Dual-flow Continuous Culture System Research Articles

PSX-20 The inclusion of a tannin-based product evaluated in a typical feedlot diet under tropical conditions increases the molar proportion of propionate in a dual-flow continuous-culture system

Abstract The objective of the present study was to evaluate increasing levels of a tannin-based product and a monensin (positive control; unique dose) using a dual-flow continuous-culture system. Diets were randomly assigned to ten fermenters in a replicated 5 x 5 Latin square with three, 10-d experimental periods consisting of 7 d for adaptation and 3 d for sample collection. Four different levels were tested independently, resulting in 5 treatments: tannin at levels of 0 (negative control), 0.07, 0.14, and 0.21 (% of DM of the total diet) and monensin as positive control at 28 mg/kg DM. The tannin-based product was a specific blend of tannin and saponins, composed of quebracho and chestnut tannin extracts, SilvaFeed-BX). Diets were prepared as concentrate mixes that were combined with sugarcane bagasse, corn grain, dry distillers grain, citrus pulp, peanut meal, and urea. Liquid and solid flow rates were adjusted to 10 and 5.0%/h, respectively. Samples were collected for digestibility, ruminal fermentation, and microbial growth. The basal diet consisted of a typical finishing diet for beef cattle (16:84 roughage:concentrate ratio). All results were assessed for residual normality and variance homogeneity. All variables were fitted through generalized mixed models (GLIMMIX procedure) and compared by using Tukey test (multiple comparison) and polynomial regressions (tannin concentrations, which were analyzed for linear and quadratic responses. Partial data were presented in the table below. Total VFA concentration, molar proportion of butyrate, and total Branched-chain VFA were not affected by treatments (P > 0.05). Molar proportion of acetate of the tannin-based product at 0.07 % of DM tended to be decreased compared with all other treatments. Molar proportion of propionate increased quadratically (P = 0.05) reaching the peak at the level of 0.07 % of DM, which were greater than monensin treatment. In conclusion, our results indicate that a smaller dose of a tannin-based product (0.07 g/kg of DM) might manipulate ruminal fermentation by increasing molar proportion of propionate in typical feedlot diet fed under tropical conditions. This is important from an energetic standpoint for the animal host, since propionate is the precursor of glucose synthesis in ruminants.

90 Awardee Talk: Shedding light into the black box: The dual-flow continuous culture system and ruminal fermentation

Abstract Nutrients derived from ruminal fermentation supply a substantial amount of metabolizable nutrients for ruminants. These include amino acids, carbohydrates, fatty acids, vitamins, and fermentation end products, such as ammonia and volatile fatty acids. Furthermore, ruminal fermentation modifies dietary nutrients in such a way that nutrients reaching the small intestine for absorption may substantially differ from those being consumed in the diet. Therefore, understanding ruminal fermentation kinetics and quantification of nutrients flowing out of the rumen is an important aspect of ruminant nutrition. Accurate quantification of these nutrients, using in vivo experiments, is laborious, costly, and invasive, requiring surgical procedures such as ruminal, abomasal, and intestinal cannulas. To decrease the time and cost of experiments as well as the use of animals, in vitro methodologies are important tools in ruminant nutrition. Therefore, the objectives of this presentation are i) describe different in vitro methodologies, ii) discuss the advantages of in vitro methodologies, iii) discuss shortcomings of in vitro methodologies, and iv) describe potential developments that may improve in vitro methodologies. Having been used for decades, in vitro methodologies such as pure, batch, and continuous cultures have been well documented to investigate a wide array of aspects of nutrition, including the effects of different dietary compositions, individual fermentation end products, and impacts on the microbiome. However, both batch and pure cultures can result in a build-up of end products that may inhibit fermentation. Continuous culture, however, allows for the removal of end products but, similar to pure and batch cultures, is applicable only to ruminal fermentation and cannot provide information regarding intestinal digestion. The dual-flow continuous culture system (DFCC), developed in the 1970s and used by various laboratories in the USA and Europe consists of fermentation vessels of approximately 1.5 L that are capable of simulating ruminal fermentation for periods longer than 10 d. It has been extensively used and evaluated by meta-analyses. When compared with other in vitro methodologies, the DFCC has longer fermentation time, larger volume, and the possibility of sampling from the liquid and the solid flows. When compared with in vivo experiments the DFCC is faster, less costly, less invasive, allows for greater range of treatments, allows for more controlled condition, and isolates ruminal function. Limitations of the DFCC include it does not predict in vivo response, it assumes equal saliva flow and concentration, no effects of intake, no ruminal absorption, less retention of protozoa, possible differences in microbiome, and limited gas emission data. Therefore, while in vitro methodologies provide useful data into the field of ruminant nutrition, some in vitro methodologies are more robust than others. Furthermore, in vivo experiments are still the ideal approach for assessing nutrient utilization and necessary to evaluate animal responses.

