Low Ammonia Research Articles

Implementation of various injection rate shapes in an ammonia/diesel dual-fuel engine with special emphasis on combustion and emissions characteristics

As the problem of global warming continues to intensify, carbon-free fuel ammonia is crucial for internal combustion engines, and a potential ammonia combustion route is dual-fuel mode. The impact of various injection rate shapes (trapezoid, wedge, slope, triangle, and rectangle) on engine combustion and emissions performance with 0 %, 20 %, and 40 % ammonia energy fractions were estimated. Under the identical ratio of the ammonia-doped schemes, the fuel injection gross mass and fuel injection duration are the same. The results indicate that the triangle injection rate shape can make the mixture of diesel and ammonia gas more uniform, leading to combustion in the combustion chamber closer to homogeneous combustion. When the injection shape is the triangle, the indicated mean effective pressure in the cylinder is the highest at 10.29 bar, which is 4.04 % higher than that of the pure diesel original injection shape. The triangle injection shape makes the ammonia-diesel dual fuel burn more concentrated, resulting in lower unburned ammonia loss and higher thermal efficiency. Under the 40 % ammonia energy fraction and triangle injection shape, the highest thermal efficiency reaches 40.57 %, 1.58 % higher than the pure diesel original injection shape. Additionally, it significantly reduces unburned ammonia emissions. The injection rate shapes have a minor impact on CO2 emissions. The rapid increase in-cylinder average temperature can substantially reduce N2O emissions, thereby lowering total greenhouse gas emissions. Among them, the total greenhouse gas emissions of 40 % ammonia energy fraction and triangle injection shape are the lowest, at 81619 ppm, which is 11.3 % lower than that of pure diesel original injection shape. On the contrary, it will increase NOx emissions. Conversely, the slopes exhibit the lowest NOx emissions at 220.8 ppm, representing an 88 % reduction compared to the pure diesel original injection shape.

Substitution of One Meat-Based Meal With Vegetarian and Vegan Alternatives Generates Lower Ammonia and Alters Metabolites in Cirrhosis: A Randomized Clinical Trial.

Diet can affect ammoniagenesis in cirrhosis and hepatic encephalopathy (HE), but the impact of dietary preferences on metabolomics in cirrhosis is unclear. As most Western populations follow meat-based diets, we aimed to determine the impact of substituting a single meat-based meal with an equal protein-containing vegan/vegetarian alternative on ammonia and metabolomics in outpatients with cirrhosis on a meat-based diet. Outpatients with cirrhosis with and without prior HE on a stable Western meat-based diet were randomized 1:1:1 into 3 groups. Patients were given a burger with 20 g protein of meat, vegan, or vegetarian. Blood for metabolomics via liquid chromatography-mass spectrometry and ammonia was drawn at baseline and hourly for 3 hours after meal while patients under observation. Stool microbiome characteristics, changes in ammonia, and metabolomics were compared between/within groups. Stool microbiome composition was similar at baseline. Serum ammonia increased from baseline in the meat group but not the vegetarian or vegan group. Metabolites of branched chain and acylcarnitines decreased in the meat group compared with the non-meat groups. Alterations in lipid profile (higher sphingomyelins and lower lysophospholipids) were noted in the meat group when compared with the vegan and vegetarian groups. Substitution of a single meat-based meal with a non-meat alternatives results in lower ammoniagenesis and altered serum metabolomics centered on branched-chain amino acids, acylcarnitines, lysophospholipids, and sphingomyelins in patients with cirrhosis regardless of HE or stool microbiome. Intermittent meat substitution with vegan or vegetarian alternatives could be helpful in reducing ammonia generation in cirrhosis.

