Control Silage Research Articles

Effects of additives containing a novel strain on the fermentation characteristics, structural carbohydrates, and α-tocopherol content of rice straw and corn stover silages

A novel α-tocopherol-producing bacteria strain was isolated and identified as Bacillus tequilensis QH1 (QH1). The effects of QH1 strain inoculation alone (QH), combined with cell wall degradation enzyme (QC), or Lactiplantibacillus plantarum subsp. plantarum YM3 and cell wall degradation enzyme (QLC) as the additives on the fermentation characteristics, structural carbohydrates, and α-tocopherol content of rice straw and corn stover silages were investigated, and without additives as the control (CON), in 4 replicates. After silages were kept in a laboratory cabinet (26–34 ℃) and the dark for 42 d, experimental silos (polyethylene plastic bags) were opened for analysis. The results exhibited that the control and additives-treated rice straw and corn stover were ensiled well, indicated by high lactic acid content and little butyric acid content. The QH and QC degraded structural carbohydrates, demonstrated by lower (P < 0.001) neutral detergent fiber (NDF) and acid detergent fiber (ADF) than the control, but did not enhance lactic acid fermentation, evidenced by lower (P < 0.001) lactic acid content in QH-treated silages compared with the control silages. The effect of QLC on degrading structural carbohydrates was influenced by material factors, evidenced by no role in decreasing the contents of NDF and ADF in rice straw silage and a good role in decreasing the contents of NDF and ADF in corn stover silage. However, the water-soluble carbohydrate (WSC) contents in both rice straw and corn stover silages were increased (P < 0.001) by QLC compared with the control. The control and additives-treated silages had much higher (P < 0.001) α-tocopherol content and lower (P < 0.001) chlorophyll content compared with the material before ensiling. Compared with the control, higher α-tocopherol content was found in QH-treated rice straw (P = 0.071) and corn stover silages (P < 0.05), and QLC-treated corn stover silage (P < 0.05). Therefore, the QH1 strain had the potential to be applied in rice straw silage production, and QLC was recommended to be applied in corn stover silage production.Graphical

Silage quality and bacterial diversity of silages inoculated with Listeria monocytogenes and Lacticaseibacillus paracasei_6714

Introduction: King grass (Cenchrus purpureus (Schumach.) Morrone, syn. Pennisetum purpuphoides) and pineapple peel (Ananas comosus) silages are food alternatives for livestock in conditions of feed shortage. Objective: To describe the dynamics of the microbiota present in king grass and pineapple silage during the fermentation process using next generation sequencing (NGS) and to evaluate the protective effect of Lacticaseibacillus paracasei_6714 as a silage inoculum against Listeria monocytogenes. Methods: We used an unrestricted randomized design to characterize the microbiota present in silages made from king grass harvested 70 days after regrowth and pineapple peel. We inoculated mixtures of grass and peel with L. paracasei_6714 or L. monocytogenes, or both, with a non-inoculated treatment as control. The nutritional and fermentative profile was evaluated after 30 days. After 15 and 30 days of fermentation, we used 16S rRNA analysis to determine the dynamics and diversity of the microbiota in the inoculated and control silages. Result: Dry matter content and digestibility did not differ significantly; however, there were differences in crude protein, pH and organic acids. We obtained 4432 amplicon sequence variants of Proteobacteria, Firmicutes, Bacterioidetes, Actinobacteria, Verrucomicrobia, Planctomycetes and Patescibacteria. The relative abundance of each phylum varied depending on the material and fermentation period. Phylum similarity was over 70 % (but not greater than 50 % with Bray-Curtis at the species level). Conclusion: These bacterial communities seem to have an important role during silage fermentation. Proper management of silage processing can reduce or eliminate pathogenic bacteria.

