Two-phase Solvent System Research Articles

Role of three-phase solvent system in the counter-current chromatography.

In counter-current chromatography, the separation efficiency greatly depends on the partitioning ability of the separated substance between the stationary phase and the mobile phase. Partitioning ability is mainly represented by the parameter partition coefficient which is one of the important parameters to evaluate the separation effect of counter-current chromatography. The scope of the partition coefficient value mainly depends on the solvent system. A suitable solvent system election is, therefore, a critical role in the separation of counter-current chromatography. The existing solvent systems that are widely used are mainly two-phase solvent systems. It is difficult to decide on an appropriate solvent system for the separation of compounds with a wide polarity range, which promotes the development of the three-phase solvent system in counter-current chromatography. This review mainly described the origin, development history of three-phase solvent system, summarized the volume ratios and volume fractions of the upper, middle, and lower phases of nearly 50 three-phase solvent systems, their advantages, and disadvantages in counter-current chromatography. In addition, the challenges and future perspectives on three-phase solvent systems in counter-current chromatography also are discussed in this review.

Bioassay-Guided Isolation of Two Eudesmane Sesquiterpenes from Lindera strychnifolia Using Centrifugal Partition Chromatography.

In this study, a centrifugal partition chromatography (CPC) separation was applied to identify antioxidant-responsive element (ARE) induction molecules from the crude extract of Lindera strychnifolia roots. CPC was operated with a two-phase solvent system composed of n-hexane-methanol-water (10:8.5:1.5, v/v/v) in dual mode (descending to ascending), which provided a high recovery rate (>95.5%) with high resolution. Then, ARE induction activity of obtained CPC fractions was examined in ARE-transfected HepG2 cells according to the weight ratios of the obtained fractions. The fraction exhibiting ARE-inducing activity was further purified by preparative HPLC that led to isolation of two eudesmane type sesquiterpenes as active compounds. The chemical structures were elucidated as linderolide U (1) and a new sesquiterpene named as linderolide V (2) by spectroscopic data. Further bioactivity test demonstrated that compounds 1 and 2 enhanced ARE activity by 22.4-fold and 7.6-fold, respectively, at 100 μM concentration while 5 μM of sulforaphane induced ARE activity 24.8-fold compared to the control.

A rational route based on liquid-liquid-refining extraction and high-speed counter-current chromatography for separation of target compound from Toona sinensis

Gallotannin, 1,2,3,4,6-penta-O-galloyl-β-d-glucose (PGG), exhibited a wide range of biological activities. In the present study, a method combined liquid-liquid refining extraction and high-speed counter-current chromatography was established for improving the separation yield of PGG from Toona sinensis. Liquid-liquid refining extraction was used to enrich the target compound, the impurities with high polarity and low polarity can be removed with appropriate two-phase solvent systems, and a series of equations were developed to determine the times of extraction and loss rate of target compound. As a result, the two solvent systems composed of n-hexane–ethyl acetate–methanol–water (1:2:1:2, v/v) and ethyl acetate–water (1:1, v/v) were selected to remove the low polarity impurities and high polarity impurities, respectively, and 78.08 % by weight of the crude extract was removed, while the loss rate of PGG was only 12.09 % after extraction. Then, the PGG enriched samples were further separated by high-speed counter-current chromatography with a two-phase solvent system n-hexane–ethyl acetate–methanol–water (0.4:5:0.4:5, v/v). PGG (75 mg) with purity of 97.33 % was isolated from 350 mg of the PGG enriched samples. This study proved that the liquid-liquid refining extraction was a very effective method to enrich the target compound from complex mixture and a good assistant for large-scale preparation of natural products.