Co-incorporation of rice straw and green manure with reduced nitrogen fertilizer application maintained rice yield and lowered ammonia volatilization

Co-incorporation of rice straw and green manure with reduced nitrogen fertilizer application maintained rice yield and lowered ammonia volatilization

Simultaneous veterinary antibiotics reduction and biomass production from pig slurry by microalgae co-immobilization in moving bed biofilm reactors

The objective of the study was to assess, for the first time, the effectiveness of using either freely suspended or co-immobilized microalgae on Moving Bed Biofilm Reactor carriers in removing lincomycin from the liquid fraction of pig slurry, while ensuring the safe production of biomass. To this end, continuous-mode (HRT = 8 d) and batch-mode (10 d) experiments were conducted on bench-scale reactors. In the continuous-mode experiment, co-immobilized microalgae removed 99 % of lincomycin and 94 % of ammonium, whereas the control reactors and free-microalgae reactors showed significantly lower ammonium removals (69 % and 87 %, respectively). The removal rates for lincomycin and ammonium in co-immobilized microalgae reactors were higher (0.85 and 0.32 d−1, respectively) than the removal rates of the free-microalgae reactors (0.32 and 0.19 d−1) and control reactor (0.18 and 0.12 d−1). Furthermore, the microalgae reactors were linked with the production of lincomycin transformation products following ammonium and nitrate removal. In contrast to the control reactors, the suspended biomass of both free microalgae and co-immobilized microalgae reactors showed no accumulation of lincomycin. This characteristic makes this biomass particularly appealing in the context of a circular economy. The study introduces an innovative method for producing biomass from pig slurry, with the goal of obtaining high-value products while minimizing pollutant content.

Computational Analysis of Low Overpotential Ammonia Oxidation by Metal-Metal Bonded Ruthenium Catalysts, and Predictions for Related Osmium Catalysts.

The catalyzed electrochemical oxidation of ammonia to nitrogen (AOR) is an important fuel-cell half-reaction that underpins a future nitrogen-based energy economy. Our laboratory has reported spontaneous chemical and electrochemical oxidation of ammonia to dinitrogen via reaction of ammonia with the metal-metal bonded diruthenium complex Ru2(chp)4OTf (chp- = 2-chloro-6-hydroxypyridinate, TfO- = trifluoromethanesulfonate). This complex facilitates electrocatalytic ammonia oxidation at mild applied potentials of -255 mV vs ferrocene, which is the [Ru2(chp)4(NH3)]0/+ redox potential. We now report a comprehensive computational investigation of possible mechanisms for this reaction and electronic structure analysis of key intermediates therein. We extend this analysis to proposed second-generation electrocatalysts bearing structurally similar fhp and hmp (2-fluoro-6-hydroxypyridinate and 2-hydroxy-6-methylpyridinate, respectively) equatorial ligands, and we further expand this study from Ru2 to analogous Os2 cores. Predicted M24+/5+ redox potentials, which we expect to correlate with experimental AOR overpotential, depend strongly on the identity of the metal center, and to a lesser degree on the nature of the equatorial supporting ligand. Os2 complexes are easier to oxidize than analogous Ru2 complexes by ∼640 mV, on average. In contrast to mono-Ru catalysts, which oxidize ammonia via a rate-limiting activation of the strong N-H bond, we find lowest-energy reaction pathways for Ru2 and Os2 complexes that involve direct N-N bond formation onto electrophilic intermediates having terminal amido, imido, or nitrido groups. While transition state energies for Os2 complexes are high, those for Ru2 complexes are moderate and notably lower than those for mono-Ru complexes. We attribute these lower barriers to enhanced electrophilicity of the Ru2 intermediates, which is a consequence of their metal-metal bonded structure. Os2 intermediates are found to be, surprisingly, less electrophilic, and we suggest that Os2 complexes may require access to oxidation states higher than Os25+ in order to perform AOR at reasonable reaction rates.

Metabolomic and morphologic surveillance reveals the impact of lactic acid-treated barley on in vitro ruminal fermentation.

Lactic acid (LA) treatment of cereals is known to improve ruminant performance. However, changes in cereal nutrient levels and variations in rumen fermentation remain unclear. This study was designed to compare the effects of 5% LA treatment on the trophic and morphological characteristics of barley and to discover the differences in rumen fermentation characteristics and metabolomes between LA-treated and untreated barley. Compared with those of untreated barley (BA), the dry matter (DM), crude protein (CP), ash and water-soluble carbohydrate contents of barley plants treated with 5% LA for 48 h (BALA) decreased, but the resistant starch (RS) and non-fiber carbohydrate contents increased. Moreover, the amount of proteinaceous matrix in BA decreased in response to LA treatment. During in vitro fermentation, BALA had a greater pH but lower dry matter disappearance and ammonia, methane, and short-chain fatty acid levels than BA. The differential metabolites between BA and BALA were clustered into metabolic pathways such as purine metabolism, lysine degradation, and linoleic acid metabolism. Observable differences in ultrastructure between BALA and BA were noted during fermentation. Lactic treatment altered barley nutrient content, including DM, CP, RS, ash, water-soluble carbohydrates and non-fiber carbohydrates, and affected barley ultrastructure. These variations led to significant and incubation time-dependent changes in the in vitro fermentation characteristics and metabolome.

