Fat Milk Replacer Research Articles

Application of starter cultures on milk and milk-containing mixtures

Milk-containing products occupy a large place in the range of popular products. Replacing milk fat or protein with vegetable fat can reduce the biological value of the product and its organoleptic properties. the effect of direct application starter cultures on raw materials that use functionally necessary ingredients (structure-forming agents, salt, sugar, etc.), food additives (thickeners, stabilizers, preservatives, etc.) and a variety of non-dairy components (non-dairy fats, non-dairy proteins, meat products, fruits, vegetables, spices, herbs, nuts, etc.) is ambiguous. The paper deals with the use of homogeneous and combined starter cultures in the production of fermented milk products from natural and normalized milk and milk-containing mixtures with a substitute for milk fat. The introduction of components of plant origin into the product leads to a decrease in the content of milk protein in the mixtures, which in turn leads to the formation of clots with a non-uniform consistency. Slow acid formation in milk-containing mixtures indicates a decrease in milk sugar in them with this type of normalization in fat, relative to the normalized milk according to the classical technology. This pattern was revealed both when using starter cultures on lactic acid thermophilic streptococci, and on combined starter cultures. In this paper, it is proposed to use Streptococcus salivarius subsp in ferments for milk-containing mixtures. thermophilus strain ST-95. The introduction of the ST-95 strain into the starter culture made it possible to obtain from the milk-containing mixture a fermented milk product with well-pronounced organoleptic properties, a stable clot structure and sufficiently high taste properties. The greatest positive effect was obtained on combined ferments.

The Effect of Replacing Milk Fat with Vegetable Oils on Labneh Content of Omega-3, Omega-6 and Omega-9

The Effect of Replacing Milk Fat with Vegetable Oils on Labneh Content of Omega-3, Omega-6 and Omega-9

Effect of fat replacement with modified starch on composition and quality of cream cheese

This study aims to produce low-calorie cream cheese (CC) to reduce the problems caused by high-fat cream cheese for some consumers by replacing milk fat with modified starch. Milk fat (MF) of buffalo’s milk was partially or fully (0.0, 25, 50, 75 and 100%) replaced by modified starch for making single cream cheese (SCC) or double cream cheese (DCC) aiming to produce low-calorie CC. The cheese samples were analyzed when fresh and after ten days of cold storage. Moisture gradually increased with increasing percentage of replacement and decreased with storage. Replacement of MF decreased protein and increased carbohydrate contents in general, while acidity increased gradually and pH decreased with increasing percentage of replacement and with storage. Energy content was significantly decreased by more replacement of MF and increased by advancing storage. Spreadability of DCC showed the same trend of energy results. Replacement of MF up to 50% improved the organoleptic properties while the full replacement adversely affected the organoleptic properties of CC.

How does milk fat replacement influence cheese analogue microstructure, rheology, and textureprofile?

Over the past few years, the market for cheese substitutes has been growing on account of the simple and cost-effective production of these cheese-like products. It is well established that the functional properties of cheeses are directly related to their composition. Therefore, the variation of fat in cheese substitutes certainly affects the characteristics of the cheeses. The purpose of this review was to summarize the latest research on the effects of milk fat replacement with vegetable oils on the rheological, textural, and microstructural properties of cheese analogues. The findings suggest that the primary effects of modifying fat in cheese analogues are associated with an alteration in the interactions among the components of the protein matrix, which varies because of milk fat extraction. Overall, changes in the functional properties of analogous cheeses will depend on the type of oil, the percentage of fat modification, and the type of cheese produced.

Effects of milk replacer feeding rate and fat content on Jersey calf nutrient digestion and performance to 4 months of age

