THERAFLEX MB-Plasma Research Articles

Inactivation of SARS-CoV-2 infectivity in platelet concentrates or plasma following treatment with ultraviolet C light or with methylene blue combined with visible light.

Severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) is unlikely to be a major transfusion-transmitted pathogen, however, convalescent plasma is a treatment option used in some regions. The risk of transfusion-transmitted infections can be minimised by implementing Pathogen Inactivation (PI), such as THERAFLEX MB-Plasma and THERAFLEX UV-Platelets systems. Here we examined the capability of these PI systems to inactivate SARS-CoV-2. SARS-CoV-2 spiked plasma units were treated using the THERAFLEX MB-Plasma system in the presence of methylene blue (~0.8 μmol/L; visible light doses: 20, 40, 60 and 120 [standard] J/cm2 ). SARS-CoV-2 spiked platelet concentrates (PCs) were treated using the THERAFLEX UV-Platelets system (UVC doses: 0.05, 0.10, 0.15 and 0.20 [standard] J/cm2 ). Samples were taken prior to the first and after each illumination dose and viral infectivity was assessed using an immunoplaque assay. Treatment of spiked plasma with the THERAFLEX MB-Plasma system resulted in an average ≥5.03 log10 reduction in SARS-CoV-2 infectivity at one third (40 J/cm2 ) of the standard visible light dose. For the platelet concentrates (PCs), treatment with the THERAFLEX UV-Platelets system resulted in an average ≥5.18 log10 reduction in SARS-CoV-2 infectivity at the standard UVC dose (0.2 J/cm2 ). SARS-CoV-2 infectivity was reduced in plasma and platelets following treatment with the THERAFLEX MB-Plasma and THERAFLEX UV-Platelets systems, to the limit of detection, respectively. These PI technologies could therefore be an effective option to reduce the risk of transfusion-transmitted emerging pathogens. This article is protected by copyright. All rights reserved.

Hepatitis E virus is effectively inactivated by methylene blue plus light treatment.

Photodynamic treatment with methylene blue (MB) and visible light is a well-established pathogen inactivation system for human plasma. This technique is routinely used in different countries. MB/light treatment was shown to inactivate several transfusion-transmittable viruses, but its efficiency for the inactivation of the quasi-enveloped hepatitis E virus (HEV) has not yet been investigated. Plasma units were spiked with cell culture-derived HEV and treated with the THERAFLEX MB-Plasma system using various light doses (30, 60, 90, and 120 J/cm2 ). HEV titers in pre- and post-treatment samples were determined by virus titration and a large-volume plating assay to improve the detection limit of the virus assay. THERAFLEX MB-Plasma efficiently inactivated HEV in human plasma. Even the lowest light dose of 30 J/cm2 inactivated HEV down to the limit of detection, with a mean log reduction factor of greater than 2.4 for the total process. Our study demonstrates that the THERAFLEX MB-Plasma system effectively inactivates HEV in human plasma.

Human Intramuscular Hyperimmune Gamma Globulin (hIHGG) Anti-SARS-CoV-2-Characteristics of Intermediates and Final Product.

This study aims to characterize the intermediates, and the final product (FP) obtained during the production of human intramuscular hyperimmune gamma globulin anti-SARS-CoV-2 (hIHGG anti-SARS-CoV-2) and to determine its stability. Material and methods: hIHGG anti-SARS-CoV-2 was fractionated from 270 convalescent plasma donations with the Cohn method. Prior to fractionation, the plasma was inactivated (Theraflex MB Plasma). Samples were defined using enzyme immunoassays (EIA) for anti-S1, anti-RBD S1, and anti-N antibodies, and neutralization assays with SARS-CoV-2 (VN) and pseudoviruses (PVN, decorated with SARS-CoV-2 S protein). Results were expressed as a titer (EIA) or 50% of the neutralization titer (IC50) estimated in a four-parameter nonlinear regression model. Results: Concentration of anti-S1 antibodies in plasma was similar before and after inactivation. Following fractionation, the anti-S1, anti-RBD, and anti-N (total tests) titers in FP were concentrated approximately 15-fold from 1:4 to 1:63 (1800 BAU/mL), 7-fold from 1:111 to 1:802 and from 1:13 to 1:88, respectively. During production, the IgA (anti-S1) antibody titer was reduced to an undetectable level and the IgM (anti-RBD) titer from 1:115 to 1:24. The neutralizing antibodies (nAb) titer increased in both VN (from 1:40 to 1:160) and PVN (IC50 from 63 to 313). The concentration of specific IgG in the FP did not change significantly for 14 months. Conclusions: The hIHGG anti-SARS-CoV-2 was stable, with concentration up to approximately 15-fold nAb compared to the source plasma pool.

