Biosolids Compost Research Articles

Solubility of phosphorus and heavy metals in potting media amended with yard waste-biosolids compost.

The potential risk of surface and ground water contamination by phosphorus (P) and heavy metals leached from compost-based containerized media has become an environmental concern. Solubility and fractionation of P and heavy metals were evaluated in media containing 0, 25, 50, 75, or 100% compost derived from biosolids and yard trimmings for potential impacts on the environment. As compost proportion in peat-based media increased from 0 to 100%, concentrations of total P, Cd, Cu, Ni, Pb, Zn, and Mn in the media increased whereas concentrations of total Co and Cr decreased. Except for Cu, all heavy metals in the water-soluble fraction decreased with increasing compost proportion in the media, because of higher Fe, Al, and Ca concentrations and pH values of the composts than the peat. When the media pH is controlled and maintained at normal range of plant growth (5.5-6.5), leaching of the heavy metals is minimal. Incorporation of compost to the peat-based media also decreased the proportion of total P that was water-soluble. However, concentrations of bioavailable inorganic phosphorus (NaHCO3-IP), readily mineralizable organic phosphorus (NaHCO3-OP), potentially bioavailable inorganic phosphorus (NaOH-IP), and potentially bioavailable organic phosphorus (NaOH-OP) were still higher in the media amended with compost because of higher total P concentration in the compost. Further study is needed to verify if less or no topdressing of chemical P fertilizer should be applied to the compost-amended media to minimize P effect on the environment when compost-amended potting media are used for nursery or greenhouse crop production systems.

In Situ Soil Treatments to Reduce the Phyto- and Bioavailability of Lead, Zinc, and Cadmium

A study was established near a former Zn and Pb smelter to test the ability of soil amendments to reduce the availability of Pb, Zn, and Cd in situ. Soil collected from the field was amended in the lab with P added as 1% P-H3PO4, biosolids compost added at 10% (referred to hereafter as “compost”), and a high-Fe by-product (referred to hereafter as “Fe”) + P-triple superphosphate (TSP) (2.5% Fe + 1% P-TSP) and incubated under laboratory conditions at a constant soil pH. Changes in Pb bioavailability were measured with an in vitro test and a feeding study with weanling rats. Field-amended and incubated soils using these plus additional treatments were evaluated using the in vitro extraction and tall fescue (Festuca arundinacea Schreb. cv. Kentucky-31) metal concentration. Reductions were observed across all parameters but were not consistent. In the feeding study, the 1% P-H3PO4 and compost treatments resulted in a decrease of 26% in rat tissue Pb concentration compared with the control soil. The 2.5% Fe + 1% P-TSP showed a 39% decrease. The 1% P-H3PO4 treatment caused the greatest reduction in in vitro extractable Pb from field samples (pH 2.2) with a measured reduction of 66%, while the compost treatment had a 39% reduction and the 2.5% Fe + 1% P-TSP treatment a 50% reduction. The in vitro extraction (pH 1.5) run on field samples showed no reduction in the compost or Fe treatments. The 1% P-H3PO4 treatment was the most effective at reducing plant Pb, Zn, and Cd.

Examining Farmland Applications of Composted Biosolid Wastes Depending on Nutrient Balance in Soils

This study emphasizes nutrient balance of soils in the farmland application of composted biosolid wastes. The loading rates of plant nutrients following the compost application to farmland in Japan were estimated and compared with the nutrient uptake of agricultural plants. Results show that the current compost application in Japan can meet the requirements of agricultural plants for plant nutrient Ca, except for K, Mg, P, Fe, Mn, Cu, and Zn. The compost application could realize the safe disposal of biosolid wastes and the effective recycling of plant nutrients in composts to soils without causing heavy metal accumulation. The application manner of composts affects the heavy metal accumulation in farmlands. Field examination indicates that the excessive compost application has led to the heavy metal accumulation in compost-amended farmlands. Measuring the nutrient balance in compost-amended farmlands is well suitable for explaining the accumulation of heavy metals, such as Cu and Zn.