Immobilized α-glucosidase using polydopamine-coated magnetic nanoparticles for targeted screening of an active component from Toona sinensis

Toona sinensis is a traditional vegetable with rich nutrition and wide biological activity. In our previous study, an active composition against α-amylase was screened from T. sinensis by ligand fishing. To investigate the effect of T. sinensis on other targets of antidiabetes, in this work, α-glucosidase was immobilized on polydopamine-coated magnetic nanoparticles to further screen the compounds against α-glucosidase by ligand fishing. The enzyme activity test showed that the 70% ethanol extract of T. sinensis (crude sample) had weak α-glucosidase inhibitory activity, but after extraction with different solvents, the ethyl acetate extract showed the highest α-glucosidase inhibitory activity. After immobilization of α-glucosidase on polydopamine (PDA)-coated magnetic nanoparticles, the properties of the enzyme were characterized and determined, and then quercetin-3-O-α-L-rhamnopyranoside was screened by ligand fishing and isolated by high-speed counter-current chromatography using the two-phase solvent system composed of n-hexane-ethyl acetate-methanol-water (1:5:1:5, v/v). The results of enzymes assay showed that the screened compound (IC50 value of 374.94 ± 4.35 μg/mL) possessed moderate α-glucosidase inhibitory activity. The presented results not only proved that ligand fishing based on polydopamine-coated magnetic α-glucosidase was an effective method for the rapid discovery of natural active substances, but also further strengthened the evidence of antidiabetic effect of T. sinensis.

A fast and efficient preparative method for separation and purification of main bioactive xanthones from the waste of Garcinia mangostana L. by high-speed countercurrent chromatography

In this work, we present a preparative elution method by high-speed countercurrent chromatography (Prep-HSCCC) for the separation and isolation of the main bioactive xanthones present in the alcoholic extract of Garcinia mangostana L. agro-industrial waste. The method proved to be quite efficient, operating with a two-phase solvent system consisting of Methanol/water/Ethanol/Hexane/methyl tert -butyl ether (6:3:1:6:4v/v), tail-head elution mode, with mobile phase flow of 5 mL/min and rotation speed of 800 rpm. The method demonstrated repeatability (RSD = 3.8–6.5%) and allowed the isolation of α-mangostin and γ-mangostin xanthones, both with purities above 93%, in a single step, performed in a time of 35 min. Isolated substances were identified by HPLC-PDA-MS and 1 H and 13 C NMR spectroscopy. Both xanthones were efficient scavengers of DPPH · and ABTS + radicals in a concentration-dependent manner with EC 50 at 8.43 and 3.31 µg/mL, respectively, for γ-mangostin, and 71.10 and 29.33 µg/mL, respectively, for α-mangostin.

A Regioselective Synthesis of Novel Functionalized Organochalcogen Compounds by Chalcogenocyclofunctionalization Reactions Based on Chalcogen Halides and Natural Products.

The regioselective synthesis of novel functionalized condensed organochalcogen compounds by chalcogenocyclofunctionalization reactions based on chalcogen halides and the natural products thymol and carvacrol has been developed. The reactions of selenium dibromide with allyl thymol and allyl carvacrol proceeded in methylene chloride at room temperature in the presence of NaHCO3 affording bis[(7-isopropyl-4-methyl-2,3-dihydro-1-benzofuran-2-yl)methyl] and bis[(4-isopropyl-7-methyl-2,3-dihydro-1-benzofuran-2-yl)methyl] selenides in 90–92% yield. Similar sulfides were obtained in 70–72% yields by the reaction of sulfur dichloride in chloroform under reflux. Trihalotellanes containing the same organic moieties were synthesized from allyl thymol, allyl carvacrol and tellurium tetrachloride or tetrabromide in quantitative yields. Corresponding functionalized ditellurides were prepared in 91–92% yields by the reduction of the trichlorotellanes with sodium metabisulfite in two-phase solvent system. The comparison of reactivity of sulfur, selenium and tellurium halides in chalcogenocyclofunctionalization and distinguishing features of each reaction were discussed.

