Co-digestion Of Biowaste Research Articles

Determination of the dewatered digestate amounts and methane yields from the co-digestion of biowaste as a basis for a cost-benefit analysis

Co-digestion is the simultaneous digestion of two or more substrates and a common practice at wastewater treatment plants (WWTPs). The amounts of methane and digested sludge produced are key parameters for evaluating the economic efficiency of co-digestion. However, the share of dewatered digestate produced from co-substrates is not known. Synergistic effects in co-digestion, i.e. a better biodegradability compared to the mono-digestion of each substrate, might reduce the amounts of digested sludge and increase methane yields. However, these effects might also influence the calculation of methane and digestate quantities from co-substrates. The main objective of this work was to provide a basis for the cost-benefit analysis of biowaste (BW) co-digestion at WWTPs for this data. Therefore, continuous and batch experiments with sewage sludge (SS) and BW co-digestion were conducted and evaluated for methane and digestate production, and possible synergistic effects. BW co-digestion led to an additional production of 0.35 t total solids (TS) of dewatered sludge per ton TSadded in continuous and 0.23 t TS of dewatered sludge per ton of TSadded in batch experiments. The methane yield from BW was 441 L/kg TSadded in continuous experiments and 482 L/kg TSadded batch test. No synergistic effects were observed in both batch and continuous co-digestion experiments. Batch tests were found to be suitable for a rough estimation of the co-digestion economic efficiency key parameters. Continuous experiments are recommended to obtain more robust data. A cost-benefit analysis found that electricity production from co-digestion can generate savings of 88-170 €/t TSadded compared to grid purchase.

Continuous Anaerobic Co-Digestion of Biowaste with Crude Glycerol under Mesophilic Conditions

A persistent topic of the anaerobic digestion of biowaste is the efficient use of co-substrates. According to Renewable Energy Sources Act the co-substrate input is limited to 10 percent of the average daily substrate feed in Germany. In this concern, the primary focus of this paper is to understand the suitability of crude glycerol in anaerobic digestion of biowaste. Two identical lab-scale anaerobic digester units were added with crude glycerol, and each unit was equipped with four identical fermenters. Unit A was fed with an average organic loading rate of 4.5 kg VS m−3 d−1, and the average organic loading rate of unit B was set at 5.5 kg VS m−3 d−1. The share of crude glycerol in the total feed was 0.77 percent of the fresh matter. The abort criterion is a ratio of the volatile organic acids and buffer capacity (FOS/TAC) in the fermenter above 1.2. The abort criterion was reached after 16 days. In summary, the results lead us to the conclusion crude glycerol is not suitable as a co-substrate for anaerobic digestion for several reasons.