The effect of silage additive on the kinetics of biogas production from lignocellulosic perennial crops

The aim of the study was to assess the effect of silage additive containing heterofermentative lactic acid bacteria (LAB) strain of Lactobacillus buchneri species on ensiling quality, as well as methane yield and the kinetics of biogas production from ensiled perennial energy grasses: Miscanthus × giganteus (miscanthus), Spartina pectinata (cordgrass), Panicum virgatum (switchgrass) and Andropogon gerardii (big bluestem). The listed plants are not commonly used for biogas production, their susceptibility to ensiling is also little known, hence the need to investigate their suitability for these processes. Effective methods for increasing the biogas yield from biomass are still demand, hence the research on the use of LAB for this purpose. After harvesting the grasses were cut and ensiled in barrels with and without (controls) the usage of commercial silage inoculant containing Lactobacillus buchneri LN40177. After 90 days of ensiling obtained silages were analysed in order to compare their chemical composition: organic acids content, the loss of dry matter, the differences in particular fibres composition. The silages were then subjected to methane fermentation using OxiTop® sensors and exposed to air in order to check their aerobic stability. The silages prepared with LAB additive had higher concentration of acetic acid than the control silages prepared without LAB addition, which contributed to increased aerobic stability but had no effect on the methane yield of miscanthus, switchgrass and big bluestem. Using the microbial inoculant during ensiling had beneficial effect in terms of reducing the duration of biogas production process from obtained silages: lag phase was shortened, daily biogas production rate was increased and 90% of biogas was produced in a shorter period of time compared to the control silages from investigated grasses. The modified Gompertz model well reflected the kinetics of biogas production process.

The Effects of Hazelnut Husk Supplementation on Silage Quality, Deterioration, and In Vitro Digestion Parameters in Second Crop Maize

The focus of this research was to investigate the effects of hazelnut husk on the low dry matter maize silage quality, microbial profile, deterioration, fiber components, and digestion parameters. Second crop maize was harvested at the milk stage of maturity (26,61% DM) and ensiled in laboratory silos with or without ground hazelnut husk. A total of 18 jars of silage were made utilizing two treatments (control silage and 15% hazelnut-contained silage), three different opening dates, and three replicates. All silage analyses were completed during all of the opening periods. Hazelnut husk increased (P

Is the Integration between Corn and Grass under Different Sowing Modalities a Viable Alternative for Silage?

This study aimed to evaluate the fermentation pattern and dry-matter losses in corn (Zea mays L.) silage intercropped with Urochloa brizantha cv. Marandu and Megathyrsus maximus cv. Mombasa grasses in different sowing modalities through crop-livestock integration. The experimental design was in randomized blocks, which were arranged in a 2 × 5 factorial scheme with four repetitions. The first factor consisted of the grass cultivars Marandu and Mombasa. The second factor was the sowing modalities of grasses intercropped with corn: (1) simultaneous row sowing and inter-row corn sowing (no fertilizer); (2) simultaneous row sowing and inter-row corn sowing (with fertilizer); (3) simultaneous sowing with double grass row in the corn inter-row; (4) delayed sowing inter-row at 7 days after corn emergence; and (5) delayed sowing inter-row at 14 days after corn emergence. The forage buffer capacity (BC), silage pH and ammoniacal nitrogen (NH3-N) content, forage (FORDM) and silage dry-matter (SILDM) percentages, gas losses (GL), effluent losses (EL), and dry-matter recovery (DMR) parameters on the ensilage were evaluated. Only forage BC, silage NH3-N, and silage DMR variables differed (p < 0.05) from the control silage (monocropped corn) when the integration was carried out. The grass cultivar factors and sowing modalities for BC and NH3-N variables had an effect. The intercropping of corn and Marandu grass or Mombasa grass, in any grass sowing modality, did not affect the quality of the silage.

The Effects of Short-Time Delayed Sealing on Fermentation, Aerobic Stability and Chemical Composition on Maize Silages

Despite the efforts to improve the methodological standards of silage trials, many factors that can influence the results of lab-scale studies need to be better understood. This study aimed to determine the effects of short-time delayed sealing and inoculation with a blend of Lentilactobacillus buchneri and Lactiplantibacillus plantarum on fermentation, aerobic stability, and chemical composition of silages. Whole-crop maize was treated with or without a commercial inoculant and ensiled (29.3% dry matter) for 55 days in 8.8 L PVC silos that were sealed immediately (up to 30 min delay) or after a delay (90, 150, or 210 min between chopping and sealing) with five replicates each. The increasing air exposure before sealing increased fermentation losses and reduced silage nutritional value. Crude protein and ash were significantly affected by inoculation, with control treatments showing higher ash and lower protein values. Lignin, neutral detergent fiber, and acid detergent fiber were only affected by the delay period. The longer the sealing delay, the higher the gas production, and the lower the starch values and lactic acid content observed in samples. Inoculation was inefficient in reducing total dry matter losses, but it increased aerobic stability, acetic acid, and ethanol contents of silages and reduced effluent loss. Control silages had higher total dry matter loss during the aerobic exposure than inoculated silages. The results confirmed that the delay periods tested were long enough to negatively interfere with the chemical composition of silages, especially the fibrous fraction content.

