Defined Mineral Medium Research Articles

Microbial synthesis of the plant natural product precursor p-coumaric acid with Corynebacterium glutamicum

BackgroundPhenylpropanoids such as p-coumaric acid represent important precursors for the synthesis of a broad range of plant secondary metabolites including stilbenoids, flavonoids, and lignans, which are of pharmacological interest due to their health-promoting properties. Although extraction from plant material or chemical synthesis is possible, microbial synthesis of p-coumaric acid from glucose has the advantage of being less expensive and more resource efficient. In this study, Corynebacterium glutamicum was engineered for the production of the plant polyphenol precursor p-coumaric acid from glucose.ResultsHeterologous expression of the tyrosine ammonia-lyase encoding gene from Flavobacterium johnsoniae enabled the conversion of endogenously provided tyrosine to p-coumaric acid. Product consumption was avoided by abolishing essential reactions of the phenylpropanoid degradation pathway. Accumulation of anthranilate as a major byproduct was eliminated by reducing the activity of anthranilate synthase through targeted mutagenesis to avoid tryptophan auxotrophy. Subsequently, the carbon flux into the shikimate pathway was increased, phenylalanine biosynthesis was reduced, and phosphoenolpyruvate availability was improved to boost p-coumaric acid accumulation. A maximum titer of 661 mg/L p-coumaric acid (4 mM) in defined mineral medium was reached. Finally, the production strain was utilized in co-cultivations with a C. glutamicum strain previously engineered for the conversion of p-coumaric acid into the polyphenol resveratrol. These co-cultivations enabled the synthesis of 31.2 mg/L (0.14 mM) resveratrol from glucose without any p-coumaric acid supplementation.ConclusionsThe utilization of a heterologous tyrosine ammonia-lyase in combination with optimization of the shikimate pathway enabled the efficient production of p-coumaric acid with C. glutamicum. Reducing the carbon flux into the phenylalanine and tryptophan branches was the key to success along with the introduction of feedback-resistant enzyme variants.

Investigation of Kluyveromyces marxianus as a novel host for large\u2010scale production of porcine parvovirus virus\u2010like particles

BackgroundPorcine Parvovirus (PPV) is a Parvovirinae virus that can cause embryonic and fetal loss and death and mummification in affected fetal pigs. Unlike conventional vaccines, virus-like particles (VLPs) inherit the natural structure of their authentic virions and highly immunostimulatory that can induce strong humoral immune and T cell responses with no risk of pathogenicity. The production of PPV VLPs is still a challenge based on traditional expression platforms due to their low yields and high culture costs. Kluyveromyces marxianus is a safe and fast-growing eukaryote that can get high biomass with low-cost cultures. In this study, we investigated the expression and downstream processes of PPV VLPs in K. marxianus, and the potential for effective stand-alone vaccines.ResultsAfter optimization according to the codon bias of K. marxianus, the VP2 protein from Kresse strain was highly expressed. In a 5 L fermentator, the yield of PPV VLPs reached 2.5 g/L, quantified by HPLC, using a defined mineral medium after 48 h fermentation. Two strategies were established to purify intracellular PPV VLPs: (i) Using the cation exchange chromatography coupled with Sephacryl® S-500 HR chromatography to purify VLPs from the supernatants of pH adjusted cell lysates. (ii) Using anion exchange chromatography followed by cross-flow diafiltration to recover the VLPs precipitated in pH adjusted cell lysates. The purity of PPV VLPs reached about 95%, and total recovery was more than 60%. Vaccination of mice with the purified PPV VLPs induced high titers of specific IgG antibodies in sera, and showed hemagglutination inhibitions on both swine and guinea pig erythrocytes. Spleen lymphocyte proliferation and cytokines detection suggested the PPV VLPs produced by K. marxianus provoked the cellular immune and humoral immunity responses in mice.ConclusionsThis is the highest production of recombinant PPV VLPs achieved to date. The superiorities, Generally Recognized As Safe (GRAS), high production, short lead time, and low cost, make K. marxianus a greatly competitive platform for bioproduction of PPV VLPs vaccine.

