Recombinant IgG Research Articles

Randomized, controlled study of bleselumab (ASKP1240) pharmacokinetics and safety in patients with moderate-to-severe plaque psoriasis.

This study evaluated the pharmacokinetics (PK), efficacy, safety, and tolerability of bleselumab – a fully‐human anti‐CD40 monoclonal recombinant IgG4. Patients with moderate‐to‐severe psoriasis were randomized on day 1 to receive bleselumab or placebo on days 1, 15 and 29 in a dose‐escalation of bleselumab at 0.1, 0.3, 1.0 or 3.0 mg/kg. The safety‐analysis set (SAF) and full‐analysis set (FAS) included all patients who received bleselumab or placebo, and the PK‐analysis set (PKAS) included patients in the SAF with ≥1 quantifiable serum bleselumab concentration. Serial blood samples were collected after each dose, and the bleselumab serum concentration was measured. After each dose, the area‐under‐the‐concentration–time curve over 336 hours (AUC336) and the maximum serum concentration (Cmax), and dose proportionality of AUC336 and Cmax were determined. The psoriasis area and severity index (PASI) score, the physician static global assessment (PSGA) score, the percentage body surface area (%BSA) affected with psoriasis, adverse events and laboratory parameters were assessed. Sixty patients were randomized and included in the SAF/FAS (bleselumab, n = 49; placebo, n = 11); 48 formed the PKAS. Bleselumab Cmax and AUC336 were more than dose proportional in the range 0.1–3.0 mg/kg, suggesting nonlinear PK after single/multiple doses. No clinically significant infusion reactions, cytokine‐release syndrome, or thromboembolic events were reported. Bleselumab did not improve the PASI scores, PSGA scores, or %BSA versus placebo. Transient elevation of alanine aminotransferase and aspartate aminotransferase levels by >3 × upper limit of normal were observed in four (8.2%) and two (4.1%) patients, respectively, in the 1.0 or 3.0 mg/kg groups. Patients with liver function test increases had no concurrent changes in bilirubin. Bleselumab demonstrated nonlinear PK after single and multiple doses, with few adverse reactions.

Pharmacology study of a chimeric decoy receptor trap fusion protein on retina neovascularization by dual blockage of VEGF and FGF-2

BackgroundClinical anti-vascular epithelial growth factor (VEGF) therapy trials faced a major challenge due to upregulated expression of other pro-angiogenic factors, such as fibroblast growth factor-2 (FGF-2). RC28, a novel recombinant dual decoy receptor IgG1 Fc-fusion protein, can block VEGFA and FGF-2 simultaneously. It is designed for the treatment of neovascular age-related macular degeneration and other pathological ocular neovascularization. The present study investigated the prevention efficacy of RC28 on choroidal neovascularization (CNV) in a monkey model and compared to the other mono VEGF antagonists; biodistribution and pharmacokinetics performance were also investigated. MethodsELISA and endothelial cell proliferation, migration, and tubule formation assay evaluated the bioactivity of RC28 in vitro, and an initial comparison was made among the mono target antagonists, Bevacizumab (Avastin), Ranibizumab (Lucentis), Aflibercept (EYLEA), Conbercept (KH902), and Ranibizumab (Lucentis). Laser-induced CNV in monkeys, and both VEGF and FGF-2 serum levels were detected in animals before and after the CNV model were induced. RC28 prevention efficacy was compared to other VEGF antagonists on CNV with respect to the incidence of CNV and several ophthalmic examinations. Ocular and systemic levels of RC28 were analyzed by 89Zr-labeled RC28 after single intravitreal administration for the biodistribution and pharmacokinetic profiles. ResultsRC28 is a unique fusion protein with high affinity to both VEGF and FGF-2, and beneficial to in vitro and in vivo bioactivity. The in vivo pharmacological studies demonstrated that the incidence of CNV formation was largely reduced in RC28 treatment groups with a low dosage as compared to other VEGF antagonist control groups. Furthermore, traces of RC28 were detected as dispersing from eyeballs to the liver after 20 days, and a prolonged half-time pharmacokinetic profile was exhibited.

