Roma Tomatoes Research Articles

Performance evaluation of an enhanced fruit solar dryer using concentrating panels

Concentrating solar panels (CSP) improve the process of solar drying Roma tomatoes. This paper presents a performance comparison between two mixed-mode solar dryers. The dryers were identically constructed, however one of the dryers utilized mobile and easily adjustable flat concentrating solar panels to maximize incident solar energy on the dryer. Temperatures inside the dryer that utilized the concentrating solar panels were approx. 10°C higher than those in the normal dryer during the majority of a sunny day testing period. This increase in temperature led to shorter Roma tomato drying times in the dryer with CSP. The concentrating solar panels showed a considerable increase in drying rate on sunny days, with a 27% decrease in total drying time as compared to the normal dryer to reach the target dimensionless moisture content of 0.2. A less significant increase in drying capacity was achieved when the dryer was tested in simulated cloudy conditions. The faster drying rate achieved in the dryer utilizing solar concentrators, under both sunny and simulated cloudy conditions, demonstrates the ability to dry produce to an acceptable moisture content in a reasonable time, with the objective of reducing postharvest loss and preventing spoilage.

SalmonellaPopulation Rebound and Its Prevention on Spray Washed and Non-washed Jalapeño Peppers and Roma Tomatoes in Humid Storage

The potential of Salmonella population to rebound on non-washed and washed roma tomatoes and jalapeño peppers in humid storage at 4°C, 10°C, 15°C, 21°C, or 35°C for ≤12 days was investigated. The initial inoculation levels of Salmonella on peppers and tomatoes were 5.6 and 5.2 log CFU/cm(2), respectively. Air-drying of fruit surfaces resulted in contamination levels of 3.9 and 3.7 log CFU/cm(2) on inoculated peppers and tomatoes, respectively. At 21°C and 35°C, the levels of air-dried Salmonella inoculums on produce surfaces increased ≥2 log cycles, with the most rapid growth in the first 3 days. Mechanical washing on rollers (rinsing; R-treatment) or revolving brushes (rinsing and brushing; RB-treatment) with water decreased Salmonella counts by ≥2.5 log CFU/cm(2) on both peppers and tomatoes. After R- or RB-treatment, peppers stored at 21°C and 35°C permitted residual Salmonella (≤1.4 log CFU/cm(2)) to grow to 2.6-3.9 log CFU/cm(2). During storage, residual Salmonella (≤1.0 log CFU/cm(2)) on washed tomatoes increased to 3.1 log CFU/cm(2) at 35°C following R-treatment and 3.8 log CFU/cm(2) at 21°C following RB-treatment. Cold storage at 4°C and 10°C effectively prevented the proliferation of Salmonella on both washed and non-washed produce. The current study on jalapeño peppers and roma tomatoes demonstrated that Salmonella population can rebound on produce in humid storage before or after washing. The finding highlights the benefit of uninterrupted cold storage for safer produce operations.

Influence of refrigerated storage time on efficacy of irradiation to reduce Salmonella on sliced Roma tomatoes.

Contamination of tomatoes with Salmonella is a recurring food safety concern. Irradiation is a nonthermal intervention that can inactivate pathogens on fresh and minimally processed produce. However, the influence of tomato processing protocols, including time in refrigerated storage and time between slicing and irradiation, has not been determined. Roma tomatoes were sliced and inoculated with a cocktail of Salmonella outbreak strains. The inoculated tomatoes were held in refrigerated storage for various times after inoculation to simulate the potential time delay between packaging and irradiation. Tomatoes were irradiated immediately (0 h) or after 24, 48, or 72 h in storage. The surviving populations were recovered and enumerated. Irradiation effectively reduced Salmonella at all times. The D(10)-values (the dose necessary for a 1-log reduction of the pathogen) were not significantly different at each storage time and ranged from 0.382 to 0.473 kGy. These results suggest that the time required for holding of processed Roma tomatoes or shipment to an off-site irradiation service provider will not alter the efficacy of irradiation in a commercial environment.

