Subsequent Anaerobic Digestion Research Articles

Energy recovery of residual yeast via hydrothermal liquefaction with multi-cycle reuse of the post-HTL wastewater and subsequent anaerobic digestion

Coupling hydrothermal liquefaction (HTL) with anaerobic digestion (AD) could be an interesting alternative for the energetic reuse of residual yeast derived from ethanol production, generating two valuable biofuels to diversify the global energy matrix. A central composite rotational design 23 optimized residual yeast HTL. The independent variables were temperature (300–400 °C), retention time (30–60 min), and solid content (5–12 wt%). The principal response variable was bio-oil yield. Three recirculation cycles of post-HTL wastewater (PHW) into the HTL reaction were investigated to enhance the energy recovery. The methanogenic potential of PHWs from recirculation cycles was then determined at mesophilic temperatures. During HTL, the bio-oil yield remained constant, while the volume of PHW decreased with recirculation cycles. The organic matter and total nitrogen present in the PHW were reduced until Cycle 2. The highest energy recovery in HTL was achieved at Cycle 0. However, the highest energy recovery in AD was attained at AD-Cycle 2, showing an approximately ∼14 % increase compared to AD-Cycle 0 (no recirculation). The total energy recovery for HTL-AD was higher in both Cycle 0 and Cycle 2, with Cycle 0 being more advantageous regarding net energy recovery from the products. In contrast, Cycle 2 offered more significant energy recovery and sustainability benefits.

Mitigation of Triclocarban Inhibition in Microbial Electrolysis Cell-Assisted Anaerobic Digestion.

Triclocarban (TCC), as a widely used antimicrobial agent, is accumulated in waste activated sludge at a high level and inhibits the subsequent anaerobic digestion of sludge. This study, for the first time, investigated the effectiveness of microbial electrolysis cell-assisted anaerobic digestion (MEC-AD) in mitigating the inhibition of TCC to methane production. Experimental results showed that 20 mg/L TCC inhibited sludge disintegration, hydrolysis, acidogenesis, and methanogenesis processes and finally reduced methane production from traditional sludge anaerobic digestion by 19.1%. Molecular docking revealed the potential inactivation of binding of TCC to key enzymes in these processes. However, MEC-AD with 0.6 and 0.8 V external voltages achieved much higher methane production and controlled the TCC inhibition to less than 5.8%. TCC in the MEC-AD systems was adsorbed by humic substances and degraded to dichlorocarbanilide, leading to a certain detoxification effect. Methanogenic activities were increased in MEC-AD systems, accompanied by complete VFA consumption. Moreover, the applied voltage promoted cell apoptosis and sludge disintegration to release biodegradable organics. Metagenomic analysis revealed that the applied voltage increased the resistance of electrode biofilms to TCC by enriching functional microorganisms (syntrophic VFA-oxidizing and electroactive bacteria and hydrogenotrophic methanogens), acidification and methanogenesis pathways, multidrug efflux pumps, and SOS response.

Leaching hazards of tire wear particles in hydrothermal treatment of sludge: Exploring molecular composition, transformation mechanism, and ecological effects of tire wear particle-derived compounds

