Fiber-rich Ingredients Research Articles

Extrusion Cooking Effect on Carbohydrate Fraction in Novel Gluten-Free Flours Based on Chickpea and Rice.

Extrusion cooking allows the development of value-added products from pulses, such as gluten-free snacks with added functional properties. The main objective of this study was to evaluate the changes induced by the extrusion process on the carbohydrate fraction (total carbohydrates, soluble sugars and oligosaccharides, dietary fiber, and arabinoxylans) of novel flour formulations based on chickpeas and rice enriched with different dietary fiber sources. Moreover, the influence of the addition of fiber-rich ingredients, such as Fibersol® and passion fruit, on the analyzed compounds was also evaluated. Sucrose was the main soluble sugar found in analyzed formulations, and raffinose was the prevalent oligosaccharide, followed by stachyose. The content of total α-galactosides tended to be higher after extrusion cooking. As a consequence of the extrusion treatment, the content of total and soluble dietary fiber was statistically increased in most of the analyzed samples. In general, no significant changes were observed in total arabinoxylan content as a consequence of the extrusion process, while the content of water-soluble arabinoxylans was significantly increased in extruded formulations. It was observed that the content of total available carbohydrates, stachyose, and water-soluble arabinoxylans were significantly influenced by the addition of passion fruit, Fibersol®, and both. The incorporation of these ingredients in gluten-free formulations based on chickpeas and rice allows one to obtain suitable functional formulations for the development of innovative, gluten-free, extruded snack-type products, which could be an interesting alternative for people with celiac disease.

Chestnut peels and wheat bran at different water level influence the physical properties of pan bread

In breadmaking, dietary fibres are used to improve the nutritional quality of the final products; on the other hand, they may affect the physical and sensory properties. This work aimed to the evaluate, on pan breads, the effect of substituting 3 g of wheat flour with an equivalent amount of fibre rich ingredients: chestnut peels (CP) or wheat bran (WB), in comparison to a traditional wheat bread formulation (C). The effect of four levels of added water (54, 60, 66, 71 g/100 of flour) was also tested. The fibre content of CP (33%) and WB (42%) affected their water binding capacity and, consequently, the quality of the final loaves, according to the different water addition levels. In bread crumb, water content and water activity increased proportionally to the water addition levels, being instead in the crust also affected by the presence of fibres: lower water retention capacity was observed for CP, in comparison to WB and C. The loaf volume resulted higher for C in comparison to WB and CP, in relation to the larger dimensions of the crumb pores, probably due to the interfering effect of fibres during the development of the gluten network. Crumb hardness resulted higher for C at low water addition levels, being instead higher for CP at high water addition levels. CP showed a darker and redder colour, than both WB and C bread, for the presence of the brown pigments carried by chestnut peels. PCA analysis confirmed that more water is required for both the fibre-enriched breads to show characteristics similar to the control loaves.

Textural properties of extruded snack products formulated with deboned poultry meat and brewer’s spent grain

The incorporation of protein- and fibre-rich ingredients into starch-based extruded snacks is of interest for obtaining healthy products. However, development of this type of product has been limited, since protein and dietary fibre have negative effect on textural properties of extruded snacks. In the present study, response surface methodology was used in order to evaluate the effect of different ratios of mechanically deboned poultry meat (MDPM) and brewer’s spent grain (BSG), as well as screw speeds, on hardness, firmness and crispiness of the extrudates produced. Regression analysis showed that BSG and screw speed had significant effects on all textural parameters, while MDPM had a significant effect only on the crispiness of snack products.

