Whey Fraction Research Articles

Aqueous fractionation of mucilage and protein from Camelina sativa seeds and defatted meal

Camelina protein and mucilage are being investigated as coproducts in addition to the oil. It has been reported that the significant amount of mucilage (10–11 %) in the seed coat interferes with the recovery of the protein. In this work, two schemes of producing mucilage and protein fractions from camelina seeds were evaluated and proximate composition of each process stream was analyzed. In the sequential extraction process, mucilage was first separated from hydrated seeds, then oil from degummed seeds, and lastly the protein from the defatted degummed meal. In the other process, aqueous fraction rich in protein and carbohydrates were extracted simultaneously from defatted meal. Proteins were obtained by alkali solubilization and acid precipitation method. Sequential extraction produced a mucilage fraction with 15.2 % protein content and a protein isolate (90.2 % crude protein). Simultaneous aqueous extraction of the defatted meal produced a mucilage fraction with 48.9–50.2 % protein content and a protein concentrate (67.4 and 75.6 % crude protein). The whey obtained had similar protein and soluble carbohydrates contents of 24.4–26.4 % and 56.5–58.2 %, respectively. The difference in composition of the mucilage, protein and whey fractions produced by each process will determine the applications of these products.

Effect of ultra-high pressure homogenization on the antirotaviral activity of bovine milk whey

In the present study, ultra-high pressure homogenization (UHPH, 100–250 MPa) was applied on bovine whey. The ability of UHPH-treated whey to neutralize the bovine rotavirus strain WC3 was evaluated in vitro using a model of human intestinal epithelium. Results showed that whey homogenized at 100 and 200 MPa inhibited the rotavirus infection in a dose-response way, exhibiting >95% neutralization at 1.5 mg mL−1 protein concentration. However, after homogenization of whey at 250 MPa, a clear neutralization pattern could not be observed. This could be attributed to aggregation and/or denaturation of some bioactive proteins, as it has been evidenced in the electrophoretic profile of that sample. Interestingly, the fat fraction obtained from all UHPH-treated wheys, showed almost complete neutralization at 1 mg mL−1 protein concentration. Therefore, whey fractions could be used as functional ingredients in novel non-thermal processed products for the control of viral infections. Industrial relevanceThis study provides useful information to increase the commercial value of sweet, skimmed whey as a functional ingredient and its recognition as a natural source of antivirals. The use of emerging processing technologies, such as UHPH, could favor the preservation of certain bioactivity within the dairy by-product.

Development and validation of a targeted mass spectrometry method for the quantification of milk protein allergens in multiple complex food matrices using matrix-independent calibration

Quantitative detection of food allergens is crucial in assessing the risk of allergic responses in susceptible individuals and ensuring regulatory compliance. Targeted mass spectrometry methods provide an opportunity to analyze allergens from complex, processed food matrices. However, probable interferences of diverse food matrices mandates preparation of matrix-matched calibration curves, challenging adaptation of methods into multiple matrices. In this study, we have developed a novel matrix-independent calibration strategy employing exogenous carrier proteins as background and demonstrated its adaptability in quantification of milk from multiple food matrices at concentrations relevant for risk assessment applications. Peptides representing casein or whey fractions of milk were detectable from concentrations as low as 1 ppm nonfat dry milk (NFDM) in baked cookie matrix at 46–99% accuracy, 0.5 ppm total milk protein (TMP) in pasteurized beverages at 94–138% accuracy, and 1 ppm casein in chocolate at 35–51% accuracy. Quantitative estimations of milk from matrix-independent calibration curves in the background of egg white powder as exogenous carrier were comparable to those from a matrix-matched calibration curve, and the quantitative precision was within 30% CV across the inter-day replicates. The sensitivity, accuracy, and precision of this matrix-independent approach ensure robustness of the method for high throughput food allergen analysis as required in routine testing labs.

