Pilot-plant-scale outdoor mixotrophic cultures of Phaeodactylum tricornutum using glycerol in vertical bubble column and airlift photobioreactors: studies in fed-batch mode.

Abstract

Pilot-scale (0.19 m column diameter, 2 m tall, and 60 L working volume) outdoor vertical bubble column (BC) and airlift photobioreactors (a split-cylinder (SC) and a draft-tube airlift device (DT)) were compared for fed-batch mixotrophic culture of the microalga Phaeodactylum tricornutum UTEX 640. The cultures were started photoautotrophically until the onset of a quasi-steady-state biomass concentration of 3.4 g L(-)(1). After this, the cultures were supplemented with organic nutrient (glycerol 0.1 M) and a reduced nitrogen source, resulting in an immediate growth rate boost, which was repeated with successive additions of nutrients in all three photobioreactors. During this period the biomass productivity was enhanced compared to photoautotrophic cultures in the three reactors, although differences were found among them. These could be attributed to the different hydrodynamic behavior influencing the transport phenomena inside the cultures. A 25.4 g L(-)(1) maximum biomass concentration was attained in the SC. Further additions of nutrients did not promote any more growth. The consumption of glycerol was quantitative in the first additions but slowed at high biomass concentration, suggesting that a minimum amount of light is needed to sustain growth. No significant effect of the supplied organic nutrient on carotenoids and chlorophylls content was observed, although it had a profound effect on the fatty acid composition. Eicosapentaenoic acid (EPA) content was increased up to 3% (DW) in mixotrophic growth, giving a productivity of 56 mg L(-)(1) d(-)(1), a significant increase compared to the photoautotrophic control, which yielded a maximum EPA content of 1.9% (DW) and a productivity of 18 mg L(-)(1) d(-)(1). The maximum biomass and EPA volumetric yields obtained in this work are comparable with those reported for commercial photoautotrophic monoculture of large quantities of P. tricornutum in closed continuous-run tubular loop bioreactors with tubes that are typically less than 0.08 m in diameter. When the comparison is established in terms of productivities based on the land area occupied, the vertical airlift and bubble-column bioreactors are extraordinarily more productive.