SF6 Tracer Technique to Estimate Methane Emission in a Dual-Flow Continuous Culture System: Test and Application

This study aimed to evaluate the sulfur hexafluoride (SF6) tracer technique for estimating methane (CH4) emissions in dual-flow continuous culture systems (DFCCS). In experiment 1 (Exp1), fermenters were filled with water, and known CH4 concentrations (0, 1.35, 2.93, or 4.43 g/d) were injected using permeation tubes with SF6 release rates (3.30 or 9.65 mg/d). Headspace gas was collected using canisters, and the SF6 technique estimated CH4 recovery. Experiment 2 (Exp2) involved a DFCCS fermentation trial with ruminal fluid from three Holstein cows, testing diets with soybean meal or its partial replacement (50%) by Chlorella or Spirulina. Headspace gas was collected at intervals post-feeding. Standard curves for SF6 and CH4 quantification were inadequate for DFCCS samples, with the CH4:SF6 ratio differing from standards, indicating the data needs further SF6 release rate evaluation. In Exp1, a high correlation (r = 0.97) was found between infused and calculated CH4, indicating good repeatability. Low and high SF6 rates performed similarly at low CH4 infusion, but high SF6 overestimated CH4 at high infusion. Exp2 showed CH4 emissions irrespective of SF6 rate and indicated reduced CH4 emissions and increased NDF degradation with algae-containing diets. Further evaluation of the SF6 tracer technique is warranted for DFCCS.

Effects of monensin and cashew nut-shell extract on bacterial community composition in a dual-flow continuous culture system.

The objective of this study was to evaluate the effects of including monensin and two doses of CNSE in a high producing dairy cow diet on ruminal bacterial communities. A dual-flow continuous culture system was used in a replicated 4 × 4 Latin Square design. A basal diet was formulated to meet the requirements of a cow producing 45kg of milk per d (17% crude protein and 27% starch). There were four experimental treatments: the basal diet without any feed additive (CON), 2.5 μM monensin (MON), 100ppm CNSE granule (CNSE100), and 200ppm CNSE granule (CNSE200). Samples were collected from the fluid and solid effluents at 3, 6, and 9h after feeding; a composite of all time points was made for each fermenter within their respective fractions. Bacterial community composition was analyzed by sequencing the V4 region of the 16S rRNA gene using the Illumina MiSeq platform. Treatment responses for bacterial community structure were analyzed with the PERMANOVA test run with the R Vegan package. Treatment responses for correlations were analyzed with the CORR procedure of SAS. Orthogonal contrasts were used to test the effects of (1) ADD (CON vs. MON, CNSE100, and CNSE200); (2) MCN (MON vs. CNSE100 and CNSE200); and (3) DOSE (CNSE100 vs. CNSE200). Significance was declared at P ≤ 0.05. We observed that the relative abundance of Sharpea (P < 0.01), Mailhella (P = 0.05), Ruminococcus (P = 0.03), Eubacterium (P = 0.01), and Coprococcus (P < 0.01) from the liquid fraction and the relative abundance of Ruminococcus (P = 0.03) and Catonella (P = 0.02) from the solid fraction decreased, while the relative abundance of Syntrophococcus (P = 0.02) increased in response to MON when compared to CNSE treatments. Our results demonstrate that CNSE and monensin have similar effects on the major ruminal bacterial genera, while some differences were observed in some minor genera. Overall, the tested additives would affect the ruminal fermentation in a similar pattern.

PSVI-30 Effects of Different Cobalt Sources on Ruminal Fermentation of Lactating Dairy Cow Diets in a Dual-Flow Continuous Culture System

Abstract The objective of this study was to evaluate the effects of different sources of cobalt in a lactating dairy cow diet on in vitro ruminal fermentation. All diets provided the same amount of supplemental Co (1 mg per kg of diet DM) included in a premix with a targeted inclusion level of 2.5% of diet DM. Treatments were cobalt carbonate (CON), and three alternative Co sources; alternative source 1 (AS1), alternative source 2 (AS2), and alternative source 3 (AS3). Eight dual-flow continuous culture fermenters were used in a replicated 4 × 4 Latin square. Experimental periods were 10 d (7 d adaptation and 3 d sample collection). Composite samples of daily effluents were collected and analyzed for NH3-N, lactate, and VFA concentration as well as for nutrient digestibility. Samples of ruminal content were collected from each fermenter at 0, 1, 2, 4, 6, and 8 h after feeding to determine lactate, NH3-N, and pH kinetics. All data were analyzed using PROC MIXED of SAS and the repeated variable of time was included for pH, lactate, and NH3-N. There were neither treatment effects nor interactions between treatment and time for pH, NH3-N, and lactate concentrations, indicating a similar Co kinetics across treatments. With regards to lactate pool, we did not observe treatment effects for L-lactate; however, we observed treatment effects for D-lactate and total-lactate as seen in Table 1. Analyses of total and individual VFA, N utilization, and nutrient degradation are still undergoing, hence, it is possible that Co sources have effects on ruminal fermentation.

