Ion-exchange Chromatography Research Articles

Modified turbidometric microassay for the measurement of sulfate in plasma and urine

Sulfate is the fourth most abundant anion in circulation. Despite being an essential nutrient for healthy growth and development, sulfate is not routinely measured in clinical settings. In research settings, animal studies have shown that hyposulfatemia and hypersulfaturia are associated with adverse developmental outcomes. Those findings have increased interest in measuring plasma and urine sulfate levels. In this study, we describe a modified assay to measure sulfate in low volumes of plasma and urine.•A streamlined microassay to measure sulfate levels using a microtiter plate format was developed.•To determine the robustness of the assay, this method assessed reagent stability and concentrations, as well as absorbance at different wavelengths and following a range of incubation times.•The optimized microassay was used to measure sulfate level in pig plasma and urine samples, which were compared to a validated ion chromatography method.

Efficacy of maturase K and rpL20 protein extracted from C. procera leaves on Anophelesstephensi

The present work is carried out to protein isolation, purification, and characterization from leaves, stem, and seed of C. procera and to evaluate the larvicidal potential on Anopheles stephensi. The whole protein was isolated using protein extraction buffer and precipitated by ammonium sulphate and larvicidal active protein was purified by the column chromatography. The homogeneity of larvicidal protein was confirmed by the SDS-PAGE. The identification of protein was done by the HPLC and LC-MS/ESI-MS.The crude protein from leaves showed 100% mortality of 3rd instar larvae of An. stephensi at the concentration of 5.5 mg/ml after 24 h of exposure. The crude protein from stem showed 25% mortality and no mortality observed was observed in seed protein. The leaves crude protein was further purified by ion exchange chromatography and eluted fractions were tested for larvicidal potential. The purified single protein fractions L2 and L3 from C. procera leaves showed 100% mortality at concentration of 0.06 mg/ml. The homogeneity of purified protein was confirmed by SDS-PAGE and two bands of 26 kDa and 15 kDa protein were observed. The peptide sequence “R.SQMLENSFLIENVMKR.L” was identified in the trypsin digested homogenous protein fraction L2 and “R.DRGSQKR.N” peptide sequence in L3 fraction by LC-MS/ESI-MS. The CprL2 peptide showed the sequence similarity with the protein maturase K and CprL3 peptide showed the sequence similarity with ribosomal protein L20 of C. procera. The conserved functional domain was also identified in both the CprL2 and CprL3 peptide. The identified proteins showed strong larvicidal efficacy at very low concentration. The identified proteins are novel and natural larvicidal agents against An. stephensi and hence can be used to control the malaria.

A compact and high-performance setup of capillary electrophoresis with capacitively coupled contactless conductivity detection (CE-C4D).

Capillary electrophoresis with capacitively coupled contactless conductivity detection (CE-C4D) has the advantages of high throughput (simultaneous detection of multiple ions), high separation efficiency (higher than 105 theoretical plates) and rapid analysis capability (less than 5 min for common inorganic ions). A compact CE-C4D system is ideal for water quality control and on-site analysis. It is suitable not only for common cations (e.g. Na+, K+, Li+, NH4+, Ca2+, etc.) and anions (e.g. Cl-, SO42-, BrO3-, etc.) but also for some ions (e.g. lanthanide ions, Pb2+, Cd2+, etc.) that require complex derivatization procedures to be detected by ion chromatography (IC). However, an obvious limitation of the CE-C4D method is that its sensitivity (e.g. 0.3-1 μM for common inorganic ions) is often insufficient for trace analysis (e.g. 1 ppb or 20 nM level for common inorganic ions) without preconcentration. For this technology to become a powerful and routine analytical technique, the system should be made compact while maintaining trace analysis sensitivity. In this study, we developed an all-in-one version of the CE-C4D instrument with custom-made modular components to make it a convenient, compact and high-performance system. The system was designed using direct digital synthesis (DDS) technology to generate programmable sinusoidal waveforms with any frequency for excitation, a kilovolt high-voltage power supply for capillary electrophoresis separation, and an "effective" differential C4D cell with a low-noise circuitry for high-sensitivity detection. We characterized the system with different concentrations of Cs+, and even a low concentration of 20 nM was detectable without preconcentration. Moreover, the optimized CE-C4D setup was applied to analyse mixed ions at a trace concentration of 200 nM with excellent signal-to-noise ratios. In typical applications, the limits of detection based on the 3σ criterion (without baseline filtering) were 9, 10, 24, 5, and 12 nM for K+, Cs+, Li+, Ca2+, and Mg2+, respectively, and about 7, 6, 6 and 6 nM for Br-, ClO4-, BrO3- and SO42-, respectively. Finally, the setup was also applied for the analysis of all 14 lanthanide ions and rare-earth minerals, and it showed an improvement in sensitivity by more than 25 times.

