Nutrient Removal Research Articles

Removal of Nitrogen, Phosphorus, Organic Matter, and Heavy Metals from Pig-Farming Wastewater Using a Microalgae-Bacteria Consortium.

Wastewater generated by the pork industry urgently requires the implementation of low-cost, high-benefit, and efficient treatment systems. Accordingly, a microalgae-bacteria consortia-based treatment system is proposed for the removal of contaminants released, by the pork-producing industry, in swine wastewater. In this study, different inoculum concentrations of the microalgae-bacteria consortium were tested to document variation in the removal of nutrients from the wastewater. At varying concentrations, it was efficient and did not present a significant difference in the removal kinetics. The treatment with the greatest amount of inoculum removed close to 87% of total nitrogen, approximately 70% of orthophosphate, and 77% of chemical oxygen demand. Removals of 84% iron, 44% copper, and 48% manganese were also obtained. These results demonstrate that microalgae-bacteria consortia are an economically viable and environmentally desirable option for the efficient treatment of wastewater from the pork industry.

The Role of Keeving in Modulating Fermentation and the Flavour Profiles of Apple Brandy

Keeving is the removal of nutrients from apple musts due to their binding to pectin, resulting in a slower fermentation and spontaneous arrest. The aim of this study was to determine the effect of keeving on the chemical composition of fermented apple must and on the volatile profile and sensory analysis of apple brandies. We compared the application of keeving during spontaneous fermentation with fermentation carried out by Saccharomyces cerevisiae (SafSpirit HG-1). We evaluated the impact of adding different doses of calcium chloride on various parameters of fermented musts and distillates. Calcium chloride had a greater effect on the ethanol concentration, total extract, and fermentation efficiency than on the type of fermentation used. However, a different phenomenon was observed with respect to the volatiles. The concentration of most of the higher alcohols, acetaldehyde, dodecanal, and geranylaceton, decreased after spontaneous fermentation and increased during the fermentation carried out with Saccharomyces cerevisiae SafSpirit HG-1. In general, the application of keeving contributed to a decrease in the concentration of ethyl and methyl esters, but caused an increase in the concentration of all acetate esters and terpenoids. When the amount of nutrients in the environment is limited and starvation occurs, microorganisms use the available nutrients for basic metabolic processes that allow them to survive and limit the formation of side metabolites such as volatiles. However, most of the samples fermented after the faecal depletion achieved high scores for the floral, fruity, and “overall note” parameters in the sensory analysis. This means that this method, carried out with a properly selected yeast strain, could be feasible for the distilling industry.

Biochar for wastewater treatment: Addressing contaminants and enhancing sustainability: Challenges and solutions

In recent years, biochar has gained interest for its potential use in treating and removing contaminants from domestic, municipal, and industrial wastewater. When applied in fixed filter columns (BFCs), biochar can effectively immobilize, filter, and recover contaminants with high treatment efficiency. On average, COD removal is 80 %, nutrient removal is 71 % for nitrogen-ammonium and 57 % for phosphorus-phosphate, and pathogen reduction averages 2.4 log10 units. These results vary depending on factors such as the biochar's surface area, the conditions under which it was pyrolyzed, and operational parameters like hydraulic loading and retention time. Biochar addresses limitations in traditional wastewater treatment by leveraging adsorption, ion exchange, and biological degradation mechanisms. The larger surface area and functionalized surface of engineered biochar make it particularly effective in treating diverse pollutants, including heavy metals, nutrients, and emerging contaminants, such as antibiotic-resistant bacteria. As the global population and industrial activities increase, there is a pressing need for sustainable wastewater treatment technologies. Biochar addresses this need and serves as a waste valorization tool, contributing to bioenergy production, soil improvement, and other applications. The present review focuses on improving biochar's performance and durability in real-world applications by addressing challenges like physical degradation. It also proposes strategies to enhance biochar's properties and reuse potential.