Methods of pathogen inactivation in whole blood and red blood cells: current state of knowledge

Although pathogen reduction technology was implemented for platelet concentrates and plasma, the risk of pathogen transmission has not been completely eliminated as no inactivation procedures were implemented for red blood cells and whole blood. Research was therefore focused on developing methods for effective pathogen inactivation in red blood cell components. Attempts were made to apply either chemical compounds (porphyrins and Sylsense compounds) or photosensitizers such as methylene blue (Theraflex MB Plasma System) and amotosalen hydrochloride (Intercept System) already in use for pathogen inactivation in plasma. None proved effective for pathogen inactivation in red blood cells. Approval was recently given to pathogen inactivation methods based on S-303 compound (for red blood cells) and with riboflavin (for whole blood). Clinical trials are ongoing. Pilot studies have shown that during storage of packed red blood cells subjected to pathogen inactivation with S-303 demonstrated slight loss of red blood cells, decrease in hemoglobin concentration, significantly lower lactate concentration, and lower pH. Pathogen inactivated whole blood stored at room temperature for up to seven days showed slight hemolysis (within the normal range). This paper presents several pilot clinical trials with pathogen inactivated red blood cells or whole blood. It focuses primarily on the recovery of red blood cells in the recipient's organism and on hemoglobin concentration.

Inactivation of Japanese encephalitis virus in plasma by methylene blue combined with visible light and in platelet concentrates by ultraviolet C light.

Japanese encephalitis virus-spiked plasma units were treated using the THERAFLEX MB-Plasma system (visible light doses, 20, 40, 60, and 120 [standard] J/cm2) in the presence of methylene blue at approximately 0.8 μmol/L and spiked platelet concentrates (PCs) were treated using the THERAFLEX UV-Platelets system (UVC doses, 0.05, 0.10, 0.15, and 0.20 [standard] J/cm2). Samples were taken before the first and after each illumination dose and tested for infectivity using an immunoplaque assay. Treatment of plasma with the THERAFLEX MB-Plasma system resulted in an average of 6.59 log reduction in JEV infectivity at one-sixth of the standard visible light dose (20 J/cm2). For PCs, treatment with the THERAFLEX UV-Platelet system resulted in an average of 7.02 log reduction in JEV infectivity at the standard UVC dose (0.20 J/cm2). The THERAFLEX MB-Plasma and THERAFLEX UV-Platelets systems effectively inactivated JEV in plasma or PCs, and thus these PI technologies could be an effective option to reduce the risk of JEV transfusion transmission.

Inactivation of three emerging viruses – severe acute respiratory syndrome coronavirus, Crimean–Congo haemorrhagic fever virus and Nipah virus – in platelet concentrates by ultraviolet C light and in plasma by methylene blue plus visible light

BackgroundEmerging viruses like severe acute respiratory syndrome coronavirus (SARS‐CoV), Crimean–Congo haemorrhagic fever virus (CCHFV) and Nipah virus (NiV) have been identified to pose a potential threat to transfusion safety. In this study, the ability of the THERAFLEX UV‐Platelets and THERAFLEX MB‐Plasma pathogen inactivation systems to inactivate these viruses in platelet concentrates and plasma, respectively, was investigated.Materials and methodsBlood products were spiked with SARS‐CoV, CCHFV or NiV, and then treated with increasing doses of UVC light (THERAFLEX UV‐Platelets) or with methylene blue (MB) plus increasing doses of visible light (MB/light; THERAFLEX MB‐Plasma). Samples were taken before and after treatment with each illumination dose and tested for residual infectivity.ResultsTreatment with half to three‐fourths of the full UVC dose (0·2 J/cm2) reduced the infectivity of SARS‐CoV (≥3·4 log), CCHFV (≥2·2 log) and NiV (≥4·3 log) to the limit of detection (LOD) in platelet concentrates, and treatment with MB and a fourth of the full light dose (120 J/cm2) decreased that of SARS‐CoV (≥3·1 log), CCHFV (≥3·2 log) and NiV (≥2·7 log) to the LOD in plasma.ConclusionOur study demonstrates that both THERAFLEX UV‐Platelets (UVC) and THERAFLEX MB‐Plasma (MB/light) effectively reduce the infectivity of SARS‐CoV, CCHFV and NiV in platelet concentrates and plasma, respectively.