PET imaging of tumor PD-L1 expression with 89Zr-labeled anti-PD-L1 antibodies

Immunotherapy for the treatment of cancer is rapidly evolving from therapies that globally and nonspecifically simulate the immune system to more targeted activation of individual components of the immune system. More specifically, therapies that inhibit the interaction between programmed death ligand 1 (PD-L1), present on the surface of tumor or antigen-presenting cells, and programmed death 1 (PD-1), present on the surface of activated lymphocytes, are generating much excitement and enthusiasm, even in malignancies that are not traditionally considered to be immunogenic. Developing new methods to predict which patients will respond to a given immunotherapy is a “holy grail” for the field. Currently, biopsy and immunohistochemistry is used to determine antigen status of the tumor. However, in the case of PD-L1, it is well established that not patients whose biopsy is PD-L1 positive will respond to anti-PD-L1 therapy, and some patients with PD-L1 negative biopsies experience durable responses. Lastly, how or if PD-L1 expression changes over the lifetime of a tumor cell is not clear. These observations call into question whether studying an archival biopsy of a single lesion in a patient with substantial and evolving tumor burden is the best manner in which to study the utility of tumor expression of PDL1 as a predictive biomarker for anti-PDL1 therapy. We proposed instead to develop an immunoPET assay to globally quantify expression of PDL1 in tumors over time. In collaboration with investigators at the Singapore Immunology Network, we have radiolabeled a recombinant human monoclonal IgG with zirconium-89 and studied its pharmacology in vitro and in vivo. Conjugation of the antibody to desferrioxamine did not compromise the affinity or immunoreactivity of the IgG. The DFO-IgG conjugate was radiolabeled to > 80% radiochemical yield and > 99% purity. The 89Zr-IgG specifically targeted multiple PDL1 positive melanoma and non-small cell lung cancer xenografts in vivo. Moreover, the 89Zr-IgG did not appreciably localize to PDL1 negative tumor cells. In summary, these data highlight the ability of 89Zr-immunoPET to establish PDL1 status on a tumor cell, and argue strongly for a first in man study.

Human protective response induced by meningococcus B vaccine is mediated by the synergy of multiple bactericidal epitopes

4CMenB is the first broad coverage vaccine for the prevention of invasive meningococcal disease caused by serogroup B strains. To gain a comprehensive picture of the antibody response induced upon 4CMenB vaccination and to obtain relevant translational information directly from human studies, we have isolated a panel of human monoclonal antibodies from adult vaccinees. Based on the Ig-gene sequence of the variable region, 37 antigen-specific monoclonal antibodies were identified and produced as recombinant Fab fragments, and a subset also produced as full length recombinant IgG1 and functionally characterized. We found that the monoclonal antibodies were cross-reactive against different antigen variants and recognized multiple epitopes on each of the antigens. Interestingly, synergy between antibodies targeting different epitopes enhanced the potency of the bactericidal response. This work represents the first extensive characterization of monoclonal antibodies generated in humans upon 4CMenB immunization and contributes to further unraveling the immunological and functional properties of the vaccine antigens. Moreover, understanding the mechanistic nature of protection induced by vaccination paves the way to more rational vaccine design and implementation.

Recombinant IgG1 Fc hexamers block cytotoxicity and pathological changes in experimental in vitro and rat models of neuromyelitis optica

Intravenous human immunoglobulin G (IVIG) may have therapeutic benefit in neuromyelitis optica spectrum disorders (herein called NMO), in part because of the anti-inflammatory properties of the IgG Fc region. Here, we evaluated recombinant Fc hexamers consisting of the IgM μ-tailpiece fused with the Fc region of human IgG1. In vitro, the Fc hexamers prevented cytotoxicity in aquaporin-4 (AQP4) expressing cells and in rat spinal cord slice cultures exposed to NMO anti-AQP4 autoantibody (AQP4-IgG) and complement, with >500-fold greater potency than IVIG or monomeric Fc fragments. Fc hexamers at low concentration also prevented antibody-dependent cellular cytotoxicity produced by AQP4-IgG and natural killer cells. Serum from rats administered a single intravenous dose of Fc hexamers at 50 mg/kg taken at 8 h did not produce complement-dependent cytotoxicity when added to AQP4-IgG-treated AQP4-expressing cell cultures. In an experimental rat model of NMO produced by intracerebral injection of AQP4-IgG, Fc hexamers at 50 mg/kg administered before and at 12 h after AQP4-IgG fully prevented astrocyte injury, complement activation, inflammation and demyelination. These results support the potential therapeutic utility of recombinant IgG1 Fc hexamers in AQP4-IgG seropositive NMO.