This study evaluated effects of milk replacer (MR) feeding rate and fat concentration in MR on total-tract digestion (TTD) and growth performance in Jersey calves. Jersey heifer calves (n = 100, 2 blocks of 50; initially 30 ± 3.0 kg of body weight; 4-11 d of age) were randomly assigned to 1 of 4 treatments in a 2 × 2 factorial arrangement of MR feeding rate [454 g for 42 d, and 227 g for 7 d (MOD); or 454 g for 7 d, 681 g for 35 d, and 341 g for 7 d (HI), as-fed basis] and MR fat content (17 or 24% fat as-fed basis). Milk replacers (24% crude protein as-fed basis) were reconstituted to 14% solids and fed in 2 equal feedings for 42 d, and then mornings only for 7 d. Textured calf starter (21% crude protein, 40% starch, dry matter basis) and water were offered for ad libitum consumption. From d 57 to 112, calf starter was mixed with 5% chopped grass hay. Calves were housed individually to d 56 and housed in groups (4-5 calves/pen) from d 57 to 112. Estimates of TTD were measured in 5 calves/treatment (block 1) at wk 3 of the study using acid-insoluble ash as an indigestible marker. From 0 to 56 d, calf starter intake (CSI) was greater for MOD vs. HI and 17 versus 24% fat; average daily gain was greater for HI versus MOD; and hip width change was greater for 17 versus 24% fat. Estimates of organic matter TTD were greater for HI versus MOD, but neutral detergent fiber TTD was greater for MOD versus HI and for 17 versus 24% fat. From 57 to 112 d, hip height change was greater for MOD versus HI, and hip width change was greater for 17 versus 24% fat. In this study, feeding Jersey calves more MR improved preweaning average daily gain, but had a negative effect on CSI and likely rumen development, as neutral detergent fiber TTD was reduced at 3 wk and frame growth was reduced from d 57 to 112. This resulted in similar final calf body weights between MR feeding rates at the end of the study. No benefits were observed for feeding more fat in MR as CSI or for NDF digestibility, and frame growth was reduced.

Effect of partial exchange of lactose with fat in milk replacer on ad libitum feed intake and performance in dairy calves

Compared with Holstein whole milk, commercial milk replacers (MR) for calves deliver relatively high levels of lactose and low levels of fat, and protein levels are rather comparable, resulting in a lower energy density and energy-to-protein ratio of the diet. Thus, the objective of this study was to determine the effects of partially exchanging lactose with fat in MR on voluntary feed intake, growth performance, and feeding behavior. Thirty-two male Holstein calves (2.1 ± 0.16 d of age, 46.4 ± 0.77 kg of body weight; BW) were assigned to 16 blocks of 2 calves per block based on arrival date and serum IgG. Within each block, calves were randomly assigned to 2 treatments: a high-lactose MR (HL; 17% fat; 44% lactose), or a high-fat MR (HF; 23% fat; 37% lactose). Lactose was exchanged by fat on a weight per weight basis, resulting in a 6% difference in metabolizable energy density per kilogram of MR. The experiment was divided into 3 phases: preweaning (P1; 0-35 d), weaning (P2; 36-56 d), and postweaning (P3; 57-84 d). For the first 2 wk of P1, calves were individually housed, fed their respective MR ad libitum through teat buckets, and provided access to water. At 14.2 ± 0.5 d of age, calves were group-housed (4 blocks/pen, 8 calves) and housed in group pens for the remainder of the study. In the group pens, calves were fed ad libitum MR, starter feed, chopped wheat straw, and water via automated feeders. During P2, calves were gradually weaned until complete milk withdrawal by 57 d and then monitored until 84 d (P3). Measurements included daily intakes and feeding behavior (rewarded and unrewarded visits), weekly BW and body measurements, and biweekly blood samples. Increasing fat content at the expense of lactose decreased MR intake during P1 by 15% (HL = 1.32 ± 0.04; HF = 1.17 ± 0.04 kg of dry matter per day), whereas total starter intake was not affected by MR composition. Once MR was restricted during P2, HL calves were reported to have more unrewarded visits to the automatic milk feeder than HF calves (11.9 ± 0.95 vs. 8.4 ± 1.03 visits/d, respectively). Crude protein intake was higher for HL calves during P1 (352.1 ± 11.2 vs. 319.6 ± 11.6 g/d), which was attributed to the higher intake of MR during that period, and metabolizable energy intake and protein-to-energy ratio remained comparable between treatments. Plasma cholesterol and nonesterified fatty acids levels were higher in HF calves as a consequence of the diet. Nevertheless, final BW (84 d) did not differ between treatments. Overall, calves fed ad libitum seemed to regulate their intake of MR based on its energy density, without significant effects on solid feed intake and overall growth.

