Use of Rhodopseudomonas palustris P1 stimulated growth by fermented pineapple extract to treat latex rubber sheet wastewater to obtain single cell protein

Abstract

Listen

Translate article

Latex rubber sheet wastewater (non sterile wastewater: RAW) was treated efficiently using a stimulated Rhodopseudomonas palustris P1 inoculum with added fermented pineapple extract (FPE) under microaerobic light conditions. Optimization of wastewater treatment conditions using a central composite design (CCD) found that a 3 % stimulated P1 inoculum with 0.9 % added FPE and a 4-day retention time (RT) were the most suitable conditions. Calculations from CCD experiments predicted that a chemical oxygen demand (COD) of 3,005 mg/L could be 98 % removed, together with 79 % of suspended solids (SS) and 72 % of total sulfide (TtS). No H2S was detected, production costs were low and single cell protein (SCP) was a by-product. The results of the verification test had an error of only 4–8 % and confirmed removal of COD (initial COD 2,742 mg/L), SS and TtS at 94 %, 75 % and 66 %, respectively. These values were less than the best set obtained from the CCD experiment (2 % stimulated P1 inoculum, 0.75 % FPE and 4 days RT); upon repeating, this set could reduce 96 % of the COD, 78 % SS and 71 % TtS. The treated wastewater met the standard guidelines for irrigation use and no H2S was detected. The biomass obtaining after wastewater treatment from the best set consisted mostly of R. palustris P1; the biomass of this set had 65 % protein, 3 % fat, 8 % carbohydrate, 14 % ash and 10 % moisture. The results demonstrated that an inoculum of stimulated P1 grew well in RAW supplemented with FPE and could be considered to be an appropriate technology for effectively treating wastewater, with SCP as a by-product.