CHARACTERIZATION OF PASTA FROM HEAT MOISTURE TREATED WHEAT FLOUR AND GRAPE PEELS

Pasta nutritional and functional value can be enhanced by incorporating fiber-rich ingredients such as grape peels and/or by applying hydrothermal treatments to wheat flour. The purpose of this study was to characterize dough rheological behavior, chemical and sensory charateristics of pasta from heat moisture treated (HMT) wheat flour, native wheat-grape peels composite flour and treated wheat-grape peels flour mix. The results revealed that grape peels addition increased the nutritional value of pasta by raising the ash, fiber and polyphenols content, while HMT determined higher resistant starch values. The elastic and viscous moduli of dough increased when HMT was applied to wheat flour and/or grape peels were incorporated. The addition of grape peels led to higher glass transition temperature, while an opposite effect was observed for HMT. Both grape peels addition and HMT caused lower maximum creep and recovery compliances. Acceptable sensory scores were obtained for all the analysed samples, pasta from treated wheat - grape peels composite flour was characterized as nutritious, fruity, sourish, pasta from treated wheat flour as elastic, gummy, sweet, pleasant, while pasta from native wheat-grape peels was characterized as satiating, fragile, innovative, sourish. These results evidenced the opportunity to increase the functional and nutritional value of pasta by applying physical modification of flour and/or by incorporating grape peels as a source of dietary fiber and bioactive compounds.

Energy values of fiber-rich ingredients with different solubility estimated by different evaluation methods in growing pigs

The objectives of this study were to test whether the time-based total fecal collection (TC) method or the index method (IM) using acid-insoluble ash could obtain similar energy values as the reference (RF) method (TC method with marker-to-marker collection procedure) for growing pigs fed fiber-rich ingredients with different solubility. A total of 24 barrows (initial body weight, 33.3 ± 3.4 kg) were assigned to 4 diets and each diet was fed to 6 pigs. Experimental diets included a corn-soybean meal basal diet and 3 fiber-rich diets which were formulated by replacing corn, soybean meal, and soybean oil in the basal diet with 200 g/kg defatted rice bran (DFRB), soybean hulls (SBH), and sugar beet pulp (SBP), respectively. All diets were formulated to contain 10 g/kg celite as a source of acid-insoluble ash to estimate the energy values by the IM method. Each group of pigs was adapted to diets and crates for 7 d, then followed by 5-d feces and urine collections using the time-based procedure and 5-d feces collection using the marker-to-marker procedure, then the same portion of fecal sample collected by the time-based TC method and the RF method for individual pigs were composited into a sample for the IM method. The results showed that the energy values and nutrients digestibility coefficients of each diet estimated by the time-based TC method agreed with the values estimated by the RF method; the IM method with acid-insoluble ash underestimated the energy values and nutrients digestibility coefficients of the SBH diet and the SBP diet compared with the RF method (P < 0.05); there no differences in energy values of fiber-rich ingredients with different solubility between the RF method and the time-based TC method, however, the IM method with acid-insoluble ash underestimated the energy values of SBH and SBP compared with the RF method or the time-based TC method (P < 0.05). In conclusion, results of this experiment indicated the RF method and the time-based TC method may be used to determine energy values for fiber-rich ingredients with different solubility. However, the IM method with acid-insoluble ash may underestimate the energy values and nutrient digestibility coefficients of some fiber-rich diets and ingredients.

Ultrasound-treated lupin (Lupinus albus L.) flour: Protein- and fiber-rich ingredient to improve physical and textural quality of bread with a reduced glycemic index

In this study, lupin (Lupinus albus L.) flours (0, 10, 15 and 20%) debittered by ultrasound application and traditional method, and resistant starch type 4 (RS4) (0, 5 and 10%) were used in bread production to improve nutritional quality. The effect of ultrasound application on physical, textural and chemical properties of bread enriched with lupin flour and RS4 was investigated. Experiments were conducted at (2 × 4 × 3)×2 factorial design. Ultrasound application presented higher volume, specific volume and lower weight, firmness, hardness and chewiness values in bread compared to the traditional method. Besides, ultrasound had no adverse effect on chemical properties of bread. While the addition of lupin flour decreased volume and specific volume values, increased ash, fat, protein, total dietary fiber, Ca, Cu, Fe, Mg, Mn, P and Zn contents of bread. The bread prepared with 5% RS4 revealed statistically similar volume and specific volume values to bread prepared without RS4 (P > 0.05). Compared to white bread, the use of lupin flour and RS4 in bread formulation significantly (P < 0.05) decreased in vitro glycemic index. These results obtained in this study may provide useful information in the food industry to improve quality of protein- and fiber-rich bread by ultrasound application.