Effects of Microencapsulated Blend of Organic Acids and Pure Botanicals on the Ruminal Microbiota in an In Vitro Dual-Flow Continuous Culture System

The objective of the study was to evaluate the effects of dietary supplementation of a microencapsulated blend of organic acids and pure botanicals (mOAPBs) on the solid- and liquid-associated microenvironment (SAM and LAM, respectively) of the ruminal microbiome using an in vitro dual-flow continuous culture system. Ruminal content was incubated in eight fermenters and the basal diet was supplemented with increasing levels of mOAPBs (0; 0.12; 0.24; or 0.36% DM) which contained 55.6% hydrogenated and refined palm oil, 25% citric acid, 16.7% sorbic acid, 1.7% thymol, and 1% vanillin. All diets had a similar nutritional composition (16.1 CP, 30.9 NDF, and 32.0 starch, % DM basis). After 7 days of adaptation, a pooled sample across the days was collected in each period for identification of the microbiome of SAM and LAM. There was no effect of mOAPB on alpha-, beta-diversity, and microbial abundance. The SAM had a greater bacterial diversity and the principal component analysis demonstrated that it had a divergent bacterial profile from LAM. Additionally, SAM had an increased abundance of carbohydrate-degrading microorganisms. In summary, mOAPBs did not modulate the ruminal microbiome. The microenvironment microbiome of solid- and liquid-associated microenvironments were different, with SAM having a greater carbohydrate-degrading microorganism population.

The Effects of Incremental Doses of Aflatoxin B1 on In Vitro Ruminal Nutrient Digestibility and Fermentation Profile of a Lactating Dairy Cow Diet in a Dual-Flow Continuous Culture System.

Aflatoxin B1 (AFB1) is a mycotoxin known to impair human and animal health. It is also believed to have a deleterious effect on ruminal nutrient digestibility under in vitro batch culture systems. The objective of this study was to evaluate the effects of increasing the dose of AFB1 on ruminal dry matter and nutrient digestibility, fermentation profile, and N flows using a dual-flow continuous culture system fed a diet formulated for lactating dairy cows. Eight fermenter vessels were used in a replicated 4 × 4 Latin square design with 10 d periods (7 d adaptation and 3 d sample collection). Treatments were randomly applied to fermenters on diet DM basis: (1) 0 μg of AFB1/kg of DM (Control); (2) 50 μg of AFB1/kg of DM (AF50); (3) 100 μg of AFB1/kg of DM (AF100); and (4) 150 μg of AFB1/kg of DM (AF150). Treatments did not affect nutrient digestibility, fermentation, and N flows. Aflatoxin B1 concentration in ruminal fluid increased with dose but decreased to undetectable levels after 4 h post-dosing. In conclusion, adding incremental doses of AFB1 did not affect ruminal fermentation, digestibility of nutrients, and N flows in a dual-flow continuous culture system fed diets formulated for lactating dairy cows.

Effects of partially replacing dietary corn with sugars in a dual-flow continuous culture system on the ruminal microbiome.

The objective of this study was to evaluate the effects of feeding sugars as a replacement for starch on the ruminal microbiome using a dual-flow continuous culture system. Four periods of 10 days each were conducted with 8 fermenters in a 4 × 4 replicated Latin square design. Treatments included: 1) control with corn-CON, 2) molasses-MOL, 3) untreated condensed whey permeate-CWP, and 4) CWP treated with a caustic agent-TCWP as a partial substitute for corn. Sugars were defined as the water-soluble carbohydrates (WSC) concentration. Diets were formulated by replacing 4% of the diet DM in the form of starch from corn with the sugars in byproducts. Microbial samples for DNA analysis were collected from the solid and liquid effluent containers at 3, 6, and 9 h after feeding. Bacterial community composition was analyzed with sequencing the V4 region of the 16S rRNA gene using Illumina MiSeq platform. Data were analyzed with R 4.1.3 packages vegan, lmer, and ggplot to determine the effects of treatment on the relative abundance of taxa in the solid and liquid fractions, as well as the correlation of Acetate: Propionate ratio and pH to taxa relative abundance. Treatments did not affect alpha or beta diversity. At the phylum level the relative abundance of Proteobacteria was increased in CON compared to sugars in the solid fraction. In the liquid fraction, Firmicutes had greater relative abundance in sugar treatments while Bacteroidota and Spirochaetota were present in lower relative abundance in CWP. For solid and liquid samples, the family Lachnospiraceae had greater relative abundance in sugar treatments compared to CON. The decreased relative abundance of Christensenellaceae and Rikenellaceae paired with the greater relative abundance of Selenomonadaceae in CWP could help explain greater propionate molar proportion and decreased ruminal pH previously observed for this treatment. The genera Olsenella a lactic acid-producing bacterium, had the greatest relative abundance in MOL. Incorporating TCWP or MOL as a partial replacement for starch was more conservative of fibrolytic bacterial taxa compared to CWP. Additionally, TCWP did not increase bacterial taxa associated with synthesis of lactate as compared to MOL. Overall, replacing starch with sugars is mostly conservative of the ruminal microbiome; however, changes observed coincide with differences observed in acetate and propionate proportions and ruminal pH.