Effects of sodium diacetate and microbial inoculants on fermentation of forage rye

Rye (Secale cereale L.) is a valuable annual forage crop in Korea but there is limited information about the impact of chemical and biological additives on fermentation characteristics of the crop. This experiment was conducted to investigate fermentation dynamics of wilted forage rye treated with the following six additives; control (no additive), sodium diacetate applied at 3 g/kg wilted forage weight (SDA3), 6 g/kg wilted forage weight (SDA6), inoculations (106 CFU/g wilted forage) of Lactobacillus plantarum (LP), L. buchneri (LB), or LP+LB. The ensiled rye sampled at 1, 2, 3, 5, 10, 20, 30, and 45 days indicated that the acidification occurred fast within five days of storage than the rest of the storage period. The microbial inoculants decline the pH of ensiled forage, more rapidly than the control or SDA treated, which accompanied by the decrease of water-soluble carbohydrates and increase of lactic acid. Compared with the control silage, all treatments suppressed ammonia-nitrogen formation below to 35 g/kg DM throughout the sampling period. Suppression of total microbial counting occurred in SDA6, LP, and LP + LB. The lactic acid production rates were generally higher in microbial inoculation treatments. Acetic acid concentration was lowest in the LP-treated silage and highest in the SDA- and LB-treated silages. The in vitro dry matter (DM) digestibility and total digestible nutrients were the highest in the silage treated with SDA (6 g/kg) at day 45 of ensiling. Based on lower ammonia-nitrogen concentrations and higher feed value, ensiling forage rye treated with SDA at 6 g/kg is promising through enhanced silage quality.

Lactobacillus plantarum and propionic acid improve the fermentation quality of high-moisture amaranth silage by altering the microbial community composition.

The objective of this study was to determine the effect of Lactobacillus plantarum (L. plantarum) and propionic acid (PA) on the microbial community and fermentation performance of high-moisture amaranth silage. Amaranth silages were rown without addition (AhGCK) as a control and with L. plantarum JYLP-002 (AhGLP) or propionic acid (AhGPA) and then were opened after 60 days of ensiling to determine the microbial community and fermentation quality. Crude protein (CP) content, lactic acid (LA) content, and lactic acid bacteria (LAB) counts were significantly higher in AhGLP and AhGPA compared with those in AhGCK (p < 0.05). In contrast, pH, acetic acid (AA) content, and yeast and aerobic bacteria counts were significantly lower in AhGLP and AhGPA compared with those in AhGCK (p < 0.05). In addition, propionic acid (PA) levels were markedly higher in AhGPA (p < 0.05). In terms of microbial communities, the silage in the additive groups showed an increased relative abundance of Lactiplantibacillus plantarum and Lentilactobacillus buchneri and a reduced relative abundance of Enterobacter cloacae and Clostridium tyrobutyricum. The abundance of Xanthomonas oryzae was significantly increased in AhGPA, but completely inhibited in the silage supplemented with L. plantarum. Spearman's correlation analysis revealed that Lentilactobacillus buchneri and Levilactobacillus brevis were positively associated with LA and negatively associated with pH. Conversely, Clostridium tyrobutyricum and Enterobacter cloacae were negatively associated with LA, but positively associated with pH and AA content. AA content was inversely correlated with Lentilactobacillus buchneri. Functional prediction analysis showed that LAB dominated the three groups of silage and the silages containing additives had improved carbohydrate and amino acid metabolism compared with the control silage; in particular, the AhGLP group had more heterotypic fermentation processes and a richer metabolic pathway. Furthermore, the epiphytic Lactiplantibacillus plantarum and Lentilactobacillus buchneri could inhibit the reproductive activity of undesirable microorganisms to a certain extent, thus slowing the spoilage process of the silage. In conclusion, L. plantarum can improve fermentation characteristics by modulating the microbial community attached to high-moisture amaranth silage and will prove useful for preserving high-moisture silage.