The Production of Functional White- Brined Cheese by the Replacement of Milk Fat with Grape Seed Oil

The Production of Functional White- Brined Cheese by the Replacement of Milk Fat with Grape Seed Oil Abstract: Background and objectives: Cheese is one of the valuable dairy products which are consumed a lot in Iran and in the world. Due to increasing fat-related diseases such as cardiovascular disease and obesity, replacement of cheese with oils containing functional fatty acids and less saturated fatty acids have been seriously taken into consideration in recent years. The aim of this study was the partial replacement of milk fat with grape seed oil which contains essential and unsaturated fatty acids for the production of a functional cheese. Materials and methods: Fresh milk was prepared from Maku farms and after separation of milk fat, it was standardized by grape seed oil, Olitalia trademark, and cream with the ratios of 25:75, 50:50 and 75:25. Then, Cheese samples were produced according to general industrial method. A control cheese sample was produced from whole milk. Physical and chemical properties of cheese samples including pH, acidity, fat, salt, moisture and sensory characteristics during the 60 days of ripening of cheese were measured according to Iranian National Standard Organization test methods, no. 2852, 1809, 760, and 4938 respectively. Measuring lipolysis index and fatty acid profiles were done through Nunez et al. and gas chromatography method respectively. Results: The results of this research showed that there was no significant difference between pH, acidity, moisture and salt content of samples substituted with grape seed oil and control cheese sample (p <0.05). But the effect of ripening time on mentioned properties was significant. All samples containing grape seed oil had more essential fatty acids, unsaturated fatty acids and less saturated fatty acids compared to the control, the amount of linoleic acid in control sample and samples containing 25%, 50%, 75% of grape seed oil, were 3, 17, 20 and 35 percent and the amount of oleic acid, 22, 26, 27.5 and 29.5 percent, respectively. The results of sensory evaluation of all treatments showed that in the term of texture, control sample cheese had the highest score, but cheese contains 75 percent grape seed oil gained highest score in color, odor and taste. In term of overall acceptability samples that contain 75% grape seed oil had more score compared to other samples. Conclusion: The results of this research showed the feasibility of substitution of cheese fat with grape seed oils for the production of more healthy, nutritional and functional white brined cheese. Key words: White brined cheese, functional, grape seed oil, milk fat

Effects of energy source in milk replacer on glucose metabolism of neonatal dairy calves

Milk replacers (MR) formulated to contain more lactose than whole milk could potentially reduce insulin sensitivity in dairy calves. This study evaluated how partially replacing lactose in MR with fat on a weight/weight basis affects glucose-insulin kinetics in neonatal dairy calves fed high quantities of MR. Thirty-four Holstein bull calves were blocked by dam parity (1.6 ± 0.3) and randomly assigned to 1 of 2 treatments (n = 17): a high-lactose MR (HL; 46.1% lactose, 18.0% crude fat, and 23.9% crude protein on a dry matter basis) or a high fat MR (HF; 39.9% lactose, 24.6% crude fat, and 24.0% crude protein on a dry matter basis). Calves were individually housed and fed pooled colostrum at 1.5 h and 12 h postnatal at 18 and 9% of metabolic body weight (BW0.75), respectively. From 24 h postnatal until the end of the study (d 7), calves were transitioned to MR (prepared at 150 g/L) at 18% of BW0.75 twice daily at 0700 and 1900 h. On d 4, an insulin-modified intravenous glucose tolerance test was conducted 8 h after the morning meal by intravenous infusion of glucose (0.54 g/kg of BW0.75, min 0) and insulin (3.9 µg/kg of BW0.75, min 20). During postprandial sampling on d 6, abomasal emptying was assessed by dosing acetaminophen (0.13 g/kg of BW0.75) with MR and measuring its appearance within plasma. Sequential blood samples were collected and analyzed for plasma glucose, insulin, and acetaminophen concentrations. Calves were killed on d 7 and liver and pancreatic tissues were collected for histomorphological analysis. Partially replacing lactose in MR with fat increased body weight gain (679.6 vs. 462.0 ± 69.68 g/d) and gain:metabolizable energy intake (186.6 vs. 120.5 ± 20.21 g of body weight/Mcal) compared with feeding HL MR. Furthermore, abomasal emptying rate was reduced in calves fed HF MR. Calculated variables based on postprandial glucose and insulin concentrations, such as maximum concentration or area under the curve, were or tended to be lower in HF than in HL calves. Postprandial insulin sensitivity tended to be reduced in HL compared with HF, although insulin sensitivity estimated from the insulin-modified intravenous glucose tolerance test was not different. Calves fed HF MR showed enhanced glucose-stimulated insulin secretion. In conclusion, partially replacing lactose in MR with fat resulted in smaller fluctuations in postprandial glucose and insulin concentrations and tended to increase postprandial but not fasting insulin sensitivity in neonatal dairy calves.

