Ectoine Production Research Articles

Quantitative RNA-seq Analysis Unveils Osmotic and Thermal Adaptation Mechanisms Relevant for Ectoine Production in Chromohalobacter salexigens.

Quantitative RNA sequencing (RNA-seq) and the complementary phenotypic assays were implemented to investigate the transcriptional responses of Chromohalobacter salexigens to osmotic and heat stress. These conditions trigger the synthesis of ectoine and hydroxyectoine, two compatible solutes of biotechnological interest. Our findings revealed that both stresses make a significant impact on C. salexigens global physiology. Apart from compatible solute metabolism, the most relevant adaptation mechanisms were related to “oxidative- and protein-folding- stress responses,” “modulation of respiratory chain and related components,” and “ion homeostasis.” A general salt-dependent induction of genes related to the metabolism of ectoines, as well as repression of ectoine degradation genes by temperature, was observed. Different oxidative stress response mechanisms, secondary or primary, were induced at low and high salinity, respectively, and repressed by temperature. A higher sensitivity to H2O2 was observed at high salinity, regardless of temperature. Low salinity induced genes involved in “protein-folding-stress response,” suggesting disturbance of protein homeostasis. Transcriptional shift of genes encoding three types of respiratory NADH dehydrogenases, ATP synthase, quinone pool, Na+/H+ antiporters, and sodium-solute symporters, was observed depending on salinity and temperature, suggesting modulation of the components of the respiratory chain and additional systems involved in the generation of H+ and/or Na+ gradients. Remarkably, the Na+ intracellular content remained constant regardless of salinity and temperature. Disturbance of Na+- and H+-gradients with specific ionophores suggested that both gradients influence ectoine production, but with differences depending on the solute, salinity, and temperature conditions. Flagellum genes were strongly induced by salinity, and further induced by temperature. However, salt-induced cell motility was reduced at high temperature, possibly caused by an alteration of Na+ permeability by temperature, as dependence of motility on Na+-gradient was observed. The transcriptional induction of genes related to the synthesis and transport of siderophores correlated with a higher siderophore production and intracellular iron content only at low salinity. An excess of iron increased hydroxyectoine accumulation by 20% at high salinity. Conversely, it reduced the intracellular content of ectoines by 50% at high salinity plus high temperature. These findings support the relevance of iron homeostasis for osmoadaptation, thermoadaptation and accumulation of ectoines, in C. salexigens.

Transcriptomic and Ectoine Analysis of Halotolerant Nocardiopsis gilva YIM 90087T Under Salt Stress.

The genus Nocardiopsis is an unique actinobacterial group that widely distributed in hypersaline environments. In this study, we investigated the growth conditions, transcriptome analysis, production and accumulation of ectoine by Nocardiopsis gilva YIM 90087T under salt stress. The colony color of N. gilva YIM 90087T changed from yellow to white under salt stress conditions. Accumulation of ectoine and hydroxyectoine in cells was an efficient way to regulate osmotic pressure. The ectoine synthesis was studied by transferring the related genes (ectA, ectB, and ectC) to Escherichia coli. Transcriptomic analysis showed that the pathways of ABC transporters (ko02010) and glycine, serine, and threonine metabolism (ko00260) played a vital role under salt stress environment. The ectABC from N. gilva YIM 90087T was activated under the salt stress. Addition of exogenous ectoine and hydroxyectoine were helpful to protect N. gilva YIM 90087T from salt stress.

With a pinch of extra salt-Did predatory protists steal genes from their food?

