Sf9 Cell Culture Research Articles

Design of an efficient medium for insect cell growth and recombinant protein production.

We report the development of a new serum-free medium based on the use of factorial experiments. At first, a variety of hydrolysates were screened using a fractional factorial approach with High-Five cells. From this experiment yeastolate ultrafiltrate was found to have, by far, the most important effect on cell growth. Furthermore, Primatone RL was found to remarkably prolong the stationary phase of Sf-9 and High-Five cell cultures. The optimal concentrations for yeastolate and Primatone were determined to be 0.6 and 0.5%, respectively, on the basis of a complete factorial experiment. This new medium, called YPR, supported good growth of both Sf-9 and High-Five cells in batch cultures, with maximal densities of 5.4 and 6.1 x 10(6) cells/ml, respectively. In addition, both cell lines achieved good growth in bioreactor batch culture and had a prolonged stationary phase of 3-4 d in YPR medium compared to Insect-XPRESS medium. The ability of the new medium to support recombinant protein expression was also tested by infecting Sf-9 or High-Five cells at high density (2 x 10(6) cells/ml) with a baculovirus expressing secreted placental alkaline phosphatase (SEAP). The maximum total SEAP concentration after 7 d was about 43 lU/ml (58 mg/L) and 28 lU/ml (39 mg/L) for High-Five and Sf-9 cells, respectively.

Pathways of glutamine metabolism in Spodoptera frugiperda (Sf9) insect cells: evidence for the presence of the nitrogen assimilation system, and a metabolic switch by 1H/ 15N NMR

1H/ 15N and 13C NMR were used to investigate metabolism in Spodoptera frugiperda (Sf9) cells. Labelled substrates ([2- 15N]glutamine, [5- 15N]glutamine, [2- 15N]glutamate, 15NH 4Cl, [2- 15N]alanine, and [1- 13C]glucose) were added to batch cultures and the concentration of labelled excreted metabolites (alanine, NH 4 +, glutamine, glycerol, and lactate) were quantified. Cultures with excess glucose and glutamine produce alanine as the main metabolic by-product while no ammonium ions are released. 1H/ 15N NMR data showed that both the amide and amine-nitrogen of glutamine was incorporated into alanine in these cultures. The amide-nitrogen of glutamine was not transferred to the amine-position in glutamate (for further transamination to alanine) via free NH 4 + but directly via an azaserine inhibitable amidotransfer reaction. In glutamine-free media 15NH 4 + was consumed and incorporated into alanine. 15NH 4 + was also incorporated into the amide-position of glutamine synthesised by the cells. These data suggest that the nitrogen assimilation system, glutamine synthetase/glutamate synthase (NADH-GOGAT), is active in glutamine-deprived cells. In cultures devoid of glucose, ammonium is the main metabolic by-product while no alanine is formed. The ammonium ions stem both from the amide and amine-nitrogen of glutamine, most likely via glutaminase and glutamate dehydrogenase. 13C NMR revealed that the [1- 13C] label from glucose appeared in glycerol, alanine, lactate, and in extracellular glutamine. Labelling data also showed that intermediates of the tricarboxylic acid cycle were recycled to glycolysis and that carbon sources, other than glucose-derived acetylCoA, entered the cycle. Furthermore, Sf9 cell cultures excreted significant amounts glycerol (1.9–3.2 mM) and ethanol (6 mM), thus highlighting the importance of sinks for reducing equivalents in maintaining the cytosolic redox balance.

Induction of apoptosis in glioma cells by recombinant human Fas ligand.