PSXI-27 Chemical Composition and In Vitro Fermentation Characteristics of Legumes Using Canine Fecal Inoculum

Abstract Legumes are a popular grain-free alternative carbohydrate source in canine diets; however, information on fermentative characteristics of select legumes have not been established. Thus, the objectives of the present study were to quantify the chemical compositions and fermentative profile of select legumes using canine fecal inoculum. Five legume varieties, whole yellow peas (WYP), green lentils (GL), black bean grits, navy bean powder, and garbanzo beans, were analyzed and compared to a control, beet pulp (BP). Substrates were analyzed for gross energy (GE), dry and organic matter, crude protein (CP), acid hydrolyzed fat, and total dietary fiber fractions, beta-glucans, starch, free and hydrolyzed sugars, and fermentative characteristics: pH, short-chain fatty acids (SCFA), branched-chain fatty acids (BCFA), total gas, hydrogen, and methane. Substrates underwent a two-stage in vitro digestion and subsequent fermentation using canine fecal inoculum for 0, 3, 6, 9, and 12 h. Statistical significance was set at P ≤ 0.05. All test substrates contained approximately 8–9% moisture and 4.5 kcal/g GE. Crude protein concentrations of pulses ranged from 21–27%. Insoluble fiber values varied from 17–33%, with soluble fiber values ranging from 0–8%. Total starch content was greatest for GL (58%) and WYP (56%). Sucrose and stachyose were the most predominant free sugars and glucose was the most predominant hydrolyzed sugar among test substrates. Production of SCFA did not differ among substrates after 3 or 6 h of fermentation. BP and WYP had the greatest acetate (1,656 and 1,765 umol/g, respectively) and propionate production values (157.7 and 126.1 umol/g, respectively) after 9 h of in vitro fermentation. Pulses are good sources of dietary protein; however, they are also fiber-rich ingredients that appear to be slowly fermentable in vitro, which may have beneficial implications on the ratios of saccharolytic to proteolytic fermentation towards the distal colon in vivo.

The direct and difference procedures result in similar estimates for amino acid digestibility in feed ingredients fed to growing pigs.

An experiment was conducted to test the hypothesis that values for standardized ileal digestibility (SID) of amino acids (AA) in corn, wheat, and wheat middlings obtained using the direct procedure are not different from values obtained using the difference procedure. Sixteen ileal-cannulated barrows (initial BW: 69.5 ± 5.0 kg) were allotted to a replicated 8 × 4 Youden Square design with 8 diets and 4 periods. Each period consisted of 5 d of adaptation to the diet and 2 d of collection of ileal digesta. Four diets were based on soybean meal (SBM), corn, wheat, or wheat middlings as the only AA-containing ingredients. Three additional diets were based on a mixture of SBM and corn, SBM and wheat, or SBM and wheat middlings, and an N-free diet was also used. The apparent ileal digestibility (AID) and the SID of crude protein (CP) and AA for the 4 diets containing SBM, corn, wheat, or wheat middlings as the sole source of AA were calculated using the direct procedure. The AID and SID of CP and AA for the 3 mixed diets containing SBM and corn, wheat, or wheat middlings were also calculated and the contribution of digestible AA from SBM was subtracted from the AID or SID values for the diets. The AID or SID of AA in corn, wheat, and wheat middlings were subsequently calculated by difference. Results indicated that the AID values for a few AA were lower (P < 0.05) if the direct procedure was used instead of the difference procedure, regardless of ingredient. The AID of Trp was greater in corn and wheat middlings, and the SID of Trp in corn and wheat middlings tended to be greater, if the direct procedure rather than the difference procedure was used, but that was not the case for wheat (interaction, P < 0.05 and P < 0.10, respectively). However, for all other indispensable AA, and for most of the dispensable AA, the SID of AA in corn, wheat, and wheat middlings was not different between the difference procedure and the direct procedure. Therefore, values for SID of AA in cereal grains and fiber-rich ingredients may be determined using either the direct or the difference procedure.

