Steam-flaked Corn Research Articles

Effect of Corn Processing in Finishing Diets Containing Wet Distillers Grains on Feedlot Performance and Carcass Characteristics of Finishing Steers

ABSTRACT Three-hundred sixty calf-fed steers (BW = 318 ± 15 kg) were used in a completely randomized design to evaluate corn processing methods in finishing diets containing wet distillers grains plus solubles (WDGS). Whole corn (WC) was compared with corn processed by different methods, consisting of dry-rolled corn (DRC), high-moisture corn (HMC), a 1:1 DRC:HMC combination (DM basis), steam-flaked corn (SFC), and finely-ground corn (FGC). The SFC with a flake density of 0.33 kg/L was obtained from a commercial feedlot. Basal dietary ingredients consisted of ground alfalfa hay (5.6% of DM) and dry supplement (3.0% of DM), with the balance being WDGS (30% of DM) and corn (61.4% of DM). Final BW and ADG were greater ( P P = 0.11) from cattle fed DRC:HMC (1.78 kg/d). Cattle fed HMC (0.185) had greater ( P P > 0.30) were detected between cattle fed HMC and DRC:HMC for ADG and G:F; however, cattle fed DRC tended to have greater ( P = 0.08) ADG, yet lower ( P = 0.08) G:F than cattle fed HMC. Carcass characteristics reflected performance. These data indicate that steam flaked and finely ground corn processing methods, or no processing, are not as effective as high-moisture or dry-rolled corn processing methods in finishing diets containing 30% WDGS.

The effects of feeding flaxseed during the receiving period on morbidity, mortality, performance, and carcass characteristics of heifers1

Two experiments were conducted at the Kansas State University Beef Cattle Research Center to determine the effects of feeding ground flaxseed (flax) during the receiving period on the growth, health, and subsequent finishing performance of heifers. Crossbred heifers (Exp. 1: n = 363, 214 +/- 1 kg of initial BW; Exp. 2: n = 377, 222 +/- 1 kg of initial BW) were purchased during January and April of 2006. Heifers were fed receiving rations based on steam-flaked corn with 0, 2, 4, or 6% ground flax (DM basis) for 56 d. Following the receiving period, cattle in Exp. 1 and 2 were fed steam-flaked corn-based diets for 150 and 147 d, respectively, and then slaughtered. Heifers were implanted 91 and 109 d before slaughter for Exp. 1 and 2, respectively. In Exp. 1, DMI during the receiving period tended to increase linearly (P = 0.09) with increasing flax in the diet. Average daily gain was 1.46, 1.56, 1.58, and 1.61 kg for heifers fed 0, 2, 4, and 6% flax, respectively (linear, P = 0.03). Final BW in Exp. 1 after the finishing period was increased (linear, P = 0.04) with increasing inclusion of flax in the receiving diets. In Exp. 2, growth performance and mortality during the receiving period were not different among treatments (P > 0.12). During the receiving period in Exp. 2, incidence of the first respiratory treatment tended to be greatest (P = 0.09) for heifers fed 4% flax. During the finishing period, DMI were 8.4, 8.4, 8.0, and 8.1 kg/d for 0, 2, 4, and 6% flax, respectively (linear, P = 0.05). In Exp. 2, LM areas were greatest (quadratic, P = 0.04) for cattle fed 2% flax at receiving. In general, feeding flax during the receiving period may have the potential to improve growth performance; however, performance between experiments was variable, and many factors excluding flax feeding may have contributed to this response.