Effect of adding Aloe vera jell on the quality and sensory properties of yogurt.

This study was planned to investigate the effect of replacing milk fat with aloe vera gel addition on yogurt quality. Purposely, yogurt was prepared with different concentration of aloe vera gel and coded as AGY0, = Control (3.5% fat and no AG), AGY1 = (1% fat and 1% AG), AGY2 = (1% fat and 2% AG), AGY3 = (1% fat and 3% AG), AGY4 = (2% fat and 1% AG), AGY5 = (2% fat and 2% AG), and AGY6 = (2% fat and 3% AG). Aloe vera gel yogurt was analyzed for physicochemical, microbial, and sensory characteristics with defined interval (0, 7th, 14th, and 21st) days. All attributes of the yogurt were significantly (0.05) affected by the addition of aloe vera gel. Results showed that the pH (4.6–4.05), viscosity (46.4–4.3), WHC (32.8%–26.1%), fat (0.9%–3.48%), protein (3.14%–3.36%), lactose (4.07%–4.23%), ash (0.48%–0.63%), total solids (11.08%–17.18%), SNF (7.69‐l5.21%), and TPC (2.36 × 107 to 1.02 × 107 CFU/ml) values of yogurt samples decreased with storage time. However, acidity and syneresis of yogurt increased with the passage of time ranging from 1.12%–1.67% and 0.9–5 ml, respectively. In conclusion, aloe vera improved the texture of the yogurt which leads to higher consumer acceptability. Addition of 3% aloe vera to 1% fat (AGY3) containing buffalo milk yogurt was found to best for physicochemical as well as organoleptic characteristics as well as organoleptic characteristics.

Effects of birth weight and dietary fat on intake, body composition, and plasma thyroxine in neonatal lambs.

Intrauterine growth restriction (IUGR) is often observed in one of the fetuses carried by well-fed prolific ewes. This condition is the result of an insufficient placental size to cover the nutritional needs of the fetus during the near exponential growth phase of the last trimester. After birth, these IUGR offspring have an elevated appetite and lower maintenance energy requirements, suggesting dysregulation of homeostatic systems governing energy metabolism. It is also unknown whether the consequent increase in fatness occurs similarly in both visceral and carcass fractions. To address these questions, lambs differing in birth size (BS, IUGR vs. Normal, 2.6 ± 0.05 vs. 4.2 ± 0.07 kg, P < 0.001) were offered unlimited amounts of a low fat [LF; 22% of dry matter (DM)] or a high fat (HF; 38% of DM) milk replacer and slaughtered on day 14 of postnatal age (n = 7 to 8 for each BS × Diet); a second group of IUGR lambs (n = 3 for each diet) was slaughtered when they reached 8.5 kg, corresponding to the weight of Normal lambs on day 14. When normalized to body weight (BW), the DM and energy intake of IUGR lambs were higher than those of Normal lambs over the first 14 d of life (BS, P < 0.01), but contrary to expectations, the HF diet did not exacerbate these effects of the IUGR condition. Intrauterine growth restricted lambs had increased viscera fat with both diets (BS and Diet, P < 0.05) but increased carcass fat only with the LF diet (BS × Diet, P = 0.08); the fatness promoting effect of the IUGR condition was increased in both body fractions when lamb groups were compared at the fixed BW of 8.5 kg. A subset of metabolic hormones was analyzed, including the metabolic rate-setting hormone thyroxine (T4) and its possible positive regulator leptin. Plasma T4 was lower in IUGR than in Normal lambs at birth (P < 0.05) but then disappeared by day 7 of postnatal life (BS × Day, P < 0.01). On the other hand, the HF diet had no effect on plasma T4 over the first 3 d but caused an increase, irrespective of BS by day 11 (Diet × Day, P < 0.001). Plasma leptin increased with dietary fat and time (P < 0.06) but bore no relation to the effects of BS or Diet on plasma T4. These data show that IUGR and Normal lambs are similarly unable to adjust caloric intake in early life and that the fatness promoting effects of the IUGR condition are more pronounced in the viscera than in the carcass. These data also reveal dynamic regulation of plasma T4 by BS and Diet in neonatal lambs.