Effects of exogenous amylolytic or fibrolytic enzymes inclusion on in vitro fermentation of lactating dairy cow diets in a dual-flow continuous-culture system

The objective of this study was to determine the effects of including exogenous amylolytic or fibrolytic enzymes in a diet for high-producing dairy cows on in vitro ruminal fermentation. Eight dual-flow continuous-culture fermentors were used in a replicated 4 × 4 Latin square. The treatments were control (CON), a xylanase and glucanase mixture (T1), an α-amylase mixture (T2), or a xylanase, glucanase, and α-amylase mixture (T3). Treatments were included at a rate of 0.008% of diet dry matter (DM) for T1 and T2 and at 0.02% for T3. All treatments replaced the equivalent amount of soybean meal in the diet compared with CON. All diets were balanced to have the same nutrient composition [30.2% neutral detergent fiber (NDF), 16.1% crude protein (CP), and 30% starch; DM basis], and fermentors were fed 106 g/d divided into 2 feedings. At each feeding, T2 was pipetted into the respective fermentor and an equivalent amount of deionized water was added to each fermentor to eliminate potential variation. Experimental periods were 10 d (7 d for adaptation and 3 d for sample collection). Composite samples of daily effluent were collected and analyzed for volatile fatty acids (VFA), NH3-N, and lactate concentrations, degradability of DM, organic matter, NDF, CP, and starch, and flow and metabolism of N. Samples of fermentor contents were collected from each fermentor at 0, 1, 2, 4, 6, and 8 h after feeding to determine kinetics of pH, NH3-N, lactate, and VFA concentrations over time. All data were analyzed using PROC GLIMMIX of SAS (SAS Institute Inc.), and the repeated variable of time was included for kinetics measurements. Treatment did not affect mean pH, degradability, N flow and metabolism, or the concentrations of VFA, NH3-N, or lactate in the effluent samples. Treatment did not affect pH, acetate:propionate ratio, or the concentrations of lactate, NH3-N, total VFA, acetate, propionate, butyrate, isobutyrate, valerate, or caproate. However, the concentration of total VFA tended to change at each time point depending upon the treatment, and T2 tended to have a greater proportion of 2-methylbutyrate and isovalerate than CON, T1, or T3. As 2-methylbutyrate and isovalerate are branched-chain VFA that are synthesized from branched-chain amino acids, T2 may have an increased fermentation of branched-chain amino acids or decreased uptake by fibrolytic microorganisms. Although we did not observe changes in N metabolism due to the enzymes, there could be changes in microbial populations that utilize branched-chain VFA. Overall, the tested enzymes did not improve in vitro ruminal fermentation in the diet of high-producing dairy cows.

Megasphaera elsdenii and Saccharomyces Cerevisiae as direct fed microbials during an in vitro acute ruminal acidosis challenge

This study aimed to evaluate the effects of Saccharomyces cerevisiae and Megasphaera elsdenii as direct fed microbials (DFM) in beef cattle finishing diets to alleviate acute ruminal lactic acidosis in vitro. A dual-flow continuous culture system was used. Treatments were a Control, no DFM; YM1, S. cerevisiae and M. elsdenii strain 1; YM2, S. cerevisiae and M. elsdenii strain 2; and YMM, S. cerevisiae and half of the doses of M. elsdenii strain 1 and strain 2. Each DFM dose had a concentration of 1 × 108 CFU/mL. Four experimental periods lasted 11 days each. For the non-acidotic days (day 1–8), diet contained 50:50 forage to concentrate ratio. For the challenge days (day 9–11), diet contained 10:90 forage to concentrate ratio. Acute ruminal acidosis was successfully established. No differences in pH, d-, l-, or total lactate were observed among treatments. Propionic acid increased in treatments containing DFM. For N metabolism, the YMM treatment decreased protein degradation and microbial protein synthesis. No treatment effects were observed on NH3–N concentration; however, efficiency of N utilization by ruminal bacteria was greater than 80% during the challenge period and NH3–N concentration was reduced to approximately 2 mg/dL as the challenge progressed.

Effects of different protein sources on nutrient disappearance, rumen fermentation parameters and microbiota in dual-flow continuous culture system

Scarce high-quality protein feed resources has limited the development of animal husbandry. In this study, we used a dual-flow continuous culture system to evaluate effects of difference dietary protein sources including soybean meal (SBM), cottonseed meal (CSM), and rapeseed meal (RSM), on nutrient disappearance, rumen fermentation, and microbiota of XiongDong black goats. Dietary proteins of either CSM, RSM or SBM had no effect on nutrient disappearance (P > 0.05). CSM or RSM significantly reduced (P < 0.01) the pH and enhanced (P < 0.01) the ammonia nitrogen (NH3-N) concentration in fermentation liquid compared to SBM. The short-chain fatty acids (SCFAs) contents were greater (P = 0.05) and acetate was lower (P < 0.01) in SBM than those in RSM and CSM, whereas propionate was greater (P < 0.01) in RSM than that in SBM, consequently reducing the acetate to propionate ratio (A/P) in RSM. Bacteroidetes, Firmicutes, and Proteobacteria were detected as the dominant phyla, and the relative abundances of Spirochaetae (P < 0.01) and Chlorobi (P < 0.05) declined in the CSM and RSM groups as compared to those in the SBM group. At the genus level, Prevotella_1 was the dominant genus; as compared to SBM, its relative abundance was greater (P < 0.01) in CSM and RSM. The abundances of Prevotellaceae_Ga6A1 and Christensenellaceae_R7 were lower (P < 0.05) in CSM, whereas Eubacterium_oxidoreducens_group, and Treponema_2 were lower (P < 0.01) in both CSM and RSM, and other genera were not different (P > 0.10). Although the bacterial community changed with different dietary protein sources, the disappearances of nutrients were not affected, suggesting that CSM and RSM could be used by rumen bacteria, as in case with SBM, and are suitable protein sources for ruminant diets.