Inactivation of yellow fever virus in plasma after treatment with methylene blue and visible light and in platelet concentrates following treatment with ultraviolet C light.

Yellow fever virus (YFV) is endemic to tropical and subtropical areas in South America and Africa, and is currently a major public health threat in Brazil. Transfusion transmission of the yellow fever vaccine virus has been demonstrated, which is indicative of the potential for viral transfusion transmission. An approach to manage the potential YFV transfusion transmission risk is the use of pathogen inactivation (PI) technology systems, such as THERAFLEX MB-Plasma and THERAFLEX UV-Platelets (Macopharma). We aimed to investigate the efficacy of these PI technology systems to inactivate YFV in plasma or platelet concentrates (PCs). YFV spiked plasma units were treated using THERAFLEX MB-Plasma system (visible light doses: 20, 40, 60, and 120 [standard] J/cm2 ) in the presence of methylene blue (approx. 0.8 μmol/L) and spiked PCs were treated using THERAFLEX UV-Platelets system (ultraviolet C doses: 0.05, 0.10, 0.15, and 0.20 [standard] J/cm2 ). Samples were taken before the first and after each illumination dose and tested for residual virus using a modified plaque assay. YFV infectivity was reduced by an average of 4.77 log or greater in plasma treated with the THERAFLEX MB-Plasma system and by 4.8 log or greater in PCs treated with THERAFLEX UV-Platelets system. Our study suggests the THERAFLEX MB-Plasma and the THERAFLEX UV-Platelets systems can efficiently inactivate YFV in plasma or PCs to a similar degree as that for other arboviruses. Given the reduction levels observed in this study, these PI technology systems could be an effective option for managing YFV transfusion-transmission risk in plasma and PCs.

Plasma temperature during methylene blue/light treatment influences virus inactivation capacity and product quality.

Photodynamic treatment using methylene blue (MB) and visible light is in routine use for pathogen inactivation of human plasma in different countries. Ambient and product temperature conditions for human plasma during production may vary between production sites. The influence of different temperature conditions on virus inactivation capacity and plasma quality of the THERAFLEX MB-Plasma procedure was investigated in this study. Plasma units equilibrated to 5±2°C, room temperature (22±2°C) or 30±2°C were treated with MB/light and comparatively assessed for the inactivation capacity for three different viruses, concentrations of MB and its photoproducts, activity of various plasma coagulation factors and clotting time. Reduced solubility of the MB pill was observed at 5±2°C. Photocatalytic degradation of MB increased with increasing temperature, and the greatest formation of photoproducts (mainly azure B) occurred at 30±2°C. Inactivation of suid herpesvirus, bovine viral diarrhoea virus and vesicular stomatitis virus was significantly lower at 5±2°C than at higher temperatures. MB/light treatment affected clotting times and the activity of almost all investigated plasma proteins. Factor VIII (-17·7±8·3%, 22±2°C) and fibrinogen (-14·4±16·4%, 22±2°C) showed the highest decreases in activity. Increasing plasma temperatures resulted in greater changes in clotting time and higher losses of plasma coagulation factor activity. Temperature conditions for THERAFLEX MB-Plasma treatment must be carefully controlled to assure uniform quality of pathogen-reduced plasma in routine production. Inactivation of cooled plasma is not recommended.

Reduction of Zika virus infectivity in platelet concentrates after treatment with ultraviolet C light and in plasma after treatment with methylene blue and visible light.

