NADH Availability Research Articles

Effects of culture redox potential on succinic acid production by Corynebacterium crenatum under anaerobic conditions

During mixed-acid fermentation by Corynebacterium crenatum under anaerobic conditions, two moles of NADH are required to synthesize 1mol of succinic acid. In this work, four controlled culture redox potentials and different carbon sources with different oxidation states were used to investigate the possibility of enhancing the succinic acid production by increasing the availability of NADH. When the culture redox potential was −300mV, the yield of succinic acid was 0.31g/g, representing a 72% increase compared with the yield when the culture redox potential was −40mV. Meanwhile, the molar ratio of succinic acid/lactic acid increased from 0.27 to 0.48. When 0.1% neutral red was added to the acid production medium, the yield of succinic acid was 0.25g/g, and the molar ratio of succinic acid/lactic acid was 0.38. Both values were higher than those obtained from glucose only (0.19g/g, 0.26) or gluconate (0.05g/g, 0.18). A higher NADH/NAD+ ratio and increased enzymatic activity could be achieved to enhance the succinic acid production by manipulating the culture to a more reductive environment.

Fast volumetric imaging of ethanol metabolism in rat liver with hyperpolarized [1‐13C]pyruvate

Rapid volumetric imaging of hyperpolarized (13) C compounds allows the real-time measurement of metabolic activity and can be useful in distinguishing between normal and diseased tissues. This work extends a fast two-dimensional undersampled spiral MRSI sequence to provide volumetric coverage, acquiring a 16 × 16 × 12 matrix with a nominal isotropic resolution of 5 mm in 4.5 s. The rapid acquisition enables a high temporal resolution for dynamic imaging. This dynamic three-dimensional MRSI method was used to investigate hyperpolarized [1-(13) C]pyruvate metabolism modulated by the administration of ethanol in rat liver. A significant increase in the pyruvate to lactate conversion was observed in the liver as a result of the greater availability of NADH (nicotinamide adenine dinucleotide, reduced form) from ethanol metabolism.

The Effects of <i>adhE</i> Deletion on the Metabolism for D-Lactic Acid Production by the <i>Escherichia coli</i> JH11

Escherichia coli W produces a mixture of organic acids during fermentation in mineral salts medium using glucose as the sole carbon source. Among these products, D-lactate, acetate, succinate, and ethanol are the majors, with formate as a minor. In order to evaluate the effect of adhE mutation on the metabolism for D-lactic acid production by E. coli W, an adhE deletion mutant JH11 was constructed using the RED recombination system and the flipase recognition target （FRT） site-specific recombinant technology. Compared to the parent strain, JH11 produced significantly higher concentration of D-lactate due to the increased NADH availability, with slightly changed acetate (increased), and succinate (decreased), in fermentations using mineral salts medium containing glucose as the carbon source and calcium carbonate as the neutralizer.

Silencing of nicotinamide nucleotide transhydrogenase impairs cellular redox homeostasis and energy metabolism in PC12 cells

Mitochondrial NADPH generation is largely dependent on the inner-membrane nicotinamide nucleotide transhydrogenase (NNT), which catalyzes the reduction of NADP+ to NADPH utilizing the proton gradient as the driving force and NADH as the electron donor. Small interfering RNA (siRNA) silencing of NNT in PC12 cells results in decreased cellular NADPH levels, altered redox status of the cell in terms of decreased GSH/GSSG ratios and increased H2O2 levels, thus leading to an increased redox potential (a more oxidized redox state). NNT knockdown results in a decrease of oxidative phosphorylation while anaerobic glycolysis levels remain unchanged. Decreased oxidative phosphorylation was associated with a) inhibition of mitochondrial pyruvate dehydrogenase (PDH) and succinyl-CoA:3-oxoacid CoA transferase (SCOT) activity; b) reduction of NADH availability, c) decline of mitochondrial membrane potential, and d) decrease of ATP levels. Moreover, the alteration of redox status actually precedes the impairment of mitochondrial bioenergetics. A possible mechanism could be that the activation of the redox-sensitive c-Jun N-terminal kinase (JNK) and its translocation to the mitochondrion leads to the inhibition of PDH (upon phosphorylation) and induction of intrinsic apoptosis, resulting in decreased cell viability. This study supports the notion that oxidized cellular redox state and decline in cellular bioenergetics – as a consequence of NNT knockdown – cannot be viewed as independent events, but rather as an interdependent relationship coordinated by the mitochondrial energy-redox axis. Disruption of electron flux from fuel substrates to redox components due to NNT suppression induces not only mitochondrial dysfunction but also cellular disorders through redox-sensitive signaling.