Comparison of glycation and glycosylation level between bovine milk-based and goat milk-based infant formula through label-free proteomics techniques

Heat treatment is unavoidable in the processing of infant formula; however, heat treatment causes the proteins to undergo Maillard reaction and form glycation products, which can negatively affect the nutrition and function of the protein. At the same time, glycosylation is a broad post-translational protein modification that is important in a variety of biological processes. However, glycated proteins as well as N-glycoprotein components in infant formula have not been well characterized. Here, a comprehensive comparative analysis of the glycated proteome as well as the N-glycosylated proteome was conducted in both bovine milk-based (BF) and goat milk-based (GF) infant formula. In total, 918 whey proteins were identified from the whey fraction, including 200 glycated proteins and 219 glycosylated proteins. Furthermore, 33 N-glycosylated proteins containing 101 N-glycosylation sites and 64 glycosylated peptides derived from 30 proteins were significantly different (p < 0.05) between BF and GF. Most of the significantly different proteins are associated with innate immunity as well as defense responses. With respect to the differences between BF and GF, ɑ-lactalbumin (LALBA) had higher glycation level in BF than GF; whereas β-lactoglobulin (LGB) had higher glycation level in GF than BF. For glycosylation level, transferin (TF) was highly glycosylated in GF than BF; while serum albumin (ALB) was highly glycosylated in BF than GF. Our results elucidated the proteome, glycated proteome, N-glycosylated proteome in bovine milk-based and goat milk-based infant formulas, which may be useful to researchers in related fields and provide guidance on the improvement of processing technology for infant formula.

Potential Prebiotic Properties of Whey Protein and Glycomacropeptide in Gut Microbiome.

Proteins in whey have prebiotic and antimicrobial properties. Whey protein comprises numerous bioactive proteins and peptides, including glycomacropeptide (GMP), a hydrophilic casein peptide that separates with the whey fraction during cheese making. GMP has traditionally been used as a protein source for individuals with phenylketonuria and also has prebiotic (supporting the growth of Bifidobacterium and lactic acid bacteria) and antimicrobial activities. GMP supplementation may help positively modulate the gut microbiome, help treat dysbiosis-related gastrointestinal disorders and improve overall health in consumers.

Comparative proteomics analysis of whey fractions from Korean mother's milk with different gender babies in the northeast China

Infant's gender may have influences on composition of breastmilk. This study investigated differences in whey fractions from milk of mothers (n = 12, 3 biological repeats) with male or female babies using a 4D label‐free proteomics. Altogether, 1572 proteins were identified and 42 of them were differentially expressed. Majority of the different proteins are located in extracellular position and possessed domain of immunoglobulin V‐set. The screened proteins were observed to contribute greatly to functions of cellular process, binding, and cell part; and pathways of immune system and immune disease. The findings may afford beneficial knowledge for understanding differences in breastmilk composition.

Effect of species on the distribution and oxidative stability of milk added of lead and cadmium

The aim of this study was to evaluate the effect of species on added lead (Pb) and cadmium (Cd) content in cow, buffalo, and goat milk and their distribution in fat, casein, and whey fractions. In addition, the oxidative stability of the milk was evaluated. Most of the Pb and Cd were recovered in the skimmed milk (96.74 and 94.21%, respectively). The distribution of Cd and Pb in casein and whey fractions, obtained by enzymatic coagulation, highlighted that they were mainly associated with casein (on average 94.77 and 90.54% of Pb and Cd, respectively). The species significantly affected the distribution of Cd and Pb in the casein and fat fractions (p < 0.01). In particular, Cd and Pb levels in fat fraction were the highest in the buffalo milk, whereas casein fraction was the highest in bovine milk. Furthermore, the presence of metals negatively influenced the oxidative stability of the milk and the species influenced its response. The results showed that in the presence of Cd and Pb, bovine milk increased the content of Malondialdehyde (MDA), advanced oxidation protein products (AOPP) and dithyrosines compared to other species. In addition, there was a significant decrease in the thiol content, highlighting a reduction in the antioxidant capacity of the contaminated milk.