The cellular adjustment of Bacteria and Archaea to high-salinity habitats is well studied and has generally been classified into one of two strategies. These are to accumulate high levels either of ions (the “salt-in” strategy) or of physiologically compliant organic osmolytes, the compatible solutes (the “salt-out” strategy). Halophilic protists are ecophysiological important inhabitants of salt-stressed ecosystems because they are not only very abundant but also represent the majority of eukaryotic lineages in nature. However, their cellular osmostress responses have been largely neglected. Recent reports have now shed new light on this issue using the geographically widely distributed halophilic heterotrophic protists Halocafeteria seosinensis, Pharyngomonas kirbyi, and Schmidingerothrix salinarum as model systems. Different approaches led to the joint conclusion that these unicellular Eukarya use the salt-out strategy to cope successfully with the persistent high salinity in their habitat. They accumulate various compatible solutes, e.g., glycine betaine, myo-inositol, and ectoines. The finding of intron-containing biosynthetic genes for ectoine and hydroxyectoine, their salt stress–responsive transcription in H. seosinensis, and the production of ectoine and its import by S. salinarum come as a considerable surprise because ectoines have thus far been considered exclusive prokaryotic compatible solutes. Phylogenetic considerations of the ectoine/hydroxyectoine biosynthetic genes of H. seosinensis suggest that they have been acquired via lateral gene transfer by these bacterivorous Eukarya from ectoine/hydroxyectoine-producing food bacteria that populate the same habitat.

Production and characterization of ectoine using a moderately halophilic strain Halomonas salina BCRC17875

This study attempted to utilize Halomonas salina BCRC17875 to produce ectoine by optimizing the agitation speed and medium composition. In addition, the chemical structure of ectoine produced by H.salina BCRC17875 was determined. The results indicate that ectoine production reached 3.65g/L at 38h of cultivation when the agitation rate and NaCl concentration were fixed at 200rpm and 2.0M, respectively. It reached 9.20g/L at 44h of cultivation when the major medium components were yeast extract (56g/L), glutamate (74.40g/L), and ammonium sulfate (14g/L). After the nitrogen concentration had been evaluated, evaluation of the nitrogen concentration revealed that the ectoine production reached 11.80g/L at 44h of cultivation when 56g/L of yeast extract and 28g/L of ammonium sulfate were used. Ectoine production reached 13.96g/L at 44h of cultivation when the carbon/nitrogen ratio was fixed at 3/1 using 84g/L of yeast extract and 28g/L of ammonium sulfate. Furthermore, the identification of ectoine were identified and characterized by fast atom bombardment mass spectrometry (FAB-MS) and 1H NMR. The results demonstrated a fermentation strategy was successful in increasing ectoine production, and that the fermentation medium of ectoine had commercialization potential.

Insights into metabolic osmoadaptation of the ectoines-producer bacterium Chromohalobacter salexigens through a high-quality genome scale metabolic model

BackgroundThe halophilic bacterium Chromohalobacter salexigens is a natural producer of ectoines, compatible solutes with current and potential biotechnological applications. As production of ectoines is an osmoregulated process that draws away TCA intermediates, bacterial metabolism needs to be adapted to cope with salinity changes. To explore and use C. salexigens as cell factory for ectoine(s) production, a comprehensive knowledge at the systems level of its metabolism is essential. For this purpose, the construction of a robust and high-quality genome-based metabolic model of C. salexigens was approached.ResultsWe generated and validated a high quality genome-based C. salexigens metabolic model (iFP764). This comprised an exhaustive reconstruction process based on experimental information, analysis of genome sequence, manual re-annotation of metabolic genes, and in-depth refinement. The model included three compartments (periplasmic, cytoplasmic and external medium), and two salinity-specific biomass compositions, partially based on experimental results from C. salexigens. Using previous metabolic data as constraints, the metabolic model allowed us to simulate and analyse the metabolic osmoadaptation of C. salexigens under conditions for low and high production of ectoines. The iFP764 model was able to reproduce the major metabolic features of C. salexigens. Flux Balance Analysis (FBA) and Monte Carlo Random sampling analysis showed salinity-specific essential metabolic genes and different distribution of fluxes and variation in the patterns of correlation of reaction sets belonging to central C and N metabolism, in response to salinity. Some of them were related to bioenergetics or production of reducing equivalents, and probably related to demand for ectoines. Ectoines metabolic reactions were distributed according to its correlation in four modules. Interestingly, the four modules were independent both at low and high salinity conditions, as they did not correlate to each other, and they were not correlated with other subsystems.ConclusionsOur validated model is one of the most complete curated networks of halophilic bacteria. It is a powerful tool to simulate and explore C. salexigens metabolism at low and high salinity conditions, driving to low and high production of ectoines. In addition, it can be useful to optimize the metabolism of other halophilic bacteria for metabolite production.