Effect of alternative NAD+-regenerating pathways on the formation of primary and secondary aroma compounds in a Saccharomyces cerevisiae glycerol-defective mutant

Saccharomyces cerevisiae maintains a redox balance under fermentative growth conditions by re-oxidizing NADH formed during glycolysis through ethanol formation. Excess NADH stimulates the synthesis of mainly glycerol, but also of other compounds. Here, we investigated the production of primary and secondary metabolites in S. cerevisiae strains where the glycerol production pathway was inactivated through deletion of the two glycerol-3-phosphate dehydrogenases genes (GPD1/GPD2) and replaced with alternative NAD(+)-generating pathways. While these modifications decreased fermentative ability compared to the wild-type strain, all improved growth and/or fermentative ability of the gpd1Δgpd2Δ strain in self-generated anaerobic high sugar medium. The partial NAD(+) regeneration ability of the mutants resulted in significant amounts of alternative products, but at lower yields than glycerol. Compared to the wild-type strain, pyruvate production increased in most genetically manipulated strains, whereas acetate and succinate production decreased in all strains. Malate production was similar in all strains. Isobutanol production increased substantially in all genetically manipulated strains compared to the wild-type strain, whereas only mutant strains expressing the sorbitol producing SOR1 and srlD genes showed increases in isoamyl alcohol and 2-phenyl alcohol. A marked reduction in ethyl acetate concentration was observed in the genetically manipulated strains, while isobutyric acid increased. The synthesis of some primary and secondary metabolites appears more readily influenced by the NAD(+)/NADH availability. The data provide an initial assessment of the impact of redox balance on the production of primary and secondary metabolites which play an essential role in the flavour and aroma character of beverages.

Enhanced production of succinic acid by Actinobacillus succinogenes with reductive carbon source

Abstract Carbon sources with different oxidation states were used to investigate the possibility increasing the availability of NADH and the NADH/NAD + ratio and to determine the effect of this manipulation on the distribution of metabolites in Actinobacillus succinogenes NJ113. The sugars glucose, sorbitol and gluconate were each used at an initial concentration of 40 g/L. The yield of succinic acid (0.75) and the ratio of succinic acid to acetic acid (5.06) were both higher for sorbitol than the values obtained with glucose (0.66 and 2.68, respectively). In contrast, with gluconate as the carbon source the yield of succinic acid was 0.54 and the ratio of succinic acid to acetic acid was only 1.70. This work showed that different levels of NADH availability and the NADH/NAD + ratio can be achieved by using carbon sources that have different oxidation states. Highly reduced sorbitol was examined as a possible carbon substrate for maximizing the redox potential during the production of succinic acid.

