Beta-propiolactone Research Articles

Efficacy of an inactivated influenza vaccine adjuvanted with Toll-like receptor ligands against transmission of H9N2 avian influenza virus in chickens

Avian influenza viruses (AIV), including the H9N2 subtype, pose a major threat to the poultry industry as well as to human health. Although vaccination provides a protective control measure, its effect on transmission remains uncertain in chickens. The objective of the present study was to investigate the efficacy of beta-propiolactone (BPL) whole inactivated H9N2 virus (WIV) vaccine either alone or in combination with CpG ODN 2007 (CpG), poly(I:C) or AddaVax™ (ADD) to prevent H9N2 AIV transmission in chickens. The seeder chickens (trial 1) and recipient chickens (trial 2) were vaccinated twice with different vaccine formulations. Ten days after secondary vaccination, seeder chickens were infected with H9N2 AIV (trial 1) and co-housed with healthy recipient chickens. In trial 2, the recipient chickens were vaccinated and then exposed to H9N2 AIV-infected seeder chickens. Our results demonstrated that BPL+ CpG and BPL+ poly(I:C) treated chickens exhibited reduced oral and cloacal shedding in both trials post-exposure (PE). The number of H9N2 AIV+ recipient chickens in the BPL+ CpG group (trial 1) was lower than in other vaccinated groups, and the reduction was higher in BPL+ CpG recipient chickens in trial 2. BPL+ CpG vaccinated chickens demonstrated enhanced systemic antibody responses with high IgM and IgY titers with higher rates of seroprotection by day 21 post-primary vaccination (ppv). Additionally, the induction of IFN-γ expression and production was higher in the BPL+ CpG treated chickens. Interleukin (IL)− 2 expression was upregulated in both BPL+ CpG and BPL+ poly(I:C) groups at 12 and 24 hr post-stimulation.

Evaluation of Stability, Inactivation, and Disinfection Effectiveness of Mpox Virus.

Mpox virus (MPXV) infections have increased in many countries since May 2022, increasing demand for diagnostic tests and research on the virus. To ensure personnel safety, appropriate and reliable measures are needed to disinfect and inactivate infectious samples; Methods: We evaluated the stability of infectious MPXV cultures stored at different temperatures and through freeze-thaw cycles. Heat physical treatment (56 °C, 70 °C, 95 °C), chemical treatment (beta-propiolactone (BPL)) and two commercialized disinfectants (Micro-Chem Plus (MCP) and ethanol) were tested against infectious MPXV cultures; Results: The results indicated that MPXV stability increases with lower temperatures. The MPXV titer was stable within three freeze-thaw cycles and only decreased by 1.04 log10 (lg) 50% cell culture infective dose (CCID50) per milliliter (12.44%) after twelve cycles. MPXV could be effectively inactivated at 56 °C for 40 min, 70 °C for 10 min, and 95 °C for 5 min. For BPL inactivation, a 1:1000 volume ratio (BPL:virus) could also effectively inactivate MPXV. A total of 2% or 5% MCP and 75% ethanol treated with MPXV for at least 1 min could reduce >4.25 lg; Conclusions: MPXV shows high stability to temperature and freeze-thaw. Heat and BPL treatments are effective for the inactivation of MPXV, while MCP and ethanol are effective for disinfection, which could help laboratory staff operate the MPXV under safer conditions and improve operational protocols.

Optimizing virus inactivation methods for molecular detection techniques: Implications for viral protein and RNA measurements