Zika virus (ZIKV) has emerged as a potential threat to transfusion safety worldwide. Pathogen inactivation is one approach to manage this risk. In this study, the efficacy of the THERAFLEX UV-Platelets system and THERAFLEX MB-Plasma system to inactivate ZIKV in platelet concentrates (PCs) and plasma was investigated. PCs spiked with ZIKV were treated with the THERAFLEX UV-Platelets system at 0.05, 0.10, 0.15, and 0.20 J/cm2 UVC. Plasma spiked with ZIKV was treated with the THERAFLEX MB-Plasma system at 20, 40, 60, and 120 J/cm2 light at 630 nm with at least 0.8 µmol/L methylene blue (MB). Samples were taken before the first and after each illumination dose and tested for residual virus. For each system the level of viral reduction was determined. Treatment of PCs with THERAFLEX UV-Platelets system resulted in a mean of 5 log reduction in ZIKV infectivity at the standard UVC dose (0.20 J/cm2 ), with dose dependency observed with increasing UVC dose. For plasma treated with MB and visible light, ZIKV infectivity was reduced by a mean of at least 5.68 log, with residual viral infectivity reaching the detection limit of the assay at 40 J/cm2 (one-third the standard dose). Our study demonstrates that the THERAFLEX UV-Platelets system and THERAFLEX MB-Plasma system can reduce ZIKV infectivity in PCs and pooled plasma to the detection limit of the assays used. These findings suggest both systems have the capacity to be an effective option to manage potential ZIKV transfusion transmission risk.

Dengue and chikungunya viruses in plasma are effectively inactivated after treatment with methylene blue and visible light.

Arboviruses, such as dengue viruses (DENV) and chikungunya virus (CHIKV), pose a risk to the safe transfusion of blood components, including plasma. Pathogen inactivation is an approach to manage this transfusion transmission risk, with a number of techniques being used worldwide for the treatment of plasma. In this study, the efficacy of the THERAFLEX MB-Plasma system to inactivate all DENV serotypes (DENV-1, DENV-2, DENV-3, DENV-4) or CHIKV in plasma, using methylene blue and light illumination at 630 nm, was investigated. Pooled plasma units were spiked with DENV-1, DENV-2, DENV-3 DENV-4, or CHIKV and treated with the THERAFLEX MB-Plasma system at four light illumination doses: 20, 40, 60, and 120 (standard dose) J/cm(2) . Pre- and posttreatment samples were collected and viral infectivity was determined. The reduction in viral infectivity was calculated for each dose. Treatment of plasma with the THERAFLEX MB-Plasma system resulted in at least a 4.46-log reduction in all DENV serotypes and CHIKV infectious virus. The residual infectivity for each was at the detection limit of the assay used at 60 J/cm(2) , with dose dependency also observed. Our study demonstrated the THERAFLEX MB-Plasma system can reduce the infectivity of all DENV serotypes and CHIKV spiked into plasma to the detection limit of the assay used at half of the standard illumination dose. This suggests this system has the capacity to be an effective option for managing the risk of DENV or CHIKV transfusion transmission in plasma.

Challenge study of the pathogen reduction capacity of the THERAFLEX MB-Plasma technology.

Although most pathogen reduction systems for plasma primarily target viruses, bacterial contamination may also occur. This study aimed to investigate the bacterial reduction capacity of a methylene blue (MB) treatment process and its virus inactivation capacity in lipaemic plasma. Bacterial concentrations in plasma units spiked with different bacterial strains were measured before and after the following steps of the THERAFLEX MB-Plasma procedure: leucocyte filtration, MB/light treatment and MB filtration. Virus inactivation was investigated for three virus types in non-lipaemic, borderline lipaemic and highly lipaemic plasma. Leucocyte filtration alone efficiently eliminated most of the tested bacteria by more than 4 logs (Staphylococcus epidermidis and Staphylococcus aureus) or to the limit of detection (LOD) (≥ 4.8 logs; Escherichia coli, Bacillus cereus and Klebsiella pneumoniae). MB/light and MB filtration further reduced Staphylococcus epidermidis and Staphylococcus aureus to below the LOD. The small bacterium Brevundimonas diminuta was reduced by 1.7 logs by leucocyte filtration alone, and to below the LOD by additional MB/light treatment and MB filtration (≥ 3.7 logs). Suid herpesvirus 1, bovine viral diarrhoea virus and human immunodeficiency virus 1 were efficiently inactivated by THERAFLEX MB-Plasma, independent of the degree of lipaemia. THERAFLEX MB-Plasma efficiently reduces bacteria, mainly via the integrated filtration system. Its virus inactivation capacity is sufficient to compensate for reduced light transparency due to lipaemia.

