Microneedle Vaccination Research Articles

Intradermal Vaccination with Influenza Virus-Like Particles by Using Microneedles Induces Protection Superior to That with Intramuscular Immunization

Influenza virus-like particles (VLPs) are a promising cell culture-based vaccine, and the skin is considered an attractive immunization site. In this study, we examined the immunogenicity and protective efficacy of influenza VLPs (H1N1 A/PR/8/34) after skin vaccination using vaccine dried on solid microneedle arrays. Coating of microneedles with influenza VLPs using an unstabilized formulation was found to decrease hemagglutinin (HA) activity, whereas inclusion of trehalose disaccharide preserved the HA activity of influenza VLP vaccines after microneedles were coated. Microneedle vaccination of mice in the skin with a single dose of stabilized influenza VLPs induced 100% protection against challenge infection with a high lethal dose. In contrast, unstabilized influenza VLPs, as well as intramuscularly injected vaccines, provided inferior immunity and only partial protection (</=40%). The stabilized microneedle vaccination group showed IgG2a levels that were 1 order of magnitude higher than those of other groups and had the lowest lung viral titers after challenge. Also, levels of recall immune responses, including hemagglutination inhibition titers, neutralizing antibodies, and antibody-secreting plasma cells, were significantly higher after skin vaccination with stabilized formulations. Therefore, our results indicate that HA stabilization, combined with vaccination via the skin using a vaccine formulated as a solid microneedle patch, confers protection superior to that with intramuscular injection and enables potential dose-sparing effects which are reflected by pronounced increases in rapid recall immune responses against influenza virus.

Enhanced Memory Responses to Seasonal H1N1 Influenza Vaccination of the Skin with the Use of Vaccine‐Coated Microneedles

Morbidity and mortality due to influenza could be reduced by improved vaccination. To develop a novel skin delivery method that is simple and allows for easy self-administration, we prepared microneedle patches with stabilized influenza vaccine and investigated their protective immune responses. Mice vaccinated with a single microneedle dose of trehalose-stabilized influenza vaccine developed strong antibody responses that were long-lived. Compared with traditional intramuscular vaccination, stabilized microneedle vaccination was superior in inducing protective immunity, as was evidenced by efficient clearance of virus from the lung and enhanced humoral and antibody-secreting cell immune responses after 100% survival from lethal challenge. Vaccine stabilization was found to be important, because mice vaccinated with an unstabilized microneedle vaccine elicited a weaker immunoglobulin G 2a antibody response, compared with the stabilized microneedle vaccine, and were only partially protected against viral challenge. Improved trafficking of dendritic cells to regional lymph nodes as a result of microneedle delivery to the skin might play a role in contributing to improved protective immunity. These findings suggest that vaccination of the skin using a microneedle patch can improve protective efficacy and induce long-term sustained immunogenicity and may also provide a simple method of administration to improve influenza vaccination coverage.

Augmented humoral and cellular immune response of hepatitis B virus DNA vaccine by micro-needle vaccination using Flt3L as an adjuvant

The purpose of this work was to assess the immune response against plasmid DNA encoding hepatitis B virus (HBV) HBsAg in C57BL/6 mice inoculated by micro-needle. Fms-like tyrosine kinase 3 ligand (Flt3L), a hematopoietic growth factor, was used as an adjuvant. Immune response was determined by analysis of cytokine production. In addition, cytotoxic lymphocyte (CTL) activity was measured 7 days after in vitro addition of tumor cells (CT26/S) stabling expressing HBsAg. The efficacy of immunoprotection against CT26/S was determined by antibody response to this challenge. A strong antibody response was induced by inoculation with the DNA vaccine via micro-needles assisted with Flt3L, Administration of the vaccine to splenocytes induced significantly higher levels of interleukin-12 and gamma interferon. CTL response to the vaccine was stronger than that stimulated by intramuscular or micro-needle injections alone. Our study suggests useful strategies for improving the efficacy of vaccines against HBV and other pathogens.