Effects of calcium magnesium carbonate and roughage level on feedlot performance, ruminal metabolism, and site and extent of digestion in steers fed high-grain diets1,2

A feedlot growth performance experiment and 2 metabolism experiments were conducted to evaluate dietary roughage concentration and calcium magnesium carbonate in steers fed a high-grain diet. In Exp. 1, one hundred ninety-two crossbred yearling steers (320 +/- 10 kg of initial BW) were fed diets based on steam-flaked corn with 0, 0.75, or 1.5% CaMg(CO(3))(2). There were no effects (P > or = 0.13) on ADG, DMI, G:F, or total water intake due to CaMg(CO(3))(2). In Exp. 2, five ruminally and duodenally fistulated steers (263 +/- 9 kg of initial BW) were used in a 5 x 5 Latin square design, with 5 dietary treatments arranged in a 2 x 2 + 1 factorial: 1) 3.8% dietary roughage and no CaMg(CO(3))(2); 2) 7.6% dietary roughage and no CaMg(CO(3))(2); 3) 11.4% dietary roughage and no CaMg(CO(3))(2); 4) 3.8% dietary roughage and 1.5% CaMg(CO(3))(2); and 5) 7.6% dietary roughage and 1.5% CaMg(CO(3))(2). Water consumption was less (quadratic, P = 0.003) when 7.6% dietary roughage was fed compared with 3.8 or 11.4% dietary roughage. Intake of DM was not affected (P > or = 0.16) by dietary roughage or by CaMg(CO(3))(2). Poststomach and total tract starch digestion decreased (linear, P < 0.01) as dietary roughage increased. Ruminal pH tended (P = 0.08) to increase as dietary roughage increased but was not affected (P = 0.60) by CaMg(CO(3))(2). In Exp. 3, DMI and ruminal pH were continuously monitored in a 6 x 6 Latin square design using 6 ruminally and duodenally fistulated Holstein steers (229 +/- 10 kg of initial BW). A 3 x 2 factorial treatment structure was utilized, with factors consisting of dietary roughage concentration (4.5, 9.0, or 13.5%) and CaMg(CO(3))(2) inclusion (0 or 1.0%) to replace MgO and partially replace lime-stone. A dietary roughage x CaMg(CO(3))(2) interaction (P = 0.01) occurred as steers consuming 13.5% roughage, 1.0% CaMg(CO(3))(2) had greater DMI per meal than those consuming 4.5% dietary roughage, no CaMg(CO(3))(2) and 9.0% dietary roughage, 1.0% CaMg(CO(3))(2). Steers consuming 13.5% dietary roughage, 1.0% CaMg(CO(3))(2) and 9.0% dietary roughage, no CaMg(CO(3))(2) had greater meal length (min/meal; P = 0.01) than steers consuming 4.5% dietary roughage, no CaMg(CO(3))(2). Total tract OM digestibility decreased linearly (P = 0.01), and ruminal pH increased linearly (P = 0.01) with increasing dietary roughage concentration. Inclusion of CaMg(CO(3))(2) can replace limestone and MgO but did not produce ruminal pH responses similar to those observed by increasing dietary roughage in high-concentrate diets.

Influence of slice baling on feeding value of alfalfa hay in receiving and finishing diets for feedlot cattle1

