Baby Hamster Kidney Cell Cultures Research Articles

Preparation and the assessed efficacy of oral baits for the vaccination of free-roaming dogs against rabies.

Background and Aim:Rabies is considered a highly fatal zoonotic disease and many deaths in humans have been associated with dog bites. This study was designed to prepare an oral anti-rabies vaccine in the form of baits to eliminate the disease in free-roaming dogs and subsequently protect humans from dog bites.Materials and Methods:The Evelyn Rokintniki Abelseth (ERA) rabies virus strain was propagated in baby hamster kidney cell cultures and adjusted to the recommended dose for application. Four forms of oral baits were employed with the rabies vaccine, which was evaluated for safety, acceptability, and potency in different dog groups. Enzyme-Linked Immunosorbent Assay (ELISA) and the serum neutralization test (SNT) were used to determine the protective rabies antibody titer in the sera of vaccinated dogs.Results:According to the results, a dose of 3 mL of the ERA strain, containing a viral titer of 107.6 TCID50/mL, induced a mean antibody titer of 25.6 by SNT, and the PI% was 75.7 by Block ELISA, providing a protective level of the rabies antibody in 100% of vaccinated dogs. All used baits were found to be safe, inducing no abnormal general post-vaccination signs (the signs are limited to mild fever, mild loss of appetite, and mild-to-moderate loss of energy for 24-36 h after vaccination).Conclusion:It was found that most of the accepted and highly potent bait types consisted of a mixture of wheat flour, vegetable oil, sodium alginate, corn starch, meat meal, cellulose gum, and water. This dog meal was covered with bran and edible wax to seal the bait cavity after inserting the vaccine sachet. This bait was able to induce a protective level of rabies antibodies in 100% of vaccinated dogs after receiving one bait/dog. Hence, such a bait could be recommended for use in the protection of free-roaming dogs and the elimination of the disease.

Substrate Optimization in Baby Hamster Kidney Cell Culture for Foot and Mouth Disease Virus Vaccine Using the Taguchi Method.

Cell culture is one of the most commonly used techniques in the production of biological products. Many physical and chemical parameters may affect cell growth and proliferation. This study was conducted to investigate the effect of chemical components as supplements using the experimental design method, which aimed at reducing the number of experiments. For this purpose, supplements including chemical components using four levels, with three replications in suspension and batch culture conditions, were examined for 72 hours using the Taguchi experimental design method. From the experiments, it was concluded that the culture media composition had a significant impact on final cell count and pH. High concentrations of different media composition alone were insufficient to ensure higher cell count. According to the results, this insufficiency was associated with an increase of 20% in the number of final cells. In the majority of cultures, the number of final cells at 48 hours increased relative to the number of final cells at 24 hours after culturing the cells.

Isolation and Molecular Characterization of Foot and Mouth Disease SAT2 Virus during Outbreak 2012 in Egypt

During April and May 2012, six outbreaks of FMD type SAT 2 were reported in Egyptian governorates: EL- Gharbiya (Kafr Qeretna, Al – Mahala Alkobra, Ebshaway Almalak, Qutoor), local cattle, buffaloes and dairy farms in Kafr El-Shaykh (Alsalmya, Fouah), AL - Minya (Village 3, Samalout, Mansafees, Abo Querkas), Dumyat (Ezbet 20, Kafr saad), ALexandria (Iraq Village, Al Aamerya), EL minufya (Monshaat Gerges, Ashmoun, Shatanoof, Ezbet Algalayla, Berket Alsabaa, Mahalet Sabak),Luxor (Al Gorna) and Al- Sharqiya (Al -Telleen, Menya Al kamh) Governorates. Suspected FMD virus samples (22 Tongue epithelium (TE), 12 vesicular fluid samples (VF)), in addition to, 10 cell culture grown virus of tongue epithelium origin, 6 cell culture grown virus of vesicular fluid origin. The assays used in this study involved CFT and Indirect ELISA typing kits for typing of FMDV virus samples; 3ABC-FMD for differentiation between vaccinated and infected animals in any revealed protective immune response in the examined sera from Egypt 2012 outbreak. PCR as an advanced confirmatory technique was done before submitting FMDV suspected clinical samples for Reference Laboratory of Foot and Mouth Disease in Pirbright, United Kingdom. Samples were isolated on primary bovine kidney and Baby Hamster kidney cell cultures, where all samples gave cytopathic effect. Also, all virus samples inoculated in swiss albino suckling baby mice showed pathognomonic paralysis effect of the virus in hind limbs of mice. Serum samples collected from suspected infected cattle were examined using FMD-3ABC. All positive samples to 3ABC antibodies indicated that the animals were infected by FMDV. FMD antibody detection revealed infection of 62%, 100%, 61%, 37.5%, 45.5% , 72.7% and 66.6% of sera collected from Al-Gharbiya, Kafr El-Shaykh, Dumyat, Alexandria, Al-Monufya, Luxor and Al-Sharqiya respectively. The obtained results of 3ABC antibodies were subsequently confirmed by Indirect ELISA Kit, which revealed that the causative agent of the outbreak was FMDV SAT2. The prefinal confirmatory technique was the Reverse transcription polymerase chain reaction (RT-PCR), which was done to detect clinically suspicious samples using target primers. Also, DNA sequencing of the current FMDV strain was performed and revealed that there was no significant divergence among the isolated strains as the divergence was 0.3 to 2.2% among them, and also there was no significant divergence between the isolated strains and FMDV SAT2/EGY/5/2012 and SAT2/EGY/15/2012 The closest percentage of identity of the isolated strains in comparison with reference strains was 89.4% with FMDV SAT2/LIB/2003. For official confirmation, the isolated viruses were sent to the Reference Laboratory for Foot and Mouth Disease in Pirbright, United Kingdom. Isolation of the causative agent is the first step for diagnosis of the disease. Finally, the PCR product was sequenced and analyzed using the gene bank data to confirm that the new out

