Influence of maceration at cutting on lactic acid bacteria populations, silage fermentation and voluntary intake and digestibility of precision‐chopped lucerne silage

Abstract

Laboratory experiments with lucerne (Medicago sativa) have shown that maceration at cutting improves silage fermentation. Samples taken during wilting and after various ensiling periods were analysed for lactic acid bacteria (LAB) numbers and indices of silage fermentation. In Experiment 1, in which maceration was tested in unwilted and wilted lucerne, there was an additive effect of maceration and wilting on LAB numbers at ensiling, thus LAB numbers were approximately 108 colony‐forming units (cfu) g−1 fresh crop for wilted, macerated forage compared with 103 cfu g−1 fresh crop for unwilted, unmacerated forage at ensiling. Initially, maceration reduced pH (P < 0·001) and increased lactic acid (unwilted comparison only; P < 0·001) and insoluble N (wilted comparison only; P < 0·001) concentrations. After 70 d ensiling, beneficial effects of maceration were associated only with the wilted silage. In Experiment 2, macerated lucerne was compared with unmacerated material, which was either ensiled after a wilting period of similar length or after wilting had proceeded to the same DM concentration as in the macerated forage. During wilting, LAB numbers were significantly higher in macerated than unmacerated forage (P < 0·05). This was also the case during the first 16 h of ensiling (P < 0·01). A decline in pH was observed earlier in macerated silage. Two days after ensiling, lactic acid concentration was higher in macerated silage (P < 0·05), but insoluble N concentration was not different. In a third experiment, unconditioned forage was compared with forages ensiled after regular conditioning or maceration. Although drying rate over 30 h was not influenced by degree of conditioning, LAB numbers during wilting increased with the degree of conditioning. In silages made from these treatments after 6 h wilting, there were no major effects on fermentation characteristics. In a fourth experiment, digestibility and voluntary intake of precision‐chopped silage were measured in sheep and found not to be increased by maceration. It was concluded that maceration per se resulted in marginal improvements in fermentation; however, when maceration also increased DM concentration, fermentation was markedly improved. In these precision‐chopped silages, maceration had no effect on intake or digestibility.