Cytotoxicity Of Polyethylenimine Research Articles

Polyelectrolyte complexes of hTERT siRNA and polyethyleneimine: Effect of degree of PEG grafting on biological and cellular activity

Gene silencing by siRNA (short interfering RNA)-targeted human telomerase reverse transcriptase (hTERT) is considered a successful strategy for cancer gene therapy. Polyelectrolyte complexes (PEC) of siRNA and cationic polymers such as polyethyleneimine (PEI) have been widely used for cellular transfection; however, they demonstrate some disadvantages such as cytotoxicity and extracellular matrix restrictions. PEG grafting technology was used in an attempt to improve the biocompatibility of PECs. Considering that this technology may compromise the cellular uptake of PECs, we aimed to study the effect of degree of PEI PEGylation on the carrier cytotoxicity, cellular association, and transfection efficiency of hTERT siRNA in the lung cancer cell line A549. Activated NHS ester of methoxy PEG–COOH 5 KDa was grafted to hyperbranched PEI 25 KDa in the molar ratios of 0.2 and 1. The copolymers were characterized by 1H-NMR spectroscopy. PECs of PEI or PEG-g-PEI with siRNA, alone or co-incubated with heparin sulfate, were studied by the ethidium bromide exclusion assay. Cytotoxicity of the polymers (PEG-g-PEI vs PEI), alone and upon formation of PEC nanoparticles with hTERT siRNA, was determined by a validated MTT assay, in comparison to a scrambled control sequence, in A549 human lung carcinoma cells. The cellular uptake of the PECs of FITC-labeled siRNA was investigated by flow cytometry at different N/P ratios, and the silencing effect of the transfected siRNA was compared to that of the control sequence for different PECs by real time RT-PCR. The cytotoxicity of PEI decreased significantly by PEG grafting, even at a low degree of PEGylation. Moreover, the nonspecific cytotoxicity of PECs decreased by PEG grafting. PECs of PEG-g-PEI showed more biologic stability on incubation with heparin sulfate. Average particle size and zeta potential of PEC nanoparticles were diminished for those of PEG-g-PEI. The cellular association was more pronounced at an N/P ratio of 2.5 for PECs of PEI and PEG-g-PEI alike. The level of silencing of hTERT mRNA by PEC of PEG-g-PEI was sequence-dependent, and determined non-inferior when compared to the native PEI. Conclusively, the biocompatibility of PEI was improved by a low degree of PEGylation, with no adverse effect on the cellular uptake and the transfection activity. PEC nanoparticles of hTERT siRNA and PEG-g-PEI could act as a promising weapon against A549 cells, which has to be considered for an in vivo evaluation.

Identification of possible cytotoxicity mechanism of polyethylenimine by proteomics analysis.

Polyethylenimine (PEI) is a polycation widely used for successful gene delivery both in vitro and in vivo experiments. However, different studies showed that PEI could be cytotoxic to transfected cells, and the mechanism of toxicity is poorly understood. Identification of PEI-interacting proteins may help in understanding the toxicity pathways. In this study, we investigated proteins that could interact with PEI in human colorectal adenocarcinoma cells (HT29). In order to identify the proteins interacting with PEI, PEI was immobilized to sepharose beads as solid matrix. The HT29 cell lysate were passed through the matrix. PEI-bound proteins were isolated, and further separation was performed by two-dimensional gel electrophoresis. After gel digestion, proteins were identified by matrix-assisted laser desorption/ionization-time-of-flight (TOF)/TOF mass spectrometry. Our data indicated that most of the identified PEI-interacting proteins such as shock proteins, glutathione-S-transferases, and protein disulfide isomerase are involved in apoptosis process in cells. Thus, although this is a preliminary experiment implicating the involvement of some proteins in PEI cytotoxicity, it could partly explain the mechanism of PEI cytotoxicity in cells.

Caveolin-1 mediates gene transfer and cytotoxicity of polyethyleneimine in mammalian cell lines.

