Dynamic Bubble Trap Research Articles

Design and 3D-model of a dynamic bubble trap for cardiopulmonary bypass

The use of extracorporeal circulation systems (cardiopulmonary bypass pumps, ECMO) can lead to brain and coronary artery microembolism, which significantly reduces postoperative rehabilitation and often leads to severe complications. Microembolism occurs when oxygen or air microbubbles (MBs) enter the arterial system of patients. Existing CPB pumps come with built-in bubble trap systems but cannot remove bubbles in the circuit. ECMO devices have arterial filters but cannot reliably filter out <40 μm bubbles in a wide flow range. We have proposed an alternative method that involves the use of an efficient dynamic bubble trap (DBT) for both large and small bubbles. The design includes development of two DBT variants for hemodynamic conditions of adult and pediatric patients. The device is installed in the CPB pump and ECMO outlet lines. It provides sufficient bubble separation from the lines in a blood flow of 3.0–5.0 L/min for adults and 0.5–2.0 L/min for children. The developed computer models have shown that MBs smaller than 10 μm can be filtered. The use of this device will greatly reduce the likelihood of air embolism and provide the opportunity to reconsider the concept of expensive arterial filters.

Neuroprotective effects of dynamic bubble trap use in patients undergoing pulmonary endarterectomy: a two-arm randomized controlled trial.

BackgroundDuring cardiosurgical procedures that use extracorporeal circulation (ECC), a variety of neurological complications can occur, and postoperative cognitive deficits remain an unsolved problem. Among the sources of these complications are intraoperatively detectable cerebral microemboli, which mainly consist of air. This study’s purpose was to assess neuroprotective effects of reducing these gaseous microemboli using a dynamic bubble trap (DBT) in patients undergoing pulmonary endarterectomy (PEA) for the treatment of chronic thromboembolic pulmonary hypertension (CTEPH).MethodsPatients undergoing PEA were randomly assigned to receive either a DBT (n=47) or no additional device (controls, n=46) during ECC. Neuropsychological testing was performed before and 3 months after PEA. The primary endpoint was cognitive improvement in the DBT group (n=29) compared with the control group (n=42). As secondary endpoint, ischemic brain micro-lesions were analyzed on postoperative days 6 through 10 using diffusion-weighted magnetic resonance imaging (MRI).ResultsAnalysis of interaction effects revealed improved performance in visual long-term memory (P=0.008, η2=0.099), verbal long-term memory (P=0.030, η2=0.067), verbal short-term memory (P=0.014, η2=0.083), and attention and processing speed (P=0.043, η2=0.056) from pre- to post-testing in the DBT group compared to control group. In MRI, postoperative ischemic micro-lesions could only be detected in one patient; another patient suffered a severe bihemispheric embolic stroke.ConclusionsDBT positively influences memory function after PEA. This effect is most likely caused by the reduction of gaseous microemboli.Trial RegistrationThis study is registered in the German Clinical Trials Register, ID: DRKS00021499.

Optimization of micro bubble elimination by the use of an oxygenator with an integrated arterial filter in combination with the dynamic bubble trap

Objectives: The occurrence of micro bubbles in the extracorporeal circuit is often described as a negative effect of the heart-lung machine. New oxygenators with integrated arterial filter shall to improve the elimination of micro bubbles. In addition to a previous study analysing the micro bubble elimination by an oxygenator with an integrated arterial filter and an oxygenator without integrated arterial filter in combination with a dynamic bubble trap, we studied the micro bubble elimination of an oxygenator with an integrated arterial filter in combination with a dynamic bubble trap (DBT).

Protecting the brain from gaseous and solid micro-emboli during coronary artery bypass grafting: a randomized controlled trial