Effects of fibre-degrading enzymes in combination with different fibre sources on ileal and total tract nutrient digestibility and fermentation products in pigs

ABSTRACT The study was conducted to determine effects of a complex of fibre-degrading enzymes (xylanase, cellulase and β-glucanase) on nutrient digestibility, fibre fermentation and concentrations of short chain fatty acids (SCFA) at different parts of digestive tract in pigs fed different fibre-rich ingredients. A total of 36 barrows fitted with T-cannulas in the distal ileum (initial body weight of 41.1 ± 2.7 kg) were randomly allotted to six dietary treatments with three different high-fibre diets including maize bran (MB), sugar beet pulp (SBP) and soybean hulls (SH) with or without supplementation of fibre-degrading enzymes. Enzyme supplementation improved (p < 0.05) apparent ileal digestibility (AID) of dietary gross energy (GE), crude protein, dry matter (DM), organic matter (OM), total dietary fibre (TDF), neutral detergent fibre (NDF) and apparent total tract digestibility (ATTD) of dietary GE, DM, OM, TDF, insoluble dietary fibre (IDF) when pigs were fed MB, SBP or SH diets. When compared to the SBP and SH diets, the AID of GE, DM, ash, OM and NDF in diet MB was higher (p < 0.05), but the hindgut disappearance and ATTD of nutrients, except for ether extract and crude ash, were lower (p < 0.05). Enzyme supplementation increased acetate and total SCFA concentrations in ileal digesta and faeces of pigs. In conclusion, enzyme addition improved IDF fermentation and SCFA concentration in the whole intestine of pigs, and there was a large variation of digestibility of fibre components among MB, SH and SBP owing to their different fibre composition. Therefore, fibre-degrading enzymes should be applied to fibrous diets to improve efficient production of swine, especially considering low fibre digestibility of fibre-rich ingredients.

Impact of Acorn Flour on Gluten-Free Dough Rheology Properties.

Gluten is a fundamental ingredient in breadmaking, since is responsible for the viscoelastic behaviour of the dough. The lack of gluten has a critical effect on gluten-free dough, leading to less cohesive and less elastic doughs, and its replacement represents a challenge for bakery industry. However, dough rheology can be improved combining different ingredients with structural capacity and taking advantage from their interactions. Although acorn flour was used to bake bread even before Romans, nowadays is an underexploited resource. It presents good nutritional characteristics, particularly high fibre content and is naturally gluten free. The aim of this study was to use acorn flour as a gluten-free ingredient to improve dough rheology, following also market trends of sustainability and fibre-rich ingredients. Doughs were prepared with buckwheat and rice flours, potato starch and hydroxypropylmethylcellulose. Two levels of acorn flour (23% and 35% w/w) were tested and compared with control formulation. Micro-doughLAB was used to study mixing and pasting properties. Doughs were characterised using small amplitude oscillatory measurements (SAOS), with a controlled stress rheometer, and regarding Texture Profile Analysis (TPA) by a texturometer. Dietary fibre content and its soluble and insoluble fractions were also evaluated on the developed breads. Acorn flour showed promising technological properties as food ingredient for gluten-free baking (improved firmness, cohesiveness and viscoelasticity of the fermented dough), being an important fibre source.

Fermentation of fibre rich ingredients exposed in vitro to the faecal inoculums of swine and turkeys.

This study was focused on in vitro fermentation and in vitro dry matter (DM) digestibility of different fibre rich ingredients that can be used in diets of pigs and turkeys. In vitro DM digestibility was determined by Daisy system via using faecal or excreta fluid of swine/turkeys as a source of inoculum. The ingredients used as substrates were commercial swine or turkey diet, dried beet pulp, wheat bran, hay, straw and two types of lignocelluloses (A and B). Marked differences between the ingredients were found and the values were: dried beet pulp (80%), swine/turkey diet (75%), wheat bran (60%), hay (40%) and straw (10%–20%). Of special interest are the data on the two lignocellulose products, the in vitro DM digestibility of product A was in the range of 20% (in turkeys) up to 30% (in pigs), whereas the product B had values of <5%. Moreover, the inoculums were incubated with the same substrates for 24h using gas measuring technique. Consecutively, commercial swine or turkey diet, dried beet pulp, wheat bran and hay produced high amounts of gas and volatile fatty acids. Lignocellulose A and straw provided lower and equal amounts of gases and fatty acids. However, lignocellulose B showed very little fermentation compared to the product A. In conclusions, faecal or excreta can be used as a source of microbial activity to determine the in vitro DM digestibility or fermentation of feeds. Comparing lignocellulose products with traditional fibre sources, the DM digestibility of lignocellulose A was greater than straw but its fermentation rate seems to be equal to straw. Thus, lignocellulose A can be used as a new source of fibre in diets of monogastric animals to optimize the gut health and improving the faeces or excreta quality.