Perilla frutescens as potential antimicrobial modifier to against forage oat silage spoilage.

The aim of this study was to investigate the influence of Perilla frutescens, alone or in combination with Lactobacillus plantarum a214 or citric acid, on forage oat silage quality, bacterial and fungal microbiological profile during ensiling and aerobic exposure. With the exception of Perilla frutescens, all additives could improve silage quality of forage oat based on lower ammonia-nitrogen content and higher residual of water soluble carbohydrates during anaerobic fermentation compared to control silage, especially in Perilla frutescens combined with citric acid (CAPF). Lactobacillus was the dominant bacteria in all silages, while CAPF group increased the relative abundance of Lactobacillus lindneri and Lactobacillus brevis compared to control silage. The application of Perilla frutescens suppressed the relative abundance of yeasts such as Pichia fermentans and Wickerhamomyces anomalus in response to aerobic exposure, especially in CAPF treatment, leading to high acetic acids and lower dry matter loss, as well as good aerobic stability. Therefore, Perilla frutescens, alone or in combination with citric acid, has potential to improve aerobic stability of forage oat silage by shifting bacterial and fungal community composition, and can be used as new additive to prepare high-quality silage for animal production.

Fermentation profile and nutritional value of millet grain silages rehydrated with whey and/or molasses

This study aimed to evaluate the fermentation profile and nutritional value of millet grain silages rehydrated with whey and/or molasses. The experiment was conducted in a completely randomized design with four treatments and six replications, with a control treatment (water rehydration), whey rehydration, water rehydration plus molasses (2.5%), and whey plus molasses (2.5%). Lower values of dry matter content (DM = 66.37; 1.55%) were found for the control silage, but within the recommended range. The contents of crude protein, neutral detergent fiber, acid detergent fiber, lignin and hemicellulose were not influenced by the use of additives. There was no difference (p&gt;0.05) for aerobic stability and ammonia-N (6.04%) between treatments. For pH, lower values were observed for silages with molasses. There was a higher concentration (p &lt;0.05) of lactic acid in silages with whey, and a higher concentration of butyric acid in silages added exclusively with molasses. The use of whey improved dry matter recovery compared to control silages. Higher dry matter degradability was observed with 8% rate of passage in silages added with molasses and/or whey in relation to the control.

Effect of Homo-Fermentative Lactic Acid Bacteria Inoculants on Fermentation Characteristics and Bacterial and Fungal Communities in Alfalfa Silage

We evaluated the effects of a homo-fermentative lactic acid bacteria (homo-LAB) inoculant on the fermentation and microbial communities of alfalfa ensiled at two dry matter (DM) contents of 38 and 46% DM. At both DMs, alfalfa was treated or not with an inoculant containing Pediococcus acidilactici, Enterococcus faecium and Lactobacillus plantarum at a targeted application rate of 165,000 cfu/g of fresh weight and stored for 3, 30 and 60 days. Treatment with the inoculant resulted in a lower drop in pH and, in general, higher lactic acid and lower acetic acid when applied to medium DM silage. For the four most abundant microbial genera, increased abundances of Bacteroides and Lactobacillus (p &lt; 0.05), as well as decreased abundances of Muribaculaceae were observed in high DM and inoculated silages. The abundance of Prevotellaceae-UCG-001 was lower in medium DM control silages than in high DM control silages. Inoculation and DM affected abundances of Vishniacozyma (p &lt; 0.05). Increased abundances of Vishniacozyma, as well as decreased abundances of Leucosporidium were observed in medium DM-inoculated silages. Changes in the relative abundance (RA) of the main populations of bacteria and yeasts did explain the fermentation and nutrition differences among treatments.