Effects of lactic acid-producing bacteria as direct-fed microbials on the ruminal microbiome

The objective of this study was to evaluate ruminal microbiome changes associated with feeding Lactobacillus plantarum GB-LP1 as direct-fed microbials (DFM) in high-producing dairy cow diets. A dual-flow continuous culture system was used in a replicated 4 × 4 Latin square design. A basal diet was formulated to meet the requirements of a cow producing 45 kg of milk per day (16% crude protein and 28% starch). There were 4 experimental treatments: the basal diet without any DFM (CTRL); a mixture of Lactobacillus acidophilus, 1 × 109 cfu/g, and Propionibacterium freudenreichii, 2 × 109 cfu/g [MLP = 0.01% of diet dry matter (DM)]; and 2 different levels of L. plantarum, 1.35 × 109 cfu/g (L1 = 0.05% and L2 = 0.10% of diet DM). Bacterial samples were collected from the fluid and particulate effluents before feeding and at 2, 4, 6, and 8 h after feeding; a composite of all time points was made for each fermentor within their respective fractionations. Bacterial community composition was analyzed through sequencing the V4 region of the 16S rRNA gene using the Illumina MiSeq platform. Sequenced data were analyzed on DADA2, and statistical analyses were performed in R (RStudio 3.0.1, https://www.r-project.org/) and SAS 9.4 (SAS Institute Inc.); orthogonal contrasts were used to compare treatments. Different than in other fermentation scenarios (e.g., silage or beef cattle high-grain diets), treatments did not affect pH or lactic acid concentration. Effects were mainly from overall DFM inclusion, and they were mostly observed in the fluid phase. The relative abundance of the phylum Firmicutes, family Lachnospiraceae, and 6 genera decreased with DFM inclusion, with emphasis on Butyrivibrio_2, Saccharofermentans, and Ruminococcus_1 that are fibrolytic and may display peptidase activity during fermentation. Lachnospiraceae_AC2044_group and Lachnospiraceae_XPB1014_group also decreased in the fluid phase, and their relative abundances were positively correlated with NH3-N daily outflow from the fermentors. Specific effects of MLP and L. plantarum were mostly in specific bacteria associated with proteolytic and fibrolytic functions in the rumen. These findings help to explain why, in the previous results from this study, DFM inclusion decreased NH3-N concentration without altering pH and lactic acid concentration.

Effects of partially replacing dietary corn with molasses, condensed whey permeate, or treated condensed whey permeate on ruminal microbial fermentation

Corn is a feedstuff commonly fed to dairy cows as a source of energy. The objective of this study was to evaluate whether partially replacing dietary corn with molasses or condensed whey permeate, in lactating dairy cow diets in a dual-flow continuous culture system, can maintain nutrient digestibility by ruminal microorganisms. Furthermore, this study evaluated whether treating condensed whey permeate before feeding could aid the fermentation of the condensed whey permeate in the rumen. Eight fermentors were used in a 4 × 4 replicated Latin square with 4 periods of 10 d each. The control diet (CON) was formulated with corn grain, and the other diets were formulated by replacing corn grain with either sugarcane molasses (MOL), condensed whey permeate (CWP), or treated condensed whey permeate (TCWP). Diets were formulated by replacing 4% of the diet dry matter (DM) in the form of starch from corn with sugars from the byproducts. Sugars were defined as water-soluble carbohydrates (WSC) in the rations. The fermentors were fed 52 g of DM twice daily of diets containing 17% crude protein, 28% neutral detergent fiber, and 45% nonfiber carbohydrates. Liquid treatments were pipetted into each fermentor. After 7 d of adaptation, samples were collected for analyses of volatile fatty acids (VFA), lactate, and ammonia, and fermentors' pH were measured at time points after the morning feeding for 3 d. Pooled samples from effluent containers were collected for similar analyses, nutrient flow, and N metabolism. Data were statistically analyzed using Proc MIXED of SAS version 9.4 (SAS Institute Inc.); fixed effects included treatment and time, and random effects included fermentor, period, and square. The interaction of treatment and time was included for the kinetics samples. The TCWP and MOL treatments maintained greater fermentor pH compared with CWP. Total VFA concentration was increased in CWP compared with MOL. The acetate:propionate ratio was increased in TCWP compared with CON, due to tendencies of increased acetate molar proportion and decreased propionate molar proportion in TCWP. Lactate concentration was increased in MOL. Digestibility of WSC was increased in the diets that replaced corn with byproducts. The partial replacement of 4% of DM from corn starch with the sugars in byproducts had minimal effects on ruminal microbial fermentation and increased pH. Treated CWP had similar effects to molasses.