Tinkering with Osmotically Controlled Transcription Allows Enhanced Production and Excretion of Ectoine and Hydroxyectoine from a Microbial Cell Factory.

Ectoine and hydroxyectoine are widely synthesized by members of the Bacteria and a few members of the Archaea as potent osmostress protectants. We have studied the salient features of the osmostress-responsive promoter directing the transcription of the ectoine/hydroxyectoine biosynthetic gene cluster from the plant-root-associated bacterium Pseudomonas stutzeri by transferring it into Escherichia coli, an enterobacterium that does not produce ectoines naturally. Using ect-lacZ reporter fusions, we found that the heterologous ect promoter reacted with exquisite sensitivity in its transcriptional profile to graded increases in sustained high salinity, responded to a true osmotic signal, and required the buildup of an osmotically effective gradient across the cytoplasmic membrane for its induction. The involvement of the -10, -35, and spacer regions of the sigma-70-type ect promoter in setting promoter strength and response to osmotic stress was assessed through site-directed mutagenesis. Moderate changes in the ect promoter sequence that increase its resemblance to housekeeping sigma-70-type promoters of E. coli afforded substantially enhanced expression, both in the absence and in the presence of osmotic stress. Building on this set of ect promoter mutants, we engineered an E. coli chassis strain for the heterologous production of ectoines. This synthetic cell factory lacks the genes for the osmostress-responsive synthesis of trehalose and the compatible solute importers ProP and ProU, and it continuously excretes ectoines into the growth medium. By combining appropriate host strains and different plasmid variants, excretion of ectoine, hydroxyectoine, or a mixture of both compounds was achieved under mild osmotic stress conditions.IMPORTANCE Ectoines are compatible solutes, organic osmolytes that are used by microorganisms to fend off the negative consequences of high environmental osmolarity on cellular physiology. An understanding of the salient features of osmostress-responsive promoters directing the expression of the ectoine/hydroxyectoine biosynthetic gene clusters is lacking. We exploited the ect promoter from an ectoine/hydroxyectoine-producing soil bacterium for such a study by transferring it into a surrogate bacterial host. Despite the fact that E. coli does not synthesize ectoines naturally, the ect promoter retained its exquisitely sensitive osmotic control, indicating that osmoregulation of ect transcription is an inherent feature of the promoter and its flanking sequences. These sequences were narrowed to a 116-bp DNA fragment. Ectoines have interesting commercial applications. Building on data from a site-directed mutagenesis study of the ect promoter, we designed a synthetic cell factory that secretes ectoine, hydroxyectoine, or a mixture of both compounds into the growth medium.

Response surface method optimization of ectoine fermentation medium with moderate halophilic bacteria Halomonas sp. H02

Moderate halophilic bacteria are of halophilic bacteria whose suitable growth of NaCl is 5-10%. When the moderate halophilic bacteria response to high osmotic stress, the intracellular will synthesize small organic molecule compatible solutes. Ectoine, which is the major synthetic osmotic compatible solutes for moderate halophilic bacteria, can help microbial enzymes, nucleic acids and the whole cell resist to hypertonic, high temperature, freezing and other inverse environment. In order to increase the Ectoine production of Moderate halophilic bacteria Halomonas sp. H02, the Ectoine fermentation medium component was optimized by Plackett-Burman (PB) and Response Surface Methodology (RSM) based on the principle of non-complete equilibrium The results of PB experiments showed that the three main influencing factors of Moderate halophilic bacteria Halomonas sp. H02 synthesis Ectoine culture medium were C5H8NNaO4 concentration, NaCl concentration and initial pH. According to the center point of the steepest climbing experiment, the central combination design experiment was used to show that the model is consistent with the actual situation. The optimum combination of three influencing factors were C5H8NNaO4 41 g/L, NaCl 87.2 g/L and initial pH 5.9, and the predicted amount of Ectoine was 1835.8 mg/L, increased by 41.6%.

