed configuration of AD plants.

ТЕОРЕТИЧЕСКИЕ АСПЕКТЫ ПРОЦЕССА ПОЛУЧЕНИЯ БИОГАЗА ПРИ АНАЭРОБНОЙ ФЕРМЕНТАЦИИ ОРГАНИЧЕСКИХ ОТХОДОВ

The biogas extraction process's theoretical description during carbon containing agricultural waste's anaerobic digestion is considered. This proposed installation's work for biogas and organic fertilizers production during waste's anaerobic digestion is described. These anaerobic methods' advantage as biological treatment's unlike classical aerobic methods, when all bacteria work under the same conditions, with properly organized anaerobic processes is made, the separated bacteria in different physico-chemical conditions working. This makes it possible the anaerobic digestion process in productivity terms optimizing, managing and, ultimately, the waste processing quality improving. Based on the proposed biogas installation, the equations for the biogas yield determining are obtained. The of pig manure biogas output's theoretical results with crushed corn grain's addition are presented. This biogas installation's calculation method on the biogas output in dependence on empirical and technical parameters' design is based. The aim is biogas and biofertilizer's production during pig manure fermentation intensity increasing. The proposed biogas installation in psychophilic (3-25°C), mesophilic (25-40°C) and thermophilic (40-55°C) temperature conditions can operating. The substrate is heated by biogas through a vortex tube passing. The organic substances' anaerobic processing leads the biodegradable substances' main part into CO2, H2O and NH3 decompositing. Bacteria such as Bacillus, Micrococcus, Pseudomonas and Clostridium play a key role in this process by enzymatic hydrolysis and acid's formation carrying out. The theoretical calculations show that the highest biogas producing with a content of solid particles in the fertilizer of no more than 8,8-10% and substrate's effective mixing is achieved. The organic waste processing into biogas is justify and preferable. This product (biogas) everywhere can be used, both on individual agricultural firms and in general in agriculture, where it will be the most effective using.

Real-world assessment of a decentralized food waste anaerobic digestion system: A test-bedding case study application

Addressing the global challenge of food waste, this research delves into the assessment of an on-site food waste treatment solution through a full-scale decentralized anaerobic digester (AD) system, specifically deployed at a Singapore hawker centre. Demonstrating efficiency in Singapore's tropical climate (29 °C) without external heating, the 10.8 m³ digester exhibited resilience over 234 days, navigating through real-world fluctuations in average organic loading rates ranging from 0.07 ± 0.02 to 0.81 ± 0.38 kgVS/(m3d). The normalized specific biogas production averaged 0.70 ± 0.48 m3/kgVS, accompanied by a methane concentration of 56.9 ± 2.9%. During peak performance, with an organic loading rate of 1.1 kgVS/(m3d), the system achieved an impressive volumetric biogas production rate of 1.18 m3biogas/m3reactor, equivalent to 1.1 m3/kgVS of specific biogas production per day. The energy assessment revealed consumption rates of 0.57–0.97 m3/kWh, positioning it comparably with commercialized biogas technologies in China and Taiwan. In the realm of microbiome composition, the prevalence of hydrogenotrophic methanogens, including Methanomicrobia, Thermoplasmata, and Nanoarchaeia, is notable. These methanogens showcase a remarkable tolerance to acetate, surpassing common aceticlastic methanogens by 11 times, thereby playing a pivotal role in enhancing the stability of the AD system over extended periods. On the economic front, the present AD system yielded losses ranging from SG$552,434 to SG$742,919, primarily due to a low payback period and substantial investment costs. Profitability becomes a possibility if there are significant reductions in capital costs and operator salaries. The challenges encountered during the operation of this decentralized system, along with the corresponding mitigation measures, are thoroughly discussed. Positioned as a promising test-bedding model, this application underscores its technical feasibility potential for sustainable food waste management through AD technology in Singapore. It stands as a replicable prototype, contributing to closing the food waste loop and advancing the bioeconomy.