Tire wear particles (TWPs) are considered a significant contributor of microplastics (MPs) in the sludge during heavy rainfall events. Numerous studies have shown that hydrothermal treatment (HT) of sludge can accelerate the leaching of MP-derived compound into hydrothermal liquid, thus impairing the performance of subsequent anaerobic digestion and the quality of the hydrothermal liquid fertilizer. However, the leaching behavior of TWPs in the HT of sludge remains inadequately explored. This study examined the molecular composition of TWP-derived compounds and transformation pathways of representative tire-related additives under different hydrothermal temperatures using liquid chromatography-tandem mass spectrometry (LC-MS/MS) combined with mass difference analysis. The acute toxicity and phytotoxicity of TWP leachates were assessed using Vibrio qinghaiensis Q67 and rice hydroponics experiments. The results indicated that elevating the hydrothermal temperature not only amplified the leaching behavior of TWPs but also enhanced the chemical complexity of the TWP leachate. Utilizing both suspect and non-target screenings, a total of 144 compounds were identified as additives, including N-(1,3-dimethylbutyl)-N’-phenyl-p-phenylenediamine (6-PDD), hexa(methoxymethyl)melamine (HMMM), dibutyl phthalate (DBP). These additives underwent various reactions, such as desaturation, acetylation, and other reactions, leading to the formation of different transformation products (TPs). Moreover, certain additives, including caprolactam and 2,2,6,6-tetramethyl-4-piperidinol, demonstrated the potential to form conjugate products with amino acids or Maillard products. Meanwhile, TWP-derived compounds showed significant acute toxicity and detrimental effects on plant growth. This study systematically investigated the environmental fate of TWPs and their derived compounds during the HT of sludge, offering novel insights into the intricate interactions between the micropollutants and dissolved organic matter (DOM) in sludge.

Influence of toilet flushing water when using an on-site faecal sludge treatment combining electrocoagulation-flotation and anaerobic digestion

Addressing the need for sustainable sanitation in public transport and tourism, this study evaluates electrocoagulation-flotation (ECF) combined with anaerobic digestion (AD) for treating synthetic human faecal sludge (FS). Especially the effects of influent aeration and the use of either rainwater or tap water for flushing on the efficiency of pollutant removal and methane production were investigated. In detail, flushing with rainwater combined with influent aeration resulted in the highest removal efficiency of total COD (tCOD), non-soluble COD (nsCOD), total nitrogen (TN), and total phosphate (TP) of 55 %, 27 %, 22 %, and 75 %, respectively, during ECF treatment, compared to 48 %, 15 %, 14 %, and 63 %, respectively, when tap water was used. As such, post-treatment is mainly necessary for the removal of TN. Combining flushing with rainwater and influent aeration also resulted in the highest faradeic efficiency (107 %) and the most insoluble iron coagulant formation. In contrast, the application of influent aeration during ECF of FS produced using rainwater flushing led to a decrease in methane production from 354 mL/g VS (when no aeration is applied) to 281 mL/g VS during subsequent AD. In conclusion, this study demonstrates that ECF can be applied as a good pre-treatment for sanitation water due to the high nsCOD and TP removal, by which ECF could replace, e.g., a septic tank. Furthermore, the potential of combining ECF with AD is demonstrated in view of energy recovery.

Temperature-phased anaerobic sludge digestion effectively removes antibiotic resistance genes in a full-scale wastewater treatment plant

Sludge is a major by-product and the final reservoir of antibiotic resistance genes (ARGs) in wastewater treatment plants (WWTPs). Temperature-phased anaerobic digestion (TPAD), consisting of thermophilic anaerobic digestion (AD) (55 °C) and mesophilic AD processes (37 °C), has been implemented in WWTPs for sludge reduction while improving the biomethane production. However, the impact of TPAD on the ARGs' fate is still undiscovered in lab-scale experiments and full-scale WWTPs. This study, for the first time, investigated the fate of ARGs during the TPAD process across three seasons in a full-size WWTP. Ten typical ARGs and one integrase gene of class 1 integron (intI1) involving ARGs horizontal gene transfer were examined in sludge before and after each step of the TPAD process. TPAD reduced aac(6′)-Ib-cr, blaTEM, drfA1, sul1, sul2, ermb, mefA, tetA, tetB and tetX by 87.3–100.0 %. TPAD reduced the overall average absolute abundance of targeted ARGs and intI1 by 92.39 % and 92.50 %, respectively. The abundance of targeted ARGs in sludge was higher in winter than in summer and autumn before and after TPAD. During the TPAD processes, thermophilic AD played a major role in the removal of ARGs, contributing to >60 % removal of ARGs, while the subsequent mesophilic AD contributed to a further 31 % removal of ARGs. The microbial community analysis revealed that thermophilic AD reduced the absolute abundance of ARGs hosts, antibiotic resistant bacteria. In addition, thermophilic AD reduced the abundance of the intI1, while the intI1 did not reproduce during the mesophilic AD, also contributing to a decline in the absolute abundance of ARGs in TPAD. This study demonstrates that TPAD can effectively reduce the abundance of ARGs in sludge, which will suppress the transmission of ARGs from sludge into the natural environment and deliver environmental and health benefits to our society.

