Suspension Concentrate crop protection formulation design and performance for low spray volume and UAS spray application.

Abstract

Unmanned aerial systems (UAS) are providing interesting disruptive solutions for spray application of crop protection products with very-low spray volumes (VLV) down to 8 L/ha that offer improved sustainability through reduced water volumes and reduced soil compaction. However, the efficacy of products can be reduced by the significantly lower crop/plant spray coverage and formulation designs that can compensate for this are highly important here. Suspension Concentrate (SC) formulations designed for VLV use containing and delivering low dose rates (g/ha) of organosilicone alkoxylate high-spreading surfactants were found to result in leaf coverage of VLVs comparable to those observed at higher spray volumes. High spreading was observed on textured leaf surfaces containing sub-micron sized epicuticular wax crystals. Greenhouse fungal disease studies showed enhanced efficacy with these SC formulations compared to standard SC formulations without these additives and maintained the observed increase in efficacy when applied at VLV. Alternatively, SC formulations without high spreading formulants but containing uptake promoting nonionic surfactants showed enhanced cuticle penetration through isolated cuticles at VLV in comparison to higher spray volumes, with coffee-ring spray deposit microstructures present at VLVs. Similarly, greenhouse studies showed enhanced efficacy that was maintained at VLV relative to SCs without these additives. At VLVs, SC formulations applied at relatively low dose rates (g/ha) of formulants (adjuvants) enhancing spreading on the leaf surface and/or uptake of the active ingredient(s) maintained good spreading, uptake and biological efficacy in greenhouse studies overcoming the coverage limitations of SC formulations without these additives. This result is unexpected considering the low dose rate of adjuvants used. © 2023 Bayer AG. Pest Management Science published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.