Growth Behavior of Selected Ustilaginaceae Fungi Used for Mannosylerythritol Lipid (MEL) Biosurfactant Production - Evaluation of a Defined Culture Medium.

Fungi of the Ustilaginaceae family are a promising source for many biotechnologically relevant products. Among these, mannosylerythritol lipid (MEL) biosurfactants have drawn a special interested over the last decades due to their manifold application possibilities. Nevertheless, there is still a knowledge gap regarding process engineering of MEL production. As an example, no reports on the use of a chemically defined culture medium have been published yet, although such a defined medium might be beneficial for scaling-up the production process toward industrial scale. Our aim therefore was to find a mineral medium that allows fast biomass growth and does not negatively affect the successive MEL production from plant oils. The results showed comparable growth performance between the newly evaluated mineral medium and the established yeast extract medium for all seven investigated Ustilaginaceae species. Final biomass concentrations and specific growth rates of 0.16-0.25 h–1 were similar for the two media. Oxygen demand was generally higher in the mineral medium than in the yeast extract medium. It was shown that high concentrations of vitamins and trace elements were necessary to support the growth. Increasing starting concentrations of the media by a factor of 10 resulted in proportionally increasing final biomass concentrations and up to 2.3-times higher maximum growth rates for all species. However, it could also lead to oxygen limitation and stagnant growth rates when too high medium concentrations were used, which was observed for Ustilago siamensis and Moesziomyces aphidis. Successive MEL production from rapeseed oil was effectively shown for 4 out of 7 organisms when the mineral medium was used for cell growth, and it was even enhanced for two organisms, M. aphidis and Pseudozyma hubeiensis pro tem., as compared to the established yeast extract medium. Conversion of rapeseed oil into MEL was generally improved when higher biomass concentrations were achieved during the initial growth phase, indicating a positive relationship between biomass concentration and MEL production. Overall, this is the first report on the use of a chemically defined mineral medium for the cell growth of Ustilaginaceae fungi and successive MEL production from rapeseed oil, as an alternative to the commonly employed yeast extract medium.

Scale-up of a Type I secretion system in E. coli using a defined mineral medium.

Secretion of heterologous proteins into the culture supernatant in laboratory strains of Escherichia coli is possible by utilizing a Type I secretion system (T1SS). One prominent example for a T1SS is based on the hemolysin A toxin. With this system, heterologous protein secretion has already been achieved. However, no cultivations in a defined mineral medium and in stirred tank bioreactors have been described in literature up to now, hampering the broad applicability of the system. In this study, a mineral medium was developed for cultivation under defined conditions. With this medium, the full potential and advantage of a secretion system in E. coli (low secretion of host proteins, no contamination with proteins from complex media compounds) can now be exploited. Additionally, quantification of the protein amount in the supernatant was demonstrated by application of the Bradford assay. In this work, host cell behavior was described in small scale by online monitoring of the oxygen transfer rate. Scalability was demonstrated by stirred tank fermentation yielding 540 mg/L HlyA1 in the supernatant. This work enhances the applicability of a protein secretion system in E. coli and paves the way for an industrial application.

Degradation of decabromodiphenyl ether (BDE-209) in microcosms mimicking sediment environment subjected to comparative bioremediation strategies