Polyethyleneimine (PEI) is a cost-effective and non-viral vector for gene transfer,but the factors determining gene transfer efficiency and cytotoxicity of PEI in different mammalian cell lines remain largely unknown. In the present study, three different cell lines were chosen for investigation. Using pEGFP DNA and PEI, 21.5, 29.2, and 92.1% of GFP-positive cells were obtained in BMSC, Hela, and 293T, respectively. In luciferase reporter assay, similar results were obtained (for luciferase activity, BMSC<Hela<293T cells). By MTT test and cell apoptotic marker analysis, we demonstrated that high gene transfer efficiency is accompanied with high cytotoxicity of PEI. Moreover, we found that high expression level of caveolin-1 was accompanied with high gene transfer efficiency and cytotoxicity of PEI in 293T cells. More convincingly, caveolin-1 silencing in 293T could reduce both gene transfer efficiency and cytotoxicity of PEI. In contrast, caveolin-1 overexpression in BMSCs increases both gene transfer efficiency and cytotoxicity of PEI. Taken together, our study suggests that caveolin-1 may at least in part determine gene transfer efficiency and cytotoxicity of PEI in mammalian cell lines, providing caveolin-1 as a potential target for improving gene transfer efficiency when applying positively charged polyplexes to cell transfection.

Diglycidyl Esters Cross-Linked with Low Molecular Weight Polyethyleneimine for Magnetofection

Magnetic polyethyleneimine (PEI) complexes have demonstrated to be simple and efficient vectors for enhancing gene transfection. However, the high cytotoxicity of PEI restricts its further application in vivo. In this study, we synthesized several low cytotoxicity biodegradable cationic polymers derived from PEI (Mw 600) linked with diglycidyl tartrate (DT-PEI) or its analogues (diglycidyl succinate (DS-PEI) and diglycidyl malate (DM-PEI); D-PEIs for all 3 polymers). Moreover, a type of biocompatible magnetic nanoparticles (MNPs) with negative charges was prepared to assemble with D-PEIs/DNA complexes via electrostatic interactions. The magnetic ternary complexes have appropriate sizes of 120–150 nm and zeta potential values of ~20–25 mV. The transfection ability and cell viability of D-PEIs increased as the amount of hydroxyl groups increased in the repeat unit, which indicated that increasing the hydroxyl number in the backbone of D-PEIs can enhance gene expression and decrease cytotoxicity in A549 cells. Magnetofection of DT-PEI showed similar transfection efficiency with 30 min incubation; in contrast, the standard incubation time was 4 h. All three magnetic complexes displayed lower cytotoxicity when compared with those of PEI complexes in COS-7 and A549. These results indicated that these series of magnetic PEI derivatives complexes could be potential nanocarriers for gene delivery.

Cross-linked polyethylenimine-tripolyphosphate nanoparticles for gene delivery.

The high transfection efficiency of polyethylenimine (PEI) makes it an attractive potential nonviral genetic vector for gene delivery and therapy. However, the highly positive charge of PEI leads to cytotoxicity and limits its application. To reduce the cytotoxicity of PEI, we prepared anion-enriched nanoparticles that combined PEI with tripolyphosphate (TPP). We then characterized the PEI-TPP nanoparticles in terms of size, zeta potential, and Fourier-transform infrared (FTIR) spectra, and assessed their transfection efficiency, cytotoxicity, and ability to resist deoxyribonuclease (DNase) I digestion. The cellular uptake of PEI-TPP with phosphorylated internal ribosome entry site–enhanced green fluorescent protein C1 or FAM (fluorouracil, Adriamycin [doxorubicin] and mitomycin)-labeled small interfering ribonucleic acids (siRNAs) was monitored by fluorescence microscopy and confocal laser microscopy. The efficiency of transfected delivery of plasmid deoxyribonucleic acid (DNA) and siRNA in vitro was 1.11- to 4.20-fold higher with the PEI-TPP particles (7.6% cross-linked) than with the PEI, at all N:P ratios (nitrogen in PEI to phosphorus in DNA) tested. The cell viability of different cell lines was more than 90% at the chosen N:P ratios of PEI-TPP/DNA complexes. Moreover, PEI-TPP nanoparticles resisted digestion by DNase I for more than 2 hours. The time-dependent absorption experiment showed that 7.6% of cross-linked PEI-TPP particles were internalized by 293T cells within 1 hour. In summary, PEI-TPP nanoparticles effectively transfected cells while conferring little or no toxicity, and thus have potential application in gene delivery.