Palygorskite-mediated simultaneous nutrient removal and antibiotic degradation from aquaculture wastewater in lab-scale constructed wetlands

In this study, palygorskite was employed as a substrate in laboratory-scale constructed wetlands (CWs) over a period of 180 days to investigate the removal efficiency of pollutants from mariculture wastewater under high loads of enrofloxacin (ENR) stress. The results indicated that the incorporation of palygorskite into CWs resulted in average effluent concentrations of total phosphorus (TP), total nitrogen (TN), chemical oxygen demand (COD), and ENR reaching 0.07 ± 0.00 mg/L, 1.07 ± 0.06 mg/L, 11.57 ± 1.04 mg/L, and 0.047 ± 0.002 mg/L, respectively. The removal efficiencies reached 96.45 ± 0.04 %, 94.62 ± 0.27 %, 88.61 ± 1.22 %, and 91.14 ± 5.00 % respectively, with phosphorus removal significantly surpassing that reported for similar CWs. This superior performance was mainly attributed to the strong binding mechanisms between phosphorus and the metal oxides and hydroxides leached from the palygorskite. The palygorskite stimulated the secretion of extracellular polymeric substances (EPS), accelerated biofilm establishment, and enhanced the relative abundance of key functional bacteria associated with carbon, nitrogen, and antibiotic removal, thus achieving rapid denitrification and efficient organic matter removal. Monitoring of metals (Ca, Fe, Mn, and Cu) in the CWs effluent suggested that their presence was insufficient to affect cytoplasmic enzyme activity or cause oxidative stress damage to plants. In conclusion, palygorskite serves as an environmentally friendly, high-nutrient removal alternative, apt as a substrate for CWs.

Growth potential, biochemical properties and nutrient removal efficiency of some freshwater microalgae and their consortia from wastewater

Impact of varying nitrate (NO3-N) and phosphate (PO4-P) concentrations and sewage water (SW) on the growth, nutrient removal, lipid accumulation, enzymatic antioxidant activity and phytochemical contents of the microalgae Scenedesmus dimorphus, Coelastrella tenuitheca, Chroococcus turgidus and Parachlorella kessleri under monoculture and their consortia have been investigated. High growth rates were observed for all the four algae in both mono and mixed culture conditions at enhanced concentrations of N (1500 mg/L NO3-N) and P (40 mg/L PO4-P). The species Scenedesmus dimorphus outperformed other microalgae growing in SW in efficiently removing nitrogen. The algal consortia of mixed species was found to be more effective in phosphorus removal. The carbohydrate and protein contents were highest in Parachlorella kessleri, about 37% and 44%, respectively, in SW cultivation. The algal consortia demonstrated highest starch content (4%) in nitrogen deprived growth medium. Highest lipid production (43%) was observed in the SW culture. The species Coelastrella tenuitheca, Chroococcus turgidus and Scenedesmus dimorphus irrespective of the growth media indicated significant accumulation of phenol, flavonoid and tannin. The DPPH, catalase and ascorbic peroxidase assay showed pronounced antioxidant activity. Nutrient (N and P) enrichment exhibited enhanced antioxidant enzymatic activity and accumulation of cell storage products.

Semi-continuous cultivation of microalgae to treat coal mine effluent in pilot scale: Nutrient removal, biodesalination and fatty acid composition analysis

Coal excavation is associated with discharge of an enormous amount of mine water rich in salt and trace metal ions, which require efficient treatment before use. Considering the potentiality of microalgae for high salt tolerance, salt removal and metallic pollutant removal from aqueous system, present study focuses semi-continuous cultivation of candidate microalgae Chlorella pyrenoidosa (NCIM 2738) in bubble column reactor (BCR) and open raceway pond (ORP) for nutrient supplemented coal mine effluent (NSCME) treatment. In between different hydraulic retention times (HRTs), HRT 6 d provide maximum average biomass productivity of 950 mg L−1 d−1 in BCR and 728.4 mg L−1 d−1 in ORP. HRT 9 d facilitates a maximum lipid content of 1.8 g L ̶ 1 in BCR and 1.4 g L ̶ 1 in ORP. Further, HRT 9 d had the maximum COD removal efficiency (96.5 % in BCR and 94.2 % in ORP) and maximum salinity removal efficiency (93 % in BCR and 92 % in ORP). Fatty acid methyl esters (FAME) characterization highlighted potential biodiesel applicability with cetane number (CN) of 53.94. Energy dispersive X-ray spectroscopy (EDS) revealed an excess amount of salt and metal ions deposition on the surface of harvested microalgae samples. Outdoor large-scale C. pyrenoidosa cultivation can be integrated with coal mine closure plans to meet sustainable development goals (SDGs) 6, 7 and 13.