Propionic acid-based additive with surfactant action on the nutritive value of rehydrated corn grain silage for growing ewe lambs performance

Thirty-six Dorper × Santa Inês ewe lambs with an initial age of 4.7 ± 0.5 months (mean ± SD) and initial weight of 27.9 ± 4.3 kg (mean ± SD) were assigned to a randomized complete block design. This study was designed to evaluate the effects of including a propionic acid-based additive with surfactant action during the ensiling of rehydrated corn grain on its nutritional value and animal performance. Ground dry corn was rehydrated to reach 400 g/kg fresh matter of moisture, with or without additive, and ensiled in 200-L plastic drums. The treatments were prepared as follows: rehydrated corn grain silage (RCGS) stored for 50 d as a negative control (50CON), RCGS stored for 90 d as a positive control (90CON) and RCGS treated with Mycoflake™ at 2 L/t and stored for 50 d (50MYC). A basal total mixed ration containing 200 g/kg sugarcane bagasse, 600 g/kg RCGS (according to treatment), 160 g/kg soybean meal, 5 g/kg urea, 20 g/kg limestone and 15 g/kg mineral in total diet dry matter (DM) was offered to the animals. The trial was divided in two subsequent periods of 28 d each in order to organize samplings and procedures with the animals and to evaluate RCGS condition over time. Ruminal DM disappearance (DMD) of RCGS was evaluated in situ using two canulated Holstein cows after 12, 24 and 48 h of incubation. The extended storage time of 90CON silage increased soluble protein (SP; P = 0.01) and NH3-N contents (P = 0.03) and the ruminal DMD. Although no change in SP content was observed for the 50MYC silage, its NH3-N content was higher than for the 50CON silage (P = 0.02), and its proportion of NH3-N in soluble N was the highest among the treatments (P < 0.01). The 50MYC silage presented the lowest concentrations of lactic acid (P < 0.01), and also yielded the lowest contents of ethanol (P < 0.01) and butyric acid (P = 0.02) in relation to the control silages. There were no changes on ruminal DMD for the silage treated with Mycoflake™ against the 50CON silage, except for a decrease in the soluble fraction only in the second feeding period (P = 0.01), and a higher undigested fraction after 48 h of incubation compared to both control silages (P = 0.02). There was no effect of storage time or additive on dry matter intake, body weight gain and feed efficiency of the ewe lambs. The silage treated with the additive also did not change the selective behavior of the animals. The results suggest that Mycoflake™ seems to promote a delay in the protein matrix degradation even with extended storage times, and that it may have potential as an additive for conservation of RCGS.

Effects of additives on the fermentation quality and bacterial community of silage prepared from fresh-cut whole-plant quinoa (Chenopodium quinoa willd.)

This study was conducted to evaluate the effects of different additives on the fermentation quality and bacterial community of silage prepared from fresh-cut whole-plant quinoa (WPQ). Fresh-cut WPQ without wilting process was directly ensiled with one of the following additives: (i) untreated (control); (ii) fibrolytic enzyme (E); (iii) molasses (M); (iv) LAB inoculant (L); (v) a combination of fibrolytic enzyme and LAB inoculant (EL); and (vi) a combination of molasses and LAB inoculant (ML). The fermentation quality and bacterial community after 60 days of ensiling were analysed. The results showed that control silage was dominated by enterobacteria (>50%), with high pH value (5.25), acetic acid (77.9 g/kg DM) and NH3–N production (261 g/kg TN). Adding E, EL and ML shifted the fermentation pattern towards increased intensity of lactic acid production, as indicated by increased lactic acid content (>62.4 g/kg DM), lactic/acetic acid ratio (>1.12) and relative abundance of Lactobacillus (>62.0%), and decreased pH value (<4.73), contents of acetic acid (<60.7 g/kg DM) and NH3-N (<179 g/kg TN) and the relative abundance of enterobacteria. The results suggested that treatments of E, EL and ML could be the feasible solutions for improving the fermentation quality and protein preservation of silage prepared from fresh-cut WPQ. The results of this study could be beneficial for producing high-quality WPQ silage in aeras where wilting is hard to conduct before ensiling. HIGHLIGHTS WPQ silage was prone to acetic acid-type fermentation dominated by enterobacteria. Adding E, EL and ML improved the lactic acid fermentation and protein preservation of fresh-cut WPQ silage. This study provided feasible solutions for producing high-quality WPQ silage under adverse climate conditions.