Chemically Conjugating Polyethylenimine with Chondroitin Sulfate to Promote CD44-Mediated Endocytosis for Gene Delivery

Polyethylenimine (PEI) is one of the most potent synthetic gene delivery vectors because of its high transfection efficiency. Although PEI has been used as a delivery vehicle for a long while, its toxicity is always an issue for clinical applications. In this study, we introduced a low molecular weight PEI of 10 kilodaltons to chondroitin sulfate (CS) via a Michael addition method. By adjusting weight ratios between cationic PEI and anionic CS, the intermolecular or intramolecular, or both, electrostatic interactions of CS-modified PEI (CP) maintained good water solubility but lost some ability to permeate cell membranes. Thus, the cytotoxicity of PEI decreased without sacrificing its gene transfection efficiency. Three CP copolymers with different PEI contents were synthesized and used to prepare polyplexes with plasmid DNA. The pDNA-formed polyplex with a low PEI content (CP(L)) was least cytotoxic and had a transfection efficiency comparable to Lipofectamine/pDNA. The good uptake of CP(L)/pDNA into U87 cells was primarily based on clatherin-dependent and CD44-mediated endocytosis.

Kidney-Specific Peptide-Conjugated Poly(ester amine) for the Treatment of Kidney Fibrosis

Kidney gene therapy using the hepatocyte growth factor (HGF) gene may offer new strategies for the treatment of chronic renal disease such as kidney fibrosis, because HGF has the potential to promote tubular repair and to inhibit tissue fibrosis. As a non-viral vector for gene delivery, polyethylenimine (PEI) exhibits high gene expression due to its buffering capacity with cytotoxicity, although its cytotoxicity depends on its molecular weight. In this study, to minimize the cytotoxicity of PEI with a high transfection efficiency, biodegradable poly(ester amine) (PEA) based on glycerol dimethacrylate (GDM) and low molecular weight PEI (LMW PEI) was synthesized and kidney targeting peptide was conjugated to the PEA (PEP-PEA) to give it kidney cell specificity. The PEP-PEA showed good physicochemical properties as a gene delivery carrier, such as DNA condensation ability, protection of the DNA in the complexes from enzyme degradation, and formation of nanosized complexes with spherical shapes. Higher transfection efficiency in 293T cells was achieved with the PEP-PEA than with the PEA and the PEI 25 kDa with lower cytotoxicity. Also, the HGF gene that was complexed with the PEP-PEA was specifically delivered to the obstructed kidney in the unilateral ureteral obstruction (UUO) model rats. The delivered HGF gene exhibited potency in recovering renal functions, which indicates the potential of the PEP-PEA as a safe and efficient carrier for the treatment of kidney fibrosis.

Cell line specific control of polyethylenimine-mediated transient transfection optimized with “Design of experiments” methodology

We describe a design of experiments (DoE) response surface modeling strategy to optimize the concentration of basal variables underpinning polyethylenimine (PEI) mediated transfection of different CHO-K1 derived parental cell populations in a chemically defined medium, specifically the relative concentration of linear 25 kD PEI, host CHO cells and plasmid DNA. Using recombinant secreted alkaline phosphatase (SEAP) reporter activity as the modeled response, a discrete simple maximum was predicted for each CHO host cell population. Differences between the modeled optima derived from host cell specific differences in PEI cytotoxicity, such that the PEI:cell interaction effectively limited PEI-DNA polyplex load at a relatively constant PEI:DNA ratio. However, across the three CHO host cell populations, SEAP reporter production was not proportional to plasmid DNA input at the host cell specific predicted basal variable optima. A 10-fold variation in SEAP reporter output per mass of plasmid DNA delivered was observed. To determine the cellular basis of this difference in transient productivity, host CHO cells were transfected with fluorescently labeled polyplexes followed by flow cytometric analysis. Each CHO host cell population exhibited a distinct functional phenotype, varying in the extent of PEI-DNA polyplex binding to the cell surface and degree of polyplex internalization. SEAP production was directly proportional to the level of polyplex internalization and heparan sulfate proteoglycan level. Taken together, these data show that choice of host CHO cell line is a critical parameter, which should rationally precede cell line specific transient production platform design using DoE methodology.

