Maceration Treatment Research Articles

Maceration Before and During Fermentation: Effect on Pinotage Wine Phenolic Composition, Total Antioxidant Capacity and Objective Colour Parameters

Low-temperature maceration treatments (1, 2 and 4 days at 10 and 15°C) before fermentation and juice/skin mixing treatments (punching-down, pumping-over and rotor action every hour and every 3 hours) during fermentation were investigated in terms of their effects on Pinotage wine phenolic composition, total antioxidant capacity (TAC) and colour over three vintages (2000 to 2002). Results for pre-fermentation maceration were not consistent between vintages. Very few significant differences in the phenolic content, TAC and objective colour parameters were observed between the control wines and wines subjected to different pre-fermentation maceration treatments. Pre-fermentation maceration, especially at 15°C, resulted in wines with increased vitisin A content. Improvement of wine quality when using pre-fermentation maceration treatments at 10°C was noted previously, while no detrimental effect on the wine TAC was observed. The pumping-over treatment yielded wines with lower TAC and phenol content, as well as less favourable objective colour values, indicating that the punching-down or rotor treatment would be preferred. Although mixing at hourly intervals yielded a higher content of some phenolic compounds compared to the 3-hour interval mixing, mixing frequency did not affect the TAC of the wine. The objective colour parameters, h* and b*, were slightly lower at the higher mixing frequency in 2002 indicating a shift in the direction of a magenta hue.

Pre-fermentative cold maceration, saignée, and various thermal treatments as options for modulating volatile aroma and phenol profiles of red wine.

The effects of six maceration treatments on volatile aroma and phenol composition of Teran red wine were studied: standard maceration (control C), cold pre-fermentation maceration (CPM), saignée (S), pre-fermentation heating with extended maceration (PHT) or juice fermentation (PHP), and post-fermentation heating (POH). PHP wine contained the highest amounts of esters, fatty acids and anthocyanins, and the lowest content of other phenols. Alternative treatments decreased higher alcohols in relation to control C. CPM treatment lowered the extraction of seed tannins, exhibited the highest acetaldehyde, ethyl acetate and C6-compounds levels, and had increased ester levels in relation to control C. POH wine contained the highest concentration of total phenols, flavonoids, monomeric, oligomeric and polymeric flavanols, and color intensity and hue. S and PHT wines contained lower amount of total phenols, but higher than in C and CPM wines. The calculated Odor Activity Values were used to establish significant differences between the treatments.

Effect of mash enzyme and heat treatments on the cellular antioxidant activity of black currant (Ribes nigrum), raspberry (Rubus idaeus), and blueberry (Vaccinium myrtillus) juices

ABSTRACTThe aim of this study was to determine the effect of mash enzymatic maceration and heating treatments before pressing on the antioxidant activities in selected berry juices. Total phenolic contents were determined by the Folin–Ciocalteau assay, antioxidant activities were determined by means of the oxygen radical absorbance capacity (ORAC) assay, and the intracellular antioxidant potentials were determined through the cellular antioxidant activity (CAA) assay. Blueberry juices exhibited the highest antioxidant activity, followed by black currant and raspberry juices. The mash enzyme treatment with Pectinex® Ultra Color enzyme preparation, improved the antioxidant activities in vitro. ORAC values correlated with CAA values (R2 = 0.91) and a slightly positive correlation was observed between Folin–Ciocalteau and CAA assays (R2 = 0.56). The findings support the observation that the mash enzymatic treatment of macerated fruits enhances their antioxidant activity. Considering the chemical assays (ORAC and total phenolic content), a combined treatment with heating to 85°C followed by mash enzymatic treatment was the most effective. Considering a biological model through the CAA assay, however, a comparable improvement in antioxidant activity resulted from the enzymatic and the combined treatments. Overall, the data showed that maceration enzymatic treatment improves the intracellular antioxidant activity in HepG2 human cells. To the best of our knowledge, this is the first report on the effect of the antioxidant potential of mash enzymatic and heating treatments assessed by means of a cellular approach.