Modern adapted infant formulas: problem status and prospects for solving

According to the World Health Organization report, in 2019 47 million children under 5 were wasted, of which 14.3 million were severely wasted. In most cases, the main reason for nutritional deficiencies in the world is a child’s diet low in calories, dietary protein deficiency and inferiority, as well as inadequate intake of vitamins and minerals. The article presents a modern literature review devoted to the main problems in creating adapted formulas for infants who are deprived of the opportunity of getting breastfeeding. Among the most pressing problems are: difficulties in bringing the total protein concentration in the formula to the breast milk level while keeping an adequate amino acid profile, the high risk of animal milk protein allergies in infants, unfulfilled hopes for the preventive effect of partially hydrolysed formulas in relation to the development of allergic diseases, as well as the high prevalence of functional gastrointestinal diseases in children who are formula-fed. At the same time, it was emphasized that the use of goat’s milk as a protein base for basic infant formulas may in the future help solve some of the above problems. The protein component of goat’s milk compares favourably with cow’s milk, and the amino acid composition helps reduce protein concentration in the finished formula enriched with whey fraction to the recommended level. The article stresses that there is a need to continue studies on the effectiveness and safety of adapted goat’s milk formulas in infants to give definite answers to the questions posed.

In vitro evaluation of the effect of yogurt acid whey fractions on iron bioavailability

A side effect of the raised consumption of Greek yogurt is the generation of massive amounts of yogurt acid whey (YAW). The dairy industry has tried several methods for handling these quantities, which constitute an environmental problem. Although the protein content of YAW is relatively low, given the huge amounts of produced YAW, the final protein amount in the produced YAW should not be underestimated. Taking into consideration the increased interest for bioactive peptides and the increased demand for dietary proteins, combined with protein and peptides content of YAW, efforts should be made toward reintroducing the latter in the food supply chain. In this context and in view of the prevalent dietary iron deficiency problem, the objective of the present study was the investigation of YAW fractions' effect on Fe bioavailability. With this purpose, an in vitro digest approach, following the INFOGEST protocol, was coupled with the Caco2 cell model. To evaluate whether YAW digest fractions exert positive, negative or neutral effect on Fe bioavailability, they were compared with the ones derived from milk, a well-studied food in this context. Milk and YAW showed the same effectiveness on both Fe bioavailability and the expression of relative genes (DCYTB, DMT1, FPN1, and HEPH). Focusing further on YAW fractions, by comparison with their blank digest control counterparts, it resulted that YAW 3- to 10-kDa digests fraction had a superior effect over the 0- to 3-kDa fraction on Fe-uptake, which was accompanied by a similar effect on the expression of Fe metabolism-related genes (DCYTB, FPN1, and HEPH). Finally, although the 3- to 10-kDa fraction of bovine YAW digests resulted in a nonsignificant increased Fe uptake, compared with the ovine and caprine YAW, the expression of DCYTB and FPN1 genes underlined this difference by showing a similar pattern with statistically significant higher expression of bovine compared with ovine and bovine compared with both ovine and caprine, respectively. The present study deals with the novel concept that YAW may contain factors affecting Fe bioavailability. The results show that it does not exert any negative effect and support the extensive investigation for specific peptides with positive effect as well as that YAW proteins should be further assessed on the prospect that they can be used in human nutrition.