Fas ligand (FasL) belongs to the tumor necrosis factor family and has the ability to induce apoptosis in susceptible target cells by binding to its receptor, Fas. It has been demonstrated recently that the FasL/Fas system plays a pivotal role in the cytocidal activity of T lymphocytes in the immune system. FasL may act as a cytotoxic effector molecule to Fas-expressing malignant tumor cells. We reported previously that Fas is commonly expressed in human brain tumor cells. In this study, we examine the possible application of FasL to therapy for malignant brain tumors. To develop an expression system yielding large amounts of FasL, we constructed a baculovirus vector containing complementary deoxyribonucleic acid of human FasL under the control of a polyhedrin promoter. We produced human FasL in Spodoptera frugiperda (Sf9) insect cells infected by the recombinant baculovirus carrying FasL complementary deoxyribonucleic acid and studied the cytocidal activity of FasL against the T98G human glioblastoma cell line. FasL expression in Sf9 cells was confirmed immunocytochemically with rabbit antibody raised against the cytoplasmic domain of human FasL. The FasL released into the supernatant of cultured Sf9 cells was also verified by Western blotting, and it specifically induced apoptosis in T98G cells. The induced apoptosis by recombinant human FasL was confirmed by annexin V-fluorescein isothiocyanate staining. The present results suggest that the induction of apoptosis by the Fas/FasL system could be a new strategy for the treatment of malignant brain tumors, which are resistant to conventional therapies.

The Role of Presenilin-1 in the γ-Secretase Cleavage of the Amyloid Precursor Protein of Alzheimer's Disease

Presenilin-1 (PS1) is required for the release of the intracellular domain of Notch from the plasma membrane as well as for the cleavage of the amyloid precursor protein (APP) at the gamma-secretase cleavage site. It remains to be demonstrated whether PS1 acts by facilitating the activity of the protease concerned or is the protease itself. PS1 could have a gamma-secretase activity by itself or could traffic APP and Notch to the appropriate cellular compartment for processing. Human APP 695 and PS1 were coexpressed in Sf9 insect cells, in which endogenous gamma-secretase activity is not detected. In baculovirus-infected Sf9 cells, PS1 undergoes endoproteolysis and interacts with APP. However, PS1 does not cleave APP in Sf9 cells. In CHO cells, endocytosis of APP is required for Abeta secretion. Deletion of the cytoplasmic sequence of APP (APPDeltaC) inhibits both APP endocytosis and Abeta production. When APPDeltaC and PS1 are coexpressed in CHO cells, Abeta is secreted without endocytosis of APP. Taken together, these results conclusively show that, although PS1 does not cleave APP in Sf9 cells, PS1 allows the secretion of Abeta without endocytosis of APP by CHO cells.

Optimized production of recombinant bluetongue core-like particles produced by the baculovirus expression system.

The baculovirus-expression vector system (BEVS) has been widely used for the experimental production of many human and animal single- and multi-unit vaccines, heterologous proteins, and viral insecticides. In this work, the production of recombinant bluetongue virus core-like particles (CLPs), using Sf9 cells in shaker-suspension culture with the SF900 II medium (GIBCO, NY), has been studied. This system involved the simultaneous production of two proteins, VP7 and VP3, and was shown to achieve high volumetric productivities. The key parameters of the time of infection (TOI), and the multiplicity of infection (MOI) were studied. The results show that the peak-volumetric yields and cell-specific yields achieved using low MOIs at low-cell densities were the same as those obtained following infections with a high MOI at high-cell densities. This work establishes the feasibility of using low MOIs in the baculovirus system to produce complex multiprotein particles.

Constitutive Secretion of an Endogenous Insulin-like Peptide Binding Protein with High Affinity for Insulin in Spodoptera frugiperda (Sf9) Cell Cultures

Serum-free medium from batch cultures of Sf9 insect cells was examined for the occurrence of proteins related to the insulin-like growth factor family. We found that the Sf9 cell line constitutively produced and secreted a soluble protein with a MW of 27 kDa that exerted specific binding to human insulin-like growth factor-I (IGF-I) and -II. Moreover, the secreted protein bound human insulin and human proinsulin with higher affinity than IGF-I and -II. The order of affinity to the insulin peptides, determined by competitive inhibition of ligand binding, was: insulin > proinsulin > IGF-I ⪢ IGF-II. The dissociation constant (kd) for IGF-II was 28.5 ± 1.7 nM and for insulin 7.2 ± 1.3 nM, as determined by Scatchard plot analysis. The results suggest that the Sf9 cells produce an insulin binding protein similar to the human insulin-like growth factor binding protein-related protein 1 (IGFBP-rP1).