Pesticide Screening in a Commercial Yard Waste And Biosolids Compost

The presence of pesticides in compost is of interest because of possible health, production and ecological risks. The presence of over 50 pesticides was assessed in raw yard waste, milled yard waste, and a finished compost (yard waste:biosolids) at a commercial compost facility in Florida. These pesticides were comprised of 38 herbicides, eight insecticides and two fungicides. Of the pesticides monitored for in this study, only atrazine, 4,4-DDE, alpha chlordane, gamma chlordane, and endosulfan I were detected, and were only present in raw yard wastes.

Immobilization and phytoavailability of cadmium in variable charge soils. III. Effect of biosolid compost addition

The effect of pH-increases due to Ca(OH)2 and KOH addition on the adsorption of cadmium (Cd) was examined in two soils which varied in their variable-charge components. The effect of Ca(OH)2 on immobilization and phytoavailability of Cd from one of the soils, treated with various levels of Cd (0–10 mg Cd kg−1 soil), was further evaluated using mustard (Brassica juncea L.) plants. Cadmium immobilization in soil was evaluated by a chemical fractionation scheme. The addition of Ca(OH)2 and KOH increased the soil pH, thereby increasing the adsorption of Cd, the effect being more pronounced in the soil dominated by variable charge components. There was a greater increase in Cd2+ adsorption in the KOH-treated than the Ca(OH)2-treated soil, which is attributed to the greater competition of Ca2+ for adsorption. Increasing addition of Cd enhanced Cd concentration in plants, resulting in decreased plant growth (i.e., phytotoxicity). Although addition of Ca(OH)2 effectively reduced Cd phytotoxicity, Cd uptake increased at the highest level, probably due to decreased Cd2+ adsorption resulting from increased Ca2+ competition. There was a significant inverse relationship between dry matter yield and Cd concentration in soil solution. Addition of Ca(OH)2 decreased the concentration of the soluble + exchangeable Cd fraction but increased the concentration of inorganic-bound Cd fractions in soil. Since there was no direct evidence for CdCO3 or Cd(OH)2 precipitation in the variable charge soil used for the plant growth experiment, alleviation of phytotoxicity can be attributed primarily to immobilization of Cd by enhanced pH-induced increases in negative charge.

Effects of compost and phosphate amendments on arsenic mobility in soils and arsenic uptake by the hyperaccumulator, Pteris vittata L.

Chinese brake fern (Pteris vittata L.), an arsenic (As) hyperaccumulator, has shown the potential to remediate As-contaminated soils. This study investigated the effects of soil amendments on the leachability of As from soils and As uptake by Chinese brake fern. The ferns were grown for 12 weeks in a chromated–copper–arsenate (CCA) contaminated soil or in As spiked contaminated (ASC) soil. Soils were treated with phosphate rock, municipal solid waste, or biosolid compost. Phosphate amendments significantly enhanced plant As uptake from the two tested soils with frond As concentrations increasing up to 265% relative to the control. After 12 weeks, plants grown in phosphate-amended soil removed >8% of soil As. Replacement of As by P from the soil binding sites was responsible for the enhanced mobility of As and subsequent increased plant uptake. Compost additions facilitated As uptake from the CCA soil, but decreased As uptake from the ASC soil. Elevated As uptake in the compost-treated CCA soil was related to the increase of soil water-soluble As and As(V) transformation into As(III). Reduced As uptake in the ASC soil may be attributed to As adsorption to the compost. Chinese brake fern took up As mainly from the iron-bound fraction in the CCA soil and from the water-soluble/exchangeable As in the ASC soil. Without ferns for As adsorption, compost and phosphate amendments increased As leaching from the CCA soil, but had decreased leaching with ferns when compared to the control. For the ASC soil, treatments reduced As leaching regardless of fern presence. This study suggest that growing Chinese brake fern in conjunction with phosphate amendments increases the effectiveness of remediating As-contaminated soils, by increasing As uptake and decreasing As leaching.

Metal bioavailability and speciation in a wetland tailings repository amended with biosolids compost, wood ash, and sulfate.