Enhancement of Anaerobic Digestion of Corn Straw: Effect of Biological Pretreatment and Heating with Bio-Heat Recovery from Pretreatment

Biological pretreatment can promote the degradation of biomass and enhance methane production via the subsequent anaerobic digestion. In addition, a large amount of bio-heat can be generated during the pretreatment process to provide heat for the anaerobic digestion process. In this study, composite microorganisms were employed for pretreating corn straw. The impact of different pretreatment times and the heat generated by the pretreatment process on subsequent anaerobic digestion were studied. The results show that the maximum temperature of the pretreatment process was 56.2 °C, obtained on day 6. After 14 days of pretreatment, the degradation rate of the pretreatment group increased by 41% compared with the control group. As a consequence, straws with different pretreatment times were used for anaerobic digestion. The group that underwent 6 days of pretreatment and utilized bio-heat generated from pretreatment achieved the highest cumulative methane production of 401.58 mL/g VS, which was 60.13% higher than in the control group without pretreatment. After 6 days of composite microorganism pretreatment, the group that utilized bio-heat achieved a 29.08% increase in cumulative methane production compared to the group that did not utilize bio-heat. In conclusion, this study highlights the potential of biological pretreatment with composite microorganisms followed by anaerobic digestion using bio-heat as an effective method for treating corn straw.

Enhancing anaerobic digestion performance of oxytetracycline-laden wastewater through micro-nano bubble ozonation pretreatment

This study investigated the potential of micro-nano bubble (MNB) ozonation pretreatment to eliminate oxytetracycline (OTC) from wastewater and improve subsequent anaerobic digestion (AD) performance. The findings revealed that MNB ozonation achieved efficient OTC oxidation (>99 % in 60 min), and significantly enhanced methane production by 51 % compared to conventional ozonation (under 30 min of pretreatment). Additionally, MNB ozonation resulted in a decrease in the soluble chemical oxygen demand and reduced volatile fatty acid accumulation compared to conventional ozonation. Furthermore, the study sheds light on the profound impact of OTC and its oxidation by-products on the sludge microbiome. Exposure to OTC and its oxidation by-products resulted in alterations in extracellular polymeric substances composition and led to significant shifts in microbial community structure. This study highlights the promise of MNB ozonation as an effective approach for pharmaceutical pollutant removal and the optimization of AD performance in wastewater treatment, with implications for improved environmental sustainability.

The fate of antibiotic resistance genes during anaerobic digestion of sewage sludge with ultrasonic pretreatment.

