Anaerobic Digestion Of Waste Activated Sludge Research Articles

Syntrophic Jiont of Sulfate-Reducing Bacteria and Hydrogen-Producing Acetogen Stimulated Methane Production from Waste Activated Sludge Digestion

Anaerobic digestion of waste-activated sludge (WAS) towards biogas recovery is constrained by the limited hydrolysis and inhibited acetogenesis steps that hinder subsequent energy recovery. This study employed Fe(VI)/S(IV) oxidation to enhance the WAS solubilization and coupled it with the syntrophic interaction of hydrogen-producing acetogen (HPA) and sulfate-reducing bacteria (SRB) to stimulate the successive procedure towards methane production. Results showed that the dosage ratio of HPA-SRB to WAS (H-S-W) with 1:1:50 outperformed with the highest methane production potential (11.63 ± 1.87 mL CH4/(g VSS·d). Meanwhile, the efficient and sequential process from acetogenesis to methanogenesis stimulated by HPA-SRB was evidenced by a significant decrease of 30.2% in the acetate concentration. The microbial community structure further manifested the crucial role of HPA-SRB with increased abundance of Desulfobulbus (2.07%), Syntrophomonas (1.24%) and Smithella (1.63%), which stimulated acetophilic methanogen boost with Methanobacterium dominating with 77.51% in H-S-W100. Furthermore, the positive syntrophic relationships among HPA-SRB and acetophilic methanogens towards methane production were confirmed via molecular ecological network and canonical correspondence analysis. This study highlighted the syntrophic cooperation of the mixed consortia of HPA and SRB on methane production based on Fe(VI)/S(IV) pretreatment and provided the theoretical and technical basis for the potential implementation of novel methanogenesis technology for WAS treatment.

Comparing the effects of Al-based coagulants in waste activated sludge anaerobic digestion: Methane yield, kinetics and sludge implications

Due to its effectiveness and ease of application, the process of flocculation and coagulation is often used for pollution removal in wastewater treatment. Most of these coagulants precipitate and accumulate in waste activated sludge (WAS), and could negatively affect sludge treatments, as observed for anaerobic digestion. Nowadays, wastewater treatment plants (WWTPs) are widely discussed because of the current paradigm shift from linear to circular economy, and the treatments performed at the facility should be planned to avoid or reduce adverse effects on other processes. The aim of this study was to compare the impact of poly aluminum chloride (PAC) and aluminum sulfate (AS) on WAS anaerobic digestion, by feeding replicate serum reactors with different levels of coagulant (5, 10 and 20 mg Al/g TS). Reactors without the addition of any coagulants represented the control group. Results revealed that Al-based coagulants inhibited methane production, which decreased as the coagulant addition increased. The inhibition was much more severe in AS-conditioned reactors, showing average reductions in methane yield from 14.4 to 31.7%, compared to the control (167.76 ± 1.88 mL CH4/g VS). Analytical analysis, FTIR and SEM investigations revealed that the addition of coagulants affected the initial conditions of the anaerobic reactors, penalizing the solubilization, hydrolysis and acidogenesis phases. Furthermore, the massive formation of H2S in AS-conditioned reactors played a key role in the suppression of methane phase. On the other hand, the use of coagulant can promote the accumulation and recovery of nutrient in WAS, especially in terms of phosphorus. Our findings will expand research knowledge in this field and guide stakeholders in the choice of coagulants at full scale plant. Future research should focus on reducing the effect of coagulants on methane production by modifying or testing new types of flocculants.

Insight into using hydrochar to alleviate ammonia nitrogen inhibition during anaerobic digestion of waste activated sludge: Performance, metagenomic and metabolomic signatures

