Faba Bean Flour Research Articles

Impact of a Dual Treatment on Resistant Starch Level and Techno‐Functional Properties of Pea and Faba Bean Flours

AbstractStarch‐rich pulses’ flours, which are rich in fiber and resistant starch (RS), can be an interesting gluten‐free ingredient for the development of novel healthy foods. The study aims to increase the RS content of protein‐reduced fraction of legume flours (pea [P] and faba bean [FB]) by the application of thermal (autoclaving‐cooling) and dual (thermal plus high‐hydrostatic pressure) treatments. Both treatments enhance the RS contents, reaching 6.8% in P flour after dual treatment. The techno‐functional properties are dependent both on the type of flour and the treatment applied. A loss of water solubility (WS) and an increase in water binding capacity are observed. The WS index and emulsion activity remained unchanged or slightly changed, but emulsion stability decreased significantly. The viscosity of the samples is modified according mainly to the flour type. P flour is more affected by the dual treatment than FB flour, which is evidenced by the greater changes shown in RS, WS, and pasting properties.

Bioaccessibility and Antioxidant Activity of Faba Bean Peptides in Comparison to those of Pea and Soy after In Vitro Gastrointestinal Digestion and Transepithelial Transport across Caco-2 and HT29-MTX-E12 Cells.

In this study, the transepithelial transport of bioactive peptides derived from faba bean flour gastrointestinal digestates was investigated, in vitro, using a Caco-2 and HT29-MTX-E12 coculture monolayer, in comparison to those of pea and soy. The profile of transported peptides was determined by mass spectrometry, and the residual antioxidant activity was assessed. The ORAC value significantly (p < 0.05) decreased after transepithelial transport (24-36% reduction) for all legumes, while the antioxidant activity in ABTS assay significantly (p < 0.05) increased, as shown by the EC50 decrease of 26-44%. Five of the nine faba bean peptides that crossed the intestinal cell monolayer exhibited antioxidant activity. Two of these peptides, TETWNPNHPEL and TETWNPNHPE, were further hydrolyzed by the cells' brush border peptidases to smaller fragments TETWNPNHP and TWNPNHPE. These metabolized peptides were synthesized, and both maintained high antioxidant activity in both ABTS (EC50 of 1.2 ± 0.2 and 0.4 ± 0.1 mM, respectively) and ORAC (2.5 ± 0.1 and 3.4 ± 0.2 mM of Trolox equivalent/mM, respectively) assays. These results demonstrated for the first time the bioaccessibility of faba bean peptides produced after in vitro gastrointestinal digestion and how their bioactive properties can be modulated during transepithelial transport.

Heat-Induced Gelation of Chickpea and Faba Bean Flour Ingredients.

This study aimed to investigate the gelling behavior of faba bean (FB) and chickpea (CP) flour between 10 and 20% (w/w) concentration at pH 3.0, 5.0, and 7.0. Both sources formed at pH 3.0 and 5.0 self-standing gels with 12% (w/w) of flour, while 16% (w/w) of flour was required to obtain a gel at pH 7.0. During gelling between 40 and 70 °C, a sharp increase of the elastic modulus G' was observed in both flours, mainly due to water absorption and swelling of the starch, one of the major constituents in the ingredients. Increasing the temperature at 95 °C, G' increased due to the denaturation of globulins and therefore the exposure of their internal part, which allowed more hydrophobic interactions and the formation of the gel. After cooling, both FB and CP gels displayed a solid-like behavior (tan δ ranging between 0.11 and 0.18) with G' values at pH 3.0 and 5.0 significantly (p < 0.05) higher than those at pH 7.0, due to the lower electrostatic repulsions at pHs far from the isoelectric point. The rheological properties were supported by the water binding capacity values, confirming the better gels' strength described by rheological analysis. These results will enhance our understanding of the role of legume flours in formulating innovative and sustainable food products as alternatives to animal ones.

Low-intensity pulsed electric field processing prior to germination improves in vitro digestibility of faba bean (Vicia faba L.) flour and its derived products: A case study on legume-enriched wheat bread

This study investigated the effect of low-intensity pulsed electric field (PEF) (0.3–0.7 kV/cm) and/or germination (0–72 h, 20 °C) on faba beans prior to flour- and breadmaking. PEF (0.5 and 0.7 kV/cm) had no significant effect on the germination performance of faba bean but had a positive effect on in vitro starch and protein hydrolysis of PEF-treated beans germinated for 72 h. The incorporation of flour from soaked, germinated, PEF-treated, and PEF-treated+germinated faba beans into wheat bread, at 30% mass level, improved the nutritional composition (total starch and protein contents) and protein digestibility but it reduced the specific volume and increased the density, brownness, and hardness of the bread. This finding shows for the first time that PEF-treatment (<0.7 kV/cm) of faba beans followed by germination (72 h) improved in vitro starch and protein hydrolysis of its flour and the protein digestibility at gastric phase of its enriched wheat bread.

