Aerosol Challenge Research Articles

Single-pass wind tunnel testing for recirculating virus aerosol control technologies

A number of recirculating flow aerosol control technologies have been commercialized to mitigate aerosol-transmitted virus infections. Many of these technologies incorporate filters for particle collection and some may also incorporate technologies for virus inactivation. Given the wide variety of commercially available aerosol control technologies to consumers, it is extremely important to develop standardized methods to characterize their performance in bioaerosol removal and inactivation, such that technologies can be compared on an “equivalent-test” basis. However, no standard procedures have been established to evaluate the effectiveness of bioaerosol removal and inactivation in recirculating aerosol control technologies. We propose the use of a single-pass tunnel to assess the performance of bioaerosol control technologies, as single-pass wind tunnels can be sealed with well-controlled velocity and particle concentration profiles. Here, we specifically describe the construction of a single-pass wind tunnel and apply it to three recirculating aerosol control technologies, incorporating UV-C sources, filters, and electrostatic precipitators, respectively. We utilize a porcine respiratory coronavirus (PRCV) challenge aerosol, generated via pneumatic nebulization of a high titer (∼107 TCID50 mL−1) viral suspension. Following guidelines similar to those used in the ANSI/ASHRAE Standard 52-2 test procedure for HVAC filters, in single-pass wind tunnel tests, velocity uniformity and particle uniformity are first monitored across the cross-section of the tunnel. The size distribution of viable particles is additionally determined in advance of tests by the collection of particles in the wind tunnel using a cascade impactor, with both RT-qPCR and titration used to quantify viruses collected on each impaction stage. We show that the viable particle size distribution follows the volumetric size distribution of the nebulized virus-laden suspension, and that this distribution can be tuned to be similar in shape to the observed distribution of aerosol from human respiratory activities. Following tunnel and virus aerosol characterization, for each tested technology, using triplicate tests, the single-pass log reduction based on RT-qPCR and viable virus titration is determined by simultaneously collecting virus aerosol particles upstream and downstream of the control technology. The tested technologies in this study have titration-based single-pass log reductions in the 1.5–4.0 range.Overall, design and testing suggest that the single-pass wind tunnel approach is a tractable method to examine the efficacy of aerosol control technologies in removing and inactivating viruses in aerosols, and suggest that such technologies should be described by their single-pass log reduction and operating flow rate, with the test virus size distribution reported alongside test results. In addition, we examine the limits of detection in single-pass wind tunnel tests in comparison to chamber tests, and in doing so find that for most control technologies, the wind tunnel test will yield higher concentrations downstream or during sampling, and hence clearer results for the log reduction.

Eastern equine encephalitis virus rapidly infects and disseminates in the brain and spinal cord of cynomolgus macaques following aerosol challenge.

Eastern equine encephalitis virus (EEEV) is mosquito-borne virus that produces fatal encephalitis in humans. We recently conducted a first of its kind study to investigate EEEV clinical disease course following aerosol challenge in a cynomolgus macaque model utilizing the state-of-the-art telemetry to measure critical physiological parameters. Here, we report the results of a comprehensive pathology study of NHP tissues collected at euthanasia to gain insights into EEEV pathogenesis. Viral RNA and proteins as well as microscopic lesions were absent in the visceral organs. In contrast, viral RNA and proteins were readily detected throughout the brain including autonomic nervous system (ANS) control centers and spinal cord. However, despite presence of viral RNA and proteins, majority of the brain and spinal cord tissues exhibited minimal or no microscopic lesions. The virus tropism was restricted primarily to neurons, and virus particles (~61-68 nm) were present within axons of neurons and throughout the extracellular spaces. However, active virus replication was absent or minimal in majority of the brain and was limited to regions proximal to the olfactory tract. These data suggest that EEEV initially replicates in/near the olfactory bulb following aerosol challenge and is rapidly transported to distal regions of the brain by exploiting the neuronal axonal transport system to facilitate neuron-to-neuron spread. Once within the brain, the virus gains access to the ANS control centers likely leading to disruption and/or dysregulation of critical physiological parameters to produce severe disease. Moreover, the absence of microscopic lesions strongly suggests that the underlying mechanism of EEEV pathogenesis is due to neuronal dysfunction rather than neuronal death. This study is the first comprehensive investigation into EEEV pathology in a NHP model and will provide significant insights into the evaluation of countermeasure.