In this study, hydrochar (HCR) was used to alleviate high ammonia inhibition to the anaerobic digestion (AD) of waste activated sludge (WAS) and to elucidate the inner microorganism mechanism. After HCR addition, the cumulative methane yield increased by 73.6 % and 35.6 % under ammonia inhibition levels of 3000 and 6000 mg/L, respectively. Metagenomic analysis showed that HCR enriched the diversity of hydrogenotrophic methanotrophs, and the relative abundances of functional microorganisms with electron transfer capabilities (Geobacteraceae bacterium etc.) were 1.5–7.8 times higher than those without HCR addition. Metabolomics analysis implied that metabolites related to fatty acid degradation, such as glutaric acid and hexadecanal, were downregulated (2.9–15.7 %) under ammonia inhibition conditions and that HCR regulates metabolites in the methane metabolic pathway. Moreover, HCR changed the methanogenic pathway from hydrogenotrophic methanogenesis to multiple pathways under ammonia inhibition conditions, especially methanolic and methylotrophic methanogenesis, which facilitated the methane yield. This study provides valuable information for understanding the inner microbial mechanism of HCR addition on alleviating high ammonia inhibition to AD of WAS, and gives basic knowledge for the application of AD of WAS under ammonia inhibition conditions.

Enhanced biomethane production from waste activated sludge anaerobic digestion by ceramsite and amended Fe2O3 ceramsite

Wastes recycling and reutilization technique could simultaneously fulfill waste control and energy recovery sustainably, which has attracted increasing attention. This work proposed a novel waste reuse technology utilizing ceramsite and amended Fe2O3-ceramsite made from waste activated sludge (WAS) as additives to promote the yield of methane from WAS anaerobic digestion (AD). Experimental results demonstrated that compared to the control (85.05 ± 0.2 mL CH4/g-VS), the cumulative methane yield was effectively enhanced by 14% and 40% when ceramsite and Fe2O3-ceramsite were added. Further investigation revealed that ceramsite, especially the Fe2O3-ceramsite, enriched the populations of key anaerobes involved in hydrolysis, acidification, and methanogenesis. Meanwhile, potential syntrophic metabolisms between syntrophic bacteria and methanogens were confirmed in the Fe2O3-ceramsite AD system. Mechanisms studies exhibited that ceramsite and Fe2O3-ceramsite reinforced intermediate processes for methane production. The favorable pore structure, enhanced Fe (III) reduction capacity and conductivity also contributed a lot to the AD process.

Revealing the roles of biochar derived from iron-rich fermented sludge residue in anaerobic digestion

Anaerobic biological treatment of waste activated sludge (WAS) is proven as a low-carbon footprint technology with dual advantages of bio-fuel recovery and sludge stabilization. However, sludge residue after anaerobic biological treatment has been a serious obstacle to build waste-free cities. In this study, sludge residue, iron-rich sludge residue, and iron-rich fermented sludge residue were selected as the raw materials of biochar and the roles of prepared biochar in anaerobic digestion of WAS were investigated. Results indicated that the prepared biochar improved methane production and biochar derived from iron-rich fermented sludge residue (PFF-BC) obtained the best performance, with an increment of 23.4%. Mechanism analysis illustrated that the structural characteristics of PFF-BC were updated, including iron species, defect levels, and specific surface area, which played positive roles in the conversion of intermediate metabolites. Meanwhile, the compositions and electro-activity properties of extracellular polymeric substances were both stimulated by PFF-BC. Correspondingly, the activities of electron transport system and cytochrome c increased by 23.4% and 36.7%, respectively. For microbial communities, the abundances of electroactive microorganisms (such as Anaerolineaceae, Syntrophomonas and Methanosaeta) increased and direct interspecies electron transfer might be established, improving CO2-reduction and acetoclastic methanogenesis pathways. These findings will provide important references for stepwise resource recovery and final disposal of WAS.

Different responses of mesophilic and thermophilic anaerobic digestion of waste activated sludge to PVC microplastics.

The effect of microplastics (MPs) retained in waste activated sludge (WAS) on anaerobic digestion (AD) performance has attracted more and more attention. However, their effect on thermophilic AD remains unclear. Here, the influence of polyvinyl chloride (PVC) MPs on methanogenesis and active microbial communities in mesophilic (37 °C) and thermophilic (55 °C) AD was investigated. The results showed that 1, 5, and 10 mg/L PVC MPs significantly promoted the cumulative methane yield in mesophilic AD by 5.62%, 7.36%, and 8.87%, respectively, while PVC MPs reduced that in thermophilic AD by 13.30%, 18.82%, and 19.99%, respectively. Moreover, propionate accumulation was only detected at the end of thermophilic AD with PVC MPs. Microbial community analysis indicated that PVC MPs in mesophilic AD enriched hydrolytic and acidifying bacteria (Candidatus Competibacter, Lentimicrobium, Romboutsia, etc.) together with acetoclastic methanogens (Methanosarcina, Methanosaeta). By contrast, most carbohydrate-hydrolyzing bacteria, propionate-oxidizing bacterium (Pelotomaculum), and Methanosarcina were inhibited by PVC MPs in thermophilic AD. Network analysis further suggested that PVC MPs significantly changed the relationship of key microorganisms in the AD process. A stronger correlation among the above genera occurred in mesophilic AD, which may promote the methanogenic performance. These results suggested that PVC MPs affected mesophilic and thermophilic AD of WAS via changing microbial activities and interaction.

