Airborne Endotoxin Concentrations Research Articles

Endotoxin and Dust at Respirable and Nonrespirable Particle Sizes are not Consistent Between Cage- and Floor-Housed Poultry Operations

Individuals engaged in work in intensive animal houses experience some of the highest rates of occupationally related respiratory symptoms. Organic dust and in particular endotoxin has been most closely associated with respiratory symptoms and lung function changes in workers. It has previously been shown that for intensive poultry operations, type of poultry housing [cage-housed (CH) versus floor-housed (FH)] can influence the levels of environmental contaminants. The goal of the study was to determine the differences in endotoxin and dust levels at different size fractions between CH and FH poultry operations. Fifteen CH and 15 FH poultry operations were sampled for stationary measurements (area) of dust and associated endotoxin. Fractioned samples were collected utilizing Marple cascade impactors. Gravimetric and endotoxin analysis were conducted on each of the filters. When assessed by individual Marple stage, there was significantly greater airborne endotoxin concentration (endotoxin units per cubic meter) in the size fraction >9.8 μm for the FH operations whereas at the size fraction 1.6-3.5 μm, the CH operations had significantly greater airborne endotoxin concentration than the FH operations. Endotoxin concentration in the dust mass (endotoxin units per milligram) was significantly greater in the CH operations as compared to the FH operations for all size fractions >1.6 μm. As such, endotoxin in the respirable fraction accounted for 24% of the total endotoxin in the CH operations whereas it accounted for only 11% in the FH operations. There was significantly more dust in all size fractions in the FH operations as compared to the CH poultry operations. There is more endotoxin in the presence of significantly lower dust levels in the respirable particle size fractions in CH poultry operations as compared to the FH poultry operations. This difference in respirable endotoxin may be important in relation to the differential respiratory response experienced by CH and FH poultry operation workers.

Evaluation of the Limulus Amebocyte Lysate and Recombinant Factor C Assays for Assessment of Airborne Endotoxin

As a potent inflammatory agent, endotoxin is a key analyte of interest for studies of lung ailments in domestic environments and occupational settings with organic dust. A relatively unexplored advance in endotoxin exposure assessment is the use of recombinant factor C (rFC) from the Limulus pathway in a fluorometric assay. In this study, we compared airborne endotoxin concentrations in laboratory- and field-collected parallel air samples using the kinetic Limulus amebocyte lysate (LAL) assay and the rFC assay. Air sampling was performed using paired Institute of Occupational Medicine (IOM) samplers, Button samplers, closed-face cassettes, and cyclone samplers. Field sampling was performed in 10 livestock production facilities, including those housing swine, chicken, turkey, dairy cows, cattle, and horses. Laboratory sampling was performed in exposure chambers using resuspended airborne dust collected in five livestock facilities. Paired samples were extracted in pyrogen-free water with 0.05% Tween 20 and analyzed using LAL and rFC assays. In 402 field sample pairs there was excellent agreement between endotoxin concentrations determined by LAL and rFC (r = 0.93; P < 0.0001). In 510 laboratory sample pairs there was also excellent agreement between the two assays (r = 0.86; P < 0.0001). Correlations for subgroups of facility or dust type ranged from 0.65 to 0.96. Mixed-model analysis of variance (ANOVA) for the field studies showed significant interactions of facility-sampler and facility-assay. rFC/LAL ratios of the geometric means were 0.9 to 1.14 for the samplers (not significantly different from 1.0). The data from this study demonstrate that the LAL assay and the rFC assay return similar estimates of exposure in livestock facilities. Both methods provided suitable lower limits of detection such that all but 19 of 1,824 samples were quantifiable.

