Abstract
Anaerobic digestion (AD) represents an advantageous solution for the treatment and valorization of organic waste and wastewater. To be suitable for energy purposes, biogas generated in AD must be subjected to proper upgrading treatments aimed at the removal of carbon dioxide and other undesirable gases. Pressurized anaerobic digestion (PDA) has gained increasing interest in recent years, as it allows the generation of a high-quality biogas with a low CO2 content. However, high pressures can cause some negative impacts on the AD process, which could be accentuated by feedstock characteristics. Until now, few studies have focused on the application of PAD to the treatment of real waste. The present work investigated, for the first time, the performance of the pressurized anaerobic digestion of raw compost leachate. The study was conducted in a lab-scale pressurized CSTR reactor, working in semi-continuous mode. Operating pressures from the atmospheric value to 4 bar were tested at organic loading rate (OLR) values of 20 and 30 kgCOD/m3d. In response to the rise in operating pressure, for both OLR values tested, a decrease of CO2 content in biogas was observed, whereas the CH4 fraction increased to values around 75% at 4 bar. Despite this positive effect, the pressure growth caused a decline in COD removal from 88 to 62% in tests with OLR = 20 kgCOD/m3d. At OLR = 30 kgCOD/m3d, an overload condition was observed, which induced abatements of about 56%, regardless of the applied pressure. With both OLR values, biogas productions and specific methane yields decreased largely when the pressure was brought from atmospheric value to just 1 bar. The values went from 0.33 to 0.27 LCH4/gCODremoved at 20 kgCOD/m3d, and from 0.27 to 0.18 LCH4/gCODremoved at 30 kgCOD/m3d. Therefore, as the pressure increased, although there was an enhanced biogas quality, the overall amount of methane was lowered. The pressured conditions did not cause substantial modification in the characteristics of digestates.
Highlights
Publisher’s Note: MDPI stays neutralEnergy consumption increases every year with technological and social development causing significant environmental impacts
Composting leachate used in this study was characterized by a moderately acidic pH of 5.3, and by a notable conductivity value of around 5.6 mS/cm (Table 1)
The results presented above ind that, as the pressure grows, the organic matter digestion and the biogas production riorate, and this effect is more marked at 20 kgCOD/m3d
Summary
Publisher’s Note: MDPI stays neutralEnergy consumption increases every year with technological and social development causing significant environmental impacts. A wet digestate and biogas are generated because of the organic matter degradation under anaerobic conditions. Biogas is a mixture mainly composed of methane (CH4 ) and carbon dioxide (CO2 ), with a lower heating value (LHV) of about 21.5 MJ/m3 [14]. It contains traces of other non-condensable gases such as H2 S, H2 , N2 , NH3 , O2 , CO, volatile organic compounds (VOCs), and steam [13,14,16]. The content of CH4 ranges with regard to jurisdictional claims in published maps and institutional affiliations
Sign-in/Register to view highlights & summary Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Schedule a callDisclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.