Isolation of Four Major Compounds of γ-Oryzanol from Rice Bran Oil by Ionic Liquids Modified High-Speed Countercurrent Chromatography and Antimicrobial Activity and Neuroprotective Effect of Cycloartenyl Ferulate In Vitro

This study presents an effective high-speed countercurrent chromatography method of two-phase solvent system combined with ionic liquids for the isolation and purification of four major compounds of γ-oryzanol from rice bran oil. The conditions of high-speed countercurrent chromatography, including solvent systems and the content of ionic liquids, were optimized to improve separation efficiency. The optimal solvent system was n-hexane–dichloromethane–acetonitrile–[C4mim][PF6] at a volume ratio of (10:1:10:0.15, v/v). Adding a small amount of ionic liquids significantly improved the separation efficiency. Four compounds of γ-oryzanol, cycloartenyl ferulate, 24-methylene cycloartanyl ferulate, campesteryl ferulate, and sitosteryl ferulate were successfully purified in one run from rice bran oil with the purities of 95.25%, 92.48%, 92.47%, and 93.43%, respectively. The result of bioassay showed that rice bran oil and separated individual cycloartenyl ferulate could significantly inhibit mycelium growth of crop diseases Rhizoctonia solani and Fusarium graminerum, the bioactivity of cycloartenyl was higher than that of the rice bran oil. The cellular antioxidant activity experimental result indicted that cycloartenyl ferulate could alleviate H2O2-induced oxidative stress.

Preparative separation and purification of Cyclosporin D from fungus Hypoxylon Spp. by improved closed-loop recycling counter-current chromatography

Improved closed-loop recycling counter-current chromatography (CLR CCC) with a two-phase solvent system composed of n-hexane–acetonitrile (1:1, v/v) was developed for separation, purification and preparation of cyclosporin D from the crude extract of fungus Hypoxylon Spp. (sj18). 28 mg cyclosporin D was successfully purified from 300 mg crude extract sample. The purity was 95.2% after five cycles, determined by HPLC. The structure of cyclosporin D was identified and assigned by 1H NMR, 13C NMR and mass spectrometric analyses. In addition, in the study, we show an interesting phenomenon that cyclosporin D can be prepared by the conventional CCC in n-hexane–ethyl acetate–methanol–water solvent system (2.5:1:2.5:1, v/v/v/v), and can also be prepared by the improved closed-loop recycling CCC in n-hexane–acetonitrile solvent system (1:1, v/v), but the efficiency of preparation varies greatly.

Development of ultrasound-assisted centrifugal extraction combined with two countercurrent chromatography systems for the simultaneous extraction and isolation of phytochemicals.

We proposed a method for the extraction of medicinal herbs, called ultrasound-assisted centrifugal extraction, and an online solvent concentration method. These techniques were coupled with two countercurrent chromatography systems and applied to the continuous extraction and online isolation of chemical constituents from Inonotus obliquus. Raw plants were extracted using a two-phase petroleum-ethanol-water (2.0:1.0:2.0, v/v/v) process, and then the aqueous and organic phases were concentrated using the proposed online solvent concentrator. The countercurrent chromatography preparation prior to separation includes pumping of the two-phase solution, rotating column, and equilibrium column. Following online concentration, the extracted solution was pumped into a second countercurrent chromatography process for separation. During separation, the extraction solution and concentrated extract were prepared automatically. Upon completion of the first cycle of ultrasound-assisted centrifugal extraction/two countercurrent chromatography, the second cycle experiment starts. This process can be indefinitely repeated. In this study, six target compounds with purities above 97.71% were successfully extracted and isolated online using a two-phase solvent system consisting of n-hexane-ethyl acetate-acetonitrile (4.5:1.5:5.5, v/v/v) and n-hexane-ethyl acetate-methanol-water (0.4:3.0:1.5:2.5, v/v/v/v). Compared to conventional extraction methods, the instrumental setup of the proposed method provides enhanced automation, efficiency, purity, and systematic extraction and isolation of natural products.

Polyphenolic Compounds Extracted and Purified from Buddleja Globosa Hope (Buddlejaceae) Leaves Using Natural Deep Eutectic Solvents and Centrifugal Partition Chromatography.