Enhancing the nutritional and bioactive benefits of faba bean flour by combining preprocessing and thermoplastic extrusion: A comprehensive study on digestion-resistant peptides

This research assessed how three preprocessing techniques [soaking (S), soaking and reconstitution (SR), and soaking and dehulling (SD)] impact the protein digestibility and bioactivity of faba bean flours when combined with thermoplastic extrusion. Samples were compared against a control (C) of extruded faba bean flour without preprocessing. Applying preprocessing techniques followed by extrusion diminished antinutrient levels while enhancing protein hydrolysis and in vitro bioactivity in higher extent compared to C. Specifically, SD combined with extrusion was the most effective, achieving an 80% rate of protein hydrolysis and uniquely promoting the release of gastric digestion-resistant proteins (50-70 kDa). It also resulted in the highest release of small peptides (<3kDa, 22.51%) and free amino acids (15.50%) during intestinal digestion. Moreover, while all preprocessing techniques increased antioxidant (ABTS radical-scavenging), antidiabetic, and anti-hypertensive activities, SD extruded flour displayed the highest levels of dipeptidyl peptidase inhibition (DPP-IVi, IC50=13.20 µg/mL), pancreatic α-amylase inhibition (IC50=8.59 mg/mL), and angiotensin I-converting enzyme inhibition (ACEi, IC50=1.71 mg protein/mL). As a result, it was selected for further peptide and in silico bioactive analysis. A total of 24 bioactive peptides were identified in intestinal digests from SD extruded flour, all with potential DPP-IVi and ACEi activities, and six were also predicted as antioxidant peptides. VIPAGYPVAIK and GLTETWNPNHPEL were highlighted as resistant bioactive peptides with the highest antidiabetic and antioxidant potential. Our findings demonstrated that combining preprocessing (particularly SD) and thermoplastic extrusion enhances protein digestibility in faba beans and promotes the release of beneficial bioactive peptides in the intestine.

Antioxidant and Angiotensin-Converting Enzyme Inhibitory Activity of Faba Bean-Derived Peptides After In Vitro Gastrointestinal Digestion: Insight into Their Mechanism of Action.

Faba bean flour, after in vitro gastrointestinal digestion, showed important antioxidant and angiotensin-converting enzyme (ACE) inhibitory activities. In the present study, 11 faba bean- derived peptides were synthesized to confirm their bioactivities and provide a deeper understanding of their mechanisms of action. The results revealed that 7 peptides were potent antioxidants, namely, NYDEGSEPR, TETWNPNHPEL, TETWNPNHPE, VIPTEPPH, VIPTEPPHA, VVIPTEPPHA, and VVIPTEPPH. Among them, TETWNPNHPEL had the highest activity in the ABTS (EC50 = 0.5 ± 0.2 mM) and DPPH (EC50 = 2.1 ± 0.1 mM) assays (p < 0.05), whereas TETWNPNHPE had the highest activity (p < 0.05) in the ORAC assay (2.84 ± 0.08 mM Trolox equivalent/mM). Synergistic and/or additive effects were found when selected peptides (TETWNPNHPEL, NYDEGSEPR, and VVIPTEPPHA) were combined. Four peptides were potent ACE inhibitors, where VVIPTEPPH (IC50 = 43 ± 1 μM) and VVIPTEPPHA (IC50 = 50 ± 5 μM) had the highest activity (p < 0.05), followed by VIPTEPPH (IC50 = 90 ± 10 μM) and then VIPTEPPHA (IC50 = 123 ± 5 μM) (p < 0.05). These peptides were noncompetitive inhibitors, as supported by kinetic studies and a molecular docking investigation. This study demonstrated that peptides derived from faba beans have multifunctional bioactivities, making them a promising food-functional and nutraceutical ingredient.