High-Molecular-Weight Polyethyleneimine Conjuncted Pluronic for Gene Transfer Agents

In order to enhance the gene delivery efficiency and decrease cytotoxicity of polyplexes, copolymers consisting of branched polyethyleneimine (PEI) 25 kDa grafted with Pluronic (F127, F68, P105) were successfully synthesized using a simple two-step procedure. The copolymers were tested for cytotoxicity and DNA condensation and complexation properties. Their polyplexes with plasmid DNA were characterized in terms of DNA size and surface charge and transfection efficiency. The complex sizes were below 300 nm, which implicated their potential for intracellular delivery. The Pluronic-g-PEI exhibited better condensation and complexation properties than PEI 25 kDa. The cytotoxicity of PEI was strongly reduced after copolymerization. The Pluronic-g-PEI showed lower cytotoxicity in three different cell lines (Hela, MCF-7, and HepG2) than PEI 25 kDa. pGL3-lus was used as a reporter gene, and the transfection efficiency was in vitro measured in HeLa cells. Compared with unmodified PEI 25 kDa Pluronic-g-PEI showed much higher transfection efficiency. These results demonstrate that polyplexes prepared using a combined strategy of surface crosslinking and grafted with Pluronic seem to provide promising properties as stable, high transfection efficiency vectors.

Polymeric Micelles Comprising Stearic Acid-Grafted Polyethyleneimine as Nonviral Gene Carriers

Non-viral vectors composed of biodegradable polymers or lipids have been considered as a safer alternative for gene carriers over viral vectors. Among some of the cationic polymers, polyethyleneimine (PEI) possess high pH-buffering capacity that can provide protection to nucleotides from acidic degradation and promotes endosomal and lysosomal release. However, it has been reported that cytotoxicity of PEI depends on the molecular weight of the polymer. Hence modifications of PEI structure for clinical application have been developed in order to reduce the cytotoxicity, or improve the insufficient transfection efficiency of lower molecular weight PEI. In this study, 10 k PEI was modified by grafting stearic acid (SA) and formulated to polymer micelles with positive surface charge and evaluated for pDNA delivery. The amine group on PEI was crosslinked with the carboxylic group of stearic acid by 1-ethyl-3-(3-dimethylamino-propyl) carbodiimide (EDC) as linker. PEI-SA micelles were then prepared using oil in water (o/w) solvent evaporation method. The success of PEI-SA conjugation structure was confirmed with 1H NMR. The average diameter and zeta potential determined by photon correlation spectroscopy was 149.6 +/- 1.2 nm and 64.1 +/- 1.5 mV, respectively. These self-assemble positive charge micelles showed effective binding to pDNA for transfection. PEI-SA micelles exhibited lower cytotoxicity compared to that of PEI only, while flow cytometry analysis revealed PEI-SA/pEGFP complex provided 62% high EGFP expression. Luciferase activity also showed high transfection efficiency of PEI-SA micelles for weight ratio above 4.5 that was comparable to PEI only. These results demonstrated that stearic acid grafted PEI micelles can provide high transfection efficiency comparable to unmodified PEI, and exhibit low cytotoxicity. Stearic acid grafted PEI micelles can be promising polymer carriers in genetic therapy.

The impact of carboxyalkylation of branched polyethylenimine on effectiveness in small interfering RNA delivery

Carboxyalkylation of branched 25 kDa polyethylenimine (PEI) was considered to reduce the positive surface charge of the polymer without reducing its 'proton sponge' buffering capacity, and to provide alkylene domains for hydrophobic interactions, thus generating optimized novel PEI carriers for efficient delivery of small interfering RNA (siRNA). Substitution of PEI was evaluated in the range of 6 to > 50 mole percentage of primary amines. Additionally, variation of the carboxyalkyl chain (one to 15 methylene groups) was explored to modulate the carrier hydrophobicity. Carriers were characterized in their buffering capacity, capability of siRNA polyplex formation, and cytotoxicity. Marker gene-silencing efficacy was evaluated using Neuro2A-eGFPLuc neuroblastoma cells. Carboxyalkylation strongly reduced cytotoxicity of PEI and improved siRNA mediated luciferase gene knockdown. An optimum silencing activity was observed at an alkylcarboxylation degree of 6-9 mole percentage of primary amines and with a broad range of carboxyalkylene chains (containing one to 15 methylene groups). Strongly enhanced gene-silencing efficacy also was observed when the biocompatible polymers were separately added at 1 h after transfection with tolerated doses of standard PEI25/siRNA polyplexes. Carboxyalkylation of branched 25 kDa PEI resulted in polymers with strongly reduced cytotoxicity and improved silencing efficacy. Mechanistic studies demonstrated that the presence of a surplus of free carboxyalkylated polymer is responsible for the improved siRNA delivery.