Improved fermentative production of the compatible solute ectoine by Corynebacterium glutamicum from glucose and alternative carbon sources

The cyclic amino acid ectoine is a compatible solute serving as a protective substance against osmotic stress. Ectoine finds various applications due to its moisturizing effect. To avoid the disadvantages of the prevailing so-called “bacterial milking ectoine production process” caused by the high salt concentration, low salt fermentation strategies are sought after. As l-lysine and ectoine biosynthesis share l-aspartate-semialdehyde as common precursor, l-lysine producing strains can be converted to ectoine producing strains. Corynebacterium glutamicum, which is used for l-lysine production in the million-ton-scale, was engineered for ectoine production by heterologous expression of the ectoine biosynthesis operon ectABC from Chromohalobacter salexigens. Derepression of glucose metabolism by deletion of the regulatory gene sugR and avoiding l-lactate formation by deletion of the lactate dehydrogenase gene ldhA increased ectoine productivity. In bioreactor fed-batch cultivations an ectoine titer of 22gL−1 and a volumetric productivity of 0.32gL−1h−1 were obtained. The ectoine yield of 0.16gg−1, to the best of our knowledge, exceeded previously reported yields. Moreover, ectoine production from the alternative carbon sources glycerol, glucosamine, xylose, arabinose, and soluble starch was achieved.

Continuous abatement of methane coupled with ectoine production by Methylomicrobium alcaliphilum 20Z in stirred tank reactors: A step further towards greenhouse gas biorefineries

This study demonstrates for the first time the feasibility of producing ectoine (a high added value osmoprotectant intensively used in the cosmetic industry) during the continuous abatement of diluted emissions of methane by Methylomicrobium alcaliphilum 20Z in stirred tank reactors under non-sterile conditions. An increase in NaCl concentration in the cultivation broth from 3 to 6% increased the intra-cellular ectoine yield by a factor of 2 (from 16.5 to 37.4 mg ectoine (g biomass)−1), while high stirring rates (600 rpm) entailed a detrimental cellular stress and 3 times lower ectoine yields (5.6 mg ectoine (g biomass)−1) compared to process operation at 300 rpm. An increase in Cu2+ concentration from 0.05 to 25 μM enhanced methane abatement by a factor of 2 (up to elimination capacities of 24.5 g m−3 h−1), did not enhance intra-cellular ectoine production but promoted the excretion to the cultivation broth of 20% of the total ectoine synthesized regardless of the NaCl concentration and stirring rate. The results obtained by culture hybridization with the specific probe Mγ1004 showed that Methylomicrobium alcaliphilum 20Z accounted for more than 80% of the total bacterial population in most experimental runs. This work confirmed the technical feasibility of a new generation of biorefineries based on the abatement of diluted CH4 emissions using extremophile methanotrophs.

Understanding the interplay of carbon and nitrogen supply for ectoines production and metabolic overflow in high density cultures of Chromohalobacter salexigens

BackgroundThe halophilic bacterium Chromohalobacter salexigens has been proposed as promising cell factory for the production of the compatible solutes ectoine and hydroxyectoine. This bacterium has evolved metabolic adaptations to efficiently grow under high salt concentrations by accumulating ectoines as compatible solutes. However, metabolic overflow, which is a major drawback for the efficient conversion of biological feedstocks, occurs as a result of metabolic unbalances during growth and ectoines production. Optimal production of ectoines is conditioned by the interplay of carbon and nitrogen metabolisms. In this work, we set out to determine how nitrogen supply affects the production of ectoines.ResultsChromohalobacter salexigens was challenged to grow in media with unbalanced carbon/nitrogen ratio. In C. salexigens, overflow metabolism and ectoines production are a function of medium composition. At low ammonium conditions, the growth rate decreased importantly, up to 80%. Shifts in overflow metabolism were observed when changing the C/N ratio in the culture medium. 13C-NMR analysis of ectoines labelling revealed a high metabolic rigidity, with almost constant flux ratios in all conditions assayed. Unbalanced C/N ratio led to pyruvate accumulation, especially upon N-limitation. Analysis of an ect− mutant demonstrated the link between metabolic overflow and ectoine biosynthesis. Under non ectoine synthesizing conditions, glucose uptake and metabolic overflow decreased importantly. Finally, in fed-batch cultures, biomass yield was affected by the feeding scheme chosen. High growth (up to 42.4 g L−1) and volumetric ectoine yields (up to 4.21 g L−1) were obtained by minimizing metabolite overflow and nutrient accumulation in high density cultures in a low nitrogen fed-batch culture. Moreover, the yield coefficient calculated for the transformation of glucose into biomass was 30% higher in fed-batch than in the batch culture, demonstrating that the metabolic efficiency of C. salexigens can be improved by careful design of culture feeding schemes.ConclusionsMetabolic shifts observed at low ammonium concentrations were explained by a shift in the energy required for nitrogen assimilation. Carbon-limited fed-batch cultures with reduced ammonium supply were the best conditions for cultivation of C. salexigens, supporting high density growth and maintaining high ectoines production.