Isolation of Trypanosoma (Megatrypanum) theileri from Dairy Cattle in Taiwan

Although Trypanosoma (Megatrypanum) theileri, a blood parasite of bovid species, is spread widely throughout the world, it has never been reported in Taiwan. When an anti-coagulated blood sample from febrile dairy cattle was directly smeared, no parasite was observed. However, a highly distinctive morphological feature of trypanosome appeared in baby hamster kidney (BHK) cell culture inoculated with non-thrown blood buffy coat. The different stages and typical ultrastructures of trypanosome were observed in our isolate. The isolate was subsequently identified as T. theileri by species-specific PCR assay (Tth625), 18S rDNA sequencing alignment and internal transcribed spacer of ribosomal genes (ITS) as a marker for molecular phylogenetic analysis. The first T. theileri isolate in Taiwan (TWTth1) could be periodically passaged in BHK cell culture for more than one year and retained good re-cryopreservation viability. The BHK culture method would be excellent for diagnostic isolation and maintenance long-term development of this parasite.

Paired Cysteine Mutagenesis to Establish the Pattern of Disulfide Bonds in the Functional Intact Secretin Receptor

The amino-terminal domain of class B G protein-coupled receptors contains six conserved cysteine residues involved in structurally and functionally critical disulfide bonds. The mapping of these bonds has been unclear, with one pattern based on biochemical and NMR structural characterizations of refolded, nonglycosylated amino-terminal fragments, and another pattern derived from functional characterizations of intact receptors having paired cysteine mutations. In the present study, we determined the disulfide bonding pattern of the prototypic class B secretin receptor by applying the same paired cysteine mutagenesis approach and confirming the predicted bonding pattern with proteolytic cleavage of intact functional receptor. As expected, systematic mutation to serine of the six conserved cysteine residues within this region of the secretin receptor singly and in pairs resulted in loss of function of most constructs. Notable exceptions were single mutations of the 4th and 6th cysteine residues and paired mutations involving the 1st and 3rd, 2nd and 5th, and 4th and 6th conserved cysteines, with secretin eliciting statistically significant cAMP responses above basal levels of activation for each of these constructs. Immunofluorescence microscopy confirmed similar levels of plasma membrane expression for each of the mutated receptors. Furthermore, cyanogen bromide cleaved a series of wild type and mutant secretin receptors, yielding patterns that agreed with our paired cysteine mutagenesis results. In conclusion, these data suggest the same pattern of disulfide bonding as that predicted previously by NMR and thus support a consistent pattern of amino-terminal disulfide bonds in class B G protein-coupled receptors.

Upregulation of myogenin by N-cadherin adhesion in three-dimensional cultures of skeletal myogenic BHK cells.