Evaluation of different vector design strategies for the expression of recombinant monoclonal antibody in CHO cells

ABSTRACTMonoclonal antibodies (mAbs) have emerged as the most promising category of recombinant proteins due to their high efficiency for the treatment of a wide range of human diseases. The complex nature of mAbs creates a great deal of challenges in both upstream and downstream manufacturing processes. Proportional expression and correct folding and assembly of the light chain and heavy chain are required for efficient production of the mAbs. In this regard, expression vector design has proven to have profound effects on the antibody expression level as well as its stability and quality. Here, we have explored the efficiency of different vector design strategies for the expression of a recombinant IgG1 antibody in Chinese hamster ovary (CHO) cells. The antibody expression level was analyzed in transient expression and stable cell pools followed by expression analysis on single-cell clones. While detectable amounts of antibody were observed in all three systems, dual-promoter single-vector system showed the highest expression level in transient and stable expression as well as the highest productivity among clonal cells. Our results here show the importance of vector design for successful production of whole mAbs in CHO cells.

Recombinant humanized anti-PD-1 monoclonal antibody (JS001) as salvage treatment for advanced esophageal squamous cell carcinoma: Preliminary results of an open-label, multi-cohort, phase Ib/II clinical study.

116 Background: Patients with Esophageal squamous cell carcinoma (EC) often present with advanced and metastatic stage disease, which has poor prognosis and limited treatment options, and represent an important unmet medical need especially in China/Asia. JS001, a humanized recombinant IgG4 antibody against PD-1, selectively blocks the interactions of PD-1 with its ligands PD-L1 and PD-L2, and promotes antigen specific T-cell activation. A phase I study of JS001 in Chinese patients with heavily pretreated solid tumors has demonstrated an acceptable safety profile in doses up to 10 mg/kg Q2W. Here we report the safety and efficacy of JS001 in a phase Ib/II clinical study in Chinese patients with refractory/metastatic EC. (Clinical trial ID: NCT02915432) Methods: Refractory/metastatic EC Patients receive JS001 3 mg/kg Q2W until disease progression or unacceptable toxicity. All patients with measurable disease will be assessed for clinical response every 8 weeks according to the RECIST 1.1 criteria. Tumor PD-L1 expression as well as additional potential predictive biomarkers are monitored for correlation with clinical response. Results: Between Apr 19 2017 and Sep 11 2017, 56 EC pts (84.9% received at least 2 Lines of treatment) were enrolled into the study. Treatment related adverse events occurred were mostly grade 1 or 2. As of Sep 11 2017, 34 EC pts have been evaluated for clinical efficacy. Among these pts, 8 PR (partial response) and 14 SD (stable disease) were observed (ORR 23.5% and DCR 64.7%). The PD-L1 expression positivity (defined as positive staining ³1% on Tumor Cell [TC] or on Immune Cell [IC] by SP142) in EC tumor tissue was 21.4% (12/56). 2/10 (20%) PD-L1+ patients and 6/24 (25%) PD-L1 negative patients achieved partial responses. Conclusions: JS001 showed a promising preliminary clinical activity in heavily pre-treated metastatic EC pts with a manageable safety profile. Clinical response was not correlated with PD-L1 expression. Pts will be continuously monitored for safety and efficacy upon JS001 treatment. Clinical trial information: NCT02915432.

Recombinant humanized anti-PD-1 monoclonal antibody (JS001) as salvage treatment for advanced gastric adenocarcinoma: Preliminary results of an open-label, multi-cohort, phase Ib/II clinical study.

