Ileal Digestible AA Research Articles

Supplementation of broiler diets with high levels of microbial protease and phytase enables partial replacement of commercial soybean meal with raw, full-fat soybean.

A 3×3+1 factorial, involving three levels of protease (0, 15,000 or 30,000 PROT/kg) and three levels of phytase (1,000, 2,000 or 3,000 FYT/kg), was used to evaluate the effect of replacing commercial soybean meal (SBM) with raw, full-fat soybean (RFSB) at 75g/kg of diet for broilers. A control diet was used for comparison. Each treatment was replicated six times, with nine birds per replicate. The concentration of trypsin inhibitors (TIs) in the test diets was approximately 10,193.4TIU/kg. Regardless of enzyme supplementation, feed intake (FI) and body weight gain (BWG) of birds in the control group were superior to those on the test diets. Birds that received the protease-free test diets had reduced FI and BWG, but when supplemented with protease, were similar to the control diet in BWG, FI (except 0-35days) and feed conversion ratio (FCR). When the test diet was supplemented with elevated levels (extradose) of protease and phytase, the BWG was improved during 0-10days (p=.05) and 0-24days (p<.01). Regardless of protease supplementation, the weight of thighs was lower for birds fed the test diets. Birds that received the control diet had smaller weight of pancreas. Increasing the level of phytase supplementation reduced (p<.05) the weight of the pancreas. The apparent ileal digestibility (AID) of CP and AA was higher in birds on the control diets, but this was also improved in test diets by protease supplementation. The activities of trypsin (7%), general proteolytic (11%) and lipase (12%) were slightly increased because of protease supplementation. Mucosal depth and apparent villus surface areas were increased by about 2.9% and 20%, respectively, due to supplementation of elevated level of phytase. It can be concluded that RFSB could partially replace SBM in broiler diets, provided the diets are supplemented with elevated levels of protease and phytase.

Chemical composition, energy, and amino acid digestibility in 7 cottonseed co-products fed to growing pigs.

The objective of this study was to determine the chemical composition, DE and ME contents, and apparent ileal digestibility (AID) and standardized ileal digestibility (SID) of AA in 7 cottonseed co-products fed to growing pigs. The 7 cottonseed co-products were: cottonseed meals (solvent extracted) with CP level of 46%, 50%, and 55% (46CSM, 50CSM, and 55CSM), cottonseed protein with CP level of 50% and 55% (50CSP and 55CSP), fermented cottonseed meal (CSMF), and expelled cottonseed meal (CSME). The DE and ME contents of the 7 test ingredients were measured using 48 crossbreed barrows (BW: 44.1 ± 4.2 kg) and 8 diets (including a corn-soybean meal basal diet) in a completely randomized design. The AID and SID of AA of the 7 test ingredients were determined using 7 crossbreed barrows (initial BW: 67.4 ± 8.5 kg) in a 6 × 8 Youden square design with 6 periods and 8 diets (including one N-free diet). The DE and ME values of the 7 cottonseed co-products varied from 12.72 to 15.63 MJ/kg and 12.24 to 14.83 MJ/kg, respectively. Among the 7 cottonseed co-products, 55CSP and CSME had the greatest (P < 0.05) ME and DE values compared to the other cottonseed co-products. In addition, 55CSP had the greatest (P < 0.05) AID and SID of all the AA tested except for Gly and Pro. In contrast, 46CSM or 55CSM had the lowest (P < 0.05) AID and SID of all the AA tested except for Gly and Pro. The 55CSP also had the greatest (P < 0.05) concentrations of standardized ileal digestible CP and all the AA tested except for Gly and Pro. In conclusion, the chemical composition, energy, and AA digestibility of cottonseed co-products with different processing techniques varied widely. Based on the energy and AA digestibility, cottonseed protein with CP level of 55% is a better dietary ingredient for growing pigs compared with the other cottonseed co-products.

High-protein distillers dried grains with solubles produced using a novel front-end-back-end fractionation technology has greater nutritional value than conventional distillers dried grains with solubles when fed to growing pigs.

Two experiments were conducted to determine the standardized ileal digestibility (SID) of CP and AA, apparent total tract digestibility (ATTD) of GE, and DE and ME in conventional distillers dried grains with solubles (DDGS-CV) and in a novel source of high-protein distillers dried grains with solubles (DDGS-HP) produced by Lincolnway Energy (Nevada, IA). In Exp. 1, 18 barrows (initial BW: 72.47 ± 9.16 kg) that had a T-cannula installed in the distal ileum were allotted to a completely randomized design with 3 diets and 6 replicate pigs per diet. A nitrogen-free diet and 2 diets that contained cornstarch and DDGS-CV or DDGS-HPLincolnway as the sole source of CP and AA were formulated. Diets were fed to pigs for 7 d, and ileal digesta were collected on days 6 and 7 of each period. The SID for Leu, Lys, Met, Phe, and Glu was greater (P < 0.05) in DDGS-HPLincolnway than in DDGS-CV, and the SID of Ile, Val, and total indispensable AA, as well as the SID of Tyr, tended to be greater (P < 0.10) in DDGS-HPLincolnway than in DDGS-CV. No difference between DDGS-CV and DDGS-HPLincolnway was observed for the SID of CP and all other AA. In Exp. 2, 24 barrows (initial BW: 52.80 ± 2.55 kg) were housed individually in metabolism crates and randomly allotted to 1 of 3 diets. A corn-based basal diet (97.25% corn) and 2 diets that contained corn and DDGS-CV or corn and DDGS-HPLincolnway were formulated. Each diet was fed to 8 pigs. Feces and urine were collected using the marker to marker approach with 7-d adaptation and 5-d collection periods. The DE and ME in DDGS-CV and DDGS-HPLincolnway were calculated using the difference procedure. The DE and ME in DDGS-HPLincolnway on an as-fed basis were greater (P < 0.05) than in corn and DDGS-CV, but the ATTD of GE in DDGS-HPLincolnway and DDGS-CV was less (P < 0.01) than in corn. In conclusion, the SID of some AA and the DE and ME in DDGS-HPLincolnway were greater than in DDGS-CV.