Cells of the baby hamster kidney (BHK) line express the skeletal muscle determining transcription factor MyoD but fail to differentiate. Unlike most skeletal myogenic cells, which express multiple members of the cadherin family of cell-cell adhesion proteins, the BHK cells lack a robust cadherin adhesion system. We previously published that forced expression of N- (or E)-cadherin in BHK cells increases the level of endogenous catenins, mediates strong cell-cell adhesion, and enhances differentiation of BHK cells induced to differentiate by placing them in three-dimensional (3-D) culture (Redfield et al. [1997] J. Cell. Biol. 138:1323-1331). This report demonstrates that N-cadherin adhesion upregulates the protein level of nuclear myogenin in cells induced to differentiate by 3-D culture. Myogenin is a transcription factor required for differentiation of skeletal muscle. It was not detected in monolayer culture, whether the cells expressed N-cadherin or not, nor was it upregulated in 3-D cultures of cells lacking N-cadherin. The activity of two myogenin-chloramphenicol acetyltransferase (CAT) reporter constructs containing 3.7 or 1.1 kb upstream regulatory region of the mouse myogenin gene was increased significantly in N-cadherin-expressing cells induced to differentiate by 3-D culture. Our observations indicate that N-cadherin adhesion stimulates skeletal myogenesis by upregulating myogenin.

Effect of polyclonal antisera developed against dense granule-associated Neospora caninum proteins on cell invasion and development in vitro by N. caninum tachyzoites.

The effects of polyclonal antisera to 2 recombinant dense granule (DG) antigens of Neospora caninum on invasion and development by N. caninum tachyzoites in baby hamster kidney cell cultures were examined. In immunofluorescent antibody tests, the anti-DG sera, at dilutions of 1:100 to 1:500, reacted intensely with individual intracellular tachyzoites and groups of tachyzoites enclosed in parasitophorous vacuoles at 2 and 52 h p.i., respectively. Tachyzoites suspended in diluted anti-DG sera and inoculated immediately into the cell cultures invaded cells in significantly fewer numbers (53-68% fewer by 2 h p.i.) than tachyzoites suspended in similarly diluted normal rabbit serum. In contrast, tachyzoites suspended in anti-Eimeria tenella sporozoite serum invaded cells as efficiently as those suspended in normal rabbit serum. Addition of anti-DG sera at the time of inoculation of tachyzoites, or to the cell cultures after the parasites had entered cells, had little effect on either the percentage or rate of their subsequent development.

Selection of Receptor-Binding Variants of Human Influenza A and B Viruses in Baby Hamster Kidney Cells

Cultivation of human influenza viruses in the allantoic cavity of embryonated chicken eggs leads to a selection of receptor-binding variants with amino acid substitutions on the globular head of the hemagglutinin (HA) molecule. Such selection can be avoided by growing the human viruses in Madin Darby canine kidney (MDCK) cells. In the present study, we tested whether baby hamster kidney (BHK) cells select receptor-binding mutants of human influenza viruses. After isolating H1N1, H3N2, and type B influenza viruses from clinical samples in MDCK cells, we passaged them in either BHK cells or chicken eggs. The BHK-grown viruses differed from their MDCK-grown counterparts by virtue of mutations in the HA: 225D → G (H1N1 virus), 128T → A and 226I → V (H3N2), and 187N → D (type B) (H3 numbering). Variants with different substitutions were selected by passaging of the same MDCK-grown parents in eggs: 141L → H, 208R → H, and 225D → G (H1N1), 194L → I (H3N2), and 137G → R (B). Compared with their MDCK-grown counterparts, both BHK- and egg-grown viruses possessed a higher affinity for the cellular membranes of BHK cells and of the chorioallantoic cells of chicken embryos and for a 3′-sialylgalactose-containing synthetic sialylglycopolymer. By contrast, changes in the affinity of mutants for a 6′-sialyl-(N-acetyllactosamine)-containing sialylglycopolymer varied from negative to positive. Fluorescence-activated cell-sorting analysis with linkage-specific lectins showed that the density of the 6′-sialyl-(N-acetyllactosamine)-containing receptors is substantially lower on the surface of BHK cells than on MDCK cells, providing an explanation for the growth restriction of human viruses in the former cells. Our data demonstrate that cultures of BHK cells, like eggs, can select receptor-binding variants of human influenza viruses.