Three studies were conducted to evaluate the feeding value of slice alfalfa hay in feedlot diets. In Exp. 1, 108 steer calves (183.1 +/- 1.2 kg initial BW; 6 pens/treatment) were used in a completely randomized design to evaluate the effect of baling method on performance and morbidity of newly received calves. The study lasted 28 d. Treatments consisted of a 65% concentrate receiving diet containing 1) ground or 2) slice alfalfa hay. Steer calves were fed daily at 0800 h. Animals also received long-stem sudangrass hay the first 7 d. Steers were weighed on d 0, 16, and 28. Feed, sudangrass hay, or feed plus sudangrass hay intakes were not affected (P > 0.25) by treatment. Conversely, ADG from d 0 to 16 was greater (P < 0.001) for slice than ground (1.27 vs. 0.81 +/- 0.067 kg/d, respectively) and from d 0 to 28 (1.23 vs. 0.91 +/- 0.042 kg/d, respectively). In addition, G:F was greater (P < 0.001) for slice than ground hay from d 0 to 16 (0.39 vs. 0.25 +/- 0.021), and from d 0 to 28 (0.31 vs. 0.24 +/- 0.013 for slice and ground, respectively). Moreover, morbidity (40.5 +/- 3.9%; P = 0.20) and retreatment rates (30.7 +/- 7.5%; P = 0.14) were similar for slice and ground. In Exp. 2, 176 crossbred steers (393.9 +/- 10.8 kg initial BW) were used in an 84-d feeding experiment (4 pens/treatment) in a randomized complete block experimental design with a 2 x 2 factorial arrangement of treatments to evaluate effects of alfalfa baling method (ground or slice) and forage level (8 or 14%) on growth performance. Experimental diets were based on steam-flaked corn. Daily BW gain was greater (P = 0.10) for steers consuming ground compared with the slice hay diet. A baling method x forage level interaction (P = 0.07) was observed for DMI. Baling method did not (P = 0.98) influence DMI with 8% roughage level. But with 14% roughage, DMI was greater (P = 0.02) for steers consuming ground hay than the slice diet. The G:F ratio was affected (P = 0.03) only by forage level (0.194 vs. 0.182 +/- 0.003 for 8 and 14% roughage, respectively). In Exp. 3, 4 ruminally cannulated mixed-breed steers were used in a 4 x 4 Latin square design to evaluate effects on digestive function. No baling method effects (P >or= 0.16) were detected for DM, OM, CP, or NDF intakes or DM, OM, and NDF total tract digestibility. Digestibility of NDF and OM were greater (P <or= 0.08) for diets which contained 14% forage compared with diets that contained 8% forage. Slice baling improved alfalfa hay feeding value for feedlot receiving cattle. However, no major effects of slice baling alfalfa on finishing performance and digestion were observed.

Performance of Dairy Cows Fed Annual Ryegrass Silage and Corn Silage with Steam-Flaked or Ground Corn

Twenty-four lactating Holstein cows were used in a 6-wk randomized block design trial with a 2×2 factorial arrangement of treatments to determine the effects of feeding ground corn (GC) or steam-flaked corn (SFC) in diets based on either annual ryegrass silage (RS) or a 50:50 blend of annual ryegrass and corn silages (BLEND). Experimental diets contained 49.6% forage and were fed as a total mixed ration once daily for 4 wk after a 2-wk preliminary period. No interactions were observed among treatments. Cows fed BLEND consumed more dry matter (DM), organic matter (OM), neutral detergent fiber (NDF), and acid detergent fiber (ADF) than those fed RS, but total-tract digestibility of OM, NDF, and ADF was greater for RS than for BLEND. No differences in nutrient intake were observed among treatments during wk 4 when nutrient digestibility was measured, but digestibility of DM and OM was greater for SFC than for GC. Cows fed BLEND tended to produce more energy-corrected milk than those fed RS, resulting in improved efficiency (kg of milk per kg of DM intake). When diets were supplemented with SFC, cows consumed less DM and produced more milk that tended to have lower milk fat percentage. Yield of milk protein and efficiency was greatest with SFC compared with GC. Blood glucose and milk urea nitrogen concentrations were similar among treatments, but blood urea nitrogen was greater for cows fed GC compared with those fed SFC. Results of this trial indicate that feeding a blend of annual ryegrass and corn silage is more desirable than feeding diets based on RS as the sole forage. Supplementing diets with SFC improved performance and efficiency compared with GC across forage sources.

Efficacy of monensin and tylosin in finishing diets based on steam-flaked corn with and without corn wet distillers grains with solubles1