Inflammation and Hypoxia May Underlie Neuronal Death in Brain of SARS‐CoV‐2 Infected Non‐Human Primates

Neuropathological complications are frequently observed in SARS‐CoV‐2 infection and brain autopsies from human subjects who died from COVID‐19 have revealed significant pathology, including wide‐spread neuroinflammation, hypoxic‐ischemic injury, and microhemorrhages. To begin to understand the neuropathogenesis of SARS‐CoV‐2 infection, we investigated brain from infected non‐human primates (NHP)s for pathological changes consistent with that seen among humans. Eight aged NHPs were inoculated with the 2019‐nCoV/USA‐WA1/2020 strain of SARS‐CoV‐2 via a multi‐route mucosal or aerosol challenge. Hematoxylin and eosin (H&E) and immunohistochemistry (IHC) staining was done on seven brain regions to elucidate general pathology, microhemorrhages, platelet derived thrombi, neuronal apoptosis, microglia and astrocyte morphology, hypoxia, and virus present. Similar to humans, pathology was variable but included wide‐spread neuroinflammation, nodular lesions, neuronal degeneration, and microhemorrhages. Neuronal degeneration was most often seen in the cerebellum and brainstem of infected animals. Neuronal death was confirmed through FluorJade C and cleaved (active) caspase 3 IHC, which showed foci of positivity, particularly among Purkinje cells of the cerebellum. Importantly, this was seen among infected animals that did not develop severe respiratory disease. Hypoxia inducible factor‐1α (HIF‐1α) was observed at a higher intensity around the vasculature within deep brain regions of the infected animals. Microhemorrhages were prevalent among all animals but were less frequently associated with platelet derived thrombi in the infected animals, as compared to mock‐infected controls. Sparse virus was detected in brain endothelial cells but did not associate with the severity of CNS injury. Increased HIF‐1α suggests that brain hypoxia may promote neuronal degeneration within infected brain. Wide‐spread neuroinflammation may also contribute to neuronal injury/death and neurological manifestations seen in the context of infection.

Limonene restores A2AAR mediated‐vascular relaxation in asthmatic mice via nitric oxide

Limonene, a mono‐terpene flavonoid, has anti‐inflammatory effects in asthma by activating A2A adenosine receptors (A2AAR). Our objective was to identify the mechanism by which limonene restored A2A mediated aortic relaxation in asthmatic mice. Ex‐vivo tissue bath was used to study the effects of inhaled d‐limonene on isolated aortic rings from asthmatic mice. We used mice in which the A2A receptor was genetically knocked out (A2AKO) and C57BLJ/6 (wild‐type; WT) for the study. The mice were divided into control (CON) and allergen‐induced sensitized (SEN), control mice treated with limonene through aerosol route (CON+LIM) and allergen‐induced sensitized mice treated with limonene (SEN+LIM). Mice were sensitized i.p. on days 1, 6 with 20μg ovalbumin (OVA) followed by 5% OVA aerosol challenges on days 11–13. Control groups were given an i.p injection of vehicle (1,6 days) and the aerosol challenge of normal saline (11–13 days). SEN +LIM, CON +LIM groups were given 0.01% v/v aerosolized limonene via inhalation 90 min prior to challenges. Aorta were isolated on day 14 for further experiments. Tissue responses were studied in the form of contraction and relaxations in all groups. Concentration‐response curves (CRC) for selective A2Aagonist CGS‐21680 (10‐11‐10‐6M) were obtained for all groups. eNOS inhibitor L‐NAME (10‐4M) or prostaglandin inhibitor indomethacin (10‐5M) was added 30 min prior to starting CRC to study effect of nitric oxide and prostaglandins on vascular response. CGS‐21680 induced aortic relaxation was absent in WT SEN (5.62±3.72% WT SEN Vs 66.91 ± 6.8% CON, *p<0.05). Limonene restored CGS 21680‐induced relaxation in asthmatic mice (63.8 ± 6.32% WT SEN+LIM Vs 5.62± 3.72% WT SEN). L‐NAME blocked CGS‐21680 response in CON, CON+ LIM and SEN+LIM, while indomethacin had minimal effect. In conclusion, it appears that limonene restores A2AAR‐mediated aortic relaxation induced through nitric oxide in asthmatic mice.

