Distillers Grains Research Articles

LC-MS/MS Determination of Antibiotic Residues in Distillers Grains: Method Modification.

Antibiotics are used in ethanol production to discourage undesirable bacteria growth. To determine if antibiotic residues remain in the distillers grain (DG) by-product, which is used as an animal food ingredient, the U.S. Food and Drug Administration/Center for Veterinary Medicine previously developed an LC-MS/MS method to detect residues of erythromycin A, penicillin G, virginiamycin M1, and virginiamycin S1 in DG to enable regulatory decision making. Erythromycin and penicillin G were quantitated using the stable isotope dilution (SID) technique with their isotopically labeled compounds, which are considered optimal internal standards (ISTDs) for quantitative mass spectrometry. With the commercial availability of virginiamycin M1-d2 since then, the objectives of this study were to evaluate the feasibility of its use as it is only doubly deuterated, and to incorporate it in the method to enhance method performance. Antibiotic residues were solvent-extracted from DG, the extract was cleaned up by a hexane wash and solid phase extraction, and analyzed by LC-MS/MS. We established suitability of virginiamycin M1-d2 as an ISTD and incorporated it in the method. For all analytes, accuracy and precision ranged 90 to 102% and 3.8 to 6.8, respectively. We modified a previously developed LC-MS/MS method that uses virginiamycin M1-d2 as an ISTD to support surveillance studies to determine several drugs in DG. Virginiamycin M1-d2 was successfully incorporated into the method for better virginiamycin M1 quantitation. This addition also allowed calibration curves for all analytes to be constructed in solvent thereby simplifying the method.

Goat Defoliation and Debarking on Eastern Redcedar with Rumen Undegradable Protein Supplement

Eastern redcedar (ERC) (Juniperus virginiana L.) encroachment threatens long-term Great Plains health. Goats browse juniper by defoliation and debarking but are limited by aversive postingestive feedback from plant secondary metabolites. Protein supplementation may increase fed juniper foliage intake by offsetting nitrogen loss from plant secondary metabolites−protein binding, but little is known for goats browsing whole juniper, mimicking a field setting. Therefore, the objective was to study the effects of rumen undegradable protein (RUP) supplementation and tree height on goat browsing. Experimental design was two 3 × 3 Latin squares of two diets and three ERC tree height treatments. Within each square, 12 Savannah × Spanish × Boer crossbred 50 kg ± 3.9 kg does were fixed to a diet for 10 d (7 d adaptation and 3 d ERC browsing). Fed diets were control (grass hay and whole corn) and supplemented (grass hay and dried distiller's grain, an RUP source). Diets were isocaloric, and supplemented diet crude protein was fed at 2 × maintenance. Each pen (three pens of four goats per diet) was offered two trees from one of three tree height treatments for 8 h daily over 3 d in a rotation where pens received all tree height treatments. Supplemented RUP did not increase defoliation (P = 0.73), trunk debarking (P = 0.84), or branch browsing (P = 0.74). However, tree height may impact browsing as short (50 cm) trees were more defoliated and 50 cm and 100 cm trees had more branches browsed than taller (200 cm) trees (P < 0.05). Therefore, for field application relevance, it may be more important for pen studies to measure browsing of whole juniper rather than fed foliage intake. Future pen and/or field studies should explore alternative protein sources, consider tree height in their design, and offer goats whole juniper.

Production of 1,3-propanediol using enzymatic hydrolysate derived from pretreated distillers' grains

To minimize environmental pollution and waste of resources, distillers’ grains (DG) was used to produce 1,3-propanediol. Biological, physical, and chemical methods were used for pretreatment. The correlation between features of pretreated samples and enzymatic digestibility was analyzed. The results showed that the glucan and xylan conversion of dilute sulfuric acid pretreated DG increased by 69.59% and 413.68%, respectively. The glucan conversion of microwave pretreated and xylan conversion of laccase pretreated DG increased by 14.22% and 34.19%, respectively. Pretreatment enhanced enzymatic digestibility through changing the dense structure and features of DG making them conductive to enzymatic hydrolysis. The production of 1,3-propanediol using enzymatic hydrolysate of pretreated DG and glycerol in shake-flask was 17 g/L. The utilization of DG not only provides plentiful raw materials replacing fossil fuels to produce biofuels and other chemicals but efficiently reduces environmental waste.

Synergistic use of optical and biophysical traits to assess Bromus inermis pasture performance and quality under different management strategies in Eastern Nebraska, U.S.