The aim of this study was to examine bioremediation strategies for BDE-209 contaminated sediments. Sediment microcosms were established to observe anaerobic debromination of BDE-209 under conditions representing three bioremediation strategies: biostimulation, bioaugmentation and natural attenuation. To simulate biostimulation, a defined mineral medium containing both a carbon source (sodium formate) and electron donor (ethanol) was added into sediments. Bioaugmentation was established by enrichment of the sediments using a culture of Dehalobium chlorocoercia strain DF-1, previously shown to dechlorinate polychlorinated biphenyls, to sediments. No amendments were made to the third set in order to represent natural attenuation. The biostimulation, bioaugmentation and natural attenuation strategies resulted in 55.3%, 40.2% and 30.9% reductions in BDE-209, respectively, after 180 days. Nona- through tri-BDEs were observed as products, with 17 PBDE congeners detected in 25 different proposed debromination pathways. At the end of the 180 day incubation period, the products for bioaugmentation, biostimulation and natural attenuation were tri-BDEs, tetra-BDEs and penta-BDEs, respectively. The proposed pathways revealed that meta- and ortho-Br removal were favored in sediments, and that debromination regiospecificity varied with each bioremediation strategy applied. Lastly, pseudo-first-order rate constants for BDE-209 reduction were calculated as 0.0049 d−1, 0.0028 d−1, 0.0025 d−1 for biostimulation, bioaugmentation and natural attenuation, respectively.

Experimental validation of in silico estimated biomass yields of Pseudomonas putida KT2440.

Pseudomonas putida is rapidly becoming a microbial cell platform for biotechnological applications. In order to understand genotype-phenotype relationships genome scale models represent helpful tools. However, the validation of in silico predictions of genome scale models is a task that is rarely performed. In this study the theoretical biomass yields of Pseudomonas putida KT2440 were estimated for 57 different carbon sources based on a genome scale stoichiometric model applying flux balance analysis. The batch growth of P. putida KT2440 with six individual carbon sources covering the range of maximal to minimal in silico biomass yields (acetate, glycerol, citrate, succinate, malate and methanol, respectively) was studied in a defined mineral medium in a fully controlled stirred-tank bioreactor on a 3 L scale. The highest growth rate of P. putida KT2440 was measured with succinate as carbon source (0.51 h-1 ). Among the 57 carbon sources tested, glycerol resulted in the highest estimated biomass yield (0.61 molCBiomass molC-1Glycerol ) which was experimentally confirmed. The comparison of experimental determined biomass yields with a modified version of the model iJP815 showed deviations of only up to 10%. The experimental data generated in this study can also be used in future studies to further improve the genome scale models of P. putida KT2440. Improved models will then help to gain deeper insights in genotype-phenotype relationships.

A novel ATP-generating machinery to counter nitrosative stress is mediated by substrate-level phosphorylation

BackgroundIt is well-known that elevated amounts of nitric oxide and other reactive nitrogen species (RNS) impact negatively on the tricarboxylic acid (TCA) cycle and oxidative phosphorylation. These perturbations severely compromise O2-dependent energy production. While bacteria are known to adapt to RNS, a key tool employed by macrophages to combat infections, the exact mechanisms are unknown. MethodsThe bacterium was cultured in a defined mineral medium and cell-free extracts obtained at the same growth phase were utilized for various biochemical studies Blue native polyacrylamide gel electrophoresis followed by in-gel activity assays, high performance liquid chromatography and co-immunoprecipitaton are applied to investigate the effects of RNS on the model microbe Pseudomonas fluorescens. ResultsCitrate is channeled away from the tricarboxylic acid cycle using a novel metabolon consisting of citrate lyase (CL), phosphoenolpyruvate carboxylase (PEPC) and pyruvate phosphate dikinase (PPDK). This metabolic engine comprising three disparate enzymes appears to transiently assemble as a supercomplex aimed at ATP synthesis. The up-regulation in the activities of adenylate kinase (AK) and nucleoside diphosphate kinase (NDPK) ensured the efficacy of this ATP-making machine. ConclusionMicrobes may escape the effects of nitrosative stress by re-engineering metabolic networks in order to generate and store ATP anaerobically when the electron transport chain is defective. General significanceThe molecular configuration described herein provides further understanding of how metabolism plays a key role in the adaptation to nitrosative stress and reveals novel targets that will inform the development of antimicrobial agents to counter RNS-resistant pathogens.