Toxicity Pathway Focused Gene Expression Profiling of PEI-Based Polymers for Pulmonary Applications

Polyethylene imine (PEI) based polycations, successfully used for gene therapy or RNA interference in vitro as well as in vivo, have been shown to cause well-known adverse side effects, especially high cytotoxicity. Therefore, various modifications have been developed to improve safety and efficiency of these nonviral vector systems, but profound knowledge about the underlying mechanisms responsible for the high cytotoxicity of PEI is still missing. In this in vitro study, we focused on stress and toxicity pathways triggered by PEI-based vector systems to be used for pulmonary application and two well-known lung toxic particles: fine crystalline silica (CS) and nanosized ZnO (NZO). The cytotoxicity profiles of all stressors were investigated in alveolar epithelial-like type II cells (LA4) to define concentrations with matching toxicity levels (cell viability >60% and LDH release <10%) for subsequent qRT-PCR-based gene array analysis. Within the first 6 h pathway analysis revealed for CS an extrinsic apoptotic signaling (TNF pathway) in contrast to the intrinsic apoptotic pathway (mitochondrial signaling) which was induced by PEI 25 kDa after 24 h treatment. The following causative chain of events seems conceivable: reactive oxygen species derived from particle surface toxicity triggers TNF signaling in the case of CS, whereby endosomal swelling and rupture upon endocytotic PEI 25 kDa uptake causes intracellular stress and mitochondrial alterations, finally leading to apoptotic cell death at higher doses. PEG modification most notably reduced the cytotoxicity of PEI 25 kDa but increased proinflammatory signaling on mRNA and even protein level. Hence in view of the lung as a sensitive target organ this inflammatory stimulation might cause unwanted side effects related to respiratory and cardiovascular disorders. Thus further optimization of the PEI-based vector systems is still needed for pulmonary application.

Cross-linked polyethylenimine-hexametaphosphate nanoparticles to deliver nucleic acids therapeutics

Branched polyethylenimine (PEI; 25 kDa) as a nonviral vector exhibits high transfection efficiency and is a potential candidate for efficient gene delivery. However, the cytotoxicity of PEI limits its application in vivo. PEI was ionically interacted with hexametaphosphate, a compact molecule with high anionic charge density, to obtain nanoparticles (PEI-HMP). Nanoparticles were assessed for their efficacy in protecting complexed DNA against nucleases. The intracellular trafficking of nanoparticles was monitored by confocal microscopy. The cytotoxicity and transfection efficiency of PEI-HMP nanoparticles were evaluated in vitro. In vitro transfection efficiency of PEI-HMP (7.7%) was ∼1.3- to 6.4-folds higher than that of the commercial reagents GenePORTER 2 TM, Fugene TM, and Superfect TM. Also, PEI-HMP (7.7%) delivered green fluorescent protein (GFP)-specific small interfering ribonucleic acid (siRNA) in culture cells leading to >80% suppression in GFP gene expression. PEI-HMP nanoparticles protected complexed DNA against DNase for at least 2 hours. A time-course uptake of PEI-HMP (7.7%) nanoparticles showed the internalization of nanoparticles inside the cell nucleus in 2 hours. Thus, PEI-HMP nanoparticles efficiently transfect cells with negligible cytotoxicity and show great promise as nonviral vectors for gene delivery. From the Clinical Editor Branched polyethylenimine (PEI) as a non-viral vector exhibits high transfection efficiency for gene delivery, but its cytotoxicity limits its applications. PEI hexametaphosphate nanoparticles (PEI-HMP) demonstrated a 1.3-6.4 folds higher transfection rate compared to commercial reagents. Overall, PEI-HMP nanoparticles efficiently transfect cells with negligible cytotoxicity and show great promise as non-viral vectors for gene delivery.

