Anaerobic Digestion Performance Research Articles

Comparative assessment of waste-to-energy scenarios to mitigate GHG emission from MSW in a developing mega city

The search for sustainable municipal solid waste management in urban areas has become a dire need as the generated unprecedented volumes of waste eventually end up in landfills and emits greenhouse gas (GHG). To offer sustainable waste management in Dhaka, Bangladesh, the performance of incineration, anaerobic digestion, and hydrothermal carbonization (HTC) based Waste to Energy (WtE) processes were assessed and compared. The population and the GDP of Dhaka North City Corporation from 2015 to 2023 were used to estimate the MSW generation rate with an empirical multivariable linear regression model. In 2023 around 3600 tons/day of MSW was generated which was 35 % higher than in 2015. The IPCC decay models, ZODM, FODM, and modified triangular model (MTM) yielded 87.3, 41.3, and 38-k tonnes of CH4 generation, respectively. The power generation from incineration-based plants can fall from 30 MW to 3 MW if the moisture content of MSW increases from 70 % to 90 %. Anaerobic digestion produces 34 MW of power. The Optimization of the HTC operating parameters was done and it demonstrates substantial energy potential (up to 65 MW with co-feeding of 420 tons/day of hydrochar with 426 tons/day of plastic from MSW) and GHG emission reduction (221.5 %) compared to landfilling. Additionally, HTC-derived wastewater presents an opportunity for nutrient recovery with 8.16 and 2.66, 0.3 tons/day of K, Na, and P reclamation potential, respectively. A comparison of different scenarios in plastic recycling in incineration and sensitivity analysis for three WtE schemes were conducted. Thus, the study provides a rigorous assessment of different pathways to offer a comprehensive framework for sustainable MSW management that contributes to a cleaner urban environment.

Effect of hydrochar from biogas slurry co-hydrothermal carbonization with biomass on anaerobic digestion performance of food waste

Anaerobic digestion is a promising method for converting food waste into renewable methane-rich biogas. However, challenges, such as significant biogas slurry generation, poor stability, and low methane production, limit its widespread adoption. This study produced 15 types of hydrochars by co-hydrothermal carbonization of biogas slurry with sugarcane leaves, cellulosic ethanol residue, or food waste digestate at 180–260 °C to enhance anaerobic digestion performance and methane yield. The methane yield was influenced by both the raw materials and hydrothermal carbonization temperature. The hydrochar derived from sugarcane leaves at 180 °C exhibited the highest methane yield of 461.59 mL/g VS, which is a 13.69 % increase over the food waste group. Additionally, different doses of SL-180 were tested for their effects on the anaerobic digestion performance in food waste. The cumulative methane yield increased from 379.68 mL/g VS to 543.26 mL/g VS with SL-180 dosages ranging from 5 g/L to 40 g/L, enhancing cumulative methane yield by 3.90–48.66 % compared to the food waste group. The primary factor influencing methane yield was hydrochar degradation, whereas secondary factors included maintaining system stability and enriching methane-producing microorganisms, particularly Methanosaeta and Methanomassiliicoccus. Energy assessment and economic analysis indicate that combining hydrothermal carbonization with anaerobic digestion can achieve high energy output and economic benefits. This study offers insights and recommendations for managing biogas slurry, resource recovery, and improving the stability and methane yield in the anaerobic digestion of food waste.

Biochar accelerates methane production efficiency from Baijiu wastewater: Some viewpoints considering direct interspecies electron transfer

The low pH of Maotai-flavor Baijiu wastewater (MFBW) adversely affects its anaerobic digestion (AD) performance, resulting in low AD efficiency. Here, coconut shell was used to produce biochar. The characteristics of biochar were regulated through acid, alkali, and magnetic modification, respectively. Biochar and modified biochars were applied to assist the AD of MFBW. The results showed that biochar could significantly increase methane yield by 220.8 %–241.7 % with the corresponding soluble chemical oxygen demand (sCOD) degradation increasing by 52.3 %–57.5 % (p < 0.05). Joint modification could significantly enhance the electron donating capacity from 0.0042 to 0.0095 mmol e−1/g (p < 0.05). The combined modification with magnetic alkali had the best stimulating effect on the AD process, which might be related to the conductive particles (Fe3O4) formed during magnetization processes. The modified biochar featured a high degree of surface roughness, a relatively large aperture, and strong electron donating ability, all of which were beneficial to the colonization and microbial growth. Supplementation with biochar resulted in the enrichment of Proteobacteria, Firmicutes, and Actinobacteria, especially for Syntrophomonas (rising from 0.013 % to 6.74 %–10.93 % of relative abundance). These microorganisms are related to the hydrolysis, acidification, and extracellular electron transfer. The enrichment of electroactive microorganism is a prerequisite for improving the direct interspecies electron transfer pathway. This study provides theoretical support for efficient MFBW treatment.

