Methyl Tert-butyl Ether Biodegradation Research Articles

Biodegradation Kinetics of MTBE in Laboratory Batch and Continuous Flow Reactors

Methyl tert-butyl ether (MTBE) biodegradation was investigated using a continuously stirred tank reactor with biomass retention (porous pot reactor) operated under aerobic conditions. MTBE was fed to the reactor at an influent concentration of 150 mg/L (1.70 mM). An identical reactor was operated as a killed control under the same conditions. Operation of these reactors demonstrated that removal of MTBE was biological and suggests that biomass retention is critical for effective degradation. MTBE removal exceeded 99.99% when the volatile suspended solids concentration in the reactor was above 600 mg/L. Batch experiments conducted using mixed liquor from the porous pot reactor indicated that the individual rates of biodegradation of MTBE and tert-butyl alcohol (TBA) increase with increasing initial concentration. When batch tests were later repeated, the MTBE degradation rates were found to have increased while the TBA degradation rates remained constant. All batch tests confirmed that the degradation rate...

Influence of gasoline hydrocarbons on methyl tert-butyl ether biotreatment in fluidized bed bioreactors

Fluidized bed bioreactors (FBRs) are frequently used for the treatment of gasoline contaminated groundwater. Due to changes in gasoline formulations in the last decade, gasoline contaminated groundwater may also contain significant quantities of methyl tert-butyl ether (MTBE), a recalcitrant gasoline additive. It has been shown that MTBE is biodegradable and there is interest in determining if MTBE contaminated groundwater can be biologically treated using FBR technology. We examined the biodegradation of MTBE in FBRs treating contaminated groundwater and establish that there was an inverse correlation between total petroleum hydrocarbon (TPH) loading and MTBE treatment efficiency. Follow-up laboratory studies demonstrated that toluene, a component of TPH, is a strong inhibitor of MTBE biotreatment in FBRs.

Carbon and hydrogen isotopic fractionation during biodegradation of methyl tert-butyl ether.

Carbon and hydrogen isotopic fractionation during aerobic biodegradation of MTBE by a bacterial pure culture (PM1) and a mixed consortia from Vandenberg Air Force Base (VAFB) were studied in order to assess the relative merits of stable carbon versus hydrogen isotopic analysis as an indicator of biodegradation. Carbon isotopic enrichment in residual MTBE of up to 8.1/1000 was observed at 99.7% biodegradation. Carbon fractionation was reproducible in the PM1 and VAFB experiments, yielding similar enrichment factors (epsilon) of -2.0/1000 +/- 0.1/1000 to -2.4/1000 +/- 0.3/1000 for replicates in the PM1 experiment and -1.5/1000 +/- 0.1/1000 to -1.8/1000 +/- 0.1/1000 for replicates in the VAFB experiment. Hydrogen isotopic fractionation was highly reproducible for the PM1 pure cultures, with epsilon values of -33/1000 +/- 5/1000 to -37/1000 +/- 4/1000 for replicate samples. In the VAFB microcosms, there was considerably more variability in epsilon values, with values of -29/1000 +/- 4/1000 and -66/1000 +/- 3/1000 measured for duplicate sample bottles. Despite this variability, hydrogen isotopic fractionation always resulted in 2H enrichment of the residual MTBE of >80/1000 at 90% biodegradation. The reproducible carbon fractionation suggests that compound-specific carbon isotope analysis may be used to estimate the extent of biodegradation at contaminated sites. Conversely, the large hydrogen isotopic fractionation documented during biodegradation of MTBE suggests that compound-specific hydrogen isotope analysis offers the most conclusive means of identifying in-situ biodegradation at contaminated sites.

In situ MTBE biodegradation supported by diffusive oxygen release.