Dry matter recovery, ensiling characteristics and aerobic stability of oat silage treated with microbial inoculants at different temperatures

ABSTRACT To evaluate the effects of temperature and lactic acid bacteria (LAB) inoculants on oat silage in Loess Plateau of China, oat was harvested at dough stage, inoculated without (Control) or with LAB inoculants Synlac I (SLI, Lactobacillus plantarum and Pedioccocus acidilactici) and a selected strain HT1 (L. rhamnosus) and ensiled at 25°C (T25), 35°C (T35) and 45°C (T45). The fermentation quality was measured after 60 d of ensiling and the aerobic exposure was conducted at 30°C for 9 d. The results showed that control silage (stored at 25°C) had better fermentation quality than that ensiled at 35°C or 45°C. High temperature of 45°C resulted in sharp decreases in LAB counts and lactic acid concentration and increases in pH and NH3-N concentration in the control group. Inoculation improved the fermentation quality, and HT1 was more effective than SLI at 35°C and 45°C, while SLI showed better performance at 25°C. All silages displayed mild fluctuation for all treatments at the first 3 d of aerobic exposure, and significant differences were observed among treatments after that. Both control and inoculated silages stored at 25°C showed a sharp pH increase, while HT1 treated silages stored at 35°C and 45°C maintained stable pH and better fermentation quality during the aerobic exposure. In conclusion, SLI was suitable for oat silage fermentation at normal atmospheric temperature (25°C), while HT1 was more effective in improving DM recovery, fermentation quality and aerobic stability of oat silage at high temperature during summer in the Loess Plateau of China.

Fermentation quality, bacterial community, and aerobic stability of ensiling Leymus chinensis with lactic acid bacteria or/and water after long-term storage.

Leymus chinensis is a major forage resource for herbivores on typical steppe and meadow steppes in Northern China. This study aimed to reveal the fermentation quality, bacterial community, and aerobic stability of L. chinensis silage treated with lactic acid bacteria or/and water after long-term storage. Leymus chinensis was harvested at the heading stage and ensiled with lactic acid bacteria [LAB, 2.00 ml/kg fresh weight (FW) of LAB, L], water (100 ml/kg FW of distilled water, W), or a combination of both [2.00 ml/kg fresh weight (FW) of LAB and 100 ml/kg FW of distilled water, LW] in polyethylene laboratory-scale silos (diameter, 20 cm; height, 30 cm) at a density of 650 kg/m3. As a control silage (CK), untreated L. chinensis silage was also assessed. The samples were taken at 0 day of opening after 300 days of ensiling (CK_0d, L_0d, W_0d, and LW_0d) and at 10 days of opening (CK_10d, L_10d, W_10d, and LW_10d). The fermentation quality, microbial counts, bacterial community, and aerobic stability of the silage were assessed. The CK_0d contained higher pH and aerobic bacteria count, and lower LA and BC concentrations than L_0d, W_0d, and LW_0d (p < 0.05), and the LAB and yeasts were only detected in CK at 0 day of opening. Lactobacillus had the most abundance among bacterial genera in all silages at 0 day of opening. Just CK had 2°C above the ambient temperature during aerobic exposure (at 224 h). During aerobic exposure, the pH and microbial counts in CK increased (p < 0.05), and Lactobacillus in L and LW had decreasing abundance (p < 0.05). The CK_10d had higher pH and microbial counts, and lower lactic acid and buffering capacity than L_10d, W_10d, and LW_10d (p < 0.05). At 10 days of opening, the coliforms and yeasts were just detected in CK, and Lactobacillus also had the most abundance among bacterial genera in all silages at 10 days of opening. Overall, inoculating LAB and adding water improved the fermentation quality and the aerobic exposure of L. chinensis silage after long-term storage. The activities of coliforms and yeasts during aerobic exposure contributed to the aerobic deterioration of L. chinensis silage without any treating. Lactobacillus dominated the bacterial communities of all silage at 0 and 10 days of opening. During aerobic exposure, the abundance of Lactobacillus reduced in L. chinensis silage treated with LAB or water.

Microbial inoculant and cottonseed cake as additives for millet silage at different fermentation times

ABSTRACT The purpose of the present study was to evaluate the effect of the addition of microbial inoculant and cottonseed cake on the fermentation profile, microbial population, aerobic stability, organic acids, chemical composition and losses of millet silages. The experimental design was completely randomised, in a 4 × 2 factorial arrangement, with the following treatments: (1) Control (millet); (2) Millet + 10% cottonseed cake (on a natural matter basis); (3) Millet + Weissella cibaria – heterofermentative lactic acid bacteria; (4) Millet + cottonseed cake and Weissella cibaria (blend); and two opening times (30 and 90 days after ensiling) with four replications, totalling 32 experimental units. Silages containing cottonseed cake had greater (P = .008) dry matter recovery. There was effect (P < .001) of the opening time on the counts of lactic acid bacteria, mould and yeast, and under aerobic stability, which were higher in silages opened at 90 days. The addition of cottonseed cake resulted in an increase in the nutritional quality of the silage, compared to control silages and silages inoculated with Weissella cibaria. The addition of cottonseed cake in millet silage proved to be efficient in reducing silage losses, improving the fermentation profile and nutritional value.