Versatile enhancement for anaerobic moving bed biofilm (AnMBBR) treating pretreated landfill leachate by hydrochar: Energy recovery, greenhouse gas emission reduction and underlying microbial mechanisms

Hydrochars were prepared from fruit peels (HC-1) and vegetable waste (HC-2), and combined with fiber spheres, respectively, to form homogeneous biocompatible carriers, which were used for anaerobic moving bed biofilm reactor (AnMBBR) to enhance anaerobic digestion (AD) performance and energy recovery of landfill leachate treatment. Compared with the control AnMBBR with conventional fiber spheres as carriers, the chemical oxygen demand (COD) removal efficiency of the AnMBBR with HC-2 increased from 75 % to 88 %, methane yield increased from 77.7 mL/g-COD to 155.3 mL/g-COD, and achieved greenhouse gases (GHG) emission reductions of 1.74 t CO2 eq/a during long-term operation. HC-2-fiber sphere biocarriers provided more sites for attached-growth biomass (AGBS) and significantly enhanced the abundance of functional microbial community, with the relative abundance of methanogenic bacteria Methanothrix increased from 0.03 % to over 24.4 %. Moreover, the gene abundance of most the key enzymes encoding the hydrolysis, acidogenesis and methanogenesis pathways were up-regulated with the assistance of HC-2. Consequently, hydrochar-assisted AnMBBR were effective to enhance methanogenesis performance, energy recovery and carbon reduction for high-strength landfill leachate treatment.

Model based analysis of trace metal dosing strategies to improve methane yield in anaerobic digestion systems

Favourable effects of trace metals (TMs) on regulating anaerobic digestion (AD) performance are extensively utilised to improve methane yield. This study discusses a model-based approach to find out the best TM dosing strategies. The model has been applied to compare continuous, preloading, pulse dosing and in-situ loading. Simulations were also carried out to comprehend appropriate dosing form, dosing time and quantity of metals to be dosed. Model results show that the best way to dose TMs is repeated pulse dosing at low concentration levels in the optimum range with high frequency. Best dosing strategy for the system in this study was found to be 5 µM pulse loading at 5 days intervals as it gave maximum methane production and low effluent metal loss. Preferable dosing form depends on reactor configuration and this has been verified after model calibration with experimental data. Easily dissociable metal chlorides are ideal for continuous reactors.

Enhanced methane production from anaerobic digestion of waste activated sludge with weak magnetic field: Insights into performances and mechanisms

The impact of weak magnetic field (WMF) on anaerobic digestion (AD) performance of waste activated sludge (WAS) and underlying mechanism were investigated. Results showed that WMF significantly stimulated the methane yield by 12.9∼25.1% with 15 and 30 mT WMF addition, but high WMF (60 mT) attenuated the positive effect. The WMF enriched the anaerobic microbes, especially the acetoclastic and hydrogenotrophic methanogen. Additionally, the WMF dramatically facilitated the metabolic pathways of key enzymes for methanogenesis, which was validated by the significant increase of absolute abundance of anaerobic functional genes (mcrA). The enzyme activities of ATP and F420 were also significantly promoted by 30 mT WMF, but high WMF (60 mT) resulted in increased activity of lactate dehydrogenase. This study reveals that low WMF can promote AD performance of WAS through enhancing microbial activities especially methanogen, but high WMF leads to the loss of cell membrane integrity and attenuates its positive effect.

Resource recovery and contaminants of emerging concern mitigation by microalgae treating wastewater