108 Background: Patients with gastric adenocarcinoma (GC) or gastroesophageal junction cancer (GEC) often present with advanced or metastatic disease, which has poor prognosis and limited treatment options and represent an important unmet medical need especially in China/Asia. JS001, a humanized recombinant IgG4 antibody against PD-1, selectively blocks the interactions of PD-1 with its ligands PD-L1 and PD-L2, and promotes antigen specific T-cell activation. A phase I study of JS001 in Chinese patients with heavily pretreated solid tumors has demonstrated an acceptable safety profile in doses up to 10 mg/kg Q2W. Here we report the safety and efficacy of JS001 in a phase Ib/II clinical study in Chinese patients with refractory/metastatic GC. (Clinical trial ID: NCT02915432) Methods: Refractory/metastatic GC Patients receive JS001 3 mg/kg Q2W until disease progression or unacceptable toxicity. All patients with measurable disease will be assessed for clinical response every 8 weeks according to the RECIST 1.1 criteria. Tumor PD-L1 expression as well as additional potential predictive biomarkers are monitored for correlation with clinical response. Results: Between Apr 19, 2017 and Sep 11, 2017, 48 GC pts (74.5% received at least 2 Lines of treatment) were enrolled into the study. Treatment related adverse events occurred were mostly grade 1 or 2. As of Sep 11, 2017, 25 GC pts have been evaluated for clinical efficacy. 5 PR (partial response) and 10 SD (stable disease) were observed (ORR 20% and DCR 60%). The PD-L1 expression positivity (defined as positive staining ³1% on Tumor Cell or on Immune Cell by SP142) in EC tumor was 14.3% (7/48). 3/5 (60%) PD-L1+ patients and 2/20 (10%) PD-L1 negative patients achieved partial responses. Conclusions: JS001 showed a promising preliminary clinical activity in heavily pre-treated metastatic GC pts with a manageable safety profile. Of the 25 evaluable GC patients by 9/11/2017, 5 PR and 10 SD were observed (ORR 20% and DCR 60%). Among PD-L1 positive patients (n=5), ORR was 60% and DCR 80%. Pts will be continuously monitored for safety and efficacy upon JS001 treatment. Clinical trial information: NCT02915432.

Generation of Recombinant Monoclonal Antibodies from Single B Cells Isolated from Synovial Tissue of Rheumatoid Arthritis Patients.

Ectopic lymphoid structure (ELS) can form in the target tissues of patients with chronic inflammatory autoimmune diseases such as rheumatoid arthritis (RA) and Sjögren's syndrome (SS). Although it is still not clear why ELS form only in a subset of patients, it is well known that these structures can acquire features of ectopic germinal centers and contribute actively to the production of autoantibodies. Here, we describe a method to generate recombinant monoclonal antibodies from single ELS+ synovial tissue B cells obtained from RA patients. This chapter gives a detailed description of the method beginning from the mononuclear cell preparation from RA synovial tissue, single-cell sort of B cells by flow cytometry, amplification of the immunoglobulin (Ig) genes (both heavy- and light-chain genes) by PCR, and subsequent Ig gene expression vector cloning for full recombinant IgG1 monoclonal antibody (rmAb) production in vitro. The recombinant mAbs generated can be then characterized for (1) analysis of the Ig gene repertoires for clonal studies, (2) immunoreactivity profile, and (3) functional studies both in vitro and in vivo.

Alga-Made Anti-Hepatitis B Antibody Binds to Human Fcγ Receptors.

Microalgae are unicellular eukaryotic organisms which represent an emerging alternative to other cell biofactories commonly used to produce monoclonal antibodies. Microalgae display several biotechnological advantages such as their rapid growth rate and their phototrophic lifestyle allowing low production costs as protein expression is solar-fueled. Recently, a fully assembled recombinant IgG antibody directed against Hepatitis B surface antigen is produced and secreted in the culture medium of the diatom Phaeodactylum tricornutum. A biochemical characterization of this recombinant antibody demonstrated that the Asn-297 is N-glycosylated by oligomannosides. In the immune system, antibodies interact with effector molecules and cells through their Fc part and the recognition of Fcγ receptors (FcγR) which are important for inducing phagocytosis of opsonized microbes. Interactions between IgG and FcγR are influenced by the N-glycan structures present on the Asn-297. In this study, the authors characterized the binding capacity of the anti-hepatitis B recombinant IgG produced in P. tricornutum to two human Fcγ receptors (FcγRI and IIIa) using a cellular binding assay and surface plasmon resonance (SPR). This allowed us to demonstrate that the alga-made antibody is able to bind FcγRI with a reduced affinity and engages FcyRIIIa with 3-times higher affinity compared to a control human IgG1.

Higher order structures of Adalimumab, Infliximab and their complexes with TNFα revealed by electron microscopy.