A DNA vaccine targeting VEE virus delivered by needle-free jet-injection protects macaques against aerosol challenge

We have previously shown that DNA vaccines expressing codon optimized alphavirus envelope glycoprotein genes protect both mice and nonhuman primates from viral challenge when delivered by particle-mediated epidermal delivery (PMED) or intramuscular (IM) electroporation (EP). Another technology with fewer logistical drawbacks is disposable syringe jet injection (DSJI) devices developed by PharmaJet, Inc. These needle-free jet injection systems are spring-powered and capable of delivering vaccines either IM or into the dermis (ID). Here, we evaluated the immunogenicity of our Venezuelan equine encephalitis virus (VEEV) DNA vaccine delivered by either the IM- or ID-DSJI devices in nonhuman primates. The protective efficacy was assessed following aerosol challenge. We found that a prime and single boost by either the IM or ID route resulted in humoral and cellular immune responses that provided significant protection against disease and viremia. Although the ID route utilized one-fifth the DNA dose used in the IM route of vaccination, and the measured humoral and cellular immune responses trended lower, the level of protection was high and performed as well as the IM route for several clinical endpoints.

Impact of Wearing on Filtration Performance of Electrostatic Filter Face Masks.

Certified disposable respirators afford important protection from hazardous aerosols but lose performance as they are worn. This study examines the effect of wear time on filtration efficiency. Disposable respirators were worn by CSIRO staff over a period of 4 weeks in early 2020. Participants wore the respirator masks for given times up to eight hours whilst working in laboratory/office environments. At that time COVID-19 precautions required staff to wear surgical (or other) masks and increase use of hand sanitizer from dispenser stations. Results obtained from a test group of ten individuals without health preconditions show an increasing number of masks failing with wear time, while the remainder continue to perform nearly unaffected for up to 8 h. Some masks were found to retain filtration performance better than others, possibly due to the type of challenge they were subjected to by the wearer. However, the rate and extent of decay are expected to differ between environments since there are many contributing factors and properties of the aerosol challenge cannot be controlled in a live trial. Penetration and variability increased during wear; the longer the wear time, the more deleterious to particle removal, particularly after approximately 2 h of wear. This behavior is captured in a descriptive statistical model based on results from a trial with this test group. The effectiveness of the masks in preventing the penetration of KCl particles was determined before and after wearing, with the analysis focusing on the most penetrating particles in a size range of 0.3–0.5 µm diameter where respirator masks are most vulnerable. The basic elements of the study, including the approach to filter testing and sample sanitization, are broadly applicable. Conclusions also have applicability to typical commercially available single-use respirator masks manufactured from melt blown polypropylene as they are reliant on the same physical principles for particle capture and electrostatic enhancement was comparable for the particle size range used for detection.

Murine model of steroid-resistant neutrophilic bronchial asthma as an attempt to simulate human pathology

Bronchial asthma (BA) is a heterogeneous chronic inflammatory disease of the airways. The majority of patients with mild to moderate BA develop Th2-biased eosinophilic pulmonary inflammation and respond well to corticosteroid treatment. However up to 10% of BA patients develop severe pathology, which is associated with neutrophilic inflammation and resistant to conventional corticosteroid therapy. Contrary to eosinophil-predominant airway inflammation neutrophilic BA is developed through Th1- and Th17-immune responses. However, the etiology of corticoid insensitive neutrophilic BA is still remains unclear. Therefore, in the current study we developed a mouse model of BA with predominant neutrophilic rather than eosinophilic pulmonary inflammation. BALB/c mice were immunized with the mixture of the ovalbumin allergen and Freund's adjuvant, followed by aerosol challenge with the same allergen mixed with E. coli lipopolysaccharide. As a result, mice developed the main BA manifestations: production of allergen specific IgE, development of airway hyperreactivity, airway remodeling and pulmonary neutrophilic inflammation. Moreover, this pathology developed through Th1- and Th17-dependent mechanisms and mice with induced neutrophilic BA phenotype responded poorly to dexamethasone treatment, that coincide to clinical observations. The established mouse model could be useful both for studying the pathogenesis and for testing novel approaches to control neutrophilic BA.