Growth, nutrient uptake and yield ofdirect seeded rice as influenced by weed management practices

A field experiment was conducted during the rainy (Kharif) seasons of 2018 and 2019 at the Kerala Agricultural University, Kerala, to evaluate the effect of herbicides and herbicide combinations on the weed management and growth, nutrient uptake and yield of direct seeded rice (DSR). The experiment was laid out in a randomized block design with three replications. Nine weed control treatments were used, including sole application of three herbicides (cyhalofop butyl @ 80 g/ha, bispyribac sodium @ 25 g/ha, fenoxaprop-p-ethyl@ 60 g/ha), five herbicidal combinations (penoxsulam + cyhalofop butyl commercial formulation @ 150 g/ha, cyhalofop butyl @ 80 g/ha + carfentrazone ethyl @ 200 g/ha, bispyribac sodium @ 25 g/ha + cyhalofop butyl @ 80 g/ha, bispyribac sodium @ 25 g/ha + fenoxaprop-p-ethyl @ 60 g/ha and stale seedbed followed by (fb) glyphosate @ 800 g/ha + oxyfluorfen @ 150 g/ha at 15-20 days after land preparation + cyhalofop butyl @ 80 g/ha + carfentrazone ethyl @ 200 g/ha), and hand weeding twice at 20 and 40 days after sowing. Weeds removed 27.72, 4.61 and 67.95 kg of N, P and K/ha respectively at 45 days after treatment application (DATA) under unweeded conditions in direct seeded rice. Herbicidal treatments enhanced grain yield by 23.89 to 58.84 % and herbicide combinations increased grain yield by 56 to 59 % compared to the unweeded control in direct seeded rice. Tank mix combination of bispyribac sodium @ 25 g/ha + fenoxaprop-p-ethyl @ 60 g/ha and bispyribac sodium @ 25 g/ha + cyhalofop butyl @ 80 g/ha and premix combination of penoxsulam + cyhalofop butyl @ 150 g/ha recorded higher nutrient uptake and grain yields (5.03, 4.76 and 4.79 t/ha, respectively) and were on par to hand weeding twice. Unweeded control recorded the lowest pooled grain yield (2.07 t/ha) and uncontrolled weed competition resulted in 59.95 % reduction in grain yield. Keywords: Crop competition, Herbicide combinations, Herbicide interactions, Nutrient removal, Nutrient uptake, Yield reduction

The effects of influent 5-Deoxystrigol concentrations on integral biogas upgrading and nutrient removal by different algal-fungal-bacterial consortium

The low quality of biogas and the difficulties in treating biogas slurry are important bottlenecks that limit the development of the fermentation industry. The effects of 5-deoxystrigol (5DS) on the growth rate, daily productivity, and photosynthetic performance of different algal-fungal-bacterial consortia were investigated, and the auxiliary activities of endophytic bacteria (S395–2), Ganoderma lucidum (G. lucidum), Bacillus licheniformis (B. licheniformis), and activated sludge in these systems were examined. The consortium Chlorella vulgaris (C. vulgaris) + G. lucidum + S395–2 was found to be the most effective combination for both biogas upgrading and nutrient removal. Removal efficiencies of chemical oxygen demand (COD), total nitrogen (TN), and total phosphorous (TP) were approximately 82.94 ± 7.88 %, 81.36 ± 7.79 %, and 83.27 ± 8.09 %, respectively, and the CO2 removal efficiency was observed to be about 69.89 ± 6.57 % at the optimum 5DS concentration of 10−11 M. On day 7 of the treatment, the CH4 content was elevated from 66.07 ± 4.84 % to 86.24 ± 8.44 %. The effect of 5DS treatments in different algal-fungal-bacterial consortia was positive in terms of growth performance and photosynthetic rate. The present study provides a framework for efficient biogas upgrading and nutrient removal by the three-phase symbionts.