To facilitate the development of effective viral detection techniques, a positive control material is required for validating their quantitative performance. Inactivated viruses serve as viable control materials, as they can be handled without the constraints of biohazard safety facilities. However, inactivation alters the structure of viral component molecules, necessitating the selection of inactivation methods that have minimal effects on the target molecules relevant to molecular detection techniques. Only a limited number of studies have investigated inactivation methods to produce viral control materials. Therefore, the aim of this study was to investigate various virus inactivation methods and evaluate their impact on molecular detection techniques, with a specific focus on viral proteins and RNA. We evaluated the effects of ultraviolet (UV) irradiation, heat, beta-propiolactone (BPL), hydrogen peroxide (H2O2), and perchloric acid (HClO4) inactivation methods to identify the most effective technique and its optimal conditions. Enzyme-linked immunosorbent assay (ELISA) and reverse transcription-digital polymerase chain reaction (RT-dPCR) were employed as model assays to assess the effects of these treatments on protein and RNA measurements. Among the evaluated methods, UV and heat treatments demonstrated minimal interference with ELISA, while heat treatment had the least impact on RT-dPCR measurements. Consequently, our findings revealed that heat inactivation holds the potential for producing inactivated viruses that can be effectively used in molecular detection techniques targeting both viral protein and RNA.

Study of the Genotoxicity of Beta-Propiolactone Using <i>E. coli</i> lux Biosensors and Nematode <i>Caenorhabditis elegans</i>

For the first time, lux biosensors of E. coli and the nematode Caenorhabditis elegans were used to study the genotoxicity of beta-propiolactone (BPL) used in the production of inactivated viral vaccines as an inactivator. It has been shown that the DNA-damaging activity of BPL is due not only to its ability to bind to bacterial DNA, but also to the ability to generate in the cell such reactive oxygen species as superoxide anion and peroxide, which have genotoxic activity. It was found that BPL in a dose-dependent manner, starting from a concentration of 0.001 mol/L, reduces the survival of bacteria. However, the intensity of expression of the antioxidant defense gene of superoxide dismutase soxS and the DNA repair gene colD increased. BPL induced DNA breaks in nematode cells detected by electrophoresis. The antioxidant acetylcysteine (ACC) reduced the genotoxic effects of BPL on both bacteria and nematode.

Development of an Inactivated Camelpox Vaccine from Attenuated Camelpox Virus Strain: Safety and Protection in Camels.

This article describes the preparation of an inactivated vaccine from an attenuated strain of camelpox. The attenuated camelpox virus (CMLV) was grown in lamb kidney cells and in Vero cells. CMLV was accumulated to a significantly higher (p ≤ 0.05) titer in lamb kidney cells (7.75 ± 0.08 log TCID50/mL) than in Vero cells (4.00 ± 0.14 log TCID50/mL). During virus inactivation, a concentration of 0.05% beta-propiolactone (BPL) completely inactivated the virus in 6 h at a temperature of 22 ± 1 °C, while a concentration of 0.2% formaldehyde inactivated the virus in 8 h. However, a viral antigen inactivated by BPL was used for vaccine preparation. The inactivated viral antigen was adsorbed with aluminum hydroxide gel, and as a result, an inactivated candidate vaccine was prepared. While the safety of the candidate vaccine was tested in camels and white mice, the protective efficacy of the vaccine was tested only in camels. In the safety evaluation of the inactivated vaccine, the vaccine was not observed to cause any adverse effects in mice and camels. During the immunogenicity study in camels, antibody formation started (0.2 ± 0.16 log2) at Day 21 post-vaccination (PV), and the antibody titer peaked (1.33 ± 0.21 log2) at Day 60 PV and decreased at Day 90 PV (0.50 ± 0.22 log2). Furthermore, no antibodies were detected in vaccinated camels from Days 180 to 365 PV. Camels that received vaccination and were subsequently exposed to wild-type virus evinced a healthy state despite lacking antibodies. In contrast, unvaccinated camels exhibited susceptibility to camelpox upon challenge.

Duck IL-7 as a novel adjuvant improves the humoral immune response to an inactivated duck tembusu virus vaccine