ELECTRON BEAM IRRADIATION ON NALIDIXIC ACID‐RESISTANT SALMONELLA MONTEVIDEO IN COOKED TOMATO PUREE OF VARIOUS pH VALUES

ABSTRACT Electron beam (e‐beam) is a technology that uses ionizing radiation to destroy bacteria in a nonthermal manner. D10 values were obtained for nalidixic acid (NA)‐resistant Salmonella Montevideo in autoclaved Roma tomato puree pH adjusted to pH 3.4, 3.9, 4.4 and 4.9 and subjected to e‐beam at 0 (control), 0.5, 1.0, 1.5, 2.0 and 2.5 kGy. Survivors were enumerated using standard spread‐plating method. NA‐resistant S. Montevideo was not recovered in puree at pH 3.4 or 3.9. Significant reductions (P < 0.05) were determined at both pH 4.4 and 4.9 between the control (0 kGy) and samples exposed to≥1.5 kGy. D10 values were 1.07 and 1.50 kGy, respectively, which are greater than previously published D10 values for other Salmonella strains in various media. Tomato puree has antioxidant potential which may have provided protection against the e‐beam radiation. Radiation resistance as a result of acid adaptation may have also contributed to this effect.PRACTICAL APPLICATIONSElectron beam (e‐beam) irradiation is a nonthermal technology that uses ionizing radiation to destroy bacteria and spoilage microorganisms. Several studies have shown this technique effective for the reduction of bacterial pathogens on fruits and vegetables with no changes in texture, color or sensory quality. Some studies have suggested that the food matrix may influence sensitivity of bacterial strains to irradiation; therefore, the objective of this experiment was to determine the e‐beam radiation dose needed to achieve a one log reduction in population (D10 value) for nalidixic acid‐resistant Salmonella Montevideo in a tomato puree at low and high pHs.

The effects of X-ray radiation on Escherichia coli O157:H7, Listeria monocytogenes, Salmonella enterica and Shigella flexneri inoculated on whole Roma tomatoes

In the last two decades several foodborne disease outbreaks associated with produce were reported. Tomatoes, in particular, have been associated with several multi-state Salmonella outbreaks. Inactivation of inoculated Escherichia coli O157:H7, Listeria monocytogenes, Salmonella enterica and Shigella flexneri on whole Roma tomato surfaces by X-ray at 0.1, 0.5, 0.75, 1.0, and 1.5 kGy was studied. The main purpose of this study was to achieve a 5 log reduction in consistent with the recommendations of the National Advisory Committee on Microbiological Criteria for Foods. Moreover, the effect of X-ray on inherent microflora (mesophilic counts, psychrotrophic counts and yeast and mold counts) of untreated and treated Roma tomatoes, during storage at ambient temperature (22 °C) for 20 days was also determined. Mixtures of three or two strains of each tested organism was spot inoculated (100 μl) onto the surface of Roma tomatoes (approximately 7–9 log per tomato), separately, and air-dried, followed by treatment with X-ray doses at 22 °C and 55–60% relative humidity. Surviving bacterial populations on tomato surfaces were evaluated using a nonselective medium (tryptic soy agar) with a selective medium overlay for each bacteria; E. coli O157:H7 (CT-SMAC agar), L. monocytogenes (MOA), and S. enterica and S. flexneri (XLD). Treatment with X-ray significantly reduced the population of the tested pathogens on whole Roma tomato surfaces, compared with the control. Approximately 4.2, 2.3, 3.7 and 3.6 log CFU reduction of E. coli O157:H7, L. monocytogenes, S. enterica and S. flexneri per tomato were achieved by treatment with 0.75 kGy X-ray, respectively. More than a 5 log CFU reduction per tomato was achieved at 1.0 or 1.5 kGy X-ray for all tested pathogens. Furthermore, treatment with X-ray significantly reduced the inherent microflora on Roma tomatoes. Inherent levels were significantly ( p < 0.05) lower than the control sample throughout storage for 20 days.