Microcosm studies with sediments from Vandenberg Air Force Base, CA, suggest that native aerobic methyl tert-butyl ether (MTBE)-degrading microorganisms can be stimulated to degrade MTBE. In a series of field experiments, dissolved oxygen has been released into the anaerobic MTBE plume by diffusion through the walls of oxygen-pressurized polymeric tubing placed in contact with the flowing groundwater. MTBE concentrations were decreased from several hundred to less than 10 microg/L during passage through the induced aerobic zone, due apparently to in situ biodegradation: abiotic MTBE loss mechanisms were insignificant. Lag time for initiation of degradation was less than 2 months, and the apparent pseudo-first-order degradation rate was 5.3 day(-1). Additional MTBE was added in steps to raise the influent concentration to a maximum of 2.1 mg/L. With each step, MTBE was degraded within the preestablished aerobic treatment zone at rates ranging from 4.4 to 8.6 day(-1). Excess dissolved oxygen suggested that even higher MTBE concentrations could have been treated. Continued flow through the treatment zone was repeatedly confirmed through tracer and other tests. These and others' results suggest that it is possible to create permeable in situ treatment zones solely by releasing oxygen to support native microbial degradation of MTBE.

Aerobic Biodegradation of Methyl tert -Butyl Ether by Aquifer Bacteria from Leaking Underground Storage Tank Sites

The potential for aerobic methyl tert-butyl ether (MTBE) degradation was investigated with microcosms containing aquifer sediment and groundwater from four MTBE-contaminated sites characterized by oxygen-limited in situ conditions. MTBE depletion was observed for sediments from two sites (e.g., 4.5 mg/liter degraded in 15 days after a 4-day lag period), whereas no consumption of MTBE was observed for sediments from the other sites after 75 days. For sediments in which MTBE was consumed, 43 to 54% of added [U-(14)C]MTBE was mineralized to (14)CO(2). Molecular phylogenetic analyses of these sediments indicated the enrichment of species closely related to a known MTBE-degrading bacterium, strain PM1. At only one site, the presence of water-soluble gasoline components significantly inhibited MTBE degradation and led to a more pronounced accumulation of the metabolite tert-butyl alcohol. Overall, these results suggest that the effects of oxygen and water-soluble gasoline components on in situ MTBE degradation will vary from site to site and that phylogenetic analysis may be a promising predictor of MTBE biodegradation potential.

Effect of redox conditions on MTBE biodegradation in surface water sediments.

Microbial degradation of methyl tert-butyl ether (MTBE) was observed in surface water-sediment microcosms under anaerobic conditions. The efficiency and products of anaerobic MTBE biodegradation were dependent on the predominant terminal electron-accepting conditions. In the presence of substantial methanogenic activity, MTBE biodegradation was nominal and involved reduction of MTBE to the toxic product, tert-butyl alcohol (TBA). In the absence of significant methanogenic activity, accumulation of [14C]TBA generally decreased, and mineralization of [U-14C]MTBE to 14CO2 generally increased as the oxidative potential of the predominant terminal electron acceptor increased in the order of SO4, Fe(III), Mn(IV) < NO3 < O2. Microbial mineralization of MTBE to CO2 under Mn(IV)-or SO4-reducing conditions has not been reported previously. The results of this study indicate that microorganisms inhabiting the sediments of streams and lakes can degrade MTBE effectively under a range of anaerobic terminal electron-accepting conditions. Thus, anaerobic bed sediment microbial processes may provide a significant environmental sink for MTBE in surface water systems throughout the United States.

Anaerobic biotransformation of fuel oxygenates under sulfate-reducing conditions

The anaerobic biotransformation of methyl tert-butyl ether (MTBE), ethyl tert-butyl ether (ETBE), and methyl tert-amyl ether (TAME) was evaluated under different anoxic electron-accepting conditions. Enrichments were established with a polluted estuarine sediment inoculum under conditions promoting denitrification, sulfate reduction, Fe(III) reduction, or methanogenesis. Complete loss of MTBE and TAME was observed under sulfate-reducing conditions, concomitant with the reduction of sulfate. A stoichiometric amount of tert-butyl alcohol and tert-amyl alcohol accumulated indicating that O-demethylation was the initial step in MTBE and TAME biodegradation under sulfate-reducing conditions. No transformation of MTBE or TAME was observed under the other electron-accepting conditions over 3 years. Under all conditions tested, there was no biotic loss of ETBE observed. MTBE and TAME were depleted upon refeeding the sulfate-reducing cultures. This study definitely demonstrates the anaerobic biodegradability of MTBE and TAME under sulfate-reducing conditions.