Duck tembusu virus (DTMUV), belonging to the Flavivirus genus, Flaviviridae family, has caused huge economic losses in the duck industry. However, the inactivated DTMUV vaccine requires multiple immunizations and has incomplete effectiveness. The humoral immune response is a key factor in the control of DTMUV infection. IL-7 derived from mammals has the ability to enhance antibody production. Whether duck IL-7 (duIL-7) possesses the ability to improve the humoral immunity of inactivated DTMUV vaccine has not yet been declared. Here, a beta-propiolactone (BPL)-inactivated DTMUV vaccine was employed to characterize the adjuvant property of duIL-7 in humoral immune responses. Intramuscular injection of DTMUV inactivated vaccine with or without duIL-7 was administered twice to the ducks. The results showed that duIL-7 was able to promote rapid antibody responses and enhance DTMUV-specific IgG and neutralizing antibody production to the vaccine. T follicular helper (Tfh) cells play a key role in assisting long humoral immunity. It was found that duIL-7 upregulated duIl-6 and duIl-21 gene expression at 3 w post first vaccination, which encode Tfh cell differentiation-related cytokines duIL-6 and duIL-21, respectively. This may be the reason that duIL-7 could prolong the humoral immune response to the inactivated DTMUV vaccine. Next, the ability of duIL-7 to simplify the immunization procedure of the inactivated DTMUV vaccine was tested. When ducks were immunized once, the titers of neutralizing antibodies in ducks from the inactivated DTMUV vaccine supplemented with duIL-7 group were significantly higher than those of ducks from the inactivated DTMUV vaccine group (P < 0.05). In addition, duIL-7 could assist the inactivated DTMUV vaccine in maintaining neutralizing antibodies at high levels during the whole experimental period. The viral titers in the ducks immunized with the inactivated DTMUV vaccine and duIL-7 were lower than those in the ducks immunized with the inactivated DTMUV vaccine alone at 3 days post infection (3 dpi, P < 0.05). Overall, duIL-7 possessed the ability to promote and prolong humoral immune responses to the inactivated DTMUV vaccine, even at one dose. This study provides a new efficient adjuvant for inactivated DTMUV vaccine development.

Development of inactivated heartwater (Ehrlichia ruminantium) vaccine in South Africa

Heartwater, Ehrlichia ruminantium infection in cattle, sheep, goats, and some wild ruminants, is an economically important disease in Africa characterized by high mortality rates in susceptible populations. In South Africa, the current commercial heartwater vaccine is an infection and treatment type of immunization using virulent live E. ruminantium organisms generated from blood of infected sheep with subsequent treatment of the animals with antibiotics at specific times during the course of infection. This vaccine has several inherent problems preventing its wide use as the vaccine must be administered intravenously and it does not protect against all the South African field isolates. A vaccine based on inactivation of Zimbabwean E. ruminantium Mbizi strain organisms produced in endothelial cell cultures can be a sustainable option because it will not require antibiotic treatment and will be safe as there is no potential for reversion to virulence. Previous data generated in laboratory trials and under natural field setting provides support for this vaccine approach.Four inactivated vaccine formulations using the E. ruminantium Mbizi strain were tested for their efficacy in Merino sheep compared to an unvaccinated control group (11 sheep per group). Two vaccines were prepared by beta-propiolactone (BPL) inactivation, and two were inactivated with binary ethylenimine (BEI) while purification was done with both percoll and polyethylene glycol (PEG). The four vaccine preparations were formulated with Montanide ISA 50V2 adjuvant and administered twice subcutaneously (2 ml per dose) at an interval of 4 weeks. All groups were challenged with a virulent homologous cell-cultured E. ruminantium inoculated via the intra-venous route on day 56. The primary variable of efficacy was measured by the percentage survival rate or mortality between the Controls and Vaccine Groups.Three vaccine formulations (BEI/Percoll (Group 3), BEI/PEG (Group 4), BPL/Percoll, (Group 1) had a significantly higher percent of animal surviving challenge compared to the unvaccinated control (p-values 0.001, 0.035, 0.030, respectively). The highest number of survivors was obtained in Group 3 BEI/Percoll; 10/11 (91%). Groups 4 (BEI/PEG) and Group 1 (BPL/Percoll) produced similar percentage of survivals of 64%. In contrast, the lowest survival rate of 50% was observed in Group 2 (BPL/PEG) which was numerically different but not significantly different from the unvaccinated control which had an 18% survival rate (2/11).The inactivated vaccine using BEI or BPL as inactivating agents blended with ISA 50 adjuvant induced protective immunity against challenge. The BEI/Percoll (Group 3) vaccination regimen was most efficacious against a lethal heartwater challenge as it significantly protected sheep against mortality which is the most important aspect of heartwater infections. Future work should be directed towards improvement of this vaccine formulation especially from the down-stream processing point of view as the percoll method is not scalable for commercialization purposes.