Characterisation of Particle Size and Viability of SARS-CoV-2 Aerosols from a Range of Nebuliser Types Using a Novel Sampling Technique.

Little is understood about the impact of nebulisation on the viability of SARS-CoV-2. In this study, a range of nebulisers with differing methods of aerosol generation were evaluated to determine SARS-CoV-2 viability following aerosolization. The aerosol particle size distribution was assessed using an aerosol particle sizer (APS) and SARS-CoV-2 viability was determined after collection into liquid media using All-Glass Impingers (AGI). Viable particles of SARS-CoV-2 were further characterised using the Collison 6-jet nebuliser in conjunction with novel sample techniques in an Andersen size-fractioning sampler to predict lung deposition profiles. Results demonstrate that all the tested nebulisers can generate stable, polydisperse aerosols (Geometric standard deviation (GSD) circa 1.8) in the respirable range (1.2 to 2.2 µm). Viable fractions (VF, units PFU/particle, the virus viability as a function of total particles produced) were circa 5 × 10−3. VF and spray factors were not significantly affected by relative humidity, within this system where aerosols were in the spray tube an extremely short time. The novel Andersen sample collection methods successfully captured viable virus particles across all sizes; with most particle sizes below 3.3 µm. Particle sizes, in MMAD (Mass Median Aerodynamic Diameters), were calculated from linear regression of log10-log10 transformed cumulative PFU data, and calculated MMADs accorded well with APS measurements and did not differ across collection method types. These data will be vital in informing animal aerosol challenge models, and infection prevention and control policies.

Neutralizing antibodies protect mice against Venezuelan equine encephalitis virus aerosol challenge.

Venezuelan equine encephalitis virus (VEEV) remains a risk for epidemic emergence or use as an aerosolized bioweapon. To develop possible countermeasures, we isolated VEEV-specific neutralizing monoclonal antibodies (mAbs) from mice and a human immunized with attenuated VEEV strains. Functional assays and epitope mapping established that potently inhibitory anti-VEEV mAbs bind distinct antigenic sites in the A or B domains of the E2 glycoprotein and block multiple steps in the viral replication cycle including attachment, fusion, and egress. A 3.2-Å cryo-electron microscopy reconstruction of VEEV virus-like particles bound by a human Fab suggests that antibody engagement of the B domain may result in cross-linking of neighboring spikes to prevent conformational requirements for viral fusion. Prophylaxis or postexposure therapy with these mAbs protected mice against lethal aerosol challenge with VEEV. Our study defines functional and structural mechanisms of mAb protection and suggests that multiple antigenic determinants on VEEV can be targeted for vaccine or antibody-based therapeutic development.

An In Vivo Model of Separate M. tuberculosis Phagocytosis by Neutrophils and Macrophages: Gene Expression Profiles in the Parasite and Disease Development in the Mouse Host.

The role of neutrophils in tuberculosis infection remains less well studied compared to that of the CD4+ T-lymphocytes and macrophages. Thus, alterations in Mycobacterium tuberculosis transcription profile following phagocytosis by neutrophils and how these shifts differ from those caused by macrophage phagocytosis remain unknown. We developed a mouse model that allows obtaining large amounts of either neutrophils or macrophages infected in vivo with M. tuberculosis for mycobacteria isolation in quantities sufficient for the whole genome RNA sequencing and aerosol challenge of mice. Here, we present: (i) the differences in transcription profiles of mycobacteria isolated from liquid cultures, neutrophils and macrophages infected in vivo; (ii) phenotypes of infection and lung inflammation (life span, colony forming units (CFU) counts in organs, lung pathology, immune cells infiltration and cytokine production) in genetically TB-susceptible mice identically infected via respiratory tract with neutrophil-passaged (NP), macrophage-passaged (MP) and conventionally prepared (CP) mycobacteria. Two-hour residence within neutrophils caused transcriptome shifts consistent with mycobacterial transition to dormancy and diminished their capacity to attract immune cells to infected lung tissue. Mycobacterial multiplication in organs did not depend upon pre-phagocytosis, whilst survival time of infected mice was shorter in the group infected with NP bacilli. We also discuss possible reasons for these phenotypic divergences.

The development of broad-spectrum antiviral medical countermeasures to treat viral hemorrhagic fevers caused by natural or weaponized virus infections.