Expression, purification and characterization of peanut (Arachis hypogaea) agglutinin (PNA) from baculovirus infected insect cells.

Peanut (Arachis hypogaea) seed lectin, PNA is widely used to identify tumor specific antigen (T-antigen), Galbeta1-3GalNAc on the eukaryotic cell surface. The functional amino acid coding region of a cDNA clone, pBSH-PN was PCR amplified and cloned downstream of the polyhedrin promoter in the Autographa californica nucleopolyhedrovirus (AcNPV) based transfer vector pVL1393. Co-transfection of Spodoptera frugiperda cells (Sf9) with the transfer vector, pAcPNA and AcRP6 (a recombinant AcNPV having B-gal downstream of the polyhedrin promoter) DNAs produced a recombinant virus, AcPNA which expresses PNA. Infection of suspension culture of Sf9 cells with plaque purified AcPNA produced as much as 9.8 mg PNA per liter (2.0 x 10(6) cells/ml) of serum-free medium. Intracellularly expressed protein (re-PNA) was purified to apparent homogeneity by affinity chromatography using ECD-Sepharose. Polyclonal antibodies against natural PNA (n-PNA) cross-reacted with re-PNA. The subunit molecular weight (30 kDa), hemagglutination activity, and carbohydrate specificity of re-PNA were found to be identical to that of n-PNA, thus confirming the abundant production of a functionally active protein in the baculovirus expression system.

On-line monitoring of the progress of infection in Sf-9 insect cell cultures using relative permittivity measurements.

The use of on-line relative permittivity (epsilon') measurements for monitoring cultures of Sf-9 cells was evaluated in a batch culture and a batch infected with a baculovirus expressing beta-galactosidase. It was found that viable cell density and volume essentially accounted for all the variation in epsilon' in both non-infected and synchronously infected cultures, indicating that the epsilon' of a cell suspension was sensitive only to changes in the viable cell population. Additionally the parameter provided clearly defined signposts of the progress of the infection.

Production and characterization of a soluble, active form of Tva, the subgroup A avian sarcoma and leukosis virus receptor.

The receptor for the subgroup A avian sarcoma and leukosis viruses [ASLV(A)] is the cellular glycoprotein Tva. A soluble form of Tva, sTva, was produced and purified with a baculovirus expression system. Using this system, 7 to 10 mg of purified sTva per liter of cultured Sf9 cells was obtained. Characterization of the carbohydrate modification of sTva revealed that the three N glycosylation sites in sTva were differentially utilized; however, the O glycosylation common to Tva produced in mammalian and avian cells was not observed. Purified sTva demonstrates significant biological activity, specifically blocking infection of avian cells by ASLV(A) with a 90% inhibitory concentration of approximately 25 pM. A quantitative enzyme-linked immunosorbent assay, developed to assess the binding of sTva to ASLV envelope glycoprotein, demonstrates that sTva has a high affinity for EnvA, with an apparent dissociation constant of approximately 0.3 nM. Once they are bound, a very stable complex is formed between EnvA and sTva, with an estimated complex half-life of 6 h. The soluble receptor protein described here represents a valuable tool for analysis of the receptor-envelope glycoprotein interaction and for structural analysis of Tva.