Endotoxin Levels at Swine Farms Using Different Waste Treatment and Management Technologies

Concentrated animal feeding operations (CAFOs) are a major source of airborne endotoxins, which are air pollutants that can cause adverse health effects to both on-site farmers and neighbors. Release of airborne endotoxins to the environment can be reduced using proper waste treatment and management technologies. In this study, the levels of endotoxins released from two swine CAFOs using conventional lagoon-sprayfield technology were compared to those of 15 farms using various alternative waste management technologies in North Carolina. Over a 2-year period, 236 endotoxin samples were collected from the 17 farm units and analyzed using the Limulus amebocyte lysate (LAL) test. Concentrations of airborne endotoxins near barn exhaust fans were significantly higher than at the upwind boundary of the farm and at other farm sites. For most of the study sites, mean concentrations of endotoxins at the downwind boundary of the farm were higher than those at the upwind boundary of the farm, indicating the release of endotoxins from swine CAFOs to the neighboring environment. Endotoxin levels were significantly associated with concentrations of airborne bacteria but not fungi. Environmental factors, such as temperature, relative humidity, and wind velocity, affected the levels of airborne endotoxins at the farms. Based on the ratios of airborne endotoxins in downwind and upwind samples from the farm units, at least five different alternative waste management technologies significantly reduced the release of endotoxins from swine CAFOs. These results suggest that swine CAFOs are important sources of airborne endotoxins, the levels of which can be reduced by applying more robust and effective waste management technologies.

Airborne Endotoxin Concentrations in Homes Burning Biomass Fuel

BackgroundAbout half of the world’s population is exposed to smoke from burning biomass fuels at home. The high airborne particulate levels in these homes and the health burden of exposure to this smoke are well described. Burning unprocessed biological material such as wood and dried animal dung may also produce high indoor endotoxin concentrations.ObjectiveIn this study we measured airborne endotoxin levels in homes burning different biomass fuels.MethodsAir sampling was carried out in homes burning wood or dried animal dung in Nepal (n = 31) and wood, charcoal, or crop residues in Malawi (n = 38). Filters were analyzed for endotoxin content expressed as airborne endotoxin concentration and endotoxin per mass of airborne particulate.ResultsAirborne endotoxin concentrations were high. Averaged over 24 hr in Malawian homes, median concentrations of total inhalable endotoxin were 24 endotoxin units (EU)/m3 in charcoal-burning homes and 40 EU/m3 in wood-burning homes. Short cooking-time samples collected in Nepal produced median values of 43 EU/m3 in wood-burning homes and 365 EU/m3 in dung-burning homes, suggesting increasing endotoxin levels with decreasing energy levels in unprocessed solid fuels.ConclusionsAirborne endotoxin concentrations in homes burning biomass fuels are orders of magnitude higher than those found in homes in developed countries where endotoxin exposure has been linked to respiratory illness in children. There is a need for work to identify the determinants of these high concentrations, interventions to reduce exposure, and health studies to examine the effects of these sustained, near-occupational levels of exposure experienced from early life.

Metalworking Fluid-Related Aerosols in Machining Plants

Respiratory problems are observed in machinists using soluble metalworking fluid (MWF). Evidences suggest that these problems could be related to the aerosolized microorganisms and their byproducts from MWF. To establish MWF aerosol exposure thresholds and to better understand their effect on human health, these aerosols must be fully characterized. This article evaluates airborne microorganisms and aerosols from soluble MWF in the working environment. Air quality parameters (endotoxin levels, culturable airborne microorganisms, fluid mist, inhalable dust and air exchange rates) were evaluated at 44 sites, in 25 shops in Quebec, Canada. Microorganism concentrations were also measured in MWF. Culturable airborne bacteria concentrations were low, ranging from 1.2 × 101 to 1.5 × 103 CFU (colony forming units) m− 3, even for metalworking fluid highly contaminated by bacteria (up to 2.4 × 109 CFU mL− 1). Inhalable dust varied between < 0.1 to 2.6 mg m− 3, while air exchange rates were mostly below the standard (4 h− 1) for this type of workplace, between 0.6 to 14.2 h− 1. Only nine of 44 sites respected the suggested minimum value for air exchange rates. Fluid mist ranged from 0.02 to 0.89 mg m− 3, which is below the threshold limit value (TLV) (ACGIH) of 5 mg m− 3. Airborne endotoxin concentrations ranged from undetectable to 183 EU m− 3 (endotoxin units), showing no correlation with airborne microorganisms or inhalable dust. Most workstations respected the suggested minimum values for fluid mist and showed low concentrations of airborne endotoxin, culturable microorganisms and inhalable dust despite fluid contamination, even when air exchange rates were below the recommendations. Airborne Pseudomonas pseudoalcaligenes was recovered from many sites at significant concentrations. Health-associated risks following exposure to this microorganism should be further investigated.