Proteome Analysis of Human and Goat Colostrum: A closer look at whey fractions

Proteome Analysis of Human and Goat Colostrum: A closer look at whey fractions

E-beam irradiation of defatted liquid camel and cow milk fractions: Antiproliferative, antidiabetic and antioxidant activities

The aim of this work was to assess the suitability of electron beam (e-beam) irradiation (at 5, 10 and 20 kGy) to treat defatted liquid cow and camel milk and their whey and casein fractions. The different milk fractions were investigated for their antiproliferative, antidiabetic and antioxidant activities. Irradiated milk fractions did not indicate any cytotoxic effect on HEK293T cell line, except for sweet whey of cow milk treated at 20 kGy, the acid whey of camel milk treated at 5, 10 and 20 kGy and β casein of cow and camel milk treated at 10 and 20 kGy. The non-irradiated and irradiated whey fractions of camel milk and the irradiated β-casein of cow milk demonstrated anti-proliferative activity against A549 tumor cell line. Irradiated and non-irradiated whey fractions of camel and cow milk exhibited interesting inhibition percentage of α-amylase (varying from 73.24 ± 2.71% to 98.99 ± 0.84% for cow milk and from 64.68 ± 2.49% to 99.39 ± 0.17% for camel milk). Whey fractions seemed to be the most resistant to e-beam irradiation. Ebeam treatment (5–20 kGy) preserved or improved the DPPH radical scavenging activity of the majority of cow and camel milk fractions, ranging from 6.27 ± 0.74% to 59.75 ± 0.84%. Industrial relevanceThe present work highlighted the suitability of e-beam irradiation as safe and friendly treatment for the preservation of cow and camel milk and corresponding whey and casein fractions. E-beam treatment at 10 kGy seems to be effective treatment for whey of camel and cow milk, preserving or enhancing the antiproliferative, antioxidant and antidiabetic activities. Ebeam treatment at 5–10 kGy is suggested to be an emergent food preservation technology with the ability of preservation or promotion of milk bioactivity.

Evaluation of the contents and ratios of five fractionated proteins to elucidate the protein composition in soybean seeds

AbstractSelecting suitable soybean cultivars is important for food processing and exploring their endowment with desirable physiological functions. We applied the fractionation method previously established to compare soy protein composition among cultivars to promote such a selection. More than 95% of the proteins in soybean cotyledons were extracted from 13 soybean cultivars using a high‐concentration salt solution. The extracted proteins were fractionated into five fractions, namely oil body‐associated protein (OBAP), polar lipid‐associated protein (PLAP), globulins (11S and 7S), and whey by centrifugation after tuning the solubility behavior of the proteins with various solutions. Protein species in each fraction were analyzed by SDS‐PAGE. Protein content in the total extract and five fractions was quantified to characterize the protein composition of soybean cultivars. The correlation between the protein content of each fraction and the total protein in cotyledon was investigated. A strong positive correlation was found only for the 11S fraction (r = 0.82), followed by a positive correlation in the 7S fraction (r = 0.65). Thus, we surmised that the increased protein content in soybean was due to increased globulin content. Furthermore, the calculation of the average ratio of protein content in each fraction indicated the globulin fraction (7S and 11S) to be 52%, the lipophilic protein fraction (OBAP and PLAP) to be 33%, and the whey fraction to be 13%. The preparation method employed in this study is a promising tool for efficiently comparing the protein composition of soybean cultivars to evaluate the potential use of cultivars for food production.

Antimicrobial Activity of Milk Whey in Different Mammals.

Antimicrobial activity of milk whey in different mammals against Candida albicans yeast cells was studied by a spectrophotometric method. The activity increased in the order goat→horse→camel→cow→human→mouse. The level of whey activity in mice was higher by 3 and 10 times than in humans and goats, respectively. Similar changes were noted for activity of the whey fraction <100 kDa containing a complex of antimicrobial polypeptides, and there was a direct correlation between these two parameters (r=0.881; p<0.05). The total activity of whey had a high degree of correlation with the content of serum albumin (r=0.992); in mice, the level of serum albumin in the milk whey was close to that in blood serum. Interspecific differences between the activity of whey in mammals may be associated with qualitative and quantitative variability of the antimicrobial polypeptide composition, as well as their synergistic or antagonistic interaction with each other.