Effects of bacterial cultures, enzymes, and yeast-based feed additive combinations on ruminal fermentation in a dual-flow continuous culture system.

Bacterial cultures, enzymes, and yeast-derived feed additives are often included in commercial dairy rations due to their effects on ruminal fermentation. However, the effects of these additives when fed together are not well understood. The objective of this study was to evaluate the changes in ruminal fermentation when a dairy ration is supplemented with combinations of bacterial probiotics, enzymes and yeast. Our hypotheses were that ruminal fermentation would be altered, indicated through changes in volatile fatty acid profile and nutrient digestibility, with the inclusion of (1) an additive, (2) yeast, and (3) increasing additive doses. Treatments were randomly assigned to 8 fermenters in a replicated 4 × 4 Latin square with four 10 d experimental periods, consisting of 7 d for diet adaptation and 3 d for sample collection. Basal diets contained 52:48 forage:concentrate and fermenters were fed 106 g of dry matter per day divided equally between two feeding times. Treatments were: control (CTRL, without additives); bacterial culture/enzyme blend (EB, 1.7 mg/d); bacterial culture/enzyme blend with a blend of live yeast and yeast culture (EBY, 49.76 mg/d); and a double dose of the EBY treatment (2×, 99.53 mg/d). The bacterial culture/enzyme blend contained five strains of probiotics (Lactobacillus animalis, Propionibacterium freudenreichii, Bacillus lichenformis, Bacillus subtilis, and Enterococcus faecium) and three enzymes (amylase, hemicellulase, and xylanase). On d 8–10, samples were collected for pH, redox, volatile fatty acids, lactate, ammonia N, and digestibility measurements. Statistical analysis was performed using the GLIMMIX procedure of SAS. Repeated measures were used for pH, redox, VFA, NH3-N, and lactate kinetics data. Orthogonal contrasts were used to test the effect of (1) additives, ADD (CTRL vs. EB, EBY, and 2X); (2) yeast, YEAST (EB vs. EBY, and 2X); and (3) dose, DOSE (EBY vs. 2X). No effects (P > 0.05) were observed for pH, redox, NH3-N, acetate, isobutyrate, valerate, total VFA, acetate:propionate, nutrient digestibility or N utilization. Within the 24 h pool, the molar proportion of butyrate increased (P = 0.03) with the inclusion of additives when compared to the control while the molar proportion of propionate tended to decrease (P = 0.07). In conclusion, the inclusion of bacterial cultures, enzymes and yeast in the diet increased butyrate concentration; but did not result in major changes in ruminal fermentation.

Antimicrobial supplementation alters digestibility and ruminal fermentation in a continuous culture model

ABSTRACT A dual-flow continuous culture system was used to evaluate the effects of laidlomycin propionate and bacitracin zinc on fermentation, nutrient digestibility, and microbial efficiency. Factors were laidlomycin propionate (LP; 2 mg/L of culture volume) and bacitracin zinc (BAC; 1.4 mg/L), and treatments were as follows: (1) no BAC or LP (CON), (2) LP without BAC (LP), (3) BAC without LP (BAC), and (4) LP and BAC (LP/BAC). A fifth treatment was supplemented with monensin sodium (MON; 6 mg/L) to act as a positive control. Both LP and LP/BAC had significantly greater pH than MON (P < 0.05). Antibiotic treatment did not affect NH 3-N concentration (P = 0.62), but did influence total VFA production (P = 0.02). Monensin fermenters had a greater proportion of total VFA than did LP fermenters (P < 0.05), and improved VFA production by 7.2% compared to CON. Laidlomycin suppressed the production of both acetate (P < 0.01) and butyrate (P = 0.05), and acetate was further reduced when LP was fed in combination with BAC (P = 0.01). Laidlomycin numerically reduced the acetate:propionate ratio (P = 0.12). These results suggest that bacitracin may produce ionophore-like effects on pH and VFA production in vitro.

183 A blend of plant extracts (Actifor Pro) potentially reduced methane production in a dual-flow continuous culture system fed bermudagrass hay with or without corn gluten feed