Year-long assessment of airborne endotoxin at a concentrated dairy operation

In this study, we monitored total airborne endotoxins at upwind and downwind sites at a large open-lot dairy each month for a year. At the upwind site, the average airborne concentration was 28.5 endotoxin units (EU) m−3, while at the downwind edge of the lot and 200 m from the lot edge, the average concentrations were 169 and 72 EU m−3, respectively. At the downwind edge of the lot, there was a significant correlation between the airborne endotoxin concentration and wind speed or air temperature. A comparison between total and inhalable airborne endotoxin concentrations, near the end of the study, revealed no significant differences between the two endotoxin collection methods. Our data suggest that endotoxin exposure can be reduced as one increases their distance from the open-lot dairy.

Resuspension of indoor aeroallergens and relationship to lung inflammation in asthmatic children

Studies have shown links between the concentration of allergens found in homes and asthma. Inhalation of allergens present in settled residential dust can occur when the dust is resuspended via human activity or air currents. Although previous studies have measured allergen concentrations in homes, the focus has been on the presence of the allergens in settled dust samples. However, the actual inhalation exposure is to airborne allergens. The relationship between the settled dust composition and suspended allergens and endotoxin and the effect of exposure of these aeroallergens to asthmatics are not well understood for species typically present indoors. In this study, settled dust and airborne particulate matter samples were collected in the homes and school classrooms of asthmatic children of ages 9 to 16 and analyzed for endotoxin and allergens including dust mite and cockroach allergen, and dog and cat dander (Der p1, Der f1, Bla g1, Can f1, and Fel d1, respectively). Concentrations of cockroach allergen were below detection limit for all samples. Measurements of the settled dust samples show higher dust mite allergen in bedroom samples than in living room samples. Concentrations of airborne endotoxin and indoor allergens were generally higher in the homes than those measured at school. Within the homes, higher concentrations of airborne allergens and endotoxin were observed in the living rooms compared to the bedrooms. Resuspension rates for endotoxin, dust mite allergen, and, cat and dog dander were estimated in this study. Calculated resuspension rates for cat dander (8.1×10−7±3.5×10−7min−1) and dust mite allergen (2.1×10−6±7.6×10−7min−1and 1.4×10−5±4.6×10−6min−1 for Der p 1 and Der f 1, respectively) were found to be higher than those for dog dander (3.1×10−7±1.3×10−7min−1) and endotoxin (3.6×10−7±1.6×10−7min−1). Markers of asthma inflammation including nitrate in exhaled breath condensate (EBC) and exhaled nitric oxide (eNO), were correlated with the concentrations of dust mite allergen (Der p 1) (Spearman r=0.598; p-value=0.068 for EBC and Spearman r=0.819; p-value=0.007 for eNO) and cat dander (Fel d 1) (Spearman r=0.917; p-value=0.0002 for EBC and Spearman r=0.697; p-value=0.054 for eNO) present in PM10 samples.

Airborne Endotoxin Concentrations at a Large Open‐Lot Dairy in Southern Idaho

Endotoxins are derived from gram-negative bacteria and are a potential respiratory health risk for animals and humans. To determine the potential for endotoxin transport from a large open-lot dairy, total airborne endotoxin concentrations were determined at an upwind location (background) and five downwind locations on three separate days. The downwind locations were situated at of the edge of the lot, 200 and 1390 m downwind from the lot, and downwind from a manure composting area and wastewater holding pond. When the wind was predominantly from the west, the average endotoxin concentration at the upwind location was 24 endotoxin units (EU) m(-3), whereas at the edge of the lot on the downwind side it was 259 EU m(-3). At 200 and 1390 m downwind from the edge of the lot, the average endotoxin concentrations were 168 and 49 EU m(-3), respectively. Average airborne endotoxin concentrations downwind from the composting site (36 EU m(-3)) and wastewater holding pond (89 EU m(-3)) and 1390 m from the edge of the lot were not significantly different from the upwind location. There were no significant correlations between ambient weather data collected and endotoxin concentrations over the experimental period. The downwind data show that the airborne endotoxin concentrations decreased exponentially with distance from the lot edge. Decreasing an individual's proximity to the dairy should lower their risk of airborne endotoxin exposure and associated health effects.