Lead poisoning of waterfowl from direct ingestion of wetland mine tailings has been reported at the Coeur d'Alene River basin in Idaho. A greenhouse study was conducted to evaluate the effects of surface applications of amendments on lead bioavailability in the tailings. Treatments included sediment only, and sediment with three different surface amendments: (i) biosolids compost plus wood ash, (ii) compost + wood ash + a low SO4(2-) addition as K2SO4, and (iii) compost + wood ash + a high SO4(2-) addition. Measured variables included growth and tissue Pb, Zn, and Cd concentration of arrowhead (Sagittaria latifolia Willd.) and cattail (Typha latifolia L.) and soil pH, redox potential (Eh), pore water Pb, Pb speciation by X-ray absorption spectroscopy, and in vitro Pb bioavailability. The compost + ash amendment alleviated phytotoxicity for both plant species. Bioavailability of Pb as measured by a rapid in vitro extract decreased by 24 to 34% (over control) in the tailings directly below the amendment layer in the compost + SO4 treatments. The ratio of acid volatile sulfide (AVS) to simultaneously extracted metals (SEM) also indicated a reduction in Pb bioavailability (1:40 control, 1:20 compost, 1:8 compost + low SO4, and 1:3 compost + high SO4). Extended X-ray adsorption fine structure (EXAFS) and X-ray absorption near edge structure (XANES) spectroscopy data indicated that lead sulfide was greater after 99 d in the treatments that included additions of sulfate. These results indicated that, under reducing conditions, surface amendments of compost + wood ash (with or without sulfate) decreased the bioavailability of Pb in metal-contaminated mine tailings.

Effects of Organic Amendments on the Reduction and Phytoavailability of Chromate in Mineral Soil

In this study, seven organic amendments (biosolid compost, farm yard manure, fish manure, horse manure, spent mushroom, pig manure, and poultry manure) were investigated for their effects on the reduction of hexavalent chromium [chromate, Cr(VI)] in a mineral soil (Manawatu sandy soil) low in organic matter content. Addition of organic amendments enhanced the rate of reduction of Cr(VI) to Cr(III) in the soil. At the same level of total organic carbon addition, there was a significant difference in the extent of Cr(VI) reduction among the soils treated with organic amendments. There was, however, a significant positive linear relationship between the extent of Cr(VI) reduction and the amount of dissolved organic carbon in the soil. The effect of biosolid compost on the uptake of Cr(VI) from the soil, treated with various levels of Cr(VI) (0–1200 mg Cr kg−1 soil), was examined with mustard (Brassica juncea L.) plants. Increasing addition of Cr(VI) increased Cr concentration in plants, resulting in decreased plant growth (i.e., phytotoxicity). Addition of the biosolid compost was effective in reducing the phytotoxicity of Cr(VI). The redistribution of Cr(VI) in various soil components was evaluated by a sequential fractionation scheme. In the unamended soil, the concentration of Cr was higher in the organic-bound, oxide-bound, and residual fractions than in the soluble and exchangeable fractions. Addition of organic amendments also decreased the concentration of the soluble and exchangeable fractions but especially increased the organic-bound fraction in soil.

Metal Bioavailability and Speciation in a Wetland Tailings Repository Amended with Biosolids Compost, Wood Ash, and Sulfate

Metal Bioavailability and Speciation in a Wetland Tailings Repository Amended with Biosolids Compost, Wood Ash, and Sulfate

Effects of organic amendments on the reduction and phytoavailability of chromate in mineral soil.

In this study, seven organic amendments (biosolid compost, farm yard manure, fish manure, horse manure, spent mushroom, pig manure, and poultry manure) were investigated for their effects on the reduction of hexavalent chromium [chromate, Cr(VI)] in a mineral soil (Manawatu sandy soil) low in organic matter content. Addition of organic amendments enhanced the rate of reduction of Cr(VI) to Cr(III) in the soil. At the same level of total organic carbon addition, there was a significant difference in the extent of Cr(VI) reduction among the soils treated with organic amendments. There was, however, a significant positive linear relationship between the extent of Cr(VI) reduction and the amount of dissolved organic carbon in the soil. The effect of biosolid compost on the uptake of Cr(VI) from the soil, treated with various levels of Cr(VI) (0-1200 mg Cr kg(-1) soil), was examined with mustard (Brassica juncea L.) plants. Increasing addition of Cr(VI) increased Cr concentration in plants, resulting in decreased plant growth (i.e., phytotoxicity). Addition of the biosolid compost was effective in reducing the phytotoxicity of Cr(VI). The redistribution of Cr(VI) in various soil components was evaluated by a sequential fractionation scheme. In the unamended soil, the concentration of Cr was higher in the organic-bound, oxide-bound, and residual fractions than in the soluble and exchangeable fractions. Addition of organic amendments also decreased the concentration of the soluble and exchangeable fractions but especially increased the organic-bound fraction in soil.