Metabolic responses to different glucose and glutamine levels in baby hamster kidney cell culture

In this work, a BHK21 clone producing a recombinant antibody/cytokine fusion protein was used to study the dependence of cell metabolism on the glucose and glutamine levels in the culture medium. Results obtained indicate that both glucose and glutamine consumptions show a Michaelis-Menten dependence on glucose and glutamine concentrations respectively. A similar dependence is also observed for lactate and ammonia productions. The estimated value of the Michaelis constant for the dependence of lactate production on glucose (KLacGlc) was 1.4 +/- 0.1 mM and for the dependence of ammonia production on glutamine (KAmmGln) was 0.25 +/- 0.11 mM and 0.10 +/- 0.03 mM, at glucose concentrations of 0.28 mM and 5.6 mM respectively. At very low glucose concentrations, the glucose to lactate yield decreased markedly, showing a metabolic shift towards lower lactate production. This metabolic shift was also confirmed by the significant increase in the specific oxygen consumption rate also observed at low glucose concentrations. Although it was highly dependent on glucose concentration, the oxygen consumption also increased with the increase in glutamine concentration. At very low glutamine concentrations, the glutamine to ammonia yield increased, showing a more efficient glutamine metabolism.

Adaptation of Sindbis virus to BHK cells selects for use of heparan sulfate as an attachment receptor.

Attachment of Sindbis virus to the cell surface glycosaminoglycan heparan sulfate (HS) and the selection of this phenotype by cell culture adaptation were investigated. Virus (TR339) was derived from a cDNA clone representing the consensus sequence of strain AR339 (K. L. McKnight, D. A. Simpson, S. C. Lin, T. A. Knott, J. M. Polo, D. F. Pence, D. B. Johannsen, H. W. Heidner, N. L. Davis, and R. E. Johnston, J. Virol. 70:1981-1989, 1996) and from mutant clones containing either one or two dominant cell culture adaptations in the E2 structural glycoprotein (Arg instead of Ser at E2 position 1 [designated TRSB]) or this mutation plus Arg for Ser at E2 114 [designated TRSB-R114]). The consensus virus, TR339, bound to baby hamster kidney (BHK) cells very poorly. The mutation in TRSB increased binding 10- to 50-fold, and the additional mutation in TRSB-R114 increased binding 3- to 5-fold over TRSB. The magnitude of binding was positively correlated with the degree of cell culture adaptation and with attenuation of these viruses in neonatal mice. HS was identified as the attachment receptor for the mutant viruses by the following experimental results. (i) Low concentrations of soluble heparin inhibited plaque formation on and binding of mutant viruses to BHK cells by >95%. In contrast, TR339 showed minimal inhibition at high concentrations. (ii) Binding and infectivity of TRSB-R114 was sensitive to digestion of cell surface HS with heparinase III, and TRSB was sensitive to both heparinase I and heparinase III. TR339 infectivity was only slightly affected by either digestion. (iii) Radiolabeled TRSB and TRSB-R114 attached efficiently to heparin-agarose beads in binding assays, while TR339 showed virtually no binding. (iv) Binding and infectivity of TRSB and TRSB-R114, but not TR339, were greatly reduced on Chinese hamster ovary cells deficient in HS specifically or all glycosaminoglycans. (v) High-multiplicity-of-infection passage of TR339 on BHK cell cultures resulted in rapid coselection of high-affinity binding to BHK cells and attachment to heparin-agarose beads. Sequencing of the passaged virus population revealed a mutation from Glu to Lys at E2 70, a mutation common to many laboratory strains of Sindbis virus. These results suggest that TR339, the most virulent virus tested, attaches to cells through a low-affinity, primarily HS-independent mechanism. Adaptive mutations, selected during cell culture growth of Sindbis virus, enhance binding and infectivity by allowing the virus to attach by an alternative mechanism that is dependent on the presence of cell surface HS.

Silicone-based microcarriers: preparation and BHK cell culture

Spherical polymeric microbeads were produced by suspension cross-linking of hydroxyl-terminated polydimethylsiloxane prepolymers. Dimethylsiloxane-ethyleneoxide copolymer, dibutyltin dilaurate and methyltriethoxysilane were used as surfactant, catalyst and cross-linker, respectively. The surfaces of the microbeads were further modified by exposure of 3-amino-propyltriethoxysilane plasma in a glow-discharge apparatus. These silicone-based microbeads were used as microcarriers in culturing of baby hamster kidney (BHK) cells both in stationary and in submerged culture conditions. High attachment and growth were achieved on the glow-discharge treated silicone microbeads with moderate surface wettabilities (contact angle: 43−46°).