Enhancing anaerobic digestion of waste activated sludge by dielectric barrier discharge pretreatment: Nutrient release, sludge hydrolysis and microbial community succession

A dielectric barrier discharge (DBD) pretreatment of waste activated sludge (WAS) was developed for boosting the releasing of organic matter from floc structures and microbial cells. The changes of protein and polysaccharide in different extracellular polymeric substances layers of SCOD releasing from sludge were determined by using three-dimensional fluorescence spectra. Significantly improved cumulative methane production was achieved via enhancing anaerobic digestion, which was 83.5% higher than that of the control. The formed ∙OH radicals play a key role in sludge hydrolysis, thus improving the biodegradability of WAS. Furthermore, high-throughput sequencing analysis showed that DBD pretreatment improved the relative abundances of the main functional microbes with respect to sludge hydrolysis and anaerobic digestion. Therefore, this study verifies the feasibility of DBD pretreatment in sludge hydrolysis and is expected to provide a practical new technology for anaerobic digestion of WAS.

Deciphering the role of polystyrene microplastics in waste activated sludge anaerobic digestion: Changes of organics transformation, microbial community and metabolic pathway

Microplastics are ubiquitous in the natural environment, which inevitably affect the relevant biochemical process. Nevertheless, the knowledge about the impacts of microplastics on organics transformation and corresponding microbial metabolism response in anaerobic environment is limited. Here, polystyrene (PS) microplastics were selected as model microplastics to explore their potential impacts on organics transformation, microbial community and metabolic pathway during sludge anaerobic digestion system operation. The results indicated that the PS microplastics exhibited the dose-dependent effects on methane production, i.e., the additive of 20–40 particles/g TS of PS microplastics improved the maximum methane yield by 3.38 %–8.22 %, whereas 80–160 particles/g TS additive led to a 4.78 %–11.04 % declining. Overall, PS microplastics facilitated the solubilization and hydrolysis of sludge, but inhibited the acidogenesis process. Key functional enzyme activities were stimulated under low PS microplastics exposure, whereas were almost severely inhibited due to the increased oxidative stress induced from excess PS microplastics. Microbial community and further metabolic analysis indicated that low PS microplastics improved the acetotrophic and hydrogenotrophic methanogenesis, while a high level of PS microplastics shifted methanogenesis from acetotrophic to hydrogenotrophic pathway. Further analysis showed that the reacted PS microplastics exhibited greater toxicity and ecological than the raw PS microplastics due to that they are more likely to adsorb contaminants. These findings revealed the dosage-dependent relationships between microplastics and organics transformation process in anaerobic environments, providing new insights for assessing the impact of PS microplastics on sludge anaerobic digestion.

Anionic polyacrylamide alleviates cadmium inhibition on anaerobic digestion of waste activated sludge

The uncontrolled discharge of industrial wastewater leads to a significant cadmium (Cd) accumulation in waste activated sludge (WAS), posing a serious threat to the steady operation of the anaerobic digestion (AD) system in wastewater treatment plants (WWTPs). Therefore, developing a viable approach to cope with the adverse effects of high-concentration Cd on the AD system is urgently required. This study aims to investigate the potential of using anionic polyacrylamide (APAM), a commonly used agent in WWTPs, to mitigate the adverse effects of Cd in a toxic amount (i.e., 5.0 mg per g total suspended solids (TSS)) on AD of WAS. The results showed that the effectiveness of higher APAM on Cd toxicity alleviation was less than that of lower APAM at the studied level (i.e., the effectiveness order was 1.5 mg APAM per g TSS > 3.0 mg APAM per g TSS > 6.0 mg APAM per g TSS). The moderate supplement of APAM (i.e., 1.5 mg per g TSS) recovered the accumulative methane yield from 190.5 ± 3.6 to 228.9 ± 4.1 mL per g volatile solids by promoting solubilization, hydrolysis, and acidification processes related to methane production. The application of APAM also increased the abundance of key microbes in the AD system, especially Methanolinea among methanogens and Caldilineaceae among hydrolyzers. Furthermore, APAM facilitated the key enzyme activities involved in AD processes and reduced reactive oxygen species (induced by Cd) production via adsorption/enmeshment of Cd by APAM. These findings demonstrate the feasibility of using moderate APAM to mitigate Cd toxicity during AD, providing a promising solution for controlling Cd or other heavy metal toxicity in WWTPs.

