KINETIC AND THERMODYNAMIC ADSORPTION STUDIES ON THE REMOVAL AND TREATMENT OF TEXTILES EFFLUENTS USING ACTIVATED CARBON DERIVED FROM DIOSPYROS MESPILLIFORMIS SEEDS.

Abstract

An agricultural waste Diospyros mespiliformis seeds were treated, and activated with 30% of 0.3M sodium hydroxide base, to obtain an activated carbon employed in an adsorption process. It was utilize to treat effluent textile water sample from African Textile Manufacturers Limited in Dala, Kano State, Nigeria. Various techniques, including scanning electron microscopy (SEM), Fourier transform infrared spectroscopy (FTIR), and proximate analysis were employed to investigate the adsorption process. The adsorbent was able to remove the dark red color to colorless found in textile effluents and shown a higher removal affinity for zinc ( 99.4%) and least affinity for nickel (0.11%), also Chromium (Cr) reduced by 39.4%, Copper (Cu) reduced by 20.9%, Iron (Fe) reduced by 91.9% , Manganese (Mg) reduced by 79.3%, are reduced significantly, the PH change from acidic PH 6.4 to neutral PH 7.1, turbidity decrease from 131 to 14 NTU , electrical conductivity change from 723 to 110 ?s·cm?1 .Diospyros mespiliformis seeds activated carbon was used for removal of congo red and malachite green from an aqueous solution. The effect of adsorbent dose, adsorbate concentration and contact time on the process of adsorption was investigated. The optimum dosage was found to be 0.5g had a percentage removal of 98.1% for congo red and 94.4% for malachite green. 10mg/l and 80minute was found to optimum concentration and optimum time in adsorption of congo red and malachite green. The equilibrium, kinetic and thermodynamic properties of the dyes removal were also investigated. The experimental data were modeled using linear regression method of analysis. The correlation coefficient was used as a criterion for model adequacy and acceptance. The pseudo second-order kinetic model was found to best correlate the experimental data with R2 of 0.9523 for CR and 0.9297 for MG. The experimental data were investigated at three different temperature, 305k, 325k and 335k were found to follow the Langmuir model with R2 of 0.9679, 0.9662 and 0.989 for CR and 0.9529, 0.9662 and 0.994 for MG. also were found to follow Temkinp model with with R2 of 0.9549, 0.9318 and 0.9952for CR and 0.9885, 0.9443 and 0.9209 for MG. The negative free gribbs energy indicated that the adsorption processes were spontaneously feasible. The positive values of +31.66KJ/mol and +92.3KJ/mol on both CR and MG indicate that adsorption process has been found to be endothermic in nature. The removal of congo red was found to be more spontaneous and feasible than the removal of malachite green on the adsorbent. From the study, it was deduced that the Diospyros mespiliformis seeds activated with sodium hydroxide was found to be a good adsorbent for the treatment of textile wastewater containing Congo red and Malachite green.