Effect of Pre-Fermentative Strategies on the Composition of Prieto Picudo (Vitis vinífera) Red Wines

The actual wine global market presents the risk of standardization of the wines and the losses of wine grape peculiarities. To combat this fact, autochthonous wine grapes are extremely interesting to use for winemaking. The use of the pre-fermentative maceration technique in autochthonous grape varieties could be an alternative of increasing their complexity. The aim of the present work was to compare the effect of five different pre-fermentative maceration treatments on the colour, phenolic and volatile composition of Prieto Picudo (PP) autochthonous red wines. The evolution during 12 months of the different wines was also studied for one vintage. Enzymatic, refrigerate and cryo-maceration treatments were applied to PP autochthonous grape varieties. The study was carried out during two consecutive vintages. Results showed that enzymatic maceration was the most effective treatment to improve levels of phenols, colour intensity and volatile compounds. Cold maceration showed also good effects. However, it was not able to improve the extractive effects of enzymatic macerations. Generally, wines obtained with pre-fermentative maceration techniques showed better colour and volatile stability than control wines.

Influence of Pre-Fermentation Treatments on Wine Volatile and Sensory Profile of the New Disease Tolerant Cultivar Solaris.

Solaris is a new disease tolerant cultivar increasingly cultivated in cool climate regions. In order to explore the winemaking processes’ potential to make different styles of Solaris wines, the effects of different pre-fermentation treatments (direct press after crushing, whole cluster press, cold maceration, and skin fermentation) on the volatile profile, chemical, and sensory properties of Solaris wines were investigated. Cold maceration treatment for 24 h and fermentation on skin led to wines with lower acidity and higher glycerol and total polyphenol indexes. Sensory analysis showed that cold maceration enhanced “apricot” and “apple” flavor while skin fermentation gave rise to increased “rose” and “elderflower” flavor. The PLS regression model revealed that fruity flavor of cold macerated wines was related to a combination of esters while β-damascenone and linalool were correlated to the “rose” and “elderflower” flavor. This study provides information about pre-fermentation techniques that allowed the possibility of obtaining wines with different styles.

Nutraceutical Composition of Ber (Zizyphus mauritiana Lamk.) Juice: Effect of Enzyme-Assisted Processing

An investigation was undertaken to study the effect of pre-press maceration treatment with cell-wall degrading enzyme, pectinase, on antioxidant composition of ber juice, during 2011-2012. Enzyme-assisted processing significantly (p<0.05) improved antioxidant composition of ber juice. Ber juice extracted using pectinase had richer nutraceutical composition than in the Control. There was an overall increase of 43% in juice yield, 30% in total phenolics and 37% in total flavonoids with use of pectinase. In vitro total antioxidant activity (AOX) in ber juice was 19.58μmol Trolox/ml in Ferric Reducing Antioxidant Power (FRAP) and 13.44μmol Trolox/ml in Cupric Reducing Antioxidant Capacity (CUPRAC) assay. There was 41-65% increase in total AOX of ber juice extracted with the enzyme overstraight pressed juice. Results indicated that tailoring of the enzyme can yield antioxidant-rich juice products.

Influence of Low Temperature Enzyme Maceration Techniques on Volatile Compounds of Semi-dry Wine Made with cv. <em>Premier</em> of Rabbiteye Blueberries (<em>Vaccinium ashei</em>)

A low temperature enzyme maceration treatment was conducted during fermentation process of semi-dry cv. <em>Premier</em> blueberry wine. The aim of this study was to investigate the influence of maceration conditions on the wine aroma. As a pre-treatment, blueberry must was divided into 6 samples which were respectively treated by pectinase with 6 different maceration conditions at 6°C 1day, 6°C 2 days, 6°C 3 days, 16°C 1 day, 16°C 2 days and 16°C 3 days. After that wines were obtained by fermentation with Saccharomyces cerevisiae. Volatile compounds of wines were analyzed by GC-MS. Overall, the typical aroma compounds of semi-dry cv. Premier wines were constituted by three groups of organic compounds including esters, alcohols and fatty acids. Isoamyl acetate, ethyl caprylate, ethyl decanoate, 2-phenethanol and 3-methylbutanoic acid, which occupied 60% of the typical volatile aromatic compounds, all had higher Odor Activity Values (OAVs) in 6°C 3 days than other conditions. Maceration temperature and time had a significant effect on concentration and varieties of wines aroma substances. The results presented will help to better understand the aroma winemaking potential of this variety.