ПРИМЕНЕНИЕ БИОГАЗОВОЙ КОГЕНЕРАЦИОННОЙ УСТАНОВКИ ДЛЯ ОБЕСПЕЧЕНИЯ ТЕПЛОСНАБЖЕНИЯ ТЕПЛИЧНОГО КОМПЛЕКСА

For the yearround population by vegetables supplying, it is necessary enclosed area’s crops growing. At the same time, vegetable production’s cost prevailing in the Irkutsk region is thermal energy to the greenhouse’s complex supplying. One of the ways of this problem solving is thermal energy by a biogas cogeneration’s installation producing. To provide heat supply due to such biogas cogeneration installation, biogas that consists of 55-75% methane is used, the rest are the impurities. Biogas in methane tanks due to the livestock farms’ organic waste anaerobic digestion is produced. Thus, at the same time, the problem of livestock by products in agricultural enterprises recycling is being solved. It is known that there are no greenhouses’ operating all year round in the Irkutsk region. The task is to find out if cattle farm will be able a greenhouse complex with an area of 500 m2 with by products’ processing the thermal energy’s necessary amount providing. An analytical dependence is presented for the thermal energy’s required amount calculate that by a biogas cogeneration installation for a greenhouse complex producing. The Irkutsk region greenhouse complex thermal processes calculation conditions’ was carried out. The temperature of the coldest five day period with a security of 0,92 was -33°C. Heat losses through structures enclosing, transoms and due to infiltration are calculated. A heat month losses’ graph is constructed. It was revealed that heat’s most losses through structures enclosing are lost. The calculations provide for soil heating as well. The heating devices required surface which will be 207 m2 was also calculated. Based on previous studies, it was revealed that the cattle farm’s theoretical energy potential a greenhouse complex with its own thermal energy can providing.

Effect of alkali pretreatment time on kitchen waste anaerobic digestion performance enhanced by alkali pretreatment combined with bentonite: performance enhancement, microbial community structure, and functional gene analysis.

Kitchen waste was mainly composed of carbohydrates, lipids, and proteins. Anaerobic digestion (AD) of kitchen waste usually occurred acidification and further deteriorated. In our previous study, alkali pretreatment combined with bentonite (AP/Be) treatment was proved to enhance high solid AD of kitchen waste. However, effects of AP time on AP/Be were not yet studied. This study investigated the effects of AP time on AP/Be treatment on enhancing high solid AD. The results showed that compared with the control group, the cumulative methane production rate could be increased by 3.30 times (149.7mL CH4/g VS) and the volatile solids (VS) reduction rate increased by 63.36%. Microbial community analysis showed that the relative abundance of Methanosarcina and Methanosaeta were increased from 6.49 and 7.83% to 47.14 and 16.39% respectively. Predictive functional analysis showed that AP/Be treatment increased the abundance of energy production and conversion, coenzyme transport, and metabolism. This study revealed the potential mechanism of AP/Be enhanced kitchen waste AD performance and AP/Be was a potential strategy to strengthen AD.

Machine learning assisted modelling of anaerobic digestion of waste activated sludge coupled with hydrothermal pre-treatment

This study utilizes decision-tree-based models, including Random Forest, XGBoost, artificial neural networks (ANNs), support vector machine regressors, and K nearest neighbors algorithms, to predict sludge solubilization and methane yield in hydrothermal pretreatment (HTP) coupled with anaerobic digestion (AD) processes. Analyzing two decades of published research, we find that ANN models exhibit superior fitting accuracy for solubilization prediction, while decision-tree models excel in methane yield prediction. Pretreatment temperature is identified as pivotal among various variables, and heating time surprisingly emerges as equally significant as holding time for solubilization and surpasses it for methane yield. Contrary to prior expectations, the HTP method's impact on sludge solubilization and AD performance is minimal. This study underscores data-driven models' potential as resource-efficient tools for optimizing advanced AD processes with HTP. Notably, our research spans nearly two decades of lab, pilot, and full-scale studies, offering novel insights not previously explored.

Enhancing biomethane production from food waste using olive pomace hydrochar: An optimization study

The effect of olive pomace hydrochar (OPHC) on food waste (FW) anaerobic digestion (AD) was investigated experimentally at five concentrations (5.85, 10, 20, 30, and 34.11 g/L). The selective concentrations are based on an experimental approach that was utilized to study the effect of adding 10-30 g/L OPHC to the AD of FW. The highest experimental methane yield (YCH4) and biodegradability are obtained for 10 and 20 g/L of OPHC, with 33 and 82 % improvement, respectively. Response surface methodology (RSM) was used to assess the impact of independent factors, including hydraulic retention time (HRT) and olive pomace hydrochar (OPHC) added, on YCH4. The R2 of 0.9073 and 0.9485 are obtained for YCH4 using face-centered and circumscribed designs, respectively, due to the model's accuracy. The optimal YCH4 was 428.81 ml/g VS with an OPHC added of 20 g/L and an HRT of 20 days.

