Replicate Pens Research Articles

Research Note: Effects of on-farm and hatchery hatching on broiler performance, intestinal lesions, and immune response during a subclinical necrotic enteritis challenge

The effects of traditional and on-farm hatching systems on broiler performance and health under a subclinical necrotic enteritis (NE) challenge were evaluated in this study. A 2×2 factorial study explored the effects of place of hatch (on-farm hatched [OFH] vs. hatchery hatched [HH]) and NE challenge (nonchallenged vs. challenged) on broilers. Cobb 500 eggs (∼E19) were acquired from a commercial hatchery; 840 eggs were placed in pens on clean shavings in prewarmed floor pens and allowed to hatch out, while 927 eggs were placed in a hatcher set under standard practices. On day (d) of hatch, all chicks were weighed and randomly distributed to 4 treatments (8 replicate pens each and 30 birds/pen). The OFH birds were placed immediately after sorting while HH birds were placed back in the hatcher overnight to simulate commercial hatchery procedures. After placing HH birds, feed and litter in the challenge group pens were sprayed with a live oocyst coccidia vaccine as a predisposing factor to NE. The small intestines of 3 male chicks per pen were scored for NE lesions (n = 24) on d 8 (peak NE challenge) and jejunal samples were collected from 1 bird per pen for RNA extraction and qPCR on d 8 and d 14. Data were analyzed using JMP Pro17 and significance between treatments was identified by LSD (P ≤ 0.05). Regardless of the hatching system, the subclinical NE challenge caused a significant reduction in average daily gain (ADG) and average daily feed intake (ADFI), and increased feed conversion ratio (FCR) until d 28 (P ≤ 0.05). Moreover, OFH birds exhibited significantly better growth (P ≤ 0.05) through d 28 but had similar performance to HH birds by d 42. There were no significant differences in NE lesion scores between HH and OFH groups. In conclusion, OFH system resulted in better broiler performance compared to HH system under both no-challenge and challenge conditions during the starter and grower periods. This practice may hold potential for further exploration by the industry as an alternative to traditional hatching, aiming to improve the welfare and productivity of broilers.

Dietary supplementation of valine, isoleucine, and tryptophan may overcome the negative effects of excess leucine in diets for weanling pigs containing corn fermented protein

BackgroundDiets with high inclusion of corn co-products such as corn fermented protein (CFP) may contain excess Leu, which has a negative impact on feed intake and growth performance of pigs due to increased catabolism of Val and Ile and reduced availability of Trp in the brain for serotonin synthesis. However, we hypothesized that the negative effect of using CFP in diets for weanling pigs may be overcome if diets are fortified with crystalline sources of Val, Trp, and (or) Ile.MethodsThree hundred and twenty weanling pigs were randomly allotted to one of 10 dietary treatments in a completely randomized design, with 4 pigs per pen and 8 replicate pens per treatment. A corn-soybean meal diet and 2 basal diets based on corn and 10% CFP or corn and 20% CFP were formulated. Seven additional diets were formulated by fortifying the basal diet with 20% CFP with Ile, Trp, Val, Ile and Val, Ile and Trp, Trp and Val, or Ile, Trp and Val. A two-phase feeding program was used, with d 1 to 14 being phase 1 and d 15 to 28 being phase 2. Fecal scores were recorded every other day. Blood samples were collected on d 14 and 28 from one pig per pen. On d 14, fecal samples were collected from one pig per pen in 3 of the 10 treatments to determine volatile fatty acids, ammonium concentration, and microbial protein. These pigs were also euthanized and ileal tissue was collected.ResultsThere were no effects of dietary treatments on any of the parameters evaluated in phase 1. Inclusion of 10% or 20% CFP in diets reduced (P < 0.05) final body weight on d 28, and average daily gain (ADG) and average daily feed intake (ADFI) in phase 2 and for the entire experimental period. However, pigs fed the CFP diet supplemented with Val, Ile, and Trp had final body weight, ADFI, ADG and gain to feed ratio in phase 2 and for the entire experiment that was not different from pigs fed the control diet. Fecal scores in phase 2 were reduced (P < 0.05) if CFP was used.ConclusionsCorn fermented protein may be included by up to 20% in diets for weanling pigs without affecting growth performance, gut health, or hindgut fermentation, if diets are fortified with extra Val, Trp, and Ile. Inclusion of CFP also improved fecal consistency of pigs.

Lactobacillus delbrueckii alleviates lipopolysaccharide-induced muscle inflammation and atrophy in weaned piglets associated with inhibition of endoplasmic reticulum stress and protein degradation.

Pro-inflammatory cytokines in muscle play a pivotal role in physiological responses and in the pathophysiology of inflammatory disease and muscle atrophy. Lactobacillus delbrueckii (LD), as a kind of probiotics, has inhibitory effects on pro-inflammatory cytokines associated with various inflammatory diseases. This study was conducted to explore the effect of dietary LD on the lipopolysaccharide (LPS)-induced muscle inflammation and atrophy in piglets and to elucidate the underlying mechanism. A total of 36 weaned piglets (Duroc × Landrace × Large Yorkshire) were allotted into three groups with six replicates (pens) of two piglets: (1) Nonchallenged control; (2) LPS-challenged (LPS); (3) 0.2% LD diet and LPS-challenged (LD+LPS). On d 29, the piglets were injected intraperitoneally with LPS or sterilized saline, respectively. All piglets were slaughtered at 4 h after LPS or saline injection, the blood and muscle samples were collected for further analysis. Our results showed that dietary supplementation of LD significantly attenuated LPS-induced production of pro-inflammatory cytokines IL-6 and TNF-α in both serum and muscle of the piglets. Concomitantly, pretreating the piglets with LD also clearly inhibited LPS-induced nuclear translocation of NF-κB p65 subunits in the muscle, which correlated with the anti-inflammatory effects of LD on the muscle of piglets. Meanwhile, LPS-induced muscle atrophy, indicated by a higher expression of muscle atrophy F-box, muscle RING finger protein (MuRF1), forkhead box O 1, and autophagy-related protein 5 (ATG5) at the transcriptional level, whereas pretreatment with LD led to inhibition of these upregulations, particularly genes for MuRF1 and ATG5. Moreover, LPS-induced mRNA expression of endoplasmic reticulum stress markers, such as eukaryotic translational initiation factor 2α (eIF-2α) was suppressed by pretreatment with LD, which was accompanied by a decrease in the protein expression levels of IRE1α and GRP78. Additionally, LD significantly prevented muscle cell apoptotic death induced by LPS. Taken together, our data indicate that the anti-inflammatory effect of LD supply on muscle atrophy of piglets could be likely regulated by inhibiting the secretion of pro-inflammatory cytokines through the inactivation of the ER stress/NF-κB singling pathway, along with the reduction in protein degradation.