Mechanism of stable autotrophic nitrogen removal and NOB inhibition in low-sludge PN-Anammox system under non-temperature control and low ammonia environment

PN/Anammox, as an economical and effective nitrogen removal process, is of great significance for reducing carbon emission in municipal wastewater treatment. However, municipal wastewater has mainstream characterized of low temperature and low NH4+-N concentration, and NOB activity is difficult to inhibit, so achieving a stable PN process is the biggest challenge in the application of PN/Anammox to mainstream wastewater. This study developed a method for stable and efficient PN/Anammox based on very low sludge volume (MLVSS = 65 mg/L). Even when the temperature dropped to 15℃ or there was exogenous nitrite-oxidizing bacteria (NOB) interference, the system still had good inhibition of NOB activity. The total stable operation time was 386 days, and the NO2–-N accumulation efficiency could reach more than 90 %. Ellin6067, Nitrosomonas and Candidatus_Brocadia were the dominant functional microorganisms in the system. Nitrospira was the dominant genera of NOB with very low relative abundance (<0.04 %). The mechanism of the long-term stable mainstream PN/Anammox system showed that low sludge content was beneficial to light irradiation on microorganisms in the reactor, while nxrA, the functional gene of NOB, had weak light resistance and oxidation resistance, which makes the system had strong inhibition effect on NOB. The construction of this new system which does not depend on activated sludge volume and complex NOB activity inhibition strategy can better promote the practical application of PN/Anammox under mainstream conditions.

Defatted black soldier fly larvae meal in lactating sow and pre-weaning piglet diets: impacts on growth performance, fecal microbiota, and metabolic pathways

Abstract To address the underexplored use of black soldier fly larval (BSFL) meal in pig farming for sustainable development, this study examined the effects of substituting conventional protein with defatted BSFL meal in the pre-weaning diet of piglets farrowed from sows fed defatted BSFL diets (0%, 2.3%, and 4.6%). Fifty-four piglets (18 piglets in each treatment) were housed with sows until 28 days of age and fed a pre-weaning diet containing 0%, 12.5%, or 25% defatted BSFL meal based on their respective sows’ dietary treatments (0%, 2.3%, and 4.6% defatted BSFL diets) from 21 to 35 days of age. The growth performances and fecal microbiota of piglets were investigated. The results showed that sow diets and defatted BSFL meal-incorporated pre-weaning diets did not have a significant effect on the growth performance of piglets (). However, piglet growth tended to decrease with increasing defatted BSFL meals in the pre-weaning diets. Additionally, piglets nursed by sows fed defatted BSFL diets showed higher fecal short-chain fatty acid and lower ammonia levels at 21 days of age than those nursed by sows fed a control diet (). Furthermore, defatted BSFL meal-incorporated pre-starter diets decreased fecal amino acids and modified the gut microbial metabolic pathways associated with stress response. These findings suggest that the appropriate inclusion of defatted BSFL meal in the diets of lactating sows and piglets did not adversely affect the growth performance of piglets and may potentially improve the health of piglets at weaning; however, attention should be paid to the chitin content in BSFL diets, which may affect nutrient digestibility. Incorporating 2.3% defatted BSFL to sow and 12.5% to pre-weaning piglet diets may serve as a feeding strategy in pig farming. The results obtained will aid the application of BSFL meal in the swine industry and the study of its dietary effect on weaning stress in piglets.