Comparison of Zika virus inactivation methods for reagent production and disinfection methods

Zika virus (ZIKV) infection remains a public health concern necessitating demand for long-term virus production for diagnostic assays and R&D activities. Inactivated virus constitutes an important component of the Trioplex rRT-PCR assay and serological IgM assay (MAC-ELISA). The aim of our study is to establish standard methods of ZIKV inactivation while maintaining antigenicity and RNA integrity. We tested viral supernatants by four different inactivation methods: 1. Heat inactivation at 56 °C and 60 °C; 2. Gamma-Irradiation; 3. Chemical inactivation by Beta-propiolactone (BPL) and 4. Fast-acting commercial disinfecting agents. Effectivity was measured by cytopathic effect (CPE) and plaque assay. RNA stability and antigenicity were measured by RT-PCR and MAC-ELISA, respectively. Results: Heat inactivation: Low titer samples, incubated at 56 °C for 2 h, showed neither CPE or plaques compared to high titer supernatants that required 2.5 h. Inactivation occurred at 60 °C for 60 min with all virus titers. Gamma irradiation: Samples irradiated at ≥3 Mrad for low virus concentrations and ≥5Mrad for high virus titer completely inactivated virus. Chemical Inactivation: Neither CPE nor plaques were observed with ≥0.045 % BPL inactivation of ZIKV. Disinfectant: Treatment of viral supernatants with Micro-Chem Plus™, inactivated virus in 2 min, whereas, Ethanol (70 %) and STERIS Coverage® Spray TB inactivated the virus in 5 min.

Propagation, Inactivation, and Safety Testing of SARS-CoV-2.

In late 2019, a novel coronavirus, severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) emerged in Wuhan, the capital of the Chinese province Hubei. Since then, SARS-CoV-2 has been responsible for a worldwide pandemic resulting in over 4 million infections and over 250,000 deaths. The pandemic has instigated widespread research related to SARS-CoV-2 and the disease that it causes, COVID-19. Research into this new virus will be facilitated by the availability of clearly described and effective procedures that enable the propagation and quantification of infectious virus. As work with the virus is recommended to be performed at biosafety level 3, validated methods to effectively inactivate the virus to enable the safe study of RNA, DNA, and protein from infected cells are also needed. Here, we report methods used to grow SARS-CoV-2 in multiple cell lines and to measure virus infectivity by plaque assay using either agarose or microcrystalline cellulose as an overlay as well as a SARS-CoV-2 specific focus forming assay. We also demonstrate effective inactivation by TRIzol, 10% neutral buffered formalin, beta propiolactone, and heat.

Multi-clade H5N1 virus-like particles: Immunogenicity and protection against H5N1 virus and effects of beta-propiolactone

During the past decade, H5N1 highly pathogenic avian influenza (HPAI) viruses have diversified genetically and antigenically, suggesting the need for multiple H5N1 vaccines. However, preparation of multiple vaccines from live H5N1 HPAI viruses is difficult and economically not feasible representing a challenge for pandemic preparedness. Here we evaluated a novel multi-clade recombinant H5N1 virus-like particle (VLP) design, in which H5 hemagglutinins (HA) and N1 neuraminidase (NA) derived from four distinct clades of H5N1 virus were co-localized within the VLP structure. The multi-clade H5N1 VLPs were prepared by using a recombinant baculovirus expression system and evaluated for functional hemagglutination and neuraminidase enzyme activities, particle size and morphology, as well as for the presence of baculovirus in the purified VLP preparations. To remove residual baculovirus, VLP preparations were treated with beta-propiolactone (BPL). Immunogenicity and efficacy of multi-clade H5N1 VLPs were determined in an experimental ferret H5N1 HPAI challenge model, to ascertain the effect of BPL on immunogenicity and protective efficacy against lethal challenge. Although treatment with BPL reduced immunogenicity of VLPs, all vaccinated ferrets were protected from lethal challenge with influenza A/VietNam/1203/2004 (H5N1) HPAI virus, indicating that multi-clade VLP preparations treated with BPL represent a potential approach for pandemic preparedness vaccines.