Anaerobic biotransformation of fuel oxygenates under sulfate-reducing conditions

The anaerobic biotransformation of methyl tert-butyl ether (MTBE), ethyl tert-butyl ether (ETBE), and methyl tert-amyl ether (TAME) was evaluated under different anoxic electron-accepting conditions. Enrichments were established with a polluted estuarine sediment inoculum under conditions promoting denitrification, sulfate reduction, Fe(III) reduction, or methanogenesis. Complete loss of MTBE and TAME was observed under sulfate-reducing conditions, concomitant with the reduction of sulfate. A stoichiometric amount of tert-butyl alcohol and tert-amyl alcohol accumulated indicating that O-demethylation was the initial step in MTBE and TAME biodegradation under sulfate-reducing conditions. No transformation of MTBE or TAME was observed under the other electron-accepting conditions over 3 years. Under all conditions tested, there was no biotic loss of ETBE observed. MTBE and TAME were depleted upon refeeding the sulfate-reducing cultures. This study definitely demonstrates the anaerobic biodegradability of MTBE and TAME under sulfate-reducing conditions.

Methyl tert-butyl ether (MTBE) degradation by a microbial consortium.

The widespread use of methyl tert-butyl ether (MTBE) as a gasoline additive has resulted in a large number of cases of groundwater contamination. Bioremediation is often proposed as the most promising alternative after treatment. However, MTBE biodegradation appears to be quite different from the biodegradation of usual gasoline contaminants such as benzene, toluene, ethyl benzene and xylene (BTEX). In the present paper, the characteristics of a consortium degrading MTBE in liquid cultures are presented and discussed. MTBE degradation rate was fast and followed zero order kinetics when added at 100 mg l(-1). The residual MTBE concentration in batch degradation experiments ranged from below the detection limit (1 microg l(-1)) to 50 microg l(-1). The specific activity of the consortium ranged from 7 to 52 mgMTBE g(dw)(-1) h(-1) (i.e. 19-141 mgCOD g(dw) (-1) h(-1)). Radioisotope experiments showed that 79% of the carbon-MTBE was converted to carbon-carbon dioxide. The consortium was also capable of degrading a variety of hydrocarbons, including tert-butyl alcohol (TBA), tert-amyl methyl ether (TAME) and gasoline constituents such as benzene, toluene, ethylbenzene and xylene (BTEX). The consortium was also characterized by a very slow growth rate (0.1 d(-1)), a low overall biomass yield (0.11 gdw g(-1)MTBE; i.e. 0.040 gdw gCOD(-1)), a high affinity for MTBE and a low affinity for oxygen, which may be a reason for the slow or absence of MTBE biodegradation in situ. Still, the results presented here show promising perspectives for engineering the in situ bioremediation of MTBE.

Methyl tert-butyl ether biodegradation by indigenous aquifer microorganisms under natural and artificial oxic conditions.

Microbial communities indigenous to a shallow groundwater system near Beaufort, SC, degraded milligram per liter concentrations of methyl tert-butyl ether (MTBE) under natural and artificial oxic conditions. Significant MTBE biodegradation was observed where anoxic, MTBE-contaminated groundwater discharged to a concrete-lined ditch. In the anoxic groundwater adjacent to the ditch, concentrations of MTBE were > 1 mg/L. Where groundwater discharge occurs, dissolved oxygen (DO) concentrations beneath the ditch exceeded 1.0 mg/Lto a depth of 1.5 m, and MTBE concentrations decreased to <1 microg/L prior to discharge. MTBE mass flux calculations indicate that 96% of MTBE mass loss occurs in the relatively small oxic zone prior to discharge. Samples of a natural microbial biofilm present in the oxic zone beneath the ditch completely degraded [U-14C]MTBE to [14C]CO2 in laboratory liquid culture studies, with no accumulation of intermediate compounds. Upgradient of the ditch in the anoxic, MTBE- and BTEX-contaminated aquifer, addition of a soluble oxygen release compound resulted in oxic conditions and rapid MTBE biodegradation by indigenous microorganisms. In an observation well located closest to the oxygen addition area, DO concentrations increased from 0.4 to 12 mg/L in <60 days and MTBE concentrations decreased from 20 to 3 mg/L. In the same time period at a downgradient observation well, DO increased from <0.2 to 2 mg/L and MTBE concentrations decreased from 30 to <5 mg/L. These results indicate that microorganisms indigenous to the groundwater system at this site can degrade milligram per liter concentrations of MTBE under natural and artificial oxic conditions.