Enhanced methane yield in anaerobic digestion of waste activated sludge by combined pretreatment with fungal mash and free nitrous acid

This study explores a novel approach for enhancing anaerobic digestion of waste activated sludge (WAS) through the combined pretreatment of fungal mash and free nitrous acid (FNA). Aspergillus PAD-2, a fungal strain with superior hydrolase secretion, was isolated from WAS and cultivated in-situ on food waste to produce fungal mash. The solubilization of WAS by fungal mash achieved a high soluble chemical oxygen demand release rate of 548 mg L−1 h−1 within first 3 h. The combined pretreatment of fungal mash and FNA further improved the sludge solubilization by 2-fold and resulted in a doubled methane production rate of 416±11 mL CH4 g−1 volatile solids. The Gompertz model analysis revealed a higher maximum specific methane production rate and shortened lag time by the combined pretreatment. These results demonstrate that the combined fungal mash and FNA pretreatment offers a promising alternative for fast anaerobic digestion of WAS.

Evaluation of bioenergy production and material flow in treating Japanese concentrated Johkasou sludge using high-solid anaerobic membrane bioreactor based on one-year operation

The treatment of waste sludge generated from on-site wastewater treatment facilities (Johkasou) applied extensively in Japan is a key concern. In this study, a high-solid anaerobic membrane bioreactor (AnMBR) was continuously operated throughout a year to investigate the bioenergy production, material flow and seasonal impacts of concentrated Johkasou sludge (CJoS). The CJoS has higher carbon-to-nitrogen ratio and lipid fraction, but less proteins than waste activated sludge (WAS). The biogas yield of CJoS by AnMBR ranged from 0.47 to 0.52 L/g-VSfed, which was higher than the anaerobic digestion of WAS and lower than mixed sewage sludge from centralized wastewater treatment facilities. The greatest biogas production rate was observed during summer (0.63 L/L/d), owing to the high total organic and solid content. However, winter CJoS had the highest biogas yield and carbon conversion rate owing to the conservation of soluble organic matter in low temperature and high digestibility. The material flow results revealed that 46.5–52.4% total COD and 50.2–58.0% carbon was converted to biogas. The energy recovery rates ranged from 8.69 to 9.96 kJ/g-VSfed and the system energy self-sufficiency rates ranged from 1.92 to 3.02. The optimal dewaterability of digested sludge was achieved when polyamidine flocculant dosage was 30 mg/g-MLSS and the corresponding sludge specific resistance to filtration was 2.26 × 1012 m/kg. The results demonstrated that AnMBR yielded high energy conversion efficiency without co-digestion and pretreatment processing.

Dose-response and type-dependent effects of antiviral drugs in anaerobic digestion of waste-activated sludge for biogas production.

In the context of the COVID-19 pandemic, antiviral drugs (AVDs) were heavily excreted into wastewater and subsequently enriched in sewage sludge due to their widespread use. The potential ecological risks of AVDs have attracted increasing attention, but information on the effects of AVDs on sludge anaerobic digestion (AD) is limited. In this study, two typical AVDs (lamivudine and ritonavir) were selected to investigate the responses of AD to AVDs by biochemical methane potential tests. The results indicated that the effects of AVDs on methane production from sludge AD were dose- and type-dependent. The increased ritonavir concentration (0.05-50mg/kg TS) contributed to an 11.27-49.43% increase in methane production compared with the control. However, methane production was significantly decreased at high lamivudine doses (50mg/kg TS). Correspondingly, bacteria related to acidification were affected when exposed to lamivudine and ritonavir. Acetoclastic and hydrotropic methanogens were inhibited at a high lamivudine dose, while ritonavir enriched methylotrophic and hydrotropic methanogens. Based on the analysis of intermediate metabolites, the inhibition of lamivudine and the promotion of ritonavir on acidification and methanation were confirmed. In addition, the existence of AVDs could affect sludge properties. Sludge solubilization was inhibited when exposed to lamivudine and enhanced by ritonavir, perhaps caused by their different structures and physicochemical properties. Moreover, lamivudine and ritonavir could be partially degraded by AD, but 50.2-68.8% of AVDs remained in digested sludge, implying environmental risks.