Responses of SNEDPR-AGS system under long-term exposure of polyethylene terephthalate microplastics for treating low C/N wastewater: Granular effect and microbial structure

The removal of nutrients in sewage treatment plants can be significantly impacted by carbon limitations, especially for treating low carbon to nitrogen ratio (C/N) wastewater, which can markedly increase operational costs. Simultaneous nitrification, endogenous denitrification, and phosphorus removal combined with aerobic granular sludge (SNEDPR-AGS) has emerged as one of the optimal processes for treating low C/N wastewater owing to its high carbon utilization efficiency; however, the long-term effect of microplastics (MPs) on this system remains unclear. This study investigated the granular effect and microbial response of an SNEDPR-AGS system for treating low C/N wastewater under long-term exposure (180 d) to polyethylene terephthalate microplastics (PET-MPs). The results showed that the integrity of the AGS structure was disrupted significantly as the PET-MP concentration increased, with clear AGS cracks appearing on days 180, 124, and 74 after exposure to 1, 10, and 100 mg/L of PET-MPs, respectively. Additionally, the addition of PET-MPs also inhibited denitrification and phosphorus removal due to a decrease in the relative abundance of functional genes (napAB, nirK/nirS, ppk1, ppk2, and ppx). Notably, both chemometric and high-throughput sequencing results indicated that the metabolic form of the system would shift from a polyphosphate-accumulating metabolism to a glycogen-accumulating metabolism. The reason may be that PET-MP stress inhibited the relative abundance of functional genes related to carbon, glycogen, phosphorus, and energy metabolism pathways in Candidatus Accumulibacter and Dechloromonas, but promoted their relative abundance of Candidatus Competibacter. Flow cytometry and molecular docking simulations have also demonstrated the direct toxic effects of PET-MPs on the SNEDPR-AGS system. The biological enhancement and functional recovery of damaged SNEDPR-AGS systems must be further investigated in future studies.

Response to shock load of titanium dioxide nanoparticles on aerobic granular sludge and algal-bacterial granular sludge processes

Titanium dioxide nanoparticles (TiO2 NPs) are extensively used in various fields and can consequently be detected in wastewater, making it necessary to study their potential impacts on biological wastewater treatment processes. In this study, the shock-load impacts of TiO2 NPs were investigated at concentrations ranging between 1 and 200 mg L−1 on nutrient removal, extracellular polymeric substances (EPSs), microbial activity in aerobic granular sludge (AGS), and algal-bacterial granular sludge (AB-AGS) bioreactors. The results indicated that low concentration (≤10 mg L−1) TiO2 NPs had no effect on microbial activity or the removal of chemical oxygen demand (COD), nitrogen, and phosphorus, due to the increased production of extracellular polymeric substances (EPSs) in the sludge. In contrast, the performance of both AGS and AB-AGS bioreactors gradually deteriorated as the concentration of TiO2 NPs in the influent increased to 50, 100, and 200 mg L−1. Specifically, the ammonia‑nitrogen removal rate in AGS decreased from 99.9 % to 88.6 %, while in AB-AGS it dropped to 91.3 % at 200 mg L−1 TiO2 NPs. Furthermore, the nitrate‑nitrogen levels remained stable in AB-AGS, while NO3-N was detected in the effluent of AGS at 100 and 200 mg L−1. Microbial activities change similarly as smaller decrease in the specific ammonia uptake rate (SAUR) and specific nitrate uptake rate (SNUR) was found in AB-AGS compared to those in AGS. Overall, the algal-bacterial sludge exhibited higher resilience against TiO2 NPs, which was attributed to a) higher EPS volume, b) smaller decrease in LB-EPS, and c) the favorable protein to polysaccharide (PN/PS) ratio. This in turn, along with the symbiotic relationship between the algae and bacteria, mitigates the toxic effects of nanoparticles.

The improvement in methane production, nutrient removal, and heavy metal passivation during anaerobic digestion of chicken manure: The role of modified porous materials

The improvement in methane production, nutrient removal, and heavy metal passivation during anaerobic digestion of chicken manure: The role of modified porous materials

Effects of different culture media on growth, composition, quality and palatability of the green algae Ulva sp. cultivated in cylindrical photobioreactors