The Joint Program Executive Office for Chemical, Biological, Radiological, and Nuclear Defense (JPEO-CBRND) began development of a broad-spectrum antiviral countermeasure against deliberate use of high-consequence viral hemorrhagic fevers (VHFs) in 2016. The effort featured comprehensive preclinical research, including laboratory testing and rapid advancement of lead molecules into nonhuman primate (NHP) models of Ebola virus disease (EVD). Remdesivir (GS-5734, Veklury, Gilead Sciences) was the first small molecule therapeutic to successfully emerge from this effort. Remdesivir is an inhibitor of RNA-dependent RNA polymerase, a viral enzyme that is essential for viral replication. Its robust potency and broad-spectrum antiviral activity against certain RNA viruses including Ebola virus and Severe Acute Respiratory Syndrome Coronavirus 2 (SARS-CoV-2) led to its clinical evaluation in randomized, controlled trials (RCTs) in human patients during the 2018 EVD outbreak in the Democratic Republic of the Congo (DRC) and the ongoing Coronavirus Disease 2019 (COVID-19) pandemic today. Remdesivir was recently approved by the US Food and Drug Administration (FDA) for the treatment of COVID-19 requiring hospitalization. Substantial gaps remain in improving the outcomes of acute viral infections for patients afflicted with both EVD and COVID-19, including how to increase therapeutic breadth and strategies for the prevention and treatment of severe disease. Combination therapy that joins therapeutics with complimentary mechanisms of action appear promising, both preclinically and in RCTs. Importantly, significant programmatic challenges endure pertaining to a clear drug and biological product development pathway for therapeutics targeting biodefense and emerging pathogens when human efficacy studies are not ethical or feasible. For example, remdesivir’s clinical development was facilitated by outbreaks of Ebola and SARS-CoV-2; as such, the development pathway employed for remdesivir is likely to be the exception rather than the rule.The current regulatory licensure pathway for therapeutics targeting rare, weaponizable VHF agents is likely to require use of FDA’s established Animal Rule (21 CFR 314.600–650 for drugs; 21 CFR 601.90–95 for biologics). The FDA may grant marketing approval based on adequate and well-controlled animal efficacy studies when the results of those studies establish that the drug is safe and likely to produce clinical benefit in humans. In practical terms, this is anticipated to include a series of rigorous, well-documented, animal challenge studies, to include aerosol challenge, combined with human safety data. While small clinical studies against naturally occurring, high-consequence pathogens are typically performed where possible, approval for the therapeutics currently under development against biodefense pathogens will likely require the Animal Rule pathway utilizing studies in NHPs. We review the development of remdesivir as illustrative of the effort that will be needed to field future therapeutics against highly lethal, infectious agents.

Replication-Deficient Lymphocytic Choriomeningitis Virus-Vectored Vaccine Candidate for the Induction of T Cell Immunity against Mycobacterium tuberculosis.

Mycobacterium tuberculosis (Mtb) represents a major burden to global health, and refined vaccines are needed. Replication-deficient lymphocytic choriomeningitis virus (rLCMV)-based vaccine vectors against cytomegalovirus have proven safe for human use and elicited robust T cell responses in a large proportion of vaccine recipients. Here, we developed an rLCMV vaccine expressing the Mtb antigens TB10.4 and Ag85B. In mice, rLCMV elicited high frequencies of polyfunctional Mtb-specific CD8 and CD4 T cell responses. CD8 but not CD4 T cells were efficiently boosted upon vector re-vaccination. High-frequency responses were also observed in neonatally vaccinated mice, and co-administration of rLCMV with Expanded Program of Immunization (EPI) vaccines did not result in substantial reciprocal interference. Importantly, rLCMV immunization significantly reduced the lung Mtb burden upon aerosol challenge, resulting in improved lung ventilation. Protection was associated with increased CD8 T cell recruitment but reduced CD4 T cell infiltration upon Mtb challenge. When combining rLCMV with BCG vaccination in a heterologous prime-boost regimen, responses to the rLCMV-encoded Mtb antigens were further augmented, but protection was not significantly different from rLCMV or BCG vaccination alone. This work suggests that rLCMV may show utility for neonatal and/or adult vaccination efforts against pulmonary tuberculosis.