Metabolic studies of γ-polyglutamic acid production in Bacillus licheniformis by small-scale continuous cultivations

For the cultivation of microorganisms shake flasks are frequently used. The development of the broth viscosity during the cultivation is usually not paid special attention to. However, changes in viscosity may have a severe impact on shake flask cultivations, ranging from effects on mass and heat transfer to the occurrence of out-of-phase conditions. Significant changes in viscosity were observed during batch cultivations with Bacillus licheniformis on defined mineral medium. The formed biopolymer was identified to be γ-polyglutamic acid (γ-PGA), a polymer, Bacillus species are known to excrete as a side-product. γ-PGA leads to increasing viscosity and, thus, has critical influences on shake flask cultivations. Consequently, the oxygen transfer is strongly influenced by viscosity and, therefore, γ-PGA formation. Furthermore, γ-PGA has chelating characteristics, which might affect nutrient and trace element availability, possibly resulting in substrate limitations. In total, these influences lead to undefined conditions in the fermentation. Therefore, the trigger for γ-PGA production was investigated. By performing continuous cultivation experiments as well as pulse experiments, catabolite controlled overflow was identified as one of the key triggers for γ-PGA production. The results suggest, that catabolite controlled overflow leads to inhibition of the 2-oxoglutarate complex, resulting in accumulation of 2-oxoglutarate and a redirection of metabolic flux toward glutamic acid and finally to γ-PGA. Additionally, oxygen limitations were determined to further potentiate γ-PGA production. As a result, fermentation conditions favoring catabolite controlled overflow as well as oxygen limitation need to be strictly avoided in order to assure defined conditions at low viscosity throughout the fermentation.

The metabolic burden of cellulase expression by recombinant Saccharomyces cerevisiae Y294 in aerobic batch culture

Two recombinant strains of Saccharomyces cerevisiae Y294 producing cellulase using different expression strategies were compared to a reference strain in aerobic culture to evaluate the potential metabolic burden that cellulase expression imposed on the yeast metabolism. In a chemically defined mineral medium with glucose as carbon source, S. cerevisiae strain Y294[CEL5] with plasmid-borne cellulase genes produced endoglucanase and β-glucosidase activities of 0.038 and 0.30 U mg dry cell weight(-1), respectively. Chromosomal expression of these two cellulases in strain Y294[Y118p] resulted in no detectable activity, although low levels of episomally co-expressed cellobiohydrolase (CBH) activity were detected. Whereas the biomass concentration of strain Y294[CEL5] was slightly greater than that of a reference strain, CBH expression by Y294[Y118p] resulted in a 1.4-fold lower maximum specific growth rate than that of the reference. Supplementation of the growth medium with amino acids significantly improved culture growth and enzyme production, but only partially mitigated the physiological effects and metabolic burden of cellulase expression. Glycerol production was decreased significantly, up to threefold, in amino acid-supplemented cultures, apparently due to redox balancing. Disproportionately higher levels of glycerol production by Y294[CEL5] indicated a potential correlation between the redox balance of anabolism and the physiological stress of cellulase production. With the reliance on cellulase expression in yeast for the development of consolidated bioprocesses for bioethanol production, this work demonstrates the need for development of yeasts that are physiologically robust in response to burdens imposed by heterologous enzyme production.

Selective Utilization of Exogenous Amino Acids by Dehalococcoides ethenogenes Strain 195 and Its Effects on Growth and Dechlorination Activity