Adalimumab and Infliximab are recombinant IgG1 monoclonal antibodies (mAbs) that bind and neutralize human tumor necrosis factor alpha (TNFα). TNFα forms a stable homotrimer with unique surface-exposed sites for Adalimumab, Infliximab, and TNF receptor binding. Here, we report the structures of Adalimumab-TNFα and Infliximab-TNFα complexes modeled from negative stain EM and cryo-EM images. EM images reveal complex structures consisting of 1:1, 1:2, 2:2, and 3:2 complexes of Adalimumab-TNFα and Infliximab-TNFα. The 2:2 complex structures of Adalimumab-TNFα and Infliximab-TNFα show diamond-shaped profiles and the 2D class averages reveal distinct orientations of the Fab domains, indicating different binding modes by Adalimumab and Infliximab to TNFα. After separation by size exclusion chromatography and analysis by negative stain EM, the 3:2 complexes of Adalimumab-TNFα or Infliximab-TNFα complexes are more complicated but retain features recognized in the 2:2 complexes. Preliminary cryo-EM analysis of 3:2 Adalimumab-TNFα complex generated a low-resolution density consistent with a TNFα trimer bound with three Fab domains from three individual antibody molecules, while each antibody molecule binds to two molecules of TNFα trimer. The Fc domains are not visible in the reconstruction. These results show the two mAbs form structurally distinct complexes with TNFα.

Generation and characterization of cross neutralizing human monoclonal antibody against 4 serotypes of dengue virus without enhancing activity.

BackgroundDengue disease is a leading cause of illness and death in the tropics and subtropics. Most severe cases occur among patients secondarily infected with a different dengue virus (DENV) serotype compared with that from the first infection, resulting in antibody-dependent enhancement activity (ADE). Our previous study generated the neutralizing human monoclonal antibody, D23-1B3B9 (B3B9), targeting the first domain II of E protein, which showed strong neutralizing activity (NT) against all four DENV serotypes. However, at sub-neutralizing concentrations, it showed ADE activity in vitro.MethodsIn this study, we constructed a new expression plasmid using the existing IgG heavy chain plasmid as a template for Fc modification at position N297Q by site-directed mutagenesis. The resulting plasmid was then co-transfected with a light chain plasmid to produce full recombinant IgG (rIgG) in mammalian cells (N297Q-B3B9). This rIgG was characterized for neutralizing and enhancing activity by using different FcγR bearing cells. To produce sufficient quantities of B3B9 rIgG for further characterization, CHO-K1 cells stably secreting N297Q-B3B9 rIgG were then established.ResultsThe generated N297Q-B3B9 rIgG which targets the conserved N-terminal fusion loop of DENV envelope protein showed the same cross-neutralizing activity to all four DENV serotypes as those of wild type rIgG. In both FcγRI- and RII-bearing THP-1 cells and FcγRII-bearing K562 cells, N297Q-B3B9 rIgG lacked ADE activity against all DENV serotypes at sub-neutralizing concentrations. Fortunately, the N297Q-B3B9 rIgG secreted from stable cells showed the same patterns of NT and ADE activities as those of the N297Q-B3B9 rIgG obtained from transient expression against DENV2. Thus, the CHO-K1 stably expressing N297Q-B3B9 HuMAb can be developed as high producer stable cells and used to produce sufficient amounts of antibody for further characterization as a promising dengue therapeutic candidate.DiscussionHuman monoclonal antibody, targeted to fusion loop of envelope domainII (EDII), was generated and showed cross-neutralizing activity to 4 serotypes of DENV, but did not cause any viral enhancement activity in vitro. This HuMAb could be further developed as therapeutic candidates.

Site-Specific Conjugation to Native and Engineered Lysines in Human Immunoglobulins by Microbial Transglutaminase.

The use of microbial transglutaminase (MTG) to produce site-specific antibody-drug conjugates (ADCs) has thus far focused on the transamidation of engineered acyl donor glutamine residues in an antibody based on the hypothesis that the lower specificity of MTG for acyl acceptor lysines may result in the transamidation of multiple native lysine residues, thereby yielding heterogeneous products. We investigated the utilization of native IgG lysines as acyl acceptor sites for glutamine-based acyl donor substrates. Of the approximately 80 lysines in multiple recombinant IgG monoclonal antibodies (mAbs), none were transamidated. Because recombinant mAbs lack the C-terminal Lys447 due to cleavage by carboxypeptidase B in the production cell host, we explored whether blocking the cleavage of Lys447 by the addition of a C-terminal amino acid could result in transamidation of Lys447 by a variety of acyl donor substrates. MTG efficiently transamidated Lys447 in the presence of any nonacidic, nonproline amino acid residue at position 448. Lysine scanning mutagenesis throughout the antibody further revealed several transamidation sites in both the heavy- and light-chain constant regions. Additionally, scanning mutagenesis of the hinge region in a Fab' fragment revealed sites of transamidation that were not reactive in the context of the full-length mAb. Here, we demonstrate the utility of single lysine substitutions and the C-terminal Lys447 for engineering efficient acyl acceptor sites suitable for site-specific conjugation to a range of glutamine-based acyl donor substrates.