Use of high-concentration-short-time chlorine dioxide gas treatments for the inactivation of Salmonella enterica spp. inoculated onto Roma tomatoes

Salmonella outbreaks have been recently linked to the consumption of fresh tomatoes. Thus, there is a need to develop systems that reduce the risk of microbial contamination to increase product shelf-life and keep fresh fruit attributes. The objectives of this study were to evaluate high-concentration-short-time chlorine dioxide gas treatments effects on Salmonella-inoculated Roma tomatoes and determine the optimal treatment conditions for microbial inactivation and shelf-life extension. Effects of ClO 2 concentration (2, 5, 8 and 10 mg/l) and exposure time (10, 30, 60, 120 and 180 s) on inoculated Roma tomatoes were studied. Salmonella enterica strains, serotype Montevideo, Javiana and Baildon, were used to experimentally inoculate the food product. After ClO 2 treatments, tomatoes were stored at room temperature for 28 days. Inherent microbial population, change in tomato color, and chlorine dioxide gas residuals were evaluated. ANOVA analysis showed that both ClO 2 concentration and treatment time were significant ( p < 0.01) for Salmonella inactivation. Surviving Salmonella populations of 3.09, 2.17 and 1.16 log CFU/cm 2 were obtained treating tomatoes with 8 mg/l ClO 2 for 60 s, 10 mg/l ClO 2 for 120 s, and 10 mg/l for 180 s, respectively (initial Salmonella population: 6.03 ± 0.11 log CFU/cm 2). The selected treatments significantly reduced background microflora ( p < 0.05), while fruit color and residual contents were not significantly different ( p > 0.05), as compared to the control. Results suggest the potential for high-concentration-short-time treatments ClO 2 gas as an effective pathogen inactivation technology for large-scale produce packing operations.

Studies on Meloidogyne javanica infestation on roma tomato (Lycopersicon esculentum Mill) under different soil amendments

The effect of different soil amendments on infestation of Meloidogyne javanica on roma tomato (Lycopersicon esculentum) was investigated at the Federal College of Agriculture, Ishiagu, Nigeria using pot experiment. Completely randomized design was used for experiment and data collected were subjected to analysis of variance (ANOVA). All significant differences observed were separated using Fisher's least significant difference (F-LSD). The parameters measured were plant height (cm) at 50% flowering, number of leaves at 50% flowering, number of fruits per plant at harvest, weight (g) of fresh fruit at harvest, number of galled roots per plant and number of galls per root per plant. The study revealed that there exist significant (P 0.05) effect on weight of fresh fruit at harvest and number of galled roots per plant. Results further showed that soil amended with organic materials (poultry droppings, grass ash and Rice husk ash) at the range of 10 to 20 t/ha were good for optimum growth, performance and control of root-knot nematode of tomato. Therefore, farmers are advised to use 20 t/ha for optimum growth and control of root knot nematode on roma tomato.

Comparison of Volatile Release in Tomatillo and Different Varieties of Tomato during Chewing

The release of volatiles from tomatillos (Physalis ixocarpa Brot.) and tomatoes in the mouthspace and nosespace was measured in real-time using selected ion flow tube mass spectrometry (SIFT-MS). (Z)-3-Hexenal, (E)-2-hexenal, hexanal, and 1-penten-3-one increased, while isobutyl alcohol, nonanal, and methylbutanal showed no significant change in the first 30 s of chewing. Cherry tomato released more (E)-2-hexenal, (Z)-3-hexenal, and 1-penten-3-one than tomatillo, Roma tomato, and vine-ripened tomato during chewing. The proportion of the average concentration of volatiles in the mouthspace after swallowing to before swallowing (MSas/MSbs) varied from 2.8% to 73.9% between different volatiles and varieties. Methylbutanal, hexanal, and nonanal were retained at a higher percentage in the mouth after swallowing than (Z)-3-hexenal, (E)-2-hexenal, 1-penten-3-one, and isobutyl alcohol. The proportion of the average volatile concentration in the mouthspace, to the headspace in a glass container (MS/HS) of 1-penten-3-one, hexanal, methylbutanal, and nonanal, and the proportion of nosespace to headspace (NS/HS) for 1-penten-3-one, hexanal, (Z)-3-hexenal, and nonanal was significantly higher in tomatillo than in tomatoes. There was no difference between tomatoes of different varieties in NS/HS ratio. The real-time volatile release from tomatillos and tomatoes was measured and compared. The information obtained on the dynamic generation of volatile compounds provides a better understanding of volatile release in the headspace of tomatillo and tomatoes. The compounds and their volatile release patterns were similar for the tomatillo and tomatoes. The green aldehydes released during chewing were not significantly higher than most tomato varieties, except for Roma tomatoes. Cherry tomato released relatively more volatiles during chewing, whereas Roma tomatoes were generally poor in mouthspace volatiles. The lingering of volatiles in the mouth after swallowing was different for different volatiles and varieties, which may appear as a sensory difference detected by consumers.