Superior mainstream partial nitritation in an acidic membrane-aerated biofilm reactor

Shortcut nitrogen removal holds significant economic appeal for mainstream wastewater treatment. Nevertheless, it is too difficult to achieve the stable suppression of nitrite-oxidizing bacteria (NOB), and simultaneously maintain the activity of ammonia-oxidizing bacteria (AOB). This study proposes to overcome this challenge by employing the novel acid-tolerant AOB, namely “Candidatus Nitrosoglobus”, in a membrane-aerated biofilm reactor (MABR). Superior partial nitritation was demonstrated in low-strength wastewater from two aspects. First, the long-term operation (256 days) under the acidic pH range of 5.0 to 5.2 showed the successful NOB washout by the in situ free nitrous acid (FNA) of approximately 1 mg N/L. This was evidenced by the stable nitrite accumulation ratio (NAR) close to 100 % and the disappearance of NOB shown by 16S rRNA gene amplicon sequencing and fluorescence in situ hybridization. Second, oxygen was sufficiently supplied in the MABR, leading to an unprecedentedly high ammonia oxidation rate (AOR) at 2.4 ± 0.1 kg N/(m3 d) at a short hydraulic retention time (HRT) of a mere 30 min. Due to the counter diffusion of substrates, the present acidic MABR displayed a significantly higher apparent oxygen affinity (0.36 ± 0.03 mg O2/L), a marginally lower apparent ammonia affinity (14.9 ± 1.9 mg N/L), and a heightened sensitivity to FNA and pH variations, compared with counterparts determined by flocculant acid-tolerant AOB. Beyond supporting the potential application of shortcut nitrogen removal in mainstream wastewater, this study also offers the attractive prospect of intensifying wastewater treatment by markedly reducing the HRT of the aerobic unit.

Coupling of struvite crystallization and aqueous phase recirculation for hydrochar upgrading and nitrogen recovery during hydrothermal carbonization of sewage sludge

Recycling of aqueous phase (AP) as a by-product after hydrothermal carbonization (HTC) of sewage sludge (SS) has been of interest. The combination of magnesium ammonium phosphate (MAP) or the so-called struvite crystallization and aqueous phase (AP) recirculation has great potential for resource recovery and hydrochar enhancement. In this study, both the aqueous phase of HTC after MAP recovery of NH4+-N (AP-MAP) and the untreated aqueous phase of HTC (AP-HTC) were reused for HTC of fresh SS, and both aqueous phases were recycled four times. The effects of the two AP cycles on the properties of AP and hydrochar at 200, 230, and 260 °C were studied, and the effect of temperature on the two AP cycles was similar. The hydrochar produced by the AP-MAP cycle had lower nitrogen content than that of the AP-HTC cycle due to the low ammonia nitrogen (NH4+-N) content, and the combustion performance was improved. MAP recovery reduces the accumulation of NH4+-N in the AP cycle and MAP is also a high-quality fertilizer. Therefore, the combination of MAP recovery and AP recycling provides a feasible technical approach for resource utilization, eutrophic AP treatment, and production of high-quality hydrochar in the HTC process of SS.

Dissolved oxygen dependence of Microbe-Derived dissolved organic nitrogen dynamics during membrane biofilm-based linear alkylbenzene sulfonate mineralization

Oxygen-based membrane biofilm reactor (O2-MBfR) can achieve bubble-free efficient linear alkylbenzene sulfonate (LAS) mineralization. However, effluent microbially derived dissolved organic nitrogen (mDON) reduces recycled water quality and induces water eutrophication. How dissolved oxygen (DO) impacts the dynamics of mDON during LAS biodegradation is unknown. Here, we explored the fate of mDON releasing, molecular characteristics and formation metabolisms in the O2-MBfR responding to DO dynamics using Fourier transform ion cyclotron resonance mass spectrometry and metagenomic analyses. Results showed that DO presents a negative impact (λ = -0.242, P < 0.001) on mDON production, but can positively influence mDON reduction through influencing total organic nitrogen (TDN) removal. DO of 0.3 mg/L led to the lowest concentration of mDON with the least number of organic molecular formulas and high proportion of stable N2– and N3-containing organics. Much lower (0.0 mg/L) or higher (0.6 mg/L) DO concentrations favored dissimilatory-based ammonia formation and assimilatory nitrogen fixation that enhancing mDON formation. Firmocutes were the dominant bacteria that contributing to mDON formation. TDN (λ = 0.844, P < 0.001) and pH (λ = 0.248, P < 0.01) directly affected the effluent mDON concentration. The relatively low effluent mDON under anoxic condition suggested that DO controlling can be an effective strategy to minimize bioavailable mDON discharges in the O2-MBfR, which showed great implication potential for high-quality reclaimed water production and eutrophication control.