Concentration of digestible and metabolizable energy, standardized ileal digestibility, and growth performance of pigs fed diets containing sorghum produced in the United States or corn produced in China.

The DE and ME content (Exp. 1) as well as the apparent ileal digestibility (AID) and standardized ileal digestibility (SID) of essential AA (EAA; Exp. 2) were compared between Chinese corn and U.S. sorghum. The effects of U.S. sorghum as a potential substitute for Chinese corn on growth performance of 114 weaned pigs (8.8 ± 1.0 kg BW; Exp. 3) and 60 growing pigs (23.4 ± 1.6 kg BW; Exp. 4) were evaluated, and the effect of protease supplementation on N utilization was determined in sorghum-based diets fed to growing pigs (Exp. 4). In Exp. 1, there was no difference in DE and ME content between corn and sorghum. In Exp. 2, the AID and SID of most EAA and the concentrations of standardized ileal digestible Lys, Met, Thr, and His were less in sorghum than in corn ( < 0.05). In Exp. 3, there was no difference in ADG and ADFI among treatments during the experimental period. The G:F and apparent total tract digestibility (ATTD) of CP was decreased for pigs fed diets with sorghum in the first 2 wk ( < 0.05) and for pigs fed diets containing 60% sorghum in the following 2 wk ( < 0.05). The fecal score for pigs fed diets with sorghum, regardless of the substitute level, was less ( < 0.05) or tended to be less ( = 0.086) than that for pigs fed diets containing 60% corn. In Exp. 4, no differences were observed in ADG and ADFI overall among pigs fed diets based on corn and soybean meal (CSBM) or sorghum and soybean meal (SSBM). Pigs fed CSBM or SSBM with protease supplementation had greater ( < 0.05) or tended to have greater ( = 0.062) G:F than pigs fed SSBM. Compared with CSBM, SSBM increased fecal N excretion by more than 25% and decreased the ATTD of CP by more than 7% during the whole experiment ( < 0.05). Protease supplementation reduced fecal N excretion by more than 12% and increased ATTD of CP by more than 6% ( < 0.05). In conclusion, based on optimal G:F and CP digestibility, diets for weaned pigs should contain less than 20% sorghum during the first 2 wk and no more than 40% during the subsequent 2 wk after weaning. Sorghum used as an alternative energy source for corn in diets fed to growing pigs decreases CP utilization by increasing manure N output, which might be partially offset by protease supplementation.

Investigating the effect of dietary calcium levels on ileal endogenous amino acid losses and standardized ileal amino acid digestibility in broilers and laying hens.

Two studies were conducted to evaluate the effect of dietary Ca levels (low, 1% and high, 3%) on ileal endogenous amino acid losses (IEAAL) and standardized ileal amino acid digestibility (SIAAD) in broilers (BR) and laying hens (LH) fed nitrogen-free diets (NFD) and distiller's dried grain with solubles (DDGS)-based diets. A total of 384 male Cobb 500 BR and 288 LH were used in a completely randomized design (CRD) with 16 (BR) or 12 (LH) replicate cages with 6 birds/replicate. IEAAL and apparent ileal digestibility (AID) of AA were analyzed using the GLM procedure of SAS appropriate for a CRD while SIAAD values were analyzed using the GLM procedure of SAS appropriate for a 2×2 factorial arrangement of treatments. For BR, IEAAL and N losses (mg/kg of dry matter intake, DMI) were higher (P <0.05) when NFD with high Ca level was fed (total AA was 39%, N was 35% higher). For most of the AA, AID was higher (P <0.05) in BR fed DDGS-based diet with high Ca level. High dietary Ca resulted in higher (P <0.05) SIAAD for all the AA except for Arg, Lys, Met, Cys, and Tyr. For LH, AID of AA was higher (P <0.05) for the DDGS diet with high Ca level in 13 of the 18 AA evaluated. There was interaction (P <0.05) between diet Ca level and correction method on LH SIAAD values for Thr, Asp, Gly, and Ser. The SIAAD values for 8 AA were higher (P <0.05) in birds on high Ca DDGS diet. Correction with low Ca NFD resulted in higher (P <0.05) SIAAD values for all the AA. Result from this study showed that high Ca increased total IEAAL in BR by 39% but decreased same by 27% in LH. Finally, SIAAD values were increased in BR fed high Ca DDGS-based diet while SIAAD value in LH was lower when correction was done using values from high Ca-NFD fed birds.