We investigated the synergic use of optical and biophysical traits to characterize Bromus inermis (smooth bromegrass) pasture lands and assess the combined effects of long-term (15-years) rotational grazing and management strategies of (i) no fertilization (C), (ii) mineral nitrogen (N) fertilization (HF), and (iii) supplemented fertilization through dry distiller grains plus soluble (DDGS; SF)- on forage growth, performance, and quality. We found that fertilization improved pasture’s biomass, specific leaf area, leaf area index (LAI), as well as forage quality. The use of N fertilization did not offer an advantage (e.g., forage quality, yield) over DDGS under both grazed and ungrazed conditions. Optical, proximal sensing techniques allowed the characterization of pasture lands in a non-invasive and time-efficient manner. We tested established vegetation indices (VIs) for their accuracy in identifying and quantifying important physiological and morphological traits. Results showed that the Normalized Difference Vegetation Index (NDVI) and Vogelmann (VOG) were among the best performing indices. Results contribute to our understanding of the impact of long-term fertilization management on Bromus inermis pastures and validate the use of proximal sensing methods. Proximal sensing methods provide direct, non-invasive, and time efficient tool for assessment of the performance and health of vegetation, keys to successful integrative management strategies.

Effects of different feeds on growth performance and meat quality of hybrid lambs

To improve the meat quality of Nei Mongol mutton and the benefits for farmers, we selected Australian salmon hybrid lambs as experimental subjects to investigate the effects of Allium mongolicum Regel powder (AMR) and yeast-fermented distiller’s grains (DGS) on their production performance and economic efficiency. The results showed that the DGS group had higher kidney index, the AMR group had better meat quality, and the economic efficiency ratio of DGS and AMR was 2.08. In conclusion, both feeds had no adverse effects on the production performance of lambs, and the DGS group had greater potential for promotion.

Replacing soybean meal with high-oil pumpkin seed cake in the diet of lactating Holstein dairy cows modulated rumen bacteria and milk fatty acid profile

This research aimed to investigate the effects of replacing soybean meal with high-oil pumpkin seed cake (HOPSC) on ruminal fermentation, lactation performance, milk fatty acid, and ruminal bacterial community in Chinese dairy cows. Six multiparous Chinese Holstein cows at 105.50 ± 5.24 d in milk (mean ± standard deviation) and 36.63 ± 0.74 kg/d of milk yield were randomly allocated, in a 3 × 3 Latin square design, to 3 dietary treatments in which HOPSC replaced soybean meal. Group 1 was the basal diet with no HOPSC (0HOPSC); group 2 was a 50% replacement of soybean meal with HOPSC and dried distillers grains with solubles (DDGS; 50HOPSC), and group 3 was a 100% replacement of soybean meal with HOPSC and DDGS (100HOPSC). We found no difference in the quantity of milk produced or milk composition among the 3 treatment groups. Feed efficiency tended to increase linearly as more HOPSC was consumed. In addition, rumen fermentation was not influenced when soybean meal was replaced with HOPSC and DDGS; the relative abundance of ruminal bacteria at the phylum and genus levels was altered. We also observed that as the level of HOPSC supplementation increased, the relative abundance of Firmicutes and Tenericutes linearly increased, whereas that of Bacteroidetes decreased. However, with increasing HOPSC supplementation, the relative abundance of Ruminococcus decreased linearly at the genus level in the rumen, and the relative abundance of Prevotella showed a linear downward tendency. Changes in dietary composition and rumen bacteria had no significant effect on the fatty acid composition of milk. In conclusion, our results indicated that replacing soybean meal with a combination of HOPSC and DDGS can meet the nutritional needs of high-yielding dairy cows without adversely affecting milk yield and quality; however, the composition of rumen bacteria could be modified. Further study is required to investigate the effects of long-term feeding of HOPSC on rumen fermentation and performance of dairy cows.

Effects of low-fat dried distillers grains on nutrient intake and digestibility in high-concentrate diets

This study aimed to evaluate the effect of including levels of low-fat dried distillers grains without soluble (DDG) in high-concentrate diets on intake and digestibility. Four rumen-cannulated Nellore cattle received four dietary treatments in a 4×4 Latin square experimental design. Treatments included diets without DDG (D0) and varying inclusion levels of DDG at 150 g/kg (D150), 300 g/kg (D300), and 450 g/kg (D450). Four periods of total feces and urine collection were performed to estimate nutrient intake and digestibility and estimate nitrogen balance. Collections of omasum digesta were used to estimate ruminal degradability. The ruminal emptying technique was performed to estimate the ruminal rates of ingestion, passage, and digestion (kd). The inclusion of DDG reduced the intake of total digestible nutrients (TDN) (P < 0.01), dry matter (DM) (P = 0.02), organic matter (OM) (P = 0.02), non-fiber carbohydrates (NFC) (P < 0.01) and ether extract (EE) (P = 0.06). The intake of neutral detergent fiber (NDF) increased linearly (P < 0.01), whereas CP had a quadratic pattern (P = 0.02). The total digestibility in kg/d of DM (P < 0.01), OM (P < 0.01), NFC (P < 0.01) and EE (P = 0.02) decreased linearly. The total digestibility in kg/d of the NDF increased linearly (P < 0.01) and the CP had a quadratic pattern (P = 0.01). The kd of DM (P = 0.01), OM (P < 0.01) decreased linearly and NDF increased linearly (P < 0.01). The amount of N retained did not change (P = 0.72), but the intake of metabolizable protein increased (P = 0.03). Therefore, the inclusion of low-fat DDG in finishing diets reduces TDN intake and reduces the digestibility of almost all nutrients.