Valorization of CH4 emissions into high-added-value products: Assessing the production of ectoine coupled with CH4 abatement

This study assessed an innovative strategy for the valorization of dilute methane emissions based on the bio-conversion of CH4 (the second most important greenhouse gas (GHG)) into ectoine by the methanotrophic ectoine-producing strain Methylomicrobium alcaliphilum 20 Z. The influence of CH4 (2–20%), Cu2+ (0.05–50 μM) and NaCl (0–9%) concentration as well as temperature (25–35 °C) on ectoine synthesis and specific CH4 biodegradation rate was evaluated for the first time. Concentrations of 20% CH4 (at 3% NaCl, 0.05 μM Cu2+, 25 °C) and 6% NaCl (at 4% CH4, 0.05 μM Cu2+, 25 °C) supported the maximum intra-cellular ectoine production yield (31.0 ±1.7 and 66.9 ±4.2 mg g biomass−1, respectively). On the other hand, extra-cellular ectoine concentrations of up to 4.7 ± 0.1 mg L−1 were detected at high Cu2+concentrations (50 μM), despite this methanotroph has not been previously classified as an ectoine-excreting strain. This research demonstrated the feasibility of the bio-conversion of dilute emissions of methane into high-added value products in an attempt to develop a sustainable GHG bioeconomy.

Osmotic Stress Confers Enhanced Cell Integrity to Hydrostatic Pressure but Impairs Growth in Alcanivorax borkumensis SK2.

Alcanivorax is a hydrocarbonoclastic genus dominating oil spills worldwide. While its presence has been detected in oil-polluted seawaters, marine sediment and salt marshes under ambient pressure, its presence in deep-sea oil-contaminated environments is negligible. Recent laboratory studies highlighted the piezosensitive nature of some Alcanivorax species, whose growth yields are highly impacted by mild hydrostatic pressures (HPs). In the present study, osmotic stress was used as a tool to increase HP resistance in the type strain Alcanivorax borkumensis SK2. Control cultures grown under standard conditions of salinity and osmotic pressure with respect to seawater (35.6 ppt or 1136 mOsm kg-1, respectively) were compared with cultures subjected to hypo- and hyperosmosis (330 and 1720 mOsm kg-1, or 18 and 62 ppt in salinity, equivalent to brackish and brine waters, respectively), under atmospheric or increased HP (0.1 and 10 MPa). Osmotic stress had a remarkably positive impact on cell metabolic activity in terms of CO2 production (thus, oil bioremediation) and O2 respiration under hyperosmosis, as acclimation to high salinity enhanced cell activity under 10 MPa by a factor of 10. Both osmotic shocks significantly enhanced cell protection by reducing membrane damage under HP, with cell integrities close to 100% under hyposmosis. The latter was likely due to intracellular water-reclamation as no trace of the piezolyte ectoine was found, contrary to hyperosmosis. Notably, ectoine production was equivalent at 0.1 MPa in hyperosmosis-acclimated cells and at 10 MPa under isosmotic conditions. While stimulating cell metabolism and enhancing cell integrity, osmotic stress had always a negative impact on culture growth and performance. No net growth was observed during 4-days incubation tests, and CO2:O2 ratios and pH values indicated that culture performance in terms of hydrocarbon degradation was lowered by the effects of osmotic stress alone or combined with increased HP. These findings confirm the piezosensitive nature of A. borkumensis, which lacks proper resistance mechanisms to improve its metabolic efficiency under increased HP, thus explaining its limited role in oil-polluted deep-sea environments.