Three hundred seventy-one crossbred-yearling heifers (299 +/- 9 kg initial BW) were obtained from a common source and used in a randomized complete-block designed finishing study. A 2 x 3 factorial arrangement of treatments was used with one factor being diet: based on steam-flaked corn finishing diet (SFC) or SFC plus 25% (dry basis) corn wet distillers grains with solubles (WDGS). The second factor was feed additives: no added antibiotics (NONE), 300 mg of monensin daily (MONENSIN), or 300 mg of monensin + 90 mg of tylosin daily (MON+TYL). Main effect of diet resulted in no difference in DMI (P = 0.34). Heifers fed SFC gained 9% faster (P = 0.01) and were 7% more efficient (P = 0.01) than heifers fed WDGS. In addition, heifers fed SFC had 3% heavier (P = 0.01) HCW; 1% greater (P = 0.01) dress yield; and had 3% larger (P = 0.05) LM area. Marbling score and carcasses that graded USDA Choice or better were both greater (P </= 0.03) for heifers fed SFC. Heifers fed MONENSIN had a smaller (P = 0.01) LM area than heifers fed NONE and tended (P = 0.09) to have smaller LM area than heifers fed MON+TYL. Marbling score, USDA quality grade, and USDA yield grade were not different (P >/= 0.12) among feed additive treatments. Kidney, pelvic, and heart fat and s.c. fat thickness at the 12th rib were also not different (P >/= 0.55) for main effects of diet and feed additive. There was a tendency (P = 0.09) for a diet x feed additive interaction for the most severe (A+) liver abscesses. Heifers fed NONE yielded the greatest percentage (16%) of A+ livers in the SFC treatment, whereas heifers fed MON+TYL yielded the greatest percentage (10%) in the WDGS treatment. Including wet distillers grains with solubles in diets based on steam-flaked corn decreased finishing heifer performance, HCW, and marbling. Tylosin addition tended to decrease severity of liver abscesses in diets containing SFC, but not in diets containing WDGS. These data indicate that monensin and tylosin may not be as effective when used in steam-flaked corn diets with 25% WDGS.

Efeitos do uso de sucedâneo do leite e milho processado no desempenho de bezerros da raça holandesa até o desmame

Seventy-two Holstein calves, 15 days old, were used to evaluate the substitution of whole milk by a milk replacer, and the effects of processed corn in starters. Animals were distributed in blocks by date of birth and sex, in a 2x3 factorial arrangement of treatments. Factors consisted of whole milk or milk replacer and steam flaked corn at densities 283, 360 and 437 g/L. During the pre-weaning period, the processed corn at different densities did not affect the performance of calves. Replacement of whole milk by milk replacer reduced daily body gain (milk = 0.56 vs. milk replacer = 0.30 kg/day), body weight at weaning (63.3 vs. 51.9 kg/day) and total dry matter intake (0.83 vs. 0.68 kg/day). Food conversion (1.61 vs. 2.60) became worse. Animals from milk replacer group were weaned earlier than the whole milk group (56.4 vs. 48.9 days).

Processamento do grão de milho e sua substituição parcial por polpa de citros peletizada sobre o desempenho, digestibilidade de nutrientes e parâmetros sangüíneos em vacas leiteiras

Four lactating cows were assigned to a 4x4 Latin square design with a 2x2 factorial arrangement for the following treatments: coarsely ground corn; steam-flaked corn; coarsely ground + citrus pulp; steam-flaked + citrus pulp. Steam-flaking grain (processing effect) increased total tract digestibility (%) of DM, OM, starch and protein; decreased rumen NH3-N and acetate and increased ruminal propionate. Feed efficiency, milk protein content and yield tended to be higher for flaked corn. Inclusion of citrus pulp did not affect DM intake and increased fiber digestibility. Inclusion of citrus pulp increased starch digestibility (%) in the case of coarsely ground corn diet. Rumen ammonia nitrogen and molar proportion of propionate were not affected by citrus pulp; ruminal acetate, however, was significantly increased. There was an interaction between grain processing and citrus pulp on plasma glucose concentration. Fat corrected milk, feed efficiency, milk fat content and yield were increased by citrus pulp.

Fontes de amido de diferentes degradabilidades e sua substituição parcial por polpa de citrus em dietas para vacas leiteiras

Four late lactating Holstein cows, canulated in rumen, were used in a 5x4 Latin Square Design to compare coarsely ground, finely ground and flaked corn and the partial replacement of these starch sources by citrus pulp. All diets contained corn silage as forage source. The treatments were finely ground corn (MF), steam-flaked corn (F), coarsely ground corn (MG), finely ground corn+ citrus pulp (MFP), steam-flaked corn + citrus pulp (FP). The MG treatment resulted in the lowest dry matter intake and lowest milk, fat and protein yields, while the FP treatment resulted in the highest dry matter intake, 3.5% fat corrected milk, fat and protein yields. The DM, CP, NDF and ADF total tract digestibility were high for FP, however F had a negative effect on fiber digestibility. The ruminal pH was low for FP. Ruminal ammonia and VFA were not affected by treatments. The F treatment reduced molar concentration of acetate and butyrate, while citrus pulp stimulated their ruminal production. Plasma glucose was not affected by treatments, however PUN was higher for MFP as compared to MG.