Apparent and standardized ileal nutrient digestibility of broiler diets containing varying levels of raw full-fat soybean and microbial protease

BackgroundAlthough soybean meal (SBM) is excellent source of protein in diets for poultry, it is sometimes inaccessible, costly and fluctuates in supply. The SBM can partially be replaced by full-fat SBM, but the meals prepared from raw full-fat soybean contain antinutritional factors. To avoid the risk of antinutritional factors, heat treatment is always advisable, but either excessive or under heating the soybean could negatively affect the quality. However, the potential for further improvement of SBM by supplementing with microbial enzymes has been suggested by many researchers. The objective of this study was to evaluate the performance and ileal nutrient digestibility of birds fed on diets containing raw soybeans and supplemented with microbial protease.MethodsA 3 × 2 factorial, involving 3 levels of raw full-fat soybean (RFFS; 0, 45 or 75 g/kg of diet) and 2 levels of protease (0 or 15,000 PROT/kg) was used. The birds were raised in a climate-controlled room. A nitrogen-free diet was also offered to a reference group from day 19 to 24 to determine protein and amino acid flow at the terminal ileum and calculate the standardized ileal digestibility of nutrients. On days 10, 24 and 35, body weight and feed leftover were recorded to calculate the body weight gain (BWG), feed intake (FI) and feed conversion ratio (FCR). On day 24, samples of ileal digesta were collected at least from two birds per replicate.ResultsWhen RFFS was increased from 0 to 75 g/kg of diet, the content of trypsin inhibitors was increased from 1747 to 10,193 trypsin inhibitors unit (TIU)/g of diets, and feed consumption of birds was also reduced (P < 0.05). Increasing RFFS level reduced the BWG from hatch 0 to 10 d (P < 0.01) and hatch to 24 d (P < 0.05). The BWG of birds from hatch to 35 was not significantly (P = 0.07) affected.Feed intake was also reduced (P < 0.05) during 0 to 35 d. However, protease supplementation improved (P < 0.05) the BWG and FCR during 0 to 24 d. Rising levels of RFFS increased the weight of pancreas (P < 0.001) and small intestine (P < 0.001) at day 24. Except for methionine, apparent and the corresponding standardized ileal digestibility of CP and AA were reduced (P < 0.01) by increasing levels of RFFS in diets.ConclusionThis study showed that some commercial SBM could be replaced by RFFS in broiler diets, without markedly compromising productivity. The AID and SID of CP and lysine were slightly improved by dietary supplementation of microbial protease.

Amino acid and phosphorus digestibility of fermented corn-soybean meal mixed feed with Bacillus subtilis and Enterococcus faecium fed to pigs1

In the present study, a 2-stage solid-state fermentation process using followed by was performed with the purpose of improving the nutritional quality of corn and soybean meal (SBM) mixed feed (MF). The matrix of native MF and fermented MF (FMF) was analyzed using scanning electron microscopy to determine external structures after solid-state fermentation. Results of the present study indicated that the FMF had a greater concentration of CP and total P compared with the unfermented feed, whereas the contents of β-conglycinin, glycinin, phytate P, raffinose, stachyose, and NDF in FMF declined by 77.6, 86.7, 41.2, 47.2, 36.6, and 38.9%, respectively. The content of trichloroacetic acid-soluble protein, particularly those of small peptides and free AA, increased more than 3 times after fermentation. Scanning electron microscopy revealed that irregular shapes and a lot of porous structures were observed in the SBM of FMF, the cell wall of corn in FMF was destroyed, and the number of starch granules was decreased after 2-stage fermentation. Two animal experiments were conducted to evaluate the digestibility of CP and P in FMF when fed to pigs. In Exp. 1, 6 barrows (15.20 ± 1.27 kg initial BW) fitted with a T-cannula in the distal ileum were allotted to a replicated 3 × 3 Latin square with 3 diets and 3 periods per square. Two diets containing unfermented MF or FMF as the only source of protein and a N-free diet were formulated. Results indicated that the apparent ileal digestibility (AID) of total AA and Lys in FMF (74.98 and 75.34%) were greater ( < 0.05) than in untreated MF (69.66 and 68.56%). The standard ileal digestibility (SID) of Lys in FMF (82.17%) was also greater ( < 0.05) than in MF (75.91%). In Exp. 2, 16 barrows (17.57 ± 1.08 kg initial BW) were allotted to 2 diets formulated to contain MF or FMF as the sole source of P to determine the digestibility of P. The apparent total tract digestibility and standardized total tract digestibility of P in FMF were 58.14 and 64.72%, respectively. These values were greater ( < 0.01) than in untreated MF (37.11 and 44.89%, respectively). Our results indicate that a solid-state fermentation process using followed by offers an effective approach to improving the quality of corn and SBM MF.

Examining the effect of dietary electrolyte balance, energy source, and length of feeding of nitrogen-free diets on ileal endogenous amino acid losses in broilers

The effect of dietary electrolyte balance (DEB), energy source (ES), and length of feeding of nitrogen-free diet (NFD) on ileal endogenous amino acid (EAA) loss in mg/kg dry matter intake (DMI) was evaluated in broiler chickens. In Experiment 1, 720 chickens consisting of 15 replicate cages with 6 chickens/replicate were used. Treatments were arranged in a 2 × 2 × 2 factorial and consisted of 4 NFD with 2 levels (low or high) of DEB and 2 ES [corn starch (CS) or dextrose (DX)], and 2 sampling time-points (diets were fed for either 72 h (d 16 to 19) or 120 h (d 16 to 21). Experiment 2 used 360 chickens in a 2 × 2 factorial arrangement of treatments with 2 levels (low or high) of DEB and 2 ES (CS or DX). Diets were fed for 72 h (d 18 to 21). All birds had access to feed and water on an ad libitum basis. Data were analyzed using the GLM procedure of SAS appropriate for a completely randomized design for a factorial arrangement of treatments. For Experiment 1, there were interactions (P < 0.05) between the 3 main factors for nitrogen and all the AA except Trp. Broilers that were fed DX-based NFD with high DEB for 72 h had the highest (P < 0.05) EAA losses. In Experiment 2, there was no interaction between DEB and ES except for His and Lys. When ileal EAA losses from birds fed the low DEB, CS-based NFD were used to standardize apparent ileal digestibility values from a previous study, there was no effect of length of feeding on standardized ileal AA digestibility values. In conclusion, DX-based NFD with high DEB increased endogenous AA loses. Despite differences in ileal EAA losses from CS-based NFD, standardized ileal AA digestibility values were not influenced by the length of feeding of NFD. Based on the results from these studies, NFD could be fed for 72 h without influencing SIAAD values.