Identification and enzymatic properties of arginine decarboxylase from Aspergillus oryzae.

Aspergillus oryzae spores, when sprinkled onto steamed rice and allowed to propagate, are referred to as rice "koji." Agmatine, a natural polyamine derived from arginine through the action of arginine decarboxylase (ADC), is abundantly produced by solid state-cultivated rice koji of A. oryzae RIB40 under low pH conditions, despite the apparent absence of ADC orthologs in its genome. Mass spectrometry imaging revealed that agmatine was accumulated inside rice koji at low pH conditions, where arginine was distributed. ADC activity was predominantly observed in substrate mycelia and minimally in aerial mycelia. Natural ADC was isolated from solid state-cultivated A. oryzae rice koji containing substrate mycelia, using ammonium sulfate fractionation, ion exchange, and gel-filtration chromatography. The purified protein was subjected to sodium dodecyl sulfate poly-acrylamide gel electrophoresis (SDS-PAGE), and the detected peptide band was digested for identification by liquid chromatography-tandem mass spectrometry (LC-MS/MS). The gene AO090102000327 of strain RIB40 was identified, previously annotated as phosphatidylserine decarboxylase (PSD), and encoded a 483-amino acid peptide. Recombinant protein encoded by AO090102000327 was expressed in Escherichia coli cells cultivated at 20°C, resulting in the detection of 49 kDa and 5 kDa peptides. The protein exhibited pyruvoyl-dependent decarboxylase activity, favoring arginine over ornithine and showing no activity with phosphatidylserine. The gene was designated Ao-adc1. Ao-ADC1 expression in rice koji at pH 4-6 was confirmed through western blotting using the anti-Ao-ADC1 serum. These findings indicate that Ao-adc1 encodes arginine decarboxylase involved in agmatine production.IMPORTANCEGene AO090102000327 in A. oryzae RIB40, previously annotated as a PSD, falls into a distinct clade when examining the phylogenetic distribution of PSDs. Contrary to the initial PSD annotation, our analysis indicates that the protein encoded by AO090102000327 is expressed in the substrate mycelia area of solid state-cultivated A. oryzae rice koji and functions as an arginine decarboxylase (ADC). The clade to which Ao-ADC1 belongs includes three other Ao-ADC1 paralogs (AO090103000445, AO090701000800, and AO090701000802) that presumably encode ADC rather than PSDs. Regarding PSD, AO090012000733 and AO090005001124 were speculated to be nonmitochondrial and mitochondrial PSDs in A. oryzae RIB40, respectively.

PURIFICATION AND CHARACTERIZATION OF AMYLASE PRODUCED FROM PROBIOTIC LACTOBACILLUS PLANTARUM CS FOR INDUSTRIAL APPLICATIONS