Important roles of coarse particles in pasting and gelling performance of different pulse flours under high-temperature heating

Dehulled pea, lentil, and faba bean grains were milled into flours with 0.5- to 2.5-mm sieves. As the particle size decreased, damaged-starch contents of the flours from the same pulse crop increased. At a holding temperature of 95 °C in RVA, peak and final viscosities and gelling ability of the flours generally increased as the particle size decreased. When the holding temperature increased from 95 to 140 °C, pasting viscosities of pea and lentil flours and gel hardness of lentil flours gradually decreased. In contrast, pasting viscosities and gel hardness of faba bean flours reached the highest values at 120 °C. The comparison of the pulse flours varying in particle size across the three market classes revealed that coarse particles comprising agglomerated starch, protein, and dietary fiber (i.e., particles of the second peak in the bimodal particle-size distribution curves) showed significant correlations with certain important functional properties of pulse flours.

Assessing the digestibility and estimated bioavailability/ bioaccessibility of plant-based proteins and minerals from soy, pea, and faba bean ingredients

Concerns have been raised about the nutritional adequacy of plant-based foods due to the presence of antinutrients and overall low protein digestibility. Therefore, this study characterizes the estimated bioavailability/bioaccessibility of iron and zinc and the protein digestibility of 11 commercially available plant-based ingredients to assess their potential in the future development of nutritious plant-based foods. The accessibility of iron and zinc was limited in all ingredients, with only faba bean isolate, pea isolate, faba bean concentrate and texturized pea containing accessible iron. Faba bean isolate was found to have the highest amount of accessible iron (67.4 mg/kg) whereas textured pea showed the lowest amount (0.5 mg/kg). The estimated bioavailability of iron and zinc, based on the calculated molar ratio of phytate, was low for all studied ingredients, with isolates showing the highest overall tendency for available iron and zinc. The amino acid composition data revealed limitations regarding valine and/or isoleucine in all protein concentrates and texturized proteins, soy isolate, and faba bean flour. In contrast, no significant differences were found in overall protein digestibility, suggesting that all tested raw materials, including faba bean, can be considered good protein sources.

Improved in vitro gastrointestinal digestion protocol mimicking brush border digestion for the determination of the Digestible Indispensable Amino Acid Score (DIAAS) of different food matrices

The Digestible Indispensable Amino Acid Score (DIAAS) is the new gold standard method for the assessment of protein nutritional quality. The DIAAS is evaluated with in vivo models, that are complex, constraining and costly. There is still no established method to assess it in vitro. In this study, we proposed to add a jejunal-ileal digestion phase to the standardized in vitro gastrointestinal digestion protocol developed by the International Network of Excellence on the Fate of Food in the Gastrointestinal Tract (INFOGEST protocol) to mimic brush border digestion and to enable DIAAS assessment in vitro in a more physiologically relevant manner. This jejunal-ileal digestion phase was performed with a porcine intestinal aminopeptidase as an alternative to brush border membrane extract, which is more difficult to obtain in a standardized way. This modified INFOGEST protocol was applied to various food matrices (faba bean, pea and soy flours, whey protein isolate and caseins) and the results were compared to published in vivo data to assess the model’s physiological relevance. The addition of the jejunal-ileal digestion phase lead to a significant (p < 0.05) increase of 31 and 29 % in free and total amino acid digestibility, respectively, and of 83 % on average for the in vitro DIAAS values for all food matrices. Although the in vitro DIAAS remained underestimated compared to the in vivo ones, a strong correlation between them was observed (r = 0.879, p = 0.009), stating the relevance of this last digestion phase. This improved digestion protocol is proposed as a suitable alternative to evaluate the DIAAS in vitro when in vivo assays are not applicable.

Estimation of Roasted and Raw Faba Bean and Lentil Flour Functional Properties

Estimation of Roasted and Raw Faba Bean and Lentil Flour Functional Properties

CHEMICAL, PHYSICAL AND SENSORY PROPERTIES OF GLUTEN-FREE POTATO CRACKERS SUPPLEMENTED WITH COWPEA, FABA BEAN AND MUNG BEAN FLOURS

In this study, some characteristics of gluten-free potato crackers substituded with cowpea, faba bean and mung bean flours were determined. The crackers containing the legume flours had significantly higher (p&lt;0.05) fat, protein, insoluble and total dietary fiber, and essential amino acids (EAA) than the control cracker (C) produced with potato flour and starch. The cracker containing faba bean flour (FC) had the highest P, K, Ca, and Zn contents. C recorded the highest L*, cracker containing cowpea flour (CC) recorded the highest a* and FC recorded the highest b* values. C had a higher hardness value than the other crackers, followed by the cracker containing mung bean flour (MC), CC and FC, respectively. SEM micrographs revealed that more cracks and pores were formed when legume flour was added to the crackers. CC, FC and MC scored higher in flavor, chewiness, crispiness and overall acceptability scores than C in sensory analysis.