Evaluation of Dietary Supplementation of a Multi-Carbohydrase Enzyme Complex on Growth Performance and Carcass Traits of Pekin Ducks Fed Corn–Soy Based Diets

The present study investigated the effect of supplementing a multi-carbohydrase enzyme complex (MCE) in corn–soy-based diets of Pekin ducks. The treatments were as follows: positive control (PC, 2980 and 3120 kcal/kg for starter and grower, respectively); negative control (NC, −132 kcal/kg energy reduction to PC achieved by reduction of fat and wheat middlings as filler); NC + MCE at 75 ppm (E75); 100 ppm (E100); and 125 ppm (E125) randomly distributed in 10 replicate pens with 25 birds each. Performance was evaluated after 14 and 35 d. On day 36 of the trial, five ducks/pen were processed to evaluate carcass traits. During days 1–14, the PC had a lower (p &lt; 0.01) feed intake compared to all other treatments. At 14 and 35 d of age the NC decreased (p &lt; 0.001) the body weight (BW) of the ducks compared to the PC by −8.3% and −5.3%, respectively. The NC BW was lower (p &lt; 0.001) compared to all MCE-supplemented treatments at 14 and 35 d. The BW of E75, E100, and E125 treatments was not different (p &gt; 0.05) from the PC at both evaluation periods. Cumulatively (1–35 d), the NC resulted in a weight-adjusted FCR increase (p = 0.001) of 9.9% compared to the PC, and the FCR of E75, E100, and E125 were able to recover 72.3%, 66.4%, and 63.5%, respectively, compared to the PC. The carcass and breast weights were lower (p &lt; 0.001) in the NC compared to all other treatments, and no differences (p &gt; 0.05) were observed between the MCE-supplemented treatments and the PC. In conclusion, these results suggest that the MCE supplementation can maintain duck growth performance with no negative effects on carcass traits in energy-reduced corn–soybean meal-based diets. From the results of the trial, 75 ppm MCE delivered the best performance recovery and 125 ppm MCE supplementation had the best % breast yield.

Effects of wheat-based fermented liquid feed on growth performance, nutrient digestibility, gut microbiota, intestinal morphology, and barrier function in grower-finisher pigs.

Fermented liquid feed (FLF) can improve dietary nutrient absorption levels, degrade anti-nutrient factors in diets, and increase beneficial bacteria abundance in animal guts. However, few systematic studies have been conducted on WFLF in pigs. The present study evaluates the effects of WFLF on the growth performance, nutrient digestibility, gastric volume, intestinal morphology, intestinal health, intestinal barrier function, serum biochemical immunity, gut microbiota, and intestinal microbial diversity of grower-finisher pigs. In total, 80 weaned pigs were randomly allocated to two treatment groups based on their initial body weight: a basal diet with pellet dry feeding (CON) and a basal diet with wheat-based fermented liquid feed (WFLF), with four replicate pens per group. The experiment lasted 82 d. Compared with CON pigs, those fed WFLF were heavier significantly at 60-82 d and had significantly higher average daily feed intake, average daily gain, and gain: feed ratio at 60-82 d and 1-82 d. WFLF pigs had significantly greater jejunum, total tract, and ileal digestibility for all nutrients and amino acids, excluding arginine, than CON pigs. WFLF intake influenced villus height, villus height: crypt depth ratio of the anterior segment of the jejunum(A-jejunum), crypt depth, and redox potential of the posterior segment of the jejunum (P-jejunum) while significantly affecting body weight. Additionally, FLF improved gastric capacity significantly. Furthermore, mRNA expression of occludin and claudin-1 in the mucosa of the ileum and jejunum was significantly higher in WFLF pigs than in CON pigs. WFLF increased serum concentrations of alanine transaminase and reduced low-density lipoprotein cholesterol, total cholesterol, and total bile acid content. The alpha diversity (Shannon and Simpson indices) in the stomachs of WFLF pigs was significantly higher than in CON pigs. Microbial diversity in the stomach, ileum, and cecum, as well as the abundance of lactic acid bacteria, were increased in WFLF pigs compared to CON pigs. In conclusion, WFLF intake may positively influence intestinal ecology by improving digestive tract structure, upregulating intestinal barrier-related genes, and improving intestinal morphology to enhance intestinal digestive function and health. Collectively, the present study shows that WFLF intake can increase growth performance while maintaining beneficial nutrient digestibility in grower-finisher pigs.