This study aimed to investigate the recovery of agricultural biostimulants and biogas from microalgae treating wastewater, in the framework of a circular bioeconomy. To this end, municipal wastewater was treated in demonstrative raceway ponds, and microalgal biomass (Scenedesmus sp.) was then harvested and downstream processed to recover biostimulants and biogas in a biorefinery approach. The effect of microalgal biostimulants on plants was evaluated by means of bioassays, while the biogas produced was quantified in biochemical methane potential (BMP) tests. Furthermore, the fate of contaminants of emerging concern (CECs) over the process was also assessed. Bioassays confirmed the biostimulant effect of microalgae, which showed gibberellin-, auxin- and cytokinin-like activity in watercress seed germination, mung bean rooting, and wheat leaf chlorophyll retention. In addition, the downstream process applied to raw biomass acted as a pre-treatment to enhance anaerobic digestion performance. After biostimulant extraction, the residual biomass represented 91% of the methane yield from the raw biomass (276 mLCH4·g−1VS). The kinetic profile of the residual biomass was 43% higher than that of the unprocessed biomass. Co-digestion with primary sludge further increased biogas production by 24%. Finally, the concentration of CECs in wastewater was reduced by more than 80%, and only 6 out of 22 CECs analyzed were present in the biostimulant obtained. Most importantly, the concentration of those contaminants was lower than in biosolids that are commonly used in agriculture, ensuring environmental safety.

Effects of long-term exposure to zinc on performances of anaerobic digesters for swine wastewater treatment under various organic loading rates

The long-term performance of anaerobic digestion (AD) often decreases substantially when treating swine wastewater contaminated with heavy metals. However, the toxicological characteristics and mechanisms of continuous exposure to heavy metals under different organic loading rates (OLR) are still poorly understood. In these semi-continuous AD experiments, it was found that zinc concentrations of 40 mg/L only deteriorated the reductive environments of AD. In comparison, a concentration of 2.0 mg/L probably facilitated the reproduction of microorganisms in the operating digesters with a constant OLR of 0.51 g COD/(L·d). Nevertheless, when the OLR was increased to 2.30 g COD/(L·d), 2.0 mg/L zinc inhibited various life activities of microorganisms at the molecular level within only 10 days. Hence, even though 2.0 mg/L zinc could promote AD performances from a macroscopic perspective, it had potential inhibitory effects on AD. Therefore, this study deepens the understanding of the inhibitions caused by heavy metals on AD and the metabolic laws of anaerobic microorganisms in swine wastewater treatment. These results could be referred to for enhancing AD in the presence of zinc in practical swine wastewater treatment.

Enhanced anaerobic digestion of prairie biomass through alkaline-based hydroxycinnamic acid extraction

This study explores the hydroxycinnamic acid extraction from prairie biomass as a potential value-added pretreatment for enhancing the performance of anaerobic digestion. Pretreatment increased the biomethane potential of prairie biomass by 33 %; when the extraction residue was left on the biomass, the biomethane potential increased by 100 %. When the treated biomass was co-digested with manure, a 134 % and 25 % increase in methane productivity and methane content was obtained, respectively, relative to raw biomass co-digested with manure. Hydroxycinnamic acid extraction also improved anaerobic digestion performance under biochar supplementation and liquid digestate recirculation conditions. Lastly, the extraction process was optimized for hydroxycinnamic acid yield. It was found that increases in treatment temperature and time could further increase yield by 5 %. Collectively, the results show hydroxycinnamic acid extraction can be used as a highly effective pretreatment for improving the anaerobic digestion of prairie biomass.

Silver nanoparticles incorporated with superior silica nanoparticles-based rice straw to maximize biogas production from anaerobic digestion of landfill leachate

Treating hazardous landfill leachate poses significant environmental challenges due to its complex nature. In this study, we propose a novel approach for enhancing the anaerobic digestion of landfill leachate using silver nanoparticles (Ag NPs) conjugated with eco-friendly green silica nanoparticles (Si NPs). The synthesized Si NPs and Ag@Si NPs were characterized using various analytical techniques, including transmission electron microscopy, X-ray diffraction, and Fourier-transform infrared spectroscopy. The anaerobic digestion performance of Si NPs and Ag@Si NPs was tested by treating landfill leachate samples with 50 mg/L of each NP. The results demonstrated an enhancement in the biogas production rate compared to the control phase without the nanocomposite, as the biogas production increased by 14% and 37% using Si NPs and Ag@Si NPs. Ag@Si NPs effectively promoted the degradation of organic pollutants in the leachate, regarding chemical oxygen demand (COD) and volatile solids (VS) by 58% and 65%. Furthermore, microbial analysis revealed that Ag@Si NPs enhanced the activity of microbial species responsible for the methanogenic process. Overall, incorporating AgNPs conjugated with eco-friendly green Si NPs represents a sustainable and efficient approach for enhancing the anaerobic digestion of landfill leachate.

Pilot-scale evaluation of cascade anaerobic digestion of mixed municipal wastewater treatment sludges.