This study investigated the effect of ultrasonic (US) pretreatment at three different contact times (30, 45, and 60 min) with a power of 240 W and frequency of 40 kHz on the fate of antibiotic resistance genes (ARGs), mobile genetic elements (MGEs), and enteric pathogens during anaerobic digestion (AD) of sludge. By using real time-qPCR, three MGEs (int1, int2, and tnpA) and seven ARGs (sul1, sul2, tetW, tetA, tetO, ermF, and aac(6')-lb) were quantified that have serious human health impacts and represent the most widely used antibiotics (tetracycline, sulfonamide, macrolide, and aminoglycoside). Results indicated that US pretreatment under different contact times improved the removal of ARGs and MGEs. Compared to 30 and 45 min of US pretreatment, 60 min of US pretreatment resulted in a higher reduction of ARGs with total ARG reduction of 41.70 ± 1.13%. Furthermore, the relative abundance of ARGs and MGEs after US pretreatment was reduced more effectively in anaerobic reactors than in a control AD without US pretreatment. The total ARGs and MGEs removal efficiency of control AD was 44.07 ± 0.72% and 63.69 ± 1.43%, and if US pretreatment at different times were applied, the total ARGs and MGEs removal efficiency of the whole pretreatment AD process improved to 59.71 ± 2.76-68.54 ± 1.58% and 69.82 ± 2.15-76.84 ± 0.22%. The highest removal of total ARGs (68.54 ± 1.58%) and MGEs (76.84 ± 0.22%) was achieved after AD with US pretreatment at 45 min. However, US pretreatment and AD with US pretreatment were not effective in inactivation of enteric pathogens (total coliforms and E. coli), suggesting that posttreatment is needed prior to land application of sludge to reduce the level of enteric pathogens. There was no detection of the studied ARGs and MGEs in the enteric pathogens after US pretreatment in subsequent AD. According to this study, long contact times of US pretreatment can mitigate ARGs and MGEs in AD processes, offering valuable insight into improving environmental safety and sustainable waste management. Additionally, the study highlights the need to investigate posttreatment techniques for reducing enteric pathogens in AD effluent, a crucial consideration for agricultural use and environmental protection.

Cold isostatic pressing-study on methane production and microbial communities in anaerobic digestion of wheat straw with high-solids

In this study, the effect of cold isostatic pressing (CIP) pretreatment on the physicochemical properties and subsequent anaerobic digestion (AD) performance of wheat straw (WS) was explored, which did not have additional chemical reagent over the whole process. The WS was subjected to CIP pretreatment by pressures from 350 to 700 MPa, respectively, while AD was carried out at mesophilic temperature with total solids (TS) 7% and 14%. The mapping indicated that the CIP pretreatment promoted the hydrolysis of WS by destroying the dense structure. The CIP pretreatment changed pH and volatile fatty acids (VFAs) in the AD system. Compared with the control group, the cumulative methane production of CIP pretreatment group with TS 14% increased by 22.07%–56.18%. The acetic acid concentration peaked on 4th day and 14th day with 3943.23 mg/L and 3815.21 mg/L, respectively, in H600, and propionic acid concentration also reached two peaks at the same time with 2014.92 mg/L and 2405.20 mg/L, respectively. It was also observed that the CIP pretreatment maintained the pH in the range of 6.44–7.40, maintaining the stability of the overall system. It was also found that CIP pretreatment increased 9 species of hydrolysis and acidogenic bacteria, and methanogen Methanosarcina, thereby facilitating the hydrolysis and methanogenic stages. Predictive functional profiling comfirmed that CIP pretreatment could promote glycolysis/gluconeogenesis, fatty acid metabolism, and fatty acid degradation, whose relative abundance increased from 1.10% to 1.13%, 0.60%–0.62%, and 0.19%–0.23%. Methanogenic capacity of the system was improved because of CIP pretreatment enhancing the accessibility of microorganisms by disrupting the microstructure of WS. The energy conversion analysis showed that this method without chemical reagent addition is feasible for high-solids anaerobic digestion.

Evaluation and optimization of hydrothermal carbonization condition for hydrochar and methane yield from anaerobic digestion of organic fraction of municipal solid waste (OFMSW)