Maternal chromium supplementation improves oxidation resistance, immunity, and intestinal morphology of goat kids injected with lipopolysaccharide

This study evaluated the effects of maternal chromium (Cr), supplemented with Cr propionate (CrPro) during perinatal period of does, on antioxidant capacity, immune response, and intestinal morphology of goat kids injected with lipopolysaccharide (LPS). Forty LeZhi black does at 90 days of pregnancy were divided into four groups based on body weight (52.36±8.24 kg) with 10 replicate pens for each treatment and one doe for each replicate pen. Treatments consisted of 0, 0.4, 1.2, or 2.0 mg of supplemental Cr per head per day (head-1 d-1) from CrPro. After birth, the goat kids were allowed to suckle until 21 days. At 21-day-old, one male goat kid per replicate was sacrificed 2 h after LPS injection. Individual weight and litter weight of goat kids on birth and 21 d were not affected by maternal Cr supplementation. Chromium concentrations in umbilical cord, colostrum and liver of goat kids were linearly increased by maternal Cr supplementation (P<0.05). Maternal Cr supplementation quadratically increased serum total superoxide dismutase (T-SOD) activity of goat kids (P<0.05). Goat kids from maternal Cr supplementation groups had higher serum T-SOD activity than those from control group (P<0.05). Serum malondialdehyde (MDA) concentration of goat kids was linearly decreased, whereas serum glutathione peroxidase (GSH-Px) activity was linearly increased as maternal Cr increased (P<0.05). Maternal Cr supplementation linearly increased colostrum immunoglobulin A (IgA), immunoglobulin G (IgG) and immunoglobulin M (IgM) concentrations (P<0.05), and quadratically increased serum IgG and IgM concentration of goat kids with the greatest response detected at 0.4 mg head-1 d-1 maternal Cr supplementation group (P<0.05). The villus height (VH) and the ratio of villus height to crypt depth (V/C) in duodenum of goat kids increased quadratically as maternal Cr increased, and both reached the highest in maternal 1.2 mg head-1 d-1 maternal Cr supplementation group. Maternal Cr supplementation linearly decreased ileal crypt depth (CD) of goat kids. The results indicate that 0.4-2.0 mg (0.47-2.41 mg by analysis) head-1 d-1 maternal Cr supplementation from CrPro could improve antioxidant capacity, immune response, and small intestinal morphology of goat kids injected with LPS.

Diets containing phytobiotics, l-arginine, vitamin E and captopril modulate ascites syndrome-related genes expression in broiler chickens exposed to low ambient temperature.

Our hypothesis centred on the potential to mitigate ascites outbreaks in birds exposed to cold stress by inhibiting pulmonary artery contraction through dietary intervention. This study aimed to evaluate the effect of natural and synthetic medications on growth performance, ascites-related parameters and the expression of ascites-related genes in the lung tissue of broiler chickens under low ambient temperature. We randomly assigned 450 one-day-old male Ross 308 chicks to six dietary treatments across five replicate pens, each containing 15 chicks. The treatments included a basal diet (control), and the basal diet was supplemented with hydroalcoholic extracts of sumac (HES, 200mg/kg), Syrian mesquite (HEM, 200mg/kg), l-arginine (40% above requirement), captopril (15mg/kg) and vitamin E (100mg/kg). Diets containing HEM, l-arginine and vitamin E resulted in increased average daily gain on days 8-14 and 0-28, whereas HES showed a similar effect only during days 8-14 compared to the control diet (p<0.05). Additionally, feed additives decreased packed cell volume, left and right ventricle volumes and systolic blood pressure (p<0.05). Moreover, chickens fed the control and l-arginine diets exhibited higher levels of angiotensin converting enzyme (ACE) mRNA in lung tissue compared to those fed HES, HEM and captopril (p<0.05). Meanwhile, supplementation with HEM and l-arginine increased the expression of inducible nitric oxide synthase (iNOS) mRNA in lung tissue compared to other treatments (p<0.05). Regarding Cu/Zn-superoxide dismutase (Cu/Zn-SOD) expression, feed additives increased mRNA level in lung tissue, except for captopril (p<0.05). This study demonstrates that the plant extracts may reduce the incidence of ascites syndrome not only through their antioxidant properties but also by modulating the expression of ACE, iNOS and Cu/Zn-SOD genes.

Effects of heat stress mitigation strategies on feedlot cattle performance, environmental, and economic outcomes in a hot climate

The increase in average global temperatures presents a challenge for the beef industry, especially in the feedlot sector where heat stress is a major animal welfare and economic concern. Shade is one of the most practical methods to mitigate heat stress in feedlot cattle. An experiment was conducted as a completely randomized design with 1 560 Bos indicus bulls (initial BW=287 kg) where three shade structure types were used to investigate the effects of different heat stress mitigation methods on cattle growth performance, environmental, and economic outcomes using live animal data, and a partial lifecycle assessment using the Integrated Farm System Model. The live animal portion of the experiment was done once a year over a 2-year period with three pen replications per treatment per year (n = 6 per treatment). Four shade structures used were conventional shade (SC; steel shade 1.8 m2 of shade/animal), double conventional shade (DS; steel shade 3.6 m2 of shade/animal), dome structures without fans (DSA; 8.5 m2/animal with 98% solar radiation blocked), and domes with fans (DCA; DSA plus three large sized low-speed fans). Each pen held 65 bulls in an area of 570 m2. Live animal data were analyzed as a completely randomized design using the GLM procedure of SAS (version 9.4) with shade type as fixed effect, pen as the experimental unit, and repetition (year) considered a random effect. Cattle housed under DCA had 22 and 20 kg heavier final body BW (P < 0.05) compared to those housed under SC and DS, respectively. Final BW of DCA and DSA cattle were similar (P > 0.05). Average daily gain, feed efficiency, and hot carcass weight were greater (P < 0.05) for cattle housed under DCA compared to the rest of the shade types. Dry matter intake was not affected (P > 0.05). When treatment results were extrapolated to the annual feedlot turnover of 209,700 animals, cattle in DSA and DCA versus SC and DS had 3–8% reductions in greenhouse gas and ammonia emission intensities. Compared to SC, DCA increased profitability by $29.66/animal, followed by DSA and DS with profit increases of $5.79 and $8.90/animal, respectively. Overall, the implementation of advanced shade structures improved cattle performance and profitability while reducing the environmental impact of beef production.