Metabolic engineering of acetoin and meso‐2, 3‐butanediol biosynthesis in E. coli

The functional reconstruction of acetoin and meso-2,3-butanediol (meso-2,3-BD) biosynthetic pathways in Escherichia coli have been explored systematically. Pathway construction involved the in vsivo screening of prospective pathway isozymes of yeast and bacterial origin. After substantial engineering of the host background to increase pyruvate availability, E. coli YYC202(DE3) ldhA(() ilvC( expressing ilvBN from E. coli and aldB from L. lactis (encoding acetolactate synthase and acetolactate decarboxylase activities, respectively) was able to produce up to 870 mg/L acetoin, with no coproduction of diacetyl observed. These strains were also found to produce small quantities of meso-2,3-BD, suggesting the existence of endogenous 2,3-BD dehydrogenase activity. Finally, the coexpression of bdh1 from S. cerevisiae, encoding 2,3-BD dehydrogenase, in this strain resulted in the production of up to 1120 mg/L meso-2,3-BD, with glucose a yield of 0.29 g/g. While disruption of the native lactate biosynthesis pathway increased pyruvate precursor availability to this strain, increased availability of NADH for acetoin reduction to meso-2,3-BD was found to be the most important consequence of ldhA deletion.

Availability of neurotransmitter glutamate is diminished when β‐hydroxybutyrate replaces glucose in cultured neurons

Ketone bodies serve as alternative energy substrates for the brain in cases of low glucose availability such as during starvation or in patients treated with a ketogenic diet. The ketone bodies are metabolized via a distinct pathway confined to the mitochondria. We have compared metabolism of [2,4-(13)C]beta-hydroxybutyrate to that of [1,6-(13)C]glucose in cultured glutamatergic neurons and investigated the effect of neuronal activity focusing on the aspartate-glutamate homeostasis, an essential component of the excitatory activity in the brain. The amount of (13)C incorporation and cellular content was lower for glutamate and higher for aspartate in the presence of [2,4-(13)C]beta-hydroxybutyrate as opposed to [1,6-(13)C]glucose. Our results suggest that the change in aspartate-glutamate homeostasis is due to a decreased availability of NADH for cytosolic malate dehydrogenase and thus reduced malate-aspartate shuttle activity in neurons using beta-hydroxybutyrate. In the presence of glucose, the glutamate content decreased significantly upon activation of neurotransmitter release, whereas in the presence of only beta-hydroxybutyrate, no decrease in the glutamate content was observed. Thus, the fraction of the glutamate pool available for transmitter release was diminished when metabolizing beta-hydroxybutyrate, which is in line with the hypothesis of formation of transmitter glutamate via an obligatory involvement of the malate-aspartate shuttle.

Effect of Transient and Permanent Permeability Transition Pore Opening on NAD(P)H Localization in Intact Cells

To study the effect of mitochondrial permeability transition pore (PTP) opening on NAD(P)H localization, intact cells were exposed to the Ca(2+) ionophore A23187. PTP opening, mitochondrial membrane potential, mitochondrial volume, and NAD(P)H localization were assessed by time-lapse laser confocal microscopy using the calcein-cobalt technique, tetramethylrhodamine methyl ester, MitoTracker, and NAD(P)H autofluorescence, respectively. Concomitant with PTP opening, NAD(P)H fluorescence increased outside mitochondria. These events occurred in all cells and were prevented by cyclosporin A. Mitochondrial membrane potential was not systematically collapsed, whereas mitochondrial volume did not change, confirming that A23187 induced transient PTP opening in a subpopulation of cells and suggesting that mitochondrial swelling did not immediately occur after PTP opening in intact cells. NAD(P)H autofluorescence remained elevated after PTP opening, particularly after membrane potential had been collapsed by an uncoupler. Extraction of nucleotide for NAD(P)H quantification confirmed that PTP opening led to an increase in NAD(P)H content. Because the oxygen consumption rate decreased, whereas the lactate/pyruvate ratio increased after PTP opening in intact cells, we conclude that PTP opening inhibits respiration and dramatically affects the cytosolic redox potential in intact cells.