Examination of the effects of virus inactivation methods on the induction of antibody- and cell-mediated immune responses against whole inactivated H9N2 avian influenza virus vaccines in chickens

Several types of avian influenza virus (AIV) vaccines exist, including live-attenuated, vectored, and whole inactivated virus (WIV) vaccines. Inactivated vaccines offer some advantages compared to other types of vaccines, including ease of production and lack of ability to revert to a virulent state. However, WIV are poorly immunogenic, especially when these vaccines are delivered to mucosal surfaces. There are several factors that contribute to the immunogenicity of vaccines, one of which is the method used to inactivate viruses. Several methods exist for producing influenza WIVs, including formaldehyde, a chemical that affects protein structures leading to virus inactivation. Other methods include treatment with beta-propiolactone (BPL) and the application of gamma radiation, both of which have less effects on protein structures compared to formaldehyde, and instead alter nucleic acids in the virion. Here, we sought to determine the effect of the above inactivation methods on immunogenicity of AIV vaccines. To this end, chickens were vaccinated with three different H9N2 WIVs using formaldehyde, BPL, and gamma radiation for inactivation. In addition to administering these three WIVs alone as vaccines, we also included CpG ODN 2007, a synthetic ligand recognized by Toll-like receptor (TLR)21 in chickens, as an adjuvant for each WIV. Subsequently, antibody- and cell-mediated immune responses were measured following vaccination. Antibody-mediated immune responses were increased in chickens that received the BPL and Gamma WIVs compared to the formaldehyde WIV. CpG ODN 2007 was found to significantly increase antibody responses for each WIV compared to WIV alone. Furthermore, we observed the presence of cell-mediated immune responses in chickens that received the BPL WIV combined with CpG ODN 2007. Based on these results, the BPL WIV + CpG ODN 2007 combination was the most effective vaccine at inducing adaptive immune responses against H9N2 AIV. Future studies should characterize mucosal adaptive immune responses to these vaccines.

Immunologic evaluation of 10 different adjuvants for use in vaccines for chickens against highly pathogenic avian influenza virus

Avian influenza viruses (AIV) are a threat to poultry production worldwide. Vaccination is utilized as a component of control programs for both high pathogenicity (HP) and low pathogenicity (LP) AIV. Over 95% of all AIV vaccine used in poultry are inactivated, adjuvanted products. To identify the best formulations for chickens, vaccines were prepared with beta-propiolactone (BPL) inactivated A/British Columbia/314514-1/2004 H7N3 LP AIV using ten commercially available or experimental adjuvants. Each vaccine formulation was evaluated for immunogenicity in chickens. Challenge studies with an antigenically homologous strain of HPAIV were conducted to compare protection against mortality and measure reductions in virus levels in oral swabs. The four best adjuvants from the studies with BPL inactivated antigen were selected and tested identically, but with vaccines prepared from formalin inactivated virus. Mineral and vegetable oil based adjuvants generally induced the highest antibody titers with 100% seroconversion by 3weeks post vaccination. Chitosan induced positive antibody titers in 100% of the chickens, but the titers were significantly lower than those of most of the oil based adjuvants. Antibody levels from calcium phosphate and alginate adjuvanted groups were similar to those of non-adjuvanted virus. All groups that received adjuvanted vaccines induced similar levels of protection against mortality (0–20%) except the groups vaccinated with calcium phosphate adjuvanted vaccines, where mortality was similar (70%) to groups that received non-adjuvanted inactivated virus or no vaccine (60–100% mortality). Virus shedding in oral swabs was variable among the treatment groups. Formalin inactivated vaccine induced similar antibody titers and protection against challenge compared to BPL inactivated vaccine groups. These studies support the use of oil adjuvanted vaccines for use in the poultry industry for control for AIV.