Ulva spp. are valuable seaweeds with recognized commercial applications, including food, feed, and ecosystem services. Ensuring a sustainable and consistent supply of biomass with desirable profiles aligned with intended uses is fundamental for the successful applications of this seaweed. In this study, the growth rate, morphology, physiology, and composition of Ulva sp. produced by propagation in indoor cylindrical photobioreactors using four different culture media (lagoon water - LW, lagoon water enriched with Guillard medium (LF), with sea urchin wastewater - LU, and cow digestate - LD) was assessed; moreover, the nutrient uptake potential of the species was evaluated. The palatability and attractivity of the produced biomass towards the sea urchin Paracentrotus lividus were investigated. It was found that the media influenced all the parameters examined, the LF biomass weight was double compared to the other treatments and showed a slightly higher absorbance. Colorimetric analyses reported a significant darker color in Ulva sp. grown under enriched media. Ulva sp. showed higher nutrient removal potential in LF. The lipid content did not vary (2–3 % dry weight, DW), while the protein content ranged from 21 % in LF to 6–9 % in the other treatments. Carbohydrates and fiber content were significantly lower in LF (16 % and 30 %) compared to the other treatments, 27–34 %, and 41–48 %, respectively. Pigment content significantly varied, being higher in biomass grown in LF and LU. Sea urchins showed preferences for biomass grown under LU, followed by LD. This study shows how different nutrient sources affect the biochemical composition, growth, quality, and palatability of Ulva sp.. When cultivated under the synthetic enriched media (LF) the species exhibits characteristics better suitable for human consumption, although requiring a higher economic investment for production, while biomass derived from wastewater nutrients (LD, LU) confirms potential applications of the seaweed as valuable feed and for bioremediation services.

Nutrient removal efficacy and microbial dynamics in constructed wetlands using Fe(III)-mineral substrates for low carbon-nitrogen ratio sewage treatment.

This study evaluated the roles of two common sources of Fe(III)-minerals-volcanic rock (VR) and synthetic banded iron formations from waste iron tailings (BIF-W)-in vertical flow-constructed wetlands (VFCWs). The evaluation was conducted in the absence of critical environmental factors, including Fe(II), Fe(III), and soil organic matter (SOM), using metagenomic analysis and integrated correlation networks to predict nitrogen removal pathways. Our findings revealed that Fe(III)-minerals enhanced metabolic activities and cellular processes related to carbohydrate decomposition, thereby increasing the average COD removal rates by 10.7% for VR and 5.90% for BIF-W. Notably, VR improved nitrogen removal by 1.70% and 5.40% compared to BIF-W and the control, respectively. Fe(III)-mineral amendment in bioreactors also improved the retention of denitrification and nitrification bacteria (phylum Proteobacteria) and anammox bacteria (phylum Planctomycetes), with increases of 3.60% and 3.20% using VR compared to BIF-W. Metagenomic functional predictionindicated that the nitrogen removal mechanisms in VFCWs with low C/N ratios involve simultaneous partial nitrification, ANAMMOX, and denitrification (SNAD). Network-based analyses and correlation pathways further suggest that the advantages of Fe(III)-minerals are manifested in the enhancement of denitrification microorganisms. Microbial communities may be activated by the functional dissolution of Fe(III)-minerals, which improves the stability of SOM or the conversion of Fe(III)/Fe(II). This study provides new insights into the functional roles of Fe(III)-minerals in VFCWs at the microbial community level, and provides a foundation for developing Fe-based SNAD enhancement technologies.

Municipal wastewater treatment using an innovative two-stage sequential microalgal co-cultivation system with different hydraulic retention time: A sustainable approach to circular economy

The present study proposes a sustainable circular bioeconomy approach for municipal wastewater (MWW) treatment, employing a sub-pilot two-stage sequential microalgal co-cultivation system (TSSCS), and evaluates the impact of hydraulic retention time (HRT) on MWW treatment efficiency, as well as biomass and biomolecule productivity. In the first stage of TSSCS, 2 ratios of Tetraselmis indica and one ratio of Picochlorum sp. (2TS:1PC) were used for the treatment of 75% raw MWW + 25% ASN-III, while in the second stage, 2PC:1TS was employed for the treatment of 50% 2TS:1PC effluent+ 50% ASN-III. At the end of the first and second stages of TSSCS, nutrient removal efficiencies were as follows: total nitrate (TN) was <80% and 90% on HRT-10 and HRT-12; total phosphate (TP) was <85% and 95% on HRT-16, and chemical oxygen demand (COD) was <75% and <85% on HRT-14 and HRT-10, respectively. In the TSSCS, 2TS:1PC (S1) and 2PC:1TS (S2) showed maximum biomass productivity of 2.65 and 2.78g/L on /L on HRT-14 and HRT-12, respectively. Additionally, biomass of 2TS:1PC (S1) and 2PC:1TS (S2) contains lipid content (38.67 and 40.67%), β-carotene (4.09 and 3.00mg/g), and astaxanthin (0.69 and 0.31mg/g), respectively.