Monitoring biodegradation of methyl tert-butyl ether (MTBE) using compound-specific carbon isotope analysis.

Methyl tert-butyl ether (MTBE), the most common gasoline oxygenate, is frequently detected in surface water and groundwater. The aim of this study was to evaluate the potential of compound-specific isotope analysis to assess in situ biodegradation of MTBE in groundwater. For that purpose, the effect of relevant physical and biological processes on carbon isotope ratios of MTBE was evaluated in laboratory studies. Carbon isotope fractionation during organic phase/gas-phase partitioning (0.50 +/- 0.15@1000), aqueous phase/gas-phase partitioning (0.17 +/- 0.05@1000), and organic phase/aqueous-phase partitioning (0.18 +/- 0.24@1000) was small in comparison to carbon isotope fractionation measured during biodegradation of MTBE in microcosms based on aquifer sediments of the Borden site. In experiments with MTBE as the only substrate and a cometabolic experiment with 3-methypentane as primary substrate, MTBE became enriched in 13C by 5.1 to 6.9@1000 after 95 to 97% degradation. For both experiments, similar isotopic enrichment factors were obtained (-1.52 +/- 0.06 to -1.97 +/- 0.05@1000). Biodegradation of TBA, which accumulated transiently in the cometabolic microcosms, was also accompanied by carbon isotope fractionation, with an isotopic enrichment factor of -4.21 +/- 0.07@1000. This study suggests that carbon isotope analysis is a potential tool to trace in situ biodegradation of MTBE and TBA and thus to better understand the fate of these contaminants in the environment.

Substrate interactions in BTEX and MTBE mixtures by an MTBE-degrading isolate.

Groundwater contaminant plumes from recent accidental gasoline releases often contain the fuel oxygenate MTBE (methyl tert-butyl ether) together with BTEX (benzene, toluene, ethylbenzene, o-xylene, m-xylene and p-xylene) compounds. This study evaluates substrate interactions during the aerobic biotransformation of MTBE and BTEX mixtures by a pure culture, PM1, capable of utilizing MTBE for growth. PM1 was unable to degrade ethylbenzene and two of the xylene isomers at concentrations of 20 mg/L following culture growth on MTBE. In addition, the presence of 20 mg/L of ethylbenzene or the xylenes in mixtures with MTBE completely inhibited MTBE degradation. When MTBE-grown cells of PM1 were exposed to MTBE/benzene and MTBE/toluene mixtures, MTBE degradation proceeded, while the degradation of benzene and toluene was delayed for several hours. Following this initial lag, benzene and toluene were degraded rapidly, while the rate of MTBE degradation slowed significantly. MTBE degradation did not increase to previous rates until benzene and toluene were almost entirely degraded. The lag in benzene and toluene degradation was presumably due to the induction of the enzymes necessary for BTEX degradation. Once these enzymes were induced, sequential additions of benzene or toluene were degraded rapidly, and growth on benzene and toluene was observed. The results of this study suggest that BTEX and MTBE degradation occurs primarily via two independent and inducible pathways. If subsurface microbial communities behave similarly to the culture used in this study, the observed severe inhibition of MTBE degradation by ethylbenzene and the xylenes and the partial inhibition by benzene and toluene suggest thatthe biodegradation of MTBE in subsurface environments would most likely be delayed until MTBE has migrated beyond the BTEX plume.