Occupational exposure to bacterial single cell protein induces inflammation in lung and blood

Bacterial single cell protein (BSCP) is used as a protein enrichment in livestock and fish feed, and is extracted from dried bacterial mass. In the production of BSCP, workers are exposed to organic dust containing high levels of endotoxins that may induce acute airway inflammation. However, the long term effect on the airways of such exposure is not known, and we have examined inflammatory markers in induced sputum and blood among BSCP exposed workers. We included 21 non-smoking production workers (age 31–42 (range; mean 35)) without respiratory symptoms and 21 healthy non-exposed references (age 21–52 (range; mean 34)). Airborne endotoxin concentrations were measured, and induced sputum samples and blood samples were collected from the workers and non-exposed references. The airborne endotoxin concentration measured in inhaled air during the work shift was 430 EU/m3 (50–2000) (median (range)). The percentage of neutrophils in induced sputum was 79% (66–93) (median (25th–75th percentiles)) and 31% (25–45) (p < 0.001) for operators and references, respectively. Protein analysis in induced sputum supernatant showed significantly elevated levels of interleukins IL-1β and IL-12 (p < 0.05), while blood analysis showed significantly elevated levels of PDGF-BB (platelet-derived growth factor-BB) and RANTES (regulated upon activation normally T cell expressed and secreted) (p < 0.05). Workers exposed to BSCP had an airway inflammation characterized by a high level of neutrophils. However, only a few cytokines were elevated in lung and blood, which could imply low inflammatory activity suggestive of possible adaptation mechanisms due to daily exposure to BSCP, or that the inflammation reaction was a dose-related response occurring at higher levels.

Comparison of Endotoxin and Particle Bounce in Marple Cascade Samplers With and Without Impaction Grease

ABSTRACT The health of persons engaged in agricultural activities are often related or associated with environmental exposures in their workplace. Accurately measuring, analyzing, and reporting these exposures is paramount to outcomes interpretation. This paper describes issues related to sampling air in poultry barns with a cascade impactor. Specifically, the authors describe how particle bounce can affect measurement outcomes and how the use of impaction grease can impact particle bounce and laboratory analyses such as endotoxin measurements. This project was designed to (1) study the effect of particle bounce in Marple cascade impactors that use polyvinyl chloride (PVC) filters; (2) to determine the effect of impaction grease on endotoxin assays when sampling poultry barn dust. A pilot study was undertaken utilizing six-stage Marple cascade impactors with PVC filters. Distortion of particulate size distributions and the effects of impaction grease on endotoxin analysis in samples of poultry dust distributed into a wind tunnel were studied. Although there was no significant difference in the overall dust concentration between utilizing impaction grease and not, there was a greater than 50% decrease in the mass median aerodynamic diameter (MMAD) values when impaction grease was not utilized. There was no difference in airborne endotoxin concentration or endotoxin MMAD between filters treated with impaction grease and those not treated. The results indicate that particle bounce should be a consideration when sampling poultry barn dust with Marple samplers containing PVC filters with no impaction grease. Careful consideration should be given to the utilization of impaction grease on PVC filters, which will undergo endotoxin analysis, as there is potential for interference, particularly if high or low levels of endotoxin are anticipated.