Energy and nutrient utilisation of maize-soy diet supplemented with a xylanase-β-glucanase complex from Talaromyces versatilis

A study was conducted to evaluate the effects of supplementing maize-soy diets with a commercial xylanase-β-glucanase complex [β-xylanase, 1,3(4)-β-glucanase, and 1,4-β-glucanase] on growth performance, energy and amino acid utilisation of broiler chickens. A total of 2016 Cobb×Cobb 500 1-d-old male chicks were distributed into 9 treatments with 8 replicates of 28 birds each in a completely randomised design. Treatments consisted of a Control diet formulated with AME and nutrients as commercially used by the Brazilian integrators without enzyme supplementation as well as 8 other diets having reductions in formulated AME (−0.33 and −0.50MJ/kg) and digestible amino acids (dig. AA; −3 and −6%). These diets were supplemented or not with 50mg/kg of the enzyme complex. Ileal contents were collected at 21 and 42 d to determine ileal digestible energy (IDE), dry matter and AA digestibilities. Broilers fed diets with AME and dig. AA reductions without enzyme had higher FCR and these diets had lower IDE (P<0.05). The supplemental enzyme increased total AA digestibility at 21 d; however, no effects were observed at 42 d. The highest total AA digestibility (P<0.05) was observed when broilers were fed the Control diet whereas the supplemental enzyme compensated the nutrient and energy reductions. The addition of 50mg/kg of the xylanase-β-glucanase complex in maize-soy diets led to improvements on FCR, IDE and ileal digestibility of dry matter in broilers at 21 and 42 d. The highest energy improvement provided by the supplemental enzyme was observed at 21 d on broilers fed diets with −0.50MJ/kg AME and −6% dig. AA, being 5.8% higher when compared to those fed the analogous diet without enzyme.

Standardized ileal digestible amino acids and digestible energy contents in high-protein distiller's dried grains with solubles fed to growing pigs1

Chemical composition and, therefore, potential nutritive value of corn distiller's dried grains with solubles (DDGS) is constantly evolving as the ethanol industry innovates processing techniques. We determined standardized ileal digestibility (SID) of AA (Exp. 1) and DE (Exp. 2) contents in high-protein (HP; >40% on a DM basis) DDGS samples. Two HP DDGS (HP-A and HP-B) samples and 1 conventional DDGS (CON) sample were selected for this study. Three semipurified corn starch-based diets (minimum 18% CP, as-fed basis) were formulated with DDGS as the sole source of AA. A fourth, N-free diet was prepared to estimate basal ileal endogenous AA losses. The corn starch:sucrose:oil ratio was kept constant across diets to allow calculation of DE content in DDGS by the difference method. In Exp. 1, 8 ileal-cannulated barrows (23.9 kg initial BW) were used in a replicated 4 × 4 Latin square design ( = 8). Pigs were fed at 2.8 × maintenance energy requirement. In each period, pigs were adjusted to diets for 5 d followed by a 2 d of 8 h each grab continuous ileal digesta collection. In Exp. 2, 9 barrows (24.9 kg BW) were assigned to the 4 diets in a repeated 9 × 4 Youden square design to give 9 replicates per diet. In each period, pigs were adjusted to diets for 7 d followed by 5 d of fecal grab sample collection. The analyzed CP was 30.1, 42.3, and 43.1% (on a DM basis) in the CON, HP-A, and HP-B samples, respectively; the corresponding values for GE were 5,067, 5,425, and 5,407 kcal/kg DM, respectively. The concentrations of fat and NDF were comparable among the DDGS samples. Except for Arg and Val, the SID values for indispensable AA were not different ( > 0.05) among the 3 DDGS samples. However, HP samples had higher ( < 0.05) SID values for indispensable AA and CP compared with the CON sample. The SID of Lys content was 4.9, 6.1, and 7.4 g/kg DM for the CON, HP-A, and HP-B, respectively; the corresponding values for Met and Thr were 4.6, 6.8, and 7.4 g/kg DM, respectively, and 6.8, 9.5, and 10.7 g/kg DM, respectively. The DE content in HP samples was greater ( < 0.01) than in the CON (3,614, 4,494, and 4,555 kcal/kg DM for the CON, HP-A, and HP-B, respectively). In conclusion, HP DDGS had higher SID content of AA and DE compared with the CON.

426 Ileal amino acid digestibility values vary depending on the exogenous indigestible indexes in pigs fed a soybean meal-based diet