Boosting electrocatalytic nitrogen fixation on Ni-P codoped MoS2 nanosheets

Electrocatalytic nitrogen fixation in an aqueous solution is considered a promising approach to ammonia synthesis. Still, this process has low Faraday efficiency and ammonia yield, so it is necessary to develop an efficient, clean, and safe catalyst to promote nitrogen reduction process. Doping can be easily carried out during the crystal growth owing to the weak interaction between the sandwiched layers (due to van der Waals forces) of MoS2. Here, a Ni-P codoped MoS2 nanosheets is designed as a highly efficient catalyst for electrochemical nitrogen fixation with superior selectivity. Especially, the doping of Ni achieved the transformation of MoS2 from 2 H phase to 1 T phase, improving the conductivity of the material. In addition, the doping of P creates more sulfur vacancies in the catalyst, thereby producing more H*, which promotes the adsorption and activation of nitrogen. The as-synthesized Ni-P codoped MoS2 nanosheets show excellent catalytic performance with a high yield of electrocatalytic ammonia synthesis (84.29 μgNH3 h−1 mgcat−1) and Faraday efficiency (2.39 %) at −0.5 V versus reversible hydrogen electrode in acidic electrolytes (0.005 M H2SO4), which outperformed most electrocatalytic ammonia synthesis catalysts. Furthermore, the Ni-P codoped MoS2 catalyst also shows outstanding electrochemical stability and durability. This work may offer a hopeful lead for designing effective non-noble-metal NRR electrocatalysts.

Epiberberine: a potential rumen microbial urease inhibitor to reduce ammonia release screened by targeting UreG

Rumen microbial urease inhibitors have been proposed for regulating nitrogen emission and improving nitrogen utilization efficiency in ruminant livestock industry. However, studies on plant-derived natural inhibitors of rumen microbial urease are limited. Urease accessory protein UreG, plays a crucial role in facilitating urease maturation, is a new target for design of urease inhibitor. The objective of this study was to select the potential effective inhibitor of rumen microbial urease from major protoberberine alkaloids in Rhizoma Coptidis by targeting UreG. Our results showed that berberine chloride and epiberberine exerted superior inhibition potential than other alkaloids based on GTPase activity study of UreG. Berberine chloride inhibition of UreG was mixed type, while inhibition kinetics type of epiberberine was uncompetitive. Furthermore, epiberberine was found to be more effective than berberine chloride in inhibiting the combination of nickel towards UreG and inducing changes in the second structure of UreG. Molecular modeling provided the rational structural basis for the higher inhibition potential of epiberberine, amino acid residues in G1 motif and G3 motif of UreG formed interactions with D ring of berberine chloride, while interacted with A ring and D ring of epiberberine. We further demonstrated the efficacy of epiberberine in the ruminal microbial fermentation with low ammonia release and urea degradation. In conclusion, our study clearly indicates that epiberberine is a promising candidate as a safe and effective inhibitor of rumen microbial urease and provides an optimal strategy and suitable feed additive for regulating nitrogen excretion in ruminants in the future.Key points• Epiberberine is the most effective inhibitor of rumen urease from Rhizoma Coptidis.• Urease accessory protein UreG is an effective target for design of urease inhibitor.• Epiberberine may be used as natural feed additive to reducing NH3 release in ruminants.

Enhancing microbial viability with biochar for increased methane production during the anaerobic digestion of chicken manure

This investigation explores the effects of integrating acid-alkali treated biochar into the anaerobic digestion of chicken manure. Digesters containing chicken manure with biochar addition exhibited an 8.4-fold improvement in methane production compared to untreated digesters. In addition, the porous structure of the biochar promoted microbial acclimation, facilitated direct interspecies electron transfer, and provided anchoring points for immobilisation. Anaerobic digesters containing chicken manure amended with biochar also demonstrated increased chemical oxygen demand removal, up to 81.8 %, and maintained lower total ammonia concentrations (2,478 mg/L) compared to levels in control reactors (4418 mg/L). In terms of the microbial community, the addition of propidium monoazide minimised errors in live microbial population estimation, providing new insights into the capacity of biochar to shield microbes from ammonia stress. These findings highlight biochar's quantitative benefits, emphasising its potential in enhancing methane production, mitigating ammonia stress, and promoting microbial resilience in anaerobic digestion.