Controlled synthesis of distiller's grains biochar for turbidity removal in Baijiu

Resource utilization of distiller's grains (DGs) is crucial for realizing sustainable development of Baijiu industry. In the prevent investigation, a low-cost activated biochar (DGABC) suitable for removing turbidity from low-alcohol Baijiu was prepared by the controlled pyrolysis of DGs, followed by steam activation. The as-prepared biochar featured a large specific surface area (320–480 m2/g) and pore volume (0.45–0.47 cm3/g). Importantly, the DGABC possessed remarkable exterior hydrophily and interior lipophilicity, which guaranteed its good dispersion in alcohol-water system as well as an efficient adsorption to the components with long lipophilic chain. As a result, the DGABC could efficiently remove the turbidity in low-alcohol Baijiu, which was mainly derived from the long lipophilic chain components, such as ethyl palmitate. Meanwhile, most of the flavor esters that had a shorter lipophilic chain and lower hydrophobicity were well kept in the low-alcohol Baijiu. Therefore, this work provided a promising strategy for DGs recycling in Baijiu industry.

Pooled analysis on the effects of inclusion, moisture, and oil removal from distillers grains on cattle performance and economic returns in diets with different corn processing.

A synthesis of data including over 9,300 head of cattle and over 980 pen means was conducted to evaluate the effect of corn processing method, distillers grains type, oil removal from distillers, and dietary distillers concentration on cattle performance and total feeding costs under different historical price scenarios. The corn processing method was either steam-flaked corn, high-moisture or dry-rolled corn or a blend of the latter two and their effects on performance with and without distillers grains. Wet, modified, and dry distillers were analyzed as either full fat or de-oiled products in diets at various dietary concentrations with either corn type to determine cattle performance. Performance estimates were used to determine the inclusion level that minimized total finishing costs ($/head) for each diet given various assumptions on corn price, corn-to-distillers price ratio, supplemental protein cost, and steam flake processing cost. Feeding distillers grains in steam-flaked or high-moisture and dry-rolled corn diets resulted in improved feed conversion and reduced cattle feeding costs, including lower supplemental protein costs and lower total feeding costs compared with a diet without distillers. However, feeding diets with steam-flaked corn improved feed conversion regardless of distillers type or level of inclusion. Feeding full fat distillers improved feed conversion relative to de-oiled distillers. Cattle fed de-oiled distillers were more efficient than those fed diets containing no distillers grains. At all corn price and corn-to-distillers price ratios examined, feeding some level of distillers of any type produced a lower total feeding costs relative to a diet without distillers. Different robustness tests were conducted to determine the impact of varying steam flake corn processing costs and the cost of supplemental protein on the optimal level of distillers inclusion level. The break-even cost a producer could pay for steam-flaking corn varied but was significantly higher when corn price was high. Feeding distillers grains in steam-flaked or high-moisture and dry-rolled corn diets resulted in improved feed efficiency, reduced cattle feeding costs, including replacement of other supplemental protein and associated costs compared to a diet without distillers grains.

Effects of hempseed cake on ruminal fermentation parameters, nutrient digestibility, nutrient flow, and nitrogen balance in finishing steers.