Engineering of 2,3-Butanediol Dehydrogenase To Reduce Acetoin Formation by Glycerol-Overproducing, Low-AlcoholSaccharomyces cerevisiae

Engineered Saccharomyces cerevisiae strains overexpressing GPD1, which codes for glycerol-3-phosphate dehydrogenase, and lacking the acetaldehyde dehydrogenase Ald6 display large-scale diversion of the carbon flux from ethanol toward glycerol without accumulating acetate. Although GPD1 ald6 strains have great potential for reducing the ethanol contents in wines, one major side effect is the accumulation of acetoin, having a negative sensory impact on wine. Acetoin is reduced to 2,3-butanediol by the NADH-dependent 2,3-butanediol dehydrogenase Bdh1. In order to investigate the influence of potential factors limiting this reaction, we overexpressed BDH1, coding for native NADH-dependent Bdh1, and the engineered gene BDH1(221,222,223), coding for an NADPH-dependent Bdh1 enzyme with the amino acid changes 221 EIA 223 to 221 SRS 223, in a glycerol-overproducing wine yeast. We have shown that both the amount of Bdh1 and the NADH availability limit the 2,3-butanediol dehydrogenase reaction. During wine fermentation, however, the major limiting factor was the level of synthesis of Bdh1. Consistent with this finding, the overproduction of native or engineered Bdh1 made it possible to redirect 85 to 90% of the accumulated acetoin into 2,3-butanediol, a compound with neutral sensory characteristics. In addition, the production of diacetyl, a compound causing off-flavor in alcoholic beverages, whose production is increased in glycerol-overproducing yeast cells, was decreased by half. The production of higher alcohols and esters, which was slightly decreased or unchanged in GPD1 ald6 cells compared to that in the control cells, was not further modified in BDH1 cells. Overall, rerouting carbons toward glycerol and 2,3-butanediol represents a new milestone in the engineering of a low-alcohol yeast with desirable organoleptic features, permitting the decrease of the ethanol contents in wines by up to 3 degrees.

Introduction of an NADH regeneration system into Klebsiella oxytoca leads to an enhanced oxidative and reductive metabolism of glycerol

Redox cofactors play crucial roles in the metabolic and regulatory network of living organisms. We reported here the effect of introducing a heterogeneous NADH regeneration system into Klebsiella oxytoca on cell growth and glycerol metabolism. Expression of fdh gene from Candida boidinii in K. oxytoca resulted in higher intracellular concentrations of both NADH and NAD + during the fermentation metaphase, with the ratio of NADH to NAD + unaltered and cell growth unaffected, interestingly different from that in engineered Escherichia coli, Lactococcus lactis, and others. Metabolic flux analysis revealed that fluxes to 1,3-propanediol, ethanol, and lactate were all increased, suggesting both the oxidative and reductive metabolisms of glycerol were enhanced. It demonstrates that in certain microbial system NADH availability can be increased with NADH to NAD + ratio unaltered, providing a new strategy to improve the metabolic flux in those microorganisms where glycolysis is not the only central metabolic pathways.

Medium- and short-chain dehydrogenase/reductase gene and protein families : Dual functions of alcohol dehydrogenase 3: implications with focus on formaldehyde dehydrogenase and S-nitrosoglutathione reductase activities.

Alcohol dehydrogenase 3 (ADH3) is highly conserved, ubiquitously expressed in mammals and involved in essential cellular pathways. A large active site pocket entails special substrate specificities: shortchain alcohols are poor substrates, while medium-chain alcohols and particularly the glutathione adducts S-hydroxymethylglutathione (HMGSH) and S-nitrosoglutathione (GSNO) are efficiently converted under concomitant use of NAD(+)/NADH. By oxidation of HMGSH, the spontaneous glutathione adduct of formaldehyde, ADH3 is implicated in the detoxification of formaldehyde. Through the GSNO reductase activity, ADH3 can affect the transnitrosation equilibrium between GSNO and S-nitrosated proteins, arguing for an important role in NO homeostasis. Recent findings suggest that ADH3-mediated GSNO reduction and subsequent product formation responds to redox states in terms of NADH availability and glutathione levels. Finally, a dual function of ADH3 is discussed in view of its potential implications for asthma.