The effect of milk fat substitution on the rheological properties of Edam-type cheese

In cheese-like products, milk components (in particular fat) are partially or completely replaced with non-dairy substitutes. An attempt was made in this study to determine whether Edam-type cheese can be distinguished from its substitute, where milk fat was replaced with palm oil, based on rheological properties. The rheological properties of Edam cheese and its substitute were analyzed during a 16-week ripening period, based on the results of a stress-relaxation test. The values of the rheological parameters were estimated with the use of the generalized Maxwell model and a non-linear model proposed by the authors, which accounted for the plastic deformation of the analyzed samples. The study revealed that both methods were equally effective in describing the stress relaxation process; therefore, they can be regarded as equivalent. Excluding the initial stage of ripening (which is not important from the consumers’ point of view), the replacement of milk fat with palm oil did not influence the rheological properties of Edam-type cheese and the cheese-like product. In subsequent stages of ripening, no significant differences were found in the rheological properties of both products, which could only be used to evaluate their ripeness.

The effect of partially or totally replacing milk fat by jojoba oil in Domiati cheese production on some nutritional and quality properties

PurposeThe purpose of this study is to evaluate the effects of partial or total substitution of milk fat by various levels of jojoba oil on the nutritional, physicochemical and sensory properties of Domiati cheese during cold storage at 6°C for 45 days.Design/methodology/approachThe fat percentage of milk used for cheese manufacture was standardized to 4% fat. Five formulas were produced by replacing milk fat with 0%, 25%, 50%, 75% and 100% of jojoba oil, respectively. The physicochemical and sensory properties of cheese samples at 0, 15, 30 and 45th days of cold store were evaluated.FindingsNo significant differences in moisture, fat, protein and acidity values amongst the control samples and those samples supplemented with different concentrations of jojoba oil. Significant differences (p = 0.05) in total volatile fatty acids were detected amongst experimental cheese samples. The highest values were recorded for control sample containing 100% milk fat, while the lowest values were recorded for cheese sample containing 100% jojoba oil (p = 0.05). Total nitrogen (TN), water-soluble nitrogen (WSN) and trichloroacetic acid soluble nitrogen (TCA-SN) levels of experimental cheeses were nearly same as for control. The results of fatty acids profile showed that jojoba oil has a unique structure of straight monounsaturated alcohols. Significantly (p = 0.05), the highest cholesterol content was recorded for control sample containing 100% milk fat; however, the lowest (p = 0.05) value was recorded for cheese sample containing 100% jojoba oil. At the end time of storage period, control sample manufactured with 100% milk fat had the highest (p = 0.05) values of free fatty acids, peroxide and thiobarbituric acid, while the lowest values were recorded for cheese sample with 100% jojoba oil as a source of fat. The sensory evaluation results demonstrated that blending milk fat with jojoba oil improved the sensory properties of Domiati cheese.Practical implicationsIt is concluded that substitution of 25%, 50%, 75% and 100% of milk fat by equal amounts of jojoba oil enhanced the nutritional and sensory characteristics of Domiati cheese.Originality/valueIt is concluded that Domiati cheese formulated with substitution of 25%, 50%, 75% and 100% of milk fat by equal amounts of jojoba oil enhanced the nutritional characteristics and improved the sensory properties of produced cheese.

Physicochemical and Sensory Properties of Low-Fat Ice Cream Made with Inulin and Maltodextrin as Fat Replacers. الخواص الفیزیائیة والکیمیائیة والحسیة للمثلجات القشدیة منخفضة الدهن المصنعة من الإنیولین والمالتودکسترین کبدائل للدهن

This study was performed to formulate and evaluate a low-fat, reduced-calories soft serve ice cream using inulin or maltodextrin as a fat replacer. Six batches of ice cream mixes with different fat content (2, 4, and 6%) was prepared by partial replacement of milk fat with either inulin or maltodextrin at levels of 2, 4, and 6% (w/w). A control batch was made with 8% milk fat without adding any fat alternatives. The chemical composition and physicochemical properties of ice cream mixes were determined. A sensory evaluation was also performed on the final products initially and monthly during storage at -18°C for two months. The results indicated that the use of either maltodextrin or inulin as a fat replacer in `low-fat reduced-calorie ice cream formulations can improve the properties of these products. However, the type and level of fat replacer used affects differently on various physical properties such as density and viscosity. It has been also concluded that it was possible to formulate a low-fat, reduced-calorie ice cream with a healthier effect by adding inulin as a healthier fat replacer, alternative to maltodextrin. Good product was obtained with nutritional, technological, and sensory acceptance.