Assessment of Novel Protein Ingredient Arthrospira platensis and Soybean Genotype Amino Acid and Oil Selection Improvements on Broiler Performance for a 28–42 d Feeding Period

Two experiments were conducted to assess the efficiency of including the novel protein ingredient Arthrospira platensis or improved soybean meal in a broiler diet. The first experiment aimed to determine the feeding value of soybean meal produced from varieties of soybeans bred for increased amino acid content (SBAA) and improved oil content (SBO) compared to a conventional soybean variety in an ANOVA design fed to Cobb 500 female broilers for 28–42 d. The SBAA and SBO soybeans contained overall higher amino acid content and lower oligosaccharide content compared to the conventional soybean variety in addition to improved oil quality. The second experiment assessed the novel protein ingredient microalgae, Arthrospira platensis (algae), and was conducted to evaluate algae and corn distillers’ grain (DDGS) inclusion on broiler performance for a 28–42 d feeding period in Cobb CF05 male broilers with a 2 × 2 factorial treatment array. Prior to the experimental period, all birds were reared on common feeds. In Experiment 1, birds were fed a diet containing 20% inclusion of an experimental soybean source in the form of full-fat soybean meal. In Experiment 2, the four dietary treatments consisted of diets containing algae at inclusion levels of either 0 or 2% and DDGS at inclusion levels of 0% and 8%. Diets were fed to 288 female broilers (Experiment 1) and 384 male broilers (Experiment 2), placed in eight replicate pens of twelve birds, and live performance was assessed from d 28 to 42. At d 42, six birds from each pen were randomly selected and processed for evaluation of carcass traits and incidence of woody breast. For Experiment 1, all performance data were analyzed using a one-way ANOVA using JMP Pro 16 software with diet as the fixed effect and block as a random effect. Statistical significance was considered at p ≤ 0.05. No significant responses were observed for any recorded measurement for live performance, carcass traits, or woody breast. All data in Experiment 2 were analyzed as a full factorial with a mixed model using JMP software with algae, DDGS, and algae × DDGS as fixed effects and block as a random effect. The F-protected Fisher’s LSD test was used to separate means when p ≤ 0.05. No significant responses were observed for the algae, DDGS, and algae × DDGS influences on BWG, FI, and FCR or processing characteristics; the ingredient source did not affect bird performance. Experimental soybean lines developed at the University of Arkansas were able to be incorporated into broiler diets without decreasing performance. Algae has the potential to be a protein-contributing ingredient for broilers.

Effects of single and complex probiotics in growing-finishing pigs and swine compost.

This study was conducted to supplement single and complex probiotics to investigate the effect on growing-finishing pigs and compost. In experiment 1, the 64 crossbred ([Landrace × Yorkshire] × Duroc) pigs with an initial body weight of 18.75 ± 0.33 kg and a birth of 63 days were assigned to a completely randomized four treatment groups based on the initial body weight (4 pigs in a pen with 4 replicate pens for each treatment). For 13 weeks, the dietary treatments were provided: 1) Control (CON; basal diet), 2) T1 (CON + 0.2% Bacillus subtilis), 3) T2 (CON + 0.2% Saccharomyces cerevisiae), 4) T3 (CON + 0.2% Bacillus subtilis + 0.2% Saccharomyces cerevisiae). In experiment 2, the pig manure was obtained from Chungbuk National University (Cheongju, Korea) swine farm. For 12 weeks, the supplementary treatments were provided: 1) CON, non-additive compost; 2) T1, spray Bacillus subtilis 10 g per 3.306 m2; 3) T2, spray Bacillus subtilis 40 g per 3.306 m2; 4) T3, spray Saccharomyces cerevisiae 10 g per 3.306 m2; 5) T4: spray Saccharomyces cerevisiae 40 g per 3.306 m2; 6) T5, spray Bacillus subtilis 5 g + Saccharomyces cerevisiae 5 g per 3.306 m2; 7) T6, spray Saccharomyces subtilis 20 g + S. cerevisiae 20 g per 3.306 m2 and there were 6 replicates each treatment. In experiment 1, During the overall experimental period, T3 showed significantly improved (p < 0.05) feed conversion ratio and average daily gain compared to other groups. In average maturity score, T3 showed significantly higher (p < 0.05) than other groups. Supplementing complex probiotics group improved (p < 0.05) H2S emissions and fecal microflora compared to the non-supplementing group. In experiment 2, additive probiotics groups had no effect (p > 0.05) on moisture content than the non-additive group at 9 and 12 weeks. T6 showed a significantly improved (p < 0.05) average maturity score at all periods and ammonia emissions at 1 week and 4 weeks compared to other groups. In summary, supplementation complex probiotics induced positive effects on both pigs and compost.

Effects of Micellar Quercetin Supplementation on Growth Performance, Nutrient Digestibility, Fecal Microbiota, Meat Quality, and Physiological Status in Broiler Chickens.

This study investigated the impacts of micellar quercetin (MQ) supplementation on growth performance, meat stability, excreta gas emissions, and physiological status. During a 35-day trial, 640 Ross 308 broilers were utilized. These birds were one day old, with an average initial body weight of 43.34 ± 1.43 g. They were randomly distributed across four experimental diets, each consisting of 10 replicate pens with 16 chicks per pen. The diets included the following: control (CON) with 0% micellar quercetin (MQ), TRT1 with 0.025% MQ, TRT2 with 0.050% MQ, and TRT3 with 0.100% MQ. The results indicate that broilers fed diets with increasing levels of MQ exhibited significantly higher body weight gains (BWGs) compared to the control group (p < 0.05). There was a clear linear increase in the breast muscle percentage with higher levels of quercetin supplementation (p < 0.05), while the breast color remained consistent across all groups (p > 0.05). Both cooking loss and drip loss exhibited a linear decrease as MQ levels in the diet increased (p < 0.05). The level of aspartate aminotransferase (AST) tended to decrease with higher MQ levels. Thyroxine (T4) and lymphocyte levels also showed a linear increase with increasing MQ dosage in the diet (p < 0.05). However, no significant effects were observed on nutrient digestibility, gas emissions, or fecal microbial components (Lactobacillus, E. coli, and Salmonella) with higher levels of MQ supplementation (p > 0.05). In conclusion, augmenting quercetin levels in the diet positively influenced the BWG, breast muscle development, and meat quality parameters such as cooking loss and drip loss, with beneficial effects on blood profiles.