Comparison of Tomatillo and Tomato Volatile Compounds in the Headspace by Selected Ion Flow Tube Mass Spectrometry (SIFT‐MS)

The concentration of 31 volatiles were measured in the headspace of tomatillos using selected ion flow tube-mass spectrometry (SIFT-MS), and were compared with those in vine-ripened tomato, roma tomato, cherry tomato, and grape tomato. None of the volatiles were higher in the headspace of tomatillos than of tomatoes. Compounds (E)-2-octenal, (E)-2-pentenal, 2-isobutylthiazole, 6-methyl-5-hepten-2-one, and phenylacetaldehyde were significantly lower in tomatillo than in the tomato varieties in the headspace. After blending, volatiles in the headspace increased, and then decreased after reaching a maximum concentration, due to further degradation or depletion. Compounds (E)-2-pentenal and 1-penten-3-one reached a maximum concentration later than (E)-2-hexenal, (Z)-3-hexenal, and hexanal for tomatillo and tomatoes. The slope of the ratio of (E)-2-hexenal and (Z)-3-hexenal was not significantly different for any of the samples, implying that the activity of cis/trans isomerase was not different between tomatillos and tomatoes.

Identification and quantification of apo-lycopenals in fruits, vegetables, and human plasma.

Research has suggested that lycopene may be metabolized by eccentric cleavage, catalyzed by beta-carotene oxygenase 2, resulting in the generation of apo-lycopenals. Apo-6'-lycopenal and apo-8'-lycopenal have been reported previously in raw tomato. We now show that several other apo-lycopenals are also present in raw and processed foods, as well as in human plasma. Apo-lycopenal standards were prepared by in vitro oxidation of lycopene, and a high-performance liquid chromatography-tandem mass spectrometry (HPLC-MS/MS) method using atmospheric pressure chemical ionization in negative mode was developed to separate and detect the apo-6'-, apo-8'-, apo-10'-, apo-12'-, apo-14'-, and apo-15'-lycopenal products formed in the reaction. Hexane/acetone extracts of raw tomato, red grapefruit, watermelon, and processed tomato products were analyzed, as well as plasma of individuals who had consumed tomato juice for 8 weeks. Apo-6'-, apo-8'-, apo-10'-, apo-12'-, and apo-14'-lycopenals were detected and quantified in all food products tested, as well as plasma. The sum of apo-lycopenals was 6.5 microg/100 g Roma tomato, 73.4 microg/100 g tomato paste, and 1.9 nmol/L plasma. We conclude that several apo-lycopenals, in addition to apo-6'- and -8'-lycopenal, are present in lycopene-containing foods. In addition, the presence of apo-lycopenals in plasma may derive from the absorption of apo-lycopenals directly from food and/or human metabolism.

Survival and growth of acid-adapted and unadapted Salmonella in and on raw tomatoes as affected by variety, stage of ripeness, and storage temperature.

Consumption of raw round and Roma tomatoes has been associated with outbreaks of salmonellosis. A study was done to determine whether survival and growth of Salmonella in and on tomatoes is affected by variety of tomato, stage of ripeness, and storage temperature. The influence of acid adaptation of cells and site of inoculation on survival and growth was studied. Salmonella grew in stem scar and pulp tissues of round, Roma, and grape tomatoes stored at 12 and 21 degrees C but not in those tomatoes stored at 4 degrees C. Survival and growth was largely unaffected by variety and stage of ripeness at the time of inoculation. The pathogen did not grow on the skin of grape tomatoes stored at 4, 12, and 21 degrees C. Survival and growth of Salmonella inoculated into stem scar and pulp tissues of round and Roma tomatoes were unaffected by exposure of cells to an acidic (pH 4.75) environment before inoculation. Results emphasize the importance of preventing contamination of tomatoes with Salmonella at all stages of ripeness, regardless of variety or previous exposure of cells to an acidic environment.