Effects of Triturated Culiseta melanura (Diptera: Culicidae) on Recovery of Eastern Equine Encephalomyelitis Virus

Experiments were done to determine the effect, if any, of larval and adult Culiseta melanura (Coquillett) suspensions on the recovery of eastern equine encephalomyelitis (EEE) virus in baby hamster kidney (BHK) and Vero cell cultures. Although triturated pools of this mosquito reduced the titer of EEE virus added to suspensions, suspensions prepared from as many as 100 Cs. melanura larvae or adults did not reduce titers of virus to undetectable levels. Similarly, the titer of EEE virus in orally infected female Cs. melanura remained detectable when a single infected mosquito was triturated in a pool with 99 uninfected mosquitoes. These results show that in BHK or Vero cell culture assay systems, triturated Cs. melanura do not completely prevent the detection of EEE virus. The results therefore indicate that mosquito suspensions would not interfere with the isolation of virus from field-collected mosquitoes. This conclusion suggests that mosquito suspensions were not a factor in previous studies that were unsuccessful at detecting transovarial transmission of EEE virus by Cs. melanura.

Entry of Rickettsia tsutsugamushi into polymorphonuclear leukocytes

Factors involved in the phagocytosis and entry into polymorphonuclear leukocytes (PMNs) of Rickettsia tsutsugamushi were studied by electron microscopy. R. tsutsugamushi propagated in baby hamster kidney cell cultures was incubated with guinea pig peritoneal PMNs in vitro at 35 degrees C. Structurally intact and degenerating rickettsiae were found in phagosomes, but only intact rickettsiae escaped phagosomes and specifically entered the glycogen-rich cytoplasm. The extraphagosomal cytoplasmic rickettsiae were found within 30 min after incubation; continued incubation for 4 h increased the rickettsial entry about fourfold as seen in ultrathin sections. Most rickettsiae in phagosomes were degenerating after 4 h of incubation. When incubated at 25 degrees C, no entry and very few phagocytized rickettsiae were observed. At 40 degrees C, rickettsial entry was greatly reduced, but more rickettsiae were found in phagosomes than at 35 degrees C. Preincubation of rickettsiae at 56 degrees C for 20 min with trypsin or with 2,4-dinitrophenol inhibited entry, but many rickettsiae were in phagosomes. Glutaraldehyde or formaldehyde fixation of rickettsiae and addition of 2-deoxyglucose, iodoacetamide, cytochalasin B, colchicine, or vinblastine inhibited all rickettsial uptake by PMNs. Acid phosphatase cytochemistry of infected PMNs revealed the enzyme activity only in phagosomes with degenerated rickettsiae and not in those with intact rickettsiae. These observations indicated that rickettsiae are passively phagocytized by PMNs, and only those that are intact actively escape from phagosomes, which selectively inhibits lysosomal fusion.

Characterization of altered BHK cells resistant to HVJ (Sendai virus) infection.

An altered baby hamster kidney cell culture which resists the c.p.e. of HVJ (haemagglutinating virus of Japan - the Sendai strain of parainfluenza I virus) has been obtained and characterized. These cells, designated BHK-R, were originally obtained by prolonged cultivation of cells surviving HVJ infection; they have been subcultured in the presence of HVJ. No infectious virus was recovered from BHK-R cells and no evidence for the presence of HVJ antigens in the cells was demonstrated by immunofluorescent staining. When BHK-R cells were inoculated with HVJ the growth of challenge virus was suppressed and no obvious cytopathic changes were detected, while these cells normally supported the replication of mumps, influenza, Newcastle disease, vesicular stomatitis or Sindbis viruses. BHK-R cells became susceptible to HVJ infection after serial subculture in growth medium free of HVJ. It was suggested that sialic acid residues present in the surface of BHK-R cell membranes and responsible for adsorption of HVJ were split off by the action of neuraminidase of virus particles, resulting in inhibition of the attachment of challenge virus of HVJ.