Invitro culturedSpodoptera frugiperda insect cells: Model for oxidative stress-induced apoptosis

Cellular imbalance in the levels of antioxidants and reactive oxygen species (ROS) is directly associated with a number of pathological states and results in programmed cell death or apoptosis. We demonstrate the use ofin vitro culturedSpodoptera frugiperda (sf9) insect cells as a model to study oxidative stress induced programmed cell death. Apoptosis ofin vitro cultured sf9 cells was induced by the exogenous treatment of H2O2 to cells growing in culture. The AD50 (concentration of H2O2 inducing about 50% apoptotic response) varied with the duration of treatment, batch to batch variation of H2O2 and the physiological state of cells. At 24 h post-treatment with H2O2 AD50 was about 475 Μm. Apoptosis could also be induced byin situ generation of H2O2 by the inhibition of catalase activity upon hydroxylamine treatment. Hydroxylamine acted synergistically with H2O2 with an AD50 of 2.2 mM. DMSO, a free radical scavenger, inhibited H2O2-induced apoptosis thereby confirming the involvement of reactive oxygen species. Exposure of cells to UV radiation (312 nm) resulted in a dose-dependent induction of apoptosis. These results provide evidence on the novel use of insect cells as a model for oxidative stress-induced apoptosis.

Optimization of the production of triabin, a novel thrombin inhibitor, in High Five™ insect cells infected with a recombinant baculovirus.

The isolation of a new type of thrombin inhibitor, called triabin, from the saliva of the hematophagous bug Triatoma pallidipennis, has recently been described. In the in vitro platelet aggregation inhibition assay triabin has a similar potency as the thrombin inhibitor hirudin now in phase III clinical trials. However, in another in vitro assay using a low molecular weight substrate for thrombin, triabin does not inhibit thrombin completely even at 6 fold higher molar doses in comparison with hirudin. This means that triabin has a novel mode of action towards thrombin making triabin into an interesting candidate as a therapeutic agent. Recently it has been shown that a recombinant baculovirus can be efficiently used for the triabin production in insect cells and that the yields in adherent cultures of High Five™ cells (approx. 20 mg l-1) were about 7 fold higher than in adherent cultures of Sf9 cells (approx. 3 mg l- 1). To optimize the triabin yield from the baculovirus/insect cell expression system, experiments were performed with suspension adapted cultures of High Five™ cells to investigate the effects of the state of the host cell, of the multiplicity of infection, of the cell density at the time of infection and of supplementation of the medium with nutrients and oxygen. Triabin yields of up to 200 mg l-1, as determined by an activity assay, could finally be obtained here.

Overexpression, purification, and characterization of human m-calpain and its active site mutant, m-C105S-calpain, using a baculovirus expression system.

Recombinant human m-calpain was produced in a soluble form at a level of 20 mg/liter of Sf-9 cell culture by the coexpression of recombinant human m-calpain large (m80K) and small (30K) subunits using a baculovirus expression system. The expressed m-calpain was purified by sequential column chromatographies on DEAE-Toyopearl, gel-filtration, and Mono Q by the same method used to purify native m-calpain. The recombinant m-calpain had a specific activity of 691 U/mg and a Ka value (Ca2+ requirement for 50% caseinolysis activity) of 0.4 mM, which are essentially identical to those of native rabbit m-calpain. A mutant m-calpain large subunit, m-C105S-80K, where the active-site cysteine-105 is converted to serine by site-directed mutagenesis, was coexpressed with 30K in Sf-9 cells, purified, and characterized. m-C105S-calpain does not degrade casein nor an artificial tetra-peptide substrate, succinyl-Leu-Leu-Val-Tyr-MCA. Further, it shows no autolytic activity with Ca2+. This is the first report of the large-scale production of a fully active m-calpain species in the baculovirus system.

High-efficiency expression and characterization of the synaptic-vesicle monoamine transporter from baculovirus-infected insect cells.