The purpose of the study was to investigate whether intra-operative filter devices protect the brain during coronary artery bypass grafting (CABG) and to determine the impact of solid and gaseous micro-emboli on neuropsychological functioning. Patients undergoing CABG received either an intra-aortic filter (Embol-X) (n = 43), designed to reduce solid micro-emboli, a dynamic bubble trap (DBT) (n = 50), designed to reduce gaseous micro-emboli, or no additional device (control group) (n = 50). Cognitive functioning was assessed before and 3 months after CABG. Micro-emboli signals (MES) were detected during surgery using transcranial Doppler (TCD) sonography. Cerebral magnetic resonance imaging (MRI) was carried out before and after surgery. Primary endpoint was the cognitive outcome of the filter groups compared with the controls. Analysis of covariance was performed using the post-operative cognitive test scores as continuous variables in covariance of the corresponding pre-operative scores. Secondary endpoints were the MES rates and the number of acute ischaemic lesions after CABG. Compared with the controls, cognitive functioning of the DBT group was better in executive functioning (t = 2.525, P = 0.0065) and verbal short-term memory (t = 2.420, P = 0.009). The Embol-X group did not perform better in any test. The total number of MES was lower in the DBT group (median 99, P = 0.0019), but not in the Embol-X group (median 162.5, P > 0.05), both compared with controls (median 164.5). After surgery, 17 patients displayed small ischaemic brain lesions on MRI with equal distribution between the groups. Gaseous micro-embolization contributes to neuropsychological decline, which is measurable 3 months post-operatively. No filter device could protect the brain during CABG completely. However, the use of the DBT tends to improve the cognitive outcome after CABG. Gas filters are recommendable for neuroprotection during cardiac surgery.

Dynamic bubble trap can replace an arterial filter during cardiopulmonary bypass surgery

The arterial filter (AF) and the dynamic bubble trap (DBT) reduce the number of air microbubbles passing through these devices. The aim of the study was to confirm that the DBT diminishes microbubbles in the arterial line similar to, or better than, the AF, and can replace it. In a clinical study, we evaluated 60 patients undergoing cardiopulmonary bypass surgery, divided into two groups (30 patients each). In the first group, we used an open extracorporeal system, and in the second group, a closed system. For 15 patients in each group, the AF was incorporated, the other 15 patients received the DBT. The microbubbles were counted before and after the AF or DBT, using two-channel-ultrasonic Doppler devices. The exposure of patients to small bubbles (< 45 microm) is significantly higher in the AF than in the DBT group. The DBT reduces large bubbles (> 45 microm) better than the AF, with a rate exceeding 16%. The use of the DBT instead of the AF yields higher air microbubble removal efficacy, allowing replacement of the AF, assuming the AF is used for air removal purpose only.

Use of a dynamic bubble trap in the arterial line reduces microbubbles during cardiopulmonary bypass and microembolic signals in the middle cerebral artery

Neurological complications remain an important cause of morbidity and mortality of patients following cardiopulmonary bypass (CPB). Microemboli, as well as cerebral hypoperfusion, are the main postulated mechanisms. This study demonstrates that the insertion of a dynamic bubble trap (DBT) into the curcuit reduces microbubbles in the arterial line and microembolic signals (MES) in the middle cerebral arteries (MCAs). We investigated 12 patients during coronary artery bypass grafting (CABG). The DBT was inserted between the arterial filter and the arterial cannula. For detection of microemboli before and after the DBT, a special ultrasound Doppler device was used. MES were detected by transcranial Doppler monitoring in both MCAs of the patients. Microbubbles and MES were counted during bypass. These data were compared to 12 patients who were operated in a previous period without the use of a DBT. There were no significant differences in both groups with respect to gender, age, crossclamp and bypass time and number of anastomoses. In the group without a DBT in the circuit, a mean of 6311 microbubbles per operation could be observed distal to the arterial filter, corresponding to 282 MES. After inclusion of a DBT, we could register, in the second group, 8496 microemboli proximal and 2915 distal of the DBT, corresponding to 89 MES per operation. The reduction rate of microbubbles in the tubing was 65.7%, corresponding to a reduction in MES of about 86.2%. We conclude that the insertion of a DBT in the arterial line of CPB circuit protects the cerebrovascular system from microembolic events, as demonstrated by lower MES counts.

Application of dynamic bubble trap in coronary artery bypass with cardiopulmonary bypass: an initial study

To investigate the effectiveness of dynamic bubble trap (DBT) on air microbubble elimination from both the cardiopulmonary bypass (CPB) circuit and middle cerebral arteries, and evaluate its possible impact on blood cells and coagulatory function. Twenty patients undergoing coronary artery bypass graft (CABG), 12 males and 8 females, with similar perioperative data were assigned randomly to DBT group and control group. Each CABG was finished with identical circuit sets except the integration of a DBT between the arterial filtrator and the aortic cannula in the DBT group. Air microbubbles were detected before and after the integration of DBT with ultrasonographic detector and microembolism signals (MES) in middle cerebral arteries were counted by transcranial Doppler (TCD). Plasma free hemoglobin (PFH), lactate dehydrogenase (LDH), fibrinogen, platelet count, coagulation factor II and anti-thrombin III (ATIII) were also assayed respectively before the operation, at the termination of CPB, and 6 hours after the operation. In the DBT group the microbubbles of different size could be expelled significantly with the clearance rates between 68% - 74% (10 - 120 microm bubbles), 79% - 81% (20 - 120 microm bubbles), and 88% - 96% (40 - 120 microm bubbles). During the total CPB phase, the mean number of MES reached 197 +/- 137 in the control group and 158 +/- 178 in the DBT group, without a significant difference between these 2 groups. The PFH and LDH levels raised while the platelet count, fibrinogen level, and coagulation factor II and AT III activities decreased sharply after CPB in these 2 groups, however without significant differences in these parameters between the two groups. DBT integration into the CPB circuit enhances neither blood cell damage nor coagulation disturbance. DBT effectively eliminates air microbubbles in arterial conduit; however, its microembolus elimination function is prone to die down during the total period of CPB.