Growth, nutrient uptake, blood metabolites and bone properties in broilers consuming feed with mineral-enriched whole black soldier fly larvae

Abstract The recycling of minerals is crucial for the future circular agriculture. Black soldier fly larvae (BSFL) can accumulate minerals in their body. This study investigated the effects of adding mineral-enriched BSFL, grown on substrates containing sewage sludge recyclates (SSR), to broiler feed to reintroduce minerals from waste streams currently subject to regulatory restrictions back into the nutrient cycle. Feed, nutrient, mineral and heavy metal intake, growth, blood metabolites and immunoglobulins, bone characteristics and mineral status of broilers were studied in response to different mineral-enriched BSFL supplements. Eighty newly-hatched mixed-sex Ross 308 chicks were divided into four groups, with six replicate pens per group. BSFL used in the broiler experiment were grown either on a modified Gainesville fly diet (FD) (L-FD) or on FD supplemented with 4% of sewage sludge biochar (L-BCH), or on the FD supplemented with Single Superphosphate (SSP) SSR (L-SSP). All broilers were fed age-specific diets and either had no access to BSFL (CON) or received 15% of CON birds’ feed intake as defrosted BSFL from three different sources. Inclusion of 15% of mineral-enriched whole BSFL in broiler rations had no adverse effects on growth performance parameters, nutrient intakes, nutrient conversion efficiency, plasma metabolites and immunoglobulins (). Birds in BSFL supply groups had higher serum Ca concentrations than CON birds (). L-BCH supplied birds had a lower serum P than CON birds (). Tibial characteristics and mineral status of birds were not affected by larvae supply (). Heavy metal intake (manganese, iron, zinc, copper, arsenic, cadmium, lead, and mercury) of the birds was not affected by dietary treatments (). In conclusion, 15% of mineral-enriched-BSFL reared on SSP can be included in broiler diets for 42 experimental days without adverse effects on nutrient intakes, growth performance parameters and bone condition.

Dietary effects of Sclerocarya birrea caffra seed cake replacing soyabean meal on physiology, meat and bone quality of indigenous chickens

This study investigated marula seed cake (MSC) as alternative protein source (APS) replacing soyabean meal (SBM) in indigenous chicken diets. Four hundred, 3-week-old Boschveld chicks were randomly allocated to 5 iso-energetic-nitrogenous maize and SBM-based grower diets with 0, 10, 15, 20, and 25 % MSC, each with 5 replicate pens of 16 birds, in a completely randomised design (CRD), for 9 weeks. Results showed that dietary MSC quadratically decreased bird overall feed intake (FI) (P < 0.001) and body weight gain (BWG) (P < 0.01) as it linearly decreased the weights of hot carcass (HCW; P < 0.05), spleen (P < 0.05), jejunum (P < 0.05), ileum (P < 0.001), and caecum (P < 0.001). In contrast, MSC increased chicken serum glucose (P < 0.05), cholesterol (P = 0.001) and phosphate (P < 0.05) as it decreased its amylase activity (P < 0.01). Also, it decreased bird meat lightness at 45 min (P < 0.05) and its yellowness at 45 min (P < 0.001) and 24 h (P < 0.001) whilst it increased its redness at 45 min (P < 0.01) and 24 h (P < 0.05) post-slaughter. In addition, MSC decreased chicken bone medial diaphysis (P < 0.05) as it induced no effects (P > 0.05) on overall feed conversion efficiency (FCE) and all other parameters. In conclusion, feeding of ≤ 15 % dietary MSC is nutritionally safe for indigenous chickens whilst detrimental on bird appetite, growth and meat yield, however without significantly affecting their physiology, at higher inclusion levels.

Effects of in ovo feeding of xylobiose and xylotriose on growth performance, carcass traits, ileal histomorphometry, and immune-related gene expression in broiler chickens

Xylooligosaccharides (XOS) are known as prebiotics which promote beneficial gut microbes, improve gut health and the performance of broilers. Xylobiose (XOS2) and xylotriose (XOS3) are two compounds in the XOS group. In ovo feeding could deliver these prebiotics to the embryo, and this is considered as an effective method for studying the effects of the prebiotics during embryonic development and the post-hatch period. This study investigated the effects of in ovo feeding of XOS2 and XOS3 on growth performance, carcass traits, ileal histomorphometry, and immune-related gene expression in broilers. A total of 144 fertilized eggs of Cobb 500 broilers were divided into three groups: (a) non-injected control (CON), (b) XOS2, and (c) XOS3. The eggs from XOS2 and XOS3 groups were injected with 0.5 ml of 0.85% normal saline solution containing 3 mg of XOS2 and 3 mg of XOS3, respectively, into their amniotic sac on the 17th embryonic day. A total of 131 hatched chicks were raised in 18 replicate pens (5 or more chicks per pen) following standard management practices and fed a corn-soybean meal-based diet for 21 days. The feed intake and body weight (BW) data were recorded weekly. The chickens were euthanized on day 7, day 14, and day 21 to collect ileum sections, and the carcass traits were recorded on only day 21. Total RNA was extracted from ileum tissues, and qPCR was performed to measure the gene expression. All the statistical analyses considered the significance level at a P value <0.05. The result showed that in ovo treatments did not affect the hatchability of the eggs. The XOS2 group showed a trend to increase the BW on day 0, compared to CON (P=0.052), and the XOS3 group showed better FCR improvement than the XOS2 group in the first week. There was no difference (P>0.05) among the groups for the weight of the breast muscle, drumsticks, gizzard, proventriculus, and carcass weight at the age of 21 days. The histomorphometry of the ileum on day 7 revealed a significant reduction (P<0.05) of villi height (VH), villi width (VW), and crypt depth (CD) in XOS2, compared to the CON group. On day 7, a lower CD and a higher VH to CD ratio were recorded in XOS3, compared to CON. On day 14, XOS3 showed an increase in VW and villi surface area (VSA) compared to XOS2 birds. On day 7, the expression of IL10 in XOS2 was higher compared to CON and XOS3, and CD56 was significantly higher (P<0.05) in the XOS2 compared to CON group. On day 21, the XOS2 and XOS3 significantly lower the expression of IFNγ. Overall, XOS2 and XOS3 significantly increased immunity until day 21. In conclusion, in ovo XOS feeding demonstrated the potential to modulate gut morphology and immunity of the chickens during the post-hatch days.