Effectively converting and utilizing the organic fraction of municipal solid waste is a critical strategy to combat environmental pollution and optimize resource utilization. Responsible handling of waste by-products in an environmentally sustainable manner is essential. The utilization of hydrothermal carbonization and anaerobic digestion are rising as progressive, environmentally sustainable technologies for handling the organic component of municipal solid waste, with the added benefit of energy recuperation. Given distinct experimental objectives, comprehensively investigating the optimal conditions for both hydrothermal carbonization and anaerobic digestion experiments with hydrochar feed poses significant challenges. As a result, this study centers its attention on the hydrochars generated through the hydrothermal carbonization process and their impact on the anaerobic digestion of the organic fraction of municipal solid waste. In the first, the relationship between proximate analysis, ultimate analysis, fuel properties, fiber composition, and methane yield of hydrochars at different conditions (150 ≤ temperature ≤ 230 °C, 20 ≤ retention time ≤ 60 min, and 0.15 ≤ biomass loading ≤ 0.35 g/ml) was evaluated. The content of carbon and hydrogen was increased while the content of oxygen decreased. The hydrothermal carbonization process resulted in an increase in the carbon and hydrogen content, accompanied by a decrease in oxygen content. Moreover, alterations in temperature and retention time during the hydrothermal pretreatment led to variations in the contents of cellulose, hemicellulose, and lignin in the hydrochars. Upon subjecting the hydrochars to anaerobic digestion, the methane yield exhibited a wide range, varying from −51.3 to 61.69% in comparison to the control sample. These outcomes emphasize the significant influence of hydrothermal carbonization conditions on the subsequent anaerobic digestion process, yielding a diverse spectrum of methane production levels. Subsequently, the Response Surface Method, a statistical methodology, was employed to investigate the influence of three parameters. Through this approach, optimal conditions were determined to achieve the maximum hydrochar yield (HC150-20-0.35) at 68.6%, the maximum methane yield (HC168.52-39.47-0.19) at 251.38 ml/g VS, and the simultaneous maximization of hydrochar yield and methane yield (HC159.9-28.75-0.23) at 63.1% and 237.68 ml/g VS, respectively. Finally, the structural and morphological properties of the optimized hydrochars were subjected to thorough analysis.

The lesser of two evils: Enhancing biodegradable bioplastics use to fight plastic pollution requires policy makers interventions in Europe

Plastic pollution is a ubiquitous and universally recognized environmental threat, and bioplastics have emerged as a potential solution to this issue in the last years. Being biobased and biodegradable, bioplastics have a reduced carbon footprint with respect to plastics, and they are not expected to accumulate and fragmentate in the environments as plastics do. Nevertheless, some bioplastics drawbacks such as their slow biodegradation in engineered (i.e., anaerobic digestion and composting) and natural (i.e., soil and water) environments have been used by sceptics to discredit bioplastics, and this have induced policy makers to use a precautionary approach to the topic (i.e., including bioplastics in the ban of single use products and in the count of inert materials in organic fertilizers).Using a simplified ecologic risk assessment analysis, this Opinion paper aimed to show that bioplastics that are proven to be intrinsically biodegradable are always a better choice than plastics. Having a residence time in natural environments of about 1–10 years, the likelihood of bioplastics causing harmful effects on living organisms is about 100–1000 times lower than plastics that resides thousands of years in the environments. Taking this into consideration, policy makers are asked to revise recent regulations and directives to enhance bioplastics diffusion and fight plastic pollution. In this sense, Single Use Plastic Directive 2019/904 may exclude biodegradable bioplastic items from the ban, and European Regulation on Fertilizers 2019/1009 may exclude biodegradable bioplastics residues from the count of inert materials in organic fertilizers. Bioplastics collection within biowastes and subsequent anaerobic digestion should be also favoured, in order to force controlled bioplastics biodegradation into biogas and reduce their leakage into the environment, resulting in the enhanced circularity of bioplastics products.

Green and chemical-free pretreatment of corn straw using cold isostatic pressure for methane production