A Simple Method for Aerosol Transport Efficiency Tests in Sampling Tubes

To obtain representative data, particle loss in sampling tubes must be minimal; otherwise, the magnitude of the losses must be known so it can be corrected. Since particle loss in sample tubes occurs through various mechanisms and depends on particle size, airflow velocity, and Reynolds number, there is no simple method to predict the particle loss of multitudinous configurations of sampling tubes. This study aims to present a simple method for experimentally determining particle loss as a function of particle sizes. Moreover, the applicability of existing models is verified experimentally. An ultrasonic atomizing nozzle was used to generate micrometer-sized polydispersed particles as challenge aerosols. Following charge neutralization, the particle size distribution and number concentration upstream and downstream of the sampling tubes are measured by an Aerodynamic Particle Sizer. The particle loss in the sampling tubes with inner diameters of 4.5, 7.7, and 10 mm are measured at various values of Re (500~5000) and the tube orientations (horizontal and vertical). Both the horizontal and vertical tubes have the lowest loss at a Re of approximately 2100. Gravitational settling and turbulent-induced inertial impaction are the main deposition mechanisms in aerosol transport for particles large than 1 μm. Gravity plays a significant role when the Re is less than 5000, then its dominant position is gradually replaced by turbulence with the Re continuing to increase. Further, the transport efficiency increased with increasing tube diameter. Consequently, each sampling tube needs to be tested according to the methods mentioned in this study to fully grasp the transport efficiency of particles through the sampling tube.

Intranasal curcumin and sodium butyrate modulates airway inflammation and fibrosis via HDAC inhibition in allergic asthma.

In present study, ovalbumin (OVA) was used to sensitize Balb/c mice and later exposed to (1%) OVA aerosol. Curcumin (5mg/kg) and Sodium butyrate (50mg/kg) was administered through intranasal route an hour before OVA aerosol challenge. Efficacies of SoB and Curcumin as HDAC inhibitors were evaluated in terms of different inflammatory parameters like, total inflammatory cell count, reactive oxygen species (ROS), histamine release, nitric oxide and serum IgE levels. Inflammatory cell recruitment was analyzed by H&E staining and structural alterations were revealed by Masson's Trichrome staining of lung sections. Enhanced Matrix Metalloproteinase-2 and 9 (MMP-2 and MMP-9) activities were observed in bronchoalveolar lavage fluid (BALF) of asthmatic mice by gelatin zymography which was inhibited in both treatment groups. Protein expressions of MMP-9, HDAC 1, H3acK9 and NF-kB p65 were modulated in intranasal curcumin and SoB pretreatment groups. This is the first report where intranasal curcumin inhibited asthma severity via affecting HDAC 1 (H3acK9) leading to NF-kB suppression in mouse model of allergic asthma.

Immunogenicity of a Candidate DTacP-sIPV Combined Vaccine and Its Protection Efficacy against Pertussis in a Rhesus Macaque Model.

The research and development of a pertussis-combined vaccine using a novel inactivated poliovirus vaccine made from the Sabin strain (sIPV) is of great significance in the polio eradication project and to address the recent resurge in pertussis. In the present study, we compared the immunogenicity and efficacy of a candidate DTacP-sIPV with those of a commercial DTacP-wIPV/Hib, DTaP/Hib, pertussis vaccine, and aluminum hydroxide adjuvant control in the rhesus macaque model with a 0-, 1-, and 2-month immunization schedule. At day 28 after the third dose, rhesus macaques were challenged with aerosol pertussis and the antibody and cellular response together with pertussis clinical symptoms were determined. The production of anti-PT, anti-PRN, anti-FHA, anti-DT, anti-TT, and polio type I, II, III antibodies was induced by the candidate DTacP-sIPV, which was as potent as commercial vaccines. In comparison with the control group that showed typical pertussis symptoms of humans after the aerosol challenge, the DTacP-sIPV group did not exhibit obvious clinical pertussis symptoms and had higher neutralization titers of anti-PT, anti-PRN, and anti-FHA. In conclusion, the DTacP-sIPV vaccine was able to induce immunity in rhesus macaques to prevent pertussis infections after immunization. The developed vaccine was as efficient as other commercial vaccines.