Recombinant humanised anti-PD-1 monoclonal antibody (JS001) treatment for patients with refractory or metastatic nasopharyngeal carcinoma: preliminary results of an open-label, phase 1b/2, clinical study

BackgroundPatients with unresectable or recurrent nasopharyngeal cancer who have disease progression after standard therapy have few treatment options and represent an important, unmet medical need. Nasopharyngeal cancer is closely associated with Epstein-Barr virus (EBV) infection and has been reported to have high concentrations of PD-L1 expression and tumour-infiltrating lymphocytes, which indicate a potential implication of PD-1 blockade in the treatment of nasopharyngeal cancer. JS001, a humanised recombinant IgG4 antibody against PD-1, selectively blocks the interactions of PD-1, with its ligands PD-L1 and PD-L2, and promotes antigen-specific T-cell activation. Results of a phase 1 study of JS001 treatment in Chinese patients with heavily pretreated solid tumours have shown an acceptable safety profile in doses up to 10 mg/kg once every 2 weeks until progressive disease, intolerance, withdrawal of consent, or investigator decision. Here we report the safety and efficacy of JS001 in a phase 1b/2 clinical study. MethodsWe did this open-label, phase 1b/2, clinical study in Chinese patients with refractory or metastatic nasopharyngeal cancer received JS001 3 mg/kg once every 2 weeks until disease progression or unacceptable toxicity. All patients with measurable disease were assessed for clinical response every 8 weeks according to the immune-related Response Evaluation Criteria In Solid Tumors (iRECIST) criteria. Tumour PD-L1 expression, plasma EBV DNA concentration, and additional potential predictive biomarkers were monitored for correlation with clinical response. This study is registered with ClinicalTrials, number NCT02915432. FindingsBetween Dec 29, 2016, and June 19, 2017, we enrolled 48 patients with nasopharyngeal cancer. Of 23 evaluable patients, the median age was 46 years (range 33–70), 81% were male, and EBV serology tested positive in 92%. Adverse events occurred in 46 (96%) of 48 patients, which were mostly grade 1 or 2. Grade 3 and worse adverse events occurred in 17 patients (35%), including abnormal liver function (n=6, 13%), dysphagia (n=2, 4%), and pulmonary infection (n=2, 4%). Rapid and deep clinical responses were observed. Seven patients (15%) had partial responses while ten patients (21%) achieved stable disease, with the proportion of patients who achieved an objective response of 30% and a disease control of 73%. The responses seemed unrelated to PD-L1 expression status on tumour biopsy. InterpretationJS001 treatment has shown good clinical activity in heavily pretreated patients with nasopharyngeal cancer and a manageable safety profile. We plan to enrol 54 patients with nasopharyngeal cancer to further monitor the safety and efficacy of JS001 treatment. FundingShanghai Science and Technology Innovation Fund.

Reproductive and developmental toxicology studies with gantenerumab in PS2APP transgenic mice

Gantenerumab is intended for the treatment of Alzheimer’s disease. It is a fully human recombinant monoclonal IgG1 which binds aggregated forms of amyloid beta such as Aβ oligomers, fibrils and neuritic amyloid plaques. A full package of developmental and reproductive toxicity (DART) studies was performed in the PS2APP double-transgenic mouse model of Alzheimer’s disease. A combined fertility and embryo fetal development study and a pre-and post-natal development study were performed. The PS2APP mouse model allowed a more complete DART evaluation than would have been possible in conventional species or strains which do not express the target antigen of gantenerumab. No developmental or reproductive hazards were identified.

Enhanced Effector Functions Due to Antibody Defucosylation Depend on the Effector Cell Fcγ Receptor Profile.