Previous studies have demonstrated that probiotic Lactobacillus plantarum CS was able to generate an appreciable amount of extracellular amylase, hence the need to purify and characterize it. The aim of the study was to purify and characterize crude amylase from probiotic Lactobacillus plantarum CS for its industrial applications Three purification steps including ammonium sulphate precipitation, ion exchange chromatography on carboxymethyl sephadex and gel filtration on Sephadex G-75 were utilized. The homogeneity of the purified enzyme was confirmed using sodium deodocyl sulphate polyacrylamide gel electrophoresis (SDS-PAGE). The purified amylase was characterized on different parameters including substrates hydrolyses, pH and temperature activity and stability profiles. The general purification elution profile revealed two different peaks of amylase activities with outstanding one having a molecular weight of 59.7kDa. Its purification fold was 4.0 with specific activity of 16.44U/mg protein and enzyme yield of 3%.  Temperature optimal activity and stability was at 400C and 7.5 for pH activity and stability. Mangenese (Mn2+) (135.17%), tween 80 (128.30%) and some food condiments garlic, thyme, ginger, and tumeric) significantly (p> 0.05) enhanced amylase activity (≥262.40%). However, selenium (Se4+) and hydrogen peroxide (H2O2) were observed to have greatest inhibiting effect (≥30.9%) on the enzyme. Substrate hydrolysis profiles showed that the amylase hydrolyzed all the test starchy substrates with the highest hydrolytic potential on indigenous sweet potato starch (Km value/ Vmax of 1.33mg/ml/ 7.89ml). The rate of hydrolysis of other test substrates had yam> rice>cassava>corn with km values ≤ 4.0mg/ml and Vmax ≤ 25ml.  The obtained results gave an insight that amylase produced from Lactobacillus plantarum CS met with the possessed properties suitable for any industrial application especially in food

Oligonucleotide Purification by Ion Exchange Chromatography: A Step-by-Step Guide to Process Understanding, Modeling, and Simulation

Oligonucleotide Purification by Ion Exchange Chromatography: A Step-by-Step Guide to Process Understanding, Modeling, and Simulation

Alocasia macrorrhiza rhizome lectin inhibits growth of pathogenic bacteria and human lung cancer cell in vitro and Ehrlich ascites carcinoma cell in vivo in mice

Cancer and antibiotic resistance represent significant global challenges, affecting public health and healthcare systems worldwide. Lectin, a carbohydrate-binding protein, displays various biological properties, including antimicrobial and anticancer activities. This study focused on anticancer and antibacterial properties of Alocasia macrorrhiza lectin (AML). AML, with a molecular weight of 11.0 ± 1.0 kDa was purified using Ion-exchange chromatography, and the homotetrameric form was detected by gel-filtration chromatography. It agglutinates mouse erythrocytes, that was inhibited by 4-Nitrophenyl-α-D-mannopyranoside. Maximum hemagglutination activity was observed below 60°C and within a pH range from 8 to 11. Additionally, it exhibited moderate toxicity against brine shrimp nauplii with LD50 values of 321 μg/ml and showed antibacterial activity against Escherichia coli and Shigella dysenteriae. In vitro experiments demonstrated that AML suppressed the proliferation of mice Ehrlich ascites carcinoma (EAC) cells by 35% and human lung cancer (A549) cells by 40% at 512 μg/ml concentration. In vivo experiments involved intraperitoneal injection of AML in EAC-bearing mice for five consecutive days at doses of 2.5 and 5.0 mg/kg/day, and the results indicated that AML inhibited EAC cell growth by 37% and 54%, respectively. Finally, it can be concluded that AML can be used for further anticancer and antibacterial studies.

Characterisation of Adobe and Mud-Straw for the Restoration and Rehabilitation of Persian Historical Adobe Buildings.

In the restoration or rehabilitation of traditional buildings, compatible materials with known characteristics must be used. However, the existing literature lacks comprehensive studies on the characterisation of Persian mud-straw plaster, focusing primarily on Persian adobe. Moreover, previous research on Persian adobe has primarily employed XRF and XRD tests, neglecting ion chromatography, moisture sorption isotherm determination, and thermogravimetric analysis with differential scanning calorimetry. Consequently, there is a shortage of information regarding the elemental composition, mineralogical characteristics, moisture sorption behaviour, and thermal properties of Persian mud-straw plaster, as well as Persian adobe bricks. This paper aims to address this research gap by examining historical and new adobe bricks and mud-straw plaster used in Iran, utilising a comprehensive array of analytical techniques. The results from XRF analysis reveal relatively similar chemical compositions across all samples, while XRD analysis indicates predominantly similar mineral phases. Ion chromatography results demonstrate higher conductivity and chloride concentrations in the mud-straw samples than the adobe samples, with higher values for new samples than historical ones. Freshly used straw, clay, or soil may have higher chloride concentrations caused by the arid climate and soil salinisation in the area. Additionally, moisture sorption isotherm determination results show that adobe and mud-straw plaster with a higher salt load of chlorides have significantly higher moisture absorption. The increased straw quantity in the samples increases the moisture content. Furthermore, thermogravimetric analysis and differential scanning calorimetry indicate that, at low heating, adobe and mud-straw plaster lose water due to dehydration, and at high heating, they lose carbon dioxide due to decarboxylation. The comprehensive characterisation of Persian adobe and mud-straw plaster in this study fills a significant gap in the literature and offers invaluable insights for informing restoration and rehabilitation processes, ensuring the compatibility of the materials used.