The full-length cDNA for the rat synaptic-vesicle monoamine transporter (VMAT2) containing a C-terminal polyhistidine epitope has been engineered into baculovirus DNA for expression in Spodoptera frugiperda (Sf9) insect cells. Using this recombinant baculovirus and cultured Sf9 cells, rVMAT2 has been expressed at levels of 7.8x10(6) transporters per cell, as assessed by [3H]dihydrotetrabenazine binding. A 1l culture of infected cells produced approx. 15 nmol (900 microg) of transporter. rVMAT2 expressed in the Sf9 cells bound [3H]dihydrotetrabenazine with a KD of 31.2 nM and a Bmax of 19.9 pmol/mg. Two polypeptides of 55 and 63 kDa were identified using the photolabel, 7-azido-8-[125I]iodoketanserin ([125I]AZIK). Photoaffinity labelling of rVMAT2 by 1 nM [125I]AZIK was protectable by 10 microM tetrabenazine and 10 microM 7-aminoketanserin. Digitonin-solubilized VMAT2 was purified to greater than 95% homogeneity using immobilized Ni2+-affinity chromatography, followed by lectin (Concanavalin A) chromatography. The purified transporter migrates as a single broad band with a molecular mass of approx. 63kDa, as analyzed by SDS/PAGE. The purified transporter retained the ability to bind ligands ([125I]AZIK and [3H]dihydrotetrabenazine). The purified VMAT2 bound [3H]dihydrotetrabenazine with a KD of 86.2 nM. As is the case with the monoamine transporter from bovine chromaffin granule membranes, purified VMAT2 is covalently modified by dicyclohexylcarbodi-imide (DCCD) and is specifically labelled by [14C]DCCD. This labelling is inhibited by tetrabenazine and ketanserin. These data indicate that VMAT2 can be overexpressed using the baculovirus expression system and purified.

Cystine/cysteine metabolism in cultured Sf9 cells: influence of cell physiology on biosynthesis, amino acid uptake and growth.

Spodoptera frugiperda (Sf9) insect cells proliferate in a cystine-free medium, with the same growth rate, reaching the same final cell density, as in a cystine-containing medium, provided that the inoculum is taken from a pre-culture sufficiently early, at 47-53 h. With an inoculum from a 103 h culture an extended lag phase accompanied by cell death was observed during the first 50 h of cystine-free culture, even though the culture had been adapted to cystine-free conditions for 10 passages. Cystine-free cultures seeded with a 103 h inoculum had lower growth rates and reached lower final cell densities than corresponding cystine-supplied cultures. Cysteine biosynthesis occurs from methionine via the β-cystathionine pathway. More methionine was consumed by the cells in cystine-free media, and cystathionine was secreted when methionine and cystine were supplied in excess. The data suggest that cysteine biosynthesis is up-regulated in proliferating cells but down-regulated when the cells enter the stationary phase.In cultures supplied with cystine (10-100 mg 1(-1)), the specific uptake rate and total consumption of cystine, as well as the uptake of glutamate, glutamine and glucose increased with increasing cystine concentrations. These results are interpreted in view of system x (c) (-) , a concentration dependent amino acid transporter. Similarly, the consumption of amino acids transported by system L (ile, leu, val, tyr) was enhanced in cystine-containing cultures, as compared to cystine-free cultures. Uptake of cystine, methionine and system L amino acids ceases abruptly in all cultures, even before growth ceased. The specific growth rate starts to decline early during the growth phase, but this growth behaviour could not be correlated to the depletion of nutrients. We therefore propose that the observed growth pattern is a result of (auto)regulatory events that control both proliferation and metabolism.

Detection of active infection of Sf9 insect cells by recombinant baculoviruses

Production of different recombinant proteins in baculovirus AcMNPV (BV)-infected cells may be facilitated by the availability of immunoassays to monitor active infection of Sf9 insect cells. To this end, two hybridomas secreting mouse monoclonal antibodies (mAbs) were established to different BV-related products. The proteins recognized by mAb SM22 and SM62 were easily detectable by immunoblotting and immunostaining in Sf9 cells infected with recombinant BV (rBV), but not in non-infected cells. Their production paralleled that of the recombinant proteins analyzed but was independent of the type of recombinant protein expressed. Thus, immunoassays with these mAbs allow: (1) daily monitoring of the infection occurring in small and large scale cultures of Sf9 cells using a defined rBV; (2) preliminary assessment of active rBV infection in the absence of a specific reagent for the recombinant protein and (3) single-reagent comparison of the infection achieved in Sf9 cells exposed to rBVs expressing different recombinant proteins.