Improvement of ectoine productivity by using sugar transporter-overexpressing Halomonas elongata.

We successfully enhanced the productivity of ectoine with Halomonas elongata by improvement of the transport of sugar. First, we carried out screening for sugar transporters capable of improving glucose and xylose consumption. We found two transporters: b3657 from Escherichia coli, which is capable of improving glucose consumption, and HEO_0208 from H. elongata, which is capable of improving xylose consumption. Using transporter-overexpressing strains, the productivity of ectoine was improved. These results indicate that sugar consumption is important for efficient ectoine production. As result of phenotypic analysis of a HEO_0208 deletion strain, we discovered that HEO_0208 is the major xylose transporter in H. elongata. This is the first report demonstrating improvement of ectoine productivity by enhancing the transport of sugar.

Biochemistry and Crystal Structure of Ectoine Synthase: A Metal-Containing Member of the Cupin Superfamily.

Ectoine is a compatible solute and chemical chaperone widely used by members of the Bacteria and a few Archaea to fend-off the detrimental effects of high external osmolarity on cellular physiology and growth. Ectoine synthase (EctC) catalyzes the last step in ectoine production and mediates the ring closure of the substrate N-gamma-acetyl-L-2,4-diaminobutyric acid through a water elimination reaction. However, the crystal structure of ectoine synthase is not known and a clear understanding of how its fold contributes to enzyme activity is thus lacking. Using the ectoine synthase from the cold-adapted marine bacterium Sphingopyxis alaskensis (Sa), we report here both a detailed biochemical characterization of the EctC enzyme and the high-resolution crystal structure of its apo-form. Structural analysis classified the (Sa)EctC protein as a member of the cupin superfamily. EctC forms a dimer with a head-to-tail arrangement, both in solution and in the crystal structure. The interface of the dimer assembly is shaped through backbone-contacts and weak hydrophobic interactions mediated by two beta-sheets within each monomer. We show for the first time that ectoine synthase harbors a catalytically important metal co-factor; metal depletion and reconstitution experiments suggest that EctC is probably an iron-dependent enzyme. We found that EctC not only effectively converts its natural substrate N-gamma-acetyl-L-2,4-diaminobutyric acid into ectoine through a cyclocondensation reaction, but that it can also use the isomer N-alpha-acetyl-L-2,4-diaminobutyric acid as its substrate, albeit with substantially reduced catalytic efficiency. Structure-guided site-directed mutagenesis experiments targeting amino acid residues that are evolutionarily highly conserved among the extended EctC protein family, including those forming the presumptive iron-binding site, were conducted to functionally analyze the properties of the resulting EctC variants. An assessment of enzyme activity and iron content of these mutants give important clues for understanding the architecture of the active site positioned within the core of the EctC cupin barrel.

Pathway construction and metabolic engineering for fermentative production of ectoine in Escherichia coli

Ectoine is a protective agent and stabilizer whose synthesis pathway exclusively exists in select moderate halophiles. A novel established process called “bacterial milking” efficiently synthesized ectoine in moderate halophiles, however, this method places high demands on equipment and is cost prohibitive. In this study, we constructed an ectoine producing strain by introducing the ectoine synthesis pathway into Escherichia coli and improved its production capacity. Firstly, the ectABC gene cluster from Halomonas elongata was introduced into E. coli W3110 and the resultant strain synthesized 4.9g/L ectoine without high osmolarity. Subsequently, thrA encoding the bifunctional aspartokinase/homoserine dehydrogenase was deleted to weaken the competitive l-threonine branch, resulting in an increase of ectoine titer by 109%. Furthermore, a feedback resistant lysC from Corynebacterium glutamicum encoding the aspartate kinase was introduced to complement the enzymatic activity deficiency caused by thrA deletion and a 9% increase of ectoine titer was obtained. Finally, the promoter of ppc that encodes phosphoenolpyruvate carboxylase was replaced by a trc promoter, and iclR, a glyoxylate shunt transcriptional repressor gene, was deleted. The oxaloacetate pool, was thus reinforced and ectoine titer increased by 21%. The final engineered strain ECT05 (pTrcECT, pSTVLysC-CG) produced 25.1g/L ectoine by fed-batch fermentation in low salt concentration with glucose as a carbon source. The specific ectoine production and productivity was 0.8g/g DCW and 0.84gL−1h−1 respectively. The overall ectoine yield was 0.11g/g of glucose.