Corn distillers grains with solubles derived from a traditional or partial fractionation process: Growth performance and carcass characteristics of finishing feedlot heifers1

Six hundred ten crossbred-yearling heifers (347 +/- 5 kg of initial BW) were obtained and used in a randomized complete-block design finishing study. Finishing diets were based on steam-flaked corn and ground alfalfa hay. The control (CONT) treatment contained no distillers grains with solubles (DGS), the second diet was formulated to contained 13% (DM basis) dried corn DGS derived from a traditional dry-grind ethanol process (TRAD), and the third diet was formulated to contained 13% (DM basis) dried corn DGS derived from a partial fractionation dry-grind process (FRAC). Dry matter intake, ADG, and gain efficiency were not different (P >/= 0.48) for yearling heifers fed CONT when compared with heifers fed DGS. Heifers fed TRAD consumed more (P = 0.01) feed than heifers fed FRAC. However, ADG and feed efficiency were not different (P >/= 0.07) for heifers fed DGS. Moderate inclusion levels of DGS in finishing flaked corn diets yielded satisfactory performance. Growth performance was not different for heifers fed DGS originating from either ethanol processing method.

The Effects of Flaxseed Oil and Derivatives on In Vitro Gas Production, Performance, Carcass Characteristics, and Meat Quality of Finishing Steers

Two studies were conducted to determine the effects of flax oil and its derivatives on finishing feedlot performance, carcass characteristics, meat quality, and in vitro gas production. In trial 1, Holstein-Jersey steers (n = 60, 452kg initial BW) were fed steam-flaked corn diets with no supplemental fat (CON), flax oil (OIL), lipase-treated flax oil (L-OIL), or linseed soapstock (SOAP) for 90 d. Following slaughter, loin sections were removed from one side of each animal for fatty acid analysis. Dry matter intakes were highest for CON, lowest for L-OIL, and intermediate for steers fed OIL and SOAP (P < 0.01). No differences among treatments existed for ADG, G:F, final BW, or carcass characteristics (P > 0.48). Steers fed diets supplemented with flax lipids produced loin steaks with higher concentrations of alpha-linolenic acid and total omega-3 fatty acids compared with CON steers (P < 0.001). In trial 2, gas production from CON, OIL, L-OIL, SOAP, and ground flax was examined. Gas production for the SOAP treatment was less compared with all other treatments (P < 0.01) Gas production increased over time for all treatments (P < 0.001). Hydrolyzing flax oil with lipase decreased DMI compared with other treatments, but supplementing flax oil and flax oil derivatives increased concentrations of omega-3 fatty acids in loin tissues of feedlot steers. Linseed soap-stock and lipase-treated oil were inferior to flax oil as a strategy to increase omega-3 fatty acid concentrations in beef tissue.

Effect of Monensin and Live Yeast Supplementation on Growth Performance, Nutrient Digestibility, Carcass Characteristics and Ruminal Fermentation Parameters in Lambs Fed Steam-flaked Corn-based Diets