Peptide mapping of the [125I]Iodoazidoketanserin and [125I]2-N-[(3'-iodo-4'-azidophenyl)propionyl]tetrabenazine binding sites for the synaptic vesicle monoamine transporter.

The full-length cDNA for the rat recombinant synaptic vesicle monoamine transporter (rVMAT2) containing a COOH-terminal polyhistidine epitope was engineered into baculovirus DNA for expression in Spodoptera frugiperda (Sf9) cells. Using this recombinant baculovirus and cultured Sf9 cells, rVMAT2 has been expressed to high levels and purified to >95% homogeneity using immobilized Ni2+-affinity chromatography followed by lectin (concanavalin A) chromatography. Purified transporter was photolabeled using [125I]-7-azido-8-iodoketanserin ([125I]AZIK) and [125I]2-N-[(3'-iodo-4'-azidophenyl)propionyl]tetrabenazine ([125I]TBZ-AIPP). Both [125I]AZIK and [125I]TBZ-AIPP photoaffinity labeling of purified rVMAT2 were protectable by 10 microM tetrabenazine (TBZ), 10 microM 7-aminoketanserin, and 1 mM concentrations of the transporter substrates dopamine, norepinephrine, and serotonin. Radiolabeled peptides were generated using enzymatic and chemical methods, purified using sodium dodecyl sulfate-polyacrylamide gel electrophoresis, and NH2-terminal microsequenced. Radiosequencing of [125I]AZIK-labeled rVMAT2 indicated derivatization of Lys-20 in the NH2 terminus, just prior to putative transmembrane domain 1 (TMD1). [125I]TBZ-AIPP derivatized a segment of rVMAT2 between Gly-408 and Cys-431 in TMD10 and 11. These data implicate juxtaposition of TMD1 and 10/11.

Comparison ofTrichoplusia ni BTI-Tn-5B1-4 (high five™) andSpodoptera frugiperda Sf-9 insect cell line metabolism in suspension cultures

Nutrient utilization and byproduct accumulation were monitored in Spodoptera frugiperda Sf-9 and Trichoplusia ni BTI-Tn-5B1-4 (High Five) cell lines during growth and following viral infection in suspension cultures in order to develop a better understanding of cell metabolism and to acquire information relevant to large scale fed-batch bioreactors. The utilization of glucose, dissolved oxygen, and amino acids were monitored in Sf-9 cell cultures grown in Sf-900 II serum-free medium (SFM) and in High Five cell cultures grown in both Sf-900 II and Express Five SFM. Using the optimal medium for each cell line, i.e., Sf-900 II SFM for Sf-9 cells and Express Five SFM for High Five cells, the cell growth rate, maximum cell density, specific glucose and glutamine utilization rates, and specific alanine production rate were comparable during cell growth. In addition, the expression level of recombinant human tissue plasminogen activator was comparable in the two cell lines on a per cell basis. It was found, however, that lactate and ammonia accumulated in High Five cell cultures, but not in Sf-9 cell cultures. In addition, High Five cells utilized asparagine more rapidly than glutamine, whereas Sf-9 cells consumed only minimal asparagine, and the oxygen utilization rate was significantly higher in High Five cell cultures. It was also found that the medium had a significant effect on High Five cell metabolism, e.g., the specific glucose utilization rate and the specific lactate and alanine production rates were significantly higher in Sf-900 II SFM than in Express Five SFM. In addition, the maximum cell density and specific asparagine utilization rate were significantly higher in Express Five SFM.

Very high single channel water permeability of aquaporin-4 in baculovirus-infected insect cells and liposomes reconstituted with purified aquaporin-4.

