Composition Of Cheddar Cheese Research Articles

Cheddar Cheese from Ultrafiltered Whole Milk Retentates in Industrial Cheese Making

Transporting whole milk retentates of ultrafiltration to a distant large industrial Cheddar cheese making site resulted in 16 lots of Cheddar cheese from vats containing 2,546 to 16,360kg of cheese milk. Whole milk retentates concentrated by ultrafiltration to 4.5:1 were added to cheese milks to give mixtures concentrated 1.2:1 and 1.3:1 with approximately 20 and 30% more protein and fat, respectively, than in unsupplemented control whole milks or unsupplemented commercial reference milks.Gross composition of Cheddar cheese made from commercial reference, control, and retentate-supplemented milk generally showed no major differences. Yield increased in cheese made from retentate-supplemented milk. Yield efficiency per kilogram total solids rose in retentate cheese over controls but not among commercial reference, control, and retentate lots based on per kilogram fat or total protein. Milk components were higher in wheys from retentate cheeses, but loss of components per kilogram cheese obtained generally showed lower values in whey from retentate cheese.General quality of retentate Cheddar cheese was equal to that of reference unsupplemented commercial cheese and higher than unsupplemented control Cheddar cheeses. It appears technically feasible to ultrafilter milk at one site, such as the farm, collecting station, or specialized center, and transport it to an industrial site for Cheddar cheese making.

Influence of homogenization of concentrated milks on the structure and properties of rennet curds

SummaryWhole milk was concentrated by ultrafiltration in a plant causing some homogenization of the fat. Comparisons were made with milk concentrated in a plant causing little homogenization and with milk homogenized conventionally. None of the processes appreciably affected the casein micelle size distribution. On rennet treatment of homogenized milk, casein micelle aggregation occurred more slowly, the protein network in the curd was less coarse and the rate of whey loss was reduced, compared with non-homogenized milk at the same concentration. In using concentrated milks for cheesemaking homogenization improved the composition of Cheddar cheese, because of increased fat and moisture retention, but curd fusion was poorer. Some aspects of the texture of the mature cheeses were improved, but the free fatty acid levels were higher. Values for the firmness of curds, formed from milks processed in different ways, did not relate to the extent of aggregation of the casein micelles. It is suggested that the complete cheesemaking process is driven by the tendency of the casein to aggregate.

The effect of the microbial flora on the flavour and free fatty acid composition of cheddar cheese

SummaryComparisons were made of the flavour, free fatty acids and bacterial flora of commercial cheese made at different factories and experimental cheese made under aseptic conditions: (i) with δ-gluconic acid lactone instead of starter, (ii) with starter only, (iii) with starter and added floras derived from the curd of the commercial cheeses (reference flora cheeses).Comparison of the bacterial flora of commercial and reference flora cheeses showed that replication of organisms was better with some reference floras than with others. In all the cheeses the lactobacilli increased in numbers during maturation, whilst other groups of organisms died out.The amount of acetic acid present was influenced by the starter and by the lactobacilli. Single-strain starters produced some acetic acid, most of which was lost in the whey; commercial starters produced considerably more, due to the presence in them of Streptococcus diacetilactis. Later in maturation lactobacilli increased the acetic acid content, a greater increase being observed with homo-than with heterofermentative strains.The initial levels of butyric and higher fatty acids in the milk varied with source of the milk and with the season, summer milk having higher levels than winter milk. During cheese-making a slight increase of these acids occurred in every cheese made with starter and a further small increase occurred during ripening. However, there was no increase in the content of these acids in the cheese made with δ-gluconic acid lactone, indicating that lactic acid bacteria were weakly hydrolysing the milk fat.Flavour trials showed that Cheddar flavour was present not only in the reference flora and commercial cheese, but also in the cheese made with starter only. Different starters produced different intensities of flavour; one strain produced an intense fruity off-flavour. Cheeses made with δ-gluconic acid lactone were devoid of cheese flavour.

Changes in Composition of Cheddar Curd during Manufacture as a Guide to Cheese Making by Direct Acidification1,2

Studies were made to determine whether the properties and composition of Cheddar cheese could be reproduced by batch methods, using simplified procedures meeting requirements for mechanization. They indicated that curd milled at pH 5.3 to 5.4 should contain 41 to 43% moisture and 4.0 to 6.0g lactose per 100g buffering constituents (total solids minus fat and lactose). Nine lots of cheese made without starter from pasteurized whole milk acidified at 40F with lactic acid to pH 5.40±.05 and renneted at 86F ranged from 41.48 to 45.21% moisture. Attempts to follow a stirred-curd procedure after draining were complicated by matting of the curd. Bitterness always developed during storage.Three lots of cheese made from pasteurized whole milk inoculated with 0.25, 1.0, and 2.0% commercial lactic starter, acidified at 40F to pH 5.60±.03 and renneted at 86F, ranged from 38.78 to 41.04% moisture. Cooking to 112F did not produce matting. Vacuum treatment of curd (25 in. for 50min) produced close-textured cheese. Initial body shortness disappeared during storage. Lots made with 1.0 and 2.0% starter did not become bitter.