Comparison of continuous flow analysis and ion chromatography for determinations of nitrate, nitrite and phosphate ions in seawater and development of related seawater certified reference materials

Comparison of continuous flow analysis and ion chromatography for determinations of nitrate, nitrite and phosphate ions in seawater and development of related seawater certified reference materials

Adjustable chromatographic performance of silica-based mixed-mode stationary phase through the control of co-grafting amounts of imidazole and C18 chain

In this paper, three imidazole- and C18- bifunctional silica stationary phases (Sil-Im-C18) were prepared by adjusting introduction interval of octadecyltrichlorosilane (ODS) and 3-imidazol-1-ylpropyl(trimethoxy)silane (TMPImS), which can be used for reversed-phase liquid chromatography (RPLC) and ion exchange chromatography (IEC) with adjustable performance. The successful preparation of Sil-Im-C18 were confirmed by the characterizations of elemental analysis, infrared spectroscopy (FTIR) and contact angle (CA). Chromatographic performance of Sil-Im-C18 were evaluated by the separation of Tanaka test mixture, alkylbenzenes, linear PAHs and a set of analytes with different properties (uracil, phenol, 1,2-dinitrobenzene and naphthalene), and compared with commonly used C18 column. It was found that the chromatographic performance of Sil-Im-C18 changed significantly with the difference in bonding amount of imidazole and C18. Sil-Im-C18 demonstrated the excellent separation performance towards polycyclic aromatic hydrocarbons (PAHs), phenylesters, phenylamines, phenols and inorganic anions, and notably, nucleobases and nucleosides can be separated using pure water as mobile phases. The van Deemter plot showed that the column efficiency of Sil-Im-C18-3 was 64,933 plate·m−1 for naphthalene, indicated that Sil-Im-C18 was reasonably chromatographic columns. The RSD values of retention time were 0.22 %-0.61 % for 10 needles alkylbenzenes injected continuously at 50 °C to investigate thermal stability and repeatability, all the fluctuations of k of naphthalene were less than 2.3 % for Sil-Im-C18-1 during flushing 24 h with the mobile phase at different pH values (pH = 3 and 8), the retention time of alkylbenzenes were almost same for Sil-Im-C18-1 at different time, the RSD values of retention time of alkylbenzenes were 0.45 %-2.28 % for two batches Sil-Im-C18-1, revealing the excellent repeatability, thermal stability, durability and reproducibility of Sil-Im-C18, and implying a commercial prospect.

Faecalibacterium prausnitzii Supplementation Prevents Intestinal Barrier Injury and Gut Microflora Dysbiosis Induced by Sleep Deprivation.

Sleep deprivation (SD) leads to impaired intestinal barrier function and intestinal flora disorder, especially a reduction in the abundance of the next generation of probiotic Faecalibacterium prausnitzii (F. prausnitzii). However, it remains largely unclear whether F. prausnitzii can ameliorate SD-induced intestinal barrier damage. A 72 h SD mouse model was used in this research, with or without the addition of F. prausnitzii. The findings indicated that pre-colonization with F. prausnitzii could protect against tissue damage from SD, enhance goblet cell count and MUC2 levels in the colon, boost tight-junction protein expression, decrease macrophage infiltration, suppress pro-inflammatory cytokine expression, and reduce apoptosis. We found that the presence of F. prausnitzii helped to balance the gut microbiota in SD mice by reducing harmful bacteria like Klebsiella and Staphylococcus, while increasing beneficial bacteria such as Akkermansia. Ion chromatography analysis revealed that F. prausnitzii pretreatment increased the fecal butyrate level in SD mice. Overall, these results suggested that incorporating F. prausnitzii could help reduce gut damage caused by SD, potentially by enhancing the intestinal barrier and balancing gut microflora. This provides a foundation for utilizing probiotics to protect against intestinal illnesses.