The objective was to test a hypothesis that ileal AA digestibility values may vary depending on the indigestible index sources including chromium oxide, titanium dioxide, and Celite. Eight barrows with an initial BW of 58.1 kg (SD = 4.3) fitted with a T-cannula in the distal ileum were randomly allotted to a 2-period crossover design with 2 diets and 8 pigs in each period. A soybean meal (SBM)-based diet and an N-free diet were prepared. Both experimental diets contained 0.4% chromium oxide, 0.4% titanium dioxide, and 0.4% Celite as indigestible indexes. A washout diet with no index was provided ad libitum to the pigs for 7 d before each 9-d experimental period. The diets were provided at daily levels of 3 times the estimated maintenance requirement for energy. Equal meals were provided at 0800 and 2000. Ileal digesta were collected from 0800 to 1600 on each day. In the same experiment, we found that the minimum adaptation period before ileal digesta collection to have constant index concentrations was 3 to 4 d. Therefore, the digestibility and endogenous loss of AA data were pooled from d 5 to 9 to investigate the influence of indigestible index on AA digestibility and endogenous losses. The ileal digesta are often collected during d 6 and 7 in many experiments, and thus, the data from d 6 and 7 were also pooled for testing index effects on AA digestibility and endogenous losses. Based on the pooled data from d 5 to 9, the apparent ileal digestibility (AID) and the standardized ileal digestibility (SID) of all AA except Tyr calculated using Cr or Ti as an index were greater (P < 0.05) than the digestibility values calculated using AIA. During d 5 to 9, the basal endogenous losses (BEL) of Arg, His, Ile, Leu, Lys, Thr, Trp, Val, Ala, Asp, Glu, Gly, Pro, and Ser calculated using Cr as an index were less (P < 0.05) than the BEL values calculated using Ti but greater (P < 0.05) than the BEL values calculated using AIA. When the data from d 6 and 7 were pooled, the AID, SID, and BEL of AA changes by indigestible indexes had the same pattern as the data from d 5 and 9. Overall, AA digestibility calculated using Cr or Ti was greater than that calculated using AIA.

Comparison of amino acid digestibility in full-fat soybean, two soybean meals, and peanut flour between broiler chickens and growing pigs.

The aim of this study was to determine the apparent ileal digestibility (AID) and the standardized ileal digestibility (SID) of CP and AA in full-fat soybean (FFSB), solvent-extracted soybean meal containing 430 g/kg CP (SBM-43), solvent-extracted soybean meal containing 470 g/kg CP (SBM-47), and peanut flour (PNF) fed to broiler chickens and pigs and to compare the digestibility of CP and AA between broiler chickens and pigs. Four diets were prepared to contain FFSB, SBM-43, SBM-47, and PNF as the sole source of N. A N-free diet was formulated to estimate the basal ileal endogenous losses of CP and AA for broiler chickens and pigs. In Exp. 1, a total of four hundred sixteen 21-d-old male broiler chickens (922.1 ± 79.9 g initial BW) were assigned to 5 experimental diets in a randomized complete block design with BW as a blocking factor. After 5 d of adaptation, ileal digesta samples were collected after birds were euthanized by CO asphyxiation. In Exp. 2, twenty barrows (62.0 ± 6.9 kg initial BW) surgically fitted with T-cannulas at the distal ileum were allotted to 5 experimental diets with 2 consecutive 7-d experimental periods. After 5 d of adaptation, ileal digesta samples were collected at d 6 and 7. For statistical analysis, treatments were considered a 2 × 4 factorial arrangement with effects of species and experimental diets (Exp. 1 vs. Exp. 2). There were no interactions between species and diets for the digestibility of CP and AA except for Cys ( < 0.01). The AID of CP and indispensable AA in pigs were greater ( < 0.01) than in broiler chickens. In both broiler chickens and pigs, the AID of CP and indispensable AA in SBM-47 were greater ( < 0.05) than in FFSB, and the AID of Lys in PNF was the least ( < 0.05) among ingredients. The SID of CP and indispensable AA in pigs were greater ( < 0.05) than in broiler chickens except for Trp. In both broiler chickens and pigs, the SID of Lys in PNF was the least ( < 0.05) among ingredients. In broiler chickens, the SID of CP, Ile, Leu, Thr, Trp, and Val in FFSB were less ( < 0.05) than that in SBM-43, SBM-47, and PNF. In pigs, the SID of Arg, Ile, Leu, Met, Phe, and Val in FFSB were less ( < 0.05) than in SBM-43, SBM-47, and PNF. In conclusion, the digestibility of CP and most AA were less in broiler chickens than in pigs, but the pattern of differences in the AA digestibility among ingredients was similar between broiler chickens and pigs.

Flaxseed meal and oat hulls supplementation modulates growth performance, blood lipids, intestinal fermentation, bile acids, and neutral sterols in growing pigs fed corn-soybean meal-based diets.

The present study was conducted to determine the effect of flaxseed meal and oat hulls supplementation on growth performance, apparent total tract digestibility (ATTD) of fat, serum lipids, and concentrations of VFA, bile acids (BA), and neutral sterols (NS) in digesta and feces in growing pigs. Forty-eight Genesus [(Duroc boar × Yorkshire-Landrace sows] barrows (25.0 ± 0.32 kg initial BW) were housed in pairs. Pigs were assigned to 1 of the 3 corn-soybean meal-based diets-a basal corn-soybean meal-containing diet (control), a flaxseed meal-containing diet (FM), or an oat hulls-containing diet (OH)-in a completely randomized design. All diets were formulated to be isoenergetic and to contain similar standardized ileal digestible AA contents and meet other nutrient requirements for growing pigs. The experiment lasted for 28 d. Average daily feed intake; ADG; G:F; ATTD of fat, serum lipids, and digesta; and fecal VFA, BA, and NS concentrations were determined. Pigs fed the control or OH had greater final BW ( < 0.001), ADFI ( = 0.005), and ADG ( < 0.001) than FM-fed pigs. The ATTD of fat in the FM was lowest at 70.1% followed by 79.2% in OH and was greatest at 92.4% in the control ( = 0.020). Total serum cholesterol content was 2.25 and 1.99 mmol/L and lower ( < 0.001) in pigs fed FM and OH, respectively, than the 2.36 mmol/L in pigs fed the control. Pigs fed the FM and OH had greater ileal and cecal total VFA ( < 0.001), ileal deoxycholic acid ( < 0.01), and cecal ( < 0.001) and fecal cholesterol ( = 0.002) concentrations than those fed the control. Pigs fed the FM excreted more fecal lithocholic acid ( = 0.002) and ursodeoxycholic acid ( = 0.001) compared with those that consumed the control and OH. The concentrations of coprostanol in cecal digesta ( < 0.001) and feces ( = 0.011) were higher in pigs fed the FM and OH than in pigs fed the control. In conclusion, feeding flaxseed meal and oat hulls induced intestinal fermentation; however, the former depressed growth performance whereas the latter did not have any effect. Addition of flaxseed meal and oat hulls in growing pig diets reduced fat digestibility and serum cholesterol and stimulated malabsorption of primary BA and excretion of secondary BA and NS.