Abstract Twelve dual-flow continuous culture fermenters (1.95 L) were used to evaluate the effect of a phytogenic feed additive (Actifor Pro, Delacon, Engerwitzdorf, Austria; ACT) on ruminal fermentation and methane production when fed high fiber diets, comprised of bermudagrass hay (BGH) with or without corn gluten feed (CGF). Fermenters were utilized in a generalized randomized block design with a 2 × 2 factorial arrangement of treatments (n = 6): 1) diet (with or without CGF at 22% of diet DM) and 2) additive (with or without ACT at 1.0 g/L ACT). Two 10-d periods were conducted. Overall, comparing to no CGF, supplementation with CGF resulted in lower dry matter, organic matter, crude protein digestibility, microbial efficiency of nitrogen utilization, and methane production (mL of CH4/mol of total VFA), but increased neutral detergent fiber digestibility (all P ≤ 0.05). Diet × additive interactions were observed for molar proportion of acetate and propionate, and acetate-to-propionate ratio (A:P, all interactions P &amp;lt; 0.05), where inclusion of ACT increased acetate molar proportion and A:P (both P &amp;lt; 0.05), and decreased propionate molar proportion in diets with CGF (P = 0.05). A diet × additive interaction was also observed for methane production (ml of CH4/mol of total VFA; P = 0.08), where ACT decreased CH4 production per mol of VFA by 42% (P = 0.04), when only BGH was fed to the fermenters. In conclusion, CGF supplementation in BGH diets reduced methane production and improved fiber digestibility. The decrease in methane production per mol of VFA observed with ACT in the BGH without CGF diet warrants further investigation.

Copper sulfate and sodium selenite lipid-microencapsulation modifies ruminal microbial fermentation in a dual-flow continuous-culture system

Undesirable interactions between trace mineral elements and ruminal contents may occur during digestion when mineral salts are supplemented. Antimicrobial effects of copper sulfate (CuSO4) may affect ruminal digestibility of nutrients when fed as a source of copper (Cu), while sodium selenite (Na2SeO3) may be reduced in the rumen to less available forms of selenium (Se). Our objective was to evaluate if protection of CuSO4 and Na2SeO3 by lipid-microencapsulation would induce changes on ruminal microbial fermentation. We used 8 fermentors in a dual-flow continuous-culture system in a 4 × 4 duplicated Latin square with a 2 × 2 factorial arrangement of treatments. Factors were CuSO4 protection (unprotected and protected by lipid-microencapsulation) and Na2SeO3 protection (unprotected and protected by lipid-microencapsulation). Treatments consisted of supplementation with 15 mg/kg of Cu and 0.3 mg/kg of Se from either unprotected or protected (lipid-microencapsulated) sources, as follows: (1) Control (unprotected CuSO4 + unprotected Na2SeO3); (2) Cu-P (protected CuSO4 + unprotected Na2SeO3); (3) Se-P (unprotected CuSO4 + protected Na2SeO3); (4) (Cu+Se)-P (protected CuSO4 + protected Na2SeO3). All diets had the same nutrient composition and fermentors were fed 106 g of dry matter/d. Each experimental period was 10 d (7 d of adaptation and 3 d for sample collections). Daily pooled samples of effluents were analyzed for pH, NH3-N, nutrient digestibility, and flows (g/d) of total N, NH3-N, nonammonia N (NAN), bacterial N, dietary N, and bacterial efficiency. Kinetics of volatile fatty acids was analyzed in samples collected daily at 0, 1, 2, 4, 6, and 8 h after feeding. Main effects of Cu protection, Se protection, and their interaction were tested for all response variables. Kinetics data were analyzed as repeated measures. Protection of Cu decreased acetate molar proportion, increased butyrate proportion, and tended to decrease acetate:propionate ratio in samples of kinetics, but did not modify nutrient digestibility. Protection of Se tended to decrease NH3-N concentration, NH3-N flow, and CP digestibility; and to increase flows of nonammonia N and dietary N. Our results indicate that protection of CuSO4 may increase butyrate concentration at expenses of acetate, while protection of Na2SeO3 tended to reduce ruminal degradation of N. Further research is needed to determine the effects of lipid-microencapsulation on intestinal absorption, tissue distribution of Cu and Se, and animal performance.

Estimating degradation of individual essential amino acids in fish meal and blood meal by rumen microbes in a dual-flow continuous-culture system

Current feeding systems are based on the assumption that the AA profile of rumen undegraded protein is similar to that of the original feed. The objective of this experiment was to determine rumen bacterial degradation of individual essential AA in fish meal (FM) and blood meal (BM). Eight dual-flow continuous-culture fermentors were used in a completely randomized block design with a factorial arrangement of treatments and 3 replicated periods. Fermentors were supplied with 95 g of dry matter/d of isonitrogenous diets. Treatments contained a nonprotein N source (urea and tryptone) that was substituted with increasing proportions of FM or BM (0, 33, 67, or 100%). Diets consisted of 22.0% crude protein, 35.2% neutral detergent fiber, 34.6% nonfiber carbohydrates, 2.0% ether extract, and 9.2% ash. We hypothesized that the increase in the flow of individual AA would be attributed to the increase in the supply of the AA from each protein supplement. True organic matter degradation was decreased by increasing levels of FM or BM, but did not affect degradation of neutral detergent fiber and acid detergent fiber, total volatile fatty acids (VFA) concentration, or the molar proportion of propionate. There was a substrate by level of inclusion interaction in acetate molar proportion and branched-chain VFA. Butyrate concentration decreased linearly with increasing levels of FM and BM in treatment. Changes in branched-chain VFA reflected differences in content of branched-chain AA between supplements and the level of inclusion, although the quadratic effect suggests that other factors were involved. Ammonia-N concentration showed a substrate by level of inclusion interaction. Total dietary N and AA flows increased with increasing levels of FM or BM in treatment. The efficiency of bacterial crude protein synthesis was not affected by treatment, but the flow of bacterial N decreased in FM diets as the level of FM increased. Flows of AA increased linearly with increasing levels of the respective AA from supplements. Arginine, Ile, Met and Phe were more degradable, while His was more resistant to bacterial degradation. Results suggest that the resistance to rumen bacterial degradation of individual AA varies within FM and BM protein and may affect the estimates of dietary supply of individual AA to the small intestine.