Abs of the IgG isotype are glycosylated in their Fc domain at a conserved asparagine at position 297. Removal of the core fucose of this glycan greatly increases the affinity for FcγRIII, resulting in enhanced FcγRIII-mediated effector functions. Normal plasma IgG contains ∼94% fucosylated Abs, but alloantibodies against, for example, Rhesus D (RhD) and platelet Ags frequently have reduced fucosylation that enhances their pathogenicity. The increased FcγRIII-mediated effector functions have been put to use in various afucosylated therapeutic Abs in anticancer treatment. To test the functional consequences of Ab fucosylation, we produced V-gene-matched recombinant anti-RhD IgG Abs of the four different subclasses (IgG1-4) with and without core fucose (i.e., 20% fucose remaining). Binding to all human FcγR types and their functional isoforms was assessed with surface plasmon resonance. All hypofucosylated anti-RhD IgGs of all IgG subclasses indeed showed enhanced binding affinity for isolated FcγRIII isoforms, without affecting binding affinity to other FcγRs. In contrast, when testing hypofucosylated anti-RhD Abs with FcγRIIIa-expressing NK cells, a 12- and 7-fold increased erythrocyte lysis was observed with the IgG1 and IgG3, respectively, but no increase with IgG2 and IgG4 anti-RhD Abs. Notably, none of the hypofucosylated IgGs enhanced effector function of macrophages, which, in contrast to NK cells, express a complex set of FcγRs, including FcγRIIIa. Our data suggest that the beneficial effects of afucosylated biologicals for clinical use can be particularly anticipated when there is a substantial involvement of FcγRIIIa-expressing cells, such as NK cells.

Abstract 65: RESPECT (REsidue-SPEcific Conjugation Technology): A platform technology utilizing native cysteine and lysine residues for the generation of homogeneous antibody-drug conjugates

Abstract The random conjugation of toxins, dyes, peptides, or other payloads to monoclonal antibodies often targets free thiol groups generated by partial reduction methods or lysine residues using succinimide- or isothiocyanate-based chemistry. There remains a need for conjugation technologies targeting specific amino acid residues as a way to produce a homogeneous antibody-drug conjugate (ADC) product with a defined drug-to-antibody ratio (DAR). Our REsidue-SPEcific Conjugation Technology (RESPECT) utilizes two methods by which payloads can be conjugated to specific residues in an antibody. Our cysteine-specific conjugation method exploits a unique intrachain disulfide bond in the light chain of rabbit antibodies between residues 80 and 171 of the variable and constant domains, respectively. Our humanization strategy allows retention of the cysteine at position 80 with a free thiol group that is both amenable for residue-specific conjugation and compatible with optimal antibody biophysical properties including antigen binding and structural stability. This platform has been optimized via antibody engineering strategy stems from in silico modeling, extensive mutagenesis, and crystallographic studies, which have allowed defining the contribution of neighboring residues to the retention of a reactive thiol group as well as the desired humanized antibody’s properties. Our C-terminal lysine-specific linkage method employs the transglutaminase enzyme that catalyzes the formation of a stable isopeptide bond between the γ-carboxyamide group (acyl donor) of a glutamine and the ϵ-amino group (acyl acceptor) of a lysine. While we found no acyl acceptor sites in recombinant wild-type IgG, all antibodies investigated lacked the C-terminal Lys447 due to cleavage by carboxypeptidase B in the antibody production cell line. Blocking the cleavage of Lys447 by addition of a C-terminal amino acid resulted in transamidation of Lys447 by a variety of acyl donor substrates in the presence of any non-acidic, non-proline amino acid residue at position 448. Antibody-drug conjugates (ADCs) prepared using our RESPECT technology targeting the tumor associated-mesothelin protein produced uniform drug-to-antibody ratios (DAR) and were shown to be highly potent and specific in vitro and effective in vivo in reduction of tumor growth in a highly aggressive mesothelin-expressing xenograft tumor model. Citation Format: Earl Albone, Jared Spidel, Xin Cheng, Young Chul Park, Sara Jacob, Arielle Verdi, Andrew Milinichik, Ben Vaessen, J. Bradford Kline, Luigi Grasso. RESPECT (REsidue-SPEcific Conjugation Technology): A platform technology utilizing native cysteine and lysine residues for the generation of homogeneous antibody-drug conjugates [abstract]. In: Proceedings of the American Association for Cancer Research Annual Meeting 2017; 2017 Apr 1-5; Washington, DC. Philadelphia (PA): AACR; Cancer Res 2017;77(13 Suppl):Abstract nr 65. doi:10.1158/1538-7445.AM2017-65

Alteration of a recombinant protein N-glycan structure in silkworms by partial suppression of N-acetylglucosaminidase gene expression.