Chemical profiling of Buddleja globosa was performed by high-performance liquid chromatography coupled to electrospray ionization (HPLC-DAD-ESI-IT/MS) and quadrupole time-of-flight high-resolution mass spectrometry (HPLC-ESI-QTOF/MS). The identification of 17 main phenolic compounds in B. globosa leaf extracts was achieved. Along with caffeoyl glucoside isomers, caffeoylshikimic acid and several verbascoside derivatives (β-hydroxyverbascoside and β-hydroxyisoverbascoside) were identified. Among flavonoid compounds, the presence of 6-hydroxyluteolin-7-O-glucoside, quercetin-3-O-glucoside, luteolin 7-O-glucoside, apigenin 7-O-glucoside was confirmed. Campneoside I, forsythoside B, lipedoside A and forsythoside A were identified along with verbascoside, isoverbascoside, eukovoside and martynoside. The isolation of two bioactive phenolic compounds verbascoside and forsythoside B from Buddleja globosa (Buddlejaceae) was successfully achieved by centrifugal partition chromatography (CPC). Both compounds were obtained in one-step using optimized CPC methodology with the two-phase solvent system comprising ethyl acetate-n-butanol-ethanol-water (0.25:0.75:0.1:1, v/v). Additionally, eight Natural Deep Eutectic Solvents (NADESs) were tested for the extraction of polyphenols and compared with 80% methanol. The contents of verbascoside and luteolin 7-O-glucoside after extraction with 80% methanol were 26.165 and 3.206 mg/g, respectively. Among the NADESs tested in this study, proline- citric acid (1:1) and choline chloride-1, 2- propanediol (1:2) were the most promising solvents. With these NADES, extraction yields for verbascoside and luteolin 7-O-glucoside were 51.045 and 4.387 mg/g, respectively. Taken together, the results of this study confirm that CPC enabled the fast isolation of bioactive polyphenols from B. globosa. NADESs displayed higher extraction efficiency of phenolic and therefore could be used as an ecofriendly alternative to classic organic solvents.

Advances in the separation of gangliosides by counter-current chromatography (CCC)

Gangliosides play critical roles in the development of many progressive diseases. Due to their structural diversity, efficient methods are needed to separate individual gangliosides for studies of their functions, and for use as standards in the analysis of ganglioside mixtures. This proof-of-concept study reports a useful analytical-semi-preparative scale counter-current chromatography (CCC) enrichment of multiple ganglioside homologues of various species and classes at the milligram level.Since few individual ganglioside standards were available, this research aimed to achieve analytical-semi-preparative scale separation of gangliosides by differences in saccharide monomer compositions (classes), their arrangements (species), or ceramide compositions (homologues), using CCC. The solvent system composition, addition of solvent modifiers, and elution modes were all adjusted to separate porcine gangliosides, mainly GM1 (d36:1), GD1a (d36:1), GD1b (d36:1) and their (d38:1) homologues as a demonstration. The eluted compounds were analyzed by flow-injection analysis (FIA)-MS and LC-MS/MS.A two-phase solvent system, consisting of butanol/methyl t-butyl ether/acetonitrile/water at a ratio of 2:4:3:8 (v/v/v/v) with 0.5% (v/v) acetic acid added to the lower phase, was used to separate mg-levels of porcine gangliosides under dual-mode elution. The relative abundances of the above 6 gangliosides increased from 10 to 21% in the ganglioside extract to 55–73% in the collected fractions through the purification.

Extraction and purification of cis/trans asarone from Acorus tatarinowii Schott: Accelerated solvent extraction and silver ion coordination high-speed counter-current chromatography

Acorus tatarinowii Schott is a traditional Chinese medicine used to treat memory and cognitive dysfunction. Because of their efficacy and lower toxic effects, research on α- and β-asarone, the phytoconstituents, has attracted attention owing to their remarkable pharmacological activities. Silver ion coordination complexation high-speed counter-current chromatography was used to separate these isomers from A. tatarinowii extract, coupled with accelerated solvent extraction. Accelerated solvent extraction parameters were investigated with single-factor and orthogonal testing. A two-phase solvent system composed of n-hexane-ethyl acetate-ethanol-water (2:1:2:1, v/v) with 0.50 mol/L silver ions was selected for separation. From 2.0 g crude extract, 1.4 g of β-asarone and 0.09 g of α-asarone were obtained with purities over 98% by sequential sample loading in 20 h. The isolated compounds were identified by electrospray ionization mass spectrometry, 1H and 13C NMR. Silver ions significantly increased the separation factor and retention of the stationary phase. The chromatographic behavior indicated that cis-configuration was more strongly complexed with the silver ion. This was further demonstrated with the help of computational analysis. In conclusion, the established method could be employed to separate other cis-trans or E/Z isomers that form coordination complexes.