In vitro prebiotic potential of agricultural by-products on intestinal fermentation, gut barrier and inflammatory status of piglets.

The inclusion of fibre-rich ingredients in diets is one possible strategy to enhance intestinal fermentation and positively impact gut ecology, barrier and immunity. Nowadays, inulin-type fructans are used as prebiotics in the feed of piglets to manipulate gut ecology for health purposes. Likewise, some by-products could be considered as sustainable and inexpensive ingredients to reduce gut disorders at weaning. In the present study, chicory root and pulp, citrus pulp, rye bran and soya hulls were tested in a three-step in vitro model of the piglet's gastro-intestinal tract combining a pepsin-pancreatin hydrolysis (digestion), a dialysis step using cellulose membranes (absorption) and a colonic batch fermentation (fermentation). The fermentation kinetics, SCFA and microbiota profiles in the fermentation broth were assessed as indicators of prebiotic activity and compared with the ones of inulin. The immunomodulatory effects of fermentation supernatant (FS) were investigated in cultured intestinal porcine epithelial cells (IPEC-J2) by high-throughput quantitative PCR. Chicory root displayed a rapid and extensive fermentation and induced the second highest butyrate ratio after inulin. Citrus pulp demonstrated high acetate ratios and induced elevated Clostridium clusters IV and XIVa levels. Chicory root and pulp FS promoted the intestinal barrier integrity with up-regulated tight and adherens junction gene expressions in comparison with inulin FS. Chicory pulp FS exerted anti-inflammatory effects in cultured IPEC-J2. The novel approach combining an in vitro fermentation model with IPEC-J2 cells highlighted that both chicory root and pulp appear to be promising ingredients and should be considered to promote intestinal health at weaning.

116 Direct vs. difference method to determine amino acid digestibility in ingredients fed to pigs

Abstract An experiment was conducted to test the hypothesis that values for standardized ileal digestibility (SID) of amino acids (AA) in cereal grains and fiber rich ingredients obtained using the direct method are not different from values obtained using the difference method. Sixteen ileal-cannulated barrows (69.45 ± 5.01 kg) were allotted to an 8 diets × 4 period Youden square design. Each period consisted of 5 d of adaptation and 2 d of ileal digesta collection. Four diets were based on soybean meal (SBM), corn, wheat, or wheat middlings as the only AA-containing ingredients. Three additional diets were based on a mixture of SBM and corn, wheat, or wheat middlings and a N-free diet was also used. The SID of AA in the 4 diets containing SBM, corn, wheat, or wheat middlings as the sole source of AA were calculated using the direct method. The SID of AA in corn, wheat, and wheat middlings were also calculated by difference from the 3 diets containing SBM and corn, wheat, or wheat middlings by subtracting the contribution from SBM of each AA from the SID values for the mixed diet. Data were analyzed using a model that included the method of determination of AA digestibility as the fixed effect, and pig and period as random effects. There was no difference between the direct and the difference method for the SID of most AA in corn, wheat, and wheat middlings, although the SID of Trp was lower (P &lt; 0.05) for the difference method than values derived by the direct method for both corn and wheat middlings (Table 1). Therefore, values for SID of AA in cereal grains or fiber-rich ingredients could be obtained using either the direct method or the difference method.