Cometabolic biodegradation of methyl tert-butyl ether by a soil consortium: Effect of components present in gasoline.

A soil consortium was tested for its ability to degrade reformulated gasoline, containing methyl tert-butyl ether (MTBE). Reformulated gasoline was rapidly degraded to completion. However, MTBE tested alone was not degraded. A screening was carried out to identify compounds in gasoline that participate in cometabolism with MTBE. Aromatic compounds (benzene, toluene, xylenes) and compounds structurally similar to MTBE (tert-butanol, 2,2-dimethylbutane, 2,2,4-trimethylpentane) were unable to cometabolize MTBE. Cyclohexane was resistant to degradation. However, all n-alkanes tested for cometabolic activity (pentane, hexane, heptane) did enable the biodegradation of MTBE. Among the alkanes tested, pentane was the most efficient (200 &mgr;g/day). Upon the depletion of pentane, the consortium stopped degrading MTBE. When the consortium was spiked with pentane, MTBE degradation continued. When the ratio of MTBE to pentane was increased, the amount of MTBE degraded by the consortium was higher. Finally, diethylether was tested for cometabolic degradation with MTBE. Both compounds were degraded, but the process differed from that observed with pentane.

Bioremediation of MTBE: a review from a practical perspective.

The addition of methyl tert-butyl ether (MTBE) to gasoline has resulted in public uncertainty regarding the continued reliance on biological processes for gasoline remediation. Despite this concern, researchers have shown that MTBE can be effectively degraded in the laboratory under aerobic conditions using pure and mixed cultures with half-lives ranging from 0.04 to 29 days. Ex-situ aerobic fixed-film and aerobic suspended growth bioreactor studies have demonstrated decreases in MTBE concentrations of 83% and 96% with hydraulic residence times of 0.3 hrs and 3 days, respectively. In microcosm and field studies, aerobic biodegradation half-lives range from 2 to 693 days. These half-lives have been shown to decrease with increasing dissolved oxygen concentrations and, in some cases, with the addition of exogenous MTBE-degraders. MTBE concentrations have also been observed to decrease under anaerobic conditions; however, these rates are not as well defined. Several detailed field case studies describing the use of ex-situ reactors, natural attenuation, and bioaugmentation are presented in this paper and demonstrate the potential for successful remediation of MTBE-contaminated aquifers. In conclusion, a substantial amount of literature is available which demonstrates that the in-situ biodegradation of MTBE is contingent on achieving aerobic conditions in the contaminated aquifer.

Review of MTBE Biodegradation and Bioremediation

Conclusive evidence of methyl tert-butyl ether (MTBE) biotransformation and complete mineralization under aerobic conditions in environmental samples and enrichment cultures is reviewed, in addition to increasing evidence of MTBE biotransformation under anaerobic conditions. The metabolic pathway of MTBE appears to have two key intermediates, tert-butyl alcohol (TBA) and 2-hydroxy isobutyric acid (HIBA). The first enzyme in MTBE biodegradation has been identified as either a cytochrome P450 or a nonhemic monooxygenase in different isolates. Mixed and pure cultures of microorganisms have utilized MTBE as a sole carbon and energy source. Cometabolism of MTBE with n-alkanes at rates of 3.9 to 52 nmol/min/mg protein has been documented. The presence of co-contaminants such as BTEX has either not affected or seemed to limit MTBE biodegradation. Some studies of MTBE natural attenuation have attributed mass loss to biodegradation, while others have attributed mass loss to dilution and dispersion. Recent advances in the assessment of MTBE biodegradation have indicated the potential for natural anaerobic transformation of MTBE. In situ bioremediation of MTBE has been enhanced by adding air or oxygen, or by adding microorganisms and air or oxygen. Bioreactors have attained significant removal of MTBE from MTBE-contaminated influent. Despite historical concerns about the biodegradability of MTBE, several biological methods can now be used for MTBE remediation.