Metaprofiling of the bacterial community in sorghum silages inoculated with lactic acid bacteria.

To characterize the fermentation process and bacterial diversity of sorghum silage inoculated with Lactiplantibacillus plantarum LpAv, Pediococcus pentosaceus PpM and Lacticaseibacillus paracasei LcAv. Chopped sorghum was ensiled using the selected strains. Physicochemical parameters (Ammonia Nitrogen/Total Nitrogen, Dry Matter, Crude Protein, Acid Detergent Fibre, Neutral Detergent Fibre, Acid Detergent Lignin, Ether Extract and Ashes), bacterial counts, cell cytometry and 16sRNA sequencing were performed to characterize the ensiling process and an animal trial (BALB/c mice) was conducted in order to preliminary explore the potential of sorghum silage to promote animal gut health. After 30 days of ensiling, the genus Lactobacillus comprised 68.4 ± 2.3% and 73.5 ± 1.8% of relative abundance, in control and inoculated silages respectively. Richness (Chao1 index) in inoculated samples, but not in control silages, diminished along ensiling, suggesting the domination of fermentation by the inoculated LAB. A trend in conferring enhanced protection against Salmonella infection was observed in the mouse model used to explore the potential to promote gut health of sorghum silage. The LAB strains used in this study were able to dominate sorghum fermentation. This is the first report using metaprofiling of 16sRNA to characterize sorghum silage, showing a microbiological insight where resident and inoculated LAB strains overwhelmed the epiphytic microbiota, inhibiting potential pathogens of the genus Klebsiella.

The effect of corn silage hybrid and inclusion on performance of finishing steers and silage hybrid effects on digestibility and performance of growing steers.

Three experiments evaluated the effects of three corn silage hybrids, inclusion, and nutrient digestibility in growing and finishing diets. The three hybrids tested included a control (CON), a hybrid containing a brown midrib (bm3) trait (BM3), and an experimental bm3 hybrid with the soft endosperm trait (BM3-SOFT). Experiment 1 utilized 360 crossbred steers (body weight [BW] = 334; SD = 25 kg) to evaluate inclusion of silage in a finishing diet at (15% or 45% of diet dry matter [DM]) and silage hybrid (CON, BM3, or BM3-SOFT). Experiment 2 and 3 utilized 216 crossbred steers (BW = 324; SD = 10 kg) and six ruminally fistulated steers (BW = 274; SD = 27 kg), respectively, to evaluate effects of either CON, BM3, or BM3-SOFT silage hybrids on performance and nutrient digestibility in growing diets. In Exp. 1, there was a silage inclusion × hybrid interaction for average daily gain (ADG) and gain-to-feed ratio (G:F). All treatments with 15% silage had greater (P ≤ 0.04) ADG and G:F compared with 45% silage. Cattle fed BM3-SOFT had greater ADG and G:F than cattle fed CON or BM3 when silage was included at 15% of the diet. When silage was fed at 45% of the diet DM, ADG did not differ between cattle fed either bm3 hybrid. Cattle fed BM3 had the greatest G:F (P < 0.01), with no difference between BM3-SOFT and CON. At 15% silage inclusion, hot carcass weight (HCW) was greater (P < 0.01) for cattle fed BM3-SOFT compared with cattle fed CON and BM3 but did not differ between cattle fed BM3 and CON. At 45% silage inclusion, steers fed either bm3 hybrid did not differ in HCW but were both heavier (P < 0.01) compared with cattle fed CON. In Exp. 2, ending BW, dry matter intake (DMI), and ADG were greater (P < 0.01) for steers fed either bm3 hybrid compared to steers fed the CON, but not different between steers fed the bm3 hybrids. There were no differences (P = 0.26) in G:F between the silage hybrids. In Exp. 3, steers fed either bm3 had greater (P < 0.01) neutral detergent fiber (NDF) and acid detergent fiber (ADF) digestibility than steers fed the CON. Ruminal pH was lower (P < 0.01), and total volatile fatty acid (VFA) concentration was greater (P < 0.01) for steers fed bm3 hybrids compared to steers fed CON. Feeding silage with the bm3 trait improved fiber digestibility, which increased DMI and subsequent ADG in high-forage growing diets. Feeding corn silage with the bm3 trait improved performance compared to non-bm3 corn silage when included above typical roughage concentration.