Bacteria of the genus Dehalococcoides are important members of bioremediation communities because of their ability to detoxify chloroethenes to the benign end product ethene. Genome-enabled studies conducted with Dehalococcoides ethenogenes 195 have revealed that two ATP-binding cassette (ABC)-type amino acid transporters are expressed during its exponential growth stages. In light of previous findings that Casamino Acids enhanced its dechlorination activity, we hypothesized that strain 195 is capable of importing amino acids from its environment to facilitate dechlorination and growth. To test this hypothesis, we applied isotopomer-based dilution analysis with (13)C-labeled acetate to differentiate the amino acids that were taken up by strain 195 from those synthesized de novo and to determine the physiological changes caused by the significantly incorporated amino acids. Our results showed that glutamate/glutamine and aspartate/asparagine were almost exclusively synthesized by strain 195, even when provided in excess in the medium. In contrast, phenylalanine, isoleucine, leucine, and methionine were identified as the four most highly incorporated amino acids, at levels >30% of respective proteinogenic amino acids. When either phenylalanine or all four highly incorporated amino acids were added to the defined mineral medium, the growth rates, dechlorination activities, and yields of strain 195 were enhanced to levels similar to those observed with supplementation with 20 amino acids. However, genes for the putative ABC-type amino acids transporters and phenylalanine biosynthesis exhibited insignificant regulation in response to the imported amino acids. This study also demonstrates that using isotopomer-based metabolite analysis can be an efficient strategy for optimizing nutritional conditions for slow-growing microorganisms.

Expression of human interleukin-1β in Saccharomyces cerevisiae using PIR4 as fusion partner and production in aerated fed-batch reactor

To circumvent cell wall retention commonly associated to Saccharomyces cerevisiae when used as a host for heterologous protein production, we have created a translational fusion of human interleukin-1β (IL-1β) to the Pir4 cell wall protein, so as to drive the secretion of the recombinant product to the growth medium. The auxotrophic S. cerevisiae BY4741 was used as host to express the Pir4-IL1β fusion protein. Once it was ascertained that the fusion protein was secreted to the culture medium and behaved as a growth-linked product, S. cerevisiae BY4741 [PIR4-IL1β] was cultured in an aerated fed-batch reactor to achieve high cell density and, consequently, high product concentration in the medium. Two cultivation media were employed, a rich complex and a defined mineral medium, the latter suitably supplemented with bacto-casamino acids as ACA (auxotrophy-complementing amino acid) source. The rich complex medium allowed a good performance of the producer strain only during batch growth, but was revealed to be inadequate for long-term fed-batch operations. The defined mineral medium ensured a better performance, even though not yet satisfactory in spite of a proper ACA supplementation. The behaviour of BY4741 was attributed to an intrinsic sensitivity of the producer strain to long-term aerated fed-batch operations.

Performance of the auxotrophic Saccharomyces cerevisiae BY4741 as host for the production of IL-1β in aerated fed-batch reactor: role of ACA supplementation, strain viability, and maintenance energy

BackgroundSaccharomyces cerevisiae BY4741 is an auxotrophic commonly used strain. In this work it has been used as host for the expression and secretion of human interleukin-1β (IL1β), using the cell wall protein Pir4 as fusion partner. To achieve high cell density and, consequently, high product yield, BY4741 [PIR4-IL1β] was cultured in an aerated fed-batch reactor, using a defined mineral medium supplemented with casamino acids as ACA (auxotrophy-complementing amino acid) source. Also the S. cerevisiae mutant BY4741 Δyca1 [PIR4-IL1β], carrying the deletion of the YCA1 gene coding for a caspase-like protein involved in the apoptotic response, was cultured in aerated fed-batch reactor and compared to the parental strain, to test the effect of this mutation on strain robustness. Viability of the producer strains was examined during the runs and a mathematical model, which took into consideration the viable biomass present in the reactor and the glucose consumption for both growth and maintenance, was developed to describe and explain the time-course evolution of the process for both, the BY4741 parental and the BY4741 Δyca1 mutant strain.ResultsOur results show that the concentrations of ACA in the feeding solution, corresponding to those routinely used in the literature, are limiting for the growth of S. cerevisiae BY4741 [PIR4-IL1β] in fed-batch reactor. Even in the presence of a proper ACA supplementation, S. cerevisiae BY4741 [PIR4-IL1β] did not achieve a high cell density. The Δyca1 deletion did not have a beneficial effect on the overall performance of the strain, but it had a clear effect on its viability, which was not impaired during fed-batch operations, as shown by the kd value (0.0045 h-1), negligible if compared to that of the parental strain (0.028 h-1). However, independently of their robustness, both the parental and the Δyca1 mutant ceased to grow early during fed-batch runs, both strains using most of the available carbon source for maintenance, rather than for further proliferation. The mathematical model used evidenced that the energy demand for maintenance was even higher in the case of the Δyca1 mutant, accounting for the growth arrest observed despite the fact that cell viability remained comparatively high.ConclusionsThe paper points out the relevance of a proper ACA formulation for the outcome of a fed-batch reactor growth carried out with S. cerevisiae BY4741 [PIR4-IL1β] strain and shows the sensitivity of this commonly used auxotrophic strain to aerated fed-batch operations. A Δyca1 disruption was able to reduce the loss of viability, but not to improve the overall performance of the process. A mathematical model has been developed that is able to describe the behaviour of both the parental and mutant producer strain during fed-batch runs, and evidence the role played by the energy demand for maintenance in the outcome of the process.