Transforming Wastewater into Biofuel: Nutrient Removal and Biomass Generation with Chlorella vulgaris

This study investigates the potential of Chlorella vulgaris for nutrient removal and biomass production in synthetic wastewater. The experiments were conducted in 2 L photobioreactors under controlled aeration, agitation, and lighting conditions for 19 days. Despite a moderate growth rate (0.137 d⁻¹), C. vulgaris achieved efficient pollutant removal, with 97% of nitrate, 90% of nitrite, and 90.6% of COD eliminated. Additionally, the biomass was processed to extract fatty acids, yielding a 20% extraction rate, indicating its potential as a biofuel feedstock. These results demonstrate C. vulgaris’s dual function in wastewater remediation and biofuel production, presenting a sustainable and economically viable approach to addressing environmental challenges.

Maximizing resource efficiency with dairy and municipal wastewater as nutrient media for Chlorella vulgaris with simultaneous CO2 sequestration

Addressing critical environmental challenges such as greenhouse gas emissions, global warming, and eutrophication demands urgent and innovative solutions. In recent years, microalgae have emerged as a promising avenue for addressing these pressing issues. In this study, the combination of dairy and municipal wastewater is proposed as a culture medium for cultivating microalgae strains capable of sequestering atmospheric CO2. Specifically, the growth of Chlorella vulgaris was investigated using Bold's basal medium, along with varying concentrations of municipal and dairy wastewater, both with and without CO2 supplementation, to assess their CO2 capture potential. Concurrently, the efficiency of chemical oxygen demand (COD), total nitrogen, potassium, and phosphate removal from the wastewater was evaluated. Additionally, the combination of wastewater media with CO2 supplementation yielded the highest CO2 uptake rates, indicating the feasibility of simultaneous CO2 capture during microalgae cultivation. Media composition with 25% municipal wastewater: 75% dairy wastewater supplemented with CO2 demonstrated superior COD elimination with a higher percentage of nutrient removal from wastewater compared to other wastewater proportions. The nutrient removal capacity of aforementioned media also comes in line with high CO2 sequestration rate (13.57 mg L−1 h−1). These findings underscore the potential of utilizing wastewater from diverse sources as a viable culture medium for microalgae cultivation, facilitating concurrent CO2 capture and wastewater treatment.

Integrating electrochemical pretreatment with microalgae treatment for nitrogen and phosphorus removal and resource recovery from swine wastewater

This study integrates electrochemical pretreatment with microalgae (Scenedesmus obliquus) treatment to enhance nitrogen and phosphorus removal and resource recovery from swine wastewater. By optimizing electrochemical and microalgae treatment conditions, the dilution factor and the hydraulic retention time for microalgae treatment were reduced to 5 times and 7 days, respectively. Under the optimized operational conditions, removal efficiencies of total nitrogen and ammonia could reach over 89 %and 96 %,respectively, and the removal efficiency of total phosphorus was over 99 %. The study also found that aluminum was more suitable than iron for anode as it produced fewer residues. Additionally, the electrochemical pretreatment reduced Cu2+ and Zn2+ concentrations, mitigating negative impacts on microalgal growth. The microalgae biomass harvested from developed processes was rich in saturated fatty acids, which was desirable for biodiesel production. This approach addresses the challenges of nutrient removal for swine wastewater treatment with high quality biomass recovery.

Effect of Light Intensity on the Growth and Nutrient Uptake of the Microalga Chlorella sorokiniana Cultivated in Biogas Plant Digestate