Fermentation quality, nutritive value and in vitro ruminal digestion of Napier grass, sugarcane top and their mixed silages prepared using lactic acid bacteria and formic acid

AbstractThis study aimed to determine the fermentation quality, nutritive value and in vitro ruminal digestion of silages produced with mixtures of Napier grass (NG) and sugarcane top (ST) in five different ratios of fresh matter: 100:0 (N100), 75:25 (N75), 50:50 (N50), 25:75 (N25) and 0:100 (N0) with or without lactic acid bacteria (LAB) and formic acid (FA). The NG contained a higher crude protein (CP) content and buffering capacity, but lower dry matter (DM), organic matter, neutral detergent fiber, acid detergent fiber and water‐soluble carbohydrates contents than ST. The N25 silage fermented well, with a significantly higher lactic acid (LA) content (p &lt; .05) and lower pH and NH3‐N concentration than those of other mixed silages (p &lt; .05). The FA addition resulted in the highest CP content and lowest pH, LA, acetic acid (AA) and NH3‐N contents, while LAB addition resulted in the highest LA content compared with other treatments. Although in vitro DM digestibility (IVDMD) did not significantly differ among the mixed silages (p &gt; .05), mixing with ST and adding LAB or FA increased the IVDMD. Gas production (GP) and AA content of N25 silages were significantly higher than those of other silages (p &lt; .05). The LAB‐ or FA‐treated silages had higher IVDMD, GP, total volatile fatty acid and AA contents (p &lt; .05) but lower pH compared with the control silage (p &lt; .05). These results demonstrated that NG utilization improved upon mixing with ST due to the enhanced fermentation during ensiling, and the optimum mixing ratio for NG and ST was 25:75 on FM basis. Using LAB and FA as additives during ensiling can improve silage fermentation quality and in vitro ruminal digestion.

Effects of fumaric and maleic acids on the fermentation, nutrient composition, proteolysis and in vitro ruminal gas of corn silage

AbstractThe study aimed to determine the effect of fumaric and maleic acids on the ensiling process. The corn herbage was ensiled without additives (control silage) or with 0.25% fumaric acid (FA25), 0.50% fumaric acid (FA50), 0.25% maleic acid (MA25), 0.50% maleic acid (MA50), FA25 + MA25 (FA25MA25) and FA50 + MA50 (FA50MA50) (treatment silages) as wet basis. The starch contents of FA50 and MA50 silages were lower than the content of the control silage (p &lt; .05). The lactic acid content of the FA50MA50 silage was lower than that of the control silage (p &lt; .05). Percentages of linoleic acid of MA25 and MA50 silages were higher than that of the FA50 silage (p &lt; .05). The in vitro methane production and metabolic energy (ME) value of FA50MA50 silage was lower than that of the control silage (p &lt; .05). The in vitro organic matter digestion (OMD) values of FA25, MA25 and FA50MA50 silages were lower than that of control silage (p &lt; .05). The molarities of acetic (AA), propionic (PA), butyric (BA), isovaleric (IVA), isobutyric (IBA) and total volatile fatty (TVFA) acids of the in vitro ruminal fermentation fluid for the FA50MA50 silage were lower than that of the control silage (p &lt; .05). As a result, the addition of fumaric and maleic acids (0.25% alone and together, or 0.5% alone) in ensiling of corn herbage did not change the quality, acidity (except for propionic, butyric and isobutyric acids) and nutrient contents (except for non‐fiber carbohydrates and starch) and in vitro ruminal fermentation values (gas–methane production and organic acids). The combined use of 0.5% fumaric plus 0.5% maleic acid harmed silage quality and in vitro ruminal fermentation values. However, 0.5% maleic acid was partially more effective than those other organic acid additions in preserving linoleic and α‐linolenic acids in the silage material.