Effect of extracellular polymeric substances removal and re-addition on anaerobic digestion of waste activated sludge

Extracellular polymeric substances (EPS) play a key role in anaerobic digestion of excess sludge. The influence of EPS removal and re-addition on sludge anaerobic digestion were investigated by batch experiment. The results showed that both EPS removal and re-addition improved sludge anaerobic digestion, the cumulative methane production increased by 14.9 % and 50.4 %. EPS removal promoted sludge hydrolysis and acidification, the soluble chemical oxygen demand (SCOD) and volatile fatty acids (VFAs) concentration increased by 31 % and 29 %. The re-addition of EPS increased the substrate of sludge fermentation, resulting in 1.64 and 1.77 times higher SCOD and VFAs concentration than that of control group. In addition, EPS contained lots of electrochemically active substances, and re-adding EPS increased the electron transfer system activity in anaerobic digestion by 164 %, which enhanced significantly methane production. Both removal and re-addition of EPS altered the microbial community structure in anaerobic digestion, the bacteria with hydrolysis and acidification functions were enriched, such as Chloroflexi and Desulfobacterota. Methanobacterium and Methanosaeta were the dominant methanogens in anaerobic digestion systems, and their relative abundance were increased by removing and re-adding EPS.

Anaerobic digestion of crude glycerol from biodiesel production for biogas generation: Process optimization and pilot scale operation

Anaerobic digestion of wastes and wastewater is a complex process that can be affected by many operational parameters. In this context, the purpose of the present study was to optimize biogas production using crude glycerol (GLY) generated in biodiesel production from waste cooking oil without pretreatment or nutrient supplementation. The study was divided into two parts: the first phase consisted of an experimental design based on central composite design (CCD) with two variables (food to microorganism (F/M) ratio and cycle time) at five levels (F/M of 0.20; 0.51; 1.02; 1.53 and 2.04 gCOD/gVS; tc of 3, 4, 5, 6, 7 days) focusing on optimizing the biogas production from crude GLY in lab-scale batch reactors (500 mL). The second phase was conducted on a pilot-scale biodigester (1.2 m3) based on the optimized variables obtained from the CCD. The optimized results showed that the F/M ratio of 2.04 gCOD/gVS and a cycle time (tc) of 6 days reached the highest specific methane production (SMP) of 46 LCH4/kgVS. However, the highest SMP of 14.7 LCH4/kgVSd was obtained during the operation of the pilot-scale biodigester for the optimized conditions of F/M ratio of 0.23 gCOD/gSV and a tc of 7 days. Therefore, pilot-scale biogas production from crude GLY was demonstrated to be feasible without the use of nutrients or GLY pretreatment at 0.15 LGLY/m3 d.

Ascorbic acid reduction pretreatment enhancing metal regulation to improve methane production from anaerobic digestion of waste activated sludge

Conversion of waste activated sludge (WAS) to methane by anaerobic digestion (AD) is often limited by the slow rate of hydrolysis, and the presence of metal ions in sludge is regarded as a critical factor hindering sludge hydrolysis. This study developed a novel strategy to remove Fe from WAS by using ascorbic acid (VC) as a reducing agent under acidic conditions. The feasibility of reduction pretreatment in improving methane production of AD and its intrinsic mechanism were investigated. Results indicate that, under VC doses of 100 mmol/L and pH of 3.50, pretreatment removed 47.60 % of Fe, 59.88 % of Ca, and 51.86 % of Mg contained in the sludge. The removal of metal ions facilitated the disruption of sludge flocculation structure and extracellular polymeric substance (EPS) layers, leading to a 14.78 % increase in cell lysis and a decrease in fractal dimension values to 2.08. Batch AD experiments showed that VC pretreatment improved methane production, with an optimized net methane yield of 190.22 mL/g·VS, an increase of 134.75 % compared to raw WAS. The pretreatment affected the interfacial interaction energy of the sludge, leading to a transformation in the sludge surfaces from hydrophilic to hydrophobic, reducing the interaction between sludge molecules and increasing the number of binding sites available for enzymatic reactions. According to a study of microbial communities, it was found that VC pretreatment caused an increase in the presence of essential functional microbes responsible for hydrolysis, acidification, and methanation. This increase in acetoclastic and hydrogenotrophic methanogens resulted in a substantial enhancement in methane production. These results can be used to develop better pretreatment methods to enhance AD performance.