Bovine vaccinia: Inactivated Vaccinia virus vaccine induces protection in murine model

Bovine vaccinia (BV), caused by Vaccinia virus (VACV), is a zoonosis characterized by exanthematous lesions on the teats of dairy cows and the milkers’ hands. Since 1999, due to the occurrence of many BV outbreaks in dairy farms across all Brazilian regions, there is a need to improve the control and prevention measures of the disease. Vaccination is one of the major tools to prevent viral diseases, and it could be an alternative for BV prevention. The main objective of this study was the development of vaccine formulations against BV using the inactivated VACV strain GP2 as antigen combined with different adjuvants. Potency tests were performed in mice, which were vaccinated with two doses at a 21-day interval, and then challenged with the vaccine homologous virus. VACV strain GP2 inactivated by beta-propiolactone (BPL) in association with adjuvants was effective in inducing a humoral immune response against VACV, as measured by neutralizing antibody (NA) titers, and was variable depending on the adjuvant used in each vaccine formulation. The vaccine formulation containing aluminum hydroxide (AH) associated with saponin as adjuvant induced the production of high NA titers in all vaccinated mice, giving 100% protection in Balb/c murine model after challenge with homologous virus.

Efficacy assessment of an inactivated Tembusu virus vaccine candidate in ducks

Duck Tembusu virus (TMUV) is a recently identified pathogen that causes severe egg drop and neurological disease in domestic duck and goose flocks. The infection has spread across the China mainland since its outbreak in 2010. Effective vaccines are needed to fight the disease. In this work, we describe the development and laboratory assessment of a cell culture-derived, inactivated duck TMUV vaccine. The TMUV-JXSP strain was successfully propagated on a baby hamster kidney cell line (BHK-21), inactivated with beta-propiolactone (BPL) and emulsified with mineral oil. The efficacy of different vaccination schedules was assessed in laying ducks and table ducks using virus challenge experiments. Two doses of vaccine provided efficient protection against the virus challenge to avoid the egg production drop in laying ducks. An ELISA demonstrated that 97% (39/40) of ducks seroconverted on day 21 after one dose of the inactivated vaccine and that significant increases in antibody titers against the virus were induced after the second immunization. For table ducks, a single dose of vaccine immunization resulted in a protection index of 87% and significant reduction of viral loads in tissues. Sterilizing immunity can be attained after second immunization. Our results demonstrate that BHK-21 cell culture is suitable for duck TMUV propagation and that BPL-inactivated TMUV vaccine can provide a high level of protection from virus challenge in laying ducks and table ducks. These data provide a scientific basis for the development of an inactivated vaccine for the prevention of duck TMUV infection.

Analysis of the beta-propiolactone sensitivity and optimization of inactivation methods for human influenza H3N2 virus

Beta-propiolactone (BPL) is used as an inactivating reagent for influenza virus in a number of countries. However, the treatment of viruses with BPL occasionally results in a decrease in the hemagglutinin (HA) titer, which complicates vaccine development. In the present study, we examined the biological and biochemical characteristics of human H1N1 and H3N2 viruses treated with BPL, and developed an inactivation method for BPL-sensitive viruses. A significant decrease in HA titer was detected in the H3N2 viruses examined. The decrease in the pH of the virus fluid was not associated with the decreased HA titer, indicating that the decrease in HA titer for the H3N2 virus is the result of the direct effect of BPL. Excessive modification of M1 by BPL and loss of virion diameter were observed in 0.1% BPL-treated H3N2 virus. Taken together, these results suggest that the BPL sensitivity of H3N2 virus results from disruption of the virion. By contrast, the H3N2 virus was successfully inactivated by 0.02% BPL without a significant decrease in the HA titer or disruption of virion structure. Furthermore, we found that the 0.02% BPL in the virion preparation was hydrolyzed successfully by incubation at 37°C for 7h. Thus, mild treatment with a low concentration of BPL enabled us to inactivate the H3N2 virus.