Industrial waste-based Ni-catalysts for ammonia decomposition to produce clean hydrogen

The high mineral containing solid waste materials generated during aluminum production currently lacks any practical application. In this work, the potential of solid waste with/without additional nickel loading (10 to 20 wt%) was investigated as an active catalyst for low temperature ammonia decomposition to produce high purity hydrogen. The X-ray diffraction (XRD) analysis of the samples reveals that iron oxide was the primary component of solid waste with the ability to catalyze the ammonia decomposition reaction. The reducibility, metal support interaction and catalytic activity of the solid waste supported Ni-based catalysts were correlated by the reduction kinetics of the catalysts using temperature-programmed reduction (H2-TPR) data and nucleation/nuclei growth models. Based on the statistical indicators, it was concluded that the random nucleation model describes catalyst reduction adequately. The estimated activation energy for the reduction of the solid waste itself was significantly higher (108.5 kJ/mol) than that of solid waste supported catalyst containing 10 wt% Ni (86.6 kJ/mol). The increase in nickel loading also slightly decreased the activation energy of catalyst reduction, indicating an improvement in the reducibility of the nickel-containing catalysts. These reduction behaviors were also reflected in the ammonia decomposition reaction in a flow reactor. The addition of nickel onto the solid waste resulted in the creation of additional active nickel sites. Consequently, the nickel loaded solid waste supported catalysts exhibited significant improvements in ammonia decomposition activity. Among the three solid waste supported Ni-based catalysts, the catalyst containing 15 wt% Ni displayed the highest activity, that also remained unchanged over extended period, indicating the catalyst stability.

Development of Structure-Property Relationships for Ammonium Transport through Charged Organogels.

Ammonia is a promising carbon-free fuel, but current methods to produce ammonia are energy intensive. New methods are thereby needed, with one promising method being electrochemical nitrogen reduction cells. Efficient cell operation requires robust catalysts but also efficient membrane separators that permit the selective transport of ions while minimizing the transport of the products across the cell. Commercial membranes have an unknown morphology which makes designing improved cells challenging. To address this problem, we synthesized a series of membranes with controlled crosslinking density and chemical composition to understand their impact on ammonium transport. Higher crosslinking density led to lower ammonium permeability. At the highest crosslinking density, similar ammonium permeability was observed independent of the water volume fraction and hydrophobicity of the monomers. These results suggest new directions to develop membranes with reduced ammonium crossover to improve the efficiency of these electrochemical cells.

Modelling Nitrogen Removal in the Kibendera Wastewater Stabilization Ponds in Ruiru, Kenya

Application of waste stabilization ponds (WSP) in wastewater treatment in the tropical regions is primarily due to their affordability and relatively high treatment performance. Monitoring of 2-year nitrogen removal behavior in Kibendera WSP in Ruiru, Kenya, was undertaken between January 2021 and December 2022. The experimental work determined the concentrations and removal efficiencies of Ammonia, Nitrate, Nitrite, Organic Nitrogen and Total Nitrogen. Standard Methods for the examination of water and wastewater determined Nitrogen and Dissolved Oxygen (DO) concentrations. Based on the experimental data obtained, mass balance reaction rate models characterized the nitrogen transformation and removal behavior in the WSP. Whereas model calibration was achieved using observed data from January to December 2021, model validation was achieved using observed data from January to December 2022. Ammonia volatilization, sedimentation, mineralization, nitrification, denitrification and microbial ammonia uptake were the possible transformation and removal pathways. Whereas ammonia volatilization contributed the least to the overall nitrogen removal (0.01-0.02 mg/L.d), denitrification contributed the most (2.12-14.67 mg/L.d). Low DO levels and high ammonia concentrations were responsible for low nitrification rates and high microbial ammonia uptake respectively. Comparison between experimental and modelled effluent concentrations yielded correlation coefficients (&amp;lt;i&amp;gt;r&amp;lt;/i&amp;gt;) of 0.77 and 0.69 for ammonia and organic nitrogen respectively during the calibration period. The corresponding model validation &amp;lt;i&amp;gt;r&amp;lt;/i&amp;gt; values were 0.74 and 0.93 respectively. The good agreement between the model output and observed effluent concentrations implies that nitrogen removal prediction and optimization is possible. External aeration to spike DO concentration levels is necessary to enhance the long-term nitrification rates.