A Cytosolic Pathway for the Conversion of Hydroxypyruvate to Glycerate during Photorespiration in Arabidopsis

Deletion of any of the core enzymes of the photorespiratory cycle, one of the major pathways of plant primary metabolism, results in severe air-sensitivity of the respective mutants. The peroxisomal enzyme hydroxypyruvate reductase (HPR1) represents the only exception to this rule. This indicates the presence of extraperoxisomal reactions of photorespiratory hydroxypyruvate metabolism. We have identified a second hydroxypyruvate reductase, HPR2, and present genetic and biochemical evidence that the enzyme provides a cytosolic bypass to the photorespiratory core cycle in Arabidopsis thaliana. Deletion of HPR2 results in elevated levels of hydroxypyruvate and other metabolites in leaves. Photosynthetic gas exchange is slightly altered, especially under long-day conditions. Otherwise, the mutant closely resembles wild-type plants. The combined deletion of both HPR1 and HPR2, however, results in distinct air-sensitivity and a dramatic reduction in photosynthetic performance. These results suggest that photorespiratory metabolism is not confined to chloroplasts, peroxisomes, and mitochondria but also extends to the cytosol. The extent to which cytosolic reactions contribute to the operation of the photorespiratory cycle in varying natural environments is not yet known, but it might be dynamically regulated by the availability of NADH in the context of peroxisomal redox homeostasis.

NADH Availability Limits Asymmetric Biocatalytic Epoxidation in a Growing Recombinant Escherichia coli Strain

Styrene can efficiently be oxidized to (S)-styrene oxide by recombinant Escherichia coli expressing the styrene monooxygenase genes styAB from Pseudomonas sp. strain VLB120. Targeting microbial physiology during whole-cell redox biocatalysis, we investigated the interdependency of styrene epoxidation, growth, and carbon metabolism on the basis of mass balances obtained from continuous two-liquid-phase cultures. Full induction of styAB expression led to growth inhibition, which could be attenuated by reducing expression levels. Operation at subtoxic substrate and product concentrations and variation of the epoxidation rate via the styrene feed concentration allowed a detailed analysis of carbon metabolism and bioconversion kinetics. Fine-tuned styAB expression and increasing specific epoxidation rates resulted in decreasing biomass yields, increasing specific rates for glucose uptake and the tricarboxylic acid (TCA) cycle, and finally saturation of the TCA cycle and acetate formation. Interestingly, the biocatalysis-related NAD(P)H consumption was 3.2 to 3.7 times higher than expected from the epoxidation stoichiometry. Possible reasons include uncoupling of styrene epoxidation and NADH oxidation and increased maintenance requirements during redox biocatalysis. At epoxidation rates of above 21 micromol per min per g cells (dry weight), the absence of limitations by O(2) and styrene and stagnating NAD(P)H regeneration rates indicated that NADH availability limited styrene epoxidation. During glucose-limited growth, oxygenase catalysis might induce regulatory stress responses, which attenuate excessive glucose catabolism and thus limit NADH regeneration. Optimizing metabolic and/or regulatory networks for efficient redox biocatalysis instead of growth (yield) is likely to be the key for maintaining high oxygenase activities in recombinant E. coli.