Impact of Adding White Pomace to Red Grapes on the Phenolic Composition and Color Stability of Syrah Wines from a Warm Climate

The influence of the fermentative addition of Pedro Ximenez grape pomace (PXGP, white variety) on the phenolic composition and color of Syrah red wines from a warm climate was studied. Changes on phenolic composition (HPLC), copigmentation/polymerization (spectrophotometry), and color (tristimulus colorimetry) allowed differences among the maceration treatments to be established. PXGP additions at the rates studied increased the extraction of total phenolics, phenolic acids, and monomeric flavanols. However, the effect on the anthocyanins, copigmentation, and polymerization depended on the doses applied, with important consequences on the color. PXGP addition at 10% led to wines with higher polymerization, more stable colors, and bluish hues. in contrast, perceptibly lighter and less intense wines were obtained with PXGP addition at 20%. Thus, the use of white grape byproducts as wine additives at appropriate levels (10% w/w) could improve the phenolic potential of red young wines from a warm climate, contributing to preserve their color characteristic.

Influence of pre-fermentation cold maceration treatment on aroma compounds of Cabernet Sauvignon wines fermented in different industrial scale fermenters

The influence of pre-fermentation cold maceration (CM) on Cabernet Sauvignon wines fermented in two different industrial-scale fermenters was studied. CM treatment had different effects on wine aroma depending on the types of fermenter, being more effective for automatic pumping-over tank (PO-tank) than automatic punching-down tank (PD-tank). When PO-tank was used, CM-treated wine showed a decrease in some fusel alcohols (isobutanol and isopentanol) and an increase in some esters (especially acetate esters). However, no significant changes were detected in these compounds when PD-tank was used. Ethyl 2-hexenoate and diethyl succinate were decreased, while geranylacetone was increased by the CM treatment in both fermenters. β-Damascenone was increased by the CM treatment in PO-tank fermented wines but decreased in PD-tank fermented wines. The fruity, caramel and floral aroma series were enhanced while chemical series were decreased by the CM treatment in PO-tank fermented wines. The content of (Z)-6-nonen-1-ol in the final wines was positively correlated to CM treatment.

Microwave Maceration of Pinot Noir Grape Must: Sanitation and Extraction Effects and Wine Phenolics Outcomes

Pinot noir grapes have a unique phenolic profile which can impinge on the extraction and stabilisation of compounds such as anthocyanins and tannins which contribute to the colour and mouthfeel of red wine. This study examined the concentration of phenolic compounds in Pinot noir grape must and wine following application of a novel microwave maceration treatment for red grape must. Microwave maceration was shown to be highly effective for extraction of phenolics from grape solids into grape juice. When juices were fermented to wine, ultraviolet–visible spectrophotometry showed microwave maceration was associated with significantly higher concentrations of total phenolics, anthocyanin, tannin and pigmented tannin in wine at 18 months bottle age, compared with control wine. Mean tannin concentration in microwave treatment wine was 0.60 gm/L at 18 months, compared with 0.14 gm/L in control wine. The microwave treatment was also associated with a substantial and rapid decrease in the grape-associated yeast population, compared with control maceration, and a shorter lag phase at the outset of alcoholic fermentation. Based on this study, microwave maceration warrants further investigation as a potential industrial-scale application in red winemaking.