Lycopene content in raw tomato varieties and tomato products

AbstractThis study evaluated the lycopene content in raw tomato varieties and processed tomato products. The separation of lycopene isomers was conducted by high‐performance liquid chromatography. Lycopene content was determined on a dry weight basis (DWB). The function of three different isomers (cis, all‐trans and 5‐cis) of lycopene was examined. Data for raw tomato varieties were analyzed within and among groups. Cherry tomatoes ranked the highest in lycopene content. On DWB, Roma tomatoes contained the highest lycopene concentration, while the vine tomatoes ranked the lowest in lycopene content. Among processed tomato products, tomato paste ranked the highest in lycopene content and canned tomato juice the lowest. Furthermore, tomato catsup ranked the lowest in lycopene concentration after DWB. Different dilution ratios may contribute to significant variability in lycopene content.

Microbial Survey of Selected Ontario-Grown Fresh Fruits and Vegetables

Recent produce-related outbreaks have been receiving heightened media coverage, which has increased public concern toward the safety of fresh fruits and vegetables. In response, the microbial contamination of Ontario-grown fresh fruits and vegetables was evaluated by the Ontario Ministry of Agriculture, Food and Rural Affairs during the summer of 2004. Prior to this survey, information specific to the microbial contamination of Ontario-produced fruits and vegetables was limited. This nonregulatory survey had two objectives: (i) to obtain a general microbiological profile of selected fruits and vegetables produced in Ontario and (ii) to use the information and knowledge gained from this survey to direct and support future on-farm food safety research and food safety programs to manage potential risks. In all, 1,183 samples, including muskmelon (151), scallions and green onions (173), leaf lettuce (263), organic leaf lettuce (112), head lettuce (155), parsley (127), cilantro (61), and fresh market tomatoes (141), were collected and analyzed. Samples were analyzed for Salmonella, Shigella, and generic E. coli. Enrichment cultures positive for E. coli were further assessed for verotoxigenicity. One sample each of Roma tomato and organic leaf lettuce were positive for Salmonella, with no samples yielding Shigella or verotoxigenic E. coli. The E. coli prevalence was highest in parsley (13.4%), followed by organic leaf lettuce (11.6%), leaf lettuce (6.5%), scallions (6.4%), cilantro (4.9%), muskmelon (1.3%), head lettuce (0%), and fresh market tomatoes (0%). These findings, in combination with foodborne illness data, will help target those commodities that require more focused risk mitigation efforts.

Free Galactose Content in Selected Fresh Fruits and Vegetables and Soy Beverages

The free galactose content was determined in three soy beverages, and 34 selected fruits and vegetables purchased at different times of the year and/or local markets in British Columbia, Canada. The objective of the work was to provide additional information on the free galactose content of foods to assist individuals with galactosemia in making dietary decisions. Free galactose contents in the selected plant materials ranged from 2.0 +/- 0.1 mg/100 g in red potato to 39.7 +/- 1.9 mg/100 g in red pepper. Different time of the season, variety, and storage of the product affected the free galactose contents in most of the plant materials measured in this study. Free galactose levels in kiwi, green seedless grapes, and bell peppers were found to be higher than previous reports, whereas the amount of free galactose in three varieties of tomatoes was significantly lower than previously reported. An evaluation of the change of galactose in Roma tomatoes during ripening showed that free galactose levels increased linearly over time, and storage at 4 degrees C significantly increased free galactose levels in tomatoes. Soy beverages made from soy protein isolate contained less free galactose (1.3 +/- 0.2 mg /100 g) compared to the samples made from whole soybeans (4.8 +/- 1.9 and 5.3 +/- 1.7 mg/ 100 g). This study provides additional information on the range of free galactose in fruits and vegetables which will allow individuals with galactosemia to make more informed dietary choices.