Brašno i izolati proteina boba kao delimični supstituenti u hlebu od mešavine pšenice i tritikalea - tehnološka i senorska svojstva

The incorporation of faba bean flour (FBF) and protein isolate (FBI) into wheat-triticale flour blends is a potential promising strategy to enhance the nutritional and functional properties of bread. This study aimed to investigate the potential of these ingredients from both technological and sensory perspectives. Multiple analyses were conducted, including chemical composition, texture profile analysis, colour, specific volume and sensory properties of breads made with a blend of wheat and triticale flours (70:30). Part of the blend was substituted with either 20% faba bean flour or 7.2% faba bean protein isolate to ensure an equal proportion of faba bean protein in the final formulations. The results showed a significant increase in protein content for both FBF and FBPI breads, with the faba bean protein isolate also increasing the ash content. Texture profile analysis (TPA) indicated that the substitutions affected bread properties by increasing hardness, gumminess, and chewiness, particularly in bread with FBI. However, cohesiveness, springiness, and resilience decreased similarly in both cases. Additionally, the specific volume decreased with the addition of faba bean flour and protein, especially in FBI bread. From the colour aspect, analysis revealed a darker hue and a more pronounced reddish nuance in the bread crust in FBF and FBI breads. Sensory evaluation indicated a slightly lower overall likeability with faba bean addition, yet the breads remained acceptable to the panellists. Detailed sensory analysis supported the TPA findings and colour differentiation, showing higher values for hardness, crust compactness, and crumbliness. Texture and colour were rated lower compared to the control sample. Moreover, both FBF and FBI breads exhibited higher overall odour intensity. Specifically, bread with the protein isolate had less uniform pores and a more pronounced flour/cereal/bran odour. In contrast, bread with faba bean flour had more uniform pores but a noticeable bitterness. In conclusion, this study demonstrates that faba bean flour and protein isolate can be used as partial substitutes in wheat-triticale flour blends to produce bread with acceptable properties. This leaves room for future in-depth analysis and modifications to address the identified challenges.

In vitro digestion properties and use of automatic image analysis to assess the quality of wheat bread enriched with whole faba bean (Vicia faba L.) flour and its protein-rich fraction

The trend of incorporating faba bean (Vicia faba L.) in breadmaking has been increasing, but its application is still facing technological difficulties. The objective of this study was to understand the influence of substituting the wheat flour (WF) with 10, 20, 30 and 40 % mass of whole bean flour (FBF) or 10 and 20 % mass of faba bean protein-rich fraction (FBPI) on the quality (volume, specific volume, density, colour, and texture), nutritional composition (total starch, free glucose, and protein contents), and kinetics of in vitro starch and protein digestibility (IVSD and IVPD, respectively) of the breads. Automated image analysis algorithm was developed to quantitatively estimate the changes in the crumb (i.e., air pockets) and crust (i.e., thickness) due to the use of FBF or FBPI as part of the partial substitution of wheat flour. Higher levels of both FBF and FBPI substitution were associated with breads having significant (p < 0.05) lower (specific) volume (at least 25 % reduction) and higher density (up to 35 %), increased brownness (up to 49 % and 78 % for crust and crumb respectively), and up to 2.3-fold increase in hardness. Result from the image analysis has provided useful insights on how FBF and FBPI affecting bread characteristics during baking such as loss of crumb expansion, decrease in air pocket expansion and increase in crust thickness. Overall, incorporation of FBF or FBPI in wheat bread were favourable in reducing the starch content and improving the protein content and IVPD of wheat bread. Since bread remains as a staple food due to its convenience, versatility and affordability for individuals and families on a budget, wheat bread enriched with faba bean could be a perfect food matrix to increase daily protein intake.