Growth performance of newborn dairy calves fed a milk replacer containing 24% crude protein and 20% fat fed at different feeding rates

ABSTRACT Objective The objective was to evaluate the preweaning (d 1 to 42) and postweaning (d 43 to 56) performance and health of calves fed a 24% CP:20% fat milk replacer (MR) at different feeding rates based on our previous work that calves fed greater feeding rates of MR demonstrated improved growth. Materials and Methods A total of 108 (2- to 5-d-old) Holstein heifer calves (40 ± 0.69 kg) were randomly assigned to 1 of 4 treatments. The same all-milk-protein MR was fed at 14.7% solids, with treatments of (1) control (MR57): MR fed at 0.57 kg daily from d 1 to 35; (2) MR71: MR fed at 0.71 kg daily from d 1 to 35; (3) MR85: MR fed at 0.68 kg daily from d 1 to 7 and at 0.85 kg daily from d 8 to 35; and (4) MR99: MR fed at 0.68 kg daily from d 1 to 7 and at 0.99 kg daily from d 8 to 35. All treatments were fed MR one time per day from d 36 to weaning, after d 42 with water, and an 18% CP texturized calf starter offered free choice. Results and Discussion Preweaning and overall ADG (0.78, 0.82, 0.83, and 0.85 kg/d for MR57, MR71, MR85, and MR99, respectively) were greater (P 0.10) and intermediate. Overall d 1 to 56 calf starter intakes were greater (P 0.10). Preweaning G:F was lowest for calves fed MR57, whereas d 1 to 56 G:F (0.49, 0.52, 0.52, and 0.54 kg/kg of DM) was greater (P Implications and Applications This study demonstrated that higher feeding rate of a 24:20 MR resulted in increased ADG and feed conversion (G:F).

ECONOMIC ACTIVITY OF MILK PROCESSING ENTERPRISES IN FOOD INDUSTRY OF UKRAINE

Introduction. An integral part of a complete human diet, especially in children and the elderly, is the consumption of dairy products that contain essential nutrients in such quantities and forms that are no longer found in any other food - milk protein and fat, lactose, lactic acid bacteria, enzymes, minerals, vitamins A and D, etc. Dairy industry is an extremely important sector of social production, which performs not only an important economic function. Purpose. Research of features of economic activity of milk processing enterprises in the food industry of Ukraine. Results. The article conducts a study that revealed a declining trend in the number of dairy plants in Ukraine, which generally increase the production of dairy products. It has been established that the number of dairy cattle, the production of raw milk and its income to processing enterprises is steadily declining. Based on a comparative analysis of the range of dairy products and its imports, it is concluded that a significant share of imported products is imported into Ukraine in large containers, packaged in domestic enterprises and sold as products of Ukrainian dairies. It is claimed that the reason for the increase in butter production while reducing the production of raw milk is in many cases its falsification - the replacement of milk fat with palm oil. Conclusions. The trend of changing the number of milk processing enterprises is a mirror image of the general trend in the food industry of Ukraine - in general, a declining trend with so far unstable growth since 2017. The production of many types of dairy products is growing. The reason for the increase in butter production while reducing the production of raw milk is in many cases its falsification - the replacement of milk fat with palm oil. Economic activity of Ukrainian dairies, in terms of forming the raw material base, is to expand the import of cheap European dairy products used as raw materials and replace milk fat with palm oil. This leads to the continuation of the curtailment of their cooperation with domestic milk producers, which is one of the main reasons for the reduction of its production. Keywords: industrial enterprises, milk processing industry, food industry, dairy raw materials, dairy products, import, counterfeiting, palm oil.