Five ruminally and duodenally cannulated red angus steers (n = 5; initial body weight [BW] = 542 kg, SD = 40 kg) were used in a three-period Youden square design consisting of three 21-d periods, three treatments, and five steers (one or two steers per treatment within each period) to evaluate the effect of feeding hempseed cake on ruminal fermentation parameters, organic matter (OM) intake, total tract nutrient digestion, and nitrogen (N) balance in steers fed finishing diets. The control (CON) diet contained 75% dry-rolled corn, 20% corn silage, and 5% supplement (DM basis). The dried corn distillers grains plus solubles (DDGS) and hempseed cake (HEMP) diets contained 55% dry-rolled corn, 20% corn silage, 20% dried corn distillers grains plus solubles or hempseed cake, and 5% supplement (DM basis). Total ruminal volatile fatty acid concentration was greater (P < 0.01) in steers fed the HEMP diet than in steers fed the DDGS or CON diets. Ruminal fluid pH was not influenced (P = 0.93) by treatment. Organic matter intake tended (P = 0.07) to be greater and OM total tract digestibility was less (P = 0.03) in steers fed the HEMP diet compared with steers fed the DDGS or CON diets. Ruminal true and total tract apparent N digestibility was greater (P < 0.01) in steers fed the HEMP diet than steers fed the DDGS or CON diets. Duodenal flow of essential, nonessential, and total amino acids was not influenced (P ≥ 0.37) by dietary treatment, but the lack of response was likely because ruminally degradable protein (RDP) supply exceeded the RDP requirement. Steers fed the HEMP diet had greater (P < 0.01) N retention (g/d) than steers fed the DDGS diet, which was greater (P < 0.01) than steers fed the CON diet, suggesting that feeding hempseed cake improved utilization of N. Although inclusion of hempseed cake decreased total tract OM digestibility compared with dried corn distillers grains or corn, improvements in N utilization suggest that hempseed cake could be a useful alternative feed ingredient for finishing cattle diets.

Comparing tryptophan:lysine ratios in dried distillers grains with solubles-based diets with and without a dried distillers grains with solubles withdrawal strategy on growth, carcass characteristics, and carcass fat iodine value of growing-finishing pigs.

A total of 6,240 finishing pigs (DNA 600 × PIC 1050; initially 22.5 ± 1.00 kg), divided into two groups, were used in a 119 or 120 d study comparing increasing Trp:Lys ratio in diets containing dried distillers grains with solubles (DDGS) or a DDGS withdrawal strategy (removing all DDGS from the last phase before marketing) on growth performance and carcass fat iodine value (IV). Pigs were randomly allotted to one of seven dietary treatments with 30 to 36 pigs per pen and 26 replications per treatment. Diets were fed in four phases, approximately 23 to 44, 44 to 71, 71 to 100, and 100 kg to market. Diets included a control corn-soybean meal-based diet (no DDGS) formulated to a 19% standardized ileal digestibility (SID) Trp:Lys ratio, four diets with 30% DDGS fed in all four phases and formulated to provide SID Trp:Lys ratios of 16%, 19%, 22%, or 25%, and two DDGS withdrawal strategy diets: 19% SID Trp:Lys with 30% DDGS in phases 1 through 3 and then 0% DDGS in phase 4 with either a 19% or 25% Trp:Lys ratio. Overall, body weight (BW), average daily gain (ADG), average daily feed intake (ADFI), and gain:feed ratio (G:F) increased (linear, P < 0.05) as SID Trp:Lys ratio increased in diets with 30% DDGS fed in all phases. Simultaneously, hot carcass weight (quadratic, P = 0.014), carcass yield (quadratic, P = 0.012), and backfat depth (linear, P = 0.040) increased with increasing Trp:Lys ratio. Pigs fed the 19% SID Trp:Lys ratio withdrawal strategy diet had similar ADG and ADFI as those fed the control diet, the 25% Trp:Lys withdrawal diet, or the 30% DDGS diets with 25% Trp:Lys ratio throughout the study. Pigs fed the control diet had decreased (P < 0.05) carcass fat IV compared to pigs fed the DDGS diets throughout the study, with pigs fed the two DDGS withdrawal strategy diets intermediate. In summary, increasing the SID Trp:Lys ratio in diets with 30% DDGS resulted in a linear increase in ADG, ADFI, G:F, and BW but did not influence carcass fat IV, with most of the benefits observed as diets increased from 16% to 19% Trp:Lys. Removing DDGS from the diet in the last period reduced carcass fat IV and increased growth rate during the withdrawal period compared to pigs fed with 30% DDGS throughout, indicating value in a withdrawal strategy.

Effect of inclusion of distillers grains with solubles and crude glycerin in beef cattle finishing diets on ruminal fermentation and fatty acid biohydrogenation.