Rice N-biofertilization by inoculation with an engineered photosynthetic diazotroph.

Photosynthetic diazotrophs expressing iron-only (Fe-only) nitrogenase can be developed into a promising biofertilizer, as it is independent on the molybdenum availability in the soil. However, the expression of Fe-only nitrogenase in diazotrophs is repressed by the fixed nitrogen of the soil, limiting the efficiency of nitrogen fixation in farmland with low ammonium concentrations that are inadequate for sustainable crop growth. Here, we succeeded in constitutively expressing the Fe-only nitrogenase even in the presence of ammonium by controlling the transcription of Fe-only nitrogenase gene cluster (anfHDGK) with the transcriptional activator of Mo nitrogenase (NifA*) in several different ways, indicating that the engineered NifA* strains can be used as promising chassis cells for efficient expression of different types of nitrogenases. When applied as a biofertilizer, the engineered Rhodopseudomonas palustris effectively stimulated rice growth, contributing to the reduced use of chemical fertilizer and the development of sustainable agriculture.

Rational design of cocatalyst for highly improved ammonia production from photoelectrochemical nitrate reduction

Photoelectrochemical nitrate reduction reaction (p-NO3RR) has been one of the most promising ways for ambient ammonia synthesis. However, current trials haven’t realized efficient ammonia production due to low ammonia yield. Herein, we present that silicon (Si) photocathode with CoNi as co-catalyst can achieve low onset potential, high ammonia yield, and close-to-unity selectivity in p-NO3RR. The optimal photocathode (Co0.95Ni0.05/Si) exhibits a record-high ammonia yield of 2054 µg h−1 cm−2 with an excellent Faraday efficiency (FE) of 98.6% at only −0.1 V vs. reversible hydrogen electrode (RHE), which outperforms reported photocathodes in literature. Our characterizations and calculations demonstrate that the metallic Co dominantly exists as the interior of Co0.95Ni0.05/Si that accelerates electron transfer, while Ni is introduced into Co3O4 on the surface that optimizes the adsorption behavior and improves the activity and selectivity. We believe that the findings provide insightful guidance for enhanced performance towards large-scale ammonia synthesis by photoelectrochemical nitrate reduction.

Enhancing biomass conservation and enzymatic hydrolysis of sweet sorghum bagasse by combining pretreatment with ensiling and NaOH.

Lignocellulosic pretreatment is an important stage in biomass utilization, which usually requires high input. In this study, a low-cost method using combined ensiling and NaOH was developed for lignocellulosic pretreatment. Sweet sorghum bagasse (SSB) was ensiled for 21 days and then treated with diluted NaOH (0%, 1%, and 2%) for fermentation. The results showed that the application of Lactobacillus plantarum (L) reduced fermentation losses of the silages, mainly low water-soluble carbohydrate (WSC) and ammonia nitrogen loss. Meanwhile, the application of Lactobacillus plantarum and ensiling enzyme (LE) promoted lignocellulosic degradation, as evidenced by low neutral detergent fiber (NDF), acid detergent fiber (ADF), lignin (ADL), and hemicellulosic (HC) contents. The dominant bacterial genera were Lactobacillus, uncultured_bacterium_f_Enterobacteriaceae, and Pantoea after silage, which corresponded to the higher lactic acid and acetic contents and lower pH. The reducing sugar yields of SSB increased after combined pretreatment of silage and NaOH and were further enhanced by the 2% NaOH application, as evidenced by the high reducing sugar yield and microstructure damage, especially in the L-2% NaOH group and the LE-2% NaOH group, in which the reducing sugar yields were 87.99 and 94.45%, respectively, compared with those of the no additive control (CK)-0 NaOH group. Therefore, this study provides an effective method for SSB pretreatment to enhance biomass conservation.