Alkylcarboxylate grafting to polyethylenimine: a simple approach to producing a DNA nanocarrier with low toxicity

Various strategies have been examined to improve both transfection efficiency and cytotoxicity of polyethylenimine (PEI), a widely used polycationic nonviral gene vector. In the present study, we sought to improve PEI transfection efficiency by combining the osmotic burst mechanism for lysing endocytotic vesicles with the lipid depletion mechanism, which was accomplished by maintaining buffering capacity at the same time as adding a lipid-absorbing hydrophobic shell. PEI was altered via the substitution of various percentages of its primary amines with carboxylate-terminated short, moderate and long alkyl chains, by reaction with bromoacetic, 6-bromohexanoic, 10-bromodecanoic and 16-bromohexadecanoic acids. Modified polymers were complexed with plasmid and the particle size and zeta potential of the polyplexes were determined. Ethidium bromide dye exclusion was used to show the DNA-binding ability of the polymers and their transfection activity and cytotoxicity was evaluated in Neuro2A mammalian cells. Decreased DNA-binding ability resulted from increases in either the degree of substitution or hydrocarbon chain length. Particle size and zeta potential measurements demonstrated that modified PEI polymers were able to form nanoparticles in the size range 60-195 nm, and surface charge decreased with an increasing degree of substitution. Higher degrees of substitution resulted in decreased cytotoxicity of polymers. Alkylcarboxylate substitution of primary amines on PEI enhanced transfection efficiencies by up to approximately five-fold relative to underivatized PEI, with the greatest increases occurring with 6-bromohexanoic acid derivatives at degrees of substitution below 10%. The results obtained suggest that an appropriate balance between cationic and hydrophobic regions of alkylated PEI yields the optimal nonviral vector with high transfection efficiency and low toxicity.

Subcutaneous Peripheral Injection of Cationized Gelatin/DNA Polyplexes As a Platform for Non-viral Gene Transfer to Sensory Neurons

Selective modulation of sensory neuron gene expression could have numerous applications for the peripheral nervous system. Here, we report that subcutaneous peripheral injection of plasmid DNA complexed with a non-viral cationized gelatin (CG) vector led to transgene expression in rat lumbar dorsal root ganglia (DRGs). CG/DNA polyplexes appeared to undergo rapid retrograde transport through sciatic and spinal nerves, with reporter gene messenger RNA (mRNA) expression detectable in L4 and L5 DRGs within 60 hours. Maximum transgene expression was observed for polyplexes formed at 7.5:1 CG-to-DNA weight ratio under salt-free conditions, which generated 615 +/- 112 nm nanoparticles with zeta-potential of 9.4 +/- 0.19 mV. Six days after injection of the CG/DNA polypex, reporter gene protein immunofluorescence was observed in 1,164 +/- 176 DRG neurons, representing an estimated transfection rate of 47% of targeted neurons. Reporter gene expression was not detected in heart, lung, or liver tissues, suggesting a lack of systemic uptake. Measurements of tactile sensitivity indicate that CG/DNA injection did not cause behavioral toxicity. The injection platform was further used for plasmid-driven short hairpin RNA-mediated suppression of glyceraldehyde-3-phosphate dehydrogenase. This non-invasive gene delivery system could be used for the mechanistic study and targeted molecular evaluation of peripheral nervous system pathologies such as neuropathic pain.

Control of Culture Environment for Improved Polyethylenimine-Mediated Transient Production of Recombinant Monoclonal Antibodies by CHO Cells