An experiment was conducted to evaluate the impact of feeding bio-fuel co-products on ruminal fermentation characteristics and composition of omasal digesta flow. Four ruminally cannulated Holstein steers (371 ± 5 kg) were used in a 4 × 4 Latin Square design. Omasal sample collection and triple marker technique was used to quantify fatty acid omasal flow. Treatments were applied as a 2 × 2 factorial where a steam flaked corn (SFC) basal diet (DGS-N CG-N) was replaced with 40% of diet DM as corn distillers grains (DGS; DGS-Y CG-N) or 10% of diet DM as crude glycerin (DGS-N CG-Y) or 40% of diet DM distillers grains and 10% of diet DM as crude glycerin (DGS-Y CG-Y). No effects were observed for the interaction of DGS and glycerin on measured rumen characteristics. Dietary inclusion of glycerin decreased (P = 0.05) ruminal content 4-h post feeding on a DM basis but did not influence DMI (P = 0.64). Feeding DGS had no effect (P = 0.34) on particulate passage to the omasum (kg/d) in spite of greater (P = 0.04) DMI. Feeding DGS reduced flow rate (% of rumen volume/h) (P = 0.05) but did not affect total VFA concentration (P = 0.46) or average ruminal pH (P = 0.72). No differences (P > 0.05) were observed in ruminal parameters when feeding glycerin, besides ruminal particulate content (kg) on DM basis (P = 0.05). An interaction of DGS and glycerin affected intake of stearic (P < 0.01), linoleic (P < 0.01), and linolenic acid (P < 0.01). An interaction of DGS and glycerin did not affect individual fatty acid flow with respect to intake for stearic (P = 0.17), linoleic (P = 0.18), or linolenic acid (P = 0.66). Dietary inclusion of glycerin had no impact on g of linolenic (P = 0.16) or linoleic (P = 0.32) acid transformed. A trend was identified for cattle fed diets with glycerin to have increased (P = 0.07) grams of conjugated linoleic acid (CLA; C18:2 cis-9, trans-11) per gram of linoleic acid intake, with no impact on the percent of saturated fat (P = 0.44) or unsaturated fat (P = 0.43) in omasal flow. For cattle fed diets with DGS, fewer grams of linoleic (P < 0.01) and linolenic (P < 0.01) were present in digesta flow per gram of intake. Inclusion of DGS in the treatment diets also increased (P < 0.01) stearic acid flow (g) and CLA flow (g) per gram of stearic and linoleic acid intake, respectively. Observed differences in CLA proportion post fermentation may indicate interrupted biohydrogenation when glycerin is fed.

Effect of substitution of distillers grains and glycerin for steam-flaked corn in finishing cattle diets on growth performance and carcass characteristics.

An experiment was conducted to determine the effect of substituting modified corn distillers grains with solubles (DGS) or crude soy glycerin (CG) for steam-flaked corn (SFC) in finishing diets on growth performance and carcass characteristics. Treatments were arranged as a 2 × 2 factorial with DGS (0% or 40%) and CG (0% or 10%) replacing dietary SFC in a basal diet. Growth performance and carcass traits were measured on 48 individually fed crossbred yearling cattle (21 steers and 27 heifers; 380 ± 37 kg). Cattle were randomly allotted to 48 Calan gate bunks. After the first 28 days, nine animals were removed from the study for health reasons or observed confirmation of consumption of feed from unassigned Calan gate bunk (n = 39). After the feeding period, cattle were harvested in two groups on day-124 and day-173. No DGS × CG interactions were observed (P > 0.10) for any dependent growth performance or carcass characteristic variable tested. Cattle-fed DGS as 40% of diet dry matter (DM) had greater (P< 0.01) dry matter intake (DMI), while CG inclusion at 10% of diet DM did not affect DMI (P = 0.16). Carcass-adjusted average daily gain (ADG) was not affected by DGS (P = 0.73) or CG (P = 0.28). Decreased (P = 0.03) carcass-adjusted gain-to-feed (G:F) was observed as the main effect of DGS. Greater DMI resulting from feeding DGS as 40% of diet DM appears to have driven the tendency for reduced G:F. Hot carcass weight, longissimus muscle area, 12th rib fat depth, yield grade, and marbling score were not (P> 0.10) influenced by DGS or CG. However, kidney, pelvic, fat (KPH) was increased (P = 0.01) when cattle were fed DGS as 40% of diet DM. Based on the findings presented, it is concluded that CG can substitute up to 10% of SFC in the diet without negatively affecting cattle growth performance or carcass characteristics, regardless of DGS inclusion as 40% of the diet DM.

High-protein dried distillers grains in dog diets: diet digestibility and palatability, intestinal fermentation products, and fecal microbiota.