To synthesize complex type N-glycans in silkworms, shRNAs against the fused lobe from Bombyx mori (BmFDL), which codes N-acetylglucosaminidase (GlcNAcase) in the Golgi, was expressed by recombinant B.mori nucleopolyhedrovirus (BmNPV) in silkworm larvae. Expression was under the control of the actin promoter of B. mori or the U6-2 and i.e.-2 promoters from Orgyia pseudotsugata multiple nucleopolyhedrovirus (OpMNPV). The reduction of specific GlcNAcase activity was observed in Bm5 cells and silkworm larvae using the U6-2 promoter. In silkworm larvae, the partial suppression of BmFDL gene expression was observed. When shRNA against BmFDL was expressed under the control of U6-2 promoter, the Man3GlcNAc(Fuc)GlcNAc structure appeared in a main N-glycans of recombinant human IgG. These results suggested that the control of BmFDL expression by its shRNA in silkworms caused the modification of its N-glycan synthetic pathway, which may lead to the alteration of N-glycans in the expressed recombinant proteins. Suppression of BmFDL gene expression by shRNA is not sufficient to synthesize complex N-glycans in silkworm larvae but can modify the N-glycan synthetic pathway.

CHO Cells adapted to inorganic phosphate limitation show higher growth and higher pyruvate carboxylase flux in phosphate replete conditions.

Inorganic phosphate (Pi ) is an essential ion involved in diverse cellular processes including metabolism. Changes in cellular metabolism upon long term adaptation to Pi limitation have been reported in E. coli. Given the essential role of Pi , adaptation to Pi limitation may also result in metabolic changes in animal cells. In this study, we have adapted CHO cells producing recombinant IgG to limiting Pi conditions for 75 days. Not surprisingly, adapted cells showed better survival under Pi limitation. Here, we report the finding that such cells also showed better growth characteristics compared to control in batch culture replete with Pi (higher peak density and integral viable cell density), accompanied by a lower specific oxygen uptake rate and cytochrome oxidase activity towards the end of exponential phase. Surprisingly, the adapted cells grew to a lower peak density under glucose limitation. This suggests long term Pi limitation may lead to selection for an altered metabolism with higher dependence on glucose availability for biomass assimilation compared to control. Steady state U-13 C glucose labeling experiments suggest that adapted cells have a higher pyruvate carboxylase flux. Consistent with this observation, supplementation with aspartate abolished the peak density difference whereas supplementation with serine did not abolish the difference. This supports the hypothesis that cell growth in the adapted culture might be higher due to a higher pyruvate carboxylase flux. Decreased fitness under carbon limitation and mutations in the sucABCD operon has been previously reported in E. coli upon long term adaptation to Pi limitation, suggestive of a similarity in cellular response among such diverse species. © 2017 American Institute of Chemical Engineers Biotechnol. Prog., 33:749-758, 2017.

Identification and characterization of monoclonal antibody fragments cleaved at the complementarity determining region using orthogonal analytical methods.

Sodium dodecyl sulfate capillary electrophoresis (CE-SDS) has been widely used to separate and quantify monoclonal antibody (mAb) fragments and impurities. Two fragments with different masses smaller than monomer were observed in the CE-SDS analysis of a recombinant IgG1 mAb treated at 40°C for 28days. Reversed phase liquid chromatography mass spectrometry (RP-LC-MS) and trypsin digestion peptide mapping followed by LC-MS/MS analysis were employed to conclusively demonstrate that these antibody fragments were the degradation products derived from a Ser-Ser peptide bond cleavage at the heavy chain complementarity determining region (CDR). The total percentage of the cleaved antibody heavy chain was increased from 1.1% in the control sample to 4.6% in the forced degradation sample stored at 40°C for 28days by using CE-SDS analysis. Native size exclusion liquid chromatography (SEC-HPLC) was used to analyze the fragment profile of this treated mAb but did not reveal fragments smaller than the monomer. However, a small fragment was detected using denaturing size exclusion liquid chromatography (dSEC-HPLC) and was confirmed to be the N-terminal fragment of the heavy chain cleaved at the CDR region using RP-LC-MS analysis. These results suggested that this N-terminal fragment may be closely associated with the rest of the cleaved antibody molecule through non-covalent bond interactions. Moreover, when dSEC-HPLC and RP-LC-MS were used to analyze the aggregate and monomer samples individually collected from SEC-HPLC, both samples contained the same amount of the cleaved N-terminal fragment. These results suggested that the CDR region cleaved fragments likely not be involved in aggregates formation of this antibody. This case study reiterated that a combination of orthogonal analytical methods plays a crucial role in comprehensively analyzing and characterizing antibody fragmentation.