Comparison of three methods for collecting interstitial fluid from subcutaneous tissue in mini pigs

Interstitial fluid, owing to its similarity to blood components and higher sensitivity and specificity, finds widespread application in disease diagnosis and tumor marker detection. However, collecting interstitial fluid, particularly from the deep subcutaneous connective tissue, remains challenging.•This study aimed to compare three different collection methods - push-pull perfusion, multi-filament nylon thread implantation, and tissue centrifugation - for collecting interstitial fluid from the subcutaneous connective tissue layer of mini-pigs. High-performance ion chromatography was employed to analyze the conventional cation components in the samples and compare ion composition analysis between the different methods.•Results indicated that while the distribution of conventional cations in the interstitial fluid collected by the three methods was generally consistent, there were slight variations in the detection rates and concentrations of different ions. Hence, suitable collection methods should be selected based on the ions or collection sites of interest.

Simultaneous determination of eight organic amines in desulfurization solution by ion chromatography

The applications of organic-amine desulfurization have steadily increased owing to its high efficiency, low cost, and low energy consumption. Different proportions of organic amines exert different effects on sulfur dioxide removal. Therefore, the accurate determination of different organic amines in the desulfurization solution is of great importance. The ion-chromatographic method for the detection of organic amines does not require a derivatization step, has simple pretreatment procedures, and allows for the simultaneous determination of many types of organic amines. In this study, a method based on ion chromatography was developed for the simultaneous determination of ethanolamine (MEA), diethylethanolamine (DEEA), n-methyldiethanolamine (MDEA), 2-amino-2-methyl-1-propanol (AMP), hydroxyethylethylenediamine (AEEA), piperazine (PZ), n-hydroxyethylpiperazine (HEPZ), and diethylenetriamine (DETA). The separation efficiency of the eight organic amines in different types of columns, leaching solutions, and column temperatures were compared. The determination was performed using an IonPac CS17 column with column temperature of 35 ℃ and gradient leaching with methyl sulfonic acid (MSA) solution via the inhibition conductance method. Samples of the desulfurization solution were analyzed using ultrapure water filtered through a 0.22 μm nylon microporous filter membrane and an OnGuard Ⅱ RP column; thus, the pretreatment steps are simple. The eight organic amines showed a good linear relationship within a certain concentration range, and the coefficient of determinations (R2) were greater than 0.998. The limits of detection (LODs) and quantification (LOQs) were determined from the mass concentrations of the organic amines corresponding to signal-to-noise ratios (S/N) of 3 and 10, respectively. LODs of 0.02-0.08 mg/L and LOQs of 0.07-0.27 mg/L were determined from a 1.0 μL sample injection. The actual recoveries ranged from 93.0% to 111%, and the relative standard deviations (RSDs, n=5) ranged from 0.31% to 1.2%. The results indicated that the proposed method has good accuracy and precision; thus, it is suitable for the determination of various organic amines in desulfurization solution.

Simultaneous detection of lower aliphatic amines and conventional cations in atmospheric PM2.5 particulates by ion chromatography

Many amine pollutants exist in the atmosphere. Lower aliphatic amines promote the formation and growth of particles into PM2.5, which damages the heart, lungs, and kidneys of the human body. PM2.5, a common atmospheric particulate pollutant with complex compositions, is the main cause of haze weather. Therefore, measuring the contents of lower aliphatic amines and cations in PM2.5 is of great significance for monitoring environmental air quality and protecting human health. This study established a suppressed ion-chromatographic method with conductivity for the simultaneous detection of four lower aliphatic amines (methylamine, dimethylamine, trimethylamine, and ethylamine) and five cations (Na+, N[Formula: see text], and Ca2+ showed high concentrations. The contents of the four lower aliphatic amines were low; however, the ethylamine content in some samples was high. The results indicate that the proposed method meets the quantification requirements for cations and lower aliphatic amines in PM2.5, with simple processing, high sensitivity, and good accuracy. It can quickly and accurately detect a large number of samples and be used to assess the pollution of small particles in the air as well as trace pollution sources to protect human health.

