Higher Extrusion Temperature Induces Greater Formation of Less Digestible Type V and Retrograded Starch in Iron-Fortified Rice Grains But Does Not Affect Iron Bioavailability: Stable Isotope Studies in Young Women

Abstract

BackgroundHot extrusion is widely used to produce iron-fortified rice, but heating may increase resistant starch and thereby decrease iron bioavailability. Cold-extruded iron-fortified rice may have higher bioavailability but has higher iron losses during cooking. Thus, warm extrusion could have nutritional benefits, but this has not been tested. Whether the addition of citric acid (CA) and trisodium citrate (TSC) counteracts any detrimental effect of high-extrusion temperature on iron bioavailability is unclear. ObjectivesOur aim was to assess the effects of varying processing temperatures on the starch microstructure of extruded iron-fortified rice and resulting iron solubility and iron bioavailability. MethodsWe produced extruded iron-fortified rice grains at cold, warm, and hot temperatures (40°C, 70°C, and 90°C), with and without CA/TSC at a molar ratio of iron to CA/TSC of 1:0.3:5.5. We characterized starch microstructure using small- and wide-angle X-ray scattering and differential scanning calorimetry, assessed color over 6 mo, and measured in vitro iron solubility. In standardized rice and vegetable test meals consumed by young women (n = 22; mean age: 23 y; geometric mean plasma ferritin: 29.3 μg/L), we measured iron absorption from the fortified rice grains intrinsically labeled with 57ferric pyrophosphate (57FePP), compared with ferrous sulfate (58FeSO4) solution added extrinsically to the meals. ResultsWarm and hot extrusion altered starch morphology from native type A to type V and increased retrograded starch. However, extrusion temperature did not significantly affect iron solubility or iron bioavailability. The geometric mean fractional iron absorption of iron from fortified rice extruded with CA/TSC (8.2%; 95% CI: 7.9%, 11.0%) was more than twice that from extruded rice without CA/TSC (3.0%; 95% CI: 2.7%, 3.4%; P < 0.001). ConclusionsHigher extrusion temperatures did not affect iron bioavailability from extruded rice in young women, but co-extrusion of CA/TSC with FePP sharply increased iron absorption independently from extrusion temperature. This trial is registered at www.clinicaltrials.gov as NCT03703726.