In this study, the effect of cold isostatic pressure (CIP) pretreatment on the physicochemical properties and subsequent anaerobic digestion (AD) performance of corn straw (CS) was explored. The CS was subjected to CIP pretreatment by pressures of 200, 400 and 600 MPa, respectively, while AD was carried out at medium temperature (35 ± 2 °C). The results showed that CIP pretreatment disrupted the dense structure of the CS and altered the crystallinity index and surface hydrophobicity of the CS, thereby affecting the AD process. The presence of CIP pretreatment increased the initial reducing sugar concentration by 0.11–0.27 g/L and increased the maximum volatile fatty acids content by 112.82–436.64 mg/L, which facilitated the process of acidification and hydrolysis of the AD. It was also observed that the CIP pretreatment maintained the pH in the range of 6.37–7.30, maintaining the stability of the overall system. Moreover, the cumulative methane production in the CIP pretreatment group increased by 27.17 %–64.90 % compared to the control group. Analysis of the microbial results showed that CIP pretreatment increased the abundance of cellulose degrading bacteria Ruminofilibacter from 21.50 % to 27.53 % and acetoclastic methanogen Methanosaeta from 45.48 % to 56.92 %, thus facilitating the hydrolysis and methanogenic stages. The energy conversion analysis showed that CIP is a green and non-polluting pretreatment strategy for the efficient AD of CS to methane.

The migration regularity and removal mechanism of antibiotic resistance genes during in situ enzymatic hydrolysis and anaerobic digestion of food waste

This study developed a high efficiency compound enzyme (fungal mash) produced in situ from food waste (FW) used for improving hydrolysis and anaerobic digestion (AD) efficiency of FW. Results showed that the soluble COD and methane yield were respectively increased by 67.80% and 16.58% after 24 h in situ enzymatic hydrolysis of food waste by fungal mash. Furthermore, most of target ARGs in FW were also reduced by 45–94% after 24 h in situ enzymatic hydrolysis, while the total tested ARGs and intI1 were respectively further removed by 44–55% and 21–73% in subsequent AD process. In-depth analysis showed that fungal mash could effectively reduce potential hosts and control the horizontal transfer of ARGs during the in situ enzymatic hydrolysis and AD process. Ultimately, correlation analysis and redundancy analysis indicated that the evolution of bacterial communities and changes in intI1 where the common driving forces for the fate of ARGs.

Accumulating ammoniacal nitrogen instead of melanoidins determines the anaerobic digestibility of thermally hydrolyzed waste activated sludge

Full-scale thermal hydrolysis processes (THP) showed an increase in nutrients release and formation of melanoidins, which are considered to negatively impact methanogenesis during mesophilic anaerobic digestion (AD). In this research, fractionation of THP-sludge was performed to elucidate the distribution of nutrients and the formed melanoidins over the liquid and solid sludge matrix. Degradation of the different fractions in subsequent AD was assessed, and the results were compared with non-pre-treated waste activated sludge (WAS). Results showed that the THP-formed soluble melanoidins were partially biodegradable under AD, especially the fraction with molecular weight under 1.1 kDa, which was related to protein-like substances. The use of THP in WAS increased the non-biodegradable soluble chemical oxygen demand (sCOD) after AD, from 1.1% to 4.9% of the total COD. The total ammoniacal nitrogen (TAN) concentration only slightly increased during THP without AD. However, after AD, TAN released was 34% higher in the THP-treated WAS compared to non-treated WAS, i.e., 36.7 ± 0.7 compared to 27.4 ± 0.4 mgTANreleased/gCODsubstrate, respectively. Results from modified specific methanogenic activities (mSMAs) tests showed that the organics solubilised during THP, were not inhibitory for acetotrophic methanogens. However, after AD of THP-treated sludge and WAS, the mSMA showed that all analysed samples presented strong inhibition on methanogenesis due to the presence of TAN and associated free ammonia nitrogen (FAN). In specific methanogenic activities (SMAs) tests with incremental concentration of TAN/FAN and melanoidins, TAN/FAN induced strong inhibition on methanogens, halving the SMA at around 2.5 gTAN/L and 100 mgFAN/L. Conversely, melanoidins did not show inhibition on the methanogens. Our present results revealed that when applying THP-AD in full-scale, the increase in TAN/FAN remarkably had a greater impact on AD than the formation of melanoidins.