PSII-21 Feed intake and growth of young turkeys in the brood when supplemented with Viribus Essentials, a blend of botanical extracts and natural flavors

Abstract The objective of this experiment was to determine the effect of adding Viribus Essentials (VB) on top of standard commercial brood diets on the performance and survivability of young turkeys in a large-scale commercial research facility. A total of 1,360 hybrid turkey toms were randomly assigned to 2 dietary treatments in a completely randomized design for a 42-d trial. There were 85 turkeys per pen and 8 replicate pens per treatment. The 2 dietary treatments were 1) CONTROL a standard set of commercial turkey brood rations (Starter, Grower), and 2) CONTROL + 1,362 grams per ton of VB in Starter and Grower. Body weight and feed disappearance were recorded by pen for d 0 to 42 to calculate average daily gain, average daily feed intake, and feed conversion ratio. The Grubb’s test was used to check data for outliers with P &amp;lt; 0.05 as the level of significance for eliminating a replicate; no replicates were removed. Data were used to calculate all parameters and were analyzed using the GLM procedure in Minitab with Fisher’s t-test determining differences between treatments. Results from this trial are shown in Table 1. VB improved feed intake by 4.6% (P &amp;lt; 0.05), which resulted in improved average daily gain (ADG) by 3.8% (P &amp;lt; 0.01), with no change in feed conversion ratio (FCR) or Mortality adjusted FCR. Survivability was numerically increased by 1.1% (P = 0.367). Overall, the supplementation of VB increases the body weight of the turkey toms at the end of the brood by 4.7% (P &amp;lt; 0.01) which is an important indicator for the lifetime performance of turkeys.

49 Effects of xylanase or a stimbiotic on growth performance and total tract digestibility of nutrients by pigs weaned from sows fed a lactation diet without or with xylanase

Abstract Two hypotheses were tested 1) the offspring of sows fed xylanase in lactation have greater growth performance after weaning than offspring of sows fed no xylanase, and 2) xylanase and a stimbiotic (i.e., xylanase in combination with xylo-oligosaccharides) improve growth performance, apparent total tract digestibility (ATTD) of gross energy (GE) and total dietary fiber (TDF), and digestible energy (DE) of diets for weanling pigs. A total of 120 newly weaned pigs from sows fed a lactation diet without xylanase and 120 pigs from sows fed a lactation diet containing 16,000 beechwood xylanase units (BXU) per kg of an exogenous xylanase were used [initial body weight (BW) = 5.81 ± 0.50 kg]. Pigs were allotted to a 2 × 3 factorial with two sow groups (lactation diet without or with xylanase) and three dietary treatments (i.e., control, control plus 100 g/t of xylanase, or control plus 100 g/t of stimbiotic). The xylanase (Econase XT) and the stimbiotic (Signis) were procured from AB Vista, Marlborough, UK. Pigs were weaned in 4 blocks and allotted to 12 pens per block, with 5 pigs per pen for a total of 8 replicate pens per treatment. Pigs were fed phase 1 diets from d 1 to 14, phase 2 diets from d 15 to 28, and phase 3 diets from d 29 to 42 post-weaning. Average daily gain (ADG), average daily feed intake (ADFI), and gain to feed ratio (G:F) were calculated. Fecal samples were collected at the end of phases 2 and 3. Data were analyzed using the MIXED procedure of SAS. Sow group, diet, and the interaction between sow group and diet were fixed effects, and block and replicate within block were random effects. Results indicated that for the overall experiment, there were no interactions between sow group and diet, and sow lactation diet treatment did not impact any post-weaning growth or digestibility parameters in the weaned pigs (Table 1). However, weaned pigs had greater (P &amp;lt; 0.05) ADG, G:F, ATTD of GE and TDF, and DE in phase 2 if fed the diet with stimbiotic than if fed the xylanase diet or the control diet, but pigs fed the xylanase diet had greater (P &amp;lt; 0.05) ADG, G:F, ATTD of GE and TDF, and DE than pigs fed the control diet (Table 2). In phase 3, pigs fed the diet with xylanase or stimbiotic had greater (P &amp;lt; 0.05) ADG, ATTD of GE and TDF, and DE than pigs fed the control diet. In conclusion, pigs fed diets containing xylanase or stimbiotic had greater nutrient digestibility and DE, resulting in greater overall ADG, G:F, and final body weight on d 42 post-weaning, but feeding sows xylanase in lactation did not influence post-weaning growth performance.