Study on the transient expression of infectious bronchitis virus spike protein in Nicotiana benthamiana leaves

Infectious bronchitis virus (IBV) is considered as one of the main causes of economic loss in chicken farms worldwide, especially in poultry producing nations. This virus, a member of the Coronaviridae family, is classified into different genotypes based on its surface spike glycoproteins which also play important roles in cell attachment and immune response. Due to continual genetic mutation of IBV, attenuated and inactivated vaccines show decreased effectiveness or lack of cross – protection; thus ongoing studies focus on the development of new generation vaccines to prevent new IBV outbreaks. This paper describes our study on expression of the antigenic region in S1 subunit of the spike in Nicotiana benthamiana. Two expression vectors carrying either S1 or receptor binding domain (RBD) coding gene (pCB301-S1 and pCB301-RBD) were constructed and transformed into tobacco leaves by agroinfiltration method. The RBD showed a clearly higher level of expression compared to the whole S1. Purification of RBD by immobilized metal ion chromatography and size exclusion chromatography represented a mixture of monomer, dimer and trimer glycoprotein with expected sizes in Western blot. In summary, this study demonstrated our primary success in establishing an expression model that could be used to investigate plant-based IBV recombinant vaccine.

Influences of alumina type and sulfate content on hydration and physicochemical changes in Portland–limestone cement

This study explored the influence of alumina type and gypsum content on the hydration, mechanical properties, and chemical changes of Portland–limestone cement (PLC) using isothermal calorimetry, inductively coupled plasma-optical emission spectroscopy (ICP-OES), ionic chromatography (IC), compressive strength testing, X-ray diffraction (XRD), 27Al magic angle spinning nuclear magnetic resonance (27Al MAS NMR) spectroscopy, and mercury intrusion porosimetry (MIP) testing. The addition of alumina shortened the induction period, accelerated the acceleration period, and increased the mechanical strength of the PLC pastes with 3 and 7 wt% gypsum. The acceleration effect and strength enhancement were not distinct in the PLC pastes with less gypsum (0.1 wt%). The addition of γ-alumina led to the greatest accelerating effect and strength improvement in the PLC pastes with 3 and 7 wt% gypsum, and the compressive strength achieved was comparable to those of pure Ordinary Portland cement (OPC) pastes without limestone. The addition of γ-alumina induced the rapid dissolution of gypsum and consumption of sulfate ions. The chemical change affected by the addition of alumina varied greatly depending on the gypsum content, and trends in AFt and AFm formation in the PLC pastes with different gypsum contents were confirmed. Finally, pore size refinement was observed through the addition of alumina to PLC pastes with 3 and 7 wt% gypsum.

Purification, and characterization of a new pro-coagulant protein from Iranian Echis carinatus venom

This work aimed to purify the proteins that cause blood coagulation in the venom of the Iranian Echis carinatus snake species in a comprehensive manner. Gel filtration chromatography (GFC), Ion exchange chromatography (IEC), and Size Exclusion High-Performance Liquid Chromatography (SEC-HPLC) were utilized in the purification of the coagulation factors. The prothrombin clotting time (PRCT) and SDS-PAGE electrophoresis were performed to confirm the coagulative fractions. The fraction with the shortest coagulation time was selected. The components of this designated fraction were identified through matrix-assisted laser desorption/ionization mass spectrometry (MALDI-TOF) following thorough purification. Circular dichroism (CD) was employed to determine the second structure of the coagulation factor. The crude venom (CV) was analyzed and had a total protein concentration of 97%.Furthermore, the PRCT of the crude venom solution at a concentration of 1 mg/ml was determined to be 24.19 ± 1.05 s. The dosage administered was found to be a factor in the venom's capacity to induce hemolysis. According to CD analysis, the protein under investigation had a helical structure of 16.7%, a beta structure of 41%, and a turn structure of 9.8%. CHNS proved that the purified coagulant protein had a Carbon content of 77.82%, 5.66% Hydrogen, 3.19% Nitrogen, and 0.49% Sulphur. In the present investigation, a particular type of snake venom metalloproteinase (SVMP) has undergone the process of purification and characterization and has been designated as EC-124. This purified fraction shows significant efficacy as a procoagulant. Our findings have shown that this compound has a function similar to factor X and most likely it can cause blood coagulation by activating factor II (FII).