Strangers in the archaeal world: osmostress-responsive biosynthesis of ectoine and hydroxyectoine by the marine thaumarchaeon Nitrosopumilus maritimus.

Ectoine and hydroxyectoine are compatible solutes widely synthesized by members of the Bacteria to cope with high osmolarity surroundings. Inspection of 557 archaeal genomes revealed that only 12 strains affiliated with the Nitrosopumilus, Methanothrix or Methanobacterium genera harbour ectoine/hydroxyectoine gene clusters. Phylogenetic considerations suggest that these Archaea have acquired these genes through horizontal gene transfer events. Using the Thaumarchaeon 'Candidatus Nitrosopumilus maritimus' as an example, we demonstrate that the transcription of its ectABCD genes is osmotically induced and functional since it leads to the production of both ectoine and hydroxyectoine. The ectoine synthase and the ectoine hydroxylase were biochemically characterized, and their properties resemble those of their counterparts from Bacteria. Transcriptional analysis of osmotically stressed 'Ca. N. maritimus' cells demonstrated that they possess an ectoine/hydroxyectoine gene cluster (hyp-ectABCD-mscS) different from those recognized previously since it contains a gene for an MscS-type mechanosensitive channel. Complementation experiments with an Escherichia coli mutant lacking all known mechanosensitive channel proteins demonstrated that the (Nm)MscS protein is functional. Hence, 'Ca. N. maritimus' cells cope with high salinity not only through enhanced synthesis of osmostress-protective ectoines but they already prepare themselves simultaneously for an eventually occurring osmotic down-shock by enhancing the production of a safety-valve (NmMscS).

GlnR-Mediated Regulation of ectABCD Transcription Expands the Role of the GlnR Regulon to Osmotic Stress Management.

Ectoine and hydroxyectoine are excellent compatible solutes for bacteria to deal with environmental osmotic stress and temperature damages. The biosynthesis cluster of ectoine and hydroxyectoine is widespread among microorganisms, and its expression is activated by high salinity and temperature changes. So far, little is known about the mechanism of the regulation of the transcription of ect genes and only two MarR family regulators (EctR1 in methylobacteria and the EctR1-related regulator CosR in Vibrio cholerae) have been found to negatively regulate the expression of ect genes. Here, we characterize GlnR, the global regulator for nitrogen metabolism in actinomycetes, as a negative regulator for the transcription of ectoine/hydroxyectoine biosynthetic genes (ect operon) in Streptomyces coelicolor. The physiological role of this transcriptional repression by GlnR is proposed to protect the intracellular glutamate pool, which acts as a key nitrogen donor for both the nitrogen metabolism and the ectoine/hydroxyectoine biosynthesis. High salinity is deleterious, and cells must evolve sophisticated mechanisms to cope with this osmotic stress. Although production of ectoine and hydroxyectoine is one of the most frequently adopted strategies, the in-depth mechanism of regulation of their biosynthesis is less understood. So far, only two MarR family negative regulators, EctR1 and CosR, have been identified in methylobacteria and Vibrio, respectively. Here, our work demonstrates that GlnR, the global regulator for nitrogen metabolism, is a negative transcriptional regulator for ect genes in Streptomyces coelicolor. Moreover, a close relationship is found between nitrogen metabolism and osmotic resistance, and GlnR-mediated regulation of ect transcription is proposed to protect the intracellular glutamate pool. Meanwhile, the work reveals the multiple roles of GlnR in bacterial physiology.