Revealing the mechanism of novel nitrogen-doped biochar supported magnetite (NBM) enhancing anaerobic digestion of waste-activated sludge by sludge characteristics

Anaerobic digestion (AD) is a promising technology in waste treatment and energy recovery. However, it suffers from long retention time and low biogas yield. In this study, novel nitrogen-doped biochar supported magnetite (NBM) was synthesized and applied to enhance the AD of waste-activated sludge. Results showed that NBM increased cumulative methane production and SCOD removal efficiency by up to 1.75 times and 15% respectively at 5 g/L compared with the blank. NBM enhanced both hydrolysis and methanogenesis process during AD and the activities of α-glucosidase, protease, coenzyme F420 and electron transport system were increased by 19%, 163%, 104% and 160% respectively at 5 g/L NBM compared with the blank. NBM also facilitated the secretion of conductive protein in extracellular polymeric substances as well as the formation of conductive pili, leading to 3.18–7.59 times higher sludge electrical conductivity. Microbial community analysis revealed that bacteria Clostridia and archaea Methanosarcina and Methanosaeta were enriched by the addition of NBM, and direct interspecies electron transfer might be promoted between them. This study provides a practical reference for future material synthesis and its application.

Unveiling the mechanisms of Fe(III)-loaded chitosan composite (CTS-Fe) in enhancing anaerobic digestion of waste activated sludge

Anaerobic digestion (AD) of waste activated sludge (WAS) is usually limited by the low generation efficiency of methane. Fe(III)-loaded chitosan composite (CTS-Fe) have been reported to effectively enhanced the digestion of WAS, but its role in promoting anaerobic sludge digestion remains unclear. In present study, the effects of CTS-Fe on the hydrolysis and methanogenesis stages of WAS anaerobic digestion were investigated. The addition of CTS-Fe increased methane production potential by 8%–23% under the tested conditions with the addition of 5–20 g/L CTS-Fe. Besides, the results demonstrate that the addition of CTS-Fe could effectively promote the hydrolysis of WAS, evidenced by lower protein or polysaccharides concentration, higher soluble organic carbon in rector adding CTS-Fe, as well as the increased activity of extracellular hydrolase with higher CTS-Fe concentration. Meanwhile, the enrichment of Clostridia abundance (iron-reducing bacteria (IRBs)) was observed in CTS-Fe adding reactor (8.9%–13.8%), which was higher than that in the control reactor (7.9%). The observation further suggesting the acceleration of hydrolysis through dissimilatory iron reduction (DIR) process, thus providing abundant substrates for methanogenesis. However, the presence of CTS-Fe was inhibited the acetoclastic and hydrogenotrophic methanogenesis process, which could be ascribed to the Fe(III) act as electron acceptor coupled to methane for anaerobic oxidation. Furthermore, coenzyme F420 activity in the CTS-Fe added reactor was 34.9% lower than in the blank, also abundance of microorganisms involved in hydrogenotrophic methanogenesis was decreased. Results from this study could provide theoretical support for the practical applications of CTS-Fe.

Enhanced hydrolysis/acidogenesis and potential mechanism in thermal-alkali-biofilm synergistic pretreatment of high-solid and low-organic-content sludge

Improving the anaerobic digestion (AD) of high-solid and low-organic-content sludge is imperative for sustainable waste activated sludge (WAS) management. Here, a thermal-alkali-biofilm pretreatment (TAB) was established to treat high-solid and low-organic-content sludge and compared with thermal and thermal-alkali methods. The results showed that TAB drastically improved WAS reduction, hydrolysis/acidogenesis efficiency, and biochemical methane potential. TAB possessed the lowest sludge particle size and the highest surface charge due to the stimulated proteolysis and WAS solubilization, supported by the protease activity test and secondary substrate identification. In addition, the biofilm assistance noticeably accelerated the elimination of autochthonous bacteria in WAS (e.g., Proteobacteria) and facilitated the enrichment of specialized fermentative microorganisms (e.g., Firmicutes) along with relevant functional genes, lying molecular foundation for the enhanced hydrolysis/acidogenesis in TAB. These findings could expand the application of biofilm in the AD of WAS and provide new insight into the pretreatment strategy of high-solid and low-organic-content sludge.