Preparative Isolation and Purification of Calycosin and Formononetin from Astragali Radix using Hydrolytic Extraction Combined with High Speed Countercurrent Chromatography.

Calycosin and formononetin were efficiently extracted from Astragali Radix and purified by high-speed countercurrent chromatography. Calycosin and formononetin could be hydrolyzed from calycosin-7-glucoside and ononin, respectively. The best extraction conditions were realized by single factor and orthogonal experiments, which were 100% ethanol, 2.5mol/L hydrochloric acid, 1:40 ratio of solid to liquid, extracted 2h and one time. The two-phase solvent system of n-hexane-ethyl acetate-ethanol-water (3:5:3:5, v/v) was selected for the purification of calycosin, and 1.3mg calycosin (the purity was 95.8% and the recovery was 85.9%) was obtained from 264.9-mg crude extraction. The two-phase solvent system of n-hexane-ethyl acetate-ethanol-water (4:5:4:5, v/v) was selected for the purification of formononetin, and 2.0mg formononetin (the purity was 98.9% and the recovery was 84.4%) was obtained from 248.9-mg crude extraction. Their structures were identified by HPLC, melting points, UV, FTIR, ESI-MS, 1H NMR and 13C NMR spectrum. According to the antioxidant activity assay, the scavenging abilities of calycosin to 1,1-diphenyl-2-picrylhydrazyl and hydroxyl free radicals (·OH) were stronger. The scavenging effect of formononetin was not demonstrated.

Stable Isotope Labeling by Carbon-13 in Bacteria Culture for the Analysis of Residual Avermectin Using Stable Isotope Dilution Liquid Chromatography Tandem Mass Spectrometry.

This study describes the development of a new stable isotope labeling method by carbon-13 in bacteria culture (SILCB) for the analysis of residual antibiotics via liquid chromatography with tandem mass spectrometry (LC-MS/MS). Stable isotope dilution (SID) LC-MS/MS with QuEChERS was employed to determine avermectin, particularly avermectin B1a (AV-a) and B1b (AV-b), based on completely 13C-labeled internal standards (13C-ISs) obtained from the SILCB. Our SILCB was developed from an optimal inorganic medium using 13C6-glucose for Streptomyces avermitilis (14893 strain). A rough extract containing 13C-ISs was purified via high-speed countercurrent chromatography with a volatile two-phase solvent system composed of n-hexane/ethyl acetate/methanol/0.5% formic acid in water (7/3/5/5/, V/V). The purified 13C-ISs were evaluated to confirm the presence of completely 13C-labeled ions with m/z 938 > 326 and m/z 923 > 309 for AV-a and AV-b, respectively. The QuEChERS approach with the 13C-ISs procedure achieved acceptable recovery rates in beef meat samples of 99.5 - 100.0% (RSD < 2.0%, n = 6). For the analysis of residual antibiotics in foodstuffs by SID-LC-MS/MS and QuEChERS, the SILCB represents a significant improvement over previous methods suffering from cumbersome sample preparation and matrix effects.

Purification of hypocrellins from Shiraia bambusicola by coordinated high-speed countercurrent chromatography using cupric chloride as a complexing agent.