Umjetno mlijeko za novorođenu siročad divljih životinja

Milk is a very complex nutrient and differs significantly between species. Monotreme and Marsupial milk contains only trace amounts of lactose, whereas in Eutherian species, lactose is the predominant saccharide. Within the Eutheria, the composition varies from 8.5% in Indian rhinoceros to 63.8% in Grey seal in concentration; from 0.3% in Indian rhinoceros to 9.3% in elephants in total fat; from 1.2% in Indian rhinoceros to 12.8% in Fin whale in total protein; and finally from 0.8% in Great panda to 6.5% in Indian rhinoceros in lactose. Milk components change during lactation and, especially in Marsupials, this should be considered in artificial feeding. Other factors to be taken into account are the amino acid panel, whey and casein fractions, iron and immunological components. In wildlife nursing, we often come across orphaned neonates that require artificial feeding. However, there are no specific formulas for each wildlife baby. The aim of this review is to compare which artificial milk replacer is best suited for selected species of wildlife neonates.

Use of milk proteins as biomarkers of changes in the rumen metaproteome of Holstein cows fed low-fiber, high-starch diets

Dietary levels of undegraded neutral detergent fiber (uNDF240) and rumen-fermentable starch (RFS) can affect the rumen microbiome and milk composition. The objective of the study is to investigate the use of milk proteins as biomarkers of rumen microbial activity through a comparative evaluation of the rumen microbial and milk protein profiles produced by Holstein cows fed diets with varying contents of physically effective uNDF240 (peuNDF240) and RFS. Eight ruminally cannulated lactating Holstein cows were included in a larger study as part of a 4 × 4 Latin square design with 4 28-d periods to assess 4 diets varying in peuNDF240 and RFS content. For this experiment, cows received one of 2 dietary treatments: (1) low-peuNDF240, high-RFS (LNHR) diet or (2) high-peuNDF240, low-RFS (HNLR) diet. Within each period, rumen fluid samples were collected from each cow on d 26 (1400 h) and d 27 (0600 h and 1000 h), and milk samples were collected from each cow on d 25 (2030 h), d 26 (0430 h, 1230 h, and 2030 h), and d 27 (0430 h and 1230 h). Microbial proteins were isolated from each rumen fluid sample. For milk samples, milk proteins were fractionated, and the whey fraction was subsequently isolated. Isolated proteins within each rumen fluid or milk sample were isobarically labeled and analyzed by liquid chromatography-tandem mass spectrometry. Product ion spectra acquired from rumen fluid samples were searched using SEQUEST against 71 composite databases. In contrast, product ion spectra acquired from milk samples were searched against the Bos taurus database. Data were analyzed using the PROC MIXED procedure in SAS 9.4 to assess the effect of diet and time of sampling. To increase stringency, the false discovery rate-adjusted P-value (PFDR) was also calculated to account for multiple comparisons. Using the mixed procedure, a total of 129 rumen microbial proteins were quantified across 24 searched microbial species. Of these, the abundance of 14 proteins across 9 microbial species was affected due to diet and diet × time interaction, including 7 proteins associated with energetics pathways. Among the 159 quantified milk proteins, the abundance of 21 proteins was affected due to the diet and diet × time interaction. The abundance of 19 of these milk proteins was affected due to diet × time interactions. Of these, 16 proteins had the disparity across diets at the 0430 h sampling time, including proteins involved in host defense, nutrient synthesis, and transportation, suggesting that biological shifts resulting from diet-induced rumen changes are not diurnally uniform across milkings. The concentration of lipoprotein lipase (LPL) was statistically higher in the milk from the cows fed with the LNHR diet, which was numerically confirmed with an ELISA. Further, as determined by ELISA, the LPL concentration was significantly higher in the milk from the cows fed with the LNHR diet at 0430 h sampling point, suggesting that LPL concentration may indicate dietary carbohydrate-induced ruminal changes. The results of this study suggest that diet-induced rumen changes can be reflected in milk in a diurnal pattern, further highlighting the need to consider sampling time points for using milk proteins as a representative biomarker of rumen microbial activity.