Ultrasonication as anaerobic digestion pretreatment to improve sewage sludge methane production: Performance and microbial characterization

A large amount of sludge is inevitably produced during sewage treatment. Ultrasonication (US) as anaerobic digestion (AD) pretreatment was implemented on different sludges and its effects on batch and semi-continuous AD performance were investigated. US was effective in sludge SCOD increase, size decrease, and CH4 production in the subsequent AD, and these effects were enhanced with an elevated specific energy input. As indicated by semi-continuous AD experiments, the mean daily CH4 production of US-pretreated A2O-, A2O-MBR-, and AO-AO-sludge were 176.9, 119.8, and 141.7 NmL/g-VSadded, which were 35.1%, 32.1% and 78.2% higher than methane production of their respective raw sludge. The US of A2O-sludge achieved preferable US effects and CH4 production due to its high organic content and weak sludge structure stability. In response to US-pretreated sludge, a more diverse microbial community was observed in AD. The US-AD system showed negative net energy; however, it exhibited other positive effects, e.g., lower required sludge retention time and less residual total solids for disposal. US is a feasible option prior to AD to improve anaerobic bioconversion and CH4 yield although further studies are necessary to advance it in practice.

Effects of thermal and enzymatic pre-treatments on the solubilisation of extracellular polymeric substances (EPS) and subsequent anaerobic digestion of microalgae-bacterial biomass

Microalgae-bacteria biomass was digested through anaerobic digestion (AD) to produce biogas. Since microalgae typically have a more resistant cell wall than activated sludge (AS), its anaerobic biodegradability is limited. Therefore, three different pre-treatment techniques were evaluated for their effect on anaerobic biodegradability, especially of the extracellular polymeric substances (EPS). Firstly, heat at 70 °C for 1.5 h. Secondly, exposure to a mixture of commercially available enzymes (cellulase, α-amylase and protease), and thirdly, adding crude hydrolytic enzymes extracted by ultrasonication from a highly loaded anaerobic digestion cascade reactor. The first and third treatments had better effects than enzymatic pre-treatment with commercial enzymes, improving anaerobic biodegradability, the solubilisation of organic matter and increasing the methane production rate by 78 and 21 %, respectively. The EPS content of microalgae-bacteria biomass was considerably lower than reported for WAS, and about 40–50 % of the EPS consisted of proteins and polysaccharides. The hydrolysis of proteins and polysaccharides was quantified, and its effect on AD was discussed. A COD balance showed that the increase of soluble COD is due to the conversion of tightly bound EPS into loosely bound and soluble EPS but also due to the release of organic matter from cellular material. Although all pre-treatments increased the soluble organic fractions, especially those corresponding to EPS, none significantly improved the overall methane yield. Nevertheless, the methane production rate increased after thermal and pre-treatment with hydrolytic enzymes, which could result in smaller and more efficient anaerobic reactors.

Chemical Pretreatments and Anaerobic Digestion Shape the Virome and Functional Microbiome in Fecal Sludge.

The decomposition and pathogen inactivation of fecal sludge (FS) are vitally important for safely managing onsite sanitation and protecting public and environmental health. However, the microbiome and virome assemblages in FS after chemical and biological treatments remain unclear. Here, we reported the differences in the solid reduction and microbiomes of FS subjected to potassium ferrate (PF), alkali (ALK), and sodium hypochlorite (NaClO) pretreatments and anaerobic digestion (AD). The PF and NaClO pretreatments enhanced FS hydrolysis and pathogen suppression, respectively; AD suppressed Gram-positive bacteria. Most of the viromes were those of bacteriophages, which were also shaped by chemical pretreatments and AD. Metatranscriptome analysis revealed distinct gene expression patterns between the PF- and ALK-pretreated FS and the subsequent AD. Differentially expressed gene profiles indicated that genes related to biological processes, molecular functions, and transcriptional regulators were upregulated in ALK-AD and PF-AD samples. These findings suggested that the effect of different treatment technologies on the viral diversity, pathogen abundance, and metabolic function of the core microbiome extends beyond FS decomposition and that the use of combined processes would provide possible alternatives for FS management in pandemic emergencies.