Effect of increasing dietary canola meal inclusion on lactation performance, milk composition, and nutrient digestibility of lactating sows.

The aim was to determine the effects of increasing dietary canola meal in substitution for soybean meal in lactation sow diets. Forty-five sows with an average parity of 1.8 (SD = 0.83) were randomly assigned to 1 of 3 dietary treatments ( = 15) consisting of a corn-based control diet and 2 diets with 15% and 30% canola meal formulated by replacing soybean meal with canola meal. Diets were formulated to be similar in standardized ileal digestible AA content and NE value and to meet or exceed nutrient recommendations for lactating sows. Sows were moved to farrowing on d 111 of gestation and fed the experimental diets until weaning on d 21. Sows were fed 3.0 kg/d from d 111 of gestation until parturition. After farrowing, feed was gradually increased through d 6 after which the diets were offered on an ad libitum basis until weaning. Sows were weighed and backfat thickness measured on d 111 of gestation and also on d 0, 7, and 21 postfarrowing. Litters were weighed on d 0, 7, and 21. Weaning to estrus interval in sows was also recorded. Blood and milk samples were collected 2 h postfeeding from sows on d 0, 7, and 21 and analyzed for plasma urea nitrogen (PUN) and milk composition. Fecal samples were collected on d 10, 11, and 12 postfarrowing to determine energy and nutrient digestibility. There were no dietary effects on lactation feed intake, sow BW and backfat change, weaning to estrus interval, and milk fat, protein, lactose, and urea composition. Also, there were no dietary effects on piglet ADG ( 0.10). Sows fed diets containing 15% and 30% canola meal had lower (linear, < 0.05) PUN values compared with those fed the control diet on d 0, 7, and 21 postfarrowing. Apparent total tract digestibility of DM, GE, CP, and P were reduced linearly ( < 0.05) with increasing canola meal inclusion. In conclusion, up to 30% canola meal in lactation diet can support satisfactory sow and suckling piglet performance.

Amino acid digestibility by weanling pigs of processed ingredients originating from soybeans, 00-rapeseeds, or a fermented mixture of plant ingredients.

An experiment was conducted to determine the apparent ileal digestibility (AID) and the standardized ileal digestibility (SID) of CP and AA in 4 sources of processed soybean products, in conventional dehulled soybean meal (SBM-CV), in conventional 00-rapeseed expellers (RSE), and in a fermented coproduct mixture (FCM) that contained rapeseed meal, wheat, soy molasses, and potato peel fed to weanling pigs. The 4 processed soybean products included 2 sources of enzyme-treated soybean meal (ESBM-1 and ESBM-2), extruded soybean meal, and soy protein concentrate (SPC). Twenty-seven weanling barrows (9.29 ± 0.58 kg initial BW) were surgically equipped with a T-cannula in the distal ileum. Pigs were randomly allotted to three 9 × 5 Youden squares with 9 pigs and five 7-d periods in each square. Seven cornstarch-based diets were prepared using each of the protein sources as the sole source of CP and AA. A N-free diet was prepared to calculate basal endogenous losses of CP and AA, and this diet was fed to 2 groups of pigs, which resulted in a total of 9 dietary treatments. Results indicate that the SID of CP was greater ( < 0.05) in ESBM-1 than in SPC, RSE, or FCM. The SID of Arg, His, Ile, Leu, Met, and Phe were greater ( < 0.05) in ESBM-1 than in SPC, and the SID of Lys was greater ( < 0.05) in SBM-CV than in ESBM-2. The SID of Thr, Trp, Val, and total indispensable AA were not different among the soybean products, but the SID of total dispensable AA in ESBM-1 was greater ( < 0.05) than in SPC. Therefore, the SID of total AA was greater ( < 0.05) in ESBM-1 than in SPC, but no other differences were observed among soybean meal (SBM) products. The SID of most AA in RSE and the SID of all AA in FCM were less ( < 0.05) than in all the SBM products, but the SID of all AA in RSE were greater ( < 0.05) than in FCM. Results of this research indicate that although processing of SBM results in increased concentration of CP, processing may also reduce the digestibility of AA, which is likely due to heat damage during processing. There are, however, differences among processed soy products, with some products having greater SID of AA than others. Results also indicate that fermentation of a mixture of rapeseed meal, wheat, and relatively low quality coproducts does not result in SID values that are similar to those of unfermented 00-rapeseed expellers or soybean products.

Standardized ileal digestible amino acid contents of canola meal from Canadian crushing plants for growing pigs.