Hypocrellins are anthraquinone that can act as excellent photosensitizers for photodynamic therapy. In the present work, we found that high-speed countercurrent chromatography using cupric chloride as a complexing agent effectively separated hypocrellins from Shiraia bambusicola extract. The optimal two-phase solvent system consisted of petroleum ether/ethyl acetate/methanol/water (7:3:5.5:4.5, v/v/v/v), with 0.01mol/L cupric chloride in the lower phase at pH of 2.45. This lower phase served as the mobile phase, whereas the upper phase acted as the stationary phase. Employing a continuous separation mode, three continuous injections were found to allow the purification of 1.2g of crude extract in approximately 12 h. Hypocrellin B (10.8mg), hypocrellin A (16.2mg), and hypocrellin C (15.6mg) were obtained from this process. Simulation of complexation of hypocrellin A with divalent copper ion by computational chemistry calculations indicated that three pairs of hydroxyl and carbonyl groups in hypocrellin A had similar binding energies, and demonstrated that hypocrellin A and B owned different metal-to-ligand ratios as compared to hypocrellin C. These factors could modify the partitioning of these compounds in two-phase solvent system, and resulting in a suitable separation factor. This method would also be used to purify other anthraquinones from natural products.

Development of metallosupramolecular phosphatases based on the combinatorial self-assembly of metal complexes and organic building blocks for the catalytic hydrolysis of phosphate monoesters

The phosphorylation and dephosphorylation of proteins and other intracellular molecules are important reactions in living systems and are generally controlled by the action of kinases and phosphatases. The design and synthesis of artificial mimics of natural enzymes are important research subjects in bioorganic and bioinorganic chemistry. A supramolecular strategy based on the three-dimensional self-assembly of molecular building blocks would be useful for the construction of artificial supramolecular complexes. The main focus of this review is on artificial mimics of natural phosphatases that contain dimetallic cores in their active sites. Previous examples of artificial mimics of alkaline phosphatases (AP) constructed covalently are initially presented, then followed by a description of artificial metallosupramolecular complexes formed by the combinatorial self-assembly of different bis(Zn2+-cyclen) complexes containing 2,2′-bipyridyl (bpy) linker (cyclen = 1,4,7,10-tetraazacyclododecane), cyanuric acid or barbital (Bar) units, and Cu2+ ion in single or two-phase solvent systems. It is now thought that the appropriate combination of the various building blocks and solvent systems (single- and two-phase solvent systems) can strongly assist in developing the artificial systems that accelerate and catalyze the hydrolysis of a phosphate monoester, mono(p-nitrophenyl) phosphate (MNP). Such approaches would be useful in terms of understanding the mechanism of action of naturally occurring enzymes and to develop biologically active, bioorthogonal, and versatile supramolecular catalysts.

Isolation of potential α-glucosidase inhibitor from Inonotus obliquus by combining ultrafiltration-liquid chromatography and consecutive high-speed countercurrent chromatography.

Inonotus obliquus is a rare medicinal fungus that contains several potential therapeutic ingredients. In this study, the α-glucosidase inhibitory activity of I. obliquus was examined, and a potential α-glucosidase inhibitor, (E)-4-(3,4-dihydroxyphenyl)but-3-en-2-one, was isolated from the I. obliquus extract through ultrafiltration-liquid chromatography (UF-LC). Consecutive high-speed countercurrent chromatography (HSCCC) was used for separation to obtain large quantities of the target compound. The universal quasi-chemical functional group activity coefficient (UNIFAC) model was utilized to prepare a two-phase solvent system, n-hexane/ethyl acetate/ethanol/water (4 : 4.5 : 3.5 : 5, v/v/v/v), wherein the proportions of n-hexane/ethyl acetate/ethanol/water in the stationary and mobile phases were 19.8 : 19.7 : 7.9 : 2.2 (v/v/v/v) and 1 : 16.4 : 57.5 : 136.6 (v/v/v/v), respectively. A flow rate of 2.5 mL min-1 and a column speed of 860 rpm were maintained. Consequently, 10.3 mg of the target compound (95.9% purity) was obtained from 900 mg (6 × 150 mg) of the I. obliquus extract. The use of the UNIFAC model, in combination with consecutive HSCCC separations, allows the purification of large quantities of samples over a short time. Furthermore, the volume of the organic solvent required is reduced. Thus, UF-LC is an effective technique for screening potential α-glucosidase inhibitors isolated from I. obliquus. This can ultimately aid in the discovery of bioactive compounds for the prevention and treatment of diabetes.