Novel Transcriptional and Translational Biomarkers of Tularemia Vaccine Efficacy in a Mouse Inhalation Model: Proof of Concept.

Francisella tularensis subspecies tularensis (Ftt) is extremely virulent for humans when inhaled as a small particle aerosol (<5 µm). Inhalation of ≥20 viable bacteria is sufficient to initiate infection with a mortality rate ≥30%. Consequently, in the past, Ftt became a primary candidate for biological weapons development. To counter this threat, the USA developed a live vaccine strain (LVS), that showed efficacy in humans against inhalation of virulent Ftt. However, the breakthrough dose was fairly low, and protection waned with time. These weaknesses triggered extensive research for better vaccine candidates. Previously, we showed that deleting the clpB gene from virulent Ftt strain, SCHU S4, resulted in a mutant that was significantly less virulent than LVS for mice, yet better protected them from aerosol challenge with wild-type SCHU S4. To date, comprehensive searches for correlates of protection for SCHU S4 ΔclpB among molecules that are critical signatures of cell-mediated immunity, have yielded little reward. In this study we used transcriptomics analysis to expand the potential range of molecular correlates of protection induced by vaccination with SCHU S4 ΔclpB beyond the usual candidates. The results provide proof-of-concept that unusual host responses to vaccination can potentially serve as novel efficacy biomarkers for new tularemia vaccines.

The O-Ag Antibody Response to Francisella Is Distinct in Rodents and Higher Animals and Can Serve as a Correlate of Protection.

Identifying correlates of protection (COPs) for vaccines against lethal human (Hu) pathogens, such as Francisella tularensis (Ft), is problematic, as clinical trials are currently untenable and the relevance of various animal models can be controversial. Previously, Hu trials with the live vaccine strain (LVS) demonstrated ~80% vaccine efficacy against low dose (~50 CFU) challenge; however, protection deteriorated with higher challenge doses (~2000 CFU of SchuS4) and no COPs were established. Here, we describe our efforts to develop clinically relevant, humoral COPs applicable to high-dose, aerosol challenge with S4. First, our serosurvey of LVS-vaccinated Hu and animals revealed that rabbits (Rbs), but not rodents, recapitulate the Hu O-Ag dependent Ab response to Ft. Next, we assayed Rbs immunized with distinct S4-based vaccine candidates (S4ΔclpB, S4ΔguaBA, and S4ΔaroD) and found that, across multiple vaccines, the %O-Ag dep Ab trended with vaccine efficacy. Among S4ΔguaBA-vaccinated Rbs, the %O-Ag dep Ab in pre-challenge plasma was significantly higher in survivors than in non-survivors; a cut-off of >70% O-Ag dep Ab predicted survival with high sensitivity and specificity. Finally, we found this COP in 80% of LVS-vaccinated Hu plasma samples as expected for a vaccine with 80% Hu efficacy. Collectively, the %O-Ag dep Ab response is a bona fide COP for S4ΔguaBA-vaccinated Rb and holds significant promise for guiding vaccine trials with higher animals.

A Nucleic Acid-Based Orthopoxvirus Vaccine Targeting the Vaccinia Virus L1, A27, B5, and A33 Proteins Protects Rabbits against Lethal Rabbitpox Virus Aerosol Challenge.

In the age of COVID, nucleic acid vaccines have garnered much attention, at least in part, because of the simplicity of construction, production, and flexibility to adjust and adapt to an evolving outbreak. Orthopoxviruses remain a threat on multiple fronts, especially as emerging zoonoses. In response, we developed a DNA vaccine, termed 4pox, that protected nonhuman primates against monkeypox virus (MPXV)-induced severe disease. Here, we examined the protective efficacy of the 4pox DNA vaccine delivered by intramuscular (i.m.) electroporation (EP) in rabbits challenged with aerosolized rabbitpox virus (RPXV), a model that recapitulates the respiratory route of exposure and low dose associated with natural smallpox exposure in humans. We found that 4pox-vaccinated rabbits developed immunogen-specific antibodies, including neutralizing antibodies, and did not develop any clinical disease, indicating protection against aerosolized RPXV. In contrast, unvaccinated animals developed significant signs of disease, including lesions, and were euthanized. These findings demonstrate that an unformulated, nonadjuvanted DNA vaccine delivered i.m. can protect against an aerosol exposure. IMPORTANCE The eradication of smallpox and subsequent cessation of vaccination have left a majority of the population susceptible to variola virus or other emerging poxviruses. This is exemplified by human monkeypox, as evidenced by the increase in reported endemic and imported cases over the past decades. Therefore, a malleable vaccine technology that can be mass produced and does not require complex conditions for distribution and storage is sought. Herein, we show that a DNA vaccine, in the absence of a specialized formulation or adjuvant, can protect against a lethal aerosol insult of rabbitpox virus.