The influence of temperature and moisture contents regimes on the aerobic microbial activity of a biosolids composting blend.

To understand the relationships between temperature, moisture content, and microbial activity during the composting of biosolids (municipal wastewater treatment sludge), well-controlled incubation experiments were conducted using a 2-factor factorial design with six temperatures (22, 29, 36, 43, 50, and 57 degrees C) and five moisture contents (30, 40, 50, 60, and 70%). The microbial activity was measured as O2 uptake rate (mg g(-1) h(-1)) using a computer controlled respirometer. In this study, moisture content proved to be a dominant factor impacting aerobic microbial activity of the composting blend. Fifty percent moisture content appeared to be the minimal requirement for obtaining activities greater than 1.0 mg g(-1) h(-1). Temperature was also documented to be an important factor for biosolids composting. However, its effect was less influential than moisture content. Particularly, the enhancement of composting activities induced by temperature increment could be realized by increasing moisture content alone.

Heavy Metal Content in Lettuce Plants Grown in Biosolids Compost

The objective of this work was to evaluate the affects of the application of composted biosolids on the accumulation of heavy metals (Cd, Cu, Ni, Pb and Zn) in lettuce leaves. Pots containing different proportions (0 to 100%) of composted biosolids were used to grow lettuce plants under greenhouse conditions. Dry and fresh weight, leaf area and Cd, Cu, Ni, Pb and Zn uptake were determined after harvest. It was found that the dry and fresh matter productions of the plants were significantly lower in the control treatment. The addition of composted biosolids caused a 20 and 40% increase in biomass accumulation. Cd and Pb concentrations in leaves were below detection limits (0.05 mg kg−1) in all treatments. Zn concentration in leaves increases as compost proportion decreases, ranging from 57.2 to 80.4 mg kg−1. Composted biosolids application increased the Cu and Ni plant concentrations, ranging from 5.1 to 9.8 mg Cu kg−1 and 2.3 to 3.7 mg Ni kg−1. In all treatments the proportions of heavy metals in plants were below the international standards of toxicity. The results allow us to suggest that, in short-term applications, composted biosolids could be used as soil amendment for lettuce production, without toxic effects in the chemical composition of the plant.

Mixtures of Coal Ash and Compost as Substrates for Highbush Blueberry

Bottom ash from a coal-fired power plant and two composts were tested as components of soil-free media and as soil amendments for growing highbush blueberry (Vaccinium corymbosum L.). Combinations of ash and compost were compared to Berryland sand, and Manor clay loam, and compost amended Manor clay loam. The pH of all treatment media was adjusted to 4.5 with sulfur at the beginning of the experiment. In 1997, plants of `Bluecrop' and `Sierra' were planted in 15-dm3 pots containing the pH-adjusted treatment media. The first substantial crop was harvested in 1999. At the end of the 1999 season, one half of the plants were destructively harvested for growth analysis. The remaining plants were cropped again in 2000. Yield and fruit size data were collected in both seasons, and leaf and fruit samples were collected in 1999 for elemental analysis. The presence of coal ash or composted biosolids in the media had no detrimental effect on leaf or fruit elemental content. Total growth and yield of both cultivars was reduced in clay loam soil compared to Berryland sand, whereas growth and yield of plants in coal ash-compost was similar to or exceeded that of plants in Berryland sand.