일부지역 양돈장 및 양계장 공기중 박테리아, 진균, 내독소 농도

This study was undertaken to determine the concentrations of airborne bacteria, fungi, particles, and endotoxin in swine and chicken houses. Six swine buildings and seven chicken houses were randomly selected in southern Gyonggi Province, South Korea. The geometric mean concentrations of airborne bacteria in swine and chicken houses were and , respectively. The airborne bacteria concentrations in chicken houses were significantly higher than those of swine houses (p, which was higher than the value of found in chicken houses. The mean concentrations of airborne particles and endotoxin in swine houses were and , and they were and in chicken houses, respectively. A significant difference between swine and chicken houses was found for total dust (p suggested in previous studies. These results may indicate a considerable respiratory hazard for workers in these environments.

Effect of microclimate on the airborne dust and endotoxin concentration in a broiler house

Poultry farming is considered to be a notable source of bioaerosols. They can be a risk factor from the aspect of some diseases and for the environment. A study was conducted to assess the effect of microclimate on the level of airborne dust and endotoxins in an intensive broiler fattening facility. The content of airborne dust, endotoxins, air temperature, relative humidity, airflow velocity, ammonia and carbon dioxide were determined. The study was conducted in a poultry house accommodating 22 000 broilers of Ross-308 breed. The measured temperature in the broiler house ranged from 22.02°C to 31.05°C, relative humidity from 49.55% to 65.45%, and airflow velocity from 0.07 m/s to 0.09 m/s. The air concentration of dust ranged from 2.0 mg/m&lt;sup&gt;3&lt;/sup&gt; at the end of fattening period to 4.9 mg/m&lt;sup&gt;3&lt;/sup&gt; in the mid-fattening period, and endotoxins from 6.21 EU/m&lt;sup&gt;3&lt;/sup&gt; in the second study week to 99.40 EU/m&lt;sup&gt;3&lt;/sup&gt; at the end of fattening period. The air concentration of ammonia ranged from 5.17 ppm at the beginning to 25.49 ppm at the end of fattening period. Air concentrations of dust and endotoxins recorded in this poultry house varied during the fattening period and depended on relative humidity and temperature as demonstrated by multiple regression at the level of &lt;I&gt;P&lt;/I&gt; ≤ 0.05.

Circulating lipopolysaccharides in the blood from “bioprotein” production workers

Background: Workers producing bacterial single-cell protein (BSCP), “bioprotein,” are exposed to organic dust containing high levels of endoxins (lipopolysaccharides, LPS). Workers in this industry have complained of episodes of fever,...

Optimization of Airborne Endotoxin Exposure Assessment: Effects of Filter Type, Transport Conditions, Extraction Solutions, and Storage of Samples and Extracts

Endotoxin exposure occurs in homes and occupational environments and is known to cause adverse health effects. In order to compare results from different studies and establish standards, airborne endotoxin exposures should be assessed using standardized methods. Although the European Committee for Standardization (CEN) developed guidelines for endotoxin exposure assessment, these leave room for individual interpretation. The influence of methods of sampling, extraction, and analysis has never been investigated in a full experimental design. Thus, we sought to fully elucidate the importance of all facets of endotoxin assessment. Inhalable dust samples collected simultaneously were used to investigate the effects on and interactions with airborne endotoxin concentration in two working environments of filter type (glass fiber or Teflon), transport conditions (with/without desiccant), sample storage (-20 or 4 degrees C), extraction solution (pyrogen-free water [PFW] or PFW plus 0.05% Tween 20), extract storage (-20 or 4 degrees C), and assay solution (PFW or PFW plus 0.05% Tween 20). Four hundred samples were collected and randomly distributed over the 20 combinations of treatments. There were no differences found for transport conditions and storage temperature of extracts. Also, no interactions between study variables existed. Sampling on glass-fiber filters, storage of samples in the freezer, and extraction in PFW plus 0.05% Tween 20 resulted in 1.3-, 1.1-, and 2.1-fold-higher estimated endotoxin concentrations, respectively. Use of PFW plus 0.05% Tween 20 in the assay solution had an additive effect. Thus, this study investigated gaps in the CEN protocol and provides data with which to fully specify a protocol for standardization of endotoxin exposure assessment.