Growth phase‐dependent global protein and metabolite profiles of Phaeobacter gallaeciensis strain DSM 17395, a member of the marine Roseobacter‐clade

The marine heterotrophic roseobacter Phaeobacter gallaeciensis DSM 17395 was grown with glucose in defined mineral medium. Relative abundance changes of global protein (2-D DIGE) and metabolite (GC-MS) profiles were determined across five different time points of growth. In total, 215 proteins were identified and 147 metabolites detected (101 structurally identified), among which 60 proteins and 87 metabolites displayed changed abundances upon entry into stationary growth phase. Glucose breakdown to pyruvate apparently proceeds via the Entner-Doudoroff (ED) pathway, since phosphofructokinase of the Embden-Meyerhof-Parnas pathway is missing and the key metabolite of the ED-pathway, 2-keto-3-desoxygluconate, was detected. The absence of pfk in other genome-sequenced roseobacters suggests that the use of the ED pathway is an important physiological property among these heterotrophic marine bacteria. Upon entry into stationary growth phase (due to glucose starvation), sulfur assimilation (including cysteine biosynthesis) and parts of cell envelope synthesis (e.g. the lipid precursor 1-monooleoylglycerol) were down-regulated and cadaverine formation up-regulated. In contrast, central carbon catabolism remained essentially unchanged, pointing to a metabolic "stand-by" modus as an ecophysiological adaptation strategy. Stationary phase response of P. gallaeciensis differs markedly from that of standard organisms such as Escherichia coli, as evident e.g. by the absence of an rpoS gene.

Verminephrobacter eiseniae gen. nov., sp. nov., a nephridial symbiont of the earthworm Eisenia foetida (Savigny)

A Gram-negative, flagellated, heterotrophic, catalase-negative, rod-shaped bacterium previously identified as an earthworm symbiont was isolated from nephridia of the earthworm Eisenia foetida. Comparisons of 16S rRNA gene sequences indicated its relatedness to the betaproteobacterial genus Acidovorax and the novel isolates shared 92-94% sequence similarity with recognized species of this genus. Gene sequence phylogenies revealed that the group of earthworm symbionts formed a cohesive and independent clade. The DNA G+C content was 67.0+/-0.2 mol%. Major fatty acids were C(16:0), C(16:1)omega7c and C(17:0) cyclo. While capable of growing in fully aerated media, all isolates favoured low oxygen concentrations and all required biotin or a mix of amino acids in order to grow on defined mineral media. Based on phylogenies inferred from three housekeeping gene sequences (gap, recA and rpoC), DNA-DNA hybridization values, the unique ecology and the distinct physiology of the novel strains, the new genus Verminephrobacter gen. nov. is proposed for the earthworm nephridial symbionts. The name Verminephrobacter eiseniae sp. nov. is proposed for the type species with strain EF01-2(T) (=ATCC BAA-1489(T)=DSM 19286(T)) as the type strain of the type species.