Studies have shown that there are variations in the chemical and nutritive composition of canola meal (CM) produced in Canada, some of which may result from differences among the canola seed crushing plants. Therefore, it is necessary to determine the variability in the nutritive value of CM as its end users desire increased meal consistency and more information on any potential variability in AA digestibility. Thus, 18 ileal cannulated barrows (average initial BW = 23.3 kg) were used to determine the apparent (AID) and standardized (SID) ileal digestibility of N and AA and standardized ileal digestible N and AA contents in CM from 6 processing plants in Canada. Two processing plants provided CM in both mash and pellet forms, whereas the other 4 provided it only in mash form, giving a total of 8 CM samples. The barrows were fed 9 cornstarch-based diets. The first 8 diets were formulated to contain the CM samples as the only source of AA. The ninth diet was a casein-cornstarch diet to determine ileal endogenous AA losses. All diets contained 0.3% titanium dioxide as an indigestible marker. Pigs were housed individually in pens and were fed the 9 diets in a completely randomized design for 3 periods to give 6 pigs per diet. Each experimental period lasted for 7 d, consisting of 5 d of adaptation and 2 d of ileal digesta collection at 2-h intervals from 0800 to 2000 h on d 6 and 7. There was an effect ( < 0.05) of CM source on 1) the AID of N, Met, Cys, Thr, Val, Gly, and Ser; 2) the SID of N, Met, and Cys; and 3) the standardized ileal digestible content of all AA. Pelleting reduced ( < 0.05) the standardized ileal digestible content of Arg, Ile, Glu, and Gly in 1 of the CM samples tested and of all AA except His in the other CM sample. The SID values for Arg, Lys, Met, and Thr averaged 87.2%, 78.2%, 84.5%, and 74.1%, respectively. The standardized ileal digestible contents of Arg, Lys, Met, and Thr averaged 2.10%, 1.71%, 0.50%, and 1.01%, respectively. In conclusion, there were variations in the AID, SID, and standardized ileal digestible AA contents of CM among crushing plants in Canada.

Variations in the chemical composition and standardized ileal digestibility of amino acids in eight genotypes of triticale fed to growing pigs.

The study was conducted to determine the chemical composition, physical characteristics, and standardized ileal digestibility (SID) of CP and AA of 8 currently available genotypes of triticale fed to growing pigs. The genotypes included Grenado, Cando, Agostino, Massimo, Tarzan, HYT Prime, SW Talentro, and Cultivo. Eight barrows with an initial BW of 31 ± 2 kg were fitted with simple T-cannulas at the distal ileum and allotted to an 8 × 8 Latin square design with 8 periods of 7 d each and 8 assay diets. The N-free method was used to determine basal ileal endogenous CP and AA losses. The 8 assay diets contained 1 of 8 triticale genotypes as the sole source of CP and AA. The triticale genotypes were grown under identical environmental conditions on the same site. Among the 8 genotypes, contents of CP ranged from 104.7 to 118.1 g/kg (as-fed basis). The content of total nonstarch polysaccharides and NDF ranged, on an as-fed basis, from 84.6 to 99.5 g/kg and from 88.4 to 149.0 g/kg, respectively. Among the 8 genotypes, SID of CP ranged from 81% in Grenado to 85% in Massimo and Tarzan. The SID of CP and AA did not differ among triticale genotypes except for SID of Arg, Glu, and Gly ( < 0.05). The mean SID of CP, Lys, Met, and Trp was 4, 4, 4, and 1 percantage units less and SID of Trp was 5 percantage units greater compared with values in current feed tables. Among the 8 triticale genotypes, standardized ileal digestible content (cSID) of CP followed total CP content and ranged from 84.8 to 98.7 g/kg (as-fed basis), with the lowest ( < 0.001) values for Grenado and the greatest ( < 0.001) values for SW Talentro and Cultivo. For CP and most AA, cSID linearly decreased as the content of total, soluble, and insoluble β-glucans increased ( < 0.05) in the 8 genotypes of triticale. There was a positive correlation between thousand seed weight and cSID of CP and most AA ( < 0.01). These variables may help to predict cSID in triticale batches, whereas other nutrients are not suitable due to their low variation among the 8 genotypes. The present study provides data on chemical composition, physical characteristics, and SID of CP and AA of 8 triticale genotypes grown under similar conditions. However, as most of the present SID values are less than those in feed tables, future research is warranted to elaborate whether these differences are caused by experimental conditions or reflect a consistent decrease that needs to be accounted for in feed tables.

Nutritional value of soy protein concentrate ground to different particle sizes and fed to pigs.

Two experiments were conducted to determine the standardized ileal digestibility (SID) of CP and AA and concentrations of DE and ME in soy protein concentrate (SPC) ground to 3 particle sizes and in soybean meal and fish meal when fed to weanling pigs. An additional experiment was conducted to determine effects on growth performance and blood characteristics of including SPC in diets fed to weanling pigs. In Exp. 1, a N-free diet and diets containing soybean meal, fish meal, or SPC ground to a mean particle size of 70, 180, or 700 μm as the only source of AA were fed to 6 barrows (initial BW: 12.90 ± 1.51 kg) that had a T-cannula installed in the distal ileum. In Exp. 2, 36 barrows (13.70 ± 1.86 kg BW) were allotted to a randomized complete block design with 6 diets and 6 replicate pigs per diet. A corn-based diet and diets containing corn and soybean meal, fish meal, or SPC ground to the 3 particle sizes were used. In Exp. 3, 160 pigs (initial BW: 7.06 ± 1.07 kg) were allotted to 4 dietary treatments with 8 pens per treatment and 5 pigs per pen. Pigs were fed one of 4 diets during phase 1 (d 0 to 14 postweaning), and a common diet in phase 2 (d 14 to 28 postweaning). The 4 diets used in phase 1 included a control diet containing fish meal and spray-dried plasma protein, and diets in which fish meal, spray-dried plasma protein, or both fish meal and spray-dried plasma protein were replaced by SPC ground to 180 μm. Results of Exp. 1 indicated that the SID of His, Lys, and Thr tended ( < 0.10) to be greater in SPC ground to 180 μm than in soybean meal, and the SID of Arg, Ile, Phe, and Trp was greater ( < 0.05) in SPC ground to 70 or 180 μm than in soybean meal. There were no differences in the DE and ME (DM-basis) among corn, soybean meal, fish meal, and SPC ground to 70, 180, or 700 μm. Results of Exp. 3 indicated that growth performance of pigs fed the 4 experimental diets in phase 1 was not different in phase 1, phase 2, or in the entire experiment. In conclusion, grinding SPC to approximately 180 µm maximizes SID of indispensable AA without impacting ME and diets based on soybean meal and SPC as the main protein sources may be fed to pigs during the initial 2 wk postweaning without affecting growth performance.