This work assessed the performance of a pilot-scale cascade anaerobic digestion (AD) system when treating mixed municipal wastewater treatment sludges. The cascade system was compared with a conventional continuous stirred tank reactor (CSTR) digester (control) in terms of process performance, stability, and digestate quality. The results showed that the cascade system achieved higher volatile solids removal (VSR) efficiencies (28-48%) than that of the reference (25-41%) when operated at the same solids residence time (SRT) in the range of 11-15 days. When the SRT of the cascade system was reduced to 8days the VSR (32-36%) was only slightly less than that of the reference digester that was operated at a 15-day SRT (39-43%). Specific hydrolysis rates in the first stage of the cascade system were 66-152% higher than those of the reference. Additionally, the cascade system exhibited relatively stable effluent concentrations of volatile fatty acids (VFAs: 100-120 mg/l), while the corresponding concentrations in the control effluent demonstrated greater fluctuations (100-160 mg/l). The cascade system's effluent pH and VFA/alkalinity ratios were consistently maintained within the optimal range. During a dynamic test when the feed total solids concentration was doubled, total VFA concentrations (85-120 mg/l) in the cascade system were noticeably less than those (100-170 mg/l) of the control, while the pH and VFA/alkalinity levels remained in a stable range. The cascade system achieved higher total solids (TS) content in the dewatered digestate (19.4-26.8%) than the control (17.4-22.1%), and E. coli log reductions (2.0-4.1 log MPN/g TS) were considerably higher (p < 0.05) than those in the control (1.3-2.9 log MPN/g TS). Overall, operating multiple CSTRs in cascade mode at typical SRTs and mixed sludge ratios enhanced the performance, stability digesters, and digestate quality of AD. PRACTITIONER POINTS: Enhanced digestion of mixed sludge digestion with cascade system. Increased hydrolysis rates in the cascade system compared to a reference CSTR. More stable conditions for methanogen growth at both steady and dynamic states. Improved dewaterability and E. coli reduction of digestate from the cascade system.

Enhancing electron transfer in anaerobic process by supercapacitor materials: Polyaniline functionated activated carbon

Strengthening the direct interspecies electron transfer (DIET) is an effective strategy to improve the performance of anaerobic digestion (AD) process. In this study, the polyaniline functionated activated carbon (AC-PANi) was prepared by chemical oxidative polymerization. This material possessed pseudo-capacitance properties as well as excellent charge transfer capability. The experimental results demonstrated that the incorporation of AC-PANi in AD process could efficiently increase the chemical oxygen demand (COD) removal (18.6 %) and daily methane production rate (35.3 %). The AC-PANi can also act as an extracellular acceptor to promote the synthesis of adenosine triphosphate (ATP) and secretion of extracellular enzymes as well as cytochrome C (Cyt-C). The content of coenzyme F420 on methanogens was also shown to be increased by 60.9 % with the addition of AC-PANi in AD reactor. Overall, this work provides an easy but feasible way to enhance AD performance by promoting DIET between acetate-producing bacteria and methanogens.

Comprehensive insights into the impact of magnetic biochar on protein hydrolysis in sludge anaerobic digestion: Protein structures, microbial activities and syntrophic metabolisms

The addition of composite conductive materials is being increasingly recognized as a promising strategy to enhance anaerobic digestion (AD) performance. However, the influence of these materials on protein hydrolysis has been poorly documented. Here, a novel magnetic biochar derived from oil sludge and straw was synthesized using different iron sources and successfully applied in sludge AD. Experimental results revealed that magnetic biochar modified by Fe2+ exhibited excellent electron transfer capacity, moderate magnetization, diverse functional groups (e.g. C=O, C-O=O-), and abundant iron distribution. These characteristics significantly enhanced the hydrolysis of tryptophan-like components, leading to increased methane production (144.44 mL gVS−1vs 79.72 mL gVS−1 in the control test). Molecular docking analysis revealed that the binding of magnetic biochar related Fe2+ and Fe3+, onto sludge proteins via hydrogen bond played a key role in promoting subsequent protein hydrolysis. Additionally, the noteworthy conservation of protein structures from α-helix and β-sheet to random coil, along with the breakdown of the amide I-associated C=O group and amide III-related CN and NH bonds following the addition of magnetic biochar, accelerated the degradation of sludge protein. Observation of variations in protease activity, coenzyme F420, electron transfer system (ETS), and conductivity within the AD systems, particularly the enrichment of Methanospirillum and Methanosaeta archaea, as well as the Petrimonas, Comamonas, and Syntrophomonas bacteria, suggested that magnetic biochar facilitated a conducive environment by improving hydrolysis-acidification and the direct interspecies electron transfer (DIET) process for acetoclastic methanogens. Moreover, metabolic pathways further proved that tryptophan metobalism and acetoclastic methanogenesis were both facilitated by magnetic biochar. This study provides an in-depth understanding of the impact of magnetic biochar on protein hydrolysis in sewage sludge AD.