Formulation and coating of microneedles with inactivated influenza virus to improve vaccine stability and immunogenicity

Microneedle patches coated with solid-state influenza vaccine have been developed to improve vaccine efficacy and patient coverage. However, dip coating microneedles with influenza vaccine can reduce antigen activity. In this study, we sought to determine the experimental factors and mechanistic pathways by which inactivated influenza vaccine can lose activity, as well as develop and assess improved microneedle coating formulations that protect the antigen from activity loss. After coating microneedles using a standard vaccine formulation, the stability of influenza vaccine was reduced to just 2%, as measured by hemagglutination activity. The presence of carboxymethylcellulose, which was added to increase viscosity of the coating formulation, was shown to contribute to vaccine activity loss. After screening a panel of candidate stabilizers, the addition of trehalose to the coating formulation was found to protect the antigen and retain 48–82% antigen activity for all three major strains of seasonal influenza: H1N1, H3N2 and B. Influenza vaccine coated in this way also exhibited thermal stability, such that activity loss was independent of temperature over the range of 4–37 °C for 24 h. Dynamic light scattering measurements showed that antigen activity loss was associated with virus particle aggregation, and that stabilization using trehalose largely blocked this aggregation. Finally, microneedles using an optimized vaccine coating formulation were applied to the skin to vaccinate mice. Microneedle vaccination induced robust systemic and functional antibodies and provided complete protection against lethal challenge infection similar to conventional intramuscular injection. Overall, these results show that antigen activity loss during microneedle coating can be largely prevented through optimized formulation and that stabilized microneedle patches can be used for effective vaccination.

Improved influenza vaccination in the skin using vaccine coated microneedles

Easy and effective vaccination methods could reduce mortality rates and morbidity due to vaccine-preventable influenza infections. In this study, we examined the use of microneedle patches to increase patient coverage through possible self-administration and enhance vaccine immunogenicity by targeted delivery to skin. We carried out a detailed study of protective immune responses after a single influenza vaccination to the skin of mice with a novel microneedle patch designed to facilitate simple and reliable vaccine delivery. Skin vaccination with inactivated virus-coated microneedles provided superior protection against lethal challenge compared to intramuscular injection as evidenced by effective virus clearance in lungs. Detailed immunologic analysis suggests that induction of virus neutralizing antibodies as well as enhanced anamnestic humoral and cellular responses contributed to improved protection by microneedle vaccination to the skin. These findings suggest that vaccination in the skin using a microneedle patch can improve protective immunity, and simplify delivery of influenza and possibly other vaccines.

Transdermal Influenza Immunization with Vaccine-Coated Microneedle Arrays

BackgroundInfluenza is a contagious disease caused by a pathogenic virus, with outbreaks all over the world and thousands of hospitalizations and deaths every year. Due to virus antigenic drift and short-lived immune responses, annual vaccination is required. However, vaccine coverage is incomplete, and improvement in immunization is needed. The objective of this study is to investigate a novel method for transdermal delivery using metal microneedle arrays (MN) coated with inactivated influenza virus to determine whether this route is a simpler and safer approach than the conventional immunization, capable to induce robust immune responses and confer protection against lethal virus challenge.Methodology/Principal FindingsInactivated A/Aichi/2/68 (H3N2) influenza virus was coated on metal microneedle arrays and applied to mice as a vaccine in the caudal dorsal skin area. Substantial antibody titers with hemagglutination inhibition activity were detected in sera collected two and four weeks after a single vaccine dose. Challenge studies in mice with 5×LD50 of mouse adapted Aichi virus demonstrated complete protection. Microneedle vaccination induced a broad spectrum of immune responses including CD4+ and CD8+ responses in the spleen and draining lymph node, a high frequency of antigen-secreting cells in the lung and induction of virus-specific memory B-cells. In addition, the use of MN showed a dose-sparing effect and a strong Th2 bias when compared to an intramuscular (IM) reference immunization.Conclusions/SignificanceThe present results show that delivery of inactivated influenza virus through the skin using metal microneedle arrays induced strong humoral and cellular immune responses capable of conferring protection against virus challenge as efficiently as intramuscular immunization, which is the standard vaccination route. In view of the convenience of delivery and the potential for self-administration, vaccine-coated metal microneedles may provide a novel and highly effective immunization method.