This study investigated the effect of light intensity on the growth and nutrient uptake of Chlorella sorokiniana cultivated in nitrogen-rich anaerobic digestion wastewater. Three light intensities (20, 68, and 162 µmol m⁻2 s⁻1) were applied over a 30-day period with a 16:8 h light–dark photoperiod. The goal was to understand how light affects biomass productivity, nutrient assimilation, and biochemical composition under varying nitrogen concentrations originating from biogas plant digestate, up to 5 g L⁻1. The results showed that higher light intensities significantly boosted biomass production, achieving a five-fold increase at 162 µmol m⁻2 s⁻1 compared to 20 µmol m⁻2 s⁻1. Nutrient uptake followed a similar pattern, with 94% of ammonium nitrogen removed in 7 days under high light, compared to 55% after 30 days under low light. Phosphorus content was also completely removed after 7 days under light intensities of 68 and 162 µmol m⁻2 s⁻1. Additionally, elevated light intensity led to increased lipid accumulation (from 29.7% to 34%) and reduced protein content (from 30.9% to 26.1%), with carbohydrate content not being affected by light intensity. These findings highlight light intensity as a critical factor for optimizing microalgae cultivation in nitrogen-rich biogas digestate, promoting both effective nutrient removal and biomass production for potential bioenergy applications.

Sulfamethoxazole removal and ammonium conversion in microalgae consortium: Physiological responses and microbial community changes

Microalgae (Mychonastes sp.) consortium was investigated for nutrient and antibiotics removal and its responses to varying sulfamethoxazole (SMX) concentrations (0–1000 μg/L) in ammonia-rich wastewater. The results showed that the introduction of SMX (100–1000 μg/L) slightly improved ammonium nitrogen removal efficiency instead of inhibition. Swift SMX degradation was observed across all SMX-treated systems, with the highest SMX removal efficiency (96 %) at an SMX concentration of 100 μg/L. Biodegradation remained the dominant SMX removal mechanism, contributing 78 % of SMX removal at an SMX concentration of 800 μg/L, while adsorption and photolysis played minor roles. Addition of SMX augmented biomass and lipid productivity, but decreased chlorophyll contents in the microalgae consortium. Furthermore, extracellular polymeric substance (EPS) production correlated positively with SMX input concentration, with the microalgae consortium exposed to 800 μg/L SMX displaying the most pronounced stimulation of protein production (51.5 ± 2.0 mg/g DCW) and polysaccharides production (74.8 ± 3.9 mg/g DCW). In response to an increase in SMX concentrations, enzyme activities associated with antioxidant defense, such as superoxide dismutase (SOD), peroxidase (POD) and malondialdehyde (MDA) increased, the catalase (CAT) decreased, indicating an initial defense mechanism. Concurrently, the relative abundance of Mychonastes sp. within the consortium rose from 87 % at 300 μg/L SMX to 99.9 % at 800 μg/L SMX. while Shannon indices of the bacterial community increased from 1.415 to 2.867. This shift inhibited the initially dominant Saprospiraceae bacteria, facilitating the profound increase of adapted Aquimonas. These findings demonstrate the feasibility of the simultaneous removal of antibiotics and nutrients from wastewater with a microalgae consortium system.

Wastewater treatment optimization utilizing polyvinyl alcohol cryogel immobilized microalgae for nutrient removal

This study investigated the use of polyvinyl alcohol (PVA) cryogels to immobilize microalgae for wastewater treatment. Chlorella sorokiniana was successfully entrapped in PVA cryogels via repeated freeze/thaw cycles. The nutrient removal efficiency of these cryogels was tested in a continuously stirred photobioreactor under varying conditions, both with and without the addition of an organic carbon source (sodium acetate). The presence of organic carbon significantly enhanced nutrient removal. Specifically, PVA cryogels with immobilized C. sorokiniana achieved 100% nitrogen removal and 97.2% phosphorus removal under mixotrophic conditions. Furthermore, the maximum nutrient removal capacities of the PVA cryogels were found to be 0.033 mg-N/cube·day for nitrogen and 0.0047 mg-P/cube·day for phosphorus. As the inorganic carbon (bicarbonate) concentration increased from 5 to 100 mg/L, the N/P ratio rose from 6 to 8, with a higher N/P ratio of 10 observed when nitrate nitrogen was used as the nitrogen source, compared to ammonia nitrogen, at 100 mg/L bicarbonate. This study offers an effective method for using microalgae immobilized in PVA cryogels for wastewater treatment. The findings highlight the potential for PVA cryogels to significantly improve nutrient removal efficiency, particularly in the presence of organic carbon sources, thereby enhancing bioreactor performance. High nitrogen and phosphorus removal efficiencies can help reduce eutrophication in water bodies, protect aquatic ecosystems, and enable nutrient recovery and reuse, supporting a circular economy in wastewater treatment practices.