This study aimed to evaluate the effects of high-protein dried distillers grains (HPDDG) on palatability and metabolizable energy (ME) of the diet, apparent total tract digestibility (ATTD) of nutrients and energy, intestinal fermentation products, and fecal microbiota in dogs. Four diets containing 0, 70, 140, and 210 g/kg of HPDDG were manufactured. To evaluate the ME and the ATTD of macronutrients of HPDDG itself, an additional test diet was manufactured containing 70% of the control diet formula (0 g/kg) and 300 g/kg of HPDDG. Fifteen adult Beagle dogs were distributed in a randomized block design, with two periods of 15 d each (n = 6). The HPDDG digestibility was obtained using the Matterson substitution method. For the palatability test, 16 adult dogs were used, comparing the diets: 0 vs. 70 g/kg of HPDDG and 0 vs. 210 g/kg of HPDDG. The ATTD of HPDDG were: dry matter = 85.5%, crude protein = 91.2%, and acid-hydrolyzed ether extract = 84.6% and the ME content was 5,041.8 kcal/kg. The ATTD of macronutrients and ME of the diets and the fecal dry matter, score, pH, and ammonia of the dogs did not differ among treatments (P > 0.05). There was a linear increase in the fecal concentrations of valeric acid with the inclusion of HPDDG in the diet (P < 0.05). Streptococcus and Megamonas genera reduced linearly (P < 0.05), and Blautia, Lachnospira, Clostridiales, and Prevotella genera showed a quadratic response to the inclusion of HPDDG in the diet (P < 0.05). Alpha-diversity results showed an increase (P < 0.05) in the number of operational taxonomic units and Shannon index and a trend (P = 0.065) for a linear increase in the Chao-1 index with the dietary inclusion of HPDDG. Dogs preferred the 210 g/kg diet over the 0 g/kg HPDDG diet (P < 0.05). These results demonstrate that the HPDDG evaluated does not affect the utilization of nutrients in the diet, but it may modulate the fecal microbiome of dogs. In addition, HPDDG may contribute to diet palatability for dogs.

Performance response of increasing the standardized ileal digestible tryptophan:lysine ratio in diets containing 40% dried distiller grains with solubles.

A total of 1,170 pigs (PIC 800 × PIC, initially 38.6 kg) were used in a 98-d grow-finish study to determine the performance response of pigs fed increasing levels standardized ileal digestible (SID) Trp:Lys ratio in diets containing 40% dried distillers grains with solubles (DDGS). Five dietary treatments were fed and consisted of a corn-soybean meal (SBM) diet or diets containing 40% DDGS with SID Trp:Lys ratios of 15%, 18%, 21%, or 24%. Each treatment was replicated 9 times and pens contained 26 pigs with the equal number of gilts and barrows. Data was analyzed as a randomized complete block design with previous nursery treatment as a random blocking factor. Pair-wise comparisons were used to evaluate the impact of diets on performance and carcass traits; specifically to compare the corn-SBM dietary treatment against other dietary treatments. Single degree of freedom orthogonal polynomials were used to evaluate the dose-response of increasing the SID Trp:Lys ratio in 40% DDGS diets. Increasing the SID Trp:Lys ratio in diets containing 40% DDGS increased (linear, P ≤ 0.02) average daily gain (ADG), average daily feed intake (ADFI), final body weight (BW), hot carcass weight (HCW), carcass gain, and daily carcass gain. Increasing the SID Trp:Lys ratio in 40% DDGS diets did not impact (P ≥ 0.65) gain to feed (G:F) for the cumulative period. Pigs fed the corn-SBM diet had greater (P ≤ 0.01) ADG and a heavier (P ≤ 0.01) final BW compared to pigs fed 40% DDGS diets, regardless of the SID Trp:Lys ratio. Diets that contained 40% DDGS with a SID Trp:Lys ratio of 24% had no difference (P|t| = 0.25) in ADFI compared to the corn-SBM dietary treatment. The cumulative G:F of pigs did not differ (P = 0.32) between pigs fed corn-SBM diets and diets containing 40% DDGS regardless of the SID Trp:Lys ratio. However, pigs receiving the corn-SBM diets had heavier HCW, greater carcass yields, total carcass gain, and daily carcass gain (P < 0.01) compared to pigs fed the 40% DDGS diets regardless of SID Trp:Lys ratio. In conclusion, increasing the SID Trp:Lys ratio in 40% DDGS diets improved ADG and ADFI for the overall grow-finish period. However, when compared to a corn-SBM diet, increasing the SID Trp:Lys ratio in 40% DDGS diets did not correct the growth performance or carcass characteristics of pigs.

Effects of replacing corn silage with alfalfa haylage in growing beef cattle diets on performance during the growing and finishing period.

