Identification and simultaneous quantification of potential genotoxic impurities in first-line HIV drug dolutegravir sodium using fast ultrasonication-assisted extraction method coupled with GC–MS and in-silico toxicity assessment

Abstract

Dolutegravir (DLG) has become a distinctive first-line antiretroviral therapy for the treatment of HIV in most countries due to its affordability, high efficacy, and low drug-drug interactions. However, the evaluation of genotoxic impurities (GTIs) in DLG and their toxicity assessment has not been explored thoroughly. Thus, in this study, a simple, fast, and selective analytical methodology was developed for the identification and determination of 7 GTIs in the comprehensive, explicit route of synthesis for the dolutegravir sodium (DLG-Na) drug. A facile, fast ultrasonication-assisted liquid–liquid extraction procedure was adapted to isolate the GTIs in DLG-Na and then analyzed using the gas chromatography (GC)-electron impact (EI)/mass spectrometer (MS) quantification (using selective ion monitoring mode) technique. This EI-GC/MS method was validated as per the current requirements of ICH Q2 (R1) guidelines. Under optimal method conditions, excellent linearities were achieved with R between 0.9959 and 0.9995, and high sensitivity was obtained in terms of detection limits (LOD) between 0.15 to 0.63 µg/g, and quantification limits (LOQ) between 0.45 to 1.66 µg/g for the seven GTIs in DLG. The obtained recoveries ranged from 98.2 to 104.3 % at LOQ, 15 µg/g, and 18 µg/g concentration levels (maximum daily dose of 100 mg). This developed and validated method is rapid, easy to adopt, specific, sensitive, and accurate in estimating the seven GTIs in a relatively complex sodium matrix of the DLG-Na drug moiety. As a method application, two different manufactured samples of DLG-Na drug substances were analyzed for the fate of the GTIs and drug safety for the intended dosage applications. Moreover, an in-silico QSAR toxicity prediction assessment was carried out to prove scientifically the potential GTI nature of each impurity from the alerting functional groups.