Abstract
Ba2Zn2Fe28O46 hexaferrite was prepared using green synthesis with different quantities of ginger root extract (obtained from 0.0, 17.5, 35, 52.5 and 70 g of ginger root) as a natural antioxidant reducing agent. The dried precipitates were preheated at 550 °C/4 h and finally heated at 1200 °C/5 h. The effect of ginger root extract on structural, phase purity, magnetic, Mӧssbauer and low frequency (10 Hz–2 MHz) dielectric properties were investigated. XRD analysis of samples prepared with extracts from 35, 52.5, and 70 g of ginger depicted pure X-phase, while the other samples (0.0, 17.5 g) showed the secondary phase of M-type (BaM, BaFe12O19) along with hematite (12% α-Fe2O3). Hence, samples with greater amounts of ginger extract formed single-phase X-type hexaferrite. Saturation magnetization (MS) varied from 40.8 A m2/kg without ginger extract to 69.8 A m2/kg with extract from 52.5 g ginger, and was <65 A m2/kg for all samples made with the ginger extract. All synthesized samples were relatively soft ferrites, and coercivity increased with amount of ginger extract used. The Mӧssbauer spectra explored six sextets of five magnetic sub-lattices, and the presence of Fe3+ (99.4–97.3 %) and Fe2+ (0.6–2.7 %) ions, with more Fe2+ present in the extract-derived samples. The variations in MS based on hysteresis loops were in agreement by Mössbauer spectroscopy. The use of the extract also significantly reduced the grain size, from 3.3 μm without ginger extract to 0.7–1.7 μm with the extract, with a corresponding increase in coercivity from 16 to 40–80 kA/m. The samples prepared with extracts from 35 g to 52.5 g ginger root possessed considerable real dielectric constant compared to the others, but the extract also increased conductivity in the high-frequency region. Complex impedance displayed low values in the high-frequency region, and Cole-Cole plots revealed that the main contribution to conductivity in extract-based samples was from the grains. The reducing action of the green extract not only produced single phase X ferrite, but it also reduced grain size to ∿1–2 μm and greatly increased MS.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Disclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.