Differential behavior of Lactobacillus helveticus B1929 and ATCC 15009 on the hydrolysis and angiotensin-I-converting enzyme inhibition activity of fermented ultra-high-temperature milk and nonfat dried milk powder

Consumers' growing interest in fermented dairy foods necessitates research on a wide array of lactic acid bacterial strains to be explored and used. This study aimed to investigate the differences in the proteolytic capacity of Lactobacillus helveticus strains B1929 and ATCC 15009 on the fermentation of commercial ultra-pasteurized (UHT) skim milk and reconstituted nonfat dried milk powder (at a comparable protein concentration, 4%). The antihypertensive properties of the fermented milk, measured by angiotensin-I-converting enzyme inhibitory (ACE-I) activity, were compared. The B1929 strain lowered the pH of the milk to 4.13 ± 0.09 at 37°C after 24 h, whereas ATCC 15009 needed 48 h to drop the pH to 4.70 ± 0.18 at 37°C. Two soluble protein fractions, one (CFS1) obtained after fermentation (acidic conditions) and the other (CFS2) after the neutralization (pH 6.70) of the pellet from CFS1 separation, were analyzed for d-/l-lactic acid production, protein concentration, the degree of protein hydrolysis, and ACE-I activity. The CFS1 fractions, dominated by whey proteins, demonstrated a greater degree of protein hydrolysis (7.9%) than CFS2. On the other hand, CFS2, mainly casein proteins, showed a higher level of ACE-I activity (33.8%) than CFS1. Significant differences were also found in the d- and l-lactic acid produced by the UHT milk between the 2 strains. These results attest that milk casein proteins possessed more detectable ACE-I activity than whey fractions, even without a measurable degree of hydrolysis. Findings from this study suggest that careful consideration must be given when selecting the bacterial strain and milk substrate for fermentation.

Взрывоопасность аэровзвеси сухой молочной сыворотки

Introduction. In many countries, regulations consider combustible dust with a particle size of more than 500 μm as dispersed material non-explosive if mixed with air. The explosiveness of mixtures of air and some substance arouses researchers’ interest. In particular, the explosiveness of whey powder specimens (hereinafter referred to as whey powder) with an average particle size of 41, 162 and 750 μm, was identified in the process of their testing in a 1 m3 chamber. The task is to find out the maximum particle size of whey powder dcr using the earlier developed procedure and to demonstrate its failure to conform to the rule specified above. Method to process experimental data. Continuous functions F of particle size distribution d were constructed for three whey powder specimens having the following values of the lower explosive limit (LEL1 = 250 g/m3, LEL2 = 250 g/m3 and LEL3 = 500 g/m3, respectively). Resulting functions F1(d), F2(d) and F3(d) were presented using Rosin – Rammler distributions that filled the gaps between the discrete data obtained as a result of the sieve analysis. dcr evaluation. We used information about the first and third whey powder specimens in compliance with the well-known procedure (Poletaev, 2014). dcr values were identified using equation F1(dcr)/F3(dcr) = LEL3/LEL1. Having solved the equation, we found that dcr = 750 μm. Discussion. The obtained evaluation of dcr is much higher than the limit value of the parameter proposed in the regulations. This evaluation is of objective origin, and it cannot be explained by the grinding of large particles during the spraying process. The latter statement is supported by a characteristic decrease in the explosibility index of whey powder and an increase in the average particle size (for explosive fractions) of the three specimens in question. Conclusions. The maximum particle size of the explosive whey fraction is about 750 µm.