Influence of wet heating and autoclaving on chemical composition and standardized ileal crude protein and amino acid digestibility in full-fat soybeans for pigs.

One batch each of eight full-fat soybeans (FFSB) was used to determine the effect of different heat treatments including wet heating (WH) and autoclaving (AC) on chemical composition and standardized ileal digestibility (SID) of CP and AA in growing pigs. The raw FFSB (K0) were either treated by WH at 80°C for 1 min (K1), at 100°C for 6 min (K2), or at 100°C for 16 min (K3). Thereafter, these batches were expanded at 125°C for 15 s. A further heat treatment included AC at 110°C for 15 (Z1), 30 (Z2), 45 (Z3), or 60 (Z4) min of FFSB that were subjected to the same WH treatment as K3. Diets were formulated to contain the respective FFSB as the sole source of CP and AA. A N-free diet was used to measure basal endogenous losses of CP and AA in an additional period at the end of the experiment. Eight ileally cannulated pigs (28 ± 1 kg) were allocated to a row-column design with 8 diets and 6 periods of 7 d each. An increase in the duration of WH had no effect on contents of AA (% of CP) and NDF, but NDIN contents linearly increased ( < 0.05) with increasing time for WH. Autoclaving resulted in a linear decrease ( < 0.05) of trypsin inhibitor activity (TIA), contents of Arg, Leu, Ala, Asp, Cys, and Gly as well as Lys to CP ratio (Lys:CP), reactive Lys to CP ratio (rLys:CP), and in an increase ( < 0.05) in contents of NDF and NDIN. There was a quadratic response ( < 0.05) of SID of CP and AA as time for WH at 100°C increased from 0 (K0) to 6 (K2) up to 16 (K3) min. Moreover, a quadratic response ( < 0.05) to increasing time of AC was observed for SID of Arg, Phe, and Pro. The SID of CP and all indispensable AA showed a quadratic response ( < 0.05) to decreasing TIA, urease activity, protein solubility in 0.2% potassium hydroxide, protein dispersibility index, Lys:CP, (lightness), and to increasing NDIN and (redness). In addition, there was a linear increase ( < 0.05) in SID values with decreasing rLys:CP and increasing NDF contents. In conclusion, WH proved to be suitable for increasing SID values. Further improvement of SID of most AA could be achieved on additional AC treatment from Z1 to Z3, however, it needs to be considered, if the observed increase due to AC is cost effective in view of the additional production costs. Several chemical and physical parameters can be used in the feed industry for quality control purposes to predict the extent of heat damage on SID of CP and indispensable AA in FFSB.

Effects of ileal digesta collection time on standardized ileal digestibility of amino acids in corn, soybean meal, and distiller's dried grains with solubles fed to growing pigs.

The objective of this experiment was to determine the minimum collection time needed to obtain representative samples of ileal digesta from pigs fed different types of diets. Eight barrows with an initial BW of 34.6 kg (SD 2.1) were individually fitted with a T-cannula in the distal ileum and randomly allotted to a replicated 4 × 4 Latin square design with 4 diets and 4 periods per square. Three diets contained corn, soybean meal (SBM), or distiller's dried grains with solubles (DDGS) as the sole source of CP. An N-free diet was also prepared. All diets contained 0.5% chromic oxide as an indigestible marker. Equal meals were provided at 0800 and 2000 h. Ileal digesta samples were collected in 2-h intervals from 0800 to 2000 h during the last 3 d of each 7-d period. When pigs were fed the corn diet, the standardized ileal digestibility (SID) of most indispensable AA and dispensable AA increased and then decreased (quadratic, < 0.05) during each of the six 2-h periods. The SID of most AA were less ( < 0.05) if the ileal digesta samples were collected from 1800 to 2000 h or from 1600 to 2000 h compared with the SID values from the ileal samples collected over the entire 12-h period. When pigs were fed the SBM diet, the SID of Ile, Leu, Thr, Trp, Val, Ala, and Cys increased and then decreased (quadratic, < 0.05) but the SID of all other AA linearly decreased ( < 0.05) during the six 2-h periods. The SID of almost all AA were greater ( < 0.05) if the ileal samples were collected from 0800 to 1000 h, from 0800 to 1200 h, from 1000 to 1400 h, or from 0800 to 1400 h but less ( < 0.05) if collected from 1600 to 1800 h, from 1800 to 2000 h, from 1600 to 2000 h, or from 1400 to 2000 h compared with the SID values from the ileal samples collected over the entire 12-h period. When pigs were fed the DDGS-based diet, the SID of Ile, Leu, Lys, Phe, Trp, Val, and Tyr increased and then decreased (quadratic, < 0.05) during the six 2-h periods. The SID of most AA were less ( < 0.05) if the ileal samples were collected from 1800 to 2000 h compared with the SID values from the ileal samples collected over the entire 12-h period. In conclusion, diurnal variations in SID of AA in pigs indicate that 6 h of ileal sample collection starting 4 or 6 h after feeding may provide representative samples of ileal digesta from pigs fed different types of diets.