In vitro unfermented fiber is a good predictor of the digestible and metabolizable energy content of corn distillers dried grains with solubles in growing pigs1

Characterizing fiber into fermentable and unfermentable fractions may enhance the accuracy of estimating DE and ME energy content in fiber-rich ingredients. Therefore, the objective of this study was to analyze the concentrations of NDF, representing both the fermentable (fNDFom) and unfermentable (uNDFom) portions among sources of corn distillers dried grains with solubles (DDGS), and determine their relative contributions to DE and ME content. The concentrations of DE and ME, as well as apparent total tract digestibility (ATTD) of GE, were measured in a previous experiment. Samples of DDGS (0.5 g) were mixed with fecal inoculum and incubated for 8, 12, and 72 h. The ash corrected NDF (NDFom) content of DDGS residues at each time point was determined. The fNDFom increased with fermentation time of 8 h (21.6%), 12 h (29.0%), and 72 h (68.6%). The ATTD of GE increased as the uNDFom decreased at 8 h (uNDFom8; R2 = 0.83; P < 0.01) and 72 h (uNDFom72; R2 = 0.83; P < 0.01). Likewise, ME content of DDGS increased as uNDFom72 decreased (R2 = 0.59; P < 0.01). The best-fit DE equation was DE (kcal/kg DM) = 2,175 - 3.07 × uNDFom8 (g/kg, DM) - 1.50 × uNDFom72 (g/kg, DM) + 0.55 × GE (kcal/kg DM) (R2 = 0.94, SE = 36.21). The best-fit ME equation was ME (kcal/kg DM) = 1,643 - 2.31 × uNDFom8 (g/kg, DM) - 2.54 × uNDFom72 (g/kg, DM) + 0.65 × GE (kcal/kg DM) - 1.42 × crude protein (g/kg DM) (R2 = 0.94, SE = 39.21). These results indicate that in vitro unfermented fiber is negatively associated with GE and NDF digestibility, and therefore, is a good predictor of DE and ME content in corn-DDGS.

Effects of dietary fiber content and different fiber-rich ingredients on endogenous loss of fat and fatty acids in growing pigs

Effects of dietary fiber content and different fiber-rich ingredients on endogenous loss of fat and fatty acids in growing pigs

Net energy content of rice bran, defatted rice bran, corn gluten feed, and corn germ meal fed to growing pigs using indirect calorimetry.

The objective of this experiment was to determine the effects of increased fiber content in diets on heat production (HP) and NE:ME ratio and to determine the NE content and NE:ME ratio of full-fat rice bran (FFRB), defatted rice bran (DFRB), corn gluten feed (CGF), and corn germ meal (CGM) fed to growing barrows using indirect calorimetry (IC). Thirty growing barrows (28.5 ± 2.4 kg BW) were allotted in a completely randomized design to 5 dietary treatments that included a corn-soybean meal basal diet and 4 experimental diets with a constant ratio of corn and soybean meal (difference method) containing 30% FFRB, DFRB, CGF, and CGF. Pigs were housed in individual metabolism crates for 20 d including 14-d adaptation to the diet and 6 d to determine the HP and total collection of feces and urine in respiration chambers. Pigs were fed their respective diets at 550 kcal ME·kg BW0.60-1·d-1 on the basis of BW measured on days 0, 7, and 14. The apparent total tract digestibility (ATTD) of DM, GE, and OM were greater (P < 0.01) in pigs fed the basal diet. The ATTD of DM, GE, and OM in pigs fed the DFRB diet were lesser (P < 0.01) when compared with those fed the basal and FFRB diets. The ATTD of ether extract (EE) in pigs fed the FFRB diet was greater (P < 0.01) compared with those fed basal, DFRB, CGF, and CGM diets. The HP adjusted for the same ME intake was greater (P < 0.01) in pigs fed the DFRB, CGF, and CGM diets compared with those fed basal and FFRB diets. The NE:ME ratio in pigs fed the FFRB diet was greater (P < 0.01) when compared with those fed the DFRB, CGF, and CGM diets. The NE content of FFRB, DFRB, CGF, and CGM determined using the IC method were 2,952, 1,100, 1,747, and 2,079 kcal/kg DM, respectively. The NE content of FFRB, CGF, and CGM determined using the IC method were 3.5%, 3.8%, and 1.8% greater, respectively, than the predicted values, whereas NE content of DFRB determined using the IC method was 2.1% lower than the predicted values. In conclusion, pigs fed the fiber-rich ingredients had greater HP and lower nutrient digestibility. However, pigs fed FFRB diets containing greater fat content had a lower heat increment and, therefore, higher utilization efficiency. The NE:ME ratio ranged from 71.6% to 82.4%. The NE of FFRB, DFRB, CGF, and CGM determined using the IC method were 2,952, 1,100, 1,747, and 2,079 kcal/kg DM, respectively.