Enhancing Mesophilic Anaerobic Digestion of Waste-Activated Sludge through Heat Pretreatment and Kinetic Modeling

Sewage sludge is a useful raw material for the production of renewable energy due to its stable annual output. In this study, the enhancement of mesophilic anaerobic digestion of sewage sludge through heat pretreatment at 95 °C for 30 min was tested in an anaerobic moving bed biofilm reactor (hAMBBR). The sludge retention time was set at 20, 15, 10, and 5 days during 300 days of operation and compared to a traditional anaerobic continuous stirred tank reactor (AnCSTR) without pretreatment. Results of this research indicate that the digestion ratio of volatile soluble solids in the hAMBBR process could be improved by 50%, and the average conversion ratio of methane could be increased by 45%. When the sludge retention time (SRT) was shortened to 5 days, the methane production approached twice that of the contrast reactor. The expanded anaerobic digestion model, including activated sludge models, was utilized for operation simulation. The effect of sludge retention time (SRT) shortening on volatile suspended solids (VSS) digestibility and methane production was well reproduced with simulations. The research conclusion reveals the impact of pretreatment and reactor types on anaerobic digestion and provides the scientific basis for improving methane production and process efficiency in anaerobic digestion.

Zinc pyrithione induced volatile fatty acids promotion derived from sludge anaerobic digestion: Interrelating the affected steps with microbial metabolic regulation and adaptive responses

The massive use of zinc pyrithione (ZPT, as broad-spectrum bactericides) resulted in its high levels in waste activated sludge (WAS) and affected subsequent WAS treatment. This work revealed the effects of ZPT on the volatile fatty acids (VFAs) during WAS anaerobic digestion, in which VFAs yield was enhanced by approximately 6-9 folds (from 353 mg COD/L in control to 2526-3318 mg COD/L with low level of ZPT (20-50 mg/g TSS)). The ZPT occurred in WAS enabled the acceleration of solubilization, hydrolysis and acidification processes while inhibited the methanogenesis. Also, the low ZPT contributed to the enrichment of functional hydrolytic-acidifying microorganisms (e.g., Ottowia and Acinetobacter) but caused the reduction of methanogens (e.g., Methanomassiliicoccus and Methanothrix). Meta-transcriptomic analysis demonstrated that the critical genes relevant to extracellular hydrolysis (i.e. CLPP and ZapA), membrane transport (i.e. gltI, and gltL), substrates metabolisms (i.e. fadj, and acd), and VFAs biosynthesis (i.e. porB and porD) were all upregulated by 25.1-701.3% with low level of ZPT. Specifically, the ZPT stimulus on amino acids metabolism for VFAs transformation was prominent over carbohydrates. Moreover, the functional species enabled to regulate the genes in QS and TCS systems to maintain favorable cell chemotaxis to adapt the ZPT stress. The cationic antimicrobial peptide resistance pathway was upregulated to blunt ZPT with the secretion of more lipopolysaccharide and activate proton pumps to maintain ions homeostasis to antagonize the ZPT toxicity for high microbial activities, the abundance of related genes was up-regulated by 60.5 to 524.5%. This work enlightened environmental behaviors of emerging pollutants on WAS anaerobic digestion process with interrelations of microbial metabolic regulation and adaptive responses.