Corn silage is the predominant mechanically harvested forage source for feedlot cattle production in the United States because of high yield. Alternatively, because of multiple cuttings per year and lower annual cost, the use of alfalfa or other forages, may increase opportunities for manure spreading, perennial soil cover, pollinator habitat, and greater carbon sequestration. The objective of this trial was to determine the feeding value of alfalfa haylage when replacing corn silage in growing cattle diets. One-hundred-sixty-five Angus crossbred steers [326 ± 51 kg of body weight (BW)] were blocked by initial BW and randomly assigned to one of 28 pens at the University of Minnesota feedlot. Pens were randomly assigned to dietary growing treatments. The control diet was comprised of (DM basis) 50% corn silage, 19.25% rolled corn grain, 19.25% high moisture corn, 7% dried distillers grains plus solubles, and 4.5% liquid supplement (corn silage control, CS Control). For alfalfa haylage (AH) diets, AH substituted corn silage at 33% (AH 33), 66% (AH 66), or 100% (AH 100). Growth performance measurements [dry matter intake (DMI), average daily gain (ADG) and gain to feed (G:F) ratio] were assessed for 42 to 70 d depending on BW block. Afterwards, steers were fed a common finishing diet until harvested. There was a linear increase in DMI (P < 0.01) with increasing AH inclusion. Replacing CS with AH linearly decreased (P ≤ 0.05) ADG and G:F. No differences (P ≥ 0.10) were observed in finishing performance or carcass traits. Results from this study demonstrated that greater substitution of corn silage with alfalfa haylage in growing diets resulted in greater intake but reduced rate of gain and gain:feed. Despite slower rate of gain, cattle fed alfalfa haylage at increasing proportions during the growing period were able to compensate in BW gains during the finishing period and reached harvest weight and backfat thickness at similar days on feed than those fed corn silage. Based on these results the energy value of corn silage and alfalfa haylage were 3.05 and 2.39 Mcal ME/kg of DM, respectively, when included at 50% of the diet DM.

Rumen and cecum bacteria of beef cattle that differ in feed efficiency fed a forage diet.

Most of the research addressing feed efficiency and the microbiota has been conducted in cattle fed grain diets, although cattle evolved to consume forage diets. Our hypothesis was that the bacteria in the rumen and cecum differed in cattle that have a common feed intake but had different ^average daily body weight gains (ADG) on a forage diet. Heifers (n = 134) were 606 ± 1 d of age and weighed 476 ± 3 kg at the start of the 84-d feeding study. Heifers were offered ad libitum access to a totally mixed ration that consisted of 86% ground brome hay, 10% wet distillers grains with solubles, and 4% mineral supplement as dry matter. Feed intake and body weight gain were measured, and gain was calculated. Heifers with the least (n = 8) and greatest (n = 8) ADG within 0.32 SD of the mean daily dry matter intake were selected for sampling. Digesta samples from the rumen and cecum were collected, and subsequent 16S analysis was conducted to identify Amplicon Sequence Variants. There were no differences in Alpha and Beta diversity between ADG classification within sample sites (P > 0.05). Both sample sites contained calculated balances of sister clades using phylogenetic isometric log ratio transferred data that differed across ADG classification. These findings suggest that bacteria did not differ at the community level, but there was structural difference at the clade level.

Polyunsaturated fatty acids and rumen undegradable protein alter ruminal fermentation and milk fatty acid profiles in dairy cows

ABSTRACT The present study evaluated the effects of incorporating polyunsaturated fatty acid (PUFA)- and rumen undegradable protein (RUP)-enriched feeds on ruminal fermentation, methane production, milk yield and milk FA profiles in dairy cows. Experiment 1 was carried out on 12 multiparous HF dairy cows in mid-lactation (106 ± 18.6 days in milk, 13.1 ± 1.67 kg/d of milk). Environmental conditions throughout the experiment were 34.5 ± 1.9 8°C, 58.0 ± 2.65% relative humidity and 85.7 ± 2.71 temperature–humidity index. Cows (n = 6/group) were randomly allocated to a control diet (Ctrl) consisting of corn silage and concentrate (F:C 60:40) containing 27.2% RUP in the crude protein (CP) or a treatment diet (Trt) consisting of 58.3% corn silage, 29.6% concentrate, 3.24% roasted soybean meal, 5.82% corn dried distiller grains with solubles and 3% added oil, which contained linseed, sunflower and tuna crude oil (1:1:1, wt/wt). The Trt diet contained 35.0% RUP in the CP. Experiment 2 was conducted in vitro using ruminal fluid collected from three Holstein Friesian dairy cows. The experimental design and diets were the same as in Exp. 1. Dry matter intake (DMI) tended to be lower (P = 0.06) in the Trt group. No difference in milk yield was detected, but the lower (P < 0.01) milk fat was measured in the Trt group (2.82% vs. 3.81%). Feed efficiency (milk/DMI) tended to be greater (P = 0.06) in the Trt cows (1.08 vs. 0.88). Lower 18:0 (5.73% vs. 8.29%), but greater concentrations of c9,t11 CLA (1.88% vs. 0.34%), c9,c12 18:2 (1.55% and 0.69%) 18:3n-3 (0.30% vs. 0.12%) and 22:6n-3 (0.17% vs. 0%) were detected in milk fat of cows fed Trt (P < 0.01). Atherogenicity and thrombogenic indices were lower (P < 0.01) with Trt. Concentrations of ruminal total volatile fatty acids and methane, which was assessed by production of volatile fatty acids, were 10.2% and 11.7% lower P < 0.01) in the Trt group. In conclusion, incorporating PUFA- and RUP-high feeds in lactating cow diets in the tropics causes a reduction in concentrations of ruminal VFA, methane production and milk fat while improving aspects of milk quality without affecting milk production.

