Remoção de alquilbenzeno linear sulfonado (LAS) e caracterização microbiana em reator anaeróbio de leito fluidificado

Abstract

OLIVEIRA, L. L. Removal of Linear Alkylbenzene Sulfonate (LAS) and Microbial Characterization in Anaerobic Fluidized Bed Reactor. 2009. 176 f. Thesis (Doctoral) – Escola de Engenharia de Sao Carlos, Universidade de Sao Paulo, Sao Carlos, 2010. This work presents the anaerobic degradation of linear alkylbenzene sulphonate (LAS), a surfactant widely used in the production of detergents and present in domestic and industrial wastewaters. It was used an anaerobic fluidized bed reactor in bench scale (1,2 L) filled with support material for biomass immobilization. Four different supports were previously tested in small scale fluidized bed reactors (350 ml): activated charcoal (R1), expanded clay (R2), glass beads (R3) and sand (R4). All reactors were inoculated with sludge from a UASB reactor treating swine wastewater and were fed with a synthetic substrate supplemented with LAS. The reactors were kept at 30 oC and operated with a hydraulic retention time (HRT) of 18 h. It was possible to note that the four tested reactors were able to remove organic matter (higher than 84%) and LAS (higher than 81%), respectively, to initial mean value of 550 mg/L and 16.5 mg/L. However, activated charcoal and expanded clay both produced shearing during reactor operation. Thus, sand was the chosen material to fill the bench scale reacto because of good results of LAS removal (99%) and smaller cost and affordability compared to glass beads. After 270 days of operation, with crescent LAS concentrations and average of 32,3 mg/L, it was found that the bench scale reactor was able to remove LAS in 93%. All supports adsorb a few LAS (maximun of 0.43 mgLAS/gclay). This value does not interfere in biologic removal process. Microscopic tests done during the reactor s operation presented microorganisms with morphologies similar to spirochetes, bacillus, filamentous, cocci and others. 16S rRNA gene sequencing and phylogenetic analysis of samples from the bench scale reactor and smaller reactor filled with glass beads (R3) and sand (R4) revealed that these reactors gave rise to broad microbial diversity, with microorganisms belonging to the phyla Bacteroidetes, Proteobacteria, Verrucomicrobia and Firmicutes, and others.