Study of rabies virus by Differential Scanning Calorimetry

Differential Scanning Calorimetry (DSC) has been used in the past to study the thermal unfolding of many different viruses. Here we present the first DSC analysis of rabies virus. We show that non-inactivated, purified rabies virus unfolds cooperatively in two events centered at approximately 62 and 73°C. Beta-propiolactone (BPL) treatment does not alter significantly viral unfolding behavior, indicating that viral inactivation does not alter protein structure significantly. The first unfolding event was absent in bromelain treated samples, causing an elimination of the G-protein ectodomain, suggesting that this event corresponds to G-protein unfolding. This hypothesis was confirmed by the observation that this first event was shifted to higher temperatures in the presence of three monoclonal, G-protein specific antibodies. We show that dithiothreitol treatment of the virus abolishes the first unfolding event, indicating that the reduction of G-protein disulfide bonds causes dramatic alterations to protein structure. Inactivated virus samples heated up to 70°C also showed abolished recognition of conformational G-protein specific antibodies by Surface Plasmon Resonance analysis. The sharpness of unfolding transitions and the low standard deviations of the Tm values as derived from multiple analysis offers the possibility of using this analytical tool for efficient monitoring of the vaccine production process and lot to lot consistency.

Evaluation of different inactivation methods for high and low pathogenic avian influenza viruses in egg-fluids for antigen preparation

In view of the emerging avian influenza (AI) viruses, it is important to study the susceptibility of AI viruses to inactivating agents for preparation of antigens and inactivated vaccines. The available information on susceptibility of both the high and low pathogenic AI viruses to different inactivating agents is inadequate and ambiguous. It has been shown that different subtypes of influenza viruses require different physical and chemical conditions for inactivation of infectivity. The present study was undertaken to evaluate the use of beta-propiolactone (BPL), formalin and ether for inactivation and its impact on antigenicity of AI viruses.A total of nine high and low pathogenic AI viruses belonging to four influenza A subtypes were included in the study. The H5N1 viruses were from the clades 2.2, 2.3.2.1 and 2.3.4. The H9N2 virus included in the study was of the G1 genotype, while the H11N1 and H4N6 viruses were from the Eurasian lineage. The viruses were treated with BPL, formalin and with ether. The confirmation of virus inactivation was performed by two serial passages of inactivated viruses in embryonated chicken eggs.The infectivity of all tested AI viruses was eliminated using 0.1% BPL and 0.1% formalin. Ether eliminated infectivity of all tested low pathogenic AI viruses; however, ether with 0.2% or 0.5% Tween-20 was required for inactivation of the highly pathogenic AI H5N1 viruses. Treatment with BPL, ether and formalin retained virus hemagglutination (HA) titers. Interestingly ether treatment resulted in significant rise in HA titers (P<0.05) of all tested AI viruses. This data demonstrated the utility of BPL, formalin and ether for the inactivation of infectivity of AI viruses used in the study for the preparation of inactivated virus antigens for research and diagnosis of AI.

Development of a whole cell pneumococcal vaccine: BPL inactivation, cGMP production, and stability

Pneumococcal infections impose a large burden of disease on the human population, mainly in developing countries, and the current pneumococcal vaccines offer serotype-specific protection, but do not cover all pathogenic strains, leaving populations vulnerable to disease caused by non-vaccine serotypes. The pneumococcal whole cell vaccine is a low-cost strategy based on non-capsular antigens common to all strains, inducing serotype-independent immunity. Therefore, we developed the process for the cGMP production of this cellular vaccine. Initially, three engineering runs and two cGMP runs were performed in 60-L bioreactors, demonstrating the consistency of the production process, as evaluated by the growth curves, glucose consumption and metabolite formation (lactate and acetate). Cell recovery by tangential filtration was 92±13%. We optimized the conditions for beta-propiolactone (BPL) inactivation of the bacterial suspensions, establishing a maximum cell density of OD600 between 27 and 30, with a BPL concentration of 1:4000 (v/v) at 150rpm and 4°C for 30h. BPL was hydrolyzed by heating for 2h at 37°C. The criteria and methods for quality control were defined using the engineering runs and the cGMP Lots passed all specifications. cGMP vaccine Lots displayed high potency, inducing between 80 and 90% survival in immunized mice when challenged with virulent pneumococci. Sera from mice immunized with the cGMP Lots recognized several pneumococcal proteins in the extract of encapsulated strains by Western blot. The cGMP whole cell antigen bulk and whole cell vaccine product lots were shown to be stable for up to 12 and 18 months, respectively, based upon survival assays following i.p. challenge. Our results show the consistency and stability of the cGMP whole cell pneumococcal vaccine lots and demonstrate the feasibility of production in a developing country setting.