Enhancing sustainable crop cultivation: The impact of renewable soil amendments and digestate fertilizer on crop growth and nutrient composition

Utilizing digestate as a fertilizer enhances soil nutrient content, improves fertility, and minimizes nutrient runoff, mitigating water pollution risks. This alternative approach replaces commercial fertilizers, thereby reducing their environmental impact and lowering greenhouse gas emissions associated with fertilizer production and landfilling. Herein, this study aimed to evaluate the impact of various soil amendments, including carbon fractions from waste materials (biochar, compost, and cocopeat), and food waste anaerobic digestate application methods on tomato plant growth (Solanum lycopersicum) and soil fertility. The results suggested that incorporating soil amendments (biochar, compost, and cocopeat) into the potting mix alongside digestate application significantly enhances crop yields, with increases ranging from 12.8 to 17.3% compared to treatments without digestate. Moreover, the combination of soil-biochar amendment and digestate application suggested notable improvements in nitrogen levels by 20.3% and phosphorus levels by 14%, surpassing the performance of the those without digestate. Microbial analysis revealed that the soil-biochar amendment significantly enhanced biological nitrification processes, leading to higher nitrogen levels compared to soil-compost and soil-cocopeat amendments, suggesting potential nitrogen availability enhancement within the rhizosphere's ecological system. Chlorophyll content analysis suggested a significant 6.91% increase with biochar and digestate inclusion in the soil, compared to the treatments without digestate. These findings underscore the substantial potential of crop cultivation using soil-biochar amendments in conjunction with organic fertilization through food waste anaerobic digestate, establishing a waste-to-food recycling system.

Revealing How Polyvinyl Chloride Microplastic Physicochemically Affect the Anaerobic Digestion of Waste Activated Sludge.

Recent studies have shown that the microplastics in waste activated sludge (WAS) can directly reduce the microbial activity and influence the performance of anaerobic digestion. Unfortunately, few studies paid attention on the interactions between WAS and MPs, since MPs could impact the contact between sludge flocs and microorganisms. We found that PVC-MP changed the interfacial energy properties of the WAS surface and affected methane production. Low concentration (40mg/L) of PVC-MP changed the water affinity and greatly reduced the energy barrier of interfacial reaction. Simultaneously, WAS surface charge characteristics changed with increasing MPs concentration, which made the sludge difficult to contact with microorganisms. The change process of WAS surface functional groups also indicated that PVC-MP first cover the sludge surface to prevent from being utilized by microorganisms, and then affect the surface protein structure before toxic substances leaching. Our study provides new insights into how MPs affect anaerobic digestion.

Preparation of ceramsite using solid residue from anaerobic digestion of waste activated sludge and its enhancing effect on catalytic ozonation

Anaerobic digestion is an environmentally friendly method for reclaiming waste activated sludge. However, it cannot be overlooked that the solid residue generated from this process can still pose environmental risks and impose economic pressure on society. To mitigate and recycle the solid residue, this study utilized it as a primary raw material for manufacturing ceramsite with potential applications in wastewater treatment. The optimal ratio of solid residue to fly ash was demonstrated to be 6:4 with an additional 15% of clay supplementing the raw ceramsite materials. Furthermore, the optimal sintering process was established as preheating at 300 °C for 25 min followed by sintering at 1085 °C for 10 min, as determined through an L16 (44) Orthogonal test. The prepared ceramsite demonstrated advantageous performance parameters that exceeded the standards outlined in the Chinese industry standard CJ/T 299–2008 for water treatment artificial ceramsite. When utilized in an ozonation system, the ceramsite exhibited remarkable catalytic activity for phenol degradation by promoting the decomposition of molecular O3 into hydroxyl radicals. Additionally, it displayed minimal leaching of heavy metals and lower application costs. These findings emphasize its attractiveness in water and wastewater treatment processes and present a practical strategy for reclaiming this solid residue.

Different responses of mesophilic and thermophilic anaerobic digestion of waste activated sludge to PVC microplastics.

The effect of microplastics (MPs) retained in waste activated sludge (WAS) on anaerobic digestion (AD) performance has attracted more and more attention. However, their effect on thermophilic AD remains unclear. Here, the influence of polyvinyl chloride (PVC) MPs on methanogenesis and active microbial communities in mesophilic (37 °C) and thermophilic (55 °C) AD was investigated. The results showed that 1, 5, and 10 mg/L PVC MPs significantly promoted the cumulative methane yield in mesophilic AD by 5.62%, 7.36%, and 8.87%, respectively, while PVC MPs reduced that in thermophilic AD by 13.30%, 18.82%, and 19.99%, respectively. Moreover, propionate accumulation was only detected at the end of thermophilic AD with PVC MPs. Microbial community analysis indicated that PVC MPs in mesophilic AD enriched hydrolytic and acidifying bacteria (Candidatus Competibacter, Lentimicrobium, Romboutsia, etc.) together with acetoclastic methanogens (Methanosarcina, Methanosaeta). By contrast, most carbohydrate-hydrolyzing bacteria, propionate-oxidizing bacterium (Pelotomaculum), and Methanosarcina were inhibited by PVC MPs in thermophilic AD. Network analysis further suggested that PVC MPs significantly changed the relationship of key microorganisms in the AD process. A stronger correlation among the above genera occurred in mesophilic AD, which may promote the methanogenic performance. These results suggested that PVC MPs affected mesophilic and thermophilic AD of WAS via changing microbial activities and interaction.