The comparison of the collagen fiber contents and hepatic stellate cell distribution in male and female chicken livers

The difference in collagen fiber content, morphological properties and hepatic stellate cell (HSC) distribution was investigated in the liver of both sexes in chicken. Collagen fiber specimens were obtained by maceration treatment with NaOH solution. HSCs were detected using desmin-specific immunohistochemistry. The ratio of liver weight to body weight was larger in the female than the male chickens. Collagen fiber content, the numerical density of HSCs and the percentage area displaying desmin immunopositivity were not different between the right and left lobes of the liver, in both male and female chickens. However, all of these parameters were larger in the males than the females. In the light microscopic observation, many HSCs in the male had large and elongated cytoplasmic processes. Conversely, HSCs with poorly developed cytoplasmic processes were frequently observed in females. Liver tissue is structurally stronger in male chickens than females and the activity and density of HSCs may be related to the collagen fiber content in chicken liver.

Effect of Different Maceration Levels on the Antioxidant and Bioavailability of Wine from &lt;i&gt;Vitis vinifera&lt;/i&gt; Cv. Muscat Hamburg

The paper studied the effect of different maceration levels on the antioxidant and bioavailability of wine from vitis vinifera cv. Muscat Hamburg in China. The bioavailability of phenolic fraction was assayed for Folin-Ciocalteu Reaction (FCR) reducing capacity, and methanol content was determined with Gas Chromatography. All maceration treatments raised wine polyphenolic content and antioxidant while increased the methanol, too. Evaluated by an in vitro digestion process, the bioavailability of polyphenolic compounds and methanol in wine showed that the FCR value of the full-maceration samples was the highest (31.56%), the methanol content of the samples was higher than that of other three groups (29.60%), and the availability was up to its maximum absorptivity (53.07%). It suggests that the Muscat red wine may represent higher quality and bioavailability after extended maceration.

The Extraction of Anthocyanins and Proanthocyanidins from Grapes to Wine during Fermentative Maceration Is Affected by the Enological Technique

The effect of three enological techniques (low temperature prefermentative maceration, must freezing with dry ice, and the use of a maceration enzyme) on the extraction of anthocyanins and proanthocyanidins from must to wine during fermentative maceration was studied to determine the extent to which these compounds are extracted and to assess the changes on their qualitative composition due to enological technique applied. The results showed that the dry ice treatment led to wines with high color intensity and high anthocyanin content, the maximum rate of extraction being observed the first 6 days of fermentative maceration. Regarding the effect of the different techniques on the quantitative and qualitative composition of proanthocyanidins, only the dry ice treatment seemed to favor the extraction of high molecular weight skin proanthocyanidins. The low temperature prefermentative maceration treatment led to the highest concentration of proanthocyanidins at the moment of pressing; however, this treatment, contrary to expectations, led to wines with the highest content of seed-derived proanthocyanidins. The use of the maceration enzyme also increased the concentration of proanthocyanidins during all of the fermentative process, as compared to a control wine, although the increase was not only due to skin proanthocyanidins but also seed proanthocyanidins. We have demonstrated in this study that maceration enzymes also facilitate seed phenolic extraction.

Black carrot ( Daucus carota ssp. sativus) juice: Processing effects on antioxidant composition and color

Black carrot, a potential source of anthocyanin pigment, has high antioxidant activity. The effect of pre-press maceration treatment with different doses of cell wall degrading enzyme pectinase ( Aspergillus niger Teigh) on antioxidant composition of black carrot juice was investigated. Enzyme-assisted processing significantly ( p < 0.05) improved the antioxidant composition of black carrot juice. There was an overall increase of 33% in juice yield, 27% in total phenolics and 46% in total flavonoids. The total anthocyanin content in black carrot juice was almost doubled. The in vitro total antioxidant activity in black carrot juice extracted through enzyme-assisted processing was 30.0 and 62.0 μmol TE/mL in ferric reducing antioxidant power (FRAP) and cupric reducing antioxidant capacity (CUPRAC) assays, respectively. There was 30% increase in total antioxidant activity of black carrot juice extracted with enzyme over straight pressed juice. The results indicate that tailoring of specific enzyme mixtures can yield antioxidant rich juice products. Optimizing a strategy for extraction of phenolic rich juice from black carrots can offer an opportunity for its utilization in developing novel functional beverages with enhanced color appeal and high antioxidant activity.