Effect of riboflavin and carbon black co-modified fillers coupled with alkaline pretreatment on anaerobic digestion of waste activated sludge

Additional various carbon and free riboflavin could improve anaerobic digestion of waste activated sludge (WAS). However, these substances were not reused. In this study, a reusable riboflavin and carbon black (RCB) co-modified filler was developed and combined with alkaline pretreatment for enhancing the production of volatile fatty acids (VFAs) and methane during anaerobic digestion of WAS. The results showed that RCB-modified fillers exhibited a promoting effect on the reduction of alkali-pretreated WAS. The amounts of the accumulated VFAs mainly containing acetate and the produced methane rose with the increased concentration of immobilized riboflavin (0–0.75 g/L) in the presence of 4 g/L carbon black. When the alkaline pretreatment time of WAS increased from 3 d to 8 d, the amount of methane production increased from 22.8% to 63.9% in the presence of 0.75 g/L riboflavin and 4 g/L carbon black compared with that without RCB-modified fillers. Moreover, 0.75 g/L riboflavin and 4 g/L carbon black had a synergetic effect on promoting methane production via broadening extracellular electron transfer pathways. During this process, microbial dehydrogenase activity, electron transport system activity and coenzyme F420 were enhanced. Microbial community analysis showed that RCB-modified filler addition promoted the enrichment of Syntrophomonas and Pseudomonas involved in direct interspecies electron transfer (DIET). These results indicated that DIET establishment was accelerated. Meanwhile, the populations of acetic acid-producing bacteria including Rikenellaceae_RC9_gut_group and Proteiniphilum, aceticlastic and acid-tolerant methanogenic archaea including Methanosarcina and Methanosaeta, RumEn_M2 were increased. These results indicate that RCB-modified fillers coupled with alkaline pretreatment is an effective method to promote the production of methane during anaerobic digestion of WAS.

Phosphorus recovery from waste-activated sludge through vivianite crystallization enhanced by magnetic biochar

Recently, phosphorus recovery as vivianite (Fe3(PO4)2·8H2O) from anaerobic digestion of waste-activated sludge (WAS) has attracted increasing attention because of its high recovery efficiency and economic value. However, the relatively small crystal size restricts the separation and recovery of vivianite. In this study, magnetic biochar (MB) was prepared by the impregnation-pyrolysis method and selected as an additive to enhance vivianite crystallization during WAS anaerobic digestion. The effects of MB iron loading and dosage on the phosphorus recovery efficiency and methane yield were investigated through batch experiments, X-ray diffraction (XRD), scanning electron microscopy (SEM), and energy dispersive spectroscopy (EDS) were used to analyze the recovered precipitates. The results showed that the phosphorus recovery efficiency reached 45% and the methane yield increased by 27% when the mass ratio of biomass to FeCl3·6H2O (mB:mFe) was 2:1 and the dosage of MB was 1 g/gVS. SEM images displayed that the vivianite produced by MB as the seed crystal (102 μm) was larger than those without addition of MB (32 μm), and vivianite synthesized with MB could be easily separated from the sludge by a magnet. The microbial analysis found the functional bacteria related to Fe3+ reduction and methane production were further enhanced and enriched by the MB. In summary, this research confirms the feasibility of recovering phosphorus in the form of vivianite from waste-activated sludge using magnetic biochar as the seed crystal, which is conducive to its subsequent separation and utilization.

Applying Dynamic Magnetic Field To Promote Anaerobic Digestion via Enhancing the Electron Transfer of a Microbial Respiration Chain.

Electrochemical methods have been reported to strengthen anaerobic digestion, but the continuous electrical power supply and the complicated electrode installed inside the digester have restricted it from practical use. In this study, a dynamic magnetic field (DMF) was placed outside a digester to induce an electromotive force to electrically promote anaerobic digestion. With the applied DMF, an electromotive force of 0.14 mV was generated in the anaerobic sludge, and a 65.02% methane increment was obtained from the anaerobic digestion of waste-activated sludge. Experiments on each stage of anaerobic digestion showed that acidification and methanogenesis that involve electron transfer of respiration chains were promoted with the DMF, while solubilization and hydrolysis less related to respiration chains were not enhanced. Further analysis indicated that the induced electromotive force polarized the protein-like substances in the sludge to increase the conductivity and capacitance of the sludge. Electrotrophic methanogens (Methanothrix) and exoelectrogens (Exiguobacterium) were enriched with DMF. The kinetic isotope effect test confirmed that electron transfer was accelerated with DMF. Consistently, the concentration ratio of co-enzymes (NADH/NAD+ and F420H2/F420) that reflects the electron exchange with respiration chains significantly increased. Applying the DMF seemed a more accessible strategy to electrically strengthen anaerobic digestion.