Comprehending the impact of berberine on anaerobic digestion of waste activated sludge

Berberine is a natural isoquinoline alkaloid performing wide-spectrum antimicrobial and antiviral effects like antibiotics. Its production generates berberine containing wastewater, and berberine adsorbed on waste activated sludge (WAS) will unavoidably enter the anaerobic digestion (AD) system while its impact on the AD process is unknown. Our research found that berberine of 20 mg/L (BBR20) slightly enhanced the methane yield (4.2 ± 0.6%) under mesophilic condition (35.0 ± 1.0 °C). However, 100 and 500 mg/L (BBR100 and BBR500) depressed methane production by 17.3 ± 4.3% and 83.2 ± 0.4%; meanwhile more soluble chemical oxygen demand (SCOD) including volatile fatty acid (VFA), protein, and polysaccharide were left in the fermentation broth, which led to an increase in sludge reduction. 88.3 ± 0.09%–99.1 ± 0.04% of berberine was distributed in the sludge phase and could be efficiently removed even under a high berberine level of 500 mg/L during the AD process. Exposure to different berberine concentrations promoted sludge dissolution and triggered more sludge extracellular polymeric substances (EPS) being dissolved. Lower berberine concentration (20 mg/L) enhanced acidification and methanogenesis steps, resulting in a final methane generation increase. While hydrolysis, acidification and methanogenesis processes were all inhibited by 100 and 500 mg/L berberine. Microbial analysis revealed that the main acid-producing bacteria genera were changed as Bacteroidetes vadinHA17 dominated in control, BBR20 and BBR100 groups, was replaced by Petrimonas in BBR500. Additionally, Methanosaeta, as a strict acetoclastic methanogen, was suppressed under exposure to 100 and 500 mg/L berberine. Accordingly, the declined abundance of archaea genera consuming acetic acid caused more VFA accumulation and less methane production in BBR100 and BBR500 groups.

Enhancing anaerobic digestion of waste activated sludge by dielectric barrier discharge pretreatment: Nutrient release, sludge hydrolysis and microbial community succession

A dielectric barrier discharge (DBD) pretreatment of waste activated sludge (WAS) was developed for boosting the releasing of organic matter from floc structures and microbial cells. The changes of protein and polysaccharide in different extracellular polymeric substances layers of SCOD releasing from sludge were determined by using three-dimensional fluorescence spectra. Significantly improved cumulative methane production was achieved via enhancing anaerobic digestion, which was 83.5% higher than that of the control. The formed ∙OH radicals play a key role in sludge hydrolysis, thus improving the biodegradability of WAS. Furthermore, high-throughput sequencing analysis showed that DBD pretreatment improved the relative abundances of the main functional microbes with respect to sludge hydrolysis and anaerobic digestion. Therefore, this study verifies the feasibility of DBD pretreatment in sludge hydrolysis and is expected to provide a practical new technology for anaerobic digestion of WAS.

A change in substance and microbial community structure during the co-composting of kitchen waste anaerobic digestion effluent, sewage sludge and Chinese medicine residue

Anaerobic digestion is a resource recovery method for organic waste, gaining attention due to carbon reduction. Disposing of anaerobic digestion effluent (ADE) is crucial for developing anaerobic digestion, but conventional wastewater treatment fails to effectively recover nutrients contained in the ADE. In the present study, the ADE without solid-liquid separation was mixed with sewage sludge and Chinese medicine residue for the composting, where the ADE could be recovered at high temperature through humification. Besides, the nitrogen balance, humification process, and microbial dynamics during the composting process were studied. The results showed that the group supplemented with ADE could increase the nitrogen retention efficiency by 2.21 % compared to the control group. High ammonia nitrogen content and salinity did not negatively affect the maturity and phytotoxicity of compost products and even increase the humification degree of compost products. Moreover, additional ADE may not alter microbial community structure, which could contribute to microbial succession. This is the first time to investigate the substance transformation and shift in microbial community structure while applying composting process for ADE treatment, in which the anaerobic-aerobic collaborative disposal process provides an alternative solution for the recovery of ADE.