Study of the influence of micro-oxygenation and oak chip maceration on wine composition using an electronic tongue and chemical analysis

The influence of micro-oxygenation (MOX) and maceration with oak chips treatments on wine was studied on wine samples from three vintages produced in the Yarra Valley, Australia. A full factorial design was employed where two factors (MOX and oak chips treatments) had two levels and one factor (vintage) had three levels. Three replicated treatments were run for each factor's setting. Wine samples were analysed using conventional laboratory methods with respect to the phenolic wine compounds and colour attributes since the phenolic fraction of wine is most affected by both MOX and oak maceration treatments. The same wine samples were measured with an electronic tongue based on potentiometric chemical sensors. The significance of treatments and vintage effects on wine phenolic compounds was assessed using ANOVA and ANOVA-Simultaneous Component Analysis (ASCA). Cross-validation was used for the ASCA sub-model optimisations and permutation test for evaluations of the significance of the factors. Main effects of vintage and maceration with oak chips were found to be significant for both physicochemical and the ET data. Main effect of MOX treatment was also found significant for the physicochemical parameters. The largest effect on the phenolic composition of wine was due to its vintage, which accounted for 70% and 33% of total variance in the physicochemical and ET data respectively. The ET was calibrated with respect to the total phenolic content, colour density and hue and chemical ages 1 and 2 and could predict these parameters of wine with good precision.

Effect of the prefermentative addition of copigments on the polyphenolic composition of Tempranillo wines after malolactic fermentation

The influence of the prefermentative addition of copigments and different winemaking technologies on the polyphenolic composition of Tempranillo red wines after malolactic fermentation was studied. Six experiments dealing with the prefermentative addition of caffeic acid, rutin, (+) catechin, white grape skin tannin, white grape seed tannin and control wines were realised. Three different winemaking technologies (traditional vinification, prefermentative cold maceration at 6–8 °C and cold soak at 0–2 °C with dry ice) were studied. Prefermentative addition of copigments increases anthocyanin copigmentation reactions and produces wines with a greater colour, a higher anthocyanin concentration, a superior contribution of anthocyanins to the colour of the wine, a superior percentage of tannins polymerised with polysaccharides and less astringency. Cold prefermentative maceration increases the extraction of polyphenols, the anthocyanin copigmentation reactions and the polymerisation reactions between tannins and polysaccharides. The effectiveness of the combination of copigments and prefermentative maceration treatments was demonstrated by the increase of the concentration of the polyphenolic compounds.

Statistically designed two step response surface optimization of enzymatic prepress treatment to increase juice yield and lower turbidity of elderberry juice

This study examined the effects of different, statistically designed, enzymatic maceration treatments on juice yield, turbidity, and phenol yield (total phenols and total anthocyanins) in experimentally produced elderberry juice. Increased pectinolytic enzyme dose, longer maceration time, and elevated reaction temperature all had significantly positive effects on the juice yield. Increased enzyme dose and maceration temperature also increased the yields of anthocyanins in the elderberry juice, while none of the reaction parameters affected the juice turbidity. The juice yield was optimized further in a new experimental template, made by using the statistical steepest ascent optimization method. In the new response surface design template an optimal maceration treatment giving maximal juice yield and anthocyanin yields and low turbidity was identified. With the optimal treatment with a pectinolytic enzyme preparation, Pectinex BE 3L, produced by a cloned Aspergillus strain, a maximal juice yield of 77% w/w of the berry mash, an anthocyanin yield of 2380 mg/kg fresh berry mash, and a turbidity level of 128 formazin nephelometric units (FNU) were obtained. Enzymatic prepress treatment generally decreased turbidity levels by 30% as compared to pressing without prior enzymatic treatment. A comparison of the responses obtained after the optimal enzymatic treatment with five different pectinolytic enzyme preparations showed that the Aspergillus niger preparation Pectinex BE Color gave slightly better juice and phenol yields, and lower turbidity levels than the other enzyme preparations tested. In conclusion, the results demonstrated that juice yields and phenolic yields in elderberry juice could be improved with enzyme treatment and that the optimal reaction conditions for obtaining the best juice yield, highest phenolics, and lowest turbidity levels could be rationally identified via statistical factor level optimization.