Valorization of fruit and vegetable waste in a novel three-stage hybrid anaerobic digester for enhanced biogas production: Performance study and microbial community analysis

The study proposes the performance of a three-stage hybrid mesophilic anaerobic digester comprising a suspended-growth hydrolytic reactor, a hybrid (suspended-growth + attached-growth) acidogenic down-flow reactor, and a hybrid methanogenic up-flow reactor, for enhanced biogas production. Commingled fruit and vegetable waste (FVW) – shredded to sizes 1 – 4 mm – plus 2.5 L of tap water served as the feedstock in 8 different batch combinations, where the weight of the waste was increased from 3.5 to 7 kg. Decoupling the three major anaerobic steps ensured desirable working pH ranges for the hydrolytic (4.02 – 6.79), the acidogenic (5.69 – 6.62), and the methanogenic stages (6.94 – 7.7). Triplicate studies of each batch type vis-à-vis all three stages were performed. The highest cumulative soluble chemical oxygen demand percentage removal of 96.3 % was noticed in the case of batch run 5. The maximum biogas yield of 781.8 ml/g CODremoved was corresponding to batch 7, with 6.5 kg FVW, whereas the lowest biogas yield, 735.8 ml/g CODremoved, was corresponding to batch 1. The produced biogas from the methanogenic digester was of high quality (≤ 0.01 % H2S) and constituted 58–62 % CH4 and 6–7 % H2. Microbial community analysis confirmed the presence of pertinent bacterial and archaeal groups, such as Firmicutes, Proteobacteria, Spirochaetes, and Methanothrix, including key homoacetogenic genera, such as Acetobacterium Woodii, Desulfotomaculum, and Desulfitobacterium.

Different regulation strategies of anaerobic digestion by AC/CaO2 and Fe3O4/CaO2: Reactive oxygen species induction, methanogenic performance, and microbial response

This study examined the combination of activated carbon and magnetite with calcium peroxide in enhancing the anaerobic digestion (AD) performance of food waste (FW). The individual mechanisms of these two approaches were also clarified. The results indicated that AC/CaO2 achieved the highest specific methane yield of 434.4 mL/g VS, followed by Fe3O4/CaO2 (416.9 mL/g VS). Both were significantly higher than other groups (control, AC, Fe3O4, and CaO2 were 330.1, 341.4, 342.8, and 373.2 mL/g VS, respectively). Additionally, compared to Fe3O4/CaO2, AC/CaO2 further increased reactive oxygen species (ROS), thereby enhancing the hydrolytic acidification process. Simultaneously, the higher ROS levels of Fe3O4/CaO2 and AC/CaO2 promoted the formation of microbial aggregates and established a more robust enzymatic defense system and unique damage repair strategy. The research comparatively analyzed the synergistic mechanism of iron-based and carbon-based conductive materials with CaO2, providing new perspectives for optimizing the AD of FW.

Reduction of inhibitory effect of lignin via degradation and improvement of anaerobic digestion performance of maize straw by oxidative pretreatment with Fe2+-activated persulfate

The stable aromatic structure of lignin is one of the factors that limit the utilization of maize straw. In this study, pretreatment with Fe2+/persulfate (PS) was used to remove lignin while reducing the contents of lignin derivatives produced in the pretreatment. In comparison with the original straw, the lignin and hemicellulose contents of the pretreated straw were reduced to 54.58 % and 72.91 %, respectively. In the Fourier transform infrared spectrum, the characteristic peaks of both syringyl and guaiacyl units were significantly weaker after pretreatment with Fe2+/PS, which indicated that the pretreatment destroyed the structure of lignin. The pretreatment products were examined by gas chromatography–mass spectrometry, and the results indicated that the present pretreatment method reduced the contents of soluble inhibitors produced from lignin. After pretreatment, only levulinic acid, 4-hydroxybenzaldehyde, vanillin, 4-hydroxybenzoic acid, xylose, coumaric acid, and 4-coumaric acid were produce, whereas more than 20 soluble inhibitors are known to be produced from lignin. In anaerobic fermentation experiments, in comparison with the control group, the pretreated group exhibited higher gas production (an increase of 18.09 %) and a significantly higher methane content. This indicates that pretreatment with Fe2+/PS can improve the efficiency of the resource utilization of maize straw by degrading lignin.