Physiological Changes in Roma-type Tomato Induced by Mechanical Stress at Several Ripeness Stages

Roma tomatoes (‘BHN 467’) were hand-harvested at mature-green color stage and treated with ethylene (100 μL·L−1 at 20 °C and 90% relative humidity) until reaching breaker (&lt;10% red), pink (30%–60% red), or light-red ripeness stage (60%–90% red). Individual fruit at each ripeness stage were subjected to double impacts over the locule using a pendulum-impact device with a force equivalent to two 40-cm drops, followed by ripening at 20 °C. Fruit exhibited most noticeable increases in respiration and ethylene production within 1 hour and 1 day after impact, respectively. After 24 hours, respiration rates increased 40%–60% regardless of ripeness stage, while ethylene production in impacted breaker-stage fruit increased 3-fold (to 6.7 μL·kg−1·h−1). Fruit impacted at breaker stage softened 2 days earlier compared with non-impacted breaker fruit. Fruit impacted at all ripeness stages had higher electrolyte leakage and polygalacturonase (PG) activity during ripening than non-impacted fruit. After 6 days, electrolyte leakage in fruit impacted at light-red ripeness stage was 23% higher than non-impacted fruit; PG activity in breaker fruit increased 40% at 10 days over non-impacted fruit. No changes were observed for soluble solids content, total titratable acidity, pH, or sugar/acid ratio from impacts, independent of ripeness stage.

Outbreak of Salmonella Braenderup infections associated with Roma tomatoes, northeastern United States, 2004: a useful method for subtyping exposures in field investigations.

Salmonella Braenderup is an uncommon serotype in the United States. In July 2004, a multistate outbreak of Salmonella Braenderup diarrhoeal infections occurred, with 125 clinical isolates identified. To investigate, we conducted a case-control study, enrolling 32 cases and 63 matched controls. Cheese, lettuce and tomato eaten at restaurants all appeared to be associated with illness. To further define specific exposures, we conducted a second study and asked managers of restaurants patronized by patients and controls about cheese, lettuce and tomato varieties used in dishes their patrons reported consuming. This information was obtained for 27 cases and 29 controls. Roma tomatoes were the only exposure significantly associated with illness (odds ratio 4.3, 95% confidence interval 1.2-15.9). Roma tomatoes from two restaurants were traced back to a single tomato packing house. The methods used in this field investigation to define specific exposures may be useful for other foodborne outbreaks.

The Key Role of Pulsed-Field Gel Electrophoresis in Investigation of a Large Multiserotype and Multistate Food-Borne Outbreak of Salmonella Infections Centered in Pennsylvania

Five different serotypes of Salmonella enterica were implicated in a large outbreak linked to fresh Roma tomatoes served at gas station deli counters in Pennsylvania and nearby states during July 2004: S. enterica serotypes Javiana, Anatum, Thompson, Typhimurium, and Muenchen. One of these serotypes, Anatum, was isolated from both tomatoes and patients. Pulsed-field gel electrophoresis (PFGE) played a key role in identifying the outbreak-associated isolates and distinguishing them from unrelated sporadic isolates. It also demonstrated that the genetic fingerprints of serotype Anatum isolates derived from patients were indistinguishable from those derived from tomatoes. Rapid communication of PFGE fingerprints with other public health laboratories through the Centers for Disease Control and Prevention's PulseNet USA national molecular surveillance network for bacterial food-borne pathogens facilitated the tracking of this outbreak in other states. The work described in this report emphasizes the laboratory's role in core public health functions and services, thereby providing a highly visible example of public health in action.

(181) 1-Methylcyclopropene Pretreatment of Roma-Type Tomato Ameliorates Effects of Physical Impact