Identification, separation by spiral high-speed counter-current chromatography, and quantification of 7-chloro-5-methyl-2H-1,4-benzothiazin-3(4H)-one, an impurity in the thioindigoid color additive D&C Red No. 30 and its lakes

An impurity in the color additives D&C Red No. 30 (R30) and D&C Red No. 30 lakes (R30L) was newly identified and characterized as 7-chloro-5-methyl-2H-1,4-benzothiazin-3(4H)-one (BTZ), and its extent and level in certified batches of these color additives was determined. BTZ was extracted from the dye with ethanol, resulting in a crude extract enriched to a concentration of over 60%. BTZ was then separated from a portion of the enriched extract by high-speed counter-current chromatography using a spiral-tube assembly column with intermittently pressed tubing of 60 ml capacity. It was the first reported use of such a column to separate a small, moderately hydrophobic compound. The two-phase solvent system was also moderately hydrophobic, consisting of hexane-ethyl acetate-methanol-water (5:2:5:2), and the retention of the organic stationary phase measured after the separation was 83.3%. The separation yielded BTZ of two purity grades, the higher of which (~95.5%) was used as a standard to quantify the impurity in 37 batches of R30 and R30L using an HPLC method developed and validated for that purpose. Analyses revealed a wide range of BTZ levels across batches, <0.05 - 0.84%, and suggested that BTZ contamination could be reduced by appropriate adjustments in the manufacturing process. An explanation of the likely source of BTZ – as a side-reaction product in a particular step of the manufacturing process – was also presented.

Isolation and purification of soyasapogenol A and B starting from soy hypocotyls: High-speed counter‐current chromatography versus preparative high‐performance liquid chromatography

Soyasapogenols derived from soyasaponins, which abundantly occur in soy hypocotyls, are of great importance as bioactive compounds due to their physiological activities. However, there is a lack of a high-efficiency and scalable preparation and isolation procedure. This work extends research on applying and comparing high-speed countercurrent chromatography (HSCCC) and preparative high-performance liquid chromatography (prep-HPLC) either singly and/or combinedly in preparative isolation of soyasapogenol A and B. The comparison reveals that the yield of 0.24 and 0.21% of soyasapogenol A and B with the purity of 98.09 and 98.90%, respectively, were obtained from the starting material of soy hypocotyls in two-steps HSCCC separation procedure. In contrast, prep-HPLC allowed isolation and purification of these two target compounds with significantly lower productivity and higher solvent consumption. An optimal two-phase solvent system of n-hexane–ethyl acetate–methanol–water (3:6:4:2, v/v/v/v) was selected to separate soyasapogenols in HSCCC procedure. The present investigation indicates that two-steps HSCCC can potentially provide a fast, high yielding, and more environmentally friendly tool for the preparative separation and purification of soyasapogenol A and B starting from the materials of soy hypocotyls.

Enantioseparation of 2-(4-chlorophenyl)succinic acid by countercurrent chromatography and investigation of injection volume on resolution.

2-(4-Chlorophenyl)succinic acid was successfully enantioseparated by countercurrent chromatography using hydroxypropyl-β-cyclodextrin as chiral selector. A two-phase solvent system composed of n-hexane-ethyl acetate-0.1mol/L phosphate buffer with pH 2.65 (5:5:10, v/v) was selected. Enantioselective liquid-liquid extraction was used to optimize the enantioseparation conditions. Meanwhile, the influence of injection volume on resolution in countercurrent chromatography was investigated and a linear relationship between the inflection point of injection volume and sample loading was tentatively obtained. The peak resolution will decrease significantly when the injection volume over the inflection point was used. In addition, it could be found that the smaller amount of sample loading, the larger impact of injection volume on resolution could be observed, which might serve as a good reference for the selection of sample volume in enantioseparations by countercurrent chromatography. Under optimized conditions, 20mg of 2-(4-chlorophenyl)succinic acid racemate dissolved in 10mL of aqueous phase was successfully enantioseparated by countercurrent chromatography. The recovery for both of the enantiomer of (±)-2-(4-chlorophenyl)succinic acid reached within 70-75% with a purity of 99.0%.