Adaptation duration for net energy determination of high fiber diets in growing pigs

This study was conducted to determine the optimal adaptation duration of growing pigs to high fiber diets for net energy (NE) determination and the effect of soluble and insoluble fiber on nutrient digestibility and energy metabolism using indirect calorimetry. Eighteen growing barrows (initial BW: 36.1 ± 3.1 kg) were allotted in a completely randomized design to 3 dietary treatments. The 3 experimental diets included a corn-soybean meal basal diet and 2 test diets formulated to contain either 220 g/kg sugar beet pulp or 200 g/kg soybean hulls at the expense of corn, soybean meal and amino acid (AA) in the basal diet. The experiment was conducted in 3 consecutive 28-d periods consisting of a 7-d preliminary period followed by a 21-d heat production (HP) measurement period, and the HP measurement period was artificially divided into 4 adaptation duration (collection periods) of 5 d (from d 8 to d 12, d 13 to d 17, d 18 to d 22, d 23 to d 27) in order to calculate DE, ME and NE values and digestibility coefficients of nutrients within each collection period and pig. Pigs required to be adapted to the three diets for these many days before they could finish the daily feed allowance. Indeed, pigs needed 7, 12 and 10 days finishing eating the basal, sugar beet pulp and soybean hulls diet, respectively. The coefficient of apparent total tract digestibility (CATTD) of dry matter (DM), total dietary fiber (TDF), neutral detergent fiber assayed with a heat stable amylase and expressed inclusive of residual ash (aNDF), ether extract (EE) and organic matter (OM) were not significantly changed with adaptation duration for respective diets. Nitrogen retention was increased (P < 0.05) in respective diets with adaptation duration. The total heat production (THP), retained energy as protein (REP) and retained energy as lipids (REL) were not changed with adaptation duration in their respective diets. Similarly, the digestible energy (DE), metabolizable energy (ME) and NE values of diets and ingredients were not changed with adaptation duration. Sugar beet pulp and soybean hulls had a negative effect (P < 0.01) on energy values and CATTD of gross energy (GE), DM, OM, crude protein (CP) and EE. However, the CATTD of fiber constituent were greater (P < 0.01) in pigs fed the sugar beet pulp diet than pigs fed other diets. In conclusion, considering the effect of high fiber diets on feed intake, a 12-d adaptation period will be necessary for NE determination of fiber-rich ingredients, even though the CATTD of most nutrients and energy values were not changed with adaptation duration. High fiber diets had a negative effect on nutrients digestibility and energy values.

The contribution of digestible and metabolizable energy from high-fiber dietary ingredients is not affected by inclusion rate in mixed diets fed to growing pigs.