Two pathogen reduction technologies—methylene blue plus light and shortwave ultraviolet light—effectively inactivate hepatitis C virus in blood products

Contamination of blood products with hepatitis C virus (HCV) can cause infections resulting in acute and chronic liver diseases. Pathogen reduction methods such as photodynamic treatment with methylene blue (MB) plus visible light as well as irradiation with shortwave ultraviolet (UVC) light were developed to inactivate viruses and other pathogens in plasma and platelet concentrates (PCs), respectively. So far, their inactivation capacities for HCV have only been tested in inactivation studies using model viruses for HCV. Recently, a HCV infection system for the propagation of infectious HCV in cell culture was developed. Inactivation studies were performed with cell culture-derived HCV and bovine viral diarrhea virus (BVDV), a model for HCV. Plasma units or PCs were spiked with high titers of cell culture-grown viruses. After treatment of the blood units with MB plus light (Theraflex MB-Plasma system, MacoPharma) or UVC (Theraflex UV-Platelets system, MacoPharma), residual viral infectivity was assessed using sensitive cell culture systems. HCV was sensitive to inactivation by both pathogen reduction procedures. HCV in plasma was efficiently inactivated by MB plus light below the detection limit already by 1/12 of the full light dose. HCV in PCs was inactivated by UVC irradiation with a reduction factor of more than 5 log. BVDV was less sensitive to the two pathogen reduction methods. Functional assays with human HCV offer an efficient tool to directly assess the inactivation capacity of pathogen reduction procedures. Pathogen reduction technologies such as MB plus light treatment and UVC irradiation have the potential to significantly reduce transfusion-transmitted HCV infections.

Updates on pathogen inactivation of plasma using Theraflex methylene blue system

Methylene blue (MB) treated plasma has been in clinical use for 15 years. The current Theraflex MB-Plasma system has a number of improved features compared with the original Springe methodology. This article gives an overview of processing methodology and recent developments, pathogen inactivation capacity, pharmacokinetics and toxicology, effects on plasma proteins and storage stability, clinical experience and future perspectives. Emphasises will be placed on most recent literature and updated information available.

The influence of methylene blue light treatment and methylene blue removal filter on fibrinogen activity states and fibrin polymerisation indices

Background-objective. Methylene blue light treatment (MBLT) is efficient in inactivating viruses in plasma. However, it may cause alterations in clotting factors, especially fibrinogen (Fg). The true mechanism of such a selective alteration is poorly understood, The effects of MBLT and MB removal filters (MBRF) on Fg concentration, functional activity and fibrin polymerisation were studied. Design. Apheresis plasma collected by Haemonetic MCS Plus ( n = 10) was split into two equal aliquots. Both were leukofiltered and virally inactivated in a standardized fashion, using Theraflex MB-Plasma Photodynamic viral inactivation Macopharma method. One of the pair was subsequently processed, using Blueflex MBRF to remove residual MB and its by-products. Control plasma samples were obtained after filtration but before MBLT. Samples were also obtained after MBLT and MBRF. All samples were analyzed for the Fg activity, Fg antigen, thrombin clotting time (TT), and alterations fibrin polymerisation indices. Results. After MBLT, mean Fg concentration increased slightly (2%) whereas functional activity decreased by 31%, as compared to control samples. Mean TT prolonged by 6 s after MBLT, with no further changes after MBRF. A similar trend was observed using RT. Both thrombin and reptilase triggered fibrin polymerisation were delayed and the polymerisation curves slopes were decreased slightly, with concomitant changes in fibrin opacity in samples from MBLT and MBRF as compared to control. Comparison is made for the first time with a similar changes observed in dysfibrinogenemia. Conclusion. MBLT resulted in about 30% decrease in Fg activity but a slight modification in fibrin polymerisation indices, with no additional alteration subsequent to MBRF. These in vitro changes are similar to those seen in plasma from patients with dysfibrinogenemia, which are usually without clinical significance.