In performance, digestibility and slaughter trials, a total of forty five male weaned lambs were used to examine the effects of monensin and live yeast supplementations on growth performance, nutrient digestibility, carcass characteristics and ruminal fermentation parameters when the lambs were fed steam-flaked corn-based diets. Animals were allotted to one of three treatment diets in a completely randomized design. The three treatment diets were: (1) basal diet (CON) with steam-flaked corn as a sole grain source, (2) basal diet supplemented with monensin (MO), and (3) basal diet supplemented with live yeast (LY). Total average daily intake (ADI) was unaffected by MO and LY supplementations. LY supplementation increased (p<0.05) average daily gain (ADG) by 13.1% compared with the CON diet. Both MO and LY supplementations resulted in a significant improvement (p<0.05) of feed efficiency over the CON diet (4.47, 4.68 vs. 5.05). Hemicellulose digestibility was higher (p<0.05) for lambs in the LY supplementation group (62.4%) as compared with the CON group (55.7%), but no differences were observed in digestibilities of dry matter (DM), organic matter (OM), crude protein (CP), neutral detergent fiber (NDF) and acid detergent fiber (ADF). All carcass traits were not influenced by dietary supplementations. Ruminal pH in lambs fed the LY supplemental diet was more stable than that with the CON diet (6.57 vs. 6.17). Neither MO nor LY supplementation influenced the concentration of ruminal ammonia-N and total volatile fatty acid (VFA), and molar percentages of individual VFA. Plasma urea-N concentration was decreased (p<0.05) by MO and LY supplementations, while plasma β-hydroxybutyrate (BHBA), glucose and other blood parameters were unaffected. In conclusion, while both MO and LY supplementations had a positive impact on feed efficiency and LY supplementation stabilized ruminal pH and improved fiber utilization, none of the supplements had the capacity to significantly enhance the carcass characteristics.

Influence of processed grains on fecal pH, starch concentration, and shedding of Escherichia coli O157 in feedlot cattle1

Manipulation of cattle diets has been proposed as a possible preharvest control measure for Escherichia coli O157. Altering hindgut fermentation through diet changes may be a means to reduce fecal shedding of E. coli O157. In Exp. 1, the objective was to determine whether fecal shedding of E. coli O157 was related to fecal starch concentration. Beginning on d 20, and every week thereafter until d 61, steers in 54 pens (6 to 7 steers per pen) were sampled (n = 122) by fecal collection and rectoanal mucosal swabs (RAMS) for E. coli O157 and fecal starch concentration determinations. Escherichia coli O157 prevalence was 3.3% in fecal samples, 4.1% as measured by RAMS, and 4.9% by fecal or RAMS samples. Steers positive for E. coli O157 contained 21% more (P < 0.05) fecal starch than steers that were negative for E. coli O157. In Exp. 2, we attempted to alter the concentration of starch escaping rumen fermentation by feeding finishing diets based on steam-flaked corn (SFC) and dry-rolled corn (DRC) to 30 heifers prescreened for being culture positive for fecal E. coli O157. Beginning on d 13, heifers were sampled (feces and RAMS) weekly to monitor fecal pH and starch concentration, and prevalence of E. coli O157. Prevalence of E. coli O157 remained above 30% for the first 13 d, but declined (P < 0.05) over the entire 7-wk period. Based on RAMS, the prevalence of E. coli O157 tended to be greater (P = 0.08) for heifers fed SFC than for those fed the DRC diet. After d 20, heifers fed DRC had greater (P < 0.05) fecal starch and lower (P < 0.05) fecal pH than heifers fed SFC. Fecal pH was negatively correlated (r = − 0.34; P < 0.05; n = 143) with fecal starch concentration. Fecal starch concentration and pH were not different (P > 0.05) for heifers that were positive or negative for E. coli O157. Our data suggest that fecal shedding of E. coli O157 was not related to fecal pH or starch concentration in cattle fed grain-based diets.

Impact of beef cattle diets containing corn or sorghum distillers grains on beef color, fatty acid profiles, and sensory attributes1,2

