Some mechanisms of immiscible fluid displacement in small networks

Abstract

We report experimental observations on immiscible displacement in two small networks using three different pairs of fluids, air-oil, air-water, and oil-water, to vary the wettability. The experiments were run for a wide range of capillary number, from 10 −7 to 10 −3. Various mechanisms are observed. These are film spreading and drainage, Haines' jump, free slip and stick-slip meniscus motion, contact angle hysteresis, snap-off, coalescence, and blocking of film and bubble. For the air-oil case, oil is perfectly wetting in the network. In imbibition, the displacement occurs first via thin film spreading, followed by snap-off of menisci, and then by piston-like displacement at low flow rates. As the flow rate increases, piston-like displacement dominates because film spreading is comparatively slow. Snap-off of menisci in the throats is a necessary condition for air trapping. In drainage, meniscus snap-off and coalescence are observed in one network. For both imbibition and drainage, during each snap-off or piston-like displacement event, all menisci move freely along the channels to adjust their curvatures, due to the lubrication of the wetting film. For the other two fluid pairs at low flow rates, this curvature readjustment through free slipping of meniscus is not observed, presumably due to the absence of wetting film during the displacement. At high flow rate, oscillation of menisci due to volumetric competition is observed. Neither wetting film spreading nor throat snap-off is observed. Stick and slip motion of meniscus is observed, probably due to the roughness and/or heterogeneous wettability of the solid surface. For the oil-water system the wettability seems to be time dependent. Coalescence between two menisci can occur in the throat, in the pore, or at the pore-throat boundary during displacement. Trapping of the displaced phase is due to its being bypassed or snapped off in the throat.