Cadmium forms and plant availability in compost-amended soil

Organic matter amendments to metal-contaminated soil can have an ameliorative effect due to increased surface area and an increase in the number of specific adsorption sites. A greenhouse experiment was conducted where composted biosolids were added at 0, 100, and 300 tons ha− 1 and a Cd salt was added at 0, 5, 10, 20, and 50 mg kg− 1 to a Southeastern Piedmont soil. Corn (Zea mays L.) was grown for 42 days and plant weights and cadmium (Cd) content was measured. Soil Cd was extracted according to a sequential fractionation procedure to extract operationally-defined forms of the metal. The CEC of the soil and the organic matter content increased with biosolid additions, but soil pH remained stable. Phytotoxicity was greatly reduced by addition of biosolids, especially at the medium rate of 10 mg kg− 1. Cadmium content of the plants was decreased from 105 to 30 mg kg− 1 by the biosolid additions at the 10 mg Cd kg− 1 rate. The decrease in phytotoxicity and in plant Cd was attributed to a redistribution of Cd from the water soluble and exchangeable fractions to the organic fraction, which decreased the plant availability. The results of this study indicate that composted biosolid amendments can be useful in decreasing Cd uptake by plants from contaminated soil and may bring about an increase in plant growth.

Growth of Ornamental Plants in Container Media Amended with Biosolids Compost

The use of biosolids compost, in the formulation of media used in the commercial production of container grown nursery crops, has been slow in the Northeast region of the United States. When biosolids compost is used in growing media, it is limited to small percentages. Regulations in Connecticut restrict the use of most biosolids compost to growing media for containerized ornamental plants and landfill cover. Information on the benefits of using biosolids compost, to grow a wide range of plant species in containers, could increase usage by nurseries. Seven species of flowering annuals, nine species of herbaceous perennials and eight species of woody ornamentals were grown in media containing 0, 25, 50, and 100 percent (by volume) biosolids compost, in combination with a mixture of bark, peat and sand. Biosolids compost came from the Metropolitan District Corporation (MDC) facility in Hartford, Connecticut. It was a mixture of wood chips and digested biosolids (3:1 by volume). Optimal plant growth generally occurred in media containing 50 and 100 percent compost. Plants growing in media high in compost were often somewhat stunted and chlorotic for several weeks after planting probably due to higher levels of salinity and ammonium nitrogen in their media. However, by the middle of the growing season these plants had recovered and at season's end, they were often superior to plants grown in media with less compost. Increasing proportions of compost generally increased the amounts of plant nutrients and heavy metals in media while decreasing air filled pore space. All heavy metal concentrations were below levels of concern.

Influence of biosolids compost on the bradyrhizobial genotypes recovered from cowpea and soybean nodules.

The interaction of biosolids compost application to soil and bradyrhizobial genotypes recovered from nodules was examined. Among 170 isolates, seven genotypes were recovered from soils receiving either no biosolids application or rates of 73 or 146 Mg/ha for three successive years. With the exception of one genotype, the distribution of the bacterial genotypes recovered from nodules was interrelated with the level of biosolids. Two of the genotypes nodulated both soybean and cowpea. Because soybean-nodulating bradyrhizobia were not recovered from control plots, it is possible that they had been introduced together with the biosolids compost application.