P450cam biocatalysis in surfactant‐stabilized two‐phase emulsions

Cytochrome P450 monooxygenases (P450s) are powerful biocatalysts that have the ability to oxidize a broad range of substrates, often at non-reactive carbon centers. However, incorporation of P450s into synthetic schemes has so far been limited to a few whole-cell transformations. P450 substrates are often hydrophobic and have low water solubility, limiting the amount of product that can be produced. To help overcome this limitation, we have examined P450cam activity in two-phase hexane/water emulsions with and without the anionic surfactant, bis(2-ethylhexyl) sulfosuccinate sodium salt (AOT). Hydroxylation of camphor to hydroxycamphor by the three- component P450cam system was chosen as the model reaction, and regeneration of NADH was accomplished with yeast alcohol dehydrogenase (YADH). P450cam was activated in the surfactant-free emulsions, and addition of AOT improved the activity even further, at least over the range of camphor concentrations for which initial rates were readily measurable in all media. The largest observed rate enhancement was 4.5-fold. Nearly 50-times more product was formed in the surfactant-stabilized emulsions than was achieved in aqueous buffer, with total turnover numbers reaching 28,900 for P450cam and 11,800 for YADH. In the absence of surfactant, the two-phase reaction appeared to be mass-transfer limited, while inclusion of AOT alleviated transport limitations and/or afforded a larger interfacial area for P450 activation. The oxidation of hydroxycamphor to 2,5-diketocamphane was also observed, owing to the large concentration of hydroxycamphor relative to camphor in the aqueous phase of the two-phase emulsion. This competing reaction was accompanied by the uncoupled oxidation of NADH (i.e., NADH oxidation without formation of 2,5-diketocamphane), which reduced the availability of NADH for camphor oxidation and further limited the yield of hydroxycamphor in the two-phase emulsions. These results indicate that a surfactant-stabilized two-phase emulsion is a promising reaction medium for practical P450 biocatalysis, although its effectiveness for a given P450/substrate combination can depend on several factors, including competitive or sequential reactions, product inhibition, and NAD(P)H uncoupling.

Influence of heme metabolism and redox regulation of sGC in the control of vascular function

The redox status of cytosolic NAD(P)H and the biosynthesis and metabolism of heme are potentially key factors regulating soluble guanylate cyclase (sGC) and the role of cGMP in vascular relaxation. The availability of both cytosolic NADH and NADPH control the generation of NAD(P)H oxidase (Nox)-derived reactive oxygen species (ROS) and their influence on sGC. Cytosolic NADPH redox appears to preserve nitric oxide-stimulation of sGC and relaxation by preventing an inhibitory effect of oxidized glutathione and by maintaining the sGC heme in its ferrous form. Studies on isolated bovine pulmonary arteries (BPA) after a 24 hour organ culture have revealed that the heme precursor aminolevulinic acid promotes the accumulation of protoporphyrin IX in amounts that stimulate sGC and cGMP-mediated relaxation, in a manner modulated by the availability of iron. Cobalt-inducers of heme oxygenase-1 (HO-1) cause a HO-1 dependent depletion of heme which can be associated with a loss of heme-dependent stimulation of sGC, and an up regulation of SOD activity which potentially alters the influence of ROS on sGC and vascular relaxation. from 3rd International Conference on cGMP Generators, Effectors and Therapeutic Implications Dresden, Germany. 15–17 June 2007

Carbon metabolism and product inhibition determine the epoxidation efficiency of solvent-tolerantPseudomonas sp. strain VLB120ΔC

Utilization of solvent tolerant bacteria as biocatalysts has been suggested to enable or improve bioprocesses for the production of toxic compounds. Here, we studied the relevance of solvent (product) tolerance and inhibition, carbon metabolism, and the stability of biocatalytic activity in such a bioprocess. Styrene degrading Pseudomonas sp. strain VLB120 is shown to be solvent tolerant and was engineered to produce enantiopure (S)-styrene oxide from styrene. Whereas glucose as sole source for carbon and energy allowed efficient styrene epoxidation at rates up to 97 micromol/min/(g cell dry weight), citrate was found to repress epoxidation by the engineered Pseudomonas sp. strain VLB120DeltaC emphasizing that carbon source selection and control is critical. In comparison to recombinant Escherichia coli, the VLB120DeltaC-strain tolerated higher toxic product levels but showed less stable activities during fed-batch cultivation in a two-liquid phase system. Epoxidation activities of the VLB120DeltaC-strain decreased at product concentrations above 130 mM in the organic phase. During continuous two-liquid phase cultivations at organic-phase product concentrations of up to 85 mM, the VLB120DeltaC-strain showed stable activities and, as compared to recombinant E. coli, a more efficient glucose metabolism resulting in a 22% higher volumetric productivity. Kinetic analyses indicated that activities were limited by the styrene concentration and not by other factors such as NADH availability or catabolite repression. In conclusion, the stability of activity of the solvent tolerant VLB120DeltaC-strain can be considered critical at elevated toxic product levels, whereas the efficient carbon and energy metabolism of this Pseudomonas strain augurs well for productive continuous processing.