Effect of Distiller's Grains Biochar Combined with Lactobacillus plantarum on Remediation of Lead, Cadmium and Zinc Complex contaminated Soil

Aiming to clarify the effect of Lactobacillus plantarum combined with distiller's grains biochar on lead, cadmium and zinc complex contaminated soil, a pot experiment was conducted to investigate soil effective heavy metal concentration, plant growth, and heavy metal accumulation in the Sorghum hybrid sudangrass. The results revealed that single application of distiller's grains biochar, Lactobacillus plantarum thallus, Lactobacillus plantarum supernatant, and combined application of distiller's grain biochar and Lactobacillus plantarum thallus could significantly reduce the content of available Cd, Pb, and Zn in soil (P&lt;0.05), and reduced the aboved metals content in the aerial parts and roots of Sorghum hybrid sudangrass to varying degrees. Compared with control group, high dosage of distiller's grain biochar and Lactobacillus plantarum thallus combined application treated Sorghum hybrid sudangrass with the lowest heavy metals content. The concentrations of Cd, Pb, and Zn decreased by 40.93%, 31.84%, and 40.25% in the aerial part, respectively, and decreased by 41.09%, 21.79%, and 29.62% in the root, respectively. The high dosage of distiller's grains biochar and the combination application of distiller's grains biochar and Lactobacillus plantarum thallus significantly increased the plant height and biomass of Sorghum hybrid sudangrass (P&lt;0.05), and the overall promotion effect was better than other treatments.

Dietary replacement of soybean meal with heat-treated soybean meal or high-protein corn distillers grains on nutrient digestibility and milk composition in mid-lactation cows.

Lactation diets dependent on rumen undegradable protein (RUP) sources derived from soybean meal (SBM) products are generally high in Lys and poor in Met. We conducted an experiment to evaluate the effects of increasing dietary RUP and altering digestible AA supply by inclusion of heat-treated soybean meal (HTSBM) or high-protein corn dried distillers grains with soluble (DDGS) on performance in mid-lactation dairy cows. Twenty-four Holstein cows (200 ± 40 d in milk and 30.0 ± 3.92 kg/d of milk yield) blocked according to parity, milk yield, and days in milk were used in a 3 × 3 Latin square design experiment with 21-d periods. Treatments were (1) control (CON), a diet with 6.0% RUP containing 15.9% SBM as the main protein source; (2) HTSBM, a diet with 6.7% RUP containing 4.4% HTSBM partially replacing SBM; and (3) high-protein DDGS (FP; FlexyPro, SJC Bioenergia), a diet with 6.9% RUP containing 5.34% FP partially replacing SBM and ground corn. Diets had similar crude protein (16.9%) and net energy of lactation. Data were submitted to ANOVA using the mixed procedure of SAS software (SAS Institute Inc.). Treatment differences were evaluated using orthogonal contrasts: (1) increasing RUP (SBM vs. HTSBM + FP) and (2) altering digestible AA supply (HTSBM vs. FP). Cows fed HTSBM and FP had greater intake (values in parentheses represent treatment means of CON, HTSBM, and FP, respectively) of neutral detergent fiber (7.14, 7.35, and 7.69 kg/d), crude protein (4.27, 4.37, and 4.51 kg/d), and ether extract (0.942, 0.968, and 1.04 kg/d) compared with cows fed CON. Feeding FP resulted in greater intake of neutral detergent fiber and ether extract compared with HTSBM. Cows fed HTSBM and FP had lower sorting index for feed particles <4 mm than cows fed CON (1.029, 1.008, and 1.022). Feeding FP resulted in greater intake of feed particles <4 mm compared with HTSBM. Treatments containing HTSBM or FP tended to decrease organic matter digestibility (72.4, 71.2, and 71.1%), but no other effects were detected in digestibility of neutral detergent fiber, crude protein, or ether extract. No evidence for differences among treatments was detected in excretion of purine derivatives in milk and urine. Milk yield was greater in cows fed HTSBM or FP than in cows fed CON (28.0, 28.9, and 28.8 kg/d, respectively). Cows fed HTSBM or FP tended to have greater energy-corrected milk and protein yield compared with those fed CON. Milk protein concentration was greater in DDGS cows than those in the HTSBM group (3.45 and 3.40%, respectively). No differences were detected in milk fat yield and concentration, milk urea nitrogen, feed efficiency, or serum concentrations of urea and glucose. Overall, increasing dietary RUP by feeding HTSBM or FP improved intake of nutrients and milk yield without affecting feed efficiency. Altering digestible AA supply while maintaining similar dietary RUP had negligible effects on performance of cows.