Effect of biosolids compost on two NSW coastal soils used to grow vegetables

The study compares the effects of biosolids compost (BC) and inorganic fertiliser (IF) on the nutrient status of a clay loam at Rydalmere in Western Sydney, and an earthy sand at Somersby, 85 km north of Sydney. The soils represent the textural range used for vegetable production in the Sydney Basin of New South Wales. The soils had been under permanent sod (Rydalmere) or native vegetation (Somersby) for at 40 years prior to the experiment. There were 3 treatments during February 1994: IF, fallow (F), and BC. The same plots were treated again during September 1994 to give the combinations: IF followed by IF (IF + IF); F by BC (F + BC); BC by BC (BC + BC). The 4 replicates of each treatment were randomised in blocks. Treatments were incorporated into raised beds to a depth of 15 cm and vegetables were planted in March and again in October 1994. The total amounts of C and N initially present in the soil in the beds (0-15 cm) at Rydalmere were at least 3 times greater than at Somersby and the ratio was greater for S, P, Ca, Mg, K, and Na. By April 1995, the quantities of the 8 monitored nutrients had decreased at both sites for the IF + IF treatment; increased at Somersby, but not at Rydalmere for F + BC; and increased at both sites for the BC + BC treatment. The changes caused by the BC + BC treatment were greater in relative terms at Somersby, because of the initial difference in fertility between the 2 soils. For example, the C and N content increased by an approximate factor of 2 at Somersby, and by greater factors for the other elements. BC + BC was also the only treatment to increase other indices of fertility, such as effective cation exchange capacity (ECEC) and Bray-P, in the surface 15 cm. The treatments did not affect pH in the soil profile (0-50 cm) and increases in EC were ephemeral. The nutrient composition of the 20-30 cm zone was affected at both sites. By the end of the experiment the concentration of C, N, P, Ca, and Bray-P increased and Mg decreased. For C and N between-treatment differences were small, indicating that the observed effects were mostly caused by leaching of the products of mineralisation of soil organic matter. Treatment effects were larger for P, Ca, Mg, and Bray-P, and the final concentrations for the F + BC and BC + BC treatments exceeded those for the IF + IF treatment. At Somersby, both BC treatments increased ECEC, consistent with the importance of leaching as a process of nutrient loss at this site. Consequently, intensive vegetable cropping may pose serious environmental risks particularly on sandy sites.

Controlling Organic Dust and Bioaerosols at a Biosolids Composting Facility

Controlling Organic Dust and Bioaerosols at a Biosolids Composting Facility

Composting of fish offal and biosolids in northwestern Patagonia

Composting of fish processing wastes and biosolids with wood by-products and yard trimmings was conducted during the summer of 1996 and winter of 1997 in NW Patagonia using: (i) static piles for fish offal and (ii) turning piles for biosolids. Fish offal was mixed with sawdust + wood shavings (FOC) at 3:1 ratio by weight and biosolids with wood shavings (BCw) and yard trimmings (BCt) at 1:1 ratio by volume. Samples were taken at six dates during the composting period and analyzed to determine the factors that predict compost maturity. Composting of biosolids was affected by the type of bulking agent during winter. Thermophilic temperatures ⩾55 °C were sustained long enough to satisfy the USEPA requirements for processes to further reduce pathogens (PFRP) in FOC and BCt, and for processes to significantly reduce pathogens (PSRP) in summer BCw, while in winter BCw temperatures were lower than those recommended for effective pathogen reduction. However, coliform fecal content in all BC treatments was less than 10 most probable number (MPN) g -1 dry sample at the end of the process. The ratio of water soluble carbon (WSC) to total nitrogen (TN) appeared to be a more adequate index to predict compost maturity than the ratio of total organic carbon to nitrogen.

Compost age and sample storage effects on maturity indicators of biosolids compost.

Compost product safety and quality assurance are required to meet the needs of the horticultural, agricultural, and silvicultural user markets. At present, there exist no industry-wide sampling and testing protocols for compost products, thus limiting the production sector. The objective of this research was to test three methods for determining compost maturity. The study followed the composting process of a locally successful commercial composting operation that had been producing lime-stabilized biosolids compost in the Washington, DC metro region for 12 yr. Change over time in the dependent variables--Dewar flask self-heating capacity, oxygen uptake rate, and cation exchange capacity (CEC)-during a 57-d composting of lime-stabilized biosolids was studied. Because cold storage at 4 degrees C is recommended when compost samples cannot be tested for maturity immediately, cold storage of up to 11 wk was included as a variable. Mathematical models were developed that predict change in the Dewar flask self-heating capacity, oxygen uptake rate, and CEC with composting time and storage at 4 degrees C. The Dewar flask self-heating test was the most useful indicator of compost maturity. This test showed change throughout the 57-d biosolids composting period while oxygen respirometry did not change after 29 d. The CEC was found to increase with age and storage. Storage effects varied for the different tests. Except for Days 1 and 57, composts continued to stabilize during storage. Testing stored composts may produce erroneous results that suggest the compost is mature.