Antifungal peptides from faba bean flour fermented by Levilactobacillus brevis AM7 improve the shelf-life of composite faba-wheat bread

Faba bean is an important crop from an ecological, nutritional, and economical perspective, hence its incorporation in plant-based products can play a key role in the sustainability of the whole food system. In this study, the antifungal properties of faba bean flour were investigated employing three bioprocessing treatments including hydrolysis with a commercial proteolytic enzyme preparation, and fermentation with selected or commercial mixed sourdough starters. Faba bean flour fermented by Levilactobacillus brevis AM7 showed the broadest inhibitory spectrum against the fungal species tested and antifungal activity ranging from 25 to 73 %. Bioactive proteins and peptides were found to be responsible for the antifungal activity. Polypeptides sequences corresponding to defensin-like and non-specific lipid-transfer proteins and seven antifungal peptides having 11–22 amino acid residues and mass from 1240.7 to 2624.2 Da, were identified via Liquid Chromatography-Electrospray Ionisation-Mass Spectra/Mass Spectra (nano-LC-ESI-MS/MS). To assess the antifungal effect in food processing conditions, fermented faba bean was used as ingredient in breadmaking at a substitution level of 30 % of the dough weight. Wheat composite-bread containing faba bean sourdough, which could be claimed as “source of proteins”, according to the current EC Regulation, delayed the molds contamination, lasting up to 10 days before mold appearance, and behaving similarly to wheat bread containing calcium propionate.

Assessment of bioactive compounds in faba bean using infrared spectroscopy

AbstractFaba bean (Vicia faba) is growing in popularity in Australia, partly due to its higher levels of health‐benefiting compounds compared to other grain crops. This study investigated infrared spectroscopy for predicting levels of bioactive compounds such as antioxidants and phenolics in faba bean flour. Calibration models were performed on 60 samples of faba bean, comprising 10 varieties grown across two field locations in 1 year. For model validation, an independent test set comprising the same varieties grown in a different year was utilised. Near‐infrared spectroscopy (NIRS) showed promise for the prediction of total phenolic content, with an R2pred of 0.66 and root mean square error of prediction (RMSEP) of 76 mg/100 g. Similarly, prediction of ferric reducing antioxidant power, a measure of antioxidant activity, gave an R2pred of 0.59 and RMSEP of 87 mg/100 g. Additionally, moving window optimisation was used to determine the most important wavelength region for the prediction of these analytes. Fourier transform infrared spectroscopy did not yield any suitable models for the analytes investigated. Although the NIRS models developed were not capable of exactly quantifying phenolic or antioxidant content, infrared spectroscopy appears useful for rapidly discriminating between samples containing high and low levels of phenolics or antioxidant compounds. With further refinement, this technique could potentially be applied for the quality assurance of phenolic content or antioxidant capacity in faba bean seeds.

Investigation of the nutritional quality of raw and processed Canadian faba bean (Vicia faba L.) flours in comparison to pea and soy using a human in vitro gastrointestinal digestion model

Faba bean is an ancient legume that is regaining interest due to its environmental and nutritional benefits. Very little is known on the protein quality of the new faba bean varieties. In this study, the digestibility and the Digestible Indispensable Amino Acid Score (DIAAS) of the protein quality of three Canadian faba bean varieties (Fabelle, Malik and Snowbird) were compared to pea and soy using the harmonized in vitro digestion procedure developed by the International Network of Excellence on the Fate of Food in the Gastrointestinal Tract (INFOGEST). The impact of boiling on the nutritional quality of faba bean flours was also ascertained. Protein content in faba bean (28.7–32.5%) was lower than defatted soy (56.6%) but higher than pea (24.2%). Total phenolics and phytate content were higher (p < 0.05) in faba bean (2.1–2.4 mg/g and 11.5–16.4 mg/g respectively) and soy (2.4 mg/g and 19.8 mg/g respectively) comparatively to pea (1.3 mg/g and 8.9 mg/g). Trypsin inhibitor activity was significantly higher (p < 0.05) in soy (15.4 mg/g) comparatively to pea (0.7 mg/g) and faba bean (0.8–1.1 mg/g). The digestibility of free amino acids of raw faba bean flours ranged from 31 to 39% while the digestibility of total amino acids ranged from 38 to 39%. The in vitro Digestible Indispensable Amino Acid Score (IV-DIAAS) of raw faba bean flours ranged from 13 to 16 (when calculated based on free amino acid digestibility) to 32–38 (when calculated based on total amino acid digestibility) and was in a similar range to pea (13–31) and soy (11–40). Boiling modified the protein electrophoretic profile and decreased trypsin inhibitor activity (30–86% reduction), while total phenolics and phytate content were unaffected. The IV-DIAAS significantly decreased in all boiled legumes, possibly due to an increased protein aggregation leading into a lower protein digestibility (18–32% reduction). After boiling, the nutritional quality of faba bean was significantly lower (p < 0.05) than soy, but higher than pea. Our results demonstrate that faba bean has a comparable protein quality than other legumes and could be used in similar food applications.