Protective effects of Surfacen® in allergen-induced asthma mice model

Airway obstruction with increased airway resistance in asthma, commonly caused by smooth muscle constriction, mucosal edema and fluid secretion into the airway lumen, may partly be due to a poor function of pulmonary surfactant. Surfacen®, a clinical pulmonary surfactant, has anti-inflammatory action, but its effect on asthma has not been studied. This work aimed to evaluate the effect of Surfacen® in a murine allergen-induced acute asthma model, using house dust mite allergens. In a therapeutic experimental setting, mice were first sensitized by being administered with two doses (sc) of Dermatophagoides siboney allergen in aluminum hydroxide followed by one intranasal administration of the allergen. Then, sensitized mice were administered with aerosol of hypertonic 3% NaCl, Salbutamol 0.15 mg/kg, or Surfacen® 16 mg in a whole-body chamber on days 22, 23, and 24. Further, mice were subjected to aerosol allergen challenge on day 25. Surfacen® showed bronchial dilation and inhibition of Th2 inflammation (lower levels of IL-5 and IL-13 in broncoalveolar lavage) which increased IFN-γ and unchanged IL-10 in BAL. Moreover, Sufacen® administration was associated with a marked inhibition of the serum specific IgE burst upon allergen exposure, as well as, IgG2a antibody increase, suggesting potential anti-allergy effects with inclination towards Th1. These results support also the effectiveness of the aerosol administration method to deliver the drug into lungs. Surfacen® induced a favorable pharmacological effect, with a bronchodilator outcome comparable to Salbutamol, consistent with its action as a lung surfactant, and with an advantageous anti-inflammatory and anti-allergic immunomodulatory effect.

Cross-Strain Neutralizing and Protective Monoclonal Antibodies against EEEV or WEEV.

The three encephalitic alphaviruses, namely, the Venezuelan, eastern, and western equine encephalitis viruses (VEEV, EEEV, and WEEV), are classified by the Centers for Disease Control and Prevention (CDC) as biothreat agents. Currently, no licensed medical countermeasures (MCMs) against these viruses are available for humans. Neutralizing antibodies (NAbs) are fast-acting and highly effective MCMs for use in both pre- and post-exposure settings against biothreat agents. While significant work has been done to identify anti-VEEV NAbs, less has been done to identify NAbs against EEEV and WEEV. In order to develop anti-EEEV or -WEEV NAbs, mice were immunized using complementary strategies with a variety of different EEEV or WEEV immunogens to maximize the generation of NAbs to each of these viruses. Of the hybridomas generated, three anti-EEEV and seven anti-WEEV monoclonal antibodies were identified with in vitro neutralization activity. The most potent neutralizers (two anti-EEEV NAbs and three anti-WEEV NAbs) were further evaluated for neutralization activity against additional strains of EEEV, a single strain of Madariaga virus (formerly South American EEEV), or WEEV. Of these, G1-2-H4 and G1-4-C3 neutralized all three EEEV strains and the Madariaga virus strain, whereas G8-2-H9 and 12 WA neutralized six out of eight WEEV strains. To determine the protective efficacy of these NAbs, the five most potent neutralizers were evaluated in respective mouse aerosol challenge models. All five NAbs demonstrated various levels of protection when administered at doses of 2.5 mg/kg or 10 mg/kg 24 h before the respective virus exposure via the aerosol route. Of these, anti-EEEV NAb G1-4-C3 and anti-WEEV NAb 8C2 provided 100% protection at both doses and all surviving mice were free of clinical signs throughout the study. Additionally, no virus was detected in the brain 14 days post virus exposure. Taken together, efficacious NAbs were developed that demonstrate the potential for the development of cross-strain antibody-based MCMs against EEEV and WEEV infections.