The insect cell/baculovirus system was used to express the mercurial-insensitive water channel aquaporin-4 (AQP4) for purification and reconstitution. Immunoblot analysis of Sf9 cells infected with recombinant baculovirus showed greatest AQP4 expression at 72 h after infection at a multiplicity-of-infection of 5. Immunostaining and cell membrane fractionation indicated AQP4 plasma membrane expression. Quantitative immunoblot analysis showed approximately 60 microg of AQP4 per milligram of plasma membrane protein (approximately 2 mg of AQP4 protein per liter of Sf9 cell culture). Functional analysis by stopped-flow light scattering indicated that AQP4 functioned as a mercurial-insensitive water-selective transporter. Osmotic water permeability (Pf) in plasma membrane vesicles from AQP4-expressing Sf9 cells was very high (0.053 cm/s at 10 degrees C), weakly temperature dependent (activation energy, 4.5 kcal/mol), and not inhibited by HgCl2. The AQP4 single channel water permeability (p(f)), estimated from Pf and protein amount, was 19 x 10(-14) cm3/s. Purification of AQP4 to a single Coomassie blue-stained protein on SDS-PAGE (1300-fold over homogenate) was achieved by membrane fractionation, carbonate stripping of nonintegral proteins, solubilization in octyl-beta-glucoside, and anion exchange chromatography. AQP4 protein identity was confirmed by mass spectrometry. Reconstitution of purified AQP4 into proteoliposomes increased osmotic water permeability by >40-fold, giving a p(f) of 15 x 10(-14) cm3/s, remarkably greater than that of 4.9 x 10(-14) cm3/s measured in parallel for AQP1. These results establish the first purification of an aquaporin from a heterologous expression system. The high AQP4 p(f) suggests (a) significant functional differences among the aquaporins, (b) inadequacy of existing pore models to account for high water flow and water permselectivity, and (c) possible enhancement of water flow by AQP4 assembly in orthogonal arrays.

Characterization of azadirachtin binding to Sf9 nuclei in vitro

[22,23-3H2]dihydroazadirachtin was incorporated by Sf9 cells in culture and was bound specifically to the nuclear fraction. The observed association constant of the binding of the radioligand to a purified nuclear fraction was determined to be 0.037 ± 0.008 min 1 using a one-phase exponential association equation, and binding appeared to be to a single population of sites. The binding was essentially irreversible, and the dissociation constant was estimated to be 0.00065 ± 0.00013 min 1. An association rate constant of 7.3 × 106 M 1 min 1 was calculated from these data. Binding was saturable, and the receptor number and affinity were determined as Bmax = 23.87 ± 1.15 pmol/mg protein, Kd = 18.1 ± 2.1 nM. The order of potency of semisynthetic azadirachtin analogues for competition for the binding site was as follows (IC30 in parentheses): azadirachtin (1.55 × 10−8 M) > dihydroazadirachtin (3.16 × 10−8 M) > dansyl dihydroazadirachtin (7.40 × 10−8 M) > DNP-azadirachtin (7.50 × 10−8 M) > biotin dihydroazadirachtin (1.27 × 10−7 M) ≫ 11-methoxy 22,23-dihydroazadirachtin (6.67 × 10−7 M). Arch. Insect Biochem. Physiol. 34:461–473, 1997. © 1997 Wiley-Liss, Inc.

Fed-batch culture of Sf-9 cells supports 3 3 10 7 cells per ml and improves baculovirus-expressed recombinant protein yields

Yields of cell and baculovirus-expressed recombinant protein in Sf-9 cultures were improved using fed-batch addition of glucose, amino acids, lipids, yeastolate ultrafiltrate, vitamins, iron and trace metals. Using this approach, the highest maximum cell and recombinant b-galactosidase volumetric yields obtained, 3 3 10 .ml and 900 units.ml , respectively, were both approximately triple their respective values in unamended cultures.