Low Temperature Fabrication of Microcrystalline Silicon Germanium Films by RF Reactive Magnetron Sputtering

Abstract

AbstractMicrocrystalline silicon germanium films (μc-SiGe) were fabricated on Corning #7059 glass substrates by the RF reactive magnetron sputtering method. The μc-SiGe films with Ge fraction of 0.7-0.8 could be crystallized at of 200 °C by H2 introduction into the sputtering gases. The absorption coefficients of the films decrease in long wavelength region corresponding to the photon energies below the energy gap by the decrease in the substrate temperature and become close to those of single crystal Si0.25Ge0.75. The dark conductivities show lower values of 10-7 S/cm at 200 °C and 300 °C with H2 introduction. Besides, the photosensitivities are observed in these samples. These results indicate that the H2 introduction into the sputtering gas has two important effects to decrease the crystallization temperature of the μc-SiGe and to improve the film properties by reducing the dangling bond defects.