A fundamental regulatory role of formate on thuringiensin production by resting cell of Bacillus thuringiensis YBT-032

In this work, a fundamental regulatory role of formate on thuringiensin production by resting cell of Bacillus thuringiensis YBT-032 was investigated. Nicotinamide adenine dinucleotide (NADH) production and formate dehydrogenase activity increased with formate addition from 0.5 to 2.0 g/L, respectively. However, with the formate addition of 1.5 g/L, the activities of pyruvate kinase and glucose 6-phosphate dehydrogenase reached a peak and increased by 316 and 150% relative to those of the control, respectively. In addition, intracellular production of pyruvate, aspartate, citrate and adenine were significantly enhanced by 75, 66, 32 and 78% as well. An improvement (90%) of thuringiensin production was also successfully obtained. Interestingly to point out, thuringiensin yield was closely correlative with adenine production, and the linear relationship was also observed. The results suggest that appropriate formate addition did act as a modulator and facilitate carbon flux in glycolysis and pentose phosphate pathway to synthesize adenine and thuringiensin via intracellular NADH availability.

Development of a bienzyme system for the electrochemical determination of nitrate in ambient air

This work reports the development of a bienzyme system consisting of salicylate hydroxylase (SHL) and nitrate reductase (NaR) for the electrochemical determination of nitrate. This method measures the concentration of nitrate directly under ambient air without suffering from oxygen interferences. The determination is based on the detection of NADH consumption, and the principle is as follows: NADH initiates the irreversible decarboxylation and hydroxylation of salicylate by SHL in the presence of oxygen to produce catechol, which results in a detectable signal due to its oxidation at the working electrode; the second enzyme, NaR, in the presence of nitrate, reduced the availability of NADH, and consequently, the current difference after the injection of nitrate is proportional to its concentration. This method shows high performance characteristics for nitrate determination with a broad detection range between 10 microM and 1,000 microM, a short measuring time of around 5 min, and a simple operation without sample pretreatment by inert gas purge or oxygen scavenger.

Inactivation of aldehyde dehydrogenase: A key factor for engineering 1,3-propanediol production by Klebsiella pneumoniae

Production of 1,3-propanediol (1,3-PD) from glycerol by Klebsiella pneumoniae is restrained by ethanol formation. The first step in the formation of ethanol from acetyl-CoA is catalyzed by aldehyde dehydrogenase (ALDH), an enzyme that competes with 1,3-PD oxidoreductase for the cofactor NADH. This study aimed to improve the production of 1,3-PD by engineering the ethanol formation pathway. An inactivation mutation of the aldA gene encoding ALDH in K. pneumoniae YMU2 was generated by insertion of a tetracycline resistance marker. Inactivation of ALDH resulted in a nearly abolished ethanol formation but a significantly improved 1,3-PD production. Metabolic flux analysis revealed that a pronounced redistribution of intracellular metabolic flux occurred. The final titer, the productivity of 1,3-PD and the yield of 1,3-PD relative to glycerol of the mutant strain reached 927.6 mmol L −1, 14.05 mmol L −1 h −1 and 0.699 mol mol −1, respectively, which were much higher than those of the parent strain. In addition, the specific 1,3-PD-producing capability (1,3-PD produced per gram of cells) of the mutant strain was 2-fold that of the parent strain due to a lower growth yield of the mutant. By increasing NADH availability, this study demonstrates an important metabolic engineering approach to improve the efficiency of oxidoreduction-coupled bioprocesses.