47 Application of a ‘high’ or ‘low’ energy matrix to a nutrient-reduced diet supplemented with a novel phytase maintained growth performance and conferred production and sustainability benefit

Abstract This study assessed the capacity of a novel consensus bacterial 6-phytase variant (PhyG) to maintain growth performance of weaned pigs when added to a nutrient-reduced mixed cereal diet with two levels of dietary net energy (NE) reduction applied. A total of 360 newly weaned pigs [Greater York × Norsvin Landrace; initial body weight (BW) 8.4 ± 0.78 kg] were assigned to 60 floor-pens and 5 dietary treatments in a randomized complete block design. There were 2 blocks (weaning group), 6 replicate pens per block, and 6 pigs/pen (3 male, 3 female), in total of 12 replications per treatment. Diets were based on wheat, corn, barley, and soybean meal and were offered to pigs in 2 phases in pelleted form (0–14 and 14–35 d post-weaning). Treatments comprised a nutritionally adequate positive control (PC) and 4 negative control (NC) diets supplemented with PhyG. The NC diets were reduced in digestible P, Ca, Na, and digestible amino acids vs. PC, according to the expected contribution of PhyG added at 1,000 phytase units (FTU)/kg (NC1) or 2,000 FTU/kg (NC2), respectively. Each NC1 and NC2 was formulated at two NE reduction levels, designated ‘low’ and ‘high’ (‘low’: -53 to -65 kcal/kg and ‘high’: -73 to -86 kcal/kg, vs. PC at 1,000 and 2,000 FTU/kg PhyG, respectively). Data were analyzed by ANOVA. Means separation was by Tukey’s HSD test. During both phases and overall (0–35 d), average BW, average daily gain (ADG), average daily feed intake (ADFI), and feed conversion ratio (FCR) in all PhyG-supplemented, nutrient- and NE-reduced treatments, were either not different or were improved compared with the PC. Overall ADG, ADFI, and final BW (d 35) were greater in NC2+PhyG 2,000 FTU/kg ‘low’ vs. PC (466 vs. 424 g, 9.9%, 622 vs. 567 g, 9.7%, and 24.7 vs. 23.1 kg, 6.9%, respectively; P &amp;lt; 0.05). Total feed costs (ingredients price, February 2023) and estimated carbon footprint (CFP; FeedPrint, WUR, The Netherland) per kilogram of BW gain (BWG) were reduced in all PhyG-supplemented, nutrient- and NE-reduced treatments vs. PC. Feed costs saving per kg BWG were greater with ‘high’ than ‘low’ NE reduction applied (-0.013 vs. -0.007 €, respectively, vs. PC) with PhyG at 1,000 FTU/kg, and it was greatest in NC2+PhyG 2,000 FTU/kg with ‘low’ NE reduction (-0.036 € vs. PC). Similarly, the CFP was reduced from 2,068 to 1,840 g CO2 eq/kg BWG (-11 %) by NC2+PhyG 2,000 FTU/kg with ‘low’ NE reduction vs. PC. In conclusion, the application of a full nutrient matrix with ‘high’ or ‘low’ NE reduction combined with supplementation of PhyG maintained growth performance of weaned pigs and reduced the total feed costs and carbon footprint per kg BW gain, lead to production and sustainability benefits.

143 Effect of increasing dietary net energy content at a constant lysine on feed intake and performance of 7 to 11 kg and 11 to 20 kg pigs

Abstract Information about NE requirements for nursery pigs is still limited. Therefore, 2 experiments were conducted to evaluate the effect of dietary NE contents on growth performance of 7 to 11 kg pigs (Exp. 1) and 11 to 20 kg pigs (Exp. 2). In Exp. 1, mixed-sex pigs (n = 192; PIC; initial body weight (BW) of 7.8 ± 1.07 kg] were assigned to 4 diets for 14 d. Diets 1 to 4 were formulated to contain 4 levels of NE (9.8, 10.1, 10.4 and 10.7 MJ/kg) and adequate in all AA with standardized ileal digestible (SID) Lys being constant at 1.42%. In Exp. 2, mixed-sex pigs (n = 192; PIC; initial BW of 11.2 ± 1.54 kg) were assigned to 4 diets for 21 d. Diets 1 to 4 contained 4 levels of NE (9.6, 9.9, 10.2 and 10.5 MJ/kg) and adequate in all AA (1.32% SID Lys). For both studies, there were 6 pen replicates (4 entire males and 4 gilts/pen) per treatment, and diets were based on corn, soybean meal, whey powder, wheat bran and soy oil. Pigs had ad libitum access to feed (mash) and water. Individual pigs and pen feed disappearance were weighed weekly to calculate average daily gain (ADG), average daily feed intake (ADFI), and feed efficiency gain to feed ratio (G:F). Data were analyzed by ANOVA using the GLM procedure of SAS with pen as the experimental unit. In Exp. 1, ADFI tended to decrease (quadratic; P ≤ 0.08) with increasing NE levels during d 0 to 7 and d 8 to 14. The ADG during d 0 to 7 tended to be greater (158, 192, 187 and 152 g for diets 1 to 4; quadratic; P = 0.08) at 10.1 MJ/kg NE; however, the overall ADG (d 0 to 14) was not affected by the NE levels. Although not significant, G:F, Lys utilization efficiency were greatest at 10.1 MJ/kg NE for the overall period. In Exp. 2, ADFI decreased (827, 783, 768 and 749 g for diets 1 to 4; linear; P = 0.05) with increasing NE levels during d 15 to 21 but was not affected (P &amp;gt; 0.05) for other periods. The ADG (d 8 to 14) tended to be greater at 9.6 MJ/kg NE (quadratic; P = 0.06) and G:F (d 15 to 21) tended to be greater at a dietary NE of 10.2 MJ/kg (linear; P = 0.10). However, the overall (d 0 to 21) ADG and G:F were not affected (P &amp;gt; 0.05) by NE levels. Although not significant, G:F and Lys utilization efficiency were greatest at a dietary NE of 10.2 MJ/kg for the overall period. These results indicate that G:F of 7 to 11 kg pigs and 11 to 20 kg pigs maximized at a dietary NE content of 10.1 MJ/kg and 10.2 MJ/kg, which correspond to 1.41 and 1.29 g SID Lys/MJ NE, respectively.