Treatment of influenza virus with Beta-propiolactone alters viral membrane fusion

Beta-propiolactone (BPL) is commonly used as an inactivating reagent to produce viral vaccines. Although BPL has been described to chemically modify nucleic acids, its effect on viral proteins, potentially affecting viral infectivity, remains poorly studied. Here, a H3N2 strain of influenza virus was submitted to treatment with various BPL concentrations (2–1000μM). Cell infectivity was progressively reduced and entirely abolished at 1mM BPL. Virus fusion with endosome being a critical step in virus infection, we analyzed its ability to fuse with lipid membrane after BPL treatment. By monitoring calcein leakage from liposomes fusing with the virus, we measured a decrease of membrane fusion in a BPL dose-dependent manner that correlates with the loss of infectivity. These data were complemented with cryo transmission electron microscopy (cryoTEM) and cryo electron tomography (cryoET) studies of native and modified viruses. In addition, a decrease of leakage irrespective of BPL concentration was measured suggesting that the insertion of HA2 fusion peptide into the target membrane was inhibited even at low BPL concentrations. Interestingly, mass spectrometry revealed that HA2 and M1 matrix proteins had been modified. Furthermore, fusion activity was partially restored by the protonophore monensin as confirmed by cryoTEM and cryoET. Moreover, exposure to amantadine, an inhibitor of M2 channel, did not alter membrane fusion activity of 1mM BPL treated virus. Taken together these results show that BPL treatment inhibits membrane fusion, likely by altering function of proteins involved in the fusion process, shedding new light on the effect of BPL on influenza virus.

Induction of mucosal and systemic immunity against respiratory syncytial virus by inactivated virus supplemented with TLR9 and NOD2 ligands

Respiratory syncytial virus (RSV) infection is the most important viral cause of severe respiratory disease in infants and children worldwide and also forms a serious threat in the elderly. The development of RSV vaccine, however, has been hampered by the disastrous outcome of an earlier trial using an inactivated and parenterally administered RSV vaccine which did not confer protection but rather primed for enhanced disease upon natural infection. Mucosal administration does not seem to prime for enhanced disease, but non-replicating RSV antigen does not induce a strong mucosal immune response. We therefore investigated if mucosal immunization with inactivated RSV supplemented with innate receptor ligands, TLR9 (CpG ODN) and NOD2 (L18-MDP) through the upper or total respiratory tract is an effective and safe approach to induce RSV-specific immunity. Our data show that beta-propiolactone (BPL) inactivated RSV (BPL-RSV) supplemented with CpG ODN and L18-MDP potentiates activation of antigen-presenting cells (APC) in vitro, as demonstrated by NF-κB induction in a model APC cell line. In vivo, BPL-RSV supplemented with CpG ODN/L18-MDP ligands induces local IgA responses and augments Th1-signature IgG2a subtype responses after total respiratory tract (TRT), but less efficient after upper respiratory tract (intranasal, IN) immunization. Addition of TLR9/NOD2 ligands to the inactivated RSV also promoted affinity maturation of RSV-specific IgG antibodies and shifted T cell responses from mainly IL-5-secreting cells to predominantly IFN-γ-producing cells, indicating a Th1-skewed response. This effect was seen for both IN and TRT immunization. Finally, BPL-RSV supplemented with TLR9/NOD2 ligands significantly improved the protection efficacy against a challenge with infectious virus, without stimulating enhanced disease as evidenced by lack of eotaxin mRNA expression and eosinophil infiltration in the lung. We conclude that mucosal immunization with inactivated RSV antigen supplemented with TLR9/NOD2 ligands is a promising approach to induce effective RSV-specific immunity without priming for enhanced disease.