NADH- vs NADPH-coupled reduction of 5-hydroxymethyl furfural (HMF) and its implications on product distribution in Saccharomyces cerevisiae

Saccharomyces cerevisiae alcohol dehydrogenases responsible for NADH-, and NADPH-specific reduction of the furaldehydes 5-hydroxymethyl-furfural (HMF) and furfural have previously been identified. In the present study, strains overexpressing the corresponding genes (mut-ADH1 and ADH6), together with a control strain, were compared in defined medium for anaerobic fermentation of glucose in the presence and absence of HMF. All strains showed a similar fermentation pattern in the absence of HMF. In the presence of HMF, the strain overexpressing ADH6 showed the highest HMF reduction rate and the highest specific ethanol productivity, followed by the strain overexpressing mut-ADH1. This correlated with in vitro HMF reduction capacity observed in the ADH6 overexpressing strain. Acetate and glycerol yields per biomass increased considerably in the ADH6 strain. In the other two strains, only the overall acetate yield per biomass was affected. When compared in batch fermentation of spruce hydrolysate, strains overexpressing ADH6 and mut-ADH1 had five times higher HMF uptake rate than the control strain and improved specific ethanol productivity. Overall, our results demonstrate that (1) the cofactor usage in the HMF reduction affects the product distribution, and (2) increased HMF reduction activity results in increased specific ethanol productivity in defined mineral medium and in spruce hydrolysate.

A Study of Tannic Acid Degradation by Soil Bacteria

A tannin-degrading strain of Bacillus sp. AB1 was isolated from a garden soil by enrichment. This organism was able to utilize 1% (w/v) tannic acid-a gallotannin at 30 degrees C and pH below 4.5 in a defined mineral medium where the acid was the sole source of carbon and energy under 96 h. Growth resulted in increase in OD concomitant with gradual decrease in pH of the culture medium. Analysis of the culture fluid by paper chromatography revealed glucose and gallic acid as major metabolites of tannic acid degradative pathway. Mineralization of tannic acid was informed when none of the metabolites was recovered after 96 h of incubation. The degradation potential of this isolate could be exploited for the production of tannase, improvement of livestock production and also detoxification of tannery effluents at extreme acidic conditions.

Effects of nutrients on biofilm formation and detachment of a Pseudomonas putida strain isolated from a paper machine

The aim of this study was to determine the effect of varying nutrient conditions on biofilm formation of a Pseudomonas putida strain isolated from a paper machine under controlled conditions. Biofilm accumulation, was investigated using a laminar flow cell reactor in a defined mineral medium. Our results indicate that increasing nutrient concentration (from 0.1 to 0.5 g l −1 glucose, C/N=40, C/P=100) or phosphate concentration (from C/P=200 to C/P=100) increased the rate and extent of biofilm accumulation, however, higher nutrient (1 g l −1 glucose, C/N=40, C/P=100) or phosphate (C/P=50) concentration reduced biofilm accumulation rate because of a higher detachment. The rate and extent of biofilm accumulation increased with nitrogen concentration (from C/N=90 to C/N=20). Detachment is a key parameter that influences biofilm accumulation since the early stage (2 h) of colonisation and strongly depends on nutrient conditions. In practice, controlling nutrient levels may be interesting to reduce biofilm formation in the paper industry.

Comparison of the xylose reductase-xylitol dehydrogenase and the xylose isomerase pathways for xylose fermentation by recombinant Saccharomyces cerevisiae