Hybrid Spreadable Cheese Analogues with Faba Bean and Mealworm (Tenebrio molitor) Flours: Optimisation Using Desirability-Based Mixture Design.

Hybrid products could help bridge the gap as new alternative diets emerge in response to the demand for less animal protein, while recent studies suggest that the Western population is not yet ready to fully embrace an alternative protein-based diet. This study used a desirability-based mixture design to model hybrid spreadable cheese analogues (SCAs). The design combined milk protein concentrate (MPC), Tenebrio molitor (IF) and faba bean (FBP) flours, representing 7.1% of the formula. Nine SCAs with different MPC/FBP/IF ratios were formulated. Incorporating the IF negatively impacted the desirable texture properties. The FBP flour improved the texture (increasing firmness and stickiness and decreasing spreadability), but only when combined with MPC. Sensory analysis showed that hybrid SCAs (≤50% MPC) C2, C7 and C9 had a more characteristic cheesy flavour than the commercial plant-based reference, and sample C2 had a texture profile similar to the dairy reference. Samples containing IF (C7 and C9) showed a better flavour profile than that without IF (C2). The SCAs had higher protein and lower saturated fat, starch and sugar content than commercial analogues. The study suggests that incorporating alternative proteins in hybrid products can be an effective approach to reduce animal protein content, specifically dairy, in food formulations.

Active Films Based on Faba Bean (Vicia faba L.) Flour Incorporated with Sumac (Rhus coriaria): Assessment of Antioxidant and Antimicrobial Performances of Packaging for Shelf Life of Chicken Breast

Active Films Based on Faba Bean (Vicia faba L.) Flour Incorporated with Sumac (Rhus coriaria): Assessment of Antioxidant and Antimicrobial Performances of Packaging for Shelf Life of Chicken Breast

The flavor of faba bean ingredients and extrudates: Chemical and sensory properties

Faba bean, processed into ingredients (flour, protein concentrate, protein isolate), can be extruded to meat alternatives with a fibrous texture. Despite its importance for consumer acceptance, not enough is known about the flavor of faba bean ingredients nor about the chemical and sensory changes caused by high-moisture extrusion. Therefore, the aim of this work was to describe the flavor of faba bean ingredients and the corresponding extrudates and to understand how their composition affects the perception of sensory attributes. Firstly, faba bean protein ingredients and extrudates were characterized for lipid-degrading enzymatic activities, flavor precursors, and volatile and non-volatile flavor-active compounds. Secondly, sensory profiling was conducted. Thirdly, partial least squares regression was applied to understand the relationship between chemical and sensory data. This study showed that faba bean protein concentrate had the strongest taste and aftertaste (respectively 7 and 6, on a 0–10 intensity scale), bitterness (6–7), and pea flavor and odor (respectively 6 and 5), whereas faba bean protein isolate had the strongest cereal flavor (4) and odor (4), and off-flavor (2) and off-odor (3). Faba bean flour had the mildest flavor. High-moisture extrusion brought several chemical changes to the ingredients, including the formation of several volatile compounds and inactivation of lipid-degrading enzymes. Only traces of tannins were found in extrudates. The presence of free phenolics, vicine, and convicine was linked to strong taste and aftertaste, bitterness, and a drying sensation of the mouth, whereas lipid oxidation products were related to pea, cereal, and off-odors and flavors.

5-Methyltetrahydrofolate Is a Crucial Factor in Determining the Bioaccessibility of Folate in Bread.

This study investigated the bioaccessibility of folate in wheat bread baked with different ingredients and processing methods. Next, different matrices were spiked with 5-methyltetrahydrofolate, gallic acid (GA), or both to investigate the stability of 5-methyltetrahydrofolate during in vitro digestion. The folate bioaccessibility in bread varied from 44 to 96%. The inclusion of whole-grain or faba bean flour significantly improved both folate content and bioaccessibility. Baking with yeast increased the folate content by 145% in bread but decreased folate bioaccessibility compared to the bread without added yeast because of the instability of 5-methyltetrahydrofolate. Spiking experiments confirmed oxidation as a critical reason for 5-methyltetrahydrofolate loss during digestion. However, GA protected this vitamer from degradation. Additionally, 5-methyltetrahydrofolate was less stable in whole-grain wheat matrices than other matrices. This study demonstrated that the stability of 5-methyltetrahydrofolate is crucial for folate bioaccessibility in bread, and methods for stabilizing this vitamer should be further studied.