Determination of phosphorus in commercially available milk using ion chromatography with perchloric acid deproteinization.

Suppressed ion chromatography with perchloric acid deproteinization was developed for the determination of phosphorus in commercially available milk. Although the perchloric acid deproteinization method is widely used in the medical field, it sees limited application in the food industry. Herein, the concentration of perchloric acid and hydrolysis conditions were examined, specifically regarding perchloric acid deproteinization, which was used as a deproteinization method in this study. The calibration curve constructed from the peak area of orthophosphoric acid (monohydrogen phosphate ion: HPO42-) was linear, with a correlation coefficient of 0.999. The relative standard deviation of the peak area of 50mg/L of HPO42- from six replicates was 0.35%. The detection and quantitative limits of HPO42-, calculated from its signal-to-noise ratio were 0.033mg/L and 0.100mg/L, respectively. The proposed method was applied to the analysis of phosphorus in commercially available milk. Perchloric acid deproteinization has proved to be useful in the food industry.

Design and optimization of a continuous purification process using ion-exchange periodic counter-current chromatography for a low-titer enzyme

AbstractA continuous purification process can be beneficial to the purification of biologics due to its higher productivity and efficiency than a conventional batch purification process. However, regulatory issues and lack of established cases render deployment of the continuous process difficult in industrial settings. Here we report a case study for design and optimization of an advanced continuous process for purifying a low-titer enzyme as a model biologic. To convert a conventional batch process to an advanced continuous one in purification of biologics, conventional unit operations (UOs), including ultrafiltration/diafiltration (UF/DF) and batch chromatography, were replaced by advanced ones such as in-line dilution conditioning (IDC) and periodic counter-current chromatography (PCC). The UF/DF UO was changed to IDC UO to adjust pH and conductivity. The mixing ratio of the sample and the conditioning buffer in IDC was determined by experiments with three buffers. PCC was optimized with two variables, column height and sample loading residence time, as the delta pressure in the columns was less than 1.0 bar. A graph indicating the operating area was plotted to efficiently control the PCC. Although the sample volume increased in IDC, PCC had a complementary advantage in that purification was performed faster than batch chromatography. We observed at least 25% increase in economic advantage when the advanced continuous process was applied to purify a low-titer enzyme. We propose not only a continuous process with the substitution of UF/DF and batch chromatography with IDC and PCC but also a method to optimize PCC by plotting operating areas.

Purification, functional characterization and enhanced production of serratiopeptidase from Serratia marcescens MES-4: An endophyte isolated from Morus rubra

Serratiopeptidase, a proteolytic enzyme serves as an important anti-inflammatory and analgesic medication. Present study reports the production and purification of extracellular serratiopeptidase from an endophyte, Serratia marcescens MES-4, isolated from Morus rubra. Purification of the enzyme by Ion exchange chromatography led to the specific activity of 13,030 U/mg protein of serratiopeptidase, showcasing about 3.1 fold enhanced activity. The catalytic domain of the purified serratiopeptidase, composed of Zn coordinated with three histidine residues (His 209, His 213, and His 219), along with glutamate (Glu 210) and tyrosine (Tyr 249). The molecular mass, as determined by SDS-PAGE was ∼51 kDa. The purified serratiopeptidase displayed optimal activity at pH 9.0, temperature 50°C. Kinetic studies revealed Vmax and Km values of 33,333 U/mL and 1.66 mg/mL, respectively. Further, optimized conditions for the production of serratiopeptidase by Taguchi design led to the productivity of 87 U/mL/h with 87.9 fold enhanced production as compared to the previous conditions.