Anthocyanin composition of the red wine Babić affected by maceration treatment

Identification of anthocyanins in the wine made of the Croatian autochthonous grape variety of Babic (Vitis vinifera L.) was carried out and their profile was determined by means of high-performance liquid chromatography with diode array and mass spectrometric detection. Dependence of anthocyanins content and profile on maceration treatment conditions was investigated. Statistically significant differences of anthocyanins concentration in wines Babic produced by various maceration treatments were confirmed by the use of multivariate analysis of variances. The investigation results indicated that the maceration temperature exerts higher influence on anthocyanins concentration than the duration of maceration. In addition, on the basis of anthocyanin composition and using different multivariate statistical analyses, differentiation of wines Babic according to maceration treatments was procured.

Effects of different enzymatic maceration treatments on enhancement of anthocyanins and other phenolics in black currant juice

Pre-press maceration treatments with 10 different pectinolytic enzyme preparations were investigated in experimental black currant juice production using response surface design templates. Enzyme dosage, maceration time, reaction temperature, and degree of berry crushing were varied, and the juice yields, anthocyanins, total phenols, and turbidity in the resulting juices were compared for a total of 250 different enzymatic treatments. The yields of anthocyanins and total phenols in the juices ranged from 900 to 2200 and 3050 to 5100 mg/kg wet weight black currant mash, respectively. Juice yields ranged from 66.4% to 78.9% by wet weight of mash. Turbidity levels ranged from 25 to 916 formazan nephelometric units (FNU). The reaction parameters induced larger variations in the responses than the different enzyme preparations, but the cloned Aspergillus niger/ Aspergillus aculeatus preparation Pectinex BE® consistently tended to be among those giving the best responses regarding anthocyanin yields, phenols, and low juice turbidity. The optimal maceration was achieved using an enzyme dosage of 0.18% by wet weight of berries with a reaction at 60 °C for 30 min on the most finely crushed berry mash. This treatment gave similar profiles of anthocyanins in the juices with all the 10 enzyme preparations. The same 10 juices all exhibited antioxidant activity against human low-density lipoprotein oxidation in vitro, but the antioxidant potency varied depending on the enzyme preparation used in the pre-press maceration.

Effects of different enzymatic pre-press maceration treatments on the release of phenols into blackcurrant juice

The effects of different pectinolytic enzyme treatments on the release of phenolic compounds from blackcurrant berry mash into juice in experimental blackcurrant juice production were examined. The influence of enzyme dose (0–0.1% by weight), degree of berry crushing, maceration time, and temperature on the total phenol concentration, the juice yield, and on polysaccharide degradation were evaluated for four commercial, fungal enzyme preparations in statistically designed experimental templates. In optimal experimental conditions, treatments with Macer8 [FJ] and Pectinex Ultra SP-L released ~6500 and 6650 mg gallic acid equivalents/L of total phenols, respectively. These levels correspond to increases of 14–15% compared to the juice extracted without enzymes, and were significantly higher than those achieved with Rapidase BE Super and Grindamyl pectinase treatments. Increased enzyme dosage gave larger juice yields and higher phenol concentrations. There was a positive, linear correlation between degradation of the substrate polysaccharides and the amount of phenols released. The juice samples inhibited the oxidation of human low-density lipoproteins in vitro in a dose-dependent matter. The non-enzyme-treated sample exhibited higher antioxidant activity than the enzyme-treated juices at equimolar test levels of phenols, presumably because of differences in their phenolic profiles.