In this study we describe optimization of polyethylenimine (PEI)-mediated transient production of recombinant protein by CHO cells by facile manipulation of a chemically defined culture environment to limit accumulation of nonproductive cell biomass, increase the duration of recombinant protein production from transfected plasmid DNA, and increase cell-specific production. The optimal conditions for transient transfection of suspension-adapted CHO cells using branched, 25 kDa PEI as a gene delivery vehicle were experimentally determined by production of secreted alkaline phosphatase reporter in static cultures and recombinant IgG4 monoclonal antibody (Mab) production in agitated shake flask cultures to be a DNA concentration of 1.25 microg 10(6) cells(-1) mL(-1) at a PEI nitrogen:DNA phosphate ratio of 20:1. These conditions represented the optimal compromise between PEI cytotoxicity and product yield with most efficient recombinant DNA utilization. Separately, both addition of recombinant insulin-like growth factor (LR3-IGF) and a reduction in culture temperature to 32 degrees C were found to increase product titer 2- and 3-fold, respectively. However, mild hypothermia and LR3-IGF acted synergistically to increase product titer 11-fold. Although increased product titer in the presence of LR3-IGF alone was solely a consequence of increased culture duration, a reduction in culture temperature post-transfection increased both the integral of viable cell concentration (IVC) and cell-specific Mab production rate. For cultures maintained at 32 degrees C in the presence of LR3-IGF, IVC and qMab were increased 4- and 2.5-fold, respectively. To further increase product yield from transfected DNA, the duration of transgene expression in cell populations maintained at 32 degrees C in the presence of LR3-IGF was doubled by periodic resuspension of transfected cells in fresh media, leading to a 3-fold increase in accumulated Mab titer from approximately 13 to approximately 39 mg L(-1). Under these conditions, Mab glycosylation at Asn297 remained essentially constant and similar to that of the same Mab produced by stably transfected GS-CHO cells. From these data we suggest that the efficiency of transient production processes (protein output per rDNA input) can be significantly improved using a combination of mild hypothermia and growth factor(s) to yield an extended "activated hypothermic synthesis".

Intracellular dynamics of the gene delivery vehicle polyethylenimine during transfection: investigation by two-photon fluorescence correlation spectroscopy

Though polyethylenimine (PEI) is one of the most efficient nonviral vectors, one concern is the significant cytotoxicity of free PEI that represents about 80% of the PEI molecules in PEI/DNA mixtures used for transfection. In this respect, the aim of this work was to further investigate the intracellular fate of PEI during transfection of L929 fibroblasts. To this end, we analyzed by fluorescence correlation spectroscopy (FCS) using two-photon excitation the intracellular concentration and diffusion properties of labeled PEI and PEI/DNA complexes in various compartments of L929 cells. High initial fluorescence intensity, rapid photobleaching and the absence of measurable autocorrelation curves in most selected locations in cytoplasm suggest that PEI/DNA complexes and PEI accumulate (up to 30 times the concentration in the extracellular medium) in late endosomes bound to the inner membrane face. This feature, together with membrane destabilizing properties of PEI, may explain the release of PEI into cytoplasm and subsequent diffusion into the nucleus. In the nucleus, the concentration of PEI was found to be about 2.5- to 3.5-fold higher than the one in the incubation medium. Moreover, autocorrelation curves obtained in the nuclear compartment can be analyzed with either a two-component model (with the major fraction undergoing free Brownian diffusion) or an anomalous diffusion model. Both the endosomal disruption and the large intranuclear PEI concentration may contribute to PEI cytotoxicity.

Transfection efficiency and toxicity of polyethylenimine in differentiated Calu-3 and nondifferentiated COS-1 cell cultures.

In the present study, we evaluated polyethylenimine (PEI) of different molecular weights (MWs) as a DNA complexing agent for its efficiency in transfecting nondifferentiated COS-1 (green monkey fibroblasts) and well-differentiated human submucosal airway epithelial cells (Calu-3). Studying the effect of particle size, zeta potential, presence of serum proteins or chloroquine, it appeared that transfection efficiency depends on the experimental conditions and not on the MW of the PEI used. Comparing transfection efficiencies in both cell lines, we found that PEI was 3 orders of magnitude more effective in COS-1 than in Calu-3 cells, because Calu-3 cells are differentiated and secrete mucins, which impose an additional barrier to gene delivery. Transfection efficiency was strongly correlated to PEI cytotoxicity. Also, some evidence for PEI-induced apoptosis in both cell lines was found. In conclusion, our results indicate that PEI is a useful vector for nonviral transfection in undifferentiated cell lines. However, results from studies in differentiated bronchial epithelial cells suggest that PEI has yet to be optimized for successful gene therapy of cystic fibrosis (CF).