Comparison of the Quality of Mountain Sheep Milk Obtained from Animals Kept on a Natural and Organic Mountain Pasture

Abstract The purpose of this study was to evaluate the quality of mountain sheep milk obtained from animals kept on mountain pastures: natural and organic. The experimental procedure was conducted under production conditions, during annual grazing of mountain sheep on two mountain pastures in the region of the Polish Carpathians: on organic pasture certified for organic farming and natural mountain pasture belonging to the National Park. This study showed greater plant species diversity in the organic mountain pasture, but its yielding was lower than that of the natural pasture. The sward of the natural pasture was characterised by lower dry matter and fibre content but contained more total protein. The type of pasture did not affect the basic composition of the milk of mountain sheep, while differences were found in terms of acidity, alcohol number, fatty acid profile of fat and milk protein fractions. Milk obtained from sheep grazed on organic pasture was characterised by a higher proportion of medium chain fatty acids, as well as polyunsaturated fatty acids, and also essential unsaturated fatty acids, both linoleic acid, α-linolenic acid, γ-linolenic acid and arachidonic acid. In milk originating from the natural mountain pasture, a higher proportion of monounsaturated fatty acids, docosahexaenoic acid and the CLA c9-t11 isomer was found. The composition of milk protein fractions varied according to the location of grazing: milk from sheep grazing on natural pasture had a higher content of whey fractions, important for consumer health, milk from organic pasture had a higher content of κ-casein, of greatest importance in dairy processing technology. The floral composition of the pasture had an influence on the quality of sheep milk in relation to the fatty acid profile of fat and protein fractions of milk, which is important in terms of both the health-promoting and technological aspects of the raw material and may affect the quality of products made from it.

Nanofiltration of the Remaining Whey after Kefir Grains' Cultivation.

Acid whey is derived from fresh cheese. The proteins were isolated by a monolithic ion-exchange column. The remaining whey fraction was used as a starter culture substrate of kefir grains. The aim of this work was, firstly, to study the possibility of column replacement by a UF membrane. If we succeeded, the concentrate would be used as a starter culture substrate of kefir grains. The second part of the research was to purify the remaining solution. The idea was to separate this solution to the permeate and the concentrate by nanofiltration. Further application of both filtration streams was tested as aqueous solutions or dried matter. Chemical and microbiological analyses were performed of both the permeate and the concentrate. The permeate analyses showed that lactose had been fully removed. The aqueous permeate was not stable, mainly due to an increase of total bacteria from 103 to 106 CFU/mL. Therefore, the permeate was spray-dried. The dry permeate was added to the moisture solution in different concentrations. The results showed that up to 0.5% of the dry permeate could be added to the moisturizing solution, with negligible changes in properties having the ability to inhibit acne growth. Anaerobic digestion of industrial sludge was performed with the addition of an aqueous concentrate, which showed improvement in anaerobic fermentation.

No Waste from Waste: Membrane-Based Fractionation of Second Cheese Whey for Potential Nutraceutical and Cosmeceutical Applications, and as Renewable Substrate for Fermentation Processes Development

Second cheese whey (SCW) derived from buffalo milk is the main by-product of the mozzarella cheese dairy industry. The objective of this study was to develop a membrane-based purification procedure to obtain specific fractions from SCW and assess their biological and applicative potential. Special interest was paid to the proteins and newly identified health-promoting compounds that could be recovered and used as value-added products in different sectors of food and pharmaceutical industries. SCW has been treated, sequentially, with microfiltration (MF), ultrafiltration (UF), and nanofiltration (NF) membranes giving the possibility to obtain three different fractions, namely retentates recovered on 100 and 10 kDa (R100 and R10) and a nanofiltration retentate (RNF). These retentates were compared for their ability to preserve human keratinocytes from dehydration, to form protein-based films by casting, and finally they were used for probiotic cultivations as the main substrate. Results showed that Lactobacillus rhamnosus could grow without any further additional nutrient up to 2.2 ± 0.3 × 109 CFU/mL in the RNF medium. Dehydration tests on HaCat cells proved R100 as the most efficient fraction in preserving cell viability from this specific stress. R10, after diafiltrations, formed transparent films with improved features when glycerol was added as a plasticizer.