Size Distribution of Airborne Mist and Endotoxin-Containing Particles in Metalworking Fluid Environments

The objective of the study was to investigate size-selective concentrations of airborne particles and endotoxin in metalworking fluid (MWF) environments. The experiments were conducted under two conditions: (1) MWF collected in the field was aerosolized with a laboratory-scale simulator (MWF simulator) in the laboratory; and (2) MWFs were aerosolized during routine field operations. All experiments included size-selective measurement of airborne concentrations of particle numbers and endotoxin mass using an electrical low-pressure impactor. During field sampling, the total microbial and endotoxin concentrations in the air were also measured with a BioSampler, and the mass concentration of MWF mists was measured with a photometer. Airborne particle concentrations were highest in the fine particle size ranges in the areas affected by MWFs. Relatively high concentrations of endotoxin were detected at particle size below 0.39 μm, which is smaller than the size of intact bacterial cells. The total microbial and endotoxin analysis revealed high microbial contamination in one sampling site although the total particle mass was not elevated. It was concluded that MWF sites can be contaminated with high concentrations of fine particles, and these fine particles may contain microbial components, such as endotoxin. The results call for the size-selective measurement of particles and endotoxin for more comprehensive exposure assessment in MWF facilities.

A Preliminary Study on Gram-Negative Bacteria (GNB) and Their Endotoxins in a Gin House in India

The presence of byssinosis, an occupational disease found among cotton mill workers, has been well documented in different parts of the world. The disease develops due to exposure to environmental cotton dust. Evidence suggests that the causative agent for the disease is gram-negative bacteria (GNB) and their endotoxins present on the cotton fibers. An investigation was carried out in a gin house in western India. Environmental dust samples were collected by vertical elutriator (VE). Airborne dust concentrations were very high in the working environment: 2.11 mg/m3 in ginning and 0.95 mg/m3 in the press department (p < 0.05), which was higher than the threshold limit value collected by VE (0.2 mg/m3), and higher than the permissible exposure limit for respirable dust (0.5 mg/m3 for nontextile industries using cotton). In the office control site, the dust concentration was 0.31 mg/m3. The Occupational Safety and Health Administration's cotton dust standard permissible exposure limit for respirable dust is 0.2 mg/m3 in yarn manufacturing, 0.75 mg/m3 in slashing and weaving, and 0.5 mg/m3 in nontextile industries using cotton. These samples also showed high concentrations of airborne endotoxin (p < 0.001) in ginning and pressing (2.77 and 1.52 μg/m3) compared with the office control site (0.009 μ g/m3 measured by Limulus amoebocyte lysate technique). Total enumeration of airborne GNB was carried out qualitatively by the petri plate exposure method and quantitatively by an Andersen 6-stage viable sampler and VE. GNB were recovered in quite high numbers. Among all the GNB, Enterobacter agglomerans were the dominant bacterial flora. Results indicate that gin workers are occupationally exposed to airborne GNB and endotoxins, and require masks.

Airborne Mold and Endotoxin Concentrations in New Orleans, Louisiana, after Flooding, October through November 2005

BackgroundThe hurricanes and flooding in New Orleans, Louisiana, in October and November 2005 resulted in damp conditions favorable to the dispersion of bioaerosols such as mold spores and endotoxin.ObjectiveOur objective in this study was to assess potential human exposure to bioaerosols in New Orleans after the flooding of the city.MethodsA team of investigators performed continuous airborne sampling for mold spores and endotoxin outdoors in flooded and nonflooded areas, and inside homes that had undergone various levels of remediation, for periods of 5–24 hr during the 2 months after the flooding.ResultsThe estimated 24-hr mold concentrations ranged from 21,000 to 102,000 spores/m3 in outdoor air and from 11,000 to 645,000 spores/m3 in indoor air. The mean outdoor spore concentration in flooded areas was roughly double the concentration in nonflooded areas (66,167 vs. 33,179 spores/m3; p < 0.05). The highest concentrations were inside homes. The most common mold species were from the genera of Cladosporium and Aspergillus/Penicillium; Stachybotrys was detected in some indoor samples. The airborne endotoxin concentrations ranged from 0.6 to 8.3 EU (endo-toxin units)/m3 but did not vary with flooded status or between indoor and outdoor environments.ConclusionsThe high concentration of mold measured indoors and outdoors in the New Orleans area is likely to be a significant respiratory hazard that should be monitored over time. Workers and returning residents should use appropriate personal protective equipment and exposure mitigation techniques to prevent respiratory morbidity and long-term health effects.