Strip loins from 236 carcasses from crossbred yearling steers were collected on each of 2 slaughter dates (slaughter 1 or 2) to determine the effects of feeding corn or sorghum distillers grains (DG) on beef color, fatty acid profiles, lipid oxidation, tenderness, and sensory attributes. Dietary treatments consisted of a steam-flaked corn (SFC) diet without (control) or with 15% (DM basis) corn dry or wet DG (CDDG and CWDG) or sorghum dry or wet DG (SDDG and SWDG) and alfalfa hay (R). Additional treatments included SDDG or SWDG with no alfalfa hay (NR). In slaughter 2, steaks from steers fed SFC had lesser L*, but greater a* (P < 0.05) values than those from steers fed DG. When comparing sorghum and corn DG steaks, the same color differences were detected. Steaks from steers fed sorghum DG had lower L*, but greater a* (P < 0.05) values than those from steers fed corn DG. Also, L* values in steaks from steers fed SWDG with R were greater (P < 0.05) than those from steers fed SWDG with NR. In slaughter 1, feeding DG increased (P < 0.05) steak n-6 fatty acid concentrations compared with SFC. In both slaughter groups, feeding dry DG increased (P < 0.05) steak linoleic acid concentrations compared with wet DG. In slaughter 2, feeding corn DG diets increased (P < 0.05) linoleic acid concentrations of steaks compared with sorghum DG diets. In addition, increased (P < 0.05) concentrations of alpha-linolenic acid in steaks resulted from feeding SDDG or SWDG with R compared with those sorghum treatments with NR. In each slaughter group, feeding DG increased (P < 0.05) the n-6:n-3 ratio of steaks compared with SFC, and feeding corn DG increased (P < 0.05) this ratio compared with sorghum DG. Furthermore, steaks from steers fed corn DG had greater (P < 0.05) concentrations of trans-vaccenic acid than those from steers fed sorghum DG. In slaughter 1, the CLA isomer 18:2, trans-10, cis-12 was greater (P < 0.05) in steaks from DG diets. On d 1 of retail display, steaks from steers fed SDDG with R in slaughter 2 had greater (P < 0.05) thiobarbituric acid reactive substances values than those from steers fed SDDG with NR. Feeding DG at 15% of the dietary DM did not affect sensory attributes or Warner-Bratzler shear force values of steaks. Feeding DG from either corn or sorghum as either a wet or dry by-product had no effect on beef sensory attributes.

The effects of ractopamine-hydrogen chloride (Optaflexx) on performance, carcass characteristics, and meat quality of finishing feedlot heifers1

Two experiments were conducted at the Kansas State University Beef Cattle Research Center to determine the effects of ractopamine-HCl (Optaflexx) on growth performance, carcass characteristics, and meat quality of finishing feedlot heifers. In Exp. 1, heifers implanted with Revalor-H (n = 302, initial BW = 479 kg) were fed steam-flaked corn diets with 0 (control) or 200 mg of ractopamine-HCl (OPT) per heifer daily for 28 d before slaughter. Average daily gain and DMI were not different between treatments (P > 0.17); however, OPT cattle tended to have a greater G:F (P = 0.06). Treatments did not differ with respect to final BW, HCW, dressing percentage, USDA yield grade, USDA quality grade, marbling score, LM area, KPH, Warner-Bratzler shear force, weight loss during cooking, or L*, a*, or b* colorimetric values during a 7-d retail display or purge loss from loin steaks during retail display (P > 0.19). In Exp. 2, nonimplanted crossbred heifers (n = 281, BW = 451 +/- 2 kg) were fed finishing diets based on steam-flaked corn. A control diet (no ractopamine) was compared with diets providing 200 mg of OPT per heifer daily for periods of 28 or 42 d (200 x 28 and 200 x 42, respectively), 300 mg/d for 28 d (300 x 28), and a step-up regimen consisting of 14 d at 100 mg, followed by 14 d at 200 mg, and the final 14 d at 300 mg of OPT (step-up). Feeding OPT had no effect on carcass weight gain among treatments (P = 0.18). The efficiency of carcass gain was 34 and 35% greater (P = 0.06) for the 200 x 42 and step-up groups compared with control, respectively. Feeding OPT at 300 mg for 28 d reduced DMI compared with the control, 200 x 28, and 200 x 42 (P < 0.05) groups. Administration of OPT had no effect on marbling score, yield grade, LM area, KPH, or percentages of carcasses grading USDA Choice (P > 0.10). Feeding ractopamine-HCl (Optaflexx) to finishing heifers generally improved the efficiency of carcass gain with minimal effect on carcass characteristics. These effects were most pronounced in heifers fed ractopamine for 42 d.