Life cycle assessment of a novel strategy based on hydrothermal carbonization for nutrient and energy recovery from food waste

In this work, a novel strategy for food waste valorization was evaluated from an environmental life-cycle perspective. A system based on acid-assisted hydrothermal carbonization of food waste combined with the exploitation of hydrochar by combustion and process water through nutrient recovery stage and subsequent anaerobic digestion, was assessed and compared with stand-alone anaerobic digestion as the reference system. This combination of processes aims to recover both nutrients in a stage of struvite precipitation from process water and energy through hydrochar and biogas combustion. Both systems were modeled in Aspen Plus® to identify and quantify their most relevant input and output flows and subsequently evaluate their environmental performance through the life cycle assessment methodology. The novel combined system was found to generally involve a more favorable environmental performance than the reference stand-alone configuration, which would be closely linked to the substitution of hydrochar for fossil fuels. In addition, the impacts associated with soil application of the struvite produced in the integrated process would also be reduced compared to the use of the digestate generated in the stand-alone anaerobic digestion process. Following these results and the evolving regulatory framework for biomass waste management, mainly in the field of nutrient recovery, combined process based on acid-assisted hydrothermal treatment plus nutrient recovery stage and anaerobic digestion is concluded to be a promising circular economy concept for food waste valorization.

Enhancement of the ligninolytic activity of Lysinibacillus sphaericus by the addition of MnSO4 and its impact on subsequent methane production from Oil Palm Empty Fruit Bunches (OPEFB)

Palm empty fruit bunches (OPEFB) is a recalcitrant agricultural waste not readily digested which is produced in abundance. The recently isolated bacteria, Lysinibacillus sphaericus is a facultative anaerobe which can digest lignin. The objective of this study was to determine if the addition of L. sphaericus and MnSO4 could aid the bioconversion of OPEFB, and if this could enhance methane production during subsequent anaerobic digestion (AD). The untreated OPEFB had a specific methane potential of 0.099 L/g VS which was doubled following pre-treatment with L. sphaericus. In the presence of 0.25 mM MnSO4 a further 1.5-fold increase in methane production was observed. This illustrates for the first time how the addition of inducers (MnSO4) can significantly enhance this bacteria's ability to degrade lignocellulose through enhancement of its lignin degrading enzymes. Thus, enabling this agricultural waste to be utilised more effectively for biogas production.

Exploration of browning reactions during alkaline thermal hydrolysis of sludge: Maillard reaction, caramelization and humic acid desorption

The browning reaction produces melanoidins, 5-hydroxymethylfurfural (HMF) and humic acids which influence subsequent anaerobic digestion and protein recovery. This paper systematically evaluates the variation of organics that make sludge browning with heating temperature and reaction time, the effect of browning organics on protein recovery and anaerobic digestion, and finally proposes a pathway for the occurrence of the Maillard reaction (MR) in the sludge environment. The results show that the browning of sludge hydrolysate is related to the comprehensive influence of the MR, caramelization and humic acid desorption. The increase of temperature (80 °C–150 °C) and pH (9–13) will promote the extent of browning of sludge hydrolysate, and the sludge browning reaction basically stabilizes at the reaction time of 1 h. Humic acid and melanoidin could co-precipitate with the protein, thereby reducing the purity of the recovered protein. The inhibition of anaerobic digestion starts when the melanoidin concentration is 8.01 mmol/L. The three-dimensional fluorescence, GC-MS and FT-IR analysis show that melanoidins have the same functional groups and fluorescence properties as humic acid does, and the humic acid in the supernatant of the sludge treated with ATH was not only converted at its adsorbed state, but also possibly generated by the reaction of the dissolved proteins with polysaccharides. Finally, LC-MS/MS was used to identify the intermediate products of the MR and the possible structural formula of melanoidin. This study further clarifies the browning reaction in hydrothermal sludge treatment and provides help for the accuracy of subsequent studies.