Design of an ectoine-responsive AraC mutant and its application in metabolic engineering of ectoine biosynthesis

Advanced high-throughput screening methods for small molecules may have important applications in the metabolic engineering of the biosynthetic pathways of these molecules. Ectoine is an excellent osmoprotectant that has been widely used in cosmetics. In this study, the Escherichia coli regulatory protein AraC was engineered to recognize ectoine as its non-natural effector and to activate transcription upon ectoine binding. As an endogenous reporter of ectoine, the mutated AraC protein was successfully incorporated into high-throughput screening of ectoine hyper-producing strains. The ectoine biosynthetic cluster from Halomonas elongata was cloned into E. coli. By engineering the rate-limiting enzyme l-2,4-diaminobutyric acid (DABA) aminotransferase (EctB), ectoine production and the specific activity of the EctB mutant were increased. Thus, these results demonstrated the effectiveness of engineering regulatory proteins into sensitive and rapid screening tools for small molecules and highlighted the importance and efficacy of directed evolution strategies applied to the engineering of genetic components for yield improvement in the biosynthesis of small molecules.

High production of ectoine from aspartate and glycerol by use of whole-cell biocatalysis in recombinant Escherichia coli

BackgroundRecently, the compatible solute 1, 4, 5, 6-tetrahydro-2-methyl-4-pyrimidinecarboxylic acid (ectoine) has attracted considerable interest due to its great potential as a protecting agent. To overcome the drawbacks of high salinity in the traditional bioprocess of ectoine using halophilic bacteria, various attempts have been made to engineer ectoine biosynthesis in nonhalophilic bacteria. Unfortunately, the yields of ectoine in these producers are still low and hardly meet the demands of large scale production. In this paper, the whole-cell biocatalytic process using aspartate and glycerol as substrates was tried for high production of ectoine in nonhalophilic bacteria.ResultsThe ectoine genes ectABC from the halophilic bacterium Halomonas elongata were successfully introduced into Escherichia coli K-12 strain BW25113 under the arabinose-inducible promoter. To our delight, a large amount of ectoine was synthesized and excreted into the medium during the course of whole-cell biocatalysis, when using aspartate and glycerol as the direct substrates. At the low cell density of 5 OD/mL in flask, under the optimal conditions (100 mM sodium phosphate buffer (pH 7.0), 100 mM sodium aspartate, 100 mM KCl and 100 mM glycerol), the concentration of extracellular ectoine was increased to 2.67 mg/mL. At the high cell density of 20 OD/mL in fermentor, a maximum titre of 25.1 g/L ectoine was achieved in 24 h. Meanwhile, the biomass productivity of ectoine is as high as 4048 mg per gram dry cell weight (g DCW)−1, which is the highest value ever reported. Furthermore, it was demonstrated that the same batch of cells could be used for at least three rounds. Finally, a total yield of 63.4 g ectoine was obtained using one litre cells.ConclusionUsing aspartate and glycerol as the direct substrates, high production of ectoine was achieved by the whole-cell biocatalysis in recombinant E. coli. Multiple rounds of whole-cell biocatalysis were established to further improve the production of ectoine. Our study herein provided a feasible biosynthesis process of ectoine with potential applications in large-scale industrial production.

Contribution of RpoS to metabolic efficiency and ectoines synthesis during the osmo- and heat-stress response in the halophilic bacterium Chromohalobacter salexigens.

Chromohalobacter salexigens is a halophilic γ-proteobacterium that responds to osmotic and heat stresses by accumulating ectoine and hydroxyectoine respectively. Evolution has optimized its metabolism to support high production of ectoines. We analysed the effect of an rpoS mutation in C. salexigens metabolism and ectoines synthesis. In long-term adapted cells, the rpoS strain was osmosensitive but not thermosensitive and showed unaltered ectoines content, suggesting that RpoS regulates ectoine(s)-independent osmoadaptive mechanisms. RpoS is involved in the regulation of C. salexigens metabolic adaptation to stress, as early steps of glucose oxidation through the Entner-Doudoroff pathway were deregulated in the rpoS mutant, leading to improved metabolic efficiency at low salinity. Moreover, a reduced pyruvate (but not acetate) overflow was displayed by the rpoS strain at low salt, probably linked to a slowdown in gluconate production and/or subsequent metabolism. Interestingly, RpoS does not seem to be the main regulator triggering the immediate transcriptional response of ectoine synthesis to osmotic or thermal upshifts. However, it contributed to the expression of the ect genes in cells previously adapted to low or high salinity.