192 Effects of inclusion of a probiotic and/or a postbiotic in diets containing a phytogenic feed additive on growth performance and fecal microbiome composition and function of nursery pigs

Abstract This study investigated the effects of inclusion of a Bacillus-based probiotic and a postbiotic from Lactobacillus acidophilus fermentation (Dia-V Nursery, Diamond V, IA) in diets containing a phytogenic feed additive (Fresta Protect, Delacon, Austria) on growth performance and fecal microbiome of pigs. Weaned pigs [n = 1,840; 19 d old; initial body weight (BW) = 6.1 ± 0.2 kg] were allotted to 16 replicate pens/ treatment (23 pigs/pen) in 2 barns. Pens were blocked by location within barn and randomly allotted to 5 treatments: 1) Basal diet (NC), 2) NC without specialty fats (soy oil blend and medium chain fatty acid blend) + 0.1% phytogenic (PC), 3) PC + 0.05% probiotic (1.1 x 106 CFU/kg of complete feed; PC+Prob), 4) PC + 0.2% postbiotic (PC+Post), and 5) PC + 0.05% probiotic + 0.2% postbiotic (PC+Prob+Post). Pigs were fed experimental diets during phase 1 (d 0-10) and 2 (d 10-23). Pig and feed weights were recorded at the beginning and end of each phase. Fecal samples were collected from 2 pigs/pen (n = 32/treatment) on d 7 and 25 post-wean and subjected to DNA extraction and shotgun metagenomics to evaluate gut microbiome. Performance data were analyzed using the lme4 package of R with treatment as fixed effect and barn and pen location within barn as random effects. Microbiome data were center-log-ratio transformed and analyzed for alpha- and beta-diversity, differentially abundant taxa and genes, microbial network, and carbohydrate active enzymes (CAZy). No differences on performance, mortality or removals were observed during phase 1, phase 2, or overall among treatments (Table 1). Microbiome features were similar between NC and PC. The PC+Prob did not affect alpha- and beta-diversities of microbiome. The PC+Post reduced (P &amp;lt; 0.05) alpha-diversity on d 7 compared with PC and affected (P &amp;lt; 0.05) beta-diversity on both timepoints. The PC+Post had the greatest number of differentially abundant taxa (P &amp;lt; 0.05) compared with PC both on d 7 (27 taxa) and 25 (14 taxa). The PC+Post had greater (P &amp;lt; 0.05) presence of CAZy including glycoside hydrolases, glycosyltransferases and carbohydrate-binding modules on both timepoints. Inclusion of probiotic and postbiotic separately or in combination reduced (P &amp;lt; 0.05) the number of positive connections within the microbial network suggesting these additives promoted a more competitive microbial ecosystem against opportunistic microorganisms compared with PC. Inclusion of postbiotic speeded up the progression of microbiome toward a more mature community. This resulted in reduction of diversity but increased carbohydrate enzyme capability making microbial community leaner and more effective. In conclusion, replacement of specialty fats with a phytogenic did not affect piglet performance or microbiome under non-challenge conditions and no differences in performance were observed between PC pigs and those supplemented with a probiotic or postbiotic despite the effects observed in microbiome.

218 Weaning weights associated with improved performance of grow-finish pigs

Abstract This study was conducted to evaluate the downstream impact of wean weight (WW) on finishing pig performance. Individual body weights (BW) were recorded at the time of weaning using the LeeO individual animal identification system. Finisher performance evaluation started at d 57 post-weaning. Pigs (n = 1,276; PIC 800 x DNA 241 F1) were blocked by wean age (20.6 ± 1.5 d) and sex, ranked in order of individual WW (6.05 ± 1.43 kg), and divided into BW quartiles to create four WW treatment groups [WW Quartile (Q) 1, 2, 3, and 4; Table 1]. Pigs (n = 21) in the same Q were housed in each pen yielding 15 replicate pens per quartile. Pigs were fed common diets formulated in a 4-phase sequence from the time of placement in the finisher through marketing, which occurred on a fixed-BW basis targeting 131.5 kg. Pen BW and feed disappearance were recorded every 3 wk and at marketing, and individual BW were recorded on d 134 post-weaning. Data were analyzed using linear mixed effects models in the lme4 package of R. Differences in mean BW of each Q were evident at weaning (P &amp;lt; 0.001), start of finisher evaluation (d 57, P &amp;lt; 0.001), and through d 121 (P &amp;lt; 0.001); by d 144, the BW between Q3 and Q4 did not differ (126.6 vs 129.0 kg, respectively, P &amp;gt; 0.05). Overall average daily gain (ADG) and average daily feed intake (ADFI) were greater (P &amp;lt; 0.001) for finishing pigs of either Q3 or Q4 compared with Q1, but no difference (P &amp;gt; 0.10) in gain to feed ratio (G:F) was observed between quartiles from 28.0 to 131.5 kg BW. Pigs in Q3 and Q4 required fewer (P &amp;lt; 0.001) days on feed than pigs in either Q1 or Q2, which culminated in an overall linear (P &amp;lt; 0.001) effect such that a 0.45-kg advantage in WW resulted in 2.25 d less to reach a market BW of 131.5 kg. Coefficient of variation (CV) in BW at d 134 post-weaning was greater (P &amp;lt; 0.001) for pigs in Q1 compared with pigs in Q2, Q3, or Q4. Backfat depth was thicker (P &amp;lt; 0.05) for Q1 pigs compared with Q4 pigs but did not differ from pigs in Q2 or Q3. A decrease (P &amp;lt; 0.001) in carcass ADG was seen for pigs in the lightest 50% of the population compared with those in Q4. In conclusion, even though feed efficiency was not impacted by WW, heavier WW resulted in fewer days to reach desired market weight while simultaneously resulting in improved carcass characteristics.