Digestibility of dried distiller’s grains with solubles in steam-flaked or dry-rolled corn diets (2008)

In previous experiments, we observed that the nutritional value of dried distiller's grains is less when added to finishing diets made of steam-flaked corn than when added to diets of dry-rolled corn. We hypothesized that effects of grain processing on value of distiller's grains are attributable to differences in the digestion characteristics of grains processed via flaking or dry rolling. In this study, our objective was to evaluate differences in ruminal metabolism and total tract digestion of diets made from dry-rolled or steam-flaked corn with and without dried distiller's grains.

Dried distiller’s grains with solubles in steam-flaked or dry-rolled corn diets with reduced roughage levels (2008)

Distiller's grains have been used extensively in the U.S. Corn Belt, where producers commonly feed dry-rolled or highmoisture corn. Fuel ethanol production is expanding into the High Plains, where most feedlots flake grain. Compared with dry- rolled corn, steam-flaked corn usually increases or has no change in average daily gain, yields lower dry matter intake and results in 12 to 16% improvement in efficiency. Previous research at Kansas State University and elsewhere suggests that the value of distiller's grains is different in flaked grain diets than in dry-rolled diets. We think this might be due to lower rumen pH when flaked grains are fed, perhaps reducing digestibility of the diet, especially the fibrous components. Because distiller's grains contain considerable amounts of fiber, it might be possible to add less roughage to finishing diets that contain distiller's grains, and doing so, improve efficiency.

Crude glycerin in steam-flaked corn-based diets for beef cattle (2008)

Plant oils contain large amounts of triglycerides that will react to a catalyst, such as methanol. The transesterification reaction between the oil and alcohol will produce approximately 10% crude glycerin and 90% biodiesel. Crude glycerin is distilled for use in human products such as soaps, cosmetics, and moisturizers, but the usefulness of glycerin as a feed source for livestock is unclear. Rapid expansion of the biodiesel industry has created excess supplies of crude glycerin. It is thought that glycerin can be used in ruminant diets to decrease feed costs, but crude glycerin from biodiesel production can contain various levels of methanol, which can be toxic to livestock at increased levels. The purpose of this experiment was to determine the effects of feeding crude glycerin derived from soybean oil in steam-flaked corn finishing diets fed to beef cattle.

Dried distiller’s grains in steam-flaked corn finishing diets with decreased roughage levels (2008)

Distiller's grains are the primary coproduct derived from fuel ethanol production. As the fuel ethanol industry expands into the High Plains, distiller's grains are becoming increasingly available as an alternative feed for livestock. Optimizing the use of distiller's grains in flaked grain rations is important to maintaining a competitive advantage among feedlot producers in this region. Because distiller's grains are relatively high in fiber, it is conceivable that the level of roughages in feedlot diets could be reduced when distiller's grains are fed to cattle. Roughages normally have low energy density; therefore, the cost per unit of energy from roughages usually is relatively high compared with cereal grains or grain co-products. If the use of distiller's grains would allow roughage levels to be decreased in finishing diets without deleterious consequences for health or performance, this generally would be viewed as a positive attribute. Our objective was to evaluate performance of feedlot cattle fed diets with and without distiller's grains, and assess the effect of reducing the level of added roughage in diets containing distiller's grains.

Substituting steam-flaked corn with distiller’s grains alters ruminal fermentation and diet digestibility (2008)

Rapid expansion of fuel ethanol production in the High Plains, where feedlots commonly use steam-flaked corn diets, has popularized substituting dried distiller's grains with solubles (DDGS) for a portion of the steam- flaked corn. Most of the starch in corn is removed during ethanol production. The residual material is rich in fiber, ruminal undegradable protein, and fat. Adding roughage to high-concentrate finishing diets helps maintain ruminal function by stimulating salivation, rumination, and gut motility. The source and level of roughage can influence dry matter intake. Our objective was to examine ruminal fermentation characteristics and diet digestibility when steam-flaked corn-based finishing diets were fed with either 0 or 25% DDGS, using alfalfa hay or corn silage as roughage sources.