Effects of exchanging lactose for fat in milk replacer on ad libitum feed intake and growth performance in dairy calves

The recent trend in the dairy industry toward ad libitum feeding of young calves merits reconsideration of calf milk replacer (CMR) formulations. Additionally, feed intake regulation in young calves provided with ad libitum milk and solid feeds is insufficiently understood. This study was designed to determine the effect of exchanging lactose for fat in CMR on voluntary feed intake and growth performance. Lactose was exchanged for fat on a weight/weight basis, resulting in different energy contents per kilogram of CMR. Thirty-two male calves (1.7 ± 0.12 d of age, 47.6 ± 0.83 kg of body weight) were assigned to 1 of 16 blocks based on arrival date. Within each block, calves were randomly assigned to 1 of 2 treatments. The experimental period was divided into 4 periods. In period 1, until 14 ± 1.7 d of age, calves were individually housed, restricted-fed their assigned CMR treatments at 2.5 to 3 L twice daily, and provided with unlimited access to water, chopped straw, and starter. In period 2, calves were group-housed with 8 calves per pen and received ad libitum access to their assigned CMR treatments, starter feed, chopped wheat straw, and water. During period 3, from 43 until 63 d of age, calves were weaned by restricting CMR allowance in 2 steps, maintaining access to all other feeds. All calves were completely weaned at d 64 of age and were monitored until 77 d of age (period 4). Measurements included the intake of all dietary components, body weight gain, and a selection of blood traits. Increasing fat content at the expense of lactose decreased CMR intake by 10%, whereas total calculated metabolizable energy intake and growth remained equal between treatments. Total solid feed (starter and straw) consumption was not affected by CMR composition. These data indicate that calves fed ad libitum regulate their CMR intake based on energy content. High-fat CMR increased plasma phosphate, nonesterified fatty acids, triglycerides, and bilirubin, whereas plasma glucose remained unchanged. Despite the limited animal numbers in the present experiment, there was a significant decrease in the total number of health events (mainly respiratory) requiring therapeutic intervention and in the total number of therapeutic interventions in calves fed high-fat CMR. Calves appeared to consume CMR based on energy content, with a difference in ad libitum intake proportional to the difference in energy content of the CMR, maintaining equal body weight gain and solid feed intake.

Growth performance of newborn dairy calves fed a milk replacer with 2 protein concentrations at 2 feeding rates

ABSTRACT Objective The objective was to evaluate the growth performance by calves fed a conventional milk replacer (MR) or modified accelerated MR (24% CP) to prevent the slump in postweaning calf starter intake and feed efficiency. Materials and Methods A total of 104 (1 to 5 d old) Holstein heifer calves (39.3 ± 0.66 kg) were assigned randomly to 1 of 4 MR treatments to evaluate preweaning (1 to 42 d) and postweaning (43 to 56 d) performance in a 2 × 2 factorial arrangement of CP concentrations [20% CP or 24% CP high protein (HP) with feeding rates (FR) of 0.57 or 0.68 kg/d]. Treatments were MR fed at 15% solids (as fed): (1) control (CP1): a 20% CP:20% fat MR fed at 0.284 kg 2×/d for 35 d; (2) CP2: the 20:20 MR fed at 0.34 kg 2×/d for 35 d; (3) HP1: a 24:20 MR fed at CP1 rate; and (4) HP2: the 24:20 MR fed at CP2 rate. Results and Discussion No interactions of CP by FR were detected for growth parameters. During 1 to 14 d, calves fed higher MR FR (CP2 and HP2) had greater (P 0.10). Intakes of calf starter from 1 to 56 d were similar (P > 0.10) for calves fed MR with different CP concentrations (0.77 and 0.78 kg/d), whereas calf starter intake (0.81 and 0.74 kg/d) was reduced (P 0.01) for calves fed different CP concentrations (0.54 and 0.55 kg/kg) but were improved when fed higher MR FR (0.53 and 0.56 kg/kg). However, a trend (P Implications and Applications Feeding calves a conventional MR (20%CP:20% fat) at different FR with different CP concentrations resulted in similar performance. Feeding a higher CP MR (24% CP:20% fat) at higher FR did not affect preweaning gain of dairy calves.

The effect of milk fat replacement and the addition of Lactobacillus paracasei LPC-37 on the sensory properties of cheeses

The market of ripened cheese is growing rapidly and is highly competitive. Dairy manufacturers have expanded their product range to include cheese-like products where milk fat is replaced with vegetable oils. Cheese-like products have gained popularity among both convenient food producers and consumers looking for cheaper cheese substitutes. Fat determines the sensory attributes of cheeses. The sensory quality of cheese can also be modified through the addition of selected adjunct cultures. This study evaluated the influence of milk fat replacement with palm oil and the addition of an adjunct culture of Lactobacillus paracasei LPC-37 on the sensory attributes of Dutch-type cheeses and cheese-like products during ripening. The chemical composition, content of volatile compounds and colour were analysed. The replacement of milk fat with palm oil contributed to differences in the sensory profile and colour of cheese-like products and deteriorated their sensory quality. However, the addition of L. paracasei LPC-37 improved the sensory characteristics of cheese-like products.