Variants of hamster fibroblasts resistant to Ricinus communis toxin (ricin)

1. Variant baby-hamster kidney (BHK) cell lines were isolated that grow in the presence of high concentrations of ricin, the toxic lectin of castor beans (Ricinus communis). The variant lines were independently derived from several cultures of normal BHK cells which had been exposed to the mutagen, methyl-N-nitro-N-nitrosoguanidine, before selection by ricin. 2. The cell lines maintain a high degree of resistance to ricin after growth in lectin-free medium for prolonged periods and therefore exhibit stable phenotypes that are different from normal BHK cells. 3. A preliminary classification of the phenotypes was made. Several cell lines bind normal amounts of 125I-labelled ricin, whereas other bind the lectin poorly. 4. A loss of surface receptors for two other lectins, R. communis RCA and Axinella polyploides, which have specificities similar to ricin, was also found in some but not all of the cell lines showing decreased surface concentrations of ricin receptors. 5. The binding to the ricin-resistant cells of lectins of different sugar specificity, namely Lens culinaris lectin and concanavalin A, was similar to, or higher than, to normal BHK cells. 6. Several of the ricin-resistant cell lines were shown to be cross-resistant to the weak cytotoxicity of Phaseolus vulgaris lectin. By contrast, some cell lines were more sensitive to concanavalin A than were normal BHK cells.

Trivittatus Virus Infections in Wild Mammals and Sentinel Rabbits in Central Iowa *

A serological survey was conducted in Iowa to determine the prevalence rate of California group virus antibodies in sera of several vertebrate species. Serum specimens were assayed for infectivity-neutralizing antibody in a microneutralization system with baby hamster kidney cell culture. Of 77 sera assayed, 21 (27%) neutralized trivittatus (TVT) virus infectivity. The antibody prevalence rate was highest for eastern cottontail rabbits inasmuch as 46% (10/22) of the serum specimens form this species possessed neutralizing activity. Other vertebrate species having TVT virus antibody included the fox squirrel, 29% (7/24), opossum, 12% (3/25), and raccoon, 17% (1/6). One cottontail rabbit serum neutralized both TVT virus and Jamestown Canyon (JC) virus infectivity, and one opossum serum specimen neutralized JC virus. None of the vertebrate sera neutralized La Crosse, St. Louis encephalitis, or western equine encephalomyelitis virus infectivity. Trivittatus virus neutralizing antibody was detected in the sera of sentinel rabbits, and TVT virus was isolated from the blood collected from one of these sentinels shortly after the first population peak of adult Aedes trivittatus mosquitoes in 1973. The implications of these data and the possibility of trans-ovarial transmission of TVT virus in A. trivittatus are discussed.

PRODUCTION AND PURIFICATION OF MILLIGRAM AMOUNTS OF FOOT-AND-MOUTH DISEASE VIRUS FROM BABY HAMSTER KIDNEY CELL CULTURES.

A stable line of baby hamster kidney cells for use in the production of, and subsequent purification of, foot-and-mouth disease virus (FMDV) was grown in large quantities on the cylindrical surfaces of 2-liter Baxter bottles. The bottles, in round wire cages, were rotated on a three-tiered roller mill. The cells retained their rapid growth characteristics and susceptibility to FMDV in a tris(hydroxymethyl)aminomethane buffer-containing medium which was especially formulated for large-scale work. This medium, without being changed, sustained cell growth for 6 to 7 days to yield confluent layers containing 500 to 750 million cells per bottle. In small-scale virus-growth experiments, harvested fluids contained about 10(3.8) to 10(8.8) plaque-forming units (PFU) per ml. This corresponded to a yield of 30 to 50 PFU per cell. In production runs with 190 cultures, the infectious fluids usually contained 10(7.9) to 10(9.2) PFU per ml, and the mass of essentially pure virus obtained therefrom ranged from 7 to 17 mg concomitant with cumulative infectivity recoveries of about 20%.

Production and Purification of Milligram Amounts of Foot-and-Mouth Disease Virus From Baby Hamster Kidney Cell Cultures

A stable line of baby hamster kidney cells for use in the production of, and subsequent purification of, foot-and-mouth disease virus (FMDV) was grown in large quantities on the cylindrical surfaces of 2-liter Baxter bottles. The bottles, in round wire cages, were rotated on a three-tiered roller mill. The cells retained their rapid growth characteristics and susceptibility to FMDV in a tris(hydroxymethyl)aminomethane buffer-containing medium which was especially formulated for large-scale work. This medium, without being changed, sustained cell growth for 6 to 7 days to yield confluent layers containing 500 to 750 million cells per bottle. In small-scale virus-growth experiments, harvested fluids contained about 10(3.8) to 10(8.8) plaque-forming units (PFU) per ml. This corresponded to a yield of 30 to 50 PFU per cell. In production runs with 190 cultures, the infectious fluids usually contained 10(7.9) to 10(9.2) PFU per ml, and the mass of essentially pure virus obtained therefrom ranged from 7 to 17 mg concomitant with cumulative infectivity recoveries of about 20%.