Roma tomatoes (`Sunoma') were hand-harvested at the mature-green color stage and treated with 100 μL·L-1 ethylene for 60 h at 20 °C and 90% RH. Tomatoes at breaker ripeness stage (&lt;10% red coloration) were sorted by weight (about 100 g) and half of the fruits were treated with 1-methylcyclopropene (1-MCP; 1 μL·L-1 for 24 h at 22 °C). After 1-MCP treatment, individual fruits were subjected to double impacts over the marked locular surface with force equivalent to a 40-cm height drop using a pendulum impactor. In non-1-MCP treated fruit, impacts increased the maximum respiration rate by 27% (to 39.1 mL·kg-1 per h) and ethylene production by 24% (to 5.5 μL·kg-1 per h). Treatment with 1-MCP decreased relative production of both CO2 (56%) and ethylene (54%) over non-1-MCP treated fruit, while the ripening period (as measured by softening and color development) was extended 2.5 times, to about 8 d. Fruits treated with 1-MCP had increased TTA (about 40%; 0.58% citric acid equivalent), decreased pH (5%), and no difference in soluble solids content (3.7 °Brix); double impacts did not affect these values. Double impacts accelerated the onset of polygalacturonase (PG) activity by about 100% (to 99.8 mol·kg-1 per min*10-5 D-galacturonic acid) at day 6 over non-impacted control fruit. 1-MCP treatment delayed the onset of increased PG activity by 10 d over non-1-MCP treated fruit. Although 1-MCP alleviated the impact-induced increase in PG activity, PG activity recovered to rates similar to those of non-1-MCP treated fruit during the final 4 d of ripening.

Autoinducer-2–Like Activity on Vegetable Produce and Its Potential Involvement in Bacterial Biofilm Formation on Tomatoes

Quorum sensing employing autoinducer molecules is a strategy used by bacterial populations to coordinately modulate their response to environmental stresses and host defense mechanisms. The objectives of this study were to determine the levels of autoinducer-2 (AI-2)-like activity on selected vegetable produce and determine whether AI-2-like molecules can promote E. coli O157:H7 biofilm formation on tomatoes. Twelve different fruit and vegetable produce samples were screened for AI-2-like activity using autoinducer sensing V. harveyi biosensor strains. All samples except strawberries showed AI-2 activity albeit at varying levels, with eggplant having the highest levels. Tomatoes, when stored at 4 degrees C for 9 days, showed increasing levels of heterotrophic bacterial populations as compared to AI-2-like activity levels, which fluctuated. Rinses from Roma tomato surfaces that were stored at refrigeration temperature for up to 9 days caused a significant increase (1.8-3.6-fold as compared to the negative controls) in biofilm formation by luxS mutant (non AI-2 producing) generic E. coli and E. coli O157:H7 strains using a micro-titer plate-based biofilm assay. These results suggest that AI-2-like activity, which is present on the surfaces of tomatoes, has the potential to enhance the production of bacterial biofilms.

Inactivation of Salmonella during Drying and Storage of Roma Tomatoes Exposed to Predrying Treatments Including Peeling, Blanching, and Dipping in Organic Acid Solutions

The objective of this study was to evaluate the influence of predrying treatments, i.e., peeling, blanching prior to inoculation, and dipping in organic acid solutions, on inactivation of Salmonella during drying (60°C for 14 h) and aerobic storage (25°C for 28 days) of inoculated (five-strain composite, 7.1 to 7.4 log CFU/g) Roma tomato halves. Four predrying treatments groups were established. One group received no treatment (C). In the other three groups, unpeeled-unblanched, unpeeled-blanched (steam blanched at 88°C for 3 min), peeled-unblanched, and peeled-blanched tomato halves were immersed for 10 min in water (W), ascorbic acid solution (AA; 3.40%, pH 2.48), or citric acid solution (CA; 0.21%, pH 2.51). Appropriate dilutions of homogenized tomato samples were spread plated on tryptic soy agar with 0.1% pyruvate and XLT4 agar for bacterial enumeration during drying and storage. Ten minutes of immersion in W, AA, or CA reduced bacterial populations by 0.7 to 1.6 log CFU/g. After 14 h of dehydration, total log reductions in the populations of bacteria were 3.2 to 4.5 (C), 3.7 to 4.9 (W), >5.6 to >6.1 (AA), and 4.5 to 5.5 (CA) log CFU/g, depending on type of agar used and condition of tomato samples. During drying and storage, the order of pathogen inactivation for predrying dipping treatments was AA > CA > W > C, with AA and CA rendering bacterial populations below detectable levels (<1.3 log CFU/g) prior to storage and between 7 and 14 days of storage, respectively. The results also indicated that peeling and blanching of tomatoes prior to inoculation may not necessarily affect destruction of Salmonella during the drying process. Use of predrying acid dipping treatments of tomatoes, especially in AA, may improve destruction of Salmonella during the dehydration process.