Effects of inclusion rate of fiber-rich ingredients on apparent ileal digestibility (AID) and apparent total tract digestibility (ATTD) of GE and on the concentration of DE and ME in mixed diets fed to growing pigs were determined. The hypothesis was that increasing the inclusion rate of fiber decreases digestibility of GE, and thus, the contribution of DE and ME from hindgut fermentation because greater concentrations may reduce the ability of microbes to ferment fiber. Twenty ileal-cannulated pigs (BW: 30.64 ± 2.09 kg) were allotted to a replicated 10 × 4 incomplete Latin Square design with 10 diets and four 26-d periods. There were 2 pigs per diet in each period for a total of 8 replications per diet. A basal diet based on corn and soybean meal (SBM) and a corn-SBM diet with 30% corn starch were formulated. Six additional diets were formulated by replacing 15% or 30% corn starch by 15% or 30% corn germ meal, sugar beet pulp, or wheat middlings, and 2 diets were formulated by including 15% or 30% canola meal in a diet containing corn, SBM, and 30% corn starch. Effects of adding 15% or 30% of each fiber source to experimental diets were analyzed using orthogonal contrasts and t-tests were used to compare inclusion rates within each ingredient. The AID and ATTD of GE and concentration of DE and ME in diets decreased (P < 0.05) with the addition of 15% or 30% canola meal, corn germ meal, sugar beet pulp, or wheat middlings compared with the corn starch diet. However, inclusion rate did not affect the calculated DE and ME or AID and ATTD of GE in any of the ingredients indicating that concentration of DE and ME in ingredients was independent of inclusion rate and utilization of energy from test ingredients was equally efficient between diets with 15% and 30% inclusion. Increased inclusion of fiber in the diet did not influence transit time in the small intestine, but reduced the time of first appearance of digesta in the feces indicating that transit time was reduced in the hindgut of pigs fed high-fiber diets. However, this had no impact on DE and ME or ATTD of GE in test ingredients. In conclusion, fiber reduced the DE and ME in the diet. However, inclusion rate of fiber-rich ingredients in diets did not affect calculated values for DE and ME in feed ingredients indicating that microbial capacity for fermentation of fiber in pigs is not overwhelmed by inclusion of 30% high-fiber ingredients in the diets.

Modification of bamboo shoot dietary fiber by extrusion-cellulase technology and its properties

ABSTRACTIn this study, the effects of extrusion combined with cellulase on the structural, physicochemical, and functional properties of bamboo shoots dietary fiber were evaluated. Extrusion-cellulase treatment increased the contents of soluble dietary fiber (22.17 g/100 g dry solids). The scanning electron microscopy and Fourier transformed infrared spectroscopy analyses showed that the extrusion-cellulase treatment altered the structure of bamboo shoots dietary fiber without destroying the main components. Bamboo shoots dietary fiber modified by extrusion-cellulase treatment showed improved water-holding capacity (9.34 g/g dry solids), oil-holding capacity (10.74 g/g dry solids), swelling capacity (8.32 mL/g dry solids), cation exchange capacity and functional properties, including glucose adsorption capacity (158 mg/g dry solids), cholesterol adsorption capacity (9.8 mg/g dry solids (pH 2), and 11.4 mg/g dry solids (pH 7)), and nitrite ion adsorption capacity (29 μg/g dry solids (pH 2) and 21 μg/g dry solids (pH 7)). This experiment provided a theoretical basis for the modification of bamboo shoots dietary fiber, and the bamboo shoots dietary fiber modified by extrusion-cellulase can be useful as a fiber-rich ingredient in functional foods.

Modification of dietary fibers from purple-fleshed potatoes ( Heimeiren ) with high hydrostatic pressure and high pressure homogenization processing: A comparative study

Abstract In this study, we evaluated the effects of high hydrostatic pressure (HHP) and high pressure homogenization (HPH) treatments on the physicochemical, functional, and structural properties of dietary fibers (DFs) obtained from purple-fleshed potatoes. DFs subjected to HHP and HPH exhibited increased content of soluble dietary fiber. HHP and HPH treatments did not improve water holding capacity, but increased oil holding and swelling capacities, and emulsion activity and stability. DFs treated with HPH showed the increased antioxidant activities (DPPH 0.89, ABTS 2.65, FRAP 3.39 mg Trolox/g DF), content of total phenol, and α-glucosidase inhibition (98.3%). HHP and HPH treatments changed monosaccharide compositions and structural characteristics of DFs. Therefore, DFs from purple-fleshed potatoes could be used as a fiber-rich ingredient in functional foods, and HPH was more useful in the modification of dietary fiber than HHP at the same treatment conditions. Industrial relevance : This article deals with the modification of dietary fibers from purple-fleshed potatoes ( Heimeiren ) with HHP and HPH treatments. Results suggest that HPH treated dietary fiber showed a higher ratio of soluble fraction, increased physicochemical and functional properties than HHP at 200 MPa. There outcomes could help the food industry identify the optimal high pressure processing type to improve physicochemical and functional properties of dietary fiber.