The dynamic air bubble trap reduces cerebral microembolism during cardiopulmonary bypass

Objective Neuropsychologic disorders are common after coronary artery bypass operations. Air microbubbles are identified as a contributing factor. A dynamic bubble trap might reduce the number of gaseous microemboli. Methods A total of 50 patients undergoing coronary artery bypass operation were recruited for this study. In 26 patients a dynamic bubble trap was placed between the arterial filter and the aortic cannula (group 1), and in 24 patients a placebo dynamic bubble trap was used (group 2). The number of high-intensity transient signals within the proximal middle cerebral artery was continuously measured on both sides during bypass, which was separated into 4 periods: phase 1, start of bypass until aortic clamping; phase 2, aortic clamping until rewarming; phase 3, rewarming until clamp removal; and phase 4, clamp removal until end of bypass. S100β values were measured before, immediately after, and 6 and 48 hours after the operation and before hospital discharge. Results The bubble elimination rate during bypass was 77% in group 1 and 28% in group 2 ( P < .0001). The number of high-intensity signals was lower in group 1 during phase 1 (5.8 ± 7.3 vs 16 ± 15.4, P < .05 vs group 2) and phase 2 (6.9 ± 7.3 vs 24.2 ± 27.3, P < .05 vs group 2) but not during phases 3 and 4. Serum S100β values were equally increased in both groups immediately after the operation. Group 2 patients had higher S100β values 6 hours after the operation and significantly higher S100β values 48 hours after the operation (0.06 ± 0.14 vs 0.18 ± 0.24, P = .0133 vs group 2). Age and S100β values were correlated in group 2 but not in group 1. Conclusion Gaseous microemboli can be removed with a dynamic bubble trap. Subclinical cerebral injury detectable by increases of S100β disappears earlier after surgical intervention.

Significant reduction of air microbubbles with the dynamic bubble trap during cardiopulmonary bypass.

Air microbubbles mostly occur unnoticed during cardiopulmonary bypass and are predominantly responsible for serious postoperative psychoneurological dysfunction. A dynamic bubble trap (DBT), which removes air microbubbles from the arterial blood, was tested in a clinical study. The aim was to evaluate the efficiency of microbubble removal under clinical conditions. As blood passes through the DBT, which is placed in the arterial line between the arterial filter and arterial cannula, it is converted into a rotating stream. The bubbles are directed to the centre of the blood flow and are collected in the distal end of the DBT, from where they are returned to the cardiotomy reservoir. Doppler ultrasonography was used to detect the microbubbles before and after the DBT, and also the number of high-intensity transient signals (HITS) in the right and left middle cerebral artery during extracorporeal circulation. A significant reduction of microbubbles in the arterial line (3,990 before DBT, 537 after, p < 0.001) and HITS in the brain (51 in the DBT group, 77 in the placebo group, p = 0.04) was measured.

A Dynamic Bubble Trap Reduces Microbubbles During Cardiopulmonary Bypass: A Case Study

Microemboli passing to the cerebral circulation during cardiopulmonary bypass can contribute to postoperative neurologic dysfunction. Many studies conclude that air microbubbles predominantly are responsible for this problem. A dynamic bubble trap (DBT) was developed to diminish the number of microbubbles in the arterial line of extracorporeal circulation. The DBT is able to substantially reduce the number of air microbubbles, as shown in two patients undergoing coronary artery bypass grafting, where a high number of microbubbles was assessed. Although a 40-µm arterial filter was used, many bubbles larger than 40 µm occurred in the arterial line. The DBT reduced the number of large microbubbles from 2,267 to 67 in patient 1 and from 897 to 61 in patient 2.