Performance of cactus mucilage and brown seaweed extract as a steel corrosion inhibitor in chloride contaminated alkaline media

Abstract

PurposeThis paper aims to present experimental results related to the performance of cactus mucilage (CM) and brown seaweed extracts (SEs) to inhibit reinforcing steel bar (rebar) corrosion in saturated calcium hydroxide alkaline solutions (pH = 12.5).Design/methodology/approachElectrochemical cells were prepared using CM solutions at 0.5, 1 and 1.38 per cent concentration (w/v), SE solutions at 0.5, 1, 1.38, 2 and 3 per cent concentration (w/v), sodium alginate at 1 per cent concentration (w/v) and calcium nitrite at 11.3 per cent (v/v). Each cell contained six deformed reinforcing steel bars of 9.5 mm nominal diameter. The experiments were performed at 23 ± 2°C in two stages. The first stage was aimed at stabilizing the rebar until passivation was reached. The second stage included adding NaCl in six steps from 0.5 to 16 g/L. Half-cell potential, linear polarization resistance and electrochemical impedance spectroscopy measurements were monitored during both stages.FindingsThe electrochemical test results indicated that both additions reduce the corrosion rate of rebars and pitting in an alkaline media with chloride ions (16 g/L NaCl). Electrochemical impedance spectroscopy results for rebars in natural-added solutions showed higher charge transfer resistance and double layer capacitance values, indicative of the formation of a second interface between the rebar and the electrolyte.Research limitations/implicationsThe information obtained was for alkaline solutions only. Further investigation is performed using concrete as the alkaline electrolyte.Practical implicationsCM and SE may be suitable low-cost corrosion inhibitors for steel in concrete.Social implicationsThe use of botanical or algae products for this application will encourage people to consider its production for this particular application. Also, the possible harvest in an environmental friendly way will diminish in the future the use of biohazards and toxic inhibitors.Originality/valueThis investigation is a continuation of a one presented in 2007, which uses only nopal mucilage. This new investigation corroborates what was concluded in the early investigation and incorporates a new natural by product, algae, as a possible corrosion inhibitor product.