Exceptional contribution of iron nanoparticle and aloe vera biomass additives to biogas production from anaerobic digestion of waste sludge

This study aims to investigate, for the first time, the improvement of the anaerobic digestion (AD) performance of waste sludge (WS) by utilizing Aloe vera waste (AVW) and Fe0 nanoparticles. Accordingly, a series of biogas generation experiments were conducted at different mixing ratios (AVW:WS = 0:1, 1:1, 2:1, and 3:1), to find out the optimum ratio for maximizing biogas generation. To gain insights into the improved biogas generation by the addition of AVW, pH value was monitored during the fermentation process and adjusted to different initial values (3, 7, and 12). Moreover, the effect of different concentrations (10 and 50 mg/L) and dosing times (0, 6, 12, 24, 48, and 96 h) of Fe0 nanoparticles on the digestion of the optimized ratio (AVW:WS = 2:1) were investigated. Results showed that the optimum ratio (AVW:WS = 2:1) resulted in improving biogas and methane generation by 62.5 % and 96.0 %, respectively, which is an excellent improvement rate of biogas and methane generation compared with the previously reported values in the literature. The addition of Fe0 at the optimum concentration (10 mg/L) and dosing time (12 h) to the optimized ratio (AVW:WS = 2:1) resulted in enhancing methane generation by 146.9 %.

Characterization of Sludge for Biogas Production Using Anaerobic Digestion: A Literature Review Approach

This article conducts bibliographic research to characterize sludge for biogas production. The focus is on identifying key components such as organic matter, nutrients, pH, and chemical composition. Additionally, parameters such as the carbon/nitrogen ratio, inhibitory compounds, and biological activity are explored to assess their impact on anaerobic digestion performance. This bibliographic approach seeks to establish optimal parameter ranges for sludge utilization in biogas production. By comprehensively understanding the composition and properties of the sludge, this study contributes to enhancing the efficiency and effectiveness of anaerobic digestion processes.

Enhancing anaerobic digestion of actual papermaking wastewater with addition of Fenton sludge

The effect of Fenton sludge on anaerobic digestion of actual papermaking wastewater was investigated in this study. The results showed the iron in the Fenton sludge primarily exists in the form of needle-like iron oxide (FeOOH) and showed high electron transfer capability. Fenton sludge promoted electron transport in anaerobic digestion and electron transport system activity increased by 59 %. Fenton sludge enhanced the metabolic activity of anaerobic microorganisms, especially that of the hydrogenotrophic methanogens, the content of coenzyme F420 increased by 48.9 %. Besides, the microbial community structure in anaerobic digestion was affected by Fenton sludge, the quantity of microorganisms increased significantly. The dissimilatory iron-reducing bacteria (Desulfobacterota) and hydrogenotrophic methanogens (Methanobacterium and Methanolinea) were enriched, which promoted the methane production. As a result, the anaerobic digestion performance of papermaking wastewater was promoted significantly by adding Fenton sludge, the organic matter removal efficiency and methane production increased by 11.17 % and 15.12 %. This study provided an effective solution for the optimisation of anaerobic treatment of actual refractory organic wastewater.

Effective anaerobic digestion performance from kitchen wastewater by nanoscale zero-valent iron composite materials: Hydrogen corrosion capability and biological biogas upgrading

In this study, nanoscale zero-valent iron (nZVI) was modified by carboxymethylcellulose (CMC), extracellular polymeric substances (EPS) and sodium dodecyl sulfate (SDS), which were compared for the ability of hydrogen corrosion and then for the biogas upgrading during kitchen wastewater anaerobic digestion. The results showed that three nZVI composite materials addition could increase hydrogen evolution performance by 6.11∼10.30 % compared with nZVI. Especially, the hydrogen evolution from sodium dodecyl sulfate modified composite material reached 121.0 mL/g. The continuous release of hydrogen promoted the biogas yield to 510.96 mL/gVS in reaction group with SDS12-nZVI10 addition (N4), with CH4 content reached 93.37 %. Microbial community analysis showed that the total relative abundance of Methanothrix and Methanolinea was 43.60 % in N4, which was higher than other groups. It was indicated that H2-assisted biogas upgrading with nZVI composite materials addition was achievable, particularly in N4.