Determination of the Inflammatory Potential of Bioaerosols from a Duck‐Fattening Unit by Using a Limulus Amebocyte Lysate Assay and Human Whole Blood Cytokine Response

Inhalation of bioaerosols from animal houses can induce acute inflammatory reactions in the respiratory tract. Determination of the concentration of airborne endotoxins is widely used to characterize this risk. In this study, the activity of bioaerosol samples from a duck-fattening unit to induce interleukin-1beta (IL-1beta) in human blood and to react with Limulus Amebocyte Lysate (LAL) was investigated. The activity detected in the whole blood assay correlated well with the endotoxic activity found in the LAL assay (Spearmen's rho = 0.902). However in all samples, the inflammation-inducing potential was overestimated by the LAL assay. It is assumed that this overestimation could be, in part, a result of an overestimation of the inflammatory potential of endotoxins originating from Pseudomonadaceae by the LAL assay. Pseudomonadaceae were regularly isolated from the air of the duck-fattening unit. The results presented here indicate that the whole blood assay can be used besides the LAL assay as an additional method to characterize the inflammation-inducing potential of bioaerosols.

Particle size distributions and concentrations of airborne endotoxin using novel collection methods in homes during the winter and summer seasons

A comparison study of novel collection methods for airborne bacteria and endotoxin was performed in an environmentally controlled chamber and in pilot-field studies. Airborne particulate matter was collected in swirling liquid impingers, air-monitoring filter cassettes, and with a micro-orifice uniform deposit impactor (MOUDI) to evaluate aerodynamic particle size distributions. Environmentally controlled chamber studies showed that impingers and MOUDI recovered significantly more airborne bacteria than filter cassettes, whereas collection methods for airborne endotoxin were not significantly different. In addition, total airborne bacteria and endotoxin concentrations were measured indoors and outdoors at three homes in Boulder, CO during winter and summer seasons. Indoor concentrations collected with the three different samplers were significantly different for airborne endotoxin, but not for airborne bacteria. Total airborne bacteria indoors and outdoors significantly varied with seasons. Outdoor airborne endotoxin significantly varied with season; no seasonal variation was seen for indoor airborne endotoxin. Indoor and outdoor levels were not significantly different for both airborne bacteria and endotoxin. The largest proportion of endotoxin was associated with airborne particulate matter <1 microm. This study compared sampling methods for airborne endotoxin, a potent and nonspecific immune system stimulant which can induce negative health responses. The data from this study showed that swirling liquid impingers and the micro-orifice uniform deposit impactor (MOUDI) recovered significantly more airborne endotoxin than the more widely adapted method of collecting airborne endotoxin on membrane filters, when collection methods were applied in realistic settings (homes). The MOUDI measured the particle size distribution of airborne endotoxin, which can be useful for determining endotoxin respiratory toxicity and its health effects.

Airways inflammation among workers in poultry houses

Previous studies have demonstrated that persons working with poultry have an increased incidence of chest symptoms and decreased lung function. A study was undertaken to evaluate the usefulness of airway responsiveness measurements to diagnose the presence of airways inflammation and relate this to the workplace exposure. The group studied comprised of 42 non-smoking poultry workers and 40 controls not exposed to organic dusts. The presence of symptoms was evaluated using a standardized questionnaire for organic dust exposures. Airway responsiveness was measured using the methacholine challenge test. The concentrations of airborne endotoxin and (1-->3)-beta-D-glucan were measured. Exposure levels were in excess of those expected to cause effects in the airways. There was significantly higher airway responsiveness among the workers compared to controls (decrease 9.5 SD 7.5 vs 3.4, SD 3.3). Poultry workers had a higher prevalence of toxic pneumonitis, airways inflammation and chronic bronchitis compared to controls. Endotoxin levels in the poultry buildings exceeded those earlier suggested as the threshold value for airways inflammation.