BackgroundTwo heterologous pathways have been used to construct recombinant xylose-fermenting Saccharomyces cerevisiae strains: i) the xylose reductase (XR) and xylitol dehydrogenase (XDH) pathway and ii) the xylose isomerase (XI) pathway. In the present study, the Pichia stipitis XR-XDH pathway and the Piromyces XI pathway were compared in an isogenic strain background, using a laboratory host strain with genetic modifications known to improve xylose fermentation (overexpressed xylulokinase, overexpressed non-oxidative pentose phosphate pathway and deletion of the aldose reductase gene GRE3). The two isogenic strains and the industrial xylose-fermenting strain TMB 3400 were studied regarding their xylose fermentation capacity in defined mineral medium and in undetoxified lignocellulosic hydrolysate.ResultsIn defined mineral medium, the xylose consumption rate, the specific ethanol productivity, and the final ethanol concentration were significantly higher in the XR- and XDH-carrying strain, whereas the highest ethanol yield was achieved with the strain carrying XI. While the laboratory strains only fermented a minor fraction of glucose in the undetoxified lignocellulose hydrolysate, the industrial strain TMB 3400 fermented nearly all the sugar available. Xylitol was formed by the XR-XDH-carrying strains only in mineral medium, whereas in lignocellulose hydrolysate no xylitol formation was detected.ConclusionDespite by-product formation, the XR-XDH xylose utilization pathway resulted in faster ethanol production than using the best presently reported XI pathway in the strain background investigated. The need for robust industrial yeast strains for fermentation of undetoxified spruce hydrolysates was also confirmed.

Production and characterization of a new bioemulsifier from Pseudomonas putida ML2

To characterize the bioemulsifier produced by a nonfluorescent strain of Pseudomonas putida isolated from a polluted sediment and to determine the influence of pH, temperature, media composition, and carbon and nitrogen source on growth and emulsifying activity. Different indexes were employed to determine the emulsifying properties of culture supernatants of P. putida ML2 in defined and complex media. Surface tension of cell-free supernatants was measured. Purification and chemical analysis of the emulsifier was performed. Confirmed results indicate that a polysaccharide with hexasaccharide repeating units is responsible for the emulsifying activity in a mineral medium with glucose as sole carbon source. Moreover, an emulsifier is produced when growing on naphthalene. Culture media composition influences the amount and the properties of the emulsifier produced by this P. putida strain. Under nitrogen limiting conditions, a polysaccharide is responsible for the emulsifying activity in defined mineral media. In complex nitrogen rich medium, a different kind of emulsifier is produced. The exopolymer may contribute to hydrocarbons solubilization. This is the first exopolysaccharide with emulsifying properties produced by a Pseudomonas strain reported to the present. Also chemical composition is significantly different from previous reports. This strain has potential use in bioremediation and the purified polysaccharide may be used in food and cosmetic industry. Moreover, the production of the exopolymer may play a role on biofilm formation.

Isolation and properties of methanesulfonate‐degrading Afipia felis from Antarctica and comparison with other strains of A. felis

Three novel strains of methylotrophic Afipia felis were isolated from several locations on Signy Island, Antarctica, and a fourth from estuary sediment from the River Douro, Portugal. They were identified as strains of the alpha-2 proteobacterium A. felis by 16S rRNA gene sequence analysis. Two strains tested were shown to contain the fdxA gene, diagnostic for A. felis. All strains grew with methanesulfonate (and two strains with dimethylsulfone) as sole carbon substrate. Growth on methanesulfonate required methanesulfonate monooxygenase (MSAMO), using NADH as the reductant and stimulated by reduced flavin nucleotides and Fe(II). Polymerase chain reaction amplification of DNA from an Antarctic strain showed a typical msmA gene for the alpha-hydroxylase of MSAMO, and both Antarctic and Portuguese strains contained mxaF, the methanol dehydrogenase large subunit gene. This is the first report of methanesulfonate-degrading bacteria from the Antarctic and of methylotrophy in Afipia, and the first description of any bacterium able to use both methanesulfonate and dimethylsulfone. In contrast, the type strain of A. felis DSM 7326(T) was not methylotrophic, but grew in defined mineral medium with a wide range of single simple organic substrates. Free-living Afipia strains occurring widely in the natural environment may be significant as methylotrophs, degrading C(1)-sulfur compounds, including the recalcitrant organosulfur compound methanesulfonate.