Effect of replacing lactose with fat in milk replacer on abomasal emptying and glucose–insulin kinetics in male dairy calves

ABSTRACT Objective Altering energy supply and the relative proportions of energy source in the first weeks of life of dairy calves may influence glycemic and insulinemic responses. The objective of this study was to assess the metabolic responses to high-lactose or high-fat milk replacer. Materials and Methods Forty male calves were fed 7 L of milk replacer per day in 2 meals given 10 h apart, considered either high lactose (44% lactose, HL) or high fat (37% lactose, HF), from the first week of life to 30 d of age. Postprandial blood plasma glucose, insulin, and acetaminophen (an abomasal emptying marker) concentrations were measured up to 420 min and used to fit a mathematical model of abomasal emptying and glucose–insulin dynamics. Additionally, an i.v. glucose tolerance test was used to assess glucose tolerance and insulin sensitivity. Results and Discussion Insulin sensitivity remained unchanged; however, glucose maximal concentration and change from baseline tended to be greater for HL in response to an i.v. glucose challenge. Postprandial glucose was elevated at 30 min for HL and HF at 60 and 90 min. Model parameterization showed no difference in abomasal emptying; however, intestinal glucose absorption tended to be faster with HL. Potentiation of insulin action was greater with HL, and pancreatic responsiveness tended to be greater with HF. Implications and Applications These results suggest HL increased early-phase postprandial glucose appearance, which may influence insulin action. In this study, modifying milk replacer composition to more closely resemble cow’s milk did not negatively affect glucose metabolism.

Effects of milk replacer feeding levels on performance and metabolism of preweaned dairy calves during summer

The objective of this study was to evaluate the effect of milk replacer (MR) feeding programs on performance and metabolism during summer. At 3 d of age (DOA), calves were randomly assigned to 1 of 4 dietary treatments: control [CON; 0.55 kg dry matter (DM) of a 20% crude protein (CP) and 20% fat MR per day], intermediate (IL; 0.66 kg DM of a 26% CP and 17% fat MR per day), high (HL; 0.77 kg DM of a 26% CP and 17% fat MR per day), or aggressive (AL; 0.87 kg DM of a 26% CP and 17% fat MR per day). Calves were managed similarly and housed in individual polyethylene hutches using sand as a bedding material. Because 3 calves fed the AL diet developed abomasum bloating during the first 30 DOA, the AL treatment was terminated. Milk replacer (12.5% solids) was offered twice daily until 42 DOA, when MR was fed once daily to reduce its intake by 50%. Calves were weaned at 49 DOA and remained in hutches until 56 DOA. Calf starter and water were offered ad libitum. Ambient temperature and relative humidity in and outside the hutches were assessed hourly. Starter and MR intakes were recorded daily. Respiration rate and rectal temperature were determined 3 times each week. Body weight was measured at 3, 14, 28, 42, and 56 DOA. Plasma was collected at 5, 10, 14, 28, 42, 43, 45, 47, 49, 51, and 56 DOA for analysis of glucose, β-hydroxybutyrate, triglycerides, nonesterified fatty acids, urea nitrogen, and insulin concentrations. There were no treatment effects on starter intake, rectal temperature, or respiration rate. By 7 DOA, calves fed the IL and HL diets consumed the same amount of MR and a higher amount of MR than the CON calves. At wk 2, calves from all treatments had similar MR consumption before returning to the projected intake by design at wk 4. Calves fed the IL and HL treatments had similar body weight but were heavier than those fed the CON diet at wk 6, 7, and 8. Calves fed the IL and HL diets had similar average daily gain, which was higher than that of calves fed the CON diet. There was no difference in plasma metabolites among treatments, but insulin concentration increased as milk allowance increased. In summary, feeding an intermediate level of MR during summer improved calf growth compared with the CON diet, but a higher MR allowance did not support further improvements in calf performance.