Lipopolysaccharide Stimulates the Growth of Bacteria That Contribute to Ruminal Acidosis.

Lipopolysaccharide (LPS) has been reported to contribute to a ruminal acidosis of cattle by affecting ruminal bacteria. The goal of this study was to determine how LPS affects the growth of pure cultures of ruminal bacteria, including those that contribute to ruminal acidosis. We found that dosing LPS (200,000 EU) increased the maximum specific growth rates of four ruminal bacterial species (Streptococcus bovis JB1, Succinivibrio dextrinosolvens 24, Lactobacillus ruminis RF1, and Selenomonas ruminantium HD4). Interestingly, all the species ferment sugars and produce lactate, contributing to acidosis. Species that consume lactate or ferment fiber were not affected by LPS. We found that S. bovis JB1 failed to grow in LPS as the carbon source in the media; growth of S. bovis JB1 was increased by LPS when glucose was present. Growth of Megasphaera elsdenii T81, which consumes lactate, was not different between the detoxified (lipid A delipidated) and regular LPS. However, the maximum specific growth rate of S. bovis JB1 was greater in regular LPS than detoxified LPS. Mixed bacteria from a dual-flow continuous culture system were collected to determine changes of metabolic capabilities of bacteria by LPS, and genes associated with LPS biosynthesis were increased by LPS. In summary, LPS was not toxic to bacteria, and lipid A of LPS stimulated the growth of lactate-producing bacteria. Our results indicate that LPS not only is increased during acidosis but also may contribute to ruminal acidosis development by increasing the growth of lactic acid-producing bacteria.IMPORTANCE Gram-negative bacteria contain lipopolysaccharide (LPS) coating their thin peptidoglycan cell wall. The presence of LPS has been suggested to be associated with a metabolic disorder of cattle-ruminal acidosis-through affecting ruminal bacteria. Ruminal acidosis could reduce feed intake and milk production and increase the incidence of diarrhea, milk fat depression, liver abscesses, and laminitis. However, how LPS affects bacteria associated with ruminal acidosis has not been studied. In this study, we investigated how LPS affects the growth of ruminal bacteria by pure cultures, including those that contribute to acidosis, and the functional genes of ruminal bacteria. Thus, this work serves to further our understanding of the roles of LPS in the pathogenesis of ruminal acidosis, as well as providing information that may be useful for the prevention of ruminal acidosis and reducetion of economic losses for farmers.

Comparison of microbial fermentation data from dual-flow continuous culture system and omasal sampling technique: A meta-analytical approach

Although the omasal sampling technique (OST) has been successfully used to estimate ruminal fermentation and nutrient flow, alternatives to invasive animal trials should be pursued and evaluated. The objective of this study was to evaluate carbohydrate and N metabolisms using a meta-analytical approach to compare 2 methods: dual-flow continuous culture system (DFCCS) and OST. To be included, studies needed to report diet chemical composition and report at least 1 of the dependent variables of interest. A total of 155 articles were included, in which 97 used the DFCCS and 58 used the OST. The independent variables used were dietary nonfiber carbohydrate concentration, neutral detergent fiber (NDF) degradability, true crude protein (CP) degradability, and efficiency of microbial protein synthesis (EMPS). In addition, 12 dependent variables were used. Statistical analyses were performed using the Mixed procedure of SAS (SAS Institute Inc., Cary, NC). A random coefficients model was used considering study as a random effect and including the possibility of covariance between the slope and the intercept. The effect of method (DFCCS or OST) was included and tested in the estimates of the intercept, linear, and quadratic effects of the independent variable. There was no method effect when NDF degradability was regressed with total volatile fatty acids concentration, true CP degradability, and EMPS. Molar proportions of acetate and propionate were quadratically associated with NDF degradability. When NDF degradability was regressed with acetate and propionate there was a method effect, differing only in the intercept (β0) estimate. True organic matter digestibility, bacterial N/total N, efficiency of N utilization, total volatile fatty acid concentration, and molar proportion of butyrate linearly increased as dietary nonfiber carbohydrate concentration increased, and none of these variables were affected by method. Concentration of ammonia N had a linear and positive association with true CP degradability. This was the only variable that had a method effect when regressed with true CP degradability, differing only in the estimate of the intercept (β0). As EMPS increased, efficiency of N utilization also increased, and it was affected by method. Overall, the majority of DFCCS responses were similar to OST. When a method effect was observed, it was mainly on the estimate of the